2022 HYUNDAI SANTA FE

5 recalls, 310 complaints - 97 TSBs - 5/5 safety rating

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirem... Read more

Consequence

A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.

Remedy

Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.

226,118 vehicles affected

Manufacturer: Hyundai Motor America

TRAILER HITCHES

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water acc... Read more

Consequence

A fire while parked or driving can increase the risk of injury.

Remedy

Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service ... Read more

584,784 vehicles affected

Manufacturer: Hyundai Motor America

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete l... Read more

Consequence

Loss of drive power increases the risk of a crash.

Remedy

Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. ... Read more

56,148 vehicles affected

Manufacturer: Hyundai Motor America

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.

Consequence

An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy

Dealers will replace the turbocharger oil supply pipe, free of charge. Owner notification letters were mailed May 26, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall 222.

16 vehicles affected

Manufacturer: Hyundai Motor America

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.

Consequence

A fuel leak increases the risk of a fire.

Remedy

Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.

15,752 vehicles affected

Manufacturer: Hyundai Motor America

Complaint Statistics

310 total complaints 14 crashes 4 fires 15 injuries

Top Reported Components

Component	Complaints
ENGINE	53
POWER TRAIN	44
ELECTRICAL SYSTEM	34
UNKNOWN OR OTHER	24
FUEL/PROPULSION SYSTEM	19
SERVICE BRAKES	14
VEHICLE SPEED CONTROL	11
AIR BAGS	8
EXTERIOR LIGHTING	8
STEERING	7

Incident date: Sep 3, 2026

Vehicle on initial start up shows no issue. Driving for a short distance or stationary for a short time. Vehicle instrument panel will show a fault of Forward safety system. Errors on Lane keeping assist, High beam assist, and Driver attention warning. Smart camera module will be hot to the touch ca... Read more

Incident date: Sep 3, 2026

Incident date: Jun 20, 2026

On June 20 2026 at 2:07pm Central Time there was a check engine light displayed on the dash of my vehicle 2022 Hyundai Santa Fe Calligraphy, while it was parked in the garage of my home and was just powered up. I had then performed the vehicle diagnostics test (pictures attached) that showed that th... Read more

Incident date: Jun 20, 2026

Incident date: Aug 24, 2026

At approximately 67,000 miles, the vehicle experienced a sudden vibration when accelerate and decelerate. Engine light was on and vehicle had a hard time to maintain speed above 40mph. Cars were honking behind us due to the lack of speed on road. It happen all of a sudden and cause me and my wife pa... Read more

Incident date: Aug 22, 2026

Symptoms are those described in Hyundai recall 236 (delayed shifting,hesitation, stalling). Vehicle has had multiple TSP services at Hyundai but symptoms persist intermittently. Software updates do not fix issue. Hyundai dealer has no other remedies.

Incident date: Aug 22, 2026

Incident date: Mar 1, 2023

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle jerked or hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that after two separate warranty repairs of the fuel injector, the fai... Read more

Incident date: Mar 1, 2023

Incident date: Nov 30, 2023

While accelerating, the 8-speed transmission sporadically hangs in 1st gear and will not change to 2nd. The motor revs to about 4000 rpm and will only travel at about 15 mph. This causes a safety hazard when attempting to enter fast moving traffic. After several attempts, the Dealer has said that... Read more

Incident date: Aug 10, 2026

The steering wheel has developed resistance to turning left and right. It is most noticeable when driving on highways where small steering inputs are needed to keep the vehicle within a lane. The steering wheel with stick in place requiring more effort than normal to turn in either direction. When t... Read more

Incident date: Jul 6, 2026

Front passenger interior door handle is a fragile component. Mine failed with little to no force where the cable disconnects from the handle. It has rendered the ability to exit the vehicle via the handle impossible, and Passenger must roll down window and reach for the exterior handle to exit. I... Read more

Incident date: Jun 25, 2026

Odometer Fraud. The contact purchased a 2014 Nissan Murano. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase, the mileage was 7,071; however, after the purchase, it was discovered via the national motor vehicle title information syste... Read more

Incident date: Apr 27, 2026

When i was driving, going about 45 MPH, the emergency braking system beeped and breaks were engaged. Not to a complete stop but like a "break tap". Nothing was in front of beside our behind me. It was terrifying and I'm unsure why this happened. Please be advised, this can cause an accident.

