2007 FORD TAURUS

1 recalls, 196 complaints - 30 TSBs

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

Defect Description

Bosch Brake Components LLC (Bosch) is recalling certain aftermarket replacement front brake pads, models Bosch QuietCast BC598 and BP765, Bosch Blue BE598 and BE598H, Prostop PD598 and PD765M, Duralast Gold DG598, Duralast MKD598, Stop Master ST598, UltraStop ULT598, UltraLife MX598 and MX765, Brake... Read more

Consequence

A damaged or broken brake disc may reduce a vehicle's braking power, increasing the risk of a crash.

Remedy

Bosch will instruct the owners how to have the affected brake pads replaced, free of charge. The recall began on May 26, 2016. Owners may contact Bosch customer service at 1-888-715-3616.

49,635 vehicles affected

Manufacturer: Robert Bosch LLC

Complaint Statistics

196 total complaints 9 crashes 8 injuries

Top Reported Components

Component	Complaints
VEHICLE SPEED CONTROL	54
ELECTRICAL SYSTEM	26
POWER TRAIN	11
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM	8
SERVICE BRAKES	8
ENGINE AND ENGINE COOLING	8
ENGINE	7
AIR BAGS	7
UNKNOWN OR OTHER	7
FUEL/PROPULSION SYSTEM	6

Incident date: Jan 5, 2021

I bought a 2007 ford Taurus SEL from a dealership Oct ,2020 3 months after having we pulling up to a stop light and it was like the car wanted to take off by it's self and then when the light turned green we started to drive and it just shut off in the middle of traffic we had to get out and push it... Read more

Incident date: Jan 5, 2021

Incident date: May 3, 2022

Severely rusted brake line to the driver side real brake ruptured and caused loss of brake function and emptying of the single brake fluid reservoir. I cannot currently find the ruptured line segment, but a portion of the other rear brake line was similarly rusted prompting preventative repair. For... Read more

Incident date: Apr 15, 2021

The contact owns a 2007 Ford Taurus. The contact stated that while the vehicle was receiving routine service, she was notified that the camber toe adjustment kit, suspension, and steering needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The approxima... Read more

Incident date: Apr 22, 2021

Basically I was driving and stopped and my house and while in ideal the wiring under the hood and under the fender into the dash all started to melt together shorting the systems so I tried to repair and replace the parts due to being a used vehicle and didn't know how to report this until now. So I... Read more

Incident date: Apr 22, 2021

Incident date: Jul 9, 2020

AS I'M DRIVING DOWN THE ROAD MY 2007 FORD TAURUS HAS STARTED TO ACCELERATE ON IT'S OWN. ON JULY 9 THIS INCIDENT OCCURRED AND I WAS INVOLVED IN A CAR ACCIDENT HITTING A TREE. WHEN I START MY CAR IT WILL REV UP TO 2 RPM AND I HAVE TO PUSH THE GAS TO BRING IT BACK DOWN. MY MECHANIC HAS CHANGED THE O2... Read more

Crash 1 injured

Incident date: Feb 6, 2020

IT'S VERY COLD OUTSIDE I'M LOOKING AT FORMS AND IT SEEM TO BE A ISSUE WITH THE TAURUS FAMILY IN THE COLD THE DOOR DOESN'T LACK NONE OF MY DOOR WILL LOCK UNTIL IT'S WARM OUTSIDE ??? HELLO IT'S AT HOME IN A PARKING SPOT LATE FOR WORK :(

Incident date: Mar 20, 2018

AS I AM DRIVING WHEN I PRESS ON MY BRAKES THE CAR TRUMBLES, SHAKES AND IT DOESN'T BRAKE ALL THE WAY, IT FEELS LIKE SOMETHING IS MISSING

Incident date: Mar 20, 2018

AS I AM DRIVING WHEN I PRESS ON MY BRAKES THE CAR TRUMBLES, SHAKES AND IT DOESN'T BRAKE ALL THE WAY, IT FEELS LIKE SOMETHING IS MISSING

Incident date: Mar 20, 2018

AS I AM DRIVING WHEN I PRESS ON MY BRAKES THE CAR TRUMBLES, SHAKES AND IT DOESN'T BRAKE ALL THE WAY, IT FEELS LIKE SOMETHING IS MISSING

