2020 HYUNDAI SANTA FE

2 recalls, 295 complaints - 136 TSBs - 5/5 safety rating

TRAILER HITCHES

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water acc... Read more

Consequence

A fire while parked or driving can increase the risk of injury.

Remedy

Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service ... Read more

584,784 vehicles affected

Manufacturer: Hyundai Motor America

VISIBILITY:WINDSHIELD

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.

Consequence

A windshield that detaches from a vehicle during a crash can increase the risk of injury.

Remedy

Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.

26,413 vehicles affected

Manufacturer: Hyundai Motor America

Complaint Statistics

295 total complaints 12 crashes 7 fires 7 injuries

Top Reported Components

Component	Complaints
ENGINE	46
ELECTRICAL SYSTEM	39
UNKNOWN OR OTHER	38
POWER TRAIN	27
STEERING	20
FUEL/PROPULSION SYSTEM	12
SERVICE BRAKES	11
STRUCTURE:BODY	8
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	7
ENGINE AND ENGINE COOLING	7

Incident date: Aug 15, 2026

At approximately 122,000 miles, my 2020 Hyundai Santa Fe experienced a serious engine malfunction while I was driving on the highway. The check engine light suddenly illuminated and the vehicle began thrusting/jerking forward unexpectedly. We immediately took action to exit the highway and were able... Read more

Incident date: Sep 7, 2026

My car has the 2.0 T GDI theta 2 motor and it went into limp mode and after scanning the codes it’s the p1326 code. The vin doesn’t show to be apart of the class action lawsuit but it’s the same motor

Incident date: Jul 16, 2026

Hyundai Motor America & Wallace Hyundai of StuartVEHICLE: 2020 Hyundai Santa Fe (2.4L Theta II GDI Engine)VIN: 5NMS23AD5LH181669INCIDENT MILEAGE: 181,000 MiHYUNDAI CASE NUMBER: 42981944SECTION 1: CATASTROPHIC INTERSTATE SAFETY INCIDENTOn July 16, 2026, while navigating heavy, high-speed traffic on I... Read more

Incident date: Jul 16, 2026

Incident date: Aug 28, 2026

My car is consuming an immense amount of oil, the manufacturer recommends oil changes every 7,500 miles, I get an oil change less than 3,000 miles and on my last oil change i was told that there are oil shavings in my oil filter. I just got the SC9C2 update and now my engine is knocking. Car drives ... Read more

Incident date: Aug 28, 2026

Incident date: Dec 7, 2025

2020 HYUNDAI SANTA FE SEL WITH 2.4L THETA II ENGINE EXPERIENCES SEVERE OIL CONSUMPTION AND REPEATED ENGINE STALLING DURING NORMAL OPERATION. THE VEHICLE HAS A DOCUMENTED HISTORY OF REPEATED LOW-OIL CONDITIONS DESPITE REGULAR OIL SERVICE. THE PROBLEM PROGRESSED TO THE ENGINE REPEATEDLY STALLING WHEN... Read more

Incident date: Jul 27, 2026

The multifunction/turn signal switch in my Hyundai has failed and causes the left turn signal to operate intermittently. While driving, I am unable to reliably activate the left turn signal when making a left turn or changing lanes. The signal may fail to engage when the turn signal lever is operate... Read more

Incident date: Jul 27, 2026

Incident date: Aug 7, 2026

Vehicle began running sluggish, gas smell noticed. Vehicle was due for oil change, took car in for oil change to AAA and mentioned gas smell. AAA identified gas leaking from fuel pump posing immediate safety issue that needed to be resolved.

Incident date: Aug 7, 2026

My new vehicle was stuck in park the dealership replaced a control module then a gear shift assembly and now some kind of brake switch and im nervous that the vehicles is unsafe. The dealership has not been letting me know much I've had to call and they won't give me any paperwork.

