2006 FORD TAURUS

3 recalls, 415 complaints - 31 TSBs

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

Defect Description

Bosch Brake Components LLC (Bosch) is recalling certain aftermarket replacement front brake pads, models Bosch QuietCast BC598 and BP765, Bosch Blue BE598 and BE598H, Prostop PD598 and PD765M, Duralast Gold DG598, Duralast MKD598, Stop Master ST598, UltraStop ULT598, UltraLife MX598 and MX765, Brake... Read more

Consequence

A damaged or broken brake disc may reduce a vehicle's braking power, increasing the risk of a crash.

Remedy

Bosch will instruct the owners how to have the affected brake pads replaced, free of charge. The recall began on May 26, 2016. Owners may contact Bosch customer service at 1-888-715-3616.

49,635 vehicles affected

Manufacturer: Robert Bosch LLC

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

CERTAIN PASSENGER VEHICLES BUILT FOR ONE SPECIFIC FLEET CUSTOMER WERE MODIFIED FOR OPTIONAL HANDS-FREE CELLULAR PHONE OPERATING CAPABILITY. TO PROVIDE THIS FUNCTIONALITY, A SPECIAL OVERLAY WIRE HARNESS WAS INSTALLED THAT INADVERTENTLY DID NOT INCLUDE THE CIRCUITS FOR PASSENGER AIR BAG DEACTIVATION ... Read more

Consequence

THE PADI LAMP WILL FAIL TO ILLUMINATE AND THE AIR BAG WARNING LAMP IN THE CLUSTER WILL STAY ILLUMINATED.

Remedy

THE FLEET CUSTOMER WAS NOTIFIED AND ALL VEHICLES HAVE BEEN REPAIRED. THE RECALL BEGAN ON APRIL 28, 2006.

19 vehicles affected

Manufacturer: FORD MOTOR COMPANY

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Defect Description

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Consequence

AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy

DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

199,942 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

415 total complaints 29 crashes 5 fires 15 injuries 1 deaths

Top Reported Components

Component	Complaints
VEHICLE SPEED CONTROL	171
ENGINE	25
ELECTRICAL SYSTEM	23
AIR BAGS	19
POWER TRAIN	19
SERVICE BRAKES	14
ENGINE AND ENGINE COOLING	14
POWER TRAIN:AUTOMATIC TRANSMISSION	11
FUEL/PROPULSION SYSTEM	11
UNKNOWN OR OTHER	11

Incident date: Sep 10, 2024

Stop Start Failure (replaced-filter and battery) Failed again same battery reason showing battery tested was fine. Still not working to date

Incident date: Jun 8, 2023

My air bag light is on red

Incident date: Jun 8, 2023

On two occasions, most recently on 6/13/23 the vehicle went from 70 mph to 10 mph very suddenly on an Interstate in heavy traffic--very dangerous. The display indicates an over-heated transmission but the dealer believes its some electrical problem. This 2018 Suburban has an 8 speed auto transmissio... Read more

Incident date: Oct 10, 2022

The Blind spot warning system malfunctions and the warning always triggers when a turn signal is activated, even with no vehicle in the blind spot. This occurs more often on the driver side. It also fails to detect vehicles sometimes. One would be better off turning the system off entirely as it sta... Read more

Incident date: Oct 10, 2022

The contact owns a 2014 Jeep Grand Cherokee. The contact stated while driving 50 MPH, the check engine warning light illuminated. The contact stated that after parking the vehicle, he noticed transmission fluid leaking underneath the vehicle. The vehicle was not drivable. The contact towed the vehic... Read more

Incident date: Jul 5, 2022

Throttle stuck and vehicle accelerated out of control. Had to brake hard and turn off engine to prevent crash. Speed Control Cable disconnected from cruise control. It has been repaired since the incident. Yes, was reproduced by the tow truck driver as well as at a service center. No warnings, only ... Read more

Incident date: Mar 29, 2022

Splines on Torque converter stripped out causing vehicle to just rev up and slow down to a stop. Car never moved again, had I been going up a large hill or something this could have been VERY VERY bad, because it wasn't until I was stopped that I realized it was the transmission having problems. A... Read more

