2014 HYUNDAI SANTA FE Recalls, Complaints & Safety

My engine failed and was diagnosed as needing to rebuilt or replaced by the dealership. During the pandemic it was hard to get parts so they rebuilt it. At first it was missed diagnosed because it was a 3.3l V6 and only the 4 cylinder engines were on recall. I had check engine lights on all the time. I paid for repairs that only masked the problem for a short time. It was such a problem I had to get a waiver to register my vehicle. After having more problems with my engine. Hyundai of Kennesaw confirmed my engine needed to be replaced they actually requested Corporate to approve an engine replacement for my vehicle in 2021. It was denied. So I paid for the rebuild. In August of 2025 i sent a letter extending the warranty which covered my vehicle engine rebuild. Hyundai denied that claim Jan 2026.

The engine has been running rough for awhile and emissions light came on. My car was having problems accelerating, 2 years ago the light came on but didn’t stay on so the dealer couldn’t diagnose problem.

My daughter owns a 2014 Hyundai Santa Fe GLS, which is currently experiencing internal engine failure and abnormal engine noise. These issues directly align with Hyundai’s notification regarding the extended warranty coverage for vehicles equipped with the 3.3L Lambda II GDI engine, which may experience abnormal engine noise or damage. Hyundai has acknowledged these concerns and extended warranty protection for engine repairs or replacement. The Hyundai Holler dealership in winter park Florida. recently inspected the vehicle and reported a critical failure requiring immediate attention. The recommended service included: Timing job (all CVVTs, intake, camshaft, chains, guides, tensioners) Both valve cover gaskets and RTV replacement ( This is the internal parts of the engine) The estimated repair cost was $6,723.92. This recommendation reflects the exact type of engine-related failure covered under Hyundai’s extended warranty for this VIN. It is both unreasonable and disappointing that my daughter was presented with such a significant repair estimate for a condition Hyundai has already committed to covering. For context, my husband is a certified technician, and we have carefully reviewed the inspection details. The diagnosis provided by Holler Hyundais service department is consistent with the warranty-covered issue. Therefore, this repair should rightfully be processed under Hyundai’s extended warranty program.I must also share that my daughter a single disabled mother of three with limited resources and income. The dealership’s approach in presenting her with an astronomical repair bill—without recognizing the warranty coverage—causes unnecessary stress and financial hardship Mr Jesse Cappiello Service consultant. Refuses to accept this as warranty, by stating the warranty is only for Rod bearing failure. When the warranty clearly states engine failure I have attached the warranty info for your review.

Bien,mi auto tuvo varios problemas al mismo tiempo: 1-falla en todo el sistema eléctrico,aire acondicionado,control de tráfico ambas partes, Power steering,ABS,Pérdida de potencia en el motor,problemas con el receptor de la llave remoto,tiene un problema eléctrico sin precedente todo ocurrió de la nada,todo ocurrió un mismo día cuando íbamos camino a una excursión mi familia y yo estuvimos en un gran riesgo,todos los componentes han sido inspeccionados y no he podido aún arreglarlos porque se necesita el consecionario de este automóvil para descubrirle las grandes fallas que presenta,aún tiene 3 señales en el tablero, check Engine, Power String, ABS, todo prendió después del problema

Fire

Bien,mi auto tuvo varios problemas al mismo tiempo: 1-falla en todo el sistema eléctrico,aire acondicionado,control de tráfico ambas partes, Power steering,ABS,Pérdida de potencia en el motor,problemas con el receptor de la llave remoto,tiene un problema eléctrico sin precedente todo ocurrió de la nada,todo ocurrió un mismo día cuando íbamos camino a una excursión mi familia y yo estuvimos en un gran riesgo,todos los componentes han sido inspeccionados y no he podido aún arreglarlos porque se necesita el consecionario de este automóvil para descubrirle las grandes fallas que presenta,aún tiene 3 señales en el tablero, check Engine, Power String, ABS, todo prendió después del problema