Incident date: Aug 7, 2026

Incident date: Jun 19, 2026

The horn is intermittenly failing and was verified by a Weimer Hyundai in Morgantown, WV on XXX. This is a known defect in 2023 Hyundai Elantras and they have issued an extended warranty to address the problem. An absence of a horn is a safety issue as you cannot signal other drivers in emergency si... Read more

Incident date: Jul 20, 2026

On XXX I purchase the vehicle TOYOTA AVALON XSE, with VIN #: [XXX]. I purchase the vehicle at LARRY [XXX] AMERICAN TOYOTA in [XXX], with the LIEN [XXX] KIRTLAND FEDERAL CREDIT UNION BANK same city of [XXX]. I was told the vehicle had a 160 point check, yet when I check the THUMB DRIVE that was given... Read more

Incident date: Jul 14, 2026

The contact owns a 2022 Ford Bronco Sport. While the contact’s daughter was driving at an undisclosed speed, there was a loud popping sound coming from the vehicle and the check engine warning light illuminated. After parking the vehicle, the contact discovered that the vehicle failed to reverse. ... Read more

Incident date: Jul 14, 2026

The contact owns a 2017 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repa... Read more

Incident date: Jul 17, 2026

There is a well known exhaust issue with the catalytic converter and the separating manifold and no recall has been issue yet. It causes the vehicle to lose pressure and shuts off in the middle of traffic. The seat belt secure locks are malfunctioning and could cause loss of life in the event of an ... Read more

Incident date: Jun 4, 2026

The contact owns a 2024 Chevrolet Trax. The contact stated that while driving approximately 35 - 50 MPH, the message that an update was needed was displayed. The contact selected to complete the update later; however, the computer system continued to perform the update, causing all indicators, scree... Read more

Incident date: Jun 4, 2026

The contact owns a 2021 GMC Yukon. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound and failed to accelerate above 25 MPH. No warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that there was metal in the e... Read more

Incident date: Jun 4, 2026

Incident date: May 18, 2026

The contact's son owns a 2023 Hyundai Tucson. The contact stated that while driving at various speeds, various warning lights illuminated, and various messages were displayed on the instrument panel; however, the warning lights disappeared upon restarting the engine. The contact stated that her son ... Read more

Incident date: Dec 1, 2025

The car's computer shorts out and disables all safety features including navigation, blind spot monitoring, all cameras, emergency braking, autopilot, lanekeeping, auto headlights and wipers. This is a known issue that Tesla will not repair. This resulted in a collision due to poor rear visibility... Read more

Crash

Incident date: Jun 17, 2026

The contact owns a 2022 Mercedes-Benz EQB350 4MATIC. The contact received notification of NHTSA Campaign Number: 26V073000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and provided a loaner vehicle. The contact stated that the m... Read more

Incident date: Jun 17, 2026

The contact owns a 2026 Mercedes-Benz GLC 300 4MATIC. The contact stated that her instrumental panel was not working, which caused her to be unable to see the gas level, oil, thermostat, and any warning lights. The vehicle was taken to a dealer twice. The first occasion the vehicle's instrumental pa... Read more

Incident date: Jun 9, 2026

My truck engine has failed due to metal shavings in the oil related to the L87 engine recall, and the failure occurred after GM had replaced the truck’s oil as part of the recall remedy. The recall remedy did not prevent the failure of the engine.

Incident date: Jun 9, 2026

Incident date: Nov 7, 2025

Four days after I took delivery of this used vehicle (April 25, 2026), multiple warning lights appeared at once: BRAKE, ABS, PARK, Check Engine, Blind Spot Monitor Unavailable, and RCTA OFF. An independent Toyota dealership diagnosed the vehicle April 27-28, 2026 (approx. 109,000 miles) and found (1... Read more

Incident date: May 19, 2026

Transmission is broken at 110,000 miles. It's happening to everyone that owns Toyota's.

