1992 FORD TAURUS

6 recalls, 1,009 complaints - 92 TSBs

STRUCTURE:FRAME AND MEMBERS

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANI... Read more

Consequence

IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

2,697,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

VEHICLE SPEED CONTROL

Defect Description

VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OH... Read more

Consequence

DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.

Remedy

DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.

212,700 vehicles affected

Manufacturer: FORD MOTOR COMPANY

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

Defect Description

THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENG... Read more

Consequence

THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.

Remedy

DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.

75,200 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SUSPENSION:FRONT:SHOCK ABSORBER

Defect Description

THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.

Consequence

OVER TIME, A PORTION OF THE BRACKET CAN TEAR AWAY FROM THE STRUT, FALLING INTO AND PUNCTURING THE TIRE OR CAUSING DAMAGE TO THE WHEEL, WHICH COULD RESULT IN AN ACCIDENT.

Remedy

MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.

98,000 vehicles affected

Manufacturer: MONROE AUTO CORP.

WHEELS

Defect Description

CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.

Consequence

THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.

Remedy

REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.

654,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT

Defect Description

MANUFACTURING ERRORS BY THE SUPPLIER OF THE LIFTGATE LATCH MECHANISM MAY CAUSE THE SECONDARY PORTION OF THE LIFTGATE LATCH NOT TO FUNCTION. IF THE LATCH IS NOT IN THE PRIMARY LATCH POSITION, THE LIFTGATE COULD OPEN WITHOUT OPERATOR ACTION.

Consequence

IF THE LIFTGATE WERE TO OPEN DURING VEHCILE OPERATION,PASSENGERS OR CARGO COULD FALL FROM THE OPEN LIFTGATE.

Remedy

REPLACE MALFUNCTIONING LIFTGATE LATCHES.

1,300 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

1,009 total complaints 62 crashes 26 fires 60 injuries 4 deaths

Top Reported Components

Component	Complaints
ENGINE AND ENGINE COOLING:ENGINE	152
POWER TRAIN:AUTOMATIC TRANSMISSION	74
STRUCTURE:FRAME AND MEMBERS	61
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	53
VEHICLE SPEED CONTROL	41
AIR BAGS:FRONTAL	32
ELECTRICAL SYSTEM:IGNITION	27
UNKNOWN OR OTHER	22
STEERING:LINKAGES:TIE ROD ASSEMBLY	20
VISIBILITY:WINDSHIELD WIPER/WASHER	19

Incident date: Nov 13, 2015

A CAR RAN A STOP SIGN, T-BONED ME ON FRONT PASS-SIDE PUSHING ME OFF THE ROAD TO THE LEFT. SEATBELT DID NOT RESTRAIN ME, BOTH AIRBAGS DEPLOYED, LEFT BAG BLEW SHRAPNEL CUTTING MY FACE AND INJURING MY RIGHT EYE.

Crash 2 injured

Incident date: Nov 13, 2015

Crash 2 injured

Incident date: Sep 30, 2012

TL* THE CONTACT OWNS A 1992 FORD TAURUS WITH GILLETTE SILVER BEAR (205/65R/15) TIRES (DOT E2URMYC2003). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH THE REAR PASSENGER SIDE TIRE BLEW OUT. THE DRIVER STOPPED THE VEHICLE ON THE SHOULDER OF THE ROAD AND REPLACED THE TIRE WITH THE SPARE T... Read more

Incident date: Apr 24, 2010

TL*THE CONTACT OWNS A 1992 FORD TAURUS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, HE HEARD A LOUD NOISE AND THE REAR CORNERS OF THE SUBFRAME FELL OFF OF THE VEHICLE. THE SUBFRAME BOLTS ON THE REAR END OF THE VEHICLE WERE COVERED WITH RUST WHICH CAUSED THE STEERING WHEEL TO BECOME UNSTABLE. ... Read more

