2003 MERCURY MOUNTAINEER Recalls, Complaints & Safety

After disconnecting the battery for battery replacement original equipment 6 cd in dash player only shows CD Error. no error number. When investigating on the internet I found over 100 complaints with the same issue. I tried all the corrections suggested but nothing works. I own the car since new has very low mileage. I have 6 diskettes in the unit I cannot eject under any circumstance.

BIG O TECHS CONNED WIFE INTO BUYING 2 TIRES AND WE OWN AWD SUV THAT REQUIRES 4 AT THE SAME INTERVALS .I IMMEDIATELY NOTIFY THEM THAT THIS IS NOT SAFE AND WILL DAMAGE MY CAR THEY CONTINUED FOR OVER 2 MONTHS TO LIE TO ME ABOUT HAVING SOMEMONE COMTACT ME . I HAVE ALL THE COMMUNICATIONS I'VE HAD WITH THEM THROUGH MESSAGES. A FEW WEEKS AFTER THEY PUT THE TIRES ON AND REFUSED TO TAKE THEM OFF AND PUT MY OLD O ES BACK ON AND ISSUE A REFUND WELL MY TRANSMISSION AND TRANSFER CASE FAILED I CONTACTED THEM AGAIN AND AGAIN THEY LIED TO ME ABOUT SOMEONE CONTACTING ME . I TOOK MY SUV TO THE TRANSMISSION SHOP WE MEASURED OVER 2 INCH CIRCUMFERENCE DIFFERENCE. I INFORMED BIG O THAT I HAVE A TSB ISSUED BY FORD MY EMPLOYER THAT DATES BACK TO 2011 ON TIRE CIRCUMFERENCE PROCEDURES FOR TIRE DEALERS TO FOLLOW . THE RESPONSE I GOT WAS THAT BIG O REFUSES TO REVIEW OR ACKNOWLEDGE TSBS . THAT'S ALARMING AS TSBS ARE ISSUED MY THE MANUFACTURERS FOR SAFETY . I HAD MY SUV FIXED FOR 3000+ $ OUT OF POCKET AND CONTACTED BIG O THE DAY I PICKED IT UP ABOUT THE TIRES STILL BEING ON THERE . I WARNED THEM THIS IS DANGEROUS AND CAN HURT MY NEW DRIVETRAIN THE VERY NEXT DAY FROM GETTING MY SUV OUT OF THE SHOP THE TIRES AGAIN CAUSED BINDING TO OCCUR BUT THIS TIME IT LED TO WHAT SHOULD'VE BEEN A FATAL ACCIDENT WHERE AS THE AWD SYSTEM DONE IT'S JOB BUT THE TIRES BEING OFF BY SO MUCH MADE THE SUV BIND A THREE IN INTO 3 360 DEGREE SPIN AND SLAMMED THE CONCRETE MEDIAN TOTALING MY VEHICLE AND INJURING MY WIFE. I'VE DOCUMENTED ALL MESSAGES WITH BIG O AND HAVE MUCH MORE EVIDENCE RELATED TO THIS CASE THAT I'M UNABLE TO ADD IN THIS DESCRIPTION BECAUSE I'M RUNNING OUT OF ALLOWED CHARACTERS REMAINING . I DID CONTACT BIG O AGAIN AND SENT PHOTOS OF MY CRASHED SUV AND SUDDENLY THEY NOW WON'T RESPOND BACK AT ALL . I THINK THIS JUSTIFIES A FULL INVESTIGATION INTO THERE REFUSAL TO REVIEW TSBS AND FULL REIMBURSEMENT FOR ALL MY