Incident date: Apr 27, 2026

I am filing this safety complaint regarding my 2021 Jeep Wrangler Unlimited Sahara Altitude. The vehicle is experiencing a fuel gauge/fuel reading malfunction. The gauge does not accurately reflect the amount of fuel in the vehicle, which creates a serious safety concern because the vehicle may run ... Read more

Incident date: Jun 30, 2026

While driving my 2022 Subaru Forester, the factory EyeSight autonomous safety system completely failed and disabled itself permanently. The total system shutdown caused an immediate loss of Pre-Collision Emergency Braking, Lane Change Detection, and Adaptive Cruise Control, creating an active highwa... Read more

Incident date: Nov 20, 2025

Traveling had an engine light come on. stopped at a dealer they inspected found multiple errors reset engine light and said continue home. when home bring into my dealer. Got home that night went to start truck, all kinds of errors started popping up on the dash, vehicle would not turn over at al... Read more

Incident date: Jun 27, 2026

I have a 2023 Hyundai Ioniq 5 Limited and had the ICCU "popped" (failed) which took about two weeks to replace. This time we were lucky that in happened at our home but had we been driving the car would it would have completed died. We regularly drive from from [XXX] to [XXX] were there are large se... Read more

Incident date: Jun 26, 2023

The contact owns a 2026 Chevrolet Silverado 1500. The contact stated that while driving 25 MPH and attempting to depress the accelerator pedal, the vehicle lost motive power, the contact attempted to start the vehicle, and the vehicle operated as intended. The check engine warning light was illumina... Read more

Incident date: May 22, 2026

This is a very common issue with the car and everytime I touch the steering wheel it says “travel assist not available”. But when it notify that message it makes a very loud noise. It is very distracting because everytime I move my hands or grab the wheel it will keep making the loud noise makin... Read more

Incident date: Jun 9, 2026

Drivers seat belt won’t lock and back up cam intermittently does not activate when shifted into reverse mode.

Incident date: May 22, 2026

Incident date: May 23, 2026

The Cruise control pacing/follow option does not slow down/break and will rear end/strike any vehicle. The auto breaking does not work. The touch screen constantly cycles randomly changing map directions, radio stations, heat and air conditioning, seat heating and cooling. Puts driver at risk due to... Read more

Incident date: May 23, 2026

Incident date: Apr 17, 2026

tried to get ford to install Heated Steering Wheel Performance Upgrade 22G06 on this and they claim the case was closed and denied because of the credit on my window sticker they closed my case ID without even notifying me about it. (Ford CASE ID for heated steering module. XXX). INFORMATION REDACT... Read more

Incident date: Apr 17, 2026

The reason for the recall on this make and model is what I'm experiencing now. The whole car will shutdown power while driving with no warnings. In traffic the car will just roll to a stop with cars closely behind me. I bought the call September 2016 yet I just saw a recall when I signed up for trip... Read more

Incident date: Apr 17, 2026

Incident date: May 21, 2026

I own a 2024 Jeep Wrangler 4XE High Altitude (VIN: [XXX]) with three open safety recalls, two of which involve fire hazards: NHTSA ID 25V741000 – High Voltage Battery May Fail and Cause Fire (parts available) NHTSA ID 25V766000 – Engine Failure May Cause Fire or Loss of Drive Power (parts not a... Read more

Incident date: Mar 31, 2026

Automatic CVT failure confirmed by Future Nissan of Roseville CA. No warning prior to failure. Replaced by Kirkwood Autoworx Mechanical since Nissan Corporate denied a good-will replacement. Reason: 15k miles over warranty - 75081odometer reading at replacement on 5/27/26. CVT failed while on a bu... Read more

Incident date: May 26, 2026

Before I begin my commute, I’m greeted by a persistent message within the center infotainment display from the satellite radio service provider SirusXM. The message will not go away until manually closed out, as the exit button is farther away from the drivers reach (more accessible from the passe... Read more