Incident date: Apr 13, 2008

TL*THE CONTACT OWNS A 1992 FORD TAURUS. WHILE DRIVING 45 MPH, THE REAR MOUNTING ATTACHMENT FOR THE ENGINE CRADLE DETERIORATED ON BOTH SIDES OF THE VEHICLE. THE FAILURE WAS CAUSED BY ROAD SALT, DEBRIS, AND OTHER NATURAL MATERIALS. THE CONTACT NOTICED THAT THE FAILURE COULD CAUSE MAJOR SAFETY HAZAR... Read more

Incident date: Apr 13, 2008

Incident date: Mar 22, 2007

I BOUGHT 3 FORD TAURUS WAGONS IN 6 MONTHS AND THE SPRINGS BROKE IN ALL OF THE 3 LATEST CARS. BOTH SPRINGS BROKE WILE I WAS DRIVING ,PUNCTURING 1 TIRE. NO REPAIR MADE YET. *AK

1 injured

Incident date: May 1, 2006

K-FRAME(SUB FRAME)FELL. BOTH TIMES WHILE DRIVING, BUT BOTH TIMES AT LOW SPEEDS. FRAME FELL AND I COULD NOT STEER CAR. BOTH TIMES MY TRANSMISSION WAS SERVICED. 1ST TIME MAY, 2006, WAS DUE TO FAULTY BUSHINGS AND WASHERS. 2ND TIME, FRAME BROKE, RUSTED, GONE. ALL AT THE PRESCRIBED LOCATION AND PROBLEM T... Read more

Incident date: Sep 21, 2006

DT*: THE CONTACT STATED THE CHILD SAFETY SEAT WAS TOO VERTICAL WHEN INSTALLED IN THE VEHICLE BY A CHILD PASSENGER SAFETY TECHNICIAN, CAUSING THE HEAD OF THE INFANT TO JERK FORWARD UPON STOPPING THE VEHICLE. THE VEHICLE WAS TRAVELING 35 MPH WHEN IT WAS STOPPED UNDER NORMAL CIRCUMSTANCES. THE MANUFA... Read more

Incident date: Apr 3, 2006

1992 TAURUS STEERING PROBLEM. *TS

Incident date: Apr 7, 2006

DT*: THE CONTACT STATED THE VEHICLE BECAME DIFFICULT TO STEER AT ANY SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO REPLACED THE BODY MOUNTS AT THE REAR SUB FRAME. THE DEALER AND MANUFACTURER HAVE BEEN ALERTED AND AGREE THE VEHICLE IS INCLUDED IN THE NHTSA RECALL, # 98V323000 CONC... Read more

Incident date: Oct 2, 2005

DT*: THE CONTACT STATED WHILE DRIVING A SNAPPING NOISE WAS HEARD IN THE FRONT LEFT SIDE. THE VEHICLE WAS DRIVEN HOME WHERE IT WAS DETERMINE D THE LEFT FRONT TIRE WAS FLAT. THE SWAY BAR BRACKET TORE AWAY FROM THE STRUT AND PUNCTURED THE TIRE. THE REPAIR PERSONNEL SUGGESTED REPLACING THE SHOCK ABSORBE... Read more

Incident date: Jun 14, 2005

DT: 1992 FORD TAURUS. THE U SHAPED HOUSING THAT HOLDS UP THE ENGINE RUSTED. CONSUMER TOOK VEHICLE TO A MECHANIC, AND THEY TOLD HIM THAT IT WAS AN UNSAFE VEHICLE. THE RIGHT OUTER TIE ROD, ENGINE CRADLE RUSTED. ALSO, THE FRONT, EMERGENCY, SERVICE AND REAR BRAKES WERE NO GOOD, THE KEY BROKE... Read more