Crash 1 injured

BIG O TECHS CONNED WIFE INTO BUYING 2 TIRES AND WE OWN AWD SUV THAT REQUIRES 4 AT THE SAME INTERVALS .I IMMEDIATELY NOTIFY THEM THAT THIS IS NOT SAFE AND WILL DAMAGE MY CAR THEY CONTINUED FOR OVER 2 MONTHS TO LIE TO ME ABOUT HAVING SOMEMONE COMTACT ME . I HAVE ALL THE COMMUNICATIONS I'VE HAD WITH THEM THROUGH MESSAGES. A FEW WEEKS AFTER THEY PUT THE TIRES ON AND REFUSED TO TAKE THEM OFF AND PUT MY OLD O ES BACK ON AND ISSUE A REFUND WELL MY TRANSMISSION AND TRANSFER CASE FAILED I CONTACTED THEM AGAIN AND AGAIN THEY LIED TO ME ABOUT SOMEONE CONTACTING ME . I TOOK MY SUV TO THE TRANSMISSION SHOP WE MEASURED OVER 2 INCH CIRCUMFERENCE DIFFERENCE. I INFORMED BIG O THAT I HAVE A TSB ISSUED BY FORD MY EMPLOYER THAT DATES BACK TO 2011 ON TIRE CIRCUMFERENCE PROCEDURES FOR TIRE DEALERS TO FOLLOW . THE RESPONSE I GOT WAS THAT BIG O REFUSES TO REVIEW OR ACKNOWLEDGE TSBS . THAT'S ALARMING AS TSBS ARE ISSUED MY THE MANUFACTURERS FOR SAFETY . I HAD MY SUV FIXED FOR 3000+ $ OUT OF POCKET AND CONTACTED BIG O THE DAY I PICKED IT UP ABOUT THE TIRES STILL BEING ON THERE . I WARNED THEM THIS IS DANGEROUS AND CAN HURT MY NEW DRIVETRAIN THE VERY NEXT DAY FROM GETTING MY SUV OUT OF THE SHOP THE TIRES AGAIN CAUSED BINDING TO OCCUR BUT THIS TIME IT LED TO WHAT SHOULD'VE BEEN A FATAL ACCIDENT WHERE AS THE AWD SYSTEM DONE IT'S JOB BUT THE TIRES BEING OFF BY SO MUCH MADE THE SUV BIND A THREE IN INTO 3 360 DEGREE SPIN AND SLAMMED THE CONCRETE MEDIAN TOTALING MY VEHICLE AND INJURING MY WIFE. I'VE DOCUMENTED ALL MESSAGES WITH BIG O AND HAVE MUCH MORE EVIDENCE RELATED TO THIS CASE THAT I'M UNABLE TO ADD IN THIS DESCRIPTION BECAUSE I'M RUNNING OUT OF ALLOWED CHARACTERS REMAINING . I DID CONTACT BIG O AGAIN AND SENT PHOTOS OF MY CRASHED SUV AND SUDDENLY THEY NOW WON'T RESPOND BACK AT ALL . I THINK THIS JUSTIFIES A FULL INVESTIGATION INTO THERE REFUSAL TO REVIEW TSBS AND FULL REIMBURSEMENT FOR ALL MY

Crash 1 injured

BIG O TECHS CONNED WIFE INTO BUYING 2 TIRES AND WE OWN AWD SUV THAT REQUIRES 4 AT THE SAME INTERVALS .I IMMEDIATELY NOTIFY THEM THAT THIS IS NOT SAFE AND WILL DAMAGE MY CAR THEY CONTINUED FOR OVER 2 MONTHS TO LIE TO ME ABOUT HAVING SOMEMONE COMTACT ME . I HAVE ALL THE COMMUNICATIONS I'VE HAD WITH THEM THROUGH MESSAGES. A FEW WEEKS AFTER THEY PUT THE TIRES ON AND REFUSED TO TAKE THEM OFF AND PUT MY OLD O ES BACK ON AND ISSUE A REFUND WELL MY TRANSMISSION AND TRANSFER CASE FAILED I CONTACTED THEM AGAIN AND AGAIN THEY LIED TO ME ABOUT SOMEONE CONTACTING ME . I TOOK MY SUV TO THE TRANSMISSION SHOP WE MEASURED OVER 2 INCH CIRCUMFERENCE DIFFERENCE. I INFORMED BIG O THAT I HAVE A TSB ISSUED BY FORD MY EMPLOYER THAT DATES BACK TO 2011 ON TIRE CIRCUMFERENCE PROCEDURES FOR TIRE DEALERS TO FOLLOW . THE RESPONSE I GOT WAS THAT BIG O REFUSES TO REVIEW OR ACKNOWLEDGE TSBS . THAT'S ALARMING AS TSBS ARE ISSUED MY THE MANUFACTURERS FOR SAFETY . I HAD MY SUV FIXED FOR 3000+ $ OUT OF POCKET AND CONTACTED BIG O THE DAY I PICKED IT UP ABOUT THE TIRES STILL BEING ON THERE . I WARNED THEM THIS IS DANGEROUS AND CAN HURT MY NEW DRIVETRAIN THE VERY NEXT DAY FROM GETTING MY SUV OUT OF THE SHOP THE TIRES AGAIN CAUSED BINDING TO OCCUR BUT THIS TIME IT LED TO WHAT SHOULD'VE BEEN A FATAL ACCIDENT WHERE AS THE AWD SYSTEM DONE IT'S JOB BUT THE TIRES BEING OFF BY SO MUCH MADE THE SUV BIND A THREE IN INTO 3 360 DEGREE SPIN AND SLAMMED THE CONCRETE MEDIAN TOTALING MY VEHICLE AND INJURING MY WIFE. I'VE DOCUMENTED ALL MESSAGES WITH BIG O AND HAVE MUCH MORE EVIDENCE RELATED TO THIS CASE THAT I'M UNABLE TO ADD IN THIS DESCRIPTION BECAUSE I'M RUNNING OUT OF ALLOWED CHARACTERS REMAINING . I DID CONTACT BIG O AGAIN AND SENT PHOTOS OF MY CRASHED SUV AND SUDDENLY THEY NOW WON'T RESPOND BACK AT ALL . I THINK THIS JUSTIFIES A FULL INVESTIGATION INTO THERE REFUSAL TO REVIEW TSBS AND FULL REIMBURSEMENT FOR ALL MY