Incident date: Jul 9, 2017

WHEN I AM DRIVING ON THE STREET 35MPH ALL OF A SUDDEN MY CAR STARTS TO EXCEL (PICKS UP SPEED) AND IN ORDER FOR ME TO STOP IT FROM PICKING UP SPEED I HAVE TO PULL OVER AND PUT IT ON PARK THEN PRESS THE GAS PEDAL ONE QUICK TIME AND THEN I CAN START TO DRIVE AGAIN. I CAN'T DO NOTHING ELSE BUT PULLOVER

Incident date: Oct 21, 2019

MY 2007 FORD TAURUS WAS UP TO 3000 RPM'S AND MY CAR WASN'T LETTING ME DRIVE FASTER THAN 19 MPH. WHEN PRESSING THE GAS PEDAL ALL THE FAR WOULD DO IT REV HIGHER AND JOLT FORWARD REALLY FAST. I TURNED MY CAR OFF AND BEGAN DRIVING NORMAL AGAIN EXCEPT THE FACT MY TRANSMISSION WAS STILL WORKING WAY TOO HA... Read more

Incident date: Jan 8, 2019

CAR SUDDENLY STOPS RUNNING WHILE DRIVING WHILE TURNING INTO INTERSECTION

Incident date: Jan 8, 2019

CAR SUDDENLY STOPS RUNNING WHILE DRIVING WHILE TURNING INTO INTERSECTION

Incident date: Dec 28, 2015

THE HIGH AC LINE DRIPS ON THE SERPENTINE BELT AS A RESULT OF CONDENSATION DURING AC USE. THIS CAUSES A LIGHT SQUEAL THAT LEADS TO A LOUD SQUEAL. DURING THE SUMMER, THE ONLY WORK AROUND IS HAVING THE BELT CLEANED REGULARLY DURING THE SUMMER MONTHS. EVENTUALLY, WHILE OPERATING THE VEHICLE ON THE EX... Read more

Incident date: Jan 31, 2018

ELECTRONIC MESSAGE CENTER (ODOMETER, TRIPOMETER ETC.) BECAME DIMLY LIT AND IMPOSSIBLE TO READ DURING DAYLIGHT

Incident date: Apr 16, 2018

WHILE STOPPED AT A STOP LIGHT (DEPRESSING THE BRAKE), THE VEHICLE LUNGED FORWARD AND RPM KEPT HIGH. RPM WENT TO NORMAL IN FEW SECONDS. IT OFTEN HAPPENS (1 OF 10 TIMES DEPRESSING BRAKE), YESTERDAY MORNIG THE CAR LOST POWER ON FREE WAY (VECHICLE SPEED WAS NOT ABLE TO PASS 40 MPH), IT BACKED NORMAL IN ... Read more

Incident date: Apr 16, 2018

Incident date: Apr 2, 2018

(SENT TO FORD) THIS LETTER SERVES TO INFORM YOU OF A SERIOUS MECHANICAL DEFECT. I DRIVE A 2007 FORD TAURUS SEL [XXX] WITH APPROXIMATELY 162,500 MILES. THE CAR IS IN GOOD SHAPE AND HAS REGULAR MAINTENANCE. WE ALSO OWN A FORD MUSTANG, FORD FOCUS, AND FORD F-150. WE HAVE BEEN REGULAR FORD CUSTOMERS FOR... Read more

Incident date: Apr 2, 2018

Incident date: Dec 2, 2017

TAKATA RECALL I WAS DRIVING 60MPH AND TRIED TO SET CRUISE CONTROL AND TOOK FOR OFF GAS ABS THE CAR KEPT ACCELERATING FAST. ABOUT 80MPH I TAPPED THE BRAKE, CRUISE CONTROL LIGHT TURNED OFF AND CAR KEPT ACCELERATING AND RPMS WERE IN THE RED. I PUSHED AS HARD AS I COULD ON THE BRAKES AND CAR KEPT ACCELE... Read more