Incident date: Jun 25, 2022

Car engine accelerate on own. Tac meter shows over 3,000 RPM when I put it in neutral. I have to tap the accelerator and it goes back to normal. This happens about once a week now. I was slowing down for a stoplight and it happened. Brakes were not enough. Almost hit a car. Only by throwing into ne... Read more

Incident date: Jun 25, 2022

Incident date: Jun 24, 2022

The contact owns a 2006 Ford Taurus. The contact stated while driving approximately 55 MPH, the vehicle failed to slow down as needed while depressing the brake to make a left turn. The contact stopped the vehicle and shifted the gear shifter to park; however, while parked the RPM rose to 5,000 RPM.... Read more

Incident date: Feb 16, 2022

Fatal accident involving the Death of a loved one

Crash 1 deaths

Incident date: Nov 12, 2021

I was in an accident on Nov12,2021 and the air bag did not deploy. My front end was completely damaged.

Crash

Incident date: Mar 12, 2021

THE THROTTLE STICKS OPEN AND THE ENGINE REVS HIGH MAKING IT HARD TO SLOW DOWN AND STOP. THE CRUISE CONTROL CABLE IS HOLDING THE THROTTLE OPEN BECAUSE OF A FAULTY ATTACHMENT TO THE THROTTLE CONTROL. THIS IS A KNOWN AND WIDE PROBLEM. PEOPLE ARE BANDAGING THE PROBLEM WITH BACK YARD FIXES THAT CAN CAUSE... Read more

Incident date: Jan 14, 2021

PERIODICALLY THE PASSENGER SIDE AIRBAG OFF LIGHT COMES ON. ALSO, PASSENGER SIDE DOOR AJAR ON DASHBOARD ON ALL THE TIME WHICH MAKES DOME LIGHT STAY ON AND DRAIN BATTERY.

Incident date: Jan 14, 2021

PERIODICALLY THE PASSENGER SIDE AIRBAG OFF LIGHT COMES ON. ALSO, PASSENGER SIDE DOOR AJAR ON DASHBOARD ON ALL THE TIME WHICH MAKES DOME LIGHT STAY ON AND DRAIN BATTERY.

Incident date: Jan 2, 2016

PROBLEM WITH WINDOWS GOING BACK UP I REPLACED THE MAIN SWITCH FOR ALL WINDOWS BUT STILL DID NOT WORK TOOK AGAIN TO ELECTRICIAN AND THEY SAID IT WAS THE MAIN FUSE BOX UNDER DRIVERS SEAT THAT NEEDED TO BE REPLACED .

Incident date: Oct 12, 2020

VEHICLE QUICKLY ACCELERATES ON ITS OWN WHEN OPERATING WHILE IN MOTION

Incident date: Jan 14, 2020

IN COLD WEATHER THE DOOR LATCHES FREEZE AND WILL NOT LATCH THIS IS THE SECOND 2006 FORD TAURUS I HAVE OWNED THAT HAS DONE THIS. HAS HAPPENED NUMEROUS TIMES ATLEAST 20

Incident date: Jan 14, 2019

VEHICLE ACCELERATES ON ITS OWN WITHOUT TOUCHING GAS IT INCREASES TO 40-60 MPH HIGH RPM IN NEUTRAL OR PARK WHILE DRIVING IT INCREASES SPEED ON ITS OWN. NEARLY REAR ENDED ANOTHER CAR AT LIGHT TODAY AS I TOOK FOOT OFF BRAKE IT JUMPED TO 20 MPH CAR HAS 68,000 MILES WELL MAINTAINED

Incident date: Oct 22, 2018

WHILE DRIVING OVER 45MPH THE ACCELERATOR STICKS. THIS HAS HAPPENED SEVERAL TIMES . IT ACCELERATED ON ITS OWN WHILE I WAS TRYING TO PARK AT WORK.