Fire

Bien,mi auto tuvo varios problemas al mismo tiempo: 1-falla en todo el sistema eléctrico,aire acondicionado,control de tráfico ambas partes, Power steering,ABS,Pérdida de potencia en el motor,problemas con el receptor de la llave remoto,tiene un problema eléctrico sin precedente todo ocurrió de la nada,todo ocurrió un mismo día cuando íbamos camino a una excursión mi familia y yo estuvimos en un gran riesgo,todos los componentes han sido inspeccionados y no he podido aún arreglarlos porque se necesita el consecionario de este automóvil para descubrirle las grandes fallas que presenta,aún tiene 3 señales en el tablero, check Engine, Power String, ABS, todo prendió después del problema

Fire

In relation to this incident, approximately 3,00 miles after an oil change, the engine oil drain plug fell out and caused all oil to leak and cause engine damage. Engine oil change was at approximately 125,000 miles. Drain plug fell out at approximately 128,000 miles. No warning lights or symptoms were present prior to vehicle shutting off and dying while driving. Vehicle was then towed to shop who previously did oil change. Shop confirmed drain plug was missing and oil level was empty. I am the manager of this shop submitting this on behalf of the customer with this vehicle. We are aware of the ongoing concerns in relation to case DP22-003 and would like to submit this information as further evidence for this case

Engine suddenly failed as I was sitting at a stop light and now is making a rattling/knocking noise

I was driving my daughters to school and the vehicle made a loud squeal and a subsequently a continuous clicking noise. I did not have any warning of the vehicle malfunctioning. There was no check engine light, no loss of power, or anything related to an impending failure. Upon this happening I was able to quickly get the vehicle moved as I was in the middle of the road with people around and lucking was not hit as I immediately stopped. I was close to home and was able to get the vehicle back to our home. Upon speaking with a Hyundai dealership they made me aware of a “silent recall” on many motors within the Hyundai failure due to internal failures. The vehicle was towed to the dealership and inspected and confirmed to have been linked to the engine failure. Hyundai is now stating that due to me being the second owner of the vehicle I am not apt to the extended warranty and there is no notice on any of the public facing knowledge to any of this information. I have gone through almost 2.5 months of back and forth with Hyundai case managers & the Attorney general.

The vehicle is making a loud clunking noise in the steering column when driving down the road. It is veering all over the road and when I hit a bump it’s very bad. It’s difficult to keep in the lane. I brought it to my mechanic who said it was most likely the electronic steering motor assembly. He said he would not drive it in its current condition. Hyundai themselves said that it would be dangerous to operate. On the complaint website I was looking on there was around 50 complaints that have been reported to the NHTSA already and the website said it would also be very dangerous to drive.

The low beams on the 2014 and many other year Hyundai Sant fe models do not work properly. While you are driving at night the low beams do not light up enough or shine bright enough on the roadway so you can see and drive safely ... I even installed brand new bulbs , and nothing changed as far as the brightness . The headlight housings are clear and do not have any type of damage that would prevent the bulbs from providing plenty of light on the roads . This is very dangerous for anyone trying to drive these vehicles on any kind of roads at night time .

Loss of acceleration and stuttering when I was trying to get up to speed on the interstate going up a hill. Instantly blinking check engine light. Won't go above 2000rpm or 60mph. P1326 code read glow relay short circuit

