2019 CHEVROLET SILVERADO 1500 Recalls, Complaints & Safety

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 35 MPH on the highway, the vehicle started vibrating abnormally. The Electronic Stability Control (ESC) warning light was illuminated. The vehicle remained operable, but the vibration remained constant. The vehicle was taken to the dealer, but it was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 120,000.

motor only has 41000 miles and uses 1 quart of oil every 700 miles

Driving my truck and I suddenly got a warning on my dashboard that said, "Low Oil Pressure. Turn Engine Off." I pulled over immediately, shut off the the engine and called for a tow. Dealership called to let me know the engine was seized and would cost $22,270 to repair. Looking online I found that Chevy had released a Customer Service Program (CSP) detailing that the oil coolant lines in 2019 Silverado 1500 could have a weak / defective crimp holding the oil coolant line onto the connector and could separate causing catastrophic oil loss. It is also stated in the CSP that cold weather makes the issue more likely. I have tried getting GM to cover the repair since they knew about the issue and never contacted me to make the fix. GM is maintaining that they did nothing wrong and that my VIN is not listed as one of the vehicles in need of repair. This, despite the acknowledgement of the CSP and that the CSP "is for the dealerships." Which I pointed out the correction listed was for me to have the oil lines replaced and that never happened. I also pointed out as they said this wouldn't have been listined on my VIN because it was for dealerships and yet no one: not GM, not the dealership I bought the truck from, nor the dealership that regularly serviced my truck mentioned the oil line issue to me.

Oil cooler line leak.

Oil cooler lines are leaking oil. A known GM issue with many owner complaints online. Transmission issues. Motor issues. electrical issues. brake issues. These particular trucks have many issues and nobody is taking responsibility for the issues.

I’d like to report a serious, ongoing safety concern with my 2019 Chevrolet Silverado (5.3 V8 53,028 mi) since Dec 2025. Over the last 4 months, I have experienced at least 20 engine failures/loss of power, with no engine light illuminated after restarting truck. These failures result in a complete loss of power, including steering and braking, posing a significant risk of a crash. Chevy said it would be hard to diagnose with no engine warning light on. Feb 24th, engine failure, warning light stayed on and towed truck to Chevy. Truck on standby, repaired Mar 10th, replacing 2 oxygen sensors per Diagnostics. Picked it up on March 11th, but engine shutdown again the same day and 4 additional failures while driving in my neighborhood, making the truck undrivable. I reached out to Chevy service supervisor, Juliana, but have received no response for the last 10 days. I urge NHTSA to investigate this defect as it poses a severe safety risk. Thank you for your urgent attention.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated on three occasions while driving at various speeds, there was a clunking or clicking sound coming from the engine compartment, before the vehicle lost power. The vehicle was taken to a dealer where it was diagnosed with engine rod bearing failure. The contact was informed that the rod bearings and engine block needed to be replaced. The vehicle was not repaired and was taken to the residence and parked. Less than a week later, the vehicle was taken back to the same dealer for the repairs. The vehicle was repaired, but the failure reoccurred approximately five months later. The vehicle was taken back to the same dealer where it was diagnosed with an exhaust manifold leak. The contact was informed that the exhaust manifold needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately two months later. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 103,000.

VECHILE CONTINUES TO FAIL OIL CONSUMPTION TEST, TEST BEGAN 09/2023, AND CONTINUES TO BE THE ISSUE PRESENT DAY. ENGINE WAS REPLACED 2025, 3-4 MONTHS LATER TRANMISSION WENT OUT. TRANSMISSION REPLACED 2025. OIL CONSUMPTION CONTINUES TO FAIL. DEALERSHIP CHUCK HUTTON 2471 MT. MORIAH ROAD, MEMPHIS, TN 38115 PERFORMED ALL THESE SERVICES. SAFETY CONCERN IS THAT THE LEAKING OIL POLLUTION IS CAUSING HARM TO ME AND MY FAMILY AS WELL AS LEAVING OIL RESIDUE IN THE DRIVEWAY. NO WARNING MESSAGES EXCEPT FOR WHEN IT SAYS ADD OIL, THAT'S WHEN I'M PUT ON NOTICE THAT THE VECHILE IS LOSING OIL. DUE TO THE LEAKING OIL, OIL IS NOW MIXING WITH GASOLINE, INDICATING THERE TO BE AN ISSUE WITH THE FUEL PUMP. NOW BEIND DIRECTED TO REPLACE THE FUEL PUMP. THIS HAS BECOME VERY COSTLY FOR ME AND MY FAMILY AND CONTINUES TO BE AN ON-GOING PROBLEM

