2022 CHEVROLET SILVERADO 1500 Recalls, Complaints & Safety

onstar telematics module went out and took away my way to call in a car problems and if stolen wont be able to find and the forward Collision don't work my high beam turn on and off by themselves and don't have there wifi or severs without it or emergency button

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while operating the vehicle, the tailgate door erroneously opened. Additionally, the battery was drained, and the vehicle needed to be jump-started. The vehicle was taken to the local dealer who diagnosed that the tailgate switch was damaged from water intrusion and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact stated that the manufacturer had issued a recall for the failure of certain Canadian-made vehicles. The failure mileage was approximately 20,000.

The vehicle experienced a sudden loss of 4WD capability and transmission communication while driving. The dealership diagnosed a defective battery ground cable. GM has issued Customer Satisfaction Program N252515590 for this exact issue, but they are refusing to cover my specific VIN despite the truck exhibiting the exact failure described. This defect causes the vehicle to lose critical powertrain functions, posing a safety risk on the road.

Vehicle experienced a sudden rough shift followed up by hard shifting and transmission locking up rear wheels. If I was traveling at a higher rate of speed (over 30mph) a accident could've easily resulted. Check engine light and vehicle went into reduced acceleration mode after 3 to 4 severe shift occurances. Dealer has vehicle and found the valve body of transmission was faulty and will be replacing entire valve body. Still under factory warranty. Mileage at occurance was 45,006 miles.

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving at 45 MPH, the tailgate unintendedly opened unintentionally while there were items stored in the trunk. Upon coming to a stop at the red light, another driver alerted the contact that the tailgate was open. The contact pulled over to the side of the road, and the tailgate was closed. The vehicle was driven to the residence and was parked and turned off; however, the contact became aware that the tailgate had opened while the vehicle was turned off. The contact disconnected the tailgate switch to prevent the battery from draining. The vehicle was taken to the dealer, where it was diagnosed, and determined that the tailgate switch had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in GM Campaign Number: N232426400. The failure mileage was approximately 63,000.

1. The fuel pump power control module on my 2022 Chevy Silverado failed. It was 38 months old and had 14,970 miles on it. I purchased it only 2 months ago. I believe the specific part number was 13554060. It was replaced with part number 13554821. The dealer retained--or more likely, disposed of--the old part. The cost of the repair was $762.87. 2. I was driving on Rt. US 20 in Toledo, Ohio. My truck experienced a sudden loss of power without warning. The vehicle stalled and would not restart. I had to call a tow truck. The truck was towed to Ballas Buick, where the part was replaced. 3. There was a voluntary recall of other vehicles that utilize this same part, so the manufacturer should be aware of the flaw in this component. The recall number is N252516900. 4. No warning light came on before the vehicle stalled, stranding me on the road. I had just enough of a sense of the impending failure to pull to the side of the road.

Truck went in for the recall around Nov/Dec 2025. Passed recall for 6.2l crankshaft and new oil was put in the vehicle. Today the truck lost power while driving and the check engine light came on to include a message saying the transmission went out. The vehicle is now un drivable and with a Chevrolets dealership waiting to be fixed

Year: 2022 Make: Chevrolet Model: Silverado 1500 Engine: 2.7L TurboMax (L3B) VIN: [XXX] Mileage at Failure: 119,139 Description of Problem: 2022 Chevrolet Silverado 1500 2.7L L3B TurboMax engine is completely inoperable due to Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Vehicle shakes severely, will not accelerate, check engine light on, and has gone into limp mode. Diagnostic codes P0304 (Cylinder 4 misfire) and P2101 (electronic throttle actuator fault triggered by engine shaking and limp mode) were recorded. All external components including spark plugs, coils, and injector harnesses were inspected and ruled out as causes. Failure is confirmed mechanical and internal. This failure was diagnosed and documented in writing by an authorized Chevrolet dealership on March 12, 2026 (Repair Order XXX, Service Advisor [XXX] ). The dealer's written estimate states verbatim: "Failed Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Cylinder head replacement required to correct this concern. Direct cause of engine noise and misfire condition." Dealer repair quote: $10,371.34. A second independent shop confirmed the same failure and cited Active Fuel Management (AFM) and Direct Fuel Injection (DFI) as known contributing design factors in this engine's oil consumption and internal wear pattern. That shop quoted between $11,876.88 and $14,897.35. This is a known pattern in the L3B engine platform. Consumer Reports has documented a 4% catastrophic failure rate in this engine. Multiple NHTSA complaints exist for this same failure across 2019-2022 model years. GM has issued technical service bulletins but has not issued a recall. General Motors was formally notified of this failure via certified mail and executive email on March 24, 2026. Vehicle is inoperable and poses a safety risk as the failure causes sudden loss of power and engine shaking w INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