Incident date: Dec 2, 2017

Incident date: Mar 4, 2018

TAKATA RECALL , MOONROOF STOPPED CLOSING ONE DAY. IT HAS TO MANUALLY BE SHUT IF OPENED SO WE DON'T USE IT. IT MAKES LOUD CLICKING NOISE. THE FUSE FOR GEM 5A STARTED HAVING ISSUE. FUSE IS NEVER BLOWN. BUT TO OPEN OR CLOSE WINDOWS, THE FUSE WOULD NEED TO BE PULLED OUT AND PUT BACK IN WITH DOOR OPEN... Read more

Incident date: Mar 1, 2018

DOOR LATCHES GET STUCK OPEN AND DOORS WILL NOT CLOSE, OR WILL UNLATCH AND SWING OPEN WHILE DRIVING. I CURRENTLY OWN TWO 2007 FORD TAURUS VEHICLES AND THIS HAS HAPPENED CONSISTENTLY WITH THOSE TWO, PLUS MY PREVIOUS TAURUS'- A 2003, 2005 AND TWO 2006 TAURUS'.

Incident date: Jun 11, 2015

I AM VERY SCARED OF MY CAR RIGHT NOW AND I FEEL LIKE IT IS GOING TO FALL APART ON ME WHILE I AM DRIVING IT. THE ACCELERATOR STICKS AN DOES NOT WANT TO LET GO TO SLOW DOWN.

Incident date: Jun 11, 2015

I AM VERY SCARED OF MY CAR RIGHT NOW AND I FEEL LIKE IT IS GOING TO FALL APART ON ME WHILE I AM DRIVING IT. THE ACCELERATOR STICKS AN DOES NOT WANT TO LET GO TO SLOW DOWN.

Incident date: Jun 11, 2015

I AM VERY SCARED OF MY CAR RIGHT NOW AND I FEEL LIKE IT IS GOING TO FALL APART ON ME WHILE I AM DRIVING IT. THE ACCELERATOR STICKS AN DOES NOT WANT TO LET GO TO SLOW DOWN.

Incident date: Aug 10, 2017

TL* THE CONTACT OWNS A 2007 FORD TAURUS. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE INADVERTENTLY ACCELERATED AT RAPID SPEED. WHILE THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE CONTINUED TO ACCELERATE RAPIDLY. THE CONTACT HAD TO PLACE THE GEAR SHIFTER IN NEUTRAL TO STOP THE VEHICLE FROM ACCELERAT... Read more

Incident date: Oct 23, 2017

TODAY WENT FOR A RIDE, SAFETY BELTS FOR FRONT PASSENGER SEATS WORKED. LEFT THE CAR FOR A FEW HOURS, WHEN WE CAME BACK THE SAFETY BELT FAILED. I WENT TO FASTEN THE BELT AND IT WAS AS IF THE LOCKING MECHANISM WAS IN THE LOCKED POSITION.

Incident date: Oct 12, 2017

I WAS DRIVING DOWN THE ROAD AND MY AIR BAG DEPLOYED ON ITS OWN ALLMOST CAUSING ME TO WRECH.

Incident date: Aug 15, 2017

THIS CAR DIED TWICE AS MY WIFE WAS DRIVING HOME YESTERDAY. NO WARNING. IT WAS RUNNING WELL SINCE BUYING IT A MONTH AGO, AND IS WELL MAINTAINED WITH 105K MILES ON IT. IT FIRST DIED 500 YARDS FROM HOME, AND DIED AGAIN AS SHE PARKED IN THE DRIVEWAY. THIS SHUTS DOWN POWER STEERING AND BECOMES VERY DIFFI... Read more

Incident date: Jul 10, 2017

ON JULY 10, 2017 I WAS PROCEEDING WITHIN THE SPEED LIMIT ON A CITY STREET. I NOTICED A LINE OF STOPPED CARS SOME DISTANCE AHEAD OF ME. I ATTEMPTED TO APPLY MY BRAKES, BUT IT SOON BECAME EVIDENT THAT THAT THEY WERE NOT FUNCTIONING PROPERLY. THUS, MY RATE OF SPEED WAS NOT BEING SUFFICIENTLY REDUCED... Read more

