1996 CHEVROLET SILVERADO 1500

0 recalls — 10 complaints — 3 TSBs

No recalls found for this vehicle.

Complaint Statistics

10 total complaints 2 crashes 2 injuries 2 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC	2
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	1
SEAT BELTS	1
STEERING	1
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	1
WHEELS	1
ENGINE AND ENGINE COOLING	1
VISIBILITY	1
SERVICE BRAKES	1

Incident date: Jul 4, 2015

TL* THE CONTACT OWNS A 1996 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND AS THE BRAKE WARNING LIGHT ILLUMINATED. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BRAKE LINE WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR ... Read more

Incident date: Feb 11, 2004

1996 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE PROBLEMS. *SMD THE CONSUMER NOTICED ANTI-FREEZE ON THE GROUND TOWARD THE REAR OF THE ENGINE. HE TOOK THE VEHICLE TOOK THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. A GM SERVICE MANAGER STATED, THEY WERE AWARE OF COOLANT ... Read more

Incident date: Feb 11, 2004

Incident date: May 16, 2012

TL* THE CONTACT OWNS A 1996 CHEVROLET SILVERADO 1500. THE CONTACT STATED THE CABLE THAT HOLDS THE SPARE TIRE UNDER HIS VEHICLE BROKE CAUSING THE TIRE TO FALL OFF. THE CONTACT HAD A FLAT TIRE AND NOTICED THE CABLE HAD BROKEN WHEN HE ATTEMPTED TO RETRIEVE THE SPARE TIRE. HE HAD NO IDEA WHEN THE TIRE F... Read more

Incident date: Aug 30, 2010

UPON BEING APPLIED, THE BRAKE PEDAL WAS GOING ALL THE WAY TO THE FLOOR OF THE VEHICLE. THE DEALER INFORMED ME THAT THIS IS A KNOWN PROBLEM WITH CHEVY TRUCKS AND THAT IT IS VERY COMMON IN THE STATES THAT HAVE SNOW AND ICE. THEY TOLD ME THAT THE ABS SENSORS NEEDED TO BE REMOVED & CLEANED. I REQUEST... Read more

Incident date: Mar 15, 2010

VEHICLE'S ABS ENGAGES IN UNWANTED FASHION AT LOW SPEEDS WHEN BRAKING FOR A STOP. EXACTLY DUPLICATES SYMPTOM IN RECALL BELOW. EXTENDS STOPPING DISTANCE AND CRASH POTENTIAL. NHTSA CAMPAIGN ID NUMBER : 05V379000 VEHICLE MAKE / MODEL: MODEL YEAR(S): CHEVROLET / AVALANCHE 2002 CHEVROLET / SILV... Read more

Incident date: Mar 15, 2010

Incident date: Apr 26, 2008

TL*THE CONTACT'S FRIEND OWNS A 1996 CHEVROLET SILVERADO 1500. WHILE ATTEMPTING TO USE THE SEAT BELT, THE CONTACT'S SON REALIZED THAT IT WAS LOCKED IN PLACE. THEREFORE, HE WAS UNABLE TO USE THE SEAT BELT. WHILE DRIVING 55 MPH, THE DRIVER ATTEMPTED TO PASS ANOTHER VEHICLE AND HAD DIFFICULTY STEERIN... Read more

Crash 1 injured 1 deaths

Incident date: Apr 26, 2008

Crash 1 injured 1 deaths

Incident date: Jan 11, 2007

TL*THE CONTACT OWNS A 1996 CHEVROLET SILVERADO 1500. THE WIRES ON THE INSIDE OF THE THROTTLE CABLE HAVE COME APART AND CAUSED THE ACCELERATOR PEDAL TO STICK. THE CONTACT HAS BEEN ATTEMPTING TO OBTAIN THE PART FROM EITHER A CHEVROLET DEALER OR THE MANUFACTURER AND WAS INFORMED THAT PART NUMBER 1573... Read more

Technical Service Bulletins — 1996 CHEVROLET SILVERADO 1500

3 manufacturer communications from 3 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
091130 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES	1
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	1
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)	1

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

091130 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CHEVROLET:GMC: ENGINEERING INFORMATION-FUEL TANK PRESSURE SENSOR, DTCS P0446, P0451 OR P0454 SET. GMC ENGINEERING IS ATTEMPTING TO DETERMINE THE ROOT CAUSE OF THE ABOVE CONCERN. *PE

NHTSA Safety Investigations — CHEVROLET SILVERADO 1500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 2021

Air Bag Malfunction

On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (... MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.Read more

CHEVROLET SILVERADO 1500 — All Years Overview

Complete safety history for the CHEVROLET SILVERADO 1500 across all model years (1997–2026).

393 Total Recalls

22,534 Total Complaints

1 Investigations

1,063 Reported Crashes

347 Reported Fires

54 Reported Deaths

CHEVROLET SILVERADO 1500 — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	4	31	View
2025	0	102	View
2024	6	321	View
2023	18	436	View
2022	26	706	View
2021	26	928	View
2020	48	938	View
2019	32	1,438	View
2018	18	715	View
2017	24	940	View
2016	34	1,027	View
2015	34	1,392	View
2014	24	2,186	View
2013	12	385	View
2012	10	274	View
2011	16	695	View
2010	18	449	View
2009	16	553	View
2008	11	1,090	View
2007	10	1,054	View
2006	0	462	View
2005	0	642	View
2004	0	951	View
2003	0	959	View
2002	0	620	View
2001	0	627	View
2000	0	731	View
1999	2	711	View
1998	2	452	View
1997	2	693	View
1996 (current)	0	10
1995	0	6	View
1994	0	10	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View