Incident date: Jun 14, 2005

Incident date: Apr 30, 2005

FORD TAURUS, 1992, FRONT K-FRAME BROKE LOOSE FROM CHASSIS RESULTING IN A LOCK-UP OF THE STEERING, FORTUNATELY AT A LOW SPEED, THEREBY ENDANGERING THE DRIVER AND PASSENGER OF THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE WE LEARNED THAT THIS WAS NOT UNUSUAL IN THE 1989-1994 FORD ... Read more

Incident date: Feb 2, 2005

THE VEHICLE IS A 1992 FORD TAURUS WAGON. ON JULY 26, 1996 THE COIL SPRINGS BROKE PUNCTURING THE FRONT TIRE WHILE BACKING OUT OF THE SERVICE DEPARTMENT OF MIDAS FOR AN OIL CHANGE. FORD AT THE TIME SAID THERE WERE NO RECALLS ON THE VEHICLE SO THEREFORE IT WAS REPAIRED AT MIDAS. THIS MORNING, FEBRUA... Read more

Incident date: Jan 1, 2003

CONSUMER IS AGAINST FORD MOTOR COMPANY. THE CONSUMER STATED FORD MAKES FAULTY CARS AND HIS CAR IS ONE OF THEM. THE CONSUMERS VEHICLE DID NOT GET GOOD GAS MILEAGE. THE VEHICLE HAD CONSTANT ENGINE AND TRANSMISSION FAILURE. THE SEAT WAS BROKEN, THE TIRE BLEW OUT, THE VEHICLE STALLED. *JB NAR 1/22/200... Read more

Incident date: Jan 1, 2003

Incident date: Aug 1, 2004

I WAS PROCEEDING AFTER WAITING FOR A TRAFFIC SIGNAL WHEN I HEARD A LOUD POP. I HESITATED FOR A MOMENT, THEN PROCEEDED SLOWLY AND DISCOVERED THAT IT WAS VERY DIFFICULT TO TURN THE STEERING WHEEL. I WAS ABLE TO PULL INTO A PARKING LOT; I CALLED AAA FOR SERVICE. AFTER THE CAR WAS HOISTED ONTO A FLAT... Read more

Incident date: Jul 1, 2003

MY 1992 FORD TAURUS JUST CUTS OFF; THE 1ST TIME THE CHECK ENGINE LIGHT CAME ON AND IT QUIT. I HAD THE CAR SERVED AND CHECKED. I'D DRIVE APPRX. 60 MILES AND IT WOULD HAPPEN AGAIN, THEN I WAS GOING BACK TO FLORIDA AND IT DID IT AGAIN, SO I TOOK IT TO ORANGE FORD IN ORANGE ,TEXAS AND THEY PUT IT ON THE... Read more

2 injured

Incident date: Jul 1, 2003

2 injured

Incident date: Jul 1, 2003

2 injured

Incident date: May 2, 2004

WHILE DRIVING 35 MPH TRAILING ARM BROKE WITHOUT WARNING. AS A RESULT, THE ENTIRE FRAME OF THE VEHICLE COLLAPSED ONTO THE TIRES. *AK

Incident date: Dec 15, 2002

COOLANT LEAKING INTO HEAD GASKET AND PISTON/CYLINDERS CAUSING ENGINE TO VAPOR LOCK AND FREEZE. WE BOUGHT A $900 EXTENDED WARRANTY ON THIS VEHICLE, AND WE HAD TO PAY A $95.00 DIAGNOSTIC FEE TO SEE WHAT WAS WRONG, HANSEL FORD IN SANTA ROSA, CALIFORNIA SAYS THAT WARRANTY WILL NOW ONLY COVER SPECIFIC PA... Read more

Incident date: Oct 15, 2003

HEAD GASKET/ TRANSMISSION FAILURE

Incident date: Oct 15, 2003

HEAD GASKET/ TRANSMISSION FAILURE

Incident date: Sep 15, 2000

THE ENGINE STALLS AT IDLE AND AT A STOP HOT OR COLD NUMEROUS ATTEMPTS BY MECHANICS DID NOT HELP THIS CAR IS A LEMON THEY ARE NOT KIDDING FORD DOES STAND FOR FIX OR REPAIR DAILY. SIGNED NEVER WILL BUY A FORD AGAIN