Incident date: May 8, 2026

The contact owns a 2019 Kia Sorento. The contact stated while driving at an undisclosed speed, the low oil and the check engine warning lights were illuminated. The contact stated that a few days later, the contact noticed white smoke coming from the exhaust. The check engine warning light illuminat... Read more

Incident date: May 5, 2026

We purchased a used 2020 Ford Expedition Max Platinum, VIN [XXX] , from Deacon Jones dealership. The vehicle currently has 128,888 miles. At the time of purchase, we were assured the SUV was in “tip-top shape” because it had previously belonged to a manager’s friend and had supposedly been we... Read more

Incident date: May 12, 2026

The contact owns a 2026 Toyota Camry Hybrid. The contact received notification of NHTSA Campaign Number: 25V869000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was not yet available. The vehicle was returned to the dealer, and the contact was provided a rental vehicle. The... Read more

Incident date: May 12, 2026

Other cars for the same year model have a recall for the issue I’m having. 24S44 Is the ford recall code. Power steering is boosted and can oscillate side side. I’ve seen other mustangs with this recall have the same issue get repaired. Mine has the exact same issue. I didn’t notice it was a... Read more

Incident date: May 19, 2026

The screen between the speedometer and tachometer has blanked out completely no fuel gauge no odometer nothing

Incident date: May 19, 2026

No collision warning; completely break failed. Vehicle had some fuel leakage which was fixed on May-21-2026 and break was failed on May-22-2026 which caused due to this repair. It was a major accident and my car got total due to this. I need full refund of my car; same amount when I bought this car... Read more

Crash 2 injured

Incident date: May 19, 2026

Car cut off in the middle of driving it entire screen goes black and disable, OnStar does not go off continues to blink green even when vehicle is disable, vehicle is not completely powering off after shut down causing the battery to drain overnight.

Incident date: Apr 24, 2026

My vehicle wasn’t reading my key fob when I was pressing the lock and unlock button, so I took out the hard key and unlock the doors. Then the alarm set off and I was using the key fob again trying to shut the alarm off no response so I took the key fob and press the start stop button and the engi... Read more

Incident date: May 21, 2026

While driving on the highway in my 2023 Volkswagen Tiguan (approximately 70,068 miles), the EPC warning light and oil warning light illuminated and the vehicle began to stall/lose power. I exited the highway immediately and shut the vehicle down safely. A substantial amount of engine oil leaked fro... Read more

Incident date: Apr 15, 2026

I bought my vehicle around May 2024. Initially, everything seemed fine. However, I noticed that my car was starting to slow down and would enter limp mode, preventing me from exceeding a certain mileage. Subsequently, all the lights on my dashboard began flashing, prompting me to pull over and call ... Read more

Incident date: Jan 3, 2026

I took my car in for the EVM engine update. Since then whenever it starts it is jumpy. The rpm rev more than they should. It’s very concerning that it will rev and won’t stop and I could possibly hit someone. I took it back to the dealer and they called the timeline and they told them to do anot... Read more

Incident date: Apr 20, 2026

2020 Hyundai Santa Fe quartz white pearl paint and the paint is blowing off as I drive in multiple places. I took it to the dealer because when I called they said there's a Z05 recall on white Hyundai paint and it would be covered. When I take it in, they say 2020's weren't covered because the pai... Read more

Incident date: Apr 29, 2026

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving 50-55 MPH, the sunroof made an abnormal, exploding sound and shattered. The shade cover was closed during the failure. There was no injury sustained. The vehicle was driven to the workplace of the contact's brother-in-la... Read more

Incident date: Apr 16, 2026

To Whom It May Concern, I am submitting this formal complaint regarding a malfunction in the air conditioning system of my 2024 Chevrolet Trax. Specifically, the evaporator and/or condenser has failed, resulting in inadequate cooling performance and potential system leakage. This issue is more than ... Read more

Incident date: Mar 28, 2026

Well driving down hwy 207 with no other vehicles in site my sunroof spontaneously exploded with no evidence of a rock in sight I did take pictures right afterwards the pictures showed the remaining glass

Incident date: Mar 30, 2026

2024 Tesla Model S. Repeated rear tire and rear wheel failures with abnormal wear and possible rear alignment or suspension-related defect. Tesla service history shows repeated rear tire replacements beginning at about 5,165 miles, a later four-wheel alignment, a right rear tire replacement for unev... Read more

Incident date: Apr 13, 2026

This is truck number two of two trucks with the same issue. I purchased 2, 2024 F350 Super Duty's for our Highway Dept. The camera systems on both trucks failed. This includes the backup camera and forward facing camera. I found a recall notice (24S66) for this exact problem affecting 2024 F350's. I... Read more

Showing 50 of 295 complaints.