Crash

Incident date: Jan 20, 2017

IN COLD WEATHER MY DRIVER DOOR WAS WILL NOT CLOSE AND LOCK. THE LOCKING MECHANISM BECOMES USELESS. IF I SLAM THE DOOR IT JUST BOUNCES FROM THE IMPACT. (I READ ANOTHER COMPLAINT AND REALIZED I HAVE THE SAME ANNOYING PROBLEM). I TRIED WD40 TO LUBRICATE LOCK, BUT IT SEEMS WHEN THE CAR WARMS UP THE LOCK... Read more

Incident date: May 17, 2017

TL* THE CONTACT OWNS A 2007 FORD TAURUS. WHILE DRIVING UNKNOWN SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO STOP AFTER A FEW SECONDS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANI... Read more

Incident date: Nov 25, 2016

TL* THE CONTACT OWNED A 2007 FORD TAURUS. WHILE ATTEMPTING TO MAKE A RIGHT TURN AND ATTEMPTING TO STOP, THE VEHICLE ACCELERATED WITHOUT WARNING AND CRASHED INTO A BUILDING. THE DRIVER AND PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS TOWED AND DESTROYED. THE PASSENGER RECEIVED CHEST INJU... Read more

Crash 2 injured

Incident date: Nov 25, 2016

Crash 2 injured

Incident date: Jan 18, 2017

I WAS DRIVING AND STARTED TO BREAK COMING UP TO A RED LIGHT. THE CAR DID SLOW DOWN BUT I COULD FEEL FROM MY FOOT ON THE BREAK PEDAL, A VIBRATION AND THE CAR ENGINE STARTED MAKING A RUMBLING SOUND, LIKE IT WAS "REVVING" IN HIGH GEAR. I TOOK MY FOOT SLIGHTLY OFF THE BREAK AND THE CAR ACCELERATED FORW... Read more

Incident date: Nov 18, 2016

I HAVE A WATER LEAK ON MY PASSANGER SIDE FLOOR WHICH SHORTED OUT MY HEATER BLOWER I HAD NOTICED THE LEAK IT HAPPENED TONIGHT WHILE I WAS DRIVING THEN WHEN I TURNED ON MY HEAT THE BLOWER STOPPED WORKING.

Incident date: Nov 18, 2016

Incident date: Nov 1, 2016

ANTI THEFT SYSTEM WILL NOT ALLOW MY CAR TO START. DROVE IT FOR A SHORT TIME, SHUT IT OFF CAME BACK OUT AND NOT MY VEHICLE WILL NOT START.

Incident date: Jul 16, 2016

TL* THE CONTACT OWNS A 2007 FORD TAURUS. WHILE DRIVING APPROXIMATELY 65 MPH, THE ABS AND BRAKE LIGHTS REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REPAIRED. THE F... Read more

Incident date: Jul 16, 2016

Incident date: Jun 16, 2016

SUDDEN ACCELERATION ON CITY STREETS WITHOUT TOUCHING THE GAS PEDAL. ENGINE RUNNING AT 4RPM AT A COMPLETE STANDSTILL AND WHILE MOVING. EVEN WHEN THE BRAKE WAS ENGAGED THE CAR KEPT LURCHING FORWARD WANTING TO PROCEED THROUGH THE RED LIGHT.

Incident date: Feb 1, 2016

WHILE DRIVING EXPERIENCED SUDDEN UNEXPLAINED ACCELERATION ON SEVERAL DIFFERENT OCCASIONS.

Incident date: Oct 11, 2015

SPUTTERS AS IF STARVING FOR GAS, WON'T GO ABOVE 3000RPMS, SHUTS OFF

Showing 50 of 196 complaints.