Incident date: Jun 15, 2001

IGNITION MODULE FAILED IN JUNE, 2001 AT 101,377 MILES AND NOW AGAIN IT HAS FAILED AT 113,000 MILES. THE FIRST TIME THE CAR JUST WOULDN'T START IN FRONT OF A BUILDING, THE SECOND TIME AT A CITY INTERSECTION AT MIDNIGHT. IN CHECKING WITH FORD CORP AND THE LOCAL FORD DEALER THEY HAVE NO HEAT DEFLECTOR,... Read more

Incident date: Mar 20, 2004

I HAVE OWNED THIS TAURUS SINCE, 1993-1994, IT HAD 43,000 MILES ON IT, FROM A DEALER (FLANNERY FORD). I HAVE HAD MOTOR MOUNTS REPLACED, WATER PUMPS (2) (ALMOST $1,000), BRAKES AND CALIPERS(TOO MANY TO REMEMBER), STRUTS (TOO MANY TO REMEMBER), IGNITION. THIS PAST SATURDAY, WHILE MY MOTHER WAS DRIVIN... Read more

Incident date: Mar 20, 2004

Incident date: Mar 11, 2004

WHILE DRIVING HIS HEADLIGHTS CAME ON AND OFF ON THEIR OWN. CONSUMER STATED THAT THIS PROBLEM SCARED HIM, ESPECIALLY DRIVING AT NIGHT DUE TO POOR VISIBILITY. *AK

Incident date: Jan 6, 2004

AFTER THE VEHICLE WAS SERVICED FOR RECALL 94E036000 FOR FRONT SHOCK ABSORBER, VEHICLE EXPERIENCED THE SAME PROBLEM . CONSUMER BOUGHT A USED VEHICLE. DEALER STATED NOTHING THEY COULD DO. COMPUTER SHOWED THE STRUTS WERE REPLACED.*AK

Incident date: Dec 22, 2003

MOTOR MOUNT FAILED. VIN: [XXX]. 1998 FORD TAURUS GL. CORROSION PROBLEM. SEE NHTSA RECALL NO. 98V323. ALTHOUGH THIS CAR WAS PURCHASED AND REGISTERED IN FL IT HAD BEEN DRIVEN IN NEW YORK FOR A CONSIDERABLE TIME IN THE EARLY YEARS. ALL OWNERS OF THIS VEHICLE AND NOT JUST THE OWNERS IN THE NORTH... Read more

Incident date: Dec 23, 2003

WHILE DRIVING AT ANY SPEED THE DRIVER HEARD A LOUD CLUNKY NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER. THE MECHANIC INDICATED THAT THE MOTOR MOUNTS WERE BROKE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM

Incident date: Nov 17, 2003

WHEN THE VEHICLE IDLES A THUMPING NOISE IS PRODUCED. *AK

Incident date: Jun 26, 2002

PASSENGER SEAT BELT DID NOT LOCK DURING AUTOMOBILE ACCIDENT. PASSENGER WAS INJURED, SUSTAINING A CERVICAL FRACTURE. *LA

Crash 2 injured

Incident date: Oct 31, 2003

I OWN A 92 FORD TAURUS WAGON LEFT TO ME BY MY NOW-DECEASED FATHER. HE HAD A RECALL DONE 3-99 FOR THE MOTOR MOUNT RECALL DONE. MY FATHER PASSED AWAY 12-99. SINCE THAT TIME I HAVE HAD A CONTINUING PROBLEM WITH THIS MOTOR MOUNT. IT IS NOW BROKEN AGAIN. IS THERE ANY WAY THIS PROBLEM CAN BE RECTIFIED... Read more

VEHICLE EXPERIENCED THE SAME DEFECT WITH SUB FRAME CORROSION AS STATED IN RECALL 98V323000. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK

VEHICLE EXPERIENCED THE SAME DEFECT WITH SUB FRAME CORROSION AS STATED IN RECALL 98V323000. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

Incident date: Aug 14, 2003

THE VEHICLE STALLED ALL AROUND TOWN BUT NOT ON THE HIGHWAY. *PH THE STALLING OCCURRED DAILY. NUMBER OF FAILURES WERE TOO NUMEROUS TO COUNT. *SCC POSSIBLE IGNITION PROBLEMS. *JB

Incident date: Sep 24, 2003

ENGINE MOUNTS BROKE. INDEPENDENT SHOP WILL REPLACED. PLEASE PROVIDE FURTHER INFORMATION. *AK

Incident date: Sep 12, 2003

WHILE DRIVING ABOUT 65 MPH ON THE HIGHWAY APPLYING THE BRAKE THE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR. THIS CAUSED THE VEHICLE TO STALL AND ANOTHER VEHICLE HIT THE CONSUMER FROM BEHIND. THE DRIVER AND PASSENGER WAS TRANSPORTED BY AMBULANCE. THERE WERE NO FATALITIES. PLEASE PROVIDE DETAILS. ... Read more

Crash 2 injured

Showing 50 of 1,009 complaints.

EPA Fuel Economy, 1992 FORD TAURUS

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.0L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	26.0	21.0	Regular	$2,950
3.8L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	16.0	26.0	19.0	Regular	$3,250

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 1992 FORD TAURUS

92 manufacturer communications from 83 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	8
061000 ENGINE AND ENGINE COOLING:ENGINE	6
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	5
100000 POWER TRAIN	4
138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR	4
980000 UNKNOWN OR OTHER	3
136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR	3
034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	3

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH

125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT

103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

BRAKE SHIFT INTERLOCK.*JB

980000 UNKNOWN OR OTHER

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

138600 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC

061000 ENGINE AND ENGINE COOLING:ENGINE

ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

THIS INFORMATION IS A SUPPLEMENT TO THE WIPER SYSTEM SERVICE INFORMATION PROVIDED IN THE WORKSHOP MANUALS. THIS SERVICE INFORMATION IS INTENDED AS AN AID TO ASSIST IN DIAGNOSIS AND REPAIR OF ERRATIC WIPER SYSTEM CONDITIONS.

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

INFORMATION ON ADDITIONAL PARTS REQUIRED WHEN REPLACING TRANSFER CASE ON VEHICLES EQUIPPPED WITH AX4S TRANSAXLE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS

114000 ELECTRICAL SYSTEM:WIRING

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT

125000 EXTERIOR LIGHTING:BRAKE LIGHTS

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT

017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT

017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT

101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT

110000 ELECTRICAL SYSTEM

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK

100000 POWER TRAIN

VEHICLES MAY EXPERIENCE SPEEDOMETER POINTER WAVER. *TT

100000 POWER TRAIN

VEHICLES MAY EXHIBIT SPEEDOMETER POINTER WAVER. *MJS

100000 POWER TRAIN

INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS

102000 POWER TRAIN:MANUAL TRANSMISSION

TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

A NEW SILICONE GASKET AND SEALANT. *YC

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT

190000 TIRES

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC

106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC

354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

SOME VEHICLES MAY CYCLE WHEN BRAKES ARE APPLIED ON ROUGH ROADS OR ON AN INCLINE WHILE MAKING A SHARP TURN. *YC

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

CONCERNS WITH COOLANT MAY LEAK FROM THE HEAD GASKETS AND / OR THE VEHICLE MAY OVERHEAT. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING THE THE AVAILABILITY OF THE REVISED HEADGASKET FOR COOLANT LOSS CONDITIONS ON SOME ENGINES. *TT

980000 UNKNOWN OR OTHER

CONDITIONS WITH THE MALFUNCTIONING OF THE INDICATOR LAMP.