Crash 1 injured

I HAVE SPENT THOUSANDS OF DOLLARS ON THE TRANSMISSION REPAIR AND NO MATTER WHAT I DO THERE ALWAYS A PROBLEM SHIFTING GEARS

I HAVE A MERCURY MOUNTAINEER 2003 AND IT WAS STATIONED THERE WAS A CRACK IN THE BACK MIDDLE OF THE HATCH NOW THERE A HUGE CRACK AND MY WINDOW OF THE TRUNK CAME UNHINGED AND FELL OFF I SEE THIS PROBLEM IN ALL MOUNTAINEERS THEY ALL HAVE THE CRACK IN THE HATCH HOPE THEIRS DON'T FALL OFF I SEE IT IN ALMOST EVERYONE'S. THIS SHOULD BE RECALLED BECAUSE WHAT WOULD OF HAPPENED IF I WAS DRIVING AND IT FELL OFF THIS IS NOT SAFE. PLEASE HAVE THIS INVESTIGATED. THANK YOU!

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. WHILE DRIVING, THE TRANSMISSION FAILED TO SHIFT. WHILE PARKED, THE EMERGENCY BRAKES FAILED AND CAUSED THE VEHICLE TO ROLL AWAY. THE CONTACT WAS ABLE TO GAIN CONTROL OF THE VEHICLE. IN ADDITION, THE BRAKE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES AND HOSES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE ISSUE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

1) FRONT WHEEL BEARING HUB ASSEMBLY FAILURE RESULTING IN UNSAFE UNDRIVEABLE (THIS HAS BEEN REPEATEDLY REPORTED BY VEHICLE OWNERS REGARDLESS OF VEHICLES MILAGE) FAILURE ACCURED WHILE SLOWING DOWN FOR A STOPLIGHT AFTER EXITING A PARKING LOT OF A RESTAURANT 2) LIFT HATCH CRACKED CENTER OF HATCH ABOVE THE EMBLEM POTENTIALLY ALLOWING WATER INTO THE INTERIOR WORKING OF HATCH AND CAUSING UNTOLD AND UNSEEN WATER RELATED DAMAGES(THIS IS AN ADMITTED FORD MANUFACTURING DEFECT ACROSS THE ENTIRE VEHICLE LINE SPENDING MULTIPLE YEARS PRODUCTION)