NHTSA Safety Ratings, 2020 HYUNDAI SANTA FE

2020 Hyundai Santa Fe SUV AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	4 / 5 ★★★★☆
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	14.6%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2020 HYUNDAI SANTA FE

136 manufacturer communications from 70 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	29
350000 EQUIPMENT	17
060000 ENGINE AND ENGINE COOLING	14
100000 POWER TRAIN	13
356000 EQUIPMENT ADAPTIVE/MOBILITY	6
200000 WHEELS	5
116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR	4
116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE	4

130000 VISIBILITY

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY/WIPER (PWS)

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

100000 POWER TRAIN

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

110000 ELECTRICAL SYSTEM

This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundaia??s Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous vers

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

100000 POWER TRAIN

This bulletin provides the procedure to update the TCU to revise the logic for P0741 (Torque converter clutch circuit).

110000 ELECTRICAL SYSTEM

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

060000 ENGINE AND ENGINE COOLING

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information related to the ECU software update for improvement of: - ISG operation in relation to the battery SOH (State Of Health) condition will be removed - ISG engagement with satisfied battery SOC (State Of Cha

110000 ELECTRICAL SYSTEM

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This bulletin describes the procedure to diagnose and repair tire pressure monitoring system (TPMS) DTC(s) on some 19MY and newer Santa Fe (TMA), 2021MY and newer Santa Fe Hybrid (TM HEV), 2022MY and newer Santa Fe Plug-In Hybrid (TM PHEV

200000 WHEELS

020000 SUSPENSION

This bulletin describes the procedure to refinish 19a?? wheels equipped on some 19-20MY Santa Fe (TMA) 2.0T vehicles with peeling clear coat.

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

200000 WHEELS

This bulletin describes the procedure to refinish 19a?? wheels equipped on some 19-20MY Santa Fe (TMA) 2.0T vehicles with peeling clear coat.

100000 POWER TRAIN

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed below, follow the repair procedure and replace the related input/output speed sensor and harness.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

100000 POWER TRAIN

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness.

060000 ENGINE AND ENGINE COOLING

This bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. Refer to the applicable Engine Control / Fuel System sections in the Shop

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

The front center speaker may produce a scratchy or distorted sound during operation. This bulletin describes the procedure to replace the crash pad center speaker for certain 20 and 21MY TMa Santa Fe.

060000 ENGINE AND ENGINE COOLING

This bulletin provides additional service diagnostic information and repair procedures related to Variable Charge Motion Controllers (VCM) equipped in the applicable vehicles listed below. This bulletin also provides information on the use

110000 ELECTRICAL SYSTEM

Certain 2020MY Santa Fe vehicles (TMA) may experience air conditioning not blowing cold air from the vents after some period of normal operation. This condition may be caused by an out of specification Evaporator Temperature Sensor. Follo

130000 VISIBILITY

060000 ENGINE AND ENGINE COOLING

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

110000 ELECTRICAL SYSTEM

Some 2020-2021 Santa Fe (TMa) and Palisade (LX2) may intermittently experience abnormal camera image display conditions on the instrument cluster when the turn signal is turned ON or the radio screen when transmission is in Reverse. The fol

350000 EQUIPMENT

260000 FORWARD COLLISION AVOIDANCE

Certain 2019-2020MY Santa Fe and 2018-2020MY Elantra equipped with the front multifunction camera may exhibit one or more of the following warnings on the instrument cluster; Lane Keep Assist System (LKAS), Front Collision Avoidance Assist

110000 ELECTRICAL SYSTEM

When using Wireless CarPlay, the system may intermittently auto disconnect. When Wireless CarPlay is disconnected, a pop up message a??Phone Not Responding. Please reconnect it and try againa?? will appear on the radio screen.

