2010 RAM 1500 Recalls, Complaints & Safety

During unrelated work, a mechanic discovered the retaining ring for recall N08 (rear axle pinion nut) was not installed and the pinion nut was loose enough to turn by hand. He stated the recall had either been performed incorrectly or not at all, and that the vehicle was unsafe to drive. The recall shows “completed” in 2013, but the defect is still present. I contacted Stellantis Customer Care, submitted photos, and they confirmed in writing that if the defect still exists, the recall must be performed free of charge regardless of age, mileage, or ownership. I sent the photos of the missing ring, screenshots showing the recall marked completed, and Stellantis’ confirmation to the dealership before having the vehicle towed to verify coverage. The truck was towed to Time Chrysler Dodge Jeep Ram of Portland. My initial contact was [XXX] at that location. However, all recall decisions and communication later came from [XXX] , who works at a different dealership. Over the next month, the dealership repeatedly stalled the recall, saying they were waiting on approval from the district manager and then from the recall department, but no action was ever taken. Despite having Stellantis’ written confirmation and clear photographic evidence of the unresolved defect, the dealership refused to perform the recall. They insisted on treating it as a “warranty” issue and cited reasons such as mileage, age, and not being the original owner—none of which apply to safety recalls. They then stated that teardown and diagnosis “would run $1000,” even though the defect has already been documented by both the mechanic and Stellantis. All communication, including photos, the mechanic’s findings, Stellantis’ confirmation of coverage, and the dealership’s refusal, is available upon request. The truck has now been sitting at the dealership for over a month with an unresolved safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Was just driving and the engine shut off and a check engine light came on and won’t start again believe timing chain failed

2010 Dodge Ram 1500 truck purchased used late May 2025 with 57000 miles. Late August 2025 with 60000 miles rear axle fell off when driving on Freeway at 60 miles per hour. Very serious accident was narrowly avoided as could not steer vehicle.Truck was serviced at dealership for recall of a pinion nut coming loose at 36107 miles in September 2013. Per this recall, the loose pinion nut can cause the axle to fail. The recall maintenance done in September 2013 at 36107 miles only lasted 24000 miles and serious safety issues reoccurred. In my opinion, on my vehicle the recall did not fix the problem. Now I am stuck with a $5000 repair on a vehicle with known recalls and safety issues that was supposedly fixed.Perhaps a second recall should be considered regarding this issue.

Me and my husband were driving down the road to go see a friend and all of a sudden the wheel hub assembly broke in half causing us to have to slam on our brakes and keep from crashing. The wheel almost ended up under our truck making the truck look like it was kachowing like Lightening McQueen from the movie Cars

Odometer Fraud. The contact purchased a 2010 Dodge Ram 1500. The contact stated that while attempting to obtain an auto warranty from Car Shield, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 125,526 and at the time of registration, it was discovered that the mileage was 228,863.

I was driving to work on [XXX] when my rear end locked up and I slid sideways down [XXX]. I was going slower than normal due to slippery road conditions. The mechanic told me it was the pinion nut that froze up and locked up the gears and snapped the drive shaft. If it had been clear roads the truck probably would have flipped over. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Crash

I was driving to work on [XXX] when my rear end locked up and I slid sideways down [XXX]. I was going slower than normal due to slippery road conditions. The mechanic told me it was the pinion nut that froze up and locked up the gears and snapped the drive shaft. If it had been clear roads the truck probably would have flipped over. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Crash

took the vehicle to the dealer on 2/27/25 on invoice # chcs169951 and they have refused to fix the issue. i was given a proof of correction paper without doing any or the work and told that they are no responsible to fix the issue because it is an older vehicle. I have been trying to register the vehicle but am unable to because it will not pass the brake and light inspection. I was told that it would take 2-3 weeks to update the system and has now been close to 2 months and still no update.

The contact owns a 2010 Dodge Ram 1500. The contact stated while driving at an undisclosed speed, there was an abnormally loud sound coming from the rear of the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the rear axle differential pin retaining bolt had failed and needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 160,704.