The start of this journey to Wesley Chapel Hyundai service department were 4 or 5 lights on the dashboard. I can’t remember what day I called to make the appointment-probably a week before the appointment as followed. I made appointment to take my Sante Fe Sport to Wesley Chapel for Monday 02/17/2025. The vehicle was not driven after the multiple lights came on the dashboard. That was their earliest appointment for service. On [XXX] the Santa Fe Sport was towed to Westly Chapel service department because a neighbor came over to tell us that the car lights were blinking. The car was not on. When they lifted the hood on the vehicle there was smoke and the smell of something burnt. They disconnected the battery, and the vehicle was towed by AAA to the Westley Chapel Hyundai. We live in a mobile home and park the car close to the kitchen window. This scared me. What could have been was losing my home to fire. Thankfully it didn’t happen. My question is how does an ABS ASSY go bad under 30,000 miles on a vehicle? And we are being told that some pump went bad first that caused the ABS ASSY to go bad. So also, I question how does a pump go bad under 30,000 miles on a vehicle? Should this ABS ASSY failure been covered under a recall? I have attached the Hyundai of Wesley Chapel invoice. Thank you, [XXX] & [XXX] [XXX] 33541-7345 [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My car has a known oil consumption problem that has not been recalled on the 2014 vehicles. I have been dealing with issue for the 15 months. Getting the run around because call is out manufacture warranty but when problem first started was still under warranty. I have a extended warranty but

While driving we notice an engine knock, particular when the car reached 2000 RPM or more. the car suddenly lost power and would not exceed 40 mph. We took the vehicle to a mechanic and were informed that it needed the engine replaced.

My steering would work while I was driving with my kids in the car, my breaks were barely working, the hood started smoking and something under the hood in the engine caught on fire, there was a horrible smell when I was breaking and the breaks would jolt. The engine and cooling was not turning off even with my key taken out, the fan engine was running nonstop no matter what, smoking etc

Fire

My steering would work while I was driving with my kids in the car, my breaks were barely working, the hood started smoking and something under the hood in the engine caught on fire, there was a horrible smell when I was breaking and the breaks would jolt. The engine and cooling was not turning off even with my key taken out, the fan engine was running nonstop no matter what, smoking etc

Fire

My steering would work while I was driving with my kids in the car, my breaks were barely working, the hood started smoking and something under the hood in the engine caught on fire, there was a horrible smell when I was breaking and the breaks would jolt. The engine and cooling was not turning off even with my key taken out, the fan engine was running nonstop no matter what, smoking etc

Fire

This model of Santa Fe has a defective steering column. The car rattles at the base of the steering column at the base of the steering wheel in the floor by your feet. When you go over 70 it rattles.

Engine failed mixing oil and coolant

Crack was found in oil pan during regular maintenance. The engine was replaced by Hyundai and now has around 60,000 miles on it. At my expense, the oil plan was replaced.

The engine went out while driving on the freeway. All maintenance has always been done and it was burning oil.

Check engine light came on and acceleration failed. Hyundai dealership indicated there are no valves in the intake and exhaust ports.

Locked the doors normally with the remote. Went into the doctor's office. Returned to the car the driver's door would not unlock. All other doors worked normally. Could not unlock the door with either handle, the switch or the remote. The Dealer says that the door latch mechanism failed in the locked position with the door closed. This would make it very difficult to exit the car in an accident, fire or submersion. The only exit is to crawl over the high mid console and exit through the right front passenger door, this is a very difficult maneuver.

Twice in the last year the high pressure fuel line has cracked while I was driving and started spraying gas all over the engine bay.

The contact owns a 2014 Hyundai Santa Fe. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound. There was no warning light illuminated. Additionally, the contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle sputtered and hesitated while responding. The vehicle was not diagnosed or repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 63,547.

My drivers side door will not close. Everytime I close it, it doesn’t latch and remains open. There is absolutely no way to close the door. This happen while I was driving my car, the door flew open and when I shut it, it wouldn’t latch.