Truck went in for the recall around Nov/Dec 2025. Passed recall for 6.2l crankshaft and new oil was put in the vehicle. Today the truck lost power while driving and the check engine light came on to include a message saying the transmission went out. The vehicle is now un drivable and with a Chevrolets dealership waiting to be fixed

Year: 2022 Make: Chevrolet Model: Silverado 1500 Engine: 2.7L TurboMax (L3B) VIN: [XXX] Mileage at Failure: 119,139 Description of Problem: 2022 Chevrolet Silverado 1500 2.7L L3B TurboMax engine is completely inoperable due to Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Vehicle shakes severely, will not accelerate, check engine light on, and has gone into limp mode. Diagnostic codes P0304 (Cylinder 4 misfire) and P2101 (electronic throttle actuator fault triggered by engine shaking and limp mode) were recorded. All external components including spark plugs, coils, and injector harnesses were inspected and ruled out as causes. Failure is confirmed mechanical and internal. This failure was diagnosed and documented in writing by an authorized Chevrolet dealership on March 12, 2026 (Repair Order XXX, Service Advisor [XXX] ). The dealer's written estimate states verbatim: "Failed Cylinder 4 exhaust roller follower failure causing exhaust camshaft failure and bent exhaust valves. Cylinder head replacement required to correct this concern. Direct cause of engine noise and misfire condition." Dealer repair quote: $10,371.34. A second independent shop confirmed the same failure and cited Active Fuel Management (AFM) and Direct Fuel Injection (DFI) as known contributing design factors in this engine's oil consumption and internal wear pattern. That shop quoted between $11,876.88 and $14,897.35. This is a known pattern in the L3B engine platform. Consumer Reports has documented a 4% catastrophic failure rate in this engine. Multiple NHTSA complaints exist for this same failure across 2019-2022 model years. GM has issued technical service bulletins but has not issued a recall. General Motors was formally notified of this failure via certified mail and executive email on March 24, 2026. Vehicle is inoperable and poses a safety risk as the failure causes sudden loss of power and engine shaking w INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

My L87 6.2L engine shut off on the interstate while driving in traffic at 70mph. I coasted to the left shoulder and attempted to restart it, but it would not turn over. I had it towed to a dealer where they diagnosed it as seized. Currently waiting for a new engine to arrive with no ETA. I had no warning signs or sounds. Two months prior it had the recall completed passing the PICO test and changed to the heavier oil.

2022 Silverado 1500 6.2L total engine failure, replacement needed

Ever since I’ve own, the vehicle emergency breaking has never worked. I get all the red lights and noises and I almost ruined somebody but luckily I swerved, but the truck is never break on its own and the dealership tells me that’s the way it is you have to hit somebody first before it breaks and the other day I was driving and all kinds of service lights came on the dash the trucks are misfiring

2022 Silverado 1500 6.2L total engine failure, replacement needed

Ever since I’ve own, the vehicle emergency breaking has never worked. I get all the red lights and noises and I almost ruined somebody but luckily I swerved, but the truck is never break on its own and the dealership tells me that’s the way it is you have to hit somebody first before it breaks and the other day I was driving and all kinds of service lights came on the dash the trucks are misfiring

I replaced rear brakes and rotors after getting brake monitor warning on 2022 silverado 1500. I have been having problem with amount of force needed to stop truck for quite a while. The pads were not worn much at all but brake pad clips were broken on both sides of rear brakes. Rotors were rusted which looked as if rear brakes have not been contacting rotors. The brakes work significantly better now. I live in NC where rust is not serious problem. I feel there is a problem with rear brake hardware on these trucks

The transmission died on my 2.7L Turbo Max engine in my 2022 Silverado. The "D" was flashing and giving no acceleration when pressing on the gas. The vehicle was also hard to shift. From my understanding the 2.7L turbo max is the only engine in this time frame that hasn't been re-called due to transmission issues.