Odometer Fraud. The contact purchased a 2010 Ram 1500. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 173,840 and at the time of registration, it was discovered that the mileage was 301,000.

Ignition,key fob will not correctly start engine. Engine dies going down the road , will not stay running after you start engine it just dies and kicks the key fob out to the floor. Trying to retrieve the fob and restarting the engine, and not crashing is a serious problem. Have nearly been in major crashes because of this .

We have had our truck taken to Nyle Maxwell in Taylor Texas and they have were suppose to check the truck because two lights came up on the dash board which dash ESP ABS and traction control light.The shift stick was stuck in park. They towed it to there shop but the lights were off and the gear shift was working. I drove off the lot had to stop at a light and my truck veered left sharply. They have looked at this problem twice. They are not finding anything but it is my truck I drive with my kids. We need so help. They also had to fix the ac and the serpentine belt because that broke while I was driving after they said it was good and safe to drive.

While driving my 2010 Dodge Ram 1500 Quad Cab, the key fob (FOBIK) has fallen out of the ignition while actively driving. The key can be removed from the ignition while actively driving with little to no effort. Upon this happening, the vehicle sometimes remains fully operable, at times it remains driving but looses speedometer, wipers, heat/ac, running/brake lights and turn signals, or the vehicle will completely shut off, losing all function and drivability to include power steering. In one instance, the vehicle remained driving but lost wipers and lights during a night time storm. On another occasion, the vehicle lost all drivability traveling at a high rate of speed at night with traffic on a highway in a rural area with no streetlights. This defect has provided for a multitude of highly dangerous events while driving. There IS a recall (recall ref K08) describing this exact issue, however my VIN was not included in the recall and is not being recognized and or honored for recall repair by local Chrysler Dodge Dealerships or by Chrysler Headquarters. Chrysler Headquarters customer service communicated it is the responsibility of the NHTSB to add my VIN to the recall in order for the repair or replacement of the faulty WIN module along with replacement and programming of key fobs to be covered. This repair is estimated to cost $2500.

WIN module failure. When driving down the road/highway, the vehicle will turn off with no warning of any problems. The key can be removed while the vehicle is still running. The vehicle will start up with the key cranked diagonally but when released the vehicle dies making it more difficult to start the vehicle after it dies while driving down the road/highway. When a bump is hit in the road the key moves and the vehicle dies. We have spoken to the local Dodge dealership who confirmed that it is a WIN module issue while servicing the vehicle due to other recalls as well as several locksmiths.

My husband was driving about 20mls per hrs when our truck cought fire the whole front of our truct cought fire. The front mirror and everything if distroit due to the fire .

Fire

My husband was driving about 20mls per hrs when our truck cought fire the whole front of our truct cought fire. The front mirror and everything if distroit due to the fire .

Fire

My husband was driving about 20mls per hrs when our truck cought fire the whole front of our truct cought fire. The front mirror and everything if distroit due to the fire .

Fire

Wireless ignition module fails and will stall out the engine. This can happen at speed or stopped. Wireless ignition module will intermittently fail and cause a loss of power at speed causing no power steering or power brakes

The frame has rusted thru, the fuel tank strap has failed and the fuel tank has dropped. If this had happened while driving, it could have killed him and many others. Upon researching for information, we found recall U04/nhsta 18v-160 which stated this document replaced service bulletin TSB# 1400218 - all for this exact problem. This was a regional recall/extended warranty and was not issued for vehicles in our region. But this document does state that should any vehicle meet the criteria described (make date range, model year, and problem) that that vehicle should be covered. My fathers truck meets all 3 criteria. Upon calling FCA (Fiat, Chrysler Automobiles), who issued the document, we were told that we aren't able to be included in this issue, since we don't have a recall listed and also because the recall turned from a recall to an extended warranty that expired in 2022. If this is a known issue why is there an expiration date on the repair of it? My father's truck only has about 67,000 miles on it, which is probably why the problem is only presenting now. And if we had known there was a possible chance that this could happen, why weren't we informed to check it? He is the original owner of the vehicle and we are appalled at the FCA repsonse. The document in reference is attached.