EPA Fuel Economy, 2007 FORD TAURUS

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.0L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	25.0	20.0	Regular	$3,100

CO2 Emissions: -1.0 g/mile (Large Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2007 FORD TAURUS

30 manufacturer communications from 7 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
160000 STRUCTURE	3
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	2
061000 ENGINE AND ENGINE COOLING:ENGINE	2
046000 SERVICE BRAKES, AIR:ANTILOCK	1
100000 POWER TRAIN	1
118000 ELECTRICAL SYSTEM:SOFTWARE	1
105000 POWER TRAIN:DRIVELINE	1
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	1

160000 STRUCTURE

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi

350000 EQUIPMENT

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo

160000 STRUCTURE

105000 POWER TRAIN:DRIVELINE

SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. TO IDE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

060000 ENGINE (PWS)

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061000 ENGINE AND ENGINE COOLING:ENGINE

060000 ENGINE AND ENGINE COOLING

118000 ELECTRICAL SYSTEM:SOFTWARE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

100000 POWER TRAIN

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

061000 ENGINE AND ENGINE COOLING:ENGINE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

046000 SERVICE BRAKES, AIR:ANTILOCK

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ

NHTSA Safety Investigations, FORD TAURUS

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2000

Speed control cable damage

On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the ... program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.Read more

PE, Closed , Model Year: 2004

Stuck throttle

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle b... ody attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation doRead more

EA, Closed , Model Year: 2002

Front Suspension Coil Spring Fracture

To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front... Read more

DP, Closed , Model Year: 2003

ENGINE STALLING FFV

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THA... Read more

EA, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF ... Read more

PE, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN AN... Read more

RP, Closed , Model Year: 2000

BRAKE/ACCELERATOR PEDAL APPLICATION

MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS... Read more

RQ, Closed , Model Year: 2000

BRAKE LIGHT SWITCH FAILURE

FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S AN... Read more

EA, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTH... Read more

PE, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.T... Read more

PE, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCE... Read more

PE, Closed , Model Year: 2000

BRAKE/ACCEL PEDAL SEPARATION

RQ, Closed , Model Year: 1993

FRONT SUSPENSION SPRING

There is no summary currently available

EA, Closed , Model Year: 1993

WINDSHIELD WIPER

ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the ... Read more

PE, Closed , Model Year: 1993

WINDSHIELD WIPER

ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING

RQ, Closed , Model Year: 1992

FRONT SUSPENSION SPRING BREAKAGE

FRONT SUSPENSION SPRINGS AY BREAK DUE TO MANUFACTURING CRACHS IN COMBINATION WITH CORROSION.

EA, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

RQ, Closed , Model Year: 1986

REAR LOWER SUBFRAME ASSEMBLY

TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE

PE, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.