Incident date: Jul 18, 2018

I WAS DRIVING ON A 2-LANE HIGHWAY WITH A RELATIVELY STEEP DOWNHILL GRADE. I NOTICED THAT THE CAR WAS ACCELERATING EVEN THOUGH I WAS NOT PRESSING THE ACCELERATOR. I THOUGHT AT FIRST THAT IT WAS JUST ACCELERATION DUE TO GRAVITY, BUT I QUICKLY REALIZED THAT THE THROTTLE MUST BE OPEN SINCE I WAS QUICKLY... Read more

Incident date: Mar 1, 2018

TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT DISCONNECTED THE SPEED CONTROL CABLE. THE LOCAL DEALER WAS CONTACTED AND DEALER STATED COTACT WOULD HAVE TO PAY FOR IT BECAUSE IT WAS OUT OF WARRANTY. THE VEHICLE WAS NOT DI... Read more

Incident date: May 3, 2018

WHILE I WAS DRIVING THE CAR THE THROTTLE CABLE GOT STUCK WITH THE CRUISE CABLE AND THE RPM RAISED TO 5000 AND DOESN'T COME DOWN. I SWITCHED THE GEARS BACK TO 1ST AND BROUGHT IT TO SLOW DOWN. LUCKILY THERE WERE NOT MUCH TRAFFIC OTHERWISE THIS COULD HAVE CAUSED A VERY BAD ACCIDENT. I REPORTED THIS ISS... Read more

Incident date: Jun 1, 2007

TL* THE CONTACT OWNS A 2006 FORD TAURUS EQUIPPED WITH HANKOOK OPTIMO H727 TIRES, SIZE: 215/60R16 (NA). WHILE DRIVING VARIOUS SPEEDS, THE STEEL BELTS PUNCTURED THE SIDE OF THE FRONT DRIVER'S TIRE. THE CONTACT STATED THAT THE DRILL SHOCK TOWER MOUNT WAS MISALIGNED. IN ADDITION, THE VEHICLE MADE A HOWL... Read more

Incident date: Jan 25, 2018

TL* THE CONTACT OWNS A 2006 FORD TAURUS. ON SEVERAL OCCASIONS, WHILE DRIVING, THE VEHICLE INDEPENDENTLY ACCELERATED. WHILE THE VEHICLE WAS PARKED, IT ACCELERATED WITHOUT WARNING. ALSO, THE CRUISE CONTROL FAILED TO OPERATE. THE CONTACT STATED THAT THE GEAR SHIFTER WAS PLACED IN NEUTRAL AND THE ACCELE... Read more

Incident date: Jan 17, 2018

CRUISE CONTROL STOPPED WORKING & THEN A COUPLE WEEKS LATER WHILE DRIVING UP A HILL THE ACCELERATOR TOOK OFF BY ITSELF LIKE THE CRUISE CONTROL WAS ON, WHEN I TOOK MY FOOT OFF THE GAS PEDAL THE CAR CONTINUED TO ACCELERATE. IN A PANIC I SHIFTED THE CAR INTO NEUTRAL & THE ENGINE REV'D UP TO OVER 4000 R... Read more

Incident date: Nov 15, 2017

FORD MOTOR COMPANY SOLD MY VEHICLE WITH A LIFE-THREATENING DESIGN DEFECT IN THE BRAKING SYSTEM. THIS DESIGN DEFECT COMPRISES A PLASTIC COVER OVER THE STAINLESS STEEL HYDRAULIC BRAKE LINES WHERE THOSE LINES PASS FROM THE FRONT OF THE CAR TO ITS REAR BENEATH THE DRIVER SIDE DOOR. THE OSTENSIBLE PURPOS... Read more

Crash

Incident date: Oct 14, 2017

2/15/17- WHILE COASTING UP-HILL WITH FOOT NOT ON THE GAS, CAR ACCELERATED TO OVER 4,000 RPM ALL BY ITSELF, BRAKING WAS EXTREMELY DIFFICULT. I PARKED, TURNED CAR OFF, TURNED IT BACK ON AND EVEN WHILE PARKED IT REVVED BACK UP TO OVER 4,000 RPM. TOOK IT TO FIRESTONE ON 2/16/17- THEY REPLACED THE IAC ... Read more