On [XXX}, the abs module failed. I did not know this until it was diagnosed by Pope Automotive, Lubbock, TX on 9/27/24. They discovered there was a recall 205 related to this issue. They started a case with Hyundai in regard to this: #[XXX]. I was in contact with my case worker who told me to have it towed to a Hyundai dealership. I did and it is currently at Gene Messer Hyundai, Lubbock, TX. Messer diagnosed the vehicle and stated the abs module is not related to the recall, because the recall work was done on 2/25/24 in Alabama. I contacted Messer Service Dept and spoke with Victoria. She stated that perhaps only the fuse was replaced, but not the abs. We need a copy of the invoice from Feb 2022, in order to know. I called Carvana, where I purchased the vehicle on [XXX] (only weeks from when the service was done). I was told it has been too long, they don't have the record. Serra Hyundai Trussville, AL said I'd have to get the information from Carvana, they cannot provide it to me. I called Carvana again today. I spoke with a different person and was told it would take 24-48 hours to send me the copy. On this invoice, we will find the abs module was replaced. There is no logical reason for it to go out in just 2.5 years. Perhaps it was a bad part. I feel it is unfair that I am being held responsible for it's replacement. If the abs module was not replaced as part of the 205 recall, I would expect it replaced. There were several model years included in the recall and hundreds of thousands of vehicles affected. There was also a class action lawsuit. There was a period of time where Hyundai parts were not quality or reliable. This has been a very stressful situation requiring many phone calls and research. It should have been a simple solution - replace the defective abs module at no cost to me. I have been without my vehicle now since [XXX]. It is the only transportation for a family of 4. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have been notified that I am in need of a new engine due to possible complete engine failure which is on the near horizon. I have the Lambda II V6 3.3L engine. It is knocking, making noises, hesitates to go, feels like it will stall out at all speeds, and is scaring me terribly. My certified local mechanic replaced a part for failed emissions, which cost almost $900. However the check engine light came back on. They stated I must go to Hyundai because they did not believe they could fix the car as it required a new engine. I took it to my Hyundai dealer, where my contact stated yes it should be covered as it was having the issues as have been identified with this engine. He later came back and stated his managers would not let him put through the claim, and said my estimate was now a whole new timing system at a cost of $4600. My car has less than 83,000 miles on it. My previous Hyundai is still running at 200,000 miles, so yes, I take good care of my vehicles. This is an early equipment failure on the part of Hyundai and Kia that they are now owning up to. I drive on busy 4 lane local roads, and I am afraid of this engine failure. Also, when I did take my Hyundai into the dealership, they did not have the ABS part needed for the recall. I was told it would be in within a couple of days. I have not been contacted back by them if it is in and to schedule me an appt. This is a huge failure in itself! I did make a claim to Hyundai Customer Care, that stated it was out of warranty. Today, I have my car at a 3rd automotive mechanic in the area to get a 3rd opinion. He has a minor timing issue code P0018 that emissions still kicked out once I finally got it passed. I am waiting to hear what he has to say regarding my engine with no beforehand knowledge of what I know so far. If my car catches fire or breaks down or seizes up on a busy road, I don't think that will go safely at all. I am very concerned for my safety and that of others.

My 2014 Hyundai Sonata is subject to the recall campaign for the 2.0L and 2.4L Gasoline Direct Injection (GDI) engines. Since June 24, 2024, the vehicle has exhibited multiple issues: 1. Check Engine Light: The check engine light is continuously on and blinking, signaling that the vehicle is unsafe to drive. Diagnostic codes retrieved include P0140 (O2 Circuit), P0172 (System Too Rich), and P0126 (Knock Sensor Circuit). While the P0126 code pertains to the knock sensor, there has been no definitive diagnosis to determine if the issue is isolated to the sensor or indicative of a deeper engine problem. 2. Engine Power Issue: The car experiences jolts and kicks back during acceleration, along with intermittent lack of power. Furthermore, an independent mechanic performed some tests on the engine, determining that it runs too rich. After the second white smoke through exhaust incident, the vehicle struggles, and often does not reach, 60 MPH; aligning with "Reduced power and/or hesitation" (case #2) in the recall campaign. 3. Exhaust Smoke: On two separate occasions, within a month, white smoke has been observed exiting the exhaust. Engine oil has been below 3/5 empty each time. No oil leak found; must be exiting through exhaust. Despite qualifying for the recall, the Hyundai Colorado Springs dealer has refused to inspect or replace the engine as required. These ongoing issues pose significant safety risks, including the potential for unexpected engine failure and loss of power while driving.