MY 2003 MERCURY MOUNTAINEER HAS A SOLID AIR BAG LIGHT ON. IT HAS A CODE OF 33, WHEN YOU TURN THE CAR ON, THE LIGHT GOES ON AND BLINKS 3 TIMES THEN 3 MORE TIMES. THIS INDICATES A CODE 33. FORD HAS A TECHNICAL LETTER ABOUT THE ISSUE. THE LETTER STATES THERE IS A KIT FOR THIS PROBLEM. 1L2Z-78610E22-AAA IS THE KIT FOR A MEDIUM DARK PARCHMENT KIT. THIS SHOULD BE A RECALL ITEM AS IT IS A KNOWN DEFECT. FORD WANTS TO CHARGE $281.00 FOR THE PART. OUTRAGEOUS. I WOULD BE FORCED TO PAY OR NOT GET MY STATE VEHICLE TEST PASSED. DEFECTIVE PART SHOULD BE COVERED UNDER SAFETY RECALL ! SEE INFORMATION : 2003 MERCURY MOUNTAINEER BUILD DATE 09/02 VIN===[XXX] BELOW IS A COPY OF A TECHNICAL SERVICE BULLETIN REGARDING YOUR CONCERN. YOU CAN BUY THE KITS THROUGH ANY FORD DEALER, THAT'S ABOUT THE ONLY PLACE TO GET THEM. YOU'LL FIND THE BUILD DATE ON THE VIN TAG ON THE DRIVER'S DOOR. FORD:2002-2003 EXPLORER MERCURY:2002-2003 MOUNTAINEER ISSUE: SOME 2002-2003 4DR EXPLORER/MOUNTAINEER VEHICLES MAY EXHIBIT AN AIR BAG WARNING LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B2292 AND LIGHT FLASHING CODE (LFC) 33 (DRIVER SEAT PRETENSIONER FAULT), OR LFC 34 (PASSENGER SEAT PRETENSIONER FAULT). THIS MAY BE CAUSED BY INTERMITTENT PRETENSIONER CONNECTION AT EITHER SEAT BELT BUCKLE. ACTION: INSTALL PRETENSIONER KIT FOR AFFECTED SIDE(S) BY BUILD DATE/COLOR. REFER TO THE FOLLOWING SERVICE INFORMATION FOR DETAILS. SERVICE INFORMATION OBTAIN CORRECT SERVICE KIT AND REFER TO INSTRUCTION SHEET INCLUDED WITH KIT FOR INSTALLATION INSTRUCTIONS. 2002 MODEL YEAR THROUGH 3/3/02 BUILD DATES MEDIUM DARK PARCHMENT 1L2Z-78610E22-AAA 2002/2003 MODEL YEARS 3/4/02 THROUGH 1/17/03 MEDIUM DARK PARCHMENT 1L2Z-78610E22-BAA [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2003 MERCURY MOUNTAINEER RECALLS I HAVE HAD TO CHANGE THE INTAKE MANIFOLD, IGNITION COILS, I'M HAVING A GAS SMELLS NOW, TRANSMISSION THUMPS HARD WHEN GOING INTO FIRST GEAR, SOUNDS LIKE MY REAR END IS ABOUT TO FALL OUT, MY FRONT SEAT IS ELECTRIC AND DOESN'T MOVE, THE O/D LIGHT COMES ON, CHECK ENGINE LIGHT ON, BRAKE LIGHT ON, I KEEP TRYING TO FIX EVERYTHING THE MORE I FIX THE MORE PROBLEMS THAT COME UP, I HAVE CHECK THE RECALL LIST FOR 2003 MERCURY MOUNTAINEER RECALL ON TRANSMISSION AND ALSO CALLED THE FORD CO THEY SAID THERE IS NOTHING. THE PROBLEM IS GETTING WORST AND AFRAID I WILL BE ON THE HIGHWAY WITH MY GRANDCHILDREN WHEN IT BREAKS. I'VE HAD TRANSMISSION LEVEL CHECKED SAID IT WAS FINE. GETTING READY TO DO A COMPLETE TUNE-UP ON IT TO SEE IF THAT WILL HELP WITH THE SMELL OF GAS AND MAKE IT RUN BETTER. IT IDLES HIGH. IT'S WORST WHEN I'M ON THE HIGHWAY.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. WHILE DRIVING APPROXIMATELY 10 TO 15 MPH, THE PASSENGER AND DRIVER SIDE AIR BAGS DEPLOYED WITHOUT WARNING OR IMPACT. THE CONTACT SUSTAINED HEAD INJURIES THAT REQUIRED MEDICAL ATTENTION, BUT THEY COULDN'T AFFORD TO GO. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,610.

1 injured

JUST LIKE EVERY OTHER MOUNTAINEER OR EXPLORER OF THIS ERA THE LIFT GATE HAS CRACKED AROUND THE VEHICLE LOGO. THIS HAS CAUSED PROBLEMS INCLUDING CORROSION, RUST, AND LOCKING MECHANISM FAILURE ON THE LIFTGATE. THIS PROBLEM CAN BE SEEN ON EVERY SINGLE MOUNTAINEER OR EXPLORER OF THIS ERA. IT'S PRETTY RIDICULOUS THAT FORD HAS NOT BEEN FORCED TO REMEDY THE ISSUE OR DONE IT VOLUNTARILY. IT IS CLEARLY AN ENGINEERING FAILURE.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. WHILE THE CONTACT'S VEHICLE WAS APPROACHING A RED LIGHT, ANOTHER VEHICLE CRASHED INTO ITS REAR AT A MODERATE RATE OF SPEED. THE SEAT BACK AND THE HEADREST FRACTURED WITHOUT WARNING. THE CONTACT SUSTAINED EXTENSIVE DAMAGES TO THE NECK AND BACK, WHICH REQUIRED MEDICAL TREATMENT. THE CONTACT INDICATED THAT THE SEAT AND HEADREST WERE NOT STRUCTURALLY SOUND. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY TO A REPAIR SHOP. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Crash 1 injured