Incident date: Oct 14, 2017

Incident date: Aug 22, 2017

AROUND 6PM I WAS DRIVING DOWN A RESIDENTIAL STREET (25 MILES SPEED), IN MOTION, ALL OF A SUDDEN THE CAR JUST TURNED OFF. LUCKILY I WAS ABLE TO STEER TO THE SHOULDER. I NOTICED ALL DASHBOARD LIGHTS ON, MY GAS PEDAL WAS NOT WORKING, BUT THE A/C WAS STILL WORKING AND THE RADIO. SO I KNOW IT WASNT MY 1 ... Read more

Incident date: Aug 22, 2017

Incident date: Aug 8, 2017

I WAS DRIVING EASTBOUND, ON A CITY STREET, APPROACHING THE INTERSECTION WITH A STOP SIGN. WHEN I PRESSED ON THE BRAKES, IT DIDN'T SLOW DOWN. IN FACT, THE CAR WAS GOING FASTER. SO I PUT THE CAR IN PARK, HOPING TO SLOW IT DOWN, BUT IT DIDN'T WORK. THEN I JUMPED THE CURB, HOPING THAT WOULD SLOW THE CAR... Read more

Crash 1 injured

Incident date: Jun 27, 2017

MY CAR, SINCE 130K MILES ACCELERATES ON ITS OWN...WHEN I PUT IN NEUTRAL AND HIT GAS IT REVS TO 5 AND THEN NORMALIZES. # DAYS AGO IT DID IT 5X WITHIN 10 MINUTES. CURRENTLY HAS 140K MILES. I HAD IT SDERVICED AND THE FORD DEALER OFFERED NO SOLUTIONS AND WERENT AWARE OF THIS TYPE OF PROBLEM

Incident date: Jun 7, 2017

TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING 40 MPH, THE BRAKE PEDAL WAS APPLIED BUT FAILED TO RESPOND AND THE VEHICLE ACCELERATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE.... Read more

Incident date: Jun 7, 2017

Incident date: Mar 20, 2015

2006 FORD TAURUS. CONSUMER WRITES IN REGARDS TO AFTERMARKET FRONT BRAKE PADS RECALL NOTICE. *SMD *JS

Incident date: Apr 12, 2017

VEHICLE WAS DRIVING NORMALLY WITHOUT ANY INDICATION OF AN ISSUE PRIOR. AFTER A STOP AT A LIGHT, CAR PROCEEDED TO DISENGAGE TRANSMISSION AND WOULD NOT ACCELERATE. ENGINE REVS BUT ZERO MOVEMENT. HAD TO HAVE IT TOWED TO DEALER.

Incident date: Oct 1, 2016

TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHEN THE CONTACT'S FOOT WAS RELEASED FROM THE ACCELERATOR PEDAL, THE VEHICLE IDLED ABNORMALLY. THE FAILURE OCCURRED WITHOUT WARNING. THE DEALER COULD NOT REPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NO... Read more

Incident date: Jan 22, 2017

TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING APPROXIMATELY 60 MPH, THE GAUGES ON THE INSTRUMENT PANEL FLICKERED, THE VEHICLE DECELERATED, AND THE DOOR LOCKS STARTED TO CLICK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED, BUT THE TECHNICIAN COULD NOT FIND A FAILURE. IN ADDITIO... Read more

Incident date: Jan 7, 2017

ACCELERATOR STICKS. CAR FAILED TO DE-ACCELERATE SEVERAL TIMES. ONCE, COMING TO STOP SIGN AND ENGINE KEPT RACING. OCCASIONALLY GOING DOWN HIGHWAY AND WANTED TO SLOW DOWN, BUT ACCELERATOR WAS STUCK. CAN BARELY STOP THE CAR WITH BRAKES. REASON: THE REASON IS WELL DOCUMENTED. THE CRUISE CONTROL CAB... Read more

Incident date: Jan 12, 2016

SUDDEN EXCELERATION WITHOUT USING THE GAS PEDAL , ENGINE PULLING RPM AND REVVING, SUCH AS WHEN IN PARK. DRIVING VEHICLE AND IT BEGAN TO ACCELERATE ON IT'S OWN., HARD STOPPING WHICH PUT MYSELF AND OTHER DRIVERS IN A DANGEROUS POSITION ON THE HIGHWAY. THE VEHICLE IS A 2006 FORD TAURUS SE AND HAS 84,00... Read more