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

100000 POWER TRAIN

This bulletin provides the procedure to update the TCU to optimize the Distance To Empty (DTE) display. This update includes the software for optimizing CLR_DIST (Distance traveled since DTCs cleared) display.

118000 ELECTRICAL SYSTEM:SOFTWARE

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This bulletin describes the procedure to diagnose and repair tire pressure monitoring system (TPMS) DTC(s) on some 2020-2021MY Palisade (LX2) and Santa Fe (TMa) vehicles equipped with surround view monitoring (SVM) system.

200000 WHEELS

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

220000 SEATS

Certain Santa Fe (TMa) and Palisade (LX2) vehicles may exhibit noise coming from the second row seat track. This bulletin provides information on how to inspect and if necessary repair the condition.

350000 EQUIPMENT

Certain Santa Fe (TMa) and Palisade (LX2) vehicles may exhibit noise coming from the second row seat track. This bulletin provides information on how to inspect and if necessary repair the condition.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Certain Santa Fe (TMa) and Palisade (LX2) vehicles may exhibit noise coming from the second row seat track. This bulletin provides information on how to inspect and if necessary repair the condition.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information related to an Electronic Control Module (ECM) software update which revises DTC P00D2: Oxygen Sensor Heater Control Circuit Range/Performance Bank 1 diagnostic logic.

119111 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

190000 TIRES

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

200000 WHEELS

100000 POWER TRAIN

280000 BACK OVER PREVENTION

110000 ELECTRICAL SYSTEM

This bulletin provides information and procedures for collecting OBD a??In Use Monitor Performance Ratioa?? (IUMPR) data on certain 2019-2021MY vehicles at California dealers. This reporting is mandated by CARB (California Air Resources Boa

350000 EQUIPMENT

260000 FORWARD COLLISION AVOIDANCE

270000 LANE DEPARTURE

100000 POWER TRAIN

This bulletin provides the procedure to update the TCU for a shift flare and shock on reacceleration when driving in Sport Mode.

010000 STEERING

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

350000 EQUIPMENT

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

100000 POWER TRAIN

This bulletin provides a procedure to transfer pressure data to the TCU using GDS Mobile. This procedure is necessary to reduce the transmission learning time and improve the shift quality.

012000 STEERING:COLUMN

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

110000 ELECTRICAL SYSTEM

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

018100 STEERING:AUTOMATED/ADAPTIVE STEERING:MOTOR/ACTUATOR

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

120000 EXTERIOR LIGHTING

This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

160000 STRUCTURE

Certain 2019-2020 Nexo (FE), 2020 Palisade (LX2), and 2019 - 2020 Santa Fe (TM) vehicles equipped with the power tailgate may experience a nonoperational condition. This campaign provides service procedures to inspect and when necessary, pe

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2019 - 2020 Nexo (FE), 2020 Palisade (LX2), and 2019 - 2020 Santa Fe (TM) vehicles equipped with the power tailgate may not operate. This bulletin provides the service procedure to inspect and when necessary perform the power tailgate

Showing 100 of 136 bulletins.

NHTSA Safety Investigations, HYUNDAI SANTA FE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2017

3.3L Engine Loss of Motive Power (LOMP)

The Office of Defects Investigation (ODI) received a petition on February 2, 2024, requesting a defect investigation into an alleged defect of the "engine" on the following vehicle model: 2017 Hyundai Santa Fe vehicles equipped with the 3.3L V-Shaped GDI Lambda-II engines. The petition cites allegat... Read more