113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC

100000 POWER TRAIN

CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD

061000 ENGINE AND ENGINE COOLING:ENGINE

BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD

980000 UNKNOWN OR OTHER

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD

061000 ENGINE AND ENGINE COOLING:ENGINE

BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD

015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

SOME POWER STEERING HOSES HAVE BEEN REPLACED WITH A REVISED DESIGN AND SHOULD NO LONGER BE USED FOR SERVICE. *JD

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW

114000 ELECTRICAL SYSTEM:WIRING

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW

101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

VEHICLE MAY EXHIBIT A CHATTER WHEN RELEASING THE CLUTCH IN REVERSE GEAR. *TW

102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT

131000 VISIBILITY:WINDSHIELD

WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW

075000 FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES. *TT

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN. *TT

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

SOME VEHICLES MAY EXPERIENCE THE AIR BAG DIAGNOSTIC LIGHT FLASHING. *TT

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PAR

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

A 'GROANING' NOISE MAY COME FROM THE FRONT POWER WINDOWS AFTER THE GLASS IS POWERED FULL UP. THIS NOISE IS CAUSED BY IMPROPER LUBRICATION ON THE WINDOW REGULATOR MECHANISM SLIDING SURFACES. THE GREASE GETS WIPED OFF FROM SLIDING SURFACES D

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

THE POWER STEERING SYSTEM MAY HAVE A 'GRUNT' AND/OR 'GROAN' NOISE. THIS MAY BE CAUSED BY HYDRAULIC FLUID MOVEMENT WITHIN THE POWER STEERING RACK.

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

THE TORQUE CONVERTER IDENTIFICATION CODES HAVE BEEN REVISED AS OF 3/1/95. *SD

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS. *SD

061000 ENGINE AND ENGINE COOLING:ENGINE

SUPPLEMENT TO ONP92M77 - PROGRAM EXPANDED TO INCLUDE 1992/93 FORD TAURUS AND MERCURY SABLES. *TW

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

KNOCKING NOISE FROM THE LOWER FRONT OF THE ENGINE. *TW

138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

UNKNOWN

151100 SEAT BELTS:FRONT:ANCHORAGE

UNKNOWN

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

UNKNOWN

022000 SUSPENSION:REAR

PREMATURE WEAR ON INNER EDGES OF REAR TIRES MAY BE CAUSED BY REAR CAMBER AND TOE SETTINGS THAT ARE NOT WITHIN SPECIFICATION. *TW

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

UNKNOWN

138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

UNKNOWN

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

UNKNOWN

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

UNKNOWN

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

UNKNOWN

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

UNKNOWN

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

UNKNOWN

022000 SUSPENSION:REAR

UNKNOWN

138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW

138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

WIPER MOTOR REPLACEMENT - UPGRADED SERVICE KITS. *TW

021000 SUSPENSION:FRONT

RATTLING OR CLUNKING NOISE FROM THE FRON SUSPENSION. *TW

021000 SUSPENSION:FRONT

PREMATURE WEAR ON THE INNER EDGES OF REAR TIRES. *TW

070000 FUEL SYSTEM, GASOLINE

ERRATIC DISTANCE-TO-EMPTY AND FUEL GAUGE READINGS. *TW

113100 ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID

SOME VEHICLES MAY EXHIBIT A NO-CRANK CONDITION DUE TO CORROSION AT THE STARTER SOLENOID CONNECTOR. *TW

021400 SUSPENSION:FRONT:MACPHERSON STRUT

VEHICLES MAY EXHIBIT A CLICKING NOISE FROM THE FRONT STRUTS. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THE FORWARD CLUTCH PISTON MAY CRACK ON ITS OUTSIDE DIAMETER. *TW

NHTSA Safety Investigations, FORD TAURUS

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2000

Speed control cable damage

On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the ... program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.Read more

PE, Closed , Model Year: 2004

Stuck throttle

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle b... ody attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation doRead more