Incident date: Nov 4, 2006

CAR SELF ACCELERATES FOR NO REASON. IT HAPPENED FOUR TIMES TODAY DURING A 10 MINUTE DRIVE. IT HAPPENS WHILE CAR IS MOVING AND AT LOW SPEED, APPROXIMATELY 25 MILES PER HOUR.11\4. *TR

Incident date: Nov 4, 2006

CAR SELF ACCELERATES FOR NO REASON. IT HAPPENED FOUR TIMES TODAY DURING A 10 MINUTE DRIVE. IT HAPPENS WHILE CAR IS MOVING AND AT LOW SPEED, APPROXIMATELY 25 MILES PER HOUR.11\4. *TR

Incident date: Apr 17, 2015

BRAKE LINE TO REAR BRAKES FAILED DUE TO RUST. ALL (ALL) BRAKE FLUID LEAKED OUT. THE SERVICE BRAKES WERE TOTALLY INOPERABLE. A LARGE OIL SPOT ON THE CONCRETE DRIVEWAY WAS THE ONLY WARNING.. NO LOW FLUID LIGHT IS INSTALLED. THIS VEHICLE IS NON-ABS. MUCH TO MY SURPRISE, THIS IS A SINGLE RESERVOIR... Read more

Incident date: Aug 10, 2016

TL* THE CONTACT OWNS A 2006 FORD TAURUS. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED TO 40 MPH ON ITS OWN AND WHILE THE BRAKE PEDAL WAS APPLIED. WHEN THE CONTACT PLACED THE GEAR SHIFTER INTO THE NEUTRAL POSITION, THE RPMS INCREASED FROM 200,000 TO 300,000. THE IGNITION WAS SHUT OFF ... Read more

Incident date: Aug 10, 2016

Incident date: Jul 24, 2016

ON THE AFTERNOON OF SUNDAY, JULY 24TH, 2016, OUR 2006 FORD TAURUS BEGAN ACCELERATING OUT OF CONTROL ON ITS OWN ACCORD WHILE DRIVING DOWN THE STREET IN WORCESTER, MASSACHUSETTS. WE TRIED TO BRAKE THE CAR, BUT WERE NOT ABLE TO COMPETE AGAINST THE RAPID ACCELERATION. WE ENDED UP PUTTING IT IN NEUTR... Read more

Incident date: Aug 1, 2016

CAR HESITATES DURING OPERATION USUALLY WHILE DRIVING IN THE CITY AND HAS EVEN STOPPED RUNNING COMPLETELY BUT WILL RESTART BY IGNITION. THE HESITATION STILL HAPPENS BUT THE STOPPING HASN'T HAPPENED RECENTLY.

Showing 50 of 415 complaints.

EPA Fuel Economy, 2006 FORD TAURUS

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.0L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	25.0	20.0	Regular	$3,100
3.0L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	17.0	25.0	20.0	Gasoline or E85	$3,100

CO2 Emissions: -1.0 g/mile (Large Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2006 FORD TAURUS

31 manufacturer communications from 12 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	4
160000 STRUCTURE	3
151300 SEAT BELTS:FRONT:RETRACTOR	1
171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH	1
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	1
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL	1
113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY	1
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	1

160000 STRUCTURE

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi

350000 EQUIPMENT

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo

160000 STRUCTURE

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

060000 ENGINE (PWS)

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061000 ENGINE AND ENGINE COOLING:ENGINE

060000 ENGINE AND ENGINE COOLING

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

EXTENDED WARRANTY COVERAGE FOR VEHICLES WITH HARD START WHEN OPERATING ON E85 FUEL, POWERTRAIN CONTROL MODULE (PCM) CALIBRATION. WARRANTY EXTENDED FOR 10 YEARS OR 100,000 MILES WHICH EVER COMES FIRST. SAMPLE CONSUMER LETTER ATTACHED. *KB

113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

FLEX FUEL - LONG CRANK/HARD START. *TT

060000 ENGINE AND ENGINE COOLING

SPARK KNOCK, HESITATION ABOVE 3000 RPM, LOSS OF POWER, MISFIRE, AND POSSIBLE ENGINE DAMAGE DUE TO DETONATION AND PRE-IGNITION - 3.0L-2V VULCAN GAS/FFV. *TT