PE, Closed , Model Year: 2011

Non-crash Vehicle Fires

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai S... Read more

DP, Closed , Model Year: 2011

Non-crash Vehicle Fires

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehi... Read more

RQ, Closed , Model Year: 2012

Scope and Timeliness

NHTSA opened Recall Query (RQ) 17-004 to investigate the timeliness and scope of Hyundai?s Theta II GDI engine recalls (Recall Nos. 15V-568 and 17V-226), and Hyundai?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Hyundai to administrative... ly resolve NHTSA?s assertions of violations of law in connection with RQ17-004. NHTSA?s assertions included that Hyundai may be liable for civil penalties on multiple grounds, including the untimeliness of Recall Nos. 15V-568 and 17V-226, inaccuracies in Hyundai?s recall reports, and that a required report describing potential safety-related issues contained certain inaccuracies or omissions.Under the Consent Order, Hyundai agreed to a total civil penalty of $140,000,000. The total civil penalty included payment of $54,000,000 as a Non-Deferred Amount. Hyundai also agreed to a sum of $46,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Additionally, Hyundai agreed to a $40,000,000 Performance Obligation Amount to be expended by Hyundai to fulfill specified Safety Data Analytics Infrastructure obligations and Test and Inspection Laboratory obligations. The Consent Order also includes other terms designed to enhance Hyundai?s safety practices, and requires Hyundai to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-004, the Consent Order is not intended to affect any other current or future investigation which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-003) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Hyundai from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with law, and to initiate a recall upon any future determination by Hyundai, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Hyundai's ongoing performance obligations, and does not represent a determination by the agency as to Hyundai?s performance under the Consent Order to date.Read more

PE, Closed , Model Year: 2013

Front Axle Shaft Failure

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai-Kia) submitted two Defect Information Reports (DIR) to NHTSA identifying a safety defect related to fracture of the right front axle shaft in MY 2013 front wheel drive Hyundai Santa Fe Sport vehicles built from Jul... Read more

PE, Closed , Model Year: 2011

Steering Shaft Universal Joint Failure

The Office of Defects Investigation (ODI) opened PE12-029 based on one complaint alleging that a fastener became loose in the steering shaft of a model year (MY) 2011 Hyundai Santa Fe vehicle and related Early Warning Reporting field report data.In it's response to ODI's information request letter f... Read more

PE, Closed , Model Year: 2010

Transmission Intermediate Driveshaft

On April 25, 2011, Kia Motors Corporation submitted a defect notification letter to NHTSA regarding a transmission intermediate driveshaft condition in approximately 12,690 model year (MY) 2011 Kia Sorento 2-wheel drive vehicles equipped with automatic transmissions and 2.4L engines (NHTSA Recall No... Read more

EA, Closed , Model Year: 2001

REAR TRAILING ARM CORROSION FAILURE

IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN TH... Read more

PE, Closed , Model Year: 2001

REAR SUSPENSION TRAILING ARM FAILURE

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) DURING THIS PRELIMINARY EVALUATION, HYUNDAI PROVIDED ODI WITH 15 ALLEGATIONS OF CORROSION FAILURE OF THE LEFT- AND/OR RIGHT-REAR SUSPENSION TRAILING ARM.THREE OF THE 15 CONSUMERS ALLEGED A LOSS OF VEHICLE ... Read more

PE, Closed , Model Year: 2001

ENGINE SEIZURE

There is no summary currently available

HYUNDAI SANTA FE - All Years Overview

Complete safety history for the HYUNDAI SANTA FE across all model years (2001, 2026).

96 Total Recalls

10,465 Total Complaints

10 Investigations

576 Reported Crashes

254 Reported Fires

17 Reported Deaths

HYUNDAI SANTA FE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	4	52	View
2025	5	194	View
2024	7	214	View
2023	1	323	View
2022	5	310	View
2021	7	242	View
2020 (current)	2	295
2019	2	282	View
2018	2	143	View
2017	6	1,281	View
2016	3	291	View
2015	2	332	View
2014	3	679	View
2013	3	807	View
2012	1	475	View
2011	3	268	View
2010	3	333	View
2009	3	507	View
2008	6	718	View
2007	9	982	View
2006	1	143	View
2005	3	300	View
2004	3	386	View
2003	4	390	View
2002	4	219	View
2001	4	293	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2020 HYUNDAI SANTA FE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2020 HYUNDAI SANTA FE

Safety Technology

Technical Service Bulletins, 2020 HYUNDAI SANTA FE

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SANTA FE

HYUNDAI SANTA FE - All Years Overview

HYUNDAI SANTA FE - Year by Year

Other HYUNDAI Models