FAULTY AIRBAGS: ON NOVEMBER 3, 2015 AT APPROXIMATELY 0540, THE SIDE CURTAIN (BOTH DRIVER SIDE AND PASSENGER SIDE) AIRBAGS EXPLODED IN MY 2003 MERCURY MOUNTAINEER WITHOUT CAUSE WHILE I WAS TRAVELING 55 MPH ON A MAJOR/BUSY STATE HIGHWAY. THE EXPLOSION OF THE AIRBAGS HIT ME ON MY LEFT SIDE CAUSING NECK STRAIN AND TEMPORARY HEARING LOSS TO THE LEFT EAR. I WAS THE ONLY OCCUPANT IN THE VEHICLE. I WAS ABLE TO SAFELY DRIVE TO SHOULDER OF ROAD (I DON'T REMEMBER HOW I GOT THERE), LUCKILY NO CARS WERE AROUND ME AT THE TIME. THE EXPLOSION ALSO CAUSED THE DRIVER SIDE WINDOW TO FALL FROM ITS CASTERS AND WAS UNABLE TO CLOSE WINDOW (AND THE PASSENGER SIDE REAR WINDOW NO LONGER WORKS). THE AIR IN THE CURTAINS WOULD NOT DISSIPATE AND I REMEMBER NOT BEING ABLE TO BREATH WELL. THERE WAS A CHEMICAL IN THE AIR AND DO TO THE CURTAINS, IT WAS DIFFICULT TO GET OUT OF THE CAR. LATER IN THE DAY I TOOK CAR TO REYNOLDS FORD AND WAS TOLD THIS WAS NOT COVERED BY FORD. I ALSO WENT TO MY PCP AND WAS TREATED WITH PREDNISONE AND EAR WASH FOR LEFT EAR HEARING LOSS. LATER, HAD DRIVERS WINDOW REPAIRED.

1 injured

BACK HATCH GLASS EXPLODED WHILE THE VEHICLE WAS STATIONARY (PARKED IN A PARKING LOG), AND THE DRIVER WAS CLOSING THE HATCH. BACK GLASS PORTION OF HATCH WAS BEING MANUALLY CLOSED AT A SLOW-MODERATE RATE, AND GLASS SUDDENLY SHATTERED WITHOUT WARNING. THERE WAS NO IMPACT TO THE GLASS, NOR ANY DISCERNIBLE REASON WHY THE GLASS SHOULD HAVE SUDDENLY SHATTERED. APPROXIMATELY 90% OF THE GLASS ENDED UP IN THE CAR OR ON THE PARKING LOT SURFACE, WITH ONLY ABOUT 10% OF THE GLASS REMAINING ATTACHED TO THE HATCH FRAME AND STRUTS.

1 injured

SEE WHERE SEVERAL PEOPLE ARE EXPERIENCING THE SAME ISSUES THAT I AM HAVING WITH MY 2003 MOUNTAINEER. THE REAR GATE IS CRACKING AROUND THE EMBLEM. I'VE HAVE REPORTED THIS TO FORD AND THEY TELL ME I CAN PAY TO FIX IT AND IF THERE IS RECALL THEY WILL REIMBURSE ME. IN ADDITION I AM ALSO EXPERIENCING THE DOOR AJAR LIGHT COMING ON WHEN ALL ARE SHUT AND SECURE. I HAVE CONTACT FORD AND SEVERAL LOCAL DEALERSHIPS. THE DEALERSHIP ALL TELL ME THEIR HANDS ARE TIED UNTIL FORD MAKES A DECISION AND THAT I AM NOT ALONE. FORD REFUSES TO DO ANYTHING. IT'S ALMOST LIKE THEY DON'T CARE. WITH ALL THESE COMPLAINTS WHY ISN'T THIS AGENCY DOING SOMETHING?

NOT IN AN ACCIDENT. A 1 1/2 INCH VERTICAL CRACK HAS APPEARED IN THE BODY BETWEEN THE MIDDLE OF THE BACK LIFT DOOR UNDER THE WINDOW EXTENDING TO THE ROUND MERCURY SYMBOL BETWEEN THE LETTERS, R AND THE C. DID NOT NOTICE UNTIL TAKING IT THROUGH A CAR WASH WHERE I WAS WARNED IT HAD TO BE COVERED.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS FAULTY. THE FUEL PUMP WAS REPLACED, BUT THE FAILURE CONTINUED. NO FURTHER INFORMATION WAS AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000.