I am reporting a catastrophic internal engine failure in a 2019 Chevrolet Silverado 1500 at 87,600 miles. Prior to this event, there were NO warning lights or symptoms. While traveling alone during the holiday on a remote, one-lane road with no shoulder, the vehicle suddenly suffered a loss of power. Every warning light on the dashboard illuminated at once, followed by shaking, misfiring, and loud knocking from the engine. Because I was on a one-lane road with no place to pull over, this created an immediate safety hazard for me and oncoming traffic. I had the car towed to the dealership ( where I bought the truck) confirmed the failure was a collapsed lifter and scored camshaft (which i found out to be a known design flaw in the 5.3L DFM engine). The dealer said it was not under warranty. I felt held over a barrel by the dealership; they initially provided an inflated quote and told me it would cost approximately $1,200, not including tax and shop fees, just to put the engine back together if I wanted to tow it elsewhere for a second opinion. I was forced to pay over $8,395 under protest just to regain use of my primary vehicle after 42 days of downtime. Upon completion, the dealer provided a "Lifetime Warranty" on the replacement parts. This is a tacit admission that these components were never intended to fail during the life of the vehicle. GM refuses to include this vehicle in its coverage list, treating a dangerous engine stall as a simple "out of warranty" repair. This is a systemic safety defect that requires a mandatory recall expansion before it results in a terrible accident. My understanding is that a Class Action lawsuit, Harrison vs. General Motors, for this same thing, but they say my car is not in it, i should have been put on notice for this so I could protect myself.

My husband, [XXX] son, my [XXX] mother-in-law, and I were traveling on the expressway at approximately 70 miles per hour in our 2019 Chevrolet Silverado 1500 with the 5.3L engine when the dashboard suddenly lit up with warning lights and alarms. My husband looked in the rear-view mirror and saw a large amount of smoke coming from the truck. We immediately had to cross two lanes of heavy traffic to reach the shoulder and get off the roadway safely. When I opened my door, I could see that engine oil was pouring from the truck and running down the expressway. We were stranded on the side of the expressway for over an hour before my brother was able to come pick us up. The tow truck company advised that it would take several hours before they could arrive. During that time, vehicles continued traveling at highway speeds and did not slow down despite our disabled truck being on the shoulder. The truck was shaking from the wind and force of cars and trucks passing by at high speeds. This created an extremely dangerous situation, particularly with our [XXX] child and my elderly mother-in-law in the vehicle. The truck was eventually towed to a local repair shop, where the mechanic determined that the engine oil cooler line had broken at the crimp, causing a significant oil leak. The repair required replacement of the oil cooler lines and related components at a cost of $2,109.92. Had we continued driving even briefly, the engine likely could have been severely damaged or destroyed due to the rapid loss of oil. This appears to match the known issue described in GM Customer Satisfaction Program N212326940 regarding oil cooler lines detaching from the crimp on 2019 Chevrolet Silverado trucks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Description: While driving at highway speeds, the oil cooling lines on my vehicle suffered a catastrophic failure, resulting in a total loss of engine oil within seconds. To ensure my safety and avoid being stranded in high-speed traffic, I proceeded less than a quarter-mile to reach the nearest exit. During the cooling process after the vehicle was stopped, the engine seized due to extreme thermal damage caused by the sudden lack of lubrication. Safety Risk: The sudden and total loss of engine oil at highway speeds presents a significant safety hazard. It creates an immediate risk of sudden engine stall or seizure while in traffic, which could lead to a high-speed collision. Furthermore, a high-volume oil leak onto hot engine components represents a severe fire risk. Technical Evidence & Manufacturer Response: There are existing Technical Service Bulletins (TSBs) for this specific vehicle model that explicitly identify these oil cooling lines as a known failure point. These TSBs state that failure to replace these lines can lead to the engine becoming non-functional. Despite this documented manufacturing defect and the clear safety implications of a sudden engine failure on a highway, Chevrolet has refused to provide a remedy, insisting that the engine replacement be paid for out-of-pocket. Requested Action: I am requesting that the NHTSA investigate this known defect for a potential safety recall, as the failure of these lines constitutes a predictable and dangerous loss of vehicle power and potential fire hazard.