Incident date: Mar 31, 2026

Incident date: May 26, 2026

Hyundai - DAW - Driver Attention Warning / Forward Attention Warning System This issue warrants immediate consideration for a recall. Despite wearing glasses, sunglasses, or no glasses, the problem persists. I occasional do remove my glasses while driving, and the warning continues to sound. This oc... Read more

Incident date: May 25, 2026

2023 Volkswagen ID.4 (VIN [XXX] ), purchased new [XXX]; now ~20,000 miles. Since the first months of ownership it has had recurring, intermittent electrical/software/capacitive-control and safety failures: the center infotainment screen and instrument cluster go blank while driving (loss of speedome... Read more

Incident date: May 20, 2022

The manufacturer STILL to this date does not have the parts to repair the recall C4B. What recourse do I have?

Incident date: May 20, 2022

The instrument cluster gauges start giving in accurate information and the whole dash start turning on and off. I found hundreds of people posting complaints about this issue with the 2018 mercedes cla 250 but mercedes refuses to acknowledge this issue and put out a recall probably out of greed and ... Read more

Incident date: May 20, 2022

Incident date: Dec 1, 2025

The vehicle experienced a failure involving the automatic transmission gear shift cable (recall AOC 2013–2016). The gear selector indicated the vehicle was in “Park,” but the transmission was not fully engaged in Park due to the defective shift cable/bushing. This created a significant safety... Read more

Incident date: Dec 1, 2025

At 170,000 miles, the 2019 Toyota Hybrid Camry LE has developed a consistent drive train lurch/stumble/shake around 20, 40 and 60 MPH, which is increasing in intensity and occurrence. This defect is quite startling and occurs regardless of efficiency, HVAC, cruise control, etc. settings. Examined tw... Read more

Incident date: Apr 13, 2026

I am reporting a safety concern related to NHTSA Recall 19V120 involving my Kia Soul. The recall identifies a defect related to catalytic converter overheating, which can lead to engine damage, stalling, and increased risk of fire. My vehicle is currently experiencing an illuminated check engine li... Read more

Incident date: Apr 13, 2026

The car's phone connectivity is always an issue. The car locks when the phone is right next to it, for example, if you put kids or groceries in the back seat then it locks before you get to the front door. This is very annoying, but what makes it a safety issue is that when the door locks, the kids ... Read more

Incident date: Apr 13, 2026

Incident date: Apr 6, 2026

The contact owns a 2016 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle started shaking, the engine made a clunking sound, and the transmission unexpectedly downshifted. The power training warning light was illuminated. The vehicle was taken to an independent ... Read more

Incident date: Apr 6, 2026

On multiple occasions our vehicle has turned off at a stop (auto start/stop) and failed to restart upon pressing the accelerator. It then takes several seconds to be able to restart and get moving.

Incident date: Apr 16, 2026

In 2024, 2025, and 2026, I have had 2 incidents in each year where the cruise control is set to 60 to 65 mph and the cruise control then accelerates the car past 100 mph. When this occurs, tapping the break does NOT disengage the cruise control. All 6 times I have had to slam the breaks to a full ... Read more

Incident date: Apr 10, 2026

Tire sidewalk had a bubble in it after 6 months of use and normal wear and tear. Pirella extra load radial tubeless R85133 255/45 R20 105v M+S

Incident date: Mar 1, 2026

While driving under normal conditions, without any prior impact, collision, or road hazard, the control arm on my vehicle suddenly detached. This occurred during active driving and caused an immediate loss of vehicle stability and control. The failure happened without warning and posed a serious sa... Read more

Incident date: Mar 1, 2026

Showing 50 of 310 complaints.

NHTSA Safety Ratings, 2022 HYUNDAI SANTA FE

2022 Hyundai Santa Fe SUV AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	14.7%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2022 HYUNDAI SANTA FE

97 manufacturer communications from 49 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
100000 POWER TRAIN	22
110000 ELECTRICAL SYSTEM	20
060000 ENGINE AND ENGINE COOLING	15
116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE	4
116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR	4
130000 VISIBILITY	3
350000 EQUIPMENT	3
050000 PARKING BRAKE	3

100000 POWER TRAIN

This bulletin provides the procedure for updating the automatic transmission TCU and ECU software (Santa Fe ONLY) to improve shift quality, judder with ISG enabled and hesitation when accelerating.