WENT TO PLACE SOMETHING IN THE BACK AND LIFTED THE GATE AND THE LEFT SIDE HINGE CAME OUT AND HAD TO CATCH THE GATE FROM FALLING. GOT MY SON TO HELP TRY TO SECURE IT AND THE STRUT ON THE LEFT SIDE DOESNT WORK SO HAD TO FORCE IT TO CLOSE

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. WHILE DRIVING APPROXIMATELY 25 TO 30 MPH, THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED LACERATIONS TO THE LEFT CHEEK THAT REQUIRED MEDICAL ATTENTION. THE AIR BAG LIGHT REMAINED ILLUMINATED AND FLASHED A CODE THIRTEEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

1 injured

ON MAY 19 2014 WHILE PUTTING A BAG IN THE REAR I NOTICED WHEN LIFTING THE TAIL GATE A CRACK HAD APPEARED AROUND THE MERCURY EMBLEM DOWN TO THE BOTTOM OF THE LIFT GATE. I WENT TO THE LOCAL FORD DEALER AS THERE ARE NO MORE MERCURY DEALERS TO QUESTION THE PROBLEM. THE COLLISION MANAGER TOLD ME THIS IS A COMMON PROBLEM ON THIS MODEL AND FORD HAS NOT DONE A RECALL. I DID NOT REPLACE THE PLASTIC PANEL DUE TO THE COST OF $500.00. IN MY OPINION FORD SHOULD HAVE ISSUED A RECALL. I ALSO NOTICED ON THE INTERNET HOW MANY PEOPLE COMPLAINED INCLUDING THIS WEBSITE. WHY HASN'T NHTSA DONE SOMETHING ABOUT IT?

TL* THE CONTACT OWN A 2003 MERCURY MOUNTAINEER. THE CONTACT STATES THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT BOTH FRONTAL SIDE AIR BAGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

ON THE BALTIMORE-WASHINGTON PARKWAY (295 N ) NORTHBOUND, CHANGED LANES TO THE LEFT AND ACCELERATED. THE GAS PEDDLE WAS PUSHED TO THE FLOOR, STAYED THERE AND WOULD NOT RELEASE. I STOOD ON THE BRAKES, BUT ONLY SOMEWHAT SLOWIED THE ACCELERATION. THE VEHICLE CONTINUED UNTIL WE REACHED ABOUT 80MPH AND COMING CLOSE TO REAR ENDING THE VEHICLE IN FRONT OF ME. I WENT OFF ON THE SHOULDER AND TURNED OFF THE IGNITION KEY TO GET THE VEHICLE STOPPED. THE BRAKE OVERHEATED BRAKES. I COULD NOT SEE A PROBLEM. THIS WAS NOT CAUSED BY A FLOOR MAT. THE PEDAL WAS STUCK TO THE FLOOR. I WIGGLED AND PULLED AND IT COME BACK UP WITH A POP. IN DAYLIGHT THE NEXT DAY, I INSPECTED THE PEDAL AND PUSHED IT DOWN. IT AGAIN WENT TO THE FLOOR AND STAYED THERE. I SLID UNDER THE DASH AND FOUND THAT THE HORIZONTAL PIN THAT HOLDS THE PEDAL TO THE FLOOR BRACKET HAD BACKED OUT SIDEWAYS FROM RIGHT TO LEFT, ALLOWING THE PEDAL TO GO SOMEWHAT SIDEWAYS AND THE MOTOR FOR THE ADJUSTABLE PEDAL ASSEMBLY HAD CAUGHT ON A METAL BRACKET KEEPING THE PEDAL FROM RETURNING TO THE UP POSITION. I REMOVED THE PEDAL ASSEMBLY AND INSPECTED THE PROBLEM. THIS IS POOR ENGINEERING AND THERE SHOULD BE A RECALL.. THERE ARE NO CLIPS OR PINS TO HOLD THE PEDAL PIN IN PLACE ! ! ! THE ASSEMBLY RELIES ON SLIGHT INTERFERENCE BETWEEN SPLINES ON THE PIN AND SPLINES INSIDE WHERE IT GOES THROUGH THE PEDAL. WHAT HAPPENED WAS, THAT OVER A PERIOD OF TIME, FROM THE PEDAL WIGGLING, THE PIN BACKED OUT.FROM USE, ON ITS OWN. AGAIN, THIS NOT SUFFICIENT TO KEEP THE PEDAL ASSEMBLED. IT NEED CLIPS ON BOTH ENDS OR COTTER PINS ON BOTH ENDS OF THE PIN ASSEMBLY. A CONCERN IS THE USE OF PLASTIC BRACKET TO MOUNT THE PEDAL TO THE FLOOR. IN MY PAST EXPERIENCE, THE MOUNTING BRACKETS HAD BEEN MADE OF METAL. PLASTIC FATIGUES FASTER THAN METAL AND IS PRONE TO CRACKING AND BREAKING. *TR