EA, Closed , Model Year: 2002

Front Suspension Coil Spring Fracture

To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front... Read more

DP, Closed , Model Year: 2003

ENGINE STALLING FFV

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THA... Read more

EA, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF ... Read more

PE, Closed , Model Year: 2000

REAR COIL SPRING FRACTURE

THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN AN... Read more

RP, Closed , Model Year: 2000

BRAKE/ACCELERATOR PEDAL APPLICATION

MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS... Read more

RQ, Closed , Model Year: 2000

BRAKE LIGHT SWITCH FAILURE

FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S AN... Read more

EA, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTH... Read more

PE, Closed , Model Year: 2000

FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH

FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.T... Read more

PE, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCE... Read more

PE, Closed , Model Year: 2000

BRAKE/ACCEL PEDAL SEPARATION

RQ, Closed , Model Year: 1993

FRONT SUSPENSION SPRING

There is no summary currently available

EA, Closed , Model Year: 1993

WINDSHIELD WIPER

ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the ... Read more

PE, Closed , Model Year: 1993

WINDSHIELD WIPER

ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING

RQ, Closed , Model Year: 1992

FRONT SUSPENSION SPRING BREAKAGE

FRONT SUSPENSION SPRINGS AY BREAK DUE TO MANUFACTURING CRACHS IN COMBINATION WITH CORROSION.

EA, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY

RQ, Closed , Model Year: 1986

REAR LOWER SUBFRAME ASSEMBLY

TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE

PE, Closed , Model Year: 1993

FRONT SUSPENSION COIL SPRING FAILURE

Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.