Engine oil cooler line leaking at the crimps.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving approximately 30-35 MPH and exiting the interstate with a speed limit of 55 MPH, the instrument panel, check engine, stability control, and several other warning lights illuminated. The vehicle felt like there was a misfire coming from the engine. The contact pulled into the nearest parking lot and turned off the vehicle. The vehicle was driven to the dealer, while not exceeding 25 - 30 MPH. The dealer diagnosed the vehicle and determined that the camshaft was damaged, and the valve lifters had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer opened a case regarding the failure. The failure mileage was approximately 97,000.

Odometer Fraud. The contact purchased a 2019 Chevrolet Silverado 1500. The contact stated that upon arriving to the DMV parking lot to register the vehicle, the contact compared the VIN the dealer had initially provided prior to the purchase, to the VIN listed on the title and on the vehicle. The contact discovered that there was a VIN discrepancy. The contact contacted an independent mechanic retrieved a Carfax Report of the VIN listed on the title and informed the contact that the actual vehicle mileage was 182,041. The vehicle was a private sale. At the time of the purchase, the vehicle mileage was 72,409; however, the Carfax Report confirmed that the actual mileage was 182,041. The seller was contacted but failed to respond and had ended communications with the contact.

I have had to put my vehicle in the shop for transmission repair. The first time it was in the shop for over a month to only get it back and have the same issue. Now the shop is telling me that GM is having a system glitch and they are unable to program it.

Vehicle info: 2019 Silverado 1500 6.2L engine with 66,xxx miles. On 3/1/26 While towing my small snowmobile trailer I was driving on I-90 with cruise control set at 65 mph. Very suddenly and shockingly I heard an extremely loud knocking noise from the engine. I then witnessed several driver info messages stating things like "low oil pressure" "engine power reduced" among others and a check engine light. Amongst freeway traffic and now under no engine power and coasting I made an emergency lane change out of the passing lane and into the right lane and subsequently on to the shoulder of the interstate. Oil pressure was also noted to be very low during these events. I called a friend to pick me up off the side of the freeway and also had a local towing company get my truck and trailer off the side of the highway asap. This was a dangerous scenario and could've ended much worse. The vehicle is now at my residence and I am not sure what steps to take right now. As I am very aware of the current recall on similar models with the same engine. I have followed the issues and complaints of these trucks and suvs with the L87 6.2L engine closely. I was under the impression that my vehicle was not included in the recall and I have always been very diligent about vehicle maintenance. I've been watching my truck closely for abnormal noises, power or oil pressure loss or any other strange symptoms I have not noticed any warning signs. I even recently switched to the new dexos approved 0w-40 engine oil that GM is recommending and/or mandating. This was very sudden and scary scenario. I do have video of the engine noises if theyre. Theyre not currently formatted for this report

Engine oil cooler line leaks and crimping does not hold hose tight enough and slipped off crimp fitting. line came completely off of crimp fitting and leaked all engine oil. Forced engine to be turned off and low engine oil marked on dash.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 15 MPH and turning left, the low oil pressure and several unknown warning lights illuminated. The vehicle was pulled over into a parking lot. The contact stated that there was no oil in the engine. The vehicle was towed to an independent mechanic to be diagnosed. The mechanic associated the failure with NHTSA ID Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 30,000.

My 2019 Chevrolet Silverado has experienced repeated engine issues, including a confirmed timing chain failure. The vehicle has been taken in for repairs approximately 6–7 times for the same or related engine problems. Most concerning, the vehicle has stalled while driving, creating a serious safety hazard. Loss of power while in motion puts me and others at risk of an accident. Despite multiple repair attempts, the issue has not been permanently resolved. The timing chain failure is a major engine defect and not expected for a vehicle of this age and mileage. I am filing this complaint due to the safety risk associated with engine stalling and failure.

Brakes lock down at approximately 45 miles per hour

I was proceeding down the interstate when several of my dash lights came on to include the check engine light and the ABS light. My truck defaulted to a restriction of 62 mph and I lost majority of my brakes. I had to apply brute force to be able to get of the exit and to the Dealership. The dealership reprogrammed my truck’s system and charged me 300 dollars. I believe this is the same issue that has plagued many other Chevy trucks in the same model year.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while stopped at a stop sign, the vehicle stalled. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with premature wear in the transmission, and the transmission needed to be replaced. The contact researched and was made aware of an unknown recall; however, the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Transmission failed while in drive and going up a hill.