060000 ENGINE AND ENGINE COOLING

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

POWER WINDOW CONCERNS - SERVICE TIP. *TT

171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

POWER LOCK CONCERNS - SERVICE TIP. *TT

151300 SEAT BELTS:FRONT:RETRACTOR

SAFETY BELT RETRACTION SPEED. *TT

060000 ENGINE AND ENGINE COOLING

NO START/HARD START/ROUGH RUNNING DURING COLD WEATHER - INCORRECT SEASONAL FUEL BLEND. *TT

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS. *TT

NHTSA Safety Investigations, FORD TAURUS

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2000

Speed control cable damage

On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the ... program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.Read more

PE, Closed , Model Year: 2004

Stuck throttle

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle b... ody attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation doRead more

EA, Closed , Model Year: 2002

Front Suspension Coil Spring Fracture

To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front... Read more

DP, Closed , Model Year: 2003

ENGINE STALLING FFV

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THA... Read more

EA, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF ... Read more

PE, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN AN... Read more

RP, Closed , Model Year: 2000

BRAKE/ACCELERATOR PEDAL APPLICATION

MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS... Read more

RQ, Closed , Model Year: 2000

BRAKE LIGHT SWITCH FAILURE

FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S AN... Read more

EA, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTH... Read more

PE, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.T... Read more

PE, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCE... Read more

PE, Closed , Model Year: 2000

BRAKE/ACCEL PEDAL SEPARATION

RQ, Closed , Model Year: 1993

FRONT SUSPENSION SPRING

There is no summary currently available

EA, Closed , Model Year: 1993

WINDSHIELD WIPER

ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the ... Read more

PE, Closed , Model Year: 1993

WINDSHIELD WIPER

ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING

RQ, Closed , Model Year: 1992

FRONT SUSPENSION SPRING BREAKAGE

FRONT SUSPENSION SPRINGS AY BREAK DUE TO MANUFACTURING CRACHS IN COMBINATION WITH CORROSION.

EA, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

RQ, Closed , Model Year: 1986

REAR LOWER SUBFRAME ASSEMBLY

TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE

PE, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.