EA, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

There is no summary currently available

EA, Closed , Model Year: 1992

HEADLIGHT FAILURE

EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OU... Read more

PE, Closed , Model Year: 1991

ENGINE COOLING FAN FIRES

IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT ... Read more

PE, Closed , Model Year: 1993

HEADLIGHTS FAILURE

There is no summary currently available

DP, Closed , Model Year: 1987

ALLEGED DEFECTIVE TIE RODS

PE, Closed , Model Year: 1992

PLASTIC TRIM PANEL SEPARATION

There is no summary currently available

DP, Closed

POWER STEERING FLUID FIRES

EA, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

PE, Closed , Model Year: 1986

POLYCAST ROAD WHEEL CRACKS

There is no summary currently available

PE, Closed , Model Year: 1988

STEERING LCK-UP/IMPEDIMENT

There is no summary currently available

PE, Closed , Model Year: 1991

FAILURE OF WHEEL STUDS

There is no summary currently available

PE, Closed , Model Year: 1988

UNDERBODY FUEL LINE FAILS

There is no summary currently available

PE, Closed , Model Year: 1987

BROKEN TIE RODS

There is no summary currently available

EA, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1986

SUB-FRM/UNIBODY ABSOR.FAIL

There is no summary currently available

PE, Closed , Model Year: 1988

POWER STEERING LEAKS/FIRES

There is no summary currently available

PE, Closed , Model Year: 1988

ENGINE MOUNT FAILURE

There is no summary currently available

EA, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

===

DP, Closed , Model Year: 1991

ANTI-LOCK BRAKES

PE, Closed , Model Year: 1986

FIRES IN IGNITION SWITCH

There is no summary currently available

PE, Closed , Model Year: 1986

STORAGE COMPAR SUFFOCATION

There is no summary currently available

PE, Closed , Model Year: 1986

DOOR HANDLES BREAKAGE

There is no summary currently available

EA, Closed , Model Year: 1989

SEAT BELT BUCKLE FAILURE

There is no summary currently available

EA, Closed , Model Year: 1985

BRAKE DISC HUB SEPARATIONS

===

PE, Closed , Model Year: 1990

SAFETY BELT BUCKLE LOCKING

There is no summary currently available

PE, Closed , Model Year: 1990

WHEEL SEPARATION

There is no summary currently available

PE, Closed , Model Year: 1986

BRAKE DISC HUB FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

THROTTLE STICKING

There is no summary currently available

PE, Closed , Model Year: 1986

SPEED CONTROL FAILURE

There is no summary currently available

EA, Closed , Model Year: 1987

POWER SEAT MALFUNC/FIRE

There is no summary currently available

EA, Closed , Model Year: 1986

SAFETY BELT FAILURE

There is no summary currently available

PE, Closed , Model Year: 1986

SAFETY BELT FAILURE

===

PE, Closed , Model Year: 1987

PWR SEAT MALFUNC - FIRE

===

EA, Closed , Model Year: 1986

FRONT SEAT BRACKET

SUMMARY:THE LOSS OF VEHICLE CONTROL APPEARS TO BE THE POTENTIALCONSEQUENCE OF A SEAT BRACKET FAILURE.===

PE, Closed , Model Year: 1986

EXHAUST GAS INTRUSION

SUMMARY: OWNERS COMPLAIN OF EXHAUST GASES, INCLUDING HYDROGEN SULFIDE,LEAKING INTO THE PASSENGER COMPARTMENT CAUSING NAUSEA, HEADACHES, ANDDISCOMFORT.HYDROGEN SULFIDE (H2S) IS A COLORLESS, FLAMMABLE, ANDVERY POISONOUS GAS.===

PE, Closed , Model Year: 1986

FRONT SEAT BRACKET

BRIEFING NOTES ODISCUSSION OF THE REPORTED DEFECT & ITS CONSEQUENCES OFAILURE MILEAGE ANALYSIS OWARRANTY DATA ANALYSIS OFORD'S BODY & CHASSIS ENGINEERING REPORT OCOMPARISON WITH OTHER SEAT-TRACK ANALYSES===

PE, Closed , Model Year: 1986

HEAD REST DROPS

===

EA, Closed , Model Year: 1986

STALLING

===

PE, Closed , Model Year: 1986

HIGH BRAKE PEDAL EFFORT

===

PE, Closed , Model Year: 1986

STEERING BINDING

BASED ON AN ODI FAILURE REPORT ANALYSIS SHOWING 6 COMPLAINTS, 4 ACCIDENTSAND 3 INUJURIES, A PRELIMINARY EVALUATION WAS OPENED AND AN INFORMATIONREQUEST WAS SENT TO FORD.SUBSEQUENTLY, ODI RECEIVED 4 ADDITIONAL COM-PLAINTS.FURTHER INFORMATION WAS DEVELOPED WHICH LED TO DELETION OF 4COMPLAINTS AND THE ... Read more

DP, Closed , Model Year: 1981

SUDDEN ACCELERATION

FORD TAURUS - All Years Overview

Complete safety history for the FORD TAURUS across all model years (1986, 2019).

173 Total Recalls

24,046 Total Complaints

60 Investigations

1,466 Reported Crashes

697 Reported Fires

43 Reported Deaths

FORD TAURUS - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2019	2	19	View
2018	4	67	View
2017	4	53	View
2016	4	104	View
2015	6	356	View
2014	5	297	View
2013	9	755	View
2012	5	100	View
2011	4	251	View
2010	3	286	View
2009	0	77	View
2008	1	240	View
2007	1	196	View
2006	3	415	View
2005	1	1,005	View
2004	2	482	View
2003	4	1,524	View
2002	4	1,759	View
2001	10	1,264	View
2000	8	1,497	View
1999	7	1,100	View
1998	4	680	View
1997	5	1,003	View
1996	8	1,132	View
1995	6	1,597	View
1994	5	1,284	View
1993	8	2,206	View
1992 (current)	6	1,009
1991	5	946	View
1990	8	542	View
1989	7	762	View
1988	6	462	View
1987	9	355	View
1986	9	150	View
1985	0	2	View
1984	0	4	View
1983	0	1	View
1981	0	2	View
1977	0	2	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1992 FORD TAURUS

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 1992 FORD TAURUS

Technical