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFTGATE BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE TECHNICIAN STATED THAT THE LIFTGATE AND WINDOW NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,500.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED WHILE TRAVELING ON A MAJOR HIGHWAY, THE ACCELERATOR PEDAL BECAME STUCK. THE CONTACT STATED THAT THE BRAKE PEDAL HAD TO BE ENGAGED AND THE ACCELERATOR PEDAL HAD TO BE DEPRESS SEVERAL TIMES IN ORDER TO RELEASE IT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE FIBERGLASS ON THE TAILGATE CRACKED AND DETACHED FROM THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

I PURCHASED A 2003 MERCURY MOUNTAINEER ON 2/15/14 AND I TOOK IT ON A ROAD TRIP ON 2/16/4 WITH MY GRANDKIDS. AFTER ENTERING THE HIGHWAY AND GAINING SPEED I STARTED TO SMELL A STRONG BURNT RUBBER AND EXHAUST SMELL. THE SMELL WAS VERY TOXIC AND STUCK TO OUR CLOTHING. ON 2/18/14, I TOOK IT TO THE DEALER FOR HIS MECHANIC TO TAKE A LOOK AT IT. THE MECHANIC SAID THERE WAS SOME DEGREASER THAT OVERFLOWED FROM A CUPLER AND LEAKED ONTO THE EXHAUST. I ASKED IF THERE WAS A LEAK AND THE MECHANIC RESPONDED BY SAYING NOT REALLY, WHICH MEANT THERE WAS A LEAK. THE MECHANIC ASSURED ME THAT THE PROBLEM WAS TAKEN CARE OF, BUT IF IT STILL OCCURS, THEY WOULD SEND IT IN FOR TWO DAYS. I CONTINUED TO SMELL THE TOXIC SMELL AND ON 2/19/14 THE HATCH ON LIFT GATE JUST CRACKED. ALSO WHEN I TURN AT A LOW SPEED, I HEAR A STRANGE SOUND AND VIBRATION, COMING FROM THE TIRE AREA. I'VE HEARD OF NUMEROUS ISSUES AND COMPLICATIONS WITH THE MERCURY MOUNTAINEERS. I DON'T WANT MY GRANDCHILDREN NOR MY LIFE PUT IN DANGER. A DRIVER SHOULD BE ENSURED WITH SAFETY WHEN DRIVING A VEHICLE. FORD DOESN'T CARE ABOUT THEIR CONSUMERS TO SELL DEFECTIVE AND NONSAFE VEHICLES. PLEASE RECALL THIS VEHICLE AS IT HAS TOO MANY ISSUES THAT CAN BE LIFE THREATENING, LIKE THE ROLLOVER RATE. *TR

I'VE BEEN REVIEW THIS SITE AND SEE WHERE SEVERAL PEOPLE ARE EXPERIENCING THE SAME ISSUES THAT I AM HAVING WITH MY 2003 MOUNTAINEER. THE REAR GATE IS CRACKING AROUND THE EMBLEM. I'VE HAVE REPORTED THIS TO FORD AND THEY TELL ME I CAN PAY TO FIX IT AND IF THERE IS RECALL THEY WILL REIMBURSE ME. IN ADDITION I AM ALSO EXPERIENCING THE DOOR AJAR LIGHT COMING ON WHEN ALL ARE SHUT AND SECURE. I HAVE CONTACT FORD AND SEVERAL LOCAL DEALERSHIPS. THE DEALERSHIP ALL TELL ME THEIR HANDS ARE TIED UNTIL FORD MAKES A DECISION AND THAT I AM NOT ALONE. FORD REFUSES TO DO ANYTHING. IT'S ALMOST LIKE THEY DON'T CARE. WITH ALL THESE COMPLAINTS WHY ISN'T THIS AGENCY DOING SOMETHING? *TR

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED WHEN ATTEMPTING TO THE CLOSE THE REAR LIFTGATE, THE RIGHT SIDE SUPPORT HINGE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 9/4/13 *CN THE CONSUMER STATED WHEN HE RAISED THE LIFTGATE, IT CAME DOWN AND THE EMBLEM CRACKED. THE RIGHT HINGE BROKE AND THE RIGHT ROD FROZE.

TL* THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE REAR DIFFERENTIAL MADE A POPPING SOUND. THE CONTACT STATED THAT WHILE IN REVERSE, THE POPPING SOUND WAS LOUDER. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC NOTICED A LEAK IN THE REAR DIFFERENTIAL AND STATED THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE REAR DIFFERENTIAL REPLACED. THE FAILURE MILEAGE WAS 240,000.