This incident has happened several times while driving on the road. When driving at slow speeds, approaching a red light, or slowing down to make a left or right turn, the vehicle shuts off without warning. The power steering and brakes stop working, making the car hard to handle. I have to put it in neutral, restart the vehicle, and start it back up without any problems. This is a very well-maintained vehicle and a daily driver. The car has 172000 miles on it. I have done internet research on this, and it seems to be a very common thing with Dodge Ram Trucks.

[XXX] My truck sway at 65mph, like a drunk person driving. Scary. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2010 Ram 1500. The contact stated while driving 40 MPH, there was an abnormal sound coming from the vehicle. The contact stated that the ESP, traction control, and ABS warning light illuminated. The vehicle was taken to the dealer and the tire pressure pump was replaced but the failure reoccurred. The vehicle was taken to the dealer, and they stated that the ABS module needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the part was no longer available. The failure mileage was 108,000.

My 2010 Dodge Ram 1500 shuts off without warning. The incident frequently happens when I am driving at city speeds. If I am turning, the vehicle shuts off, and the power steering also cuts off, causing problems turning the steering wheel. When I am driving straight, there are no warning lights on the dashboard, and the vehicle shuts down. This is very dangerous while going.

i recieved a recall for the rear axle pinion nut, took truck in and was told my truck was not involved. then i recieved another recall for the same thing and took truck in and they installed a retainer on the nut and this was supposed to fix the problem. now at 85,000 miles the pinion came loose so the retainer was not the answer. took to dealer and they want me to pay then try to get my money back from chrysler. i think chrysler should fix it at there cost because they knew they had a bad product to start with. truck is well taken care of not beaten normal driving. there is no way a rear end should go out at 85,000 miles. sent a notice to chrysler complaint dept but no responce, gues they just dont care.hope you do

The contact owns a 2010 Dodge Ram 1500. The contact stated that while driving at an unknown speed, the vehicle was jerking as the check engine warning light illuminated. The vehicle was taken to a local dealer where the contact was informed that the oxygen sensors and transmission fluid needed to be replaced. The vehicle was not repaired, however, the contact attempted to replace the oxygen sensors himself. The failure reoccurred and the vehicle was then taken to an independent mechanic, where it was diagnosed that the engine needed to be replaced. The vehicle was repaired and the proper oxygen sensors were replaced; however, the contact stated that when he drove over 45 MPH, all warning lights would illuminate on the instrument panel and that an abnormal noise was heard coming from the rear of the vehicle. The vehicle was then taken back to the independent mechanic where it was diagnosed that the transmission needed to be replaced. Additionally, during the repair the contact was informed that the rear differential had loose bolts and would also need to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure however the VIN was not available at the time of the call therefore a case could not be opened. The VIN was not available. The approximate failure mileage was 240,000.

Charging system failure at pcm causing low voltage and battery will not charge causing the vehicle to become disabled. I was on the interstate battery light came Om with system Low voltage code for engine light. The truck shut off and I was left without power steering or brakes. doing 75mph. Voltage regulator is in pcm and pcm needs replaced. Vehicle is still out of commission

The contact owns a 2010 Dodge Ram 1500. The contact received notification of NHTSA Campaign Numbers: 13V038000 (Power Train), 18V160000 (Fuel System, Gasoline), and 17V821000 (Power Train). The contact stated that while driving at an undisclosed speed, the rear axle pinion holding the rear drive shaft loosened. The vehicle was taken to the dealer, and the dealer declined to honor the recall repairs due to the age of the vehicle and possible liability issues. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 183,000.

The vehicle was repaired under recall, but was not correctly fixed. Now the rear differential is totally shot with no warning. My dealer says it will not be covered under recall warranty since I was not the owner at the time of the recall repair.

Failure in cam and lifters, this am I going problem that needs to be addressed. These repairs should be covered 100% by Dodge / Ram.