130000 VISIBILITY/WIPER (PWS)

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

110000 ELECTRICAL SYSTEM

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

100000 POWER TRAIN

This TSB provides information to diagnose the push button shifter operation.

030000 SERVICE BRAKES, HYDRAULIC

Certain Tucson (NX4A), Santa Cruz (NXT), Santa Fe (TMA), and Santa Fe Hybrid (TMA HEV) vehicles may exhibit a brake judder condition. This bulletin describes the procedure to inspect the brakes, resurface or replace and perform a brake burn

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

100000 POWER TRAIN

If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. a?? DIAGNOSTIC TROUBLE CODES: a??

100000 POWER TRAIN

The Shift-By-Wire (SBW) buttons have been made available as separate service parts for the SBW lever. If replacement of the SBW button is required due to one or more button plating peeling, replace the button(s) with a new one. Do not repla

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

This bulletin provides information related to a Transmission Control Unit (TCU) software update for certain vehicles equipped with an 8-speed wet dual clutch transmissions (8WDCT) that improves the touch point learning variation. Certain 8W

100000 POWER TRAIN

This bulletin outlines changes to the service procedure regarding the replacement of 8-speed wet dual clutch transmissions (8WDCT) and associated transmission control unit (TCU). These changes only apply to vehicles equipped with Theta 2.5T

100000 POWER TRAIN

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

This TSB provides information to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms listed below or DTCs (listed on Page 2) , follow the Service Procedure on Page 3. SYMPTOMS: a?? a??Shifter System

100000 POWER TRAIN

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

If you are servicing an 8-speed DCT front-wheel-drive vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. a?? DIAGNOSTIC TROUBLE CODES: a?? P070500 - Transmission range sensor circuit m

103300 POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

100000 POWER TRAIN

114900 ELECTRICAL SYSTEM:WIRING:POSITION/LIMIT SENSOR/SWITCH

110000 ELECTRICAL SYSTEM

This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundaia??s Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous vers

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

060000 ENGINE AND ENGINE COOLING

This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain 21-23MY Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to i

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

060000 ENGINE AND ENGINE COOLING

This bulletin provides the procedure to update the ECU and TCU software to correct the ROM ID and TCU software to optimize shift quality when accelerating.

100000 POWER TRAIN

This bulletin provides the procedure to update the ECU and TCU software to correct the ROM ID and TCU software to optimize shift quality when accelerating.

050000 PARKING BRAKE

Some Elantra (CN7A), Sonata (DN8A) and Santa Fe (TMA) vehicles may exhibit the Electronic Parking Brake (EPB) warning light on due to brake fluid entering the HECU electrical connector. DTC C1501 (EPB Switch Failure) may be present, but EPB

050000 PARKING BRAKE

Certain Hyundai Elantra, Sonata, and Santa Fe vehicles may exhibit the Electronic Parking Brake (EPB) warning light on due to brake fluid entering the HECU (Hydraulic Electronic Control Unit) electrical connector. DTC C1501 (EPB Switch Fail

100000 POWER TRAIN

This bulletin provides the procedure to update the ECU and TCU software to correct the ROM ID and TCU software to optimize shift quality when accelerating.

060000 ENGINE AND ENGINE COOLING

Certain 2022MY Santa Fe (TMa) 2.5L vehicles equipped with an 8-speed transmission will require an update to the ECU and TCU software to correct the ROM IDs and TCU software to optimize shift quality when accelerating.

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

This bulletin provides the procedure to update the ECU and TCU software to correct the ROM ID and TCU software to optimize shift quality when accelerating.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

This bulletin provides service procedures to prevent possible moisture intrusion of the HP EOP (High Flow Electric Oil Pump) connector when servicing the 8-speed wet dual clutch transmission (8WDCT). If moisture enters the HF EOP connector,

100000 POWER TRAIN

This TSB applies only if Recall 236 or Service Campaign T8N has been performed and the 8 speed wet dual clutch transmission (8WDCT) replacement is necessary related due to high pressure electric oil pump (HP EOP) DTCa??s P1C2D03 (HP EOP Mot

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

050000 PARKING BRAKE

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain MY21-23 Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to i