On [XXX] I was driving down a busy 4-lane in Los Angeles and my engine suddenly died. There were no warning signs like indicator lights or warning noises. It was traumatic and frightening and I thought I was going to be struck by a car or truck. I had little control over the car-it would not accelerate to get out of the road lane. I was coasting, stopped half toward the side of the road but still sticking out in the road lane and was terrified I'd get hit by another vehicle from my back driver's corner. Cars and trucks that were traveling at normal speed were trying to avoid a collision with me and swerving around me, putting myself and others at risk for serious injury or death. I had had all the systems updated 2 years ago at a HMA, Hyundai dealership as I was directed, which included the KSDS (Knock Sensor Detection System). Dealer said it was to warn me of possible engine noise and issues. I never got any warning. I was NEVER told by anyone including Hyundai or any regulatory agency that the engine could suddenly fail as I'm driving the car OR I WOULD NOT HAVE BEEN DRIVING IT! There were never any warnings at that time or any time that anything was wrong with the vehicle. The car was towed to a Hyundai dealership and they diagnosed the problem on 8/28/2024 as a failed engine bearings clearance test at 63Kmiles. I kept all maintenance records, all done timely and properly with full synthetic oil. The components were assessed by the Hyundai dealership in communication and with guidance through HMA, Hyundai Technical /Techline confirmed failed engine bearings clearance test. My engine was not making any noises beforehand at all, and no engine warning light or sounds gave any warnings to be cautious or do anything other than drive normally. I was told I need an engine replacement. A Prior Approval for the engine replacement was started on 8/28/24 and sent to HMA, Hyundai. 9/17/2024, I still don't have engine replacement, dealer refuses to give records. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM

Engine was replaced in Feb. 2020 as part of the 162 engine recall. Car engine completely shuts down while driving and cannot be restarted for 20 or so minutes. This leaves me stuck in traffic with no ability to move the car. The new engine only has 40,000 miles on it. Dealership first said it was an issue with the engine and valves but when I wanted them to pay, they said the car is fine and passes all inspections. The check oil light and engine light come on when the engine stops, but they are not on prior to the engine stalling. I have made three visits regarding this - 1 to my personal mechanic and two to the Hyundai dealership. I filmed a video of the stall but it is too long to upload.

See attached document for complaint

vehicle was driving then all of a sudden there was an excessive amount of white smoke coming out of exhaust Engine was making a clicking sound before like a card in spokes on a bike and has been excessively consuming oil recently Auto shop discovered that a piston came loose and was rattling around the engine until it eventually shot through the engine

This past Tuesday, July 23, 2024, I started to drive out of my driveway and I heard a very loud knocking noise coming from under the hood. Upon driving the car less than 100 feet the car lost power. It was extremely difficult to get the car back to my driveway. The car was completely impossible to drive and control of my Santa Fe Limited was lost. I had a tow company tow my Santa Fe to the place where I got normal routine service done. Both the tow truck driver and the owner of the auto service business stated the failure was a broken connecting rod or something very similar in the engine. The result was the engine is not able to be repaired and would need to be replaced by a new engine. I purchased the Santa Fe Limited new on May 17, 2024 and I am the only owner. It currently has 72,600 miles on it. I performed all service requirements and changed oil and filter every 5000 miles. Also had my tires rotated and balanced every 5000 miles.

Drive side door latch does not open from inside or out. Even after removing inner door panel and manually pulling latch cables the latch remains in the locked position. This is an obvious and major safety issue where the driver is unavailable to exit the vehicle. Other years were recalled for this issue however my 2014 model is not on the recall list for some reason. Even though the very same safety issue with door latch occurs.

I took my vehicle in for recall and they replaced the fuse box. Starting that day, the auxiliary power outlet in the rear (trunk) started to short out my pump that I have used many times while blowing up lake tubing equipment. Also since then my trunk has been randomly opening on its own (mostly while I’m asleep). It is happening about every 3 days. There is nothing in the way of the latch or the door and it is closed and locked before I walk away. Started happening 6/29 and the recall replacement was on 6/27