The truck has shut down completely while turning into busy intersections and crossing highways we have been lucky to have been not hit by oncoming traffic. You have to put the truck in park and restart the vehicle. It has been to the dealership in the past and couldn’t be replicated. It shows no faults just shuts off for no reason this has happened 5 times in 3 months, 8 in a year,

Vehicle driving speed limit of 65 when all of a sudden check engine light came on and off a few times. Driver pulled over to side of road and raised hood. Waiting on tow truck and vehicle caught fire in engine compartment.

Fire

Vehicle driving speed limit of 65 when all of a sudden check engine light came on and off a few times. Driver pulled over to side of road and raised hood. Waiting on tow truck and vehicle caught fire in engine compartment.

Fire

The contact owns a 2010 Dodge Ram 1500. The contact stated that while her husband was driving at 75 MPH, the ignition key fell out of the ignition module. There were no warning lights illuminated. The contact's husband veered to the side of the road and was able to place the key back in the ignition module. The contact stated that her husband continued to drive the vehicle. The contact stated that the ignition module had failed to hold the key and they were unable to restart the vehicle. The contact referenced NHTSA Campaign Number: 10V200000 (Electrical System). The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 120,000.

One of the Front Swivel bar ends fell off.

When I go to get fuel, the tank takes the fuel slower than it should. And if does start to accept the fuel at the pace in which the pumps deliver it, it then overflows.

When going to start the vehicle, the key fob has to be turned multiple times. I have had the key reinstalled by a lock Smith. He stated this issue is common with the dodge key fobs. This could be a safety issue if you were to be somewhere in the woods or such and your vehicle did not start.

vehicle has 113,000 miles on it now, the engine is knocking so I brought it in to Weber in Detroit Lakes Minnesota they say it needs cams and lifters e c t. Estimate is $5,000 or new engine $9,000 so now I can't get to work! I commute back and forth every day 70 miles each way, this vehicle should not have this problem as of yet in my eyes! Will the factory / dealership warranty this fix for me? I purchased vehicle from Weber in Detroit Lakes almost four years ago with 80,000 miles on it I have only driven at 33,000 miles since then!! I don't have that kind of money for this fix nor can I afford to buy a replacement vehicle but now the knocking you can hear it outside the vehicle but you cannot hear it in the cab of the vehicle so how long has this problem actually been going on before the fact of me noticing it just very recently so then I quit driving it immediately and brought it directly to Weber as per appointment

TL* THE CONTACT OWNS A 2010 RAM 1500. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE ELECTRICAL SYSTEM FAILED CAUSING THE TURN SIGNALS, THE SPEEDOMETER, AND THE FANS TO MALFUNCTION. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED WITH THE WIRELESS IGNITION NODE NEEDING TO BE REPLACED. THE CONTACT RELATED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 10V200000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE BUT INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 53,200.

THE AIRBAG LIGHT IN MY TRUCK CAME ON IN SEPTEMBER OF 2018. I HAVE HAD IT CHECKED OUT AND THE AIRBAG CONTROL MODULE IS NOT WORKING. I HAVE CONTACTED DODGE ON NUMEROUS OCCASIONS TO ORDER THE PART HOWEVER IT HAS BEEN ON AN INDEFINITE BACKORDER FOR THE PAST FEW YEARS. THE LAST TIME I CONTACTED THE DEALERSHIP WAS THIS PAST TUESDAY, FEBRUARY 23, 2021. I ALSO CONTACTED THE CHRYSLER CARE LINE IN JANUARY 2021. I AM AWARE THAT THERE WAS A CIVIL ACTION LAWSUIT AGAINST THE MANUFACTURER REGARDING THIS PART DATING BACK TO AROUND 2017. THIS IS A SIGNIFICANT SAFETY ISSUE BECAUSE MY TRUCK DOES NOT HAVE WORKING AIRBAGS. I AM ASKING FOR FURTHER ASSISTANCE IN FIXING OR SETTLING THIS ISSUE.