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This bulletin describes the procedure to diagnose and repair tire pressure monitoring system (TPMS) DTC(s) on some 19MY and newer Santa Fe (TMA), 2021MY and newer Santa Fe Hybrid (TM HEV), 2022MY and newer Santa Fe Plug-In Hybrid (TM PHEV

200000 WHEELS

100000 POWER TRAIN

This bulletin outlines changes to the service manual regarding the replacement of 8-speed dual clutch transmissions (DCT) and associated transmission control module (TCM). Additional steps, not in the service manual, are required within GDS

060000 ENGINE AND ENGINE COOLING

This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-22MY Sonata, Santa Fe, and certain 22MY Santa Cruz, and Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to internally leaking GD

100000 POWER TRAIN

This bulletin provides the procedure to update ECU and TCU of a vehicle experiencing any of the following DTC: P013E - O2 Sensor Delayed Response - Rich to Lean Bank 1 Sensor 2 P0456 - Evaporative System

060000 ENGINE AND ENGINE COOLING

100000 POWER TRAIN

This bulletin provides the procedure to update the TCU software to improve drivability and shift quality.

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

100000 POWER TRAIN

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed on Page 2, follow the repair procedure and perform the diagnosis. If necessary, replace the High Flow electric oil pump (HF

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

100000 POWER TRAIN

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness.

110000 ELECTRICAL SYSTEM

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

110000 ELECTRICAL SYSTEM

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

346000 COMMUNICATION:MANUFACTURER TELEMATICS

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

350000 EQUIPMENT

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

350000 EQUIPMENT

This bulletin describes the procedure to update wireless CarPlay to alleviate frequent disconnection of wireless CarPlay caused by other wireless noise from unknown sources which could make wireless communication unstable between D-Audio an

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

Certain 2020-22MY Sonata (DN8a) and 2021-22MY Santa Fe (TMa) vehicles equipped with 2.5L engine may exhibit a MIL with DTC(s): a?? P2074: Mass Airflow Sensor Plausibility a?? P2074F0: Manifold Absolute Pressure/Mass Air Flow - Throttle Po

353000 EQUIPMENT:ELECTRICAL

100000 POWER TRAIN

This TSB provides a procedure to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms or DTC listed below, follow the Service Procedure, Page 2.

350000 EQUIPMENT

Certain 2022MY Santa Fe (TMa) vehicles may exhibit an intermittent shift bump and slight hesitation during low-speed acceleration. This bulletin provides the procedure to update the ECU and TCU software with revised logic to resolve these c

060000 ENGINE AND ENGINE COOLING

103110 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

118000 ELECTRICAL SYSTEM:SOFTWARE

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Certain vehicles listed below equipped with 2.5T turbo engines may have a misassembled check valve for the PCV (Positive Crankcase Ventilation) system, resulting in engine oil entering the intake and contaminating the air cleaner. This bull

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Certain 2020-22MY Sonata (DN8a), 2021-22MY Santa Fe (TMa), and 2022MY Tucson (NX4/NX4a) vehicles equipped with 2.5L engine may exhibit a MIL with DTC(s): a?? P2074: Mass Airflow Sensor Plausibility a?? P2074F0: Manifold Absolute Pressure/

130000 VISIBILITY

This bulletin describes the procedure to inspect, and if necessary, replace the sun visor retainer for certain 2021 a?? 2022MY Santa Fe (TMa) vehicles with Calligraphy trim and Obsidian Black interior (color code: NNB).

100000 POWER TRAIN

This TSB provides a procedure to diagnose the push button shifter operation.