EA, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

There is no summary currently available

EA, Closed , Model Year: 1992

HEADLIGHT FAILURE

EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OU... Read more

PE, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT ... Read more

PE, Closed , Model Year: 1993

HEADLIGHTS FAILURE

There is no summary currently available

DP, Closed , Model Year: 1987

ALLEGED DEFECTIVE TIE RODS

PE, Closed , Model Year: 1992

PLASTIC TRIM PANEL SEPARATION

There is no summary currently available

DP, Closed

POWER STEERING FLUID FIRES

EA, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

PE, Closed , Model Year: 1986

POLYCAST ROAD WHEEL CRACKS

There is no summary currently available

PE, Closed , Model Year: 1988

STEERING LCK-UP/IMPEDIMENT

There is no summary currently available

PE, Closed , Model Year: 1991

FAILURE OF WHEEL STUDS

There is no summary currently available

PE, Closed , Model Year: 1988

UNDERBODY FUEL LINE FAILS

There is no summary currently available

PE, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

EA, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1988

POWER STEERING LEAKS/FIRES

There is no summary currently available

PE, Closed , Model Year: 1988

ENGINE MOUNT FAILURE

There is no summary currently available

EA, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

===

DP, Closed , Model Year: 1991

ANTI-LOCK BRAKES

PE, Closed , Model Year: 1986

FIRES IN IGNITION SWITCH

There is no summary currently available

PE, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

There is no summary currently available

PE, Closed , Model Year: 1986

DOOR HANDLES BREAKAGE

There is no summary currently available

EA, Closed , Model Year: 1989

SEAT BELT BUCKLE FAILURE

There is no summary currently available

EA, Closed , Model Year: 1985

BRAKE DISC HUB SEPARATIONS

===

PE, Closed , Model Year: 1990

SAFETY BELT BUCKLE LOCKING

There is no summary currently available

PE, Closed , Model Year: 1990

WHEEL SEPARATION

There is no summary currently available

PE, Closed , Model Year: 1986

BRAKE DISC HUB FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

THROTTLE STICKING

There is no summary currently available

PE, Closed , Model Year: 1986

SPEED CONTROL FAILURE

There is no summary currently available

EA, Closed , Model Year: 1987

POWER SEAT MALFUNC/FIRE

There is no summary currently available

EA, Closed , Model Year: 1986

SAFETY BELT FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

SAFETY BELT FAILURE

===

PE, Closed , Model Year: 1987

PWR SEAT MALFUNC - FIRE

===

EA, Closed , Model Year: 1986

FRONT SEAT BRACKET

SUMMARY:THE LOSS OF VEHICLE CONTROL APPEARS TO BE THE POTENTIALCONSEQUENCE OF A SEAT BRACKET FAILURE.===

PE, Closed , Model Year: 1986

EXHAUST GAS INTRUSION

SUMMARY: OWNERS COMPLAIN OF EXHAUST GASES, INCLUDING HYDROGEN SULFIDE,LEAKING INTO THE PASSENGER COMPARTMENT CAUSING NAUSEA, HEADACHES, ANDDISCOMFORT.HYDROGEN SULFIDE (H2S) IS A COLORLESS, FLAMMABLE, ANDVERY POISONOUS GAS.===

PE, Closed , Model Year: 1986

FRONT SEAT BRACKET

BRIEFING NOTES ODISCUSSION OF THE REPORTED DEFECT & ITS CONSEQUENCES OFAILURE MILEAGE ANALYSIS OWARRANTY DATA ANALYSIS OFORD'S BODY & CHASSIS ENGINEERING REPORT OCOMPARISON WITH OTHER SEAT-TRACK ANALYSES===

PE, Closed , Model Year: 1986

HEAD REST DROPS

===

EA, Closed , Model Year: 1986

STALLING

===

PE, Closed , Model Year: 1986

HIGH BRAKE PEDAL EFFORT

===

PE, Closed , Model Year: 1986

STEERING BINDING

BASED ON AN ODI FAILURE REPORT ANALYSIS SHOWING 6 COMPLAINTS, 4 ACCIDENTSAND 3 INUJURIES, A PRELIMINARY EVALUATION WAS OPENED AND AN INFORMATIONREQUEST WAS SENT TO FORD.SUBSEQUENTLY, ODI RECEIVED 4 ADDITIONAL COM-PLAINTS.FURTHER INFORMATION WAS DEVELOPED WHICH LED TO DELETION OF 4COMPLAINTS AND THE ... Read more

DP, Closed , Model Year: 1981

SUDDEN ACCELERATION

FORD TAURUS - All Years Overview

Complete safety history for the FORD TAURUS across all model years (1986, 2019).

173 Total Recalls

24,046 Total Complaints

60 Investigations

1,466 Reported Crashes

697 Reported Fires

43 Reported Deaths

FORD TAURUS - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2019	2	19	View
2018	4	67	View
2017	4	53	View
2016	4	104	View
2015	6	356	View
2014	5	297	View
2013	9	755	View
2012	5	100	View
2011	4	251	View
2010	3	286	View
2009	0	77	View
2008	1	240	View
2007 (current)	1	196
2006	3	415	View
2005	1	1,005	View
2004	2	482	View
2003	4	1,524	View
2002	4	1,759	View
2001	10	1,264	View
2000	8	1,497	View
1999	7	1,100	View
1998	4	680	View
1997	5	1,003	View
1996	8	1,132	View
1995	6	1,597	View
1994	5	1,284	View
1993	8	2,206	View
1992	6	1,009	View
1991	5	946	View
1990	8	542	View
1989	7	762	View
1988	6	462	View
1987	9	355	View
1986	9	150	View
1985	0	2	View
1984	0	4	View
1983	0	1	View
1981	0	2	View
1977	0	2	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2007 FORD TAURUS

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2007 FORD TAURUS

Technical Service Bulletins, 2007 FORD TAURUS

Most Affected Components

NHTSA Safety Investigations, FORD TAURUS

FORD TAURUS - All Years Overview

FORD TAURUS - Year by Year

Other FORD Models