EA, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

There is no summary currently available

EA, Closed , Model Year: 1992

HEADLIGHT FAILURE

EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OU... Read more

PE, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT ... Read more

PE, Closed , Model Year: 1993

HEADLIGHTS FAILURE

There is no summary currently available

DP, Closed , Model Year: 1987

ALLEGED DEFECTIVE TIE RODS

PE, Closed , Model Year: 1992

PLASTIC TRIM PANEL SEPARATION

There is no summary currently available

DP, Closed

POWER STEERING FLUID FIRES

EA, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

PE, Closed , Model Year: 1986

POLYCAST ROAD WHEEL CRACKS

There is no summary currently available

PE, Closed , Model Year: 1988

STEERING LCK-UP/IMPEDIMENT

There is no summary currently available

PE, Closed , Model Year: 1991

FAILURE OF WHEEL STUDS

There is no summary currently available

PE, Closed , Model Year: 1988

UNDERBODY FUEL LINE FAILS

There is no summary currently available

PE, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

EA, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1988

POWER STEERING LEAKS/FIRES

There is no summary currently available

PE, Closed , Model Year: 1988

ENGINE MOUNT FAILURE

There is no summary currently available

EA, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

===

DP, Closed , Model Year: 1991

ANTI-LOCK BRAKES

PE, Closed , Model Year: 1986

FIRES IN IGNITION SWITCH

There is no summary currently available

PE, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

There is no summary currently available

PE, Closed , Model Year: 1986

DOOR HANDLES BREAKAGE

There is no summary currently available

EA, Closed , Model Year: 1989

SEAT BELT BUCKLE FAILURE

There is no summary currently available

EA, Closed , Model Year: 1985

BRAKE DISC HUB SEPARATIONS

===

PE, Closed , Model Year: 1990

SAFETY BELT BUCKLE LOCKING

There is no summary currently available

PE, Closed , Model Year: 1990

WHEEL SEPARATION

There is no summary currently available

PE, Closed , Model Year: 1986

BRAKE DISC HUB FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

THROTTLE STICKING

There is no summary currently available

PE, Closed , Model Year: 1986

SPEED CONTROL FAILURE

There is no summary currently available

EA, Closed , Model Year: 1987

POWER SEAT MALFUNC/FIRE

There is no summary currently available

EA, Closed , Model Year: 1986

SAFETY BELT FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

SAFETY BELT FAILURE

===

PE, Closed , Model Year: 1987

PWR SEAT MALFUNC - FIRE

===

EA, Closed , Model Year: 1986

FRONT SEAT BRACKET

SUMMARY:THE LOSS OF VEHICLE CONTROL APPEARS TO BE THE POTENTIALCONSEQUENCE OF A SEAT BRACKET FAILURE.===

PE, Closed , Model Year: 1986

EXHAUST GAS INTRUSION

SUMMARY: OWNERS COMPLAIN OF EXHAUST GASES, INCLUDING HYDROGEN SULFIDE,LEAKING INTO THE PASSENGER COMPARTMENT CAUSING NAUSEA, HEADACHES, ANDDISCOMFORT.HYDROGEN SULFIDE (H2S) IS A COLORLESS, FLAMMABLE, ANDVERY POISONOUS GAS.===

PE, Closed , Model Year: 1986

FRONT SEAT BRACKET

BRIEFING NOTES ODISCUSSION OF THE REPORTED DEFECT & ITS CONSEQUENCES OFAILURE MILEAGE ANALYSIS OWARRANTY DATA ANALYSIS OFORD'S BODY & CHASSIS ENGINEERING REPORT OCOMPARISON WITH OTHER SEAT-TRACK ANALYSES===

PE, Closed , Model Year: 1986

HEAD REST DROPS

===

EA, Closed , Model Year: 1986

STALLING

===

PE, Closed , Model Year: 1986

HIGH BRAKE PEDAL EFFORT

===

PE, Closed , Model Year: 1986

STEERING BINDING

BASED ON AN ODI FAILURE REPORT ANALYSIS SHOWING 6 COMPLAINTS, 4 ACCIDENTSAND 3 INUJURIES, A PRELIMINARY EVALUATION WAS OPENED AND AN INFORMATIONREQUEST WAS SENT TO FORD.SUBSEQUENTLY, ODI RECEIVED 4 ADDITIONAL COM-PLAINTS.FURTHER INFORMATION WAS DEVELOPED WHICH LED TO DELETION OF 4COMPLAINTS AND THE ... Read more

DP, Closed , Model Year: 1981

SUDDEN ACCELERATION

FORD TAURUS - All Years Overview

Complete safety history for the FORD TAURUS across all model years (1986, 2019).

173 Total Recalls

24,046 Total Complaints

60 Investigations

1,466 Reported Crashes

697 Reported Fires

43 Reported Deaths

FORD TAURUS - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2019	2	19	View
2018	4	67	View
2017	4	53	View
2016	4	104	View
2015	6	356	View
2014	5	297	View
2013	9	755	View
2012	5	100	View
2011	4	251	View
2010	3	286	View
2009	0	77	View
2008	1	240	View
2007	1	196	View
2006 (current)	3	415
2005	1	1,005	View
2004	2	482	View
2003	4	1,524	View
2002	4	1,759	View
2001	10	1,264	View
2000	8	1,497	View
1999	7	1,100	View
1998	4	680	View
1997	5	1,003	View
1996	8	1,132	View
1995	6	1,597	View
1994	5	1,284	View
1993	8	2,206	View
1992	6	1,009	View
1991	5	946	View
1990	8	542	View
1989	7	762	View
1988	6	462	View
1987	9	355	View
1986	9	150	View
1985	0	2	View
1984	0	4	View
1983	0	1	View
1981	0	2	View
1977	0	2	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2006 FORD TAURUS

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2006 FORD TAURUS

Technical Service Bulletins, 2006 FORD TAURUS

Most Affected Components

NHTSA Safety Investigations, FORD TAURUS

FORD TAURUS - All Years Overview

FORD TAURUS - Year by Year

Other FORD Models