Crash

as i was driving down the highway the engine warning light came on and engine quit running immediately so i began to pull off of the road but couldn't get all the way off so it was sticking out on the highway i did put in park and checked oil level which was good, so i was going to try to push vehicle off the road more because there was semi-trucks and other vehicles going by at a high rate of speed but the shifter would not shift unless vehicle was running. so for the safety of my wife and myself we had to stand off into the ditch for about an hour waiting for help hoping no one slammed into our vehicle and there was some close calls. after getting the truck back to my home i then trailered it to a repair shop called Eagle Chevrolet in Chadron Nebraska where i was told the bearing in the engine had spun and it is very common on the engine in my truck which is an 6.2 L87 ENGINE and there is recalls on the same engine but only for the year 2022 and up and mine is a 2019 and was given a quote for Repair which is over $10,000.00

Engine Oil cooler line

I have a 2019 Chevrolet Silverado LT 1500 with only 19K Miles. When I brought this vehicle I was having problems with hearing a loud clunking noise coming from the rear of the Vehicle. Every Time I Stop at a red light, stop at a stop sign, yield at a yield sign, and slow down to turn in my driveway I can hear this clunking noise coming from the rear of the vehicle. If someone is riding in the backseat of the vehicle, they can feel the clunking noise every time I hit the brakes or slow down. After doing some research I honestly believe it’s the drive shaft that is on my vehicle that is causing this issue. Also, my vehicle does a hesitation when trying to accelerate on the gas pedal, which the drive shaft can cause this issue as well. There is a recall against this issue (Drive Shaft) but my Vin Number doesn’t call for a recall, I believe my vin number was missed in this recall. This is very dangerous because my Drive Shaft can drop beneath my vehicle while driving on the roads or highways and can cause my Truck to loose control and get into a serious accident or fatal accident. All I want is to have the Chevrolet Dealership to repair my Drive Shaft for free, because Chevrolet states that they will fixed all the drive shaft that is on recall on there time and the customer doesn’t have to pay anything. Please follow up on this serious matter. I don’t feel safe driving my truck anymore, so I keep it parked in my garage. PS : I took my truck in several times to three Chevrolet Dealership when I had full warranty’s and each Dealership told me that my truck is fine, I just have to drive it because it’s still new and this is not a problem at all.

Afm lifters has failed in my vehicle 3 times as of date. Being that its a costly repair this should be recalled. Information provided is the latest mileage.

The oil cooler lines cracked due to cold weather and oil spouted out of the engine. Truck was immediately pulled over when the chime went off, however the engine still seized up and needs to be replaced. No warning lights before, just the chime at 0 oil pressure. I see that Canada and Alaska has this part recalled and I want to know why it’s not recalled everywhere. No oil was leaking prior to this incident. This left us stranded on the side of the highway and we now have to purchase a new engine with only 65,000 miles on it.

Took it to Chevy dealer for oil cooler lines to be replaced I have been in touch with gm since my truck wasn’t under any open recalls to try to get some of the money back for the oil cooler lines since gm has had a big problem with them losing oil

My Chevrolet Silverado has unresolved Electronic Stability Control (ESC) issues after recall reprogramming was performed twice under my VIN. The vehicle is shaking, hesitating, experiencing reduced acceleration, and feels like it may stall while driving. The truck is unsafe to operate. Dealer diagnosis is scheduled. GM Customer Care advised me to take it to the dealership before escalation. This is a loss-of-propulsion safety concern combined with unresolved ESC recall repairs. Vehicle has approximately 130,000 miles. Symptoms include shaking, hesitation, near-stall, and power loss while driving. ESC recall previously performed and still not resolved. Vehicle is drivable but unsafe. Blinking Engine light code cylinder 1 misfire. All ESC lights on parking brake, traction control.