NHTSA Safety Investigations, HYUNDAI SANTA FE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2017

3.3L Engine Loss of Motive Power (LOMP)

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegat... Read more

PE, Closed , Model Year: 2011

Non-crash Vehicle Fires

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai S... Read more

DP, Closed , Model Year: 2011

Non-crash Vehicle Fires

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehi... Read more

RQ, Closed , Model Year: 2012

Scope and Timeliness

NHTSA opened Recall Query (RQ) 17-004 to investigate the timeliness and scope of Hyundai?s Theta II GDI engine recalls (Recall Nos. 15V-568 and 17V-226), and Hyundai?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Hyundai to administrative... ly resolve NHTSA?s assertions of violations of law in connection with RQ17-004. NHTSA?s assertions included that Hyundai may be liable for civil penalties on multiple grounds, including the untimeliness of Recall Nos. 15V-568 and 17V-226, inaccuracies in Hyundai?s recall reports, and that a required report describing potential safety-related issues contained certain inaccuracies or omissions.Under the Consent Order, Hyundai agreed to a total civil penalty of $140,000,000. The total civil penalty included payment of $54,000,000 as a Non-Deferred Amount. Hyundai also agreed to a sum of $46,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Additionally, Hyundai agreed to a $40,000,000 Performance Obligation Amount to be expended by Hyundai to fulfill specified Safety Data Analytics Infrastructure obligations and Test and Inspection Laboratory obligations. The Consent Order also includes other terms designed to enhance Hyundai?s safety practices, and requires Hyundai to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-004, the Consent Order is not intended to affect any other current or future investigation which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-003) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Hyundai from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with law, and to initiate a recall upon any future determination by Hyundai, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Hyundai's ongoing performance obligations, and does not represent a determination by the agency as to Hyundai?s performance under the Consent Order to date.Read more

PE, Closed , Model Year: 2013

Front Axle Shaft Failure

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai-Kia) submitted two Defect Information Reports (DIR) to NHTSA identifying a safety defect related to fracture of the right front axle shaft in MY 2013 front wheel drive Hyundai Santa Fe Sport vehicles built from Jul... Read more

PE, Closed , Model Year: 2011

Steering Shaft Universal Joint Failure

The Office of Defects Investigation (ODI) opened PE12-029 based on one complaint alleging that a fastener became loose in the steering shaft of a model year (MY) 2011 Hyundai Santa Fe vehicle and related Early Warning Reporting field report data.In it's response to ODI's information request letter f... Read more

PE, Closed , Model Year: 2010

Transmission Intermediate Driveshaft

On April 25, 2011, Kia Motors Corporation submitted a defect notification letter to NHTSA regarding a transmission intermediate driveshaft condition in approximately 12,690 model year (MY) 2011 Kia Sorento 2-wheel drive vehicles equipped with automatic transmissions and 2.4L engines (NHTSA Recall No... Read more

EA, Closed , Model Year: 2001

REAR TRAILING ARM CORROSION FAILURE

IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN TH... Read more

PE, Closed , Model Year: 2001

REAR SUSPENSION TRAILING ARM FAILURE

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) DURING THIS PRELIMINARY EVALUATION, HYUNDAI PROVIDED ODI WITH 15 ALLEGATIONS OF CORROSION FAILURE OF THE LEFT- AND/OR RIGHT-REAR SUSPENSION TRAILING ARM.THREE OF THE 15 CONSUMERS ALLEGED A LOSS OF VEHICLE ... Read more

PE, Closed , Model Year: 2001

ENGINE SEIZURE

There is no summary currently available

HYUNDAI SANTA FE - All Years Overview

Complete safety history for the HYUNDAI SANTA FE across all model years (2001, 2026).

96 Total Recalls

10,465 Total Complaints

10 Investigations

576 Reported Crashes

254 Reported Fires

17 Reported Deaths

HYUNDAI SANTA FE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	4	52	View
2025	5	194	View
2024	7	214	View
2023	1	323	View
2022 (current)	5	310
2021	7	242	View
2020	2	295	View
2019	2	282	View
2018	2	143	View
2017	6	1,281	View
2016	3	291	View
2015	2	332	View
2014	3	679	View
2013	3	807	View
2012	1	475	View
2011	3	268	View
2010	3	333	View
2009	3	507	View
2008	6	718	View
2007	9	982	View
2006	1	143	View
2005	3	300	View
2004	3	386	View
2003	4	390	View
2002	4	219	View
2001	4	293	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2022 HYUNDAI SANTA FE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2022 HYUNDAI SANTA FE

Safety Technology

Technical Service Bulletins, 2022 HYUNDAI SANTA FE

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SANTA FE

HYUNDAI SANTA FE - All Years Overview

HYUNDAI SANTA FE - Year by Year

Other HYUNDAI Models