Fuel tank and def tank issues that throws error codes that will make your engine go into slump mode

The rear tailgate started opening when I opened my doors and also when driving down the road. I would pull up and tail gate was wide open. I was okay but thankfully nothing in the back came out and hit vehicles behind me. No warning lights and anything. Dealership said it’s a faulty tailgate switch. Which 800,000 vehicles were recalled but not mine. Even though it’s the same year as the recalled vehicles. Gm needs to be held accountable for all of them. This was a problem for 3 weeks. Constant dead batteries, jumping vehicle, closing tailgate and causing lights to go crazy. This is a definite safety concern. Had to wait a week to get into dealership for diagnosis. Than over a week for the parts.

Fuel tank and def tank issues that throws error codes that will make your engine go into slump mode

My coolant control valve has failed, the dealership is saying the radiator is now leaking at a weld. They said this is a know issue, but are refusing to repair it. It is caused by the know failing ccv, causing the radiator to overheat.

The tailgate is clicking continuously and dropping at random moments when I’m stationary as well as driving. It is draining the battery and leaving me stranded with zero power or resources for help.

While driving with my trailer my Tailgate opened by itself and hit my trailer when backing up. There is a open recall for a faulty switch that may allow the Tailgate to open unexpectedly. I called my dealer and said they could only replace the faulty switch and not my damaged tailgate. It was due to the faulty switch that led to my Tailgate getting damaged. I believe this switch and my Tailgate need to replaced.

While turning left, the transmission stuttered and got stuck in first gear. I did some basic research and learned that this is a known issue with 2020-2022 Chevrolet Silverado vehicles. I attempted the suggested fix which worked briefly. I then took the vehicle to my local Chevrolet dealer for repairs. After further research I learned that this is a known issue with my year and model of Silverado. GM further voluntarily offered a 15 year, 150,000 mile warranty for this issue. According to GM, my particular VIN is not included in this recall. I am concerned as to how many other trucks are not included. This issue also cost nearly $4,000 for the repair.

Unknown. The transmission is kicking really bad. There are recalls on other vehicles similar to ours that are having the same issue. It has been doing this for a while now. It shifts hard from 1st to 2nd gear and when coming to a complete stop it also jerks. Also at times the check engine light comes on and it will not shift at all. I am afraid this is going to cause an accident.

While turning left, the transmission stuttered and got stuck in first gear. I did some basic research and learned that this is a known issue with 2020-2022 Chevrolet Silverado vehicles. I attempted the suggested fix which worked briefly. I then took the vehicle to my local Chevrolet dealer for repairs. After further research I learned that this is a known issue with my year and model of Silverado. GM further voluntarily offered a 15 year, 150,000 mile warranty for this issue. According to GM, my particular VIN is not included in this recall. I am concerned as to how many other trucks are not included. This issue also cost nearly $4,000 for the repair.

Unknown. The transmission is kicking really bad. There are recalls on other vehicles similar to ours that are having the same issue. It has been doing this for a while now. It shifts hard from 1st to 2nd gear and when coming to a complete stop it also jerks. Also at times the check engine light comes on and it will not shift at all. I am afraid this is going to cause an accident.

L87 6.2L engine failure after doing recommended recall for a different oil

While stopped at a stop light engine quit running and after three attempts to restart MIL appeared and stated low oil pressure. Safety hazards included; being stuck at an intersection blocking traffic and putting myself at risk of being rear ended. was below freezing temperatures and stranded for an hour before tow arrived GM dealership found engine to be bad and needs replaced.

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while attempting to start the vehicle, the battery failed. The battery was replaced, and the next day the same failure reoccurred. The contact stated that the tailgate suddenly opened without the vehicle being started. The contact became aware of NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not available. The recall information suggested that water was entering the vehicle and causing an electrical short. The vehicle was taken to the dealer, who diagnosed that the liftgate exterior release assembly had failed, Part Number: 85734717, and needed to be replaced with a new Part Number: 85877552. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 52,689.