"Approximately four months ago, I noticed an oil leak coming from the midsection of the engine/transmission of my 2019 Chevy Silverado LTZ with the 6.2-liter engine. At the same time, I noticed a slight knocking or rattling noise coming from, I believe, the front of the engine. Upon taking it to the dealership, they replaced the engine oil coolant lines, only to find out that the engine was still leaking oil and still making the knocking and rattling noise. They then discovering that it was the rear main seal, they have since replaced it about one week ago. Yesterday, February 6th, about 12:15 pm in the afternoon, while I was getting off the I-405 in Renton Washington and merging onto the southbound lanes of 167. I was in the left lane and I made it about a quarter mile down 167 doing about 60 to 65 miles per hour and I lost power suddenly. As I started to merge into the right lane, I noticed the engine light came on, and then the truck seemed to kick down into first gear while I was doing 50 miles per hour, which instantly slowed it down. This forced me to cross over an on-ramp lane to get to the shoulder and come to a complete stop. After that, the truck would not start at all. I then had to sit on the side of the road for three and a half hours waiting for a tow truck to take me and my truck back to the dealership, which is also the same dealership where I bought the truck back in 2019. They have not diagnosed it yet as I just dropped it off at 4 pm on 2/5/2026. My truck has approximately 155,000 miles on it.

The contact owns a 2019 Chevrolet Silverado 1500. The vehicle was taken to the dealer for an oil change and the contact was informed that the engine oil coolant line had detached from the crimp joints, causing an oil leak. Prior to the maintenance service, oil stains were found on the ground of the garage floor. The vehicle was not repaired. The contact stated that a week prior to the failure, there was an abnormal coolant odor coming from the vehicle and was entering the cabin from the A/C vents. The vehicle was taken to the dealer, where a pressure test was performed, and the contact was informed that the radiator was cracked. The vehicle was not repaired. The vehicle was taken to Firestone for a second opinion, and it was confirmed that the radiator was cracked. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 40,000.

"Approximately four months ago, I noticed an oil leak coming from the midsection of the engine/transmission of my 2019 Chevy Silverado LTZ with the 6.2-liter engine. At the same time, I noticed a slight knocking or rattling noise coming from, I believe, the front of the engine. Upon taking it to the dealership, they replaced the engine oil coolant lines, only to find out that the engine was still leaking oil and still making the knocking and rattling noise. They then discovering that it was the rear main seal, they have since replaced it about one week ago. Yesterday, February 6th, about 12:15 pm in the afternoon, while I was getting off the I-405 in Renton Washington and merging onto the southbound lanes of 167. I was in the left lane and I made it about a quarter mile down 167 doing about 60 to 65 miles per hour and I lost power suddenly. As I started to merge into the right lane, I noticed the engine light came on, and then the truck seemed to kick down into first gear while I was doing 50 miles per hour, which instantly slowed it down. This forced me to cross over an on-ramp lane to get to the shoulder and come to a complete stop. After that, the truck would not start at all. I then had to sit on the side of the road for three and a half hours waiting for a tow truck to take me and my truck back to the dealership, which is also the same dealership where I bought the truck back in 2019. They have not diagnosed it yet as I just dropped it off at 4 pm on 2/5/2026. My truck has approximately 155,000 miles on it.

Engine was running at the mechanic shop after getting serviced for spark plugs ,wires, new radiator was installed,and transmission service. The engine was running on the lift for the mechanic to top off transmission fluid. The engine stop by itself. Went to restart the engine no start just extending cranking. The mechanic shop has the truck trying find the issue why did engine stop while running.

Cylinder 7 lost compression due to Cylinder 7 Exhaust AFM cylinder not moving. this is the second time I have had this issue in a little over a year. at the time of failure while driving the vehicle lost all power and would only run 25 - 30 mph causing me to have to veer off on the shoulder. yes it has been reproduced Register Chevrolet has it in the shop now and have found the same issue as before there were no warnings other than a slight backfire and then a severe engine misfire.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was parked in the driveway, and the contact became aware of a puddle on the ground underneath the vehicle. The contact thought that the puddle was coolant, but discovered that the vehicle was leaking oil. The vehicle was taken to the dealer, who determined that the oil cooler line had failed and needed to be replaced. The vehicle was not yet repaired. The contact related the failure to the Customer Satisfaction Program: N192220080 (Engine Oil Cooler Lines Detaching from Crimp – Canada and State of Alaska Only); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 118,000.

COMPLETE ENGINE FAILURE AND LOSS OF POWER. While driving, I lost complete power of all systems and truck shut down with no warning lights or alarms at all. Truck is regularly serviced but has always used oil between servicing. Truck had only been driven for 500 miles since last oil service. Upon towing to the repair shop, we were told that the engine was destroyed and we have to have a new engine.