I WANT FORD TO RECALL THERE MERCURY MOUNTAINEER AS IT HAS A MAJOR SAFETY ISSUE. ALL OF THERE MERCURY FROM 2002 ONWARD HAVE A CRACK ON THERE REAR LIFT GATE. I DONE GOOGLE AND ALMOST NET IS FULL OF COMPLAINTS ON THIS. *TR CRACK STARTS RIGHT BELOW MERCURY LOGO AND KEEP INCREASING AND INCREASING. MY CAR LOGO NOT CAME OFF, BUT FEW CARS, THIS LOGO BLOWN OFF. ALSO NOW I LEARNT THAT CAR HINGES HOLDING THIS VERY REAR HOOD CAME OFF.. I THOUGHT ITS MINE, BUT AGAIN, ALMOST WEB IS FULL OF COMPLAINTS ON THIS AND KNOWING HOW RISKY THIS IS, TRYING BEST TO GO TO EVERY LOOK AND CORNER SO TO ENSURE THAT FORD DOES REPAIR ASAP

THE HASN'T BEEN AN ACCIDENT. I WANTED TO REPORT THAT I HAVE A CRACKED TAILGATE ON MY VEHICLE. THE CRACK APPEARED ONE MORNING - I WASN'T EVEN DRIVING THE VEHICLE. THE CRACKED BEGINS AT THE TOP OF THE TAILGATE, AROUND THE EMBLEM PART OF THE LIFT GATE, THEN DOWN TOWARDS THE TAILGATE LIFT HANDLE. I CALLED MY LOCAL FORD DEALER, CITRUS FORD, ONTARIO, CA, BUT WAS INFORMED THERE WASN'T A RECALL AND THE ISSUE HAD TO DEAL WITH WATER LEAKING INTO THE LOCKING MECHANISM AND CRACKING BECAUSE ITS PLASTIC AND NOT METAL. AT LEAST THE DEALERSHIP DIDN'T ACCUSE ME OF BEING IN AN ACCIDENT, BUT NO EFFORTS WERE MADE TO REPAIR THE CRACKED TAILGATE AT NO COST TO ME, THE CUSTOMER. CAN NHTSA PUSH FORD TO RECALL THIS MATTER? *TR

BACK HINGES BROKE ALLOWING THE GLASS TO FALL. *TR

THE BACK LIFT GATE IS CRACKED FROM THE BOTTOM OF THE WINDOW, AROUND THE SIDE OF THE MERCURY EMBLEM, ALL THE WAY DOWN. I'VE NOTICED THE SAME CRACKING ON ALMOST EVERY OTHER MOUNTAINEER ON THE ROADS, AND I SEE A HUGE NUMBER OF THE SAME COMPLAINT ON THE NHTSA WEBSITE. OBVIOUSLY THIS IS A DEFECT AND NEEDS TO BE RECALLED. *TR

WHEN LIFTING UP REAR WINDOW SECTION (TOP HALF OF REAR DOOR) THE HINGES BROKE CAUSING THE WINDOW AND IT'S FRAME TO FALL DOWN. WINDOW FRAME WAS BARELY HANGING BY PISTON SUPPORTS. *TR

FORD HAS A TSB ON THEIR WEBSITE FOR THE PROBLEMS I AM HAVING WITH MY VEHICLE. I CONTACTED TYEM AND I WAS TOLD THAT I HAVE TO PAY FOR THE REPAIRS. WHAT I DO NOT UNDERSTAND IS IF THERE ARE SOOO MANY COMPLAINT FROM CONSUMERS ON THIS VEHICLE FOR THE SAME ISSUES IS THAT NOT THE RESPONSIBILITY OF THE MANUFACTURE BEING IT CONSIDERED A DEFECTIVE PRODUCT? I HAVE TO CHILDREN AND THIS IS OF EXTREME CONCERN TO ME THAT THESE ISSUES ON MY CAR CAN CAUSE AN ACCIDENT. -BACK TRUNK DOOR IS CRACKED DOWN THE LATCH. -THE CAR DOESN'T SHIFT CORRECTLY AND TIRES SEEM LOOSE -THE OVERDRIVE LIGHT IS BLINKING ALL THE TIME AND THE TRANSMISSION IS SIGNALING.. I HAVE FOUND SO MANY WEBSITES WITH COMPLAINTS ABOUT THE SAME ISSUES ON 2003-2004 MERCURY MOUNTAINEERS. *TR

THE GEAR SHIFT GETS STUCK IN PARK AND I HAVE TO PULL DOWN ON IT REALLY HARD TO GET IT IN DRIVE OR REVERSE I'M AFRAID THAT ITS GOING TO BREAK ONE DAY. *TR