I went to Chevy in Warwick Rhode Island a few months back after all my adaptive cruise control and lane departure stuff stopped working. They reset it and it was fine for a couple months and now it isn’t working again. I went there and they said that my camera is not getting enough power and they have seen so many of these problems happening with these trucks but still no recall. Was waiting to get one because there should be a recall on these if so many trucks are having issues with it

February 3, 2026 my 2022 Silverado ZR2 with 37,000 miles shut off on me while driving at a speed of 45 mph, i was able to pull over safely, I mentioned this to the dealership and they were unable to figure out why. 2 weeks later, my truck began to start making a loud knocking noise from the engine, I took it to the dealership and they stated that it was a failed engine and they would need to start a claim and most likely need a new engine. I have been waiting for a new engine now without a ship date on when the engine will arrive to the dealership to begin repairing my truck. They did do the recall test, change the oil type and oil cap. However, the engine still failed and I have been left without my truck until who knows when. I’ve started a claim myself with General Motors to get better updates, but they don’t have one either at this time.

I went to Chevy in Warwick Rhode Island a few months back after all my adaptive cruise control and lane departure stuff stopped working. They reset it and it was fine for a couple months and now it isn’t working again. I went there and they said that my camera is not getting enough power and they have seen so many of these problems happening with these trucks but still no recall. Was waiting to get one because there should be a recall on these if so many trucks are having issues with it

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving approximately 30 MPH, the rear wheels locked up, causing the vehicle to drive off the roadway. The vehicle was still running; however, when the contact attempted to shift into reverse(R) to get back onto the roadway, the message "Conditions not Correct for Shift" was displayed. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and DTC: P2724 and P0700 were retrieved. The dealer determined that the valve body needed to be replaced. The dealer associated the failure with NHTSA Campaign Number: 26V083000 (Power Train); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The failure mileage was 76,642.

The contact owns a 2022 Chevrolet Silverado1500. The contact stated that while starting the vehicle in the driveway, the vehicle failed to start. The vehicle was jump-started, and the instrument panel was black. The contact was unable to see the speed, fuel gauge, and other important information. The vehicle was taken to a certified mechanic who diagnosed the vehicle with battery failure. The battery was replaced; however, the instrument panel was still black. The vehicle was not diagnosed or repaired. The mechanic informed the contact that when the vehicle was started, the battery charge immediately started to drain. The mechanic was contacted and reached out to the manufacturer for assistance. The failure mileage was approximately 13,000.

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that after driving home and parking the vehicle in the driveway, the contact later discovered that the rear tailgate had erroneously opened. The vehicle was taken to the local dealer, who diagnosed the vehicle and determined that the exterior touchpad switch assembly on the rear tailgate was damaged due to water intrusion and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V060000 (LATCHES/LOCKS/LINKAGES); only the 2500 and 3500 models were included. The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 45,000.

2022 ZR2 Silverado with the L87 6.2L. Have been complaining of shuttering starting at 22,500 miles and a few times after that. Vehicle passed PICO recall test and engine failed within 2,000 miles with zero warning. I was merging into traffic accelerating.

Component Involved: Visibility/Backup Device, Electrical System, Forward Collision Avoidance Description of Incident: The Android 12-based infotainment system in this vehicle is suffering from a progressive hardware/software failure that creates a severe, multi-layered safety hazard. CRITICAL DRIVER DISTRACTION: The system has become largely non-responsive, requiring me to repeatedly press on-screen buttons to perform basic functions. This forces me to divert my eyes and manual attention away from the road for periods far exceeding 2 seconds. This "visual-manual distraction" is a direct result of the system's inability to process commands, making safe operation impossible while attempting to use vehicle controls. VISIBILITY FAILURE (FMVSS 111): The failure impacts the digital rearview mirror and the safety camera feeds. These cameras frequently glitch, lag, or freeze, depriving me of necessary rear and surround visibility while moving. This is a violation of federal safety standards for rearview visibility. SYSTEMIC ELECTRICAL FAILURE: This "slowly dying" system is also interfering with the vehicle's communication bus, causing the power door locks to malfunction. This creates an entrapment or security risk. I have reported these issues to General Motors/OnStar. Despite their awareness of these "electrical gremlins" and the existence of limited service updates (like Program #N242435631), no permanent fix has been provided. This is a systemic safety defect that requires a mandatory recall to prevent accidents caused by driver distraction and visibility loss. The system needs updating to Android 14. It is Android 12 now. This is the fix. Gm want me to pay $250 for a hour for a macanic to update it. Gm was updating over the air, but it was causing the battery on the vehicle's to prematurely die under warranty. It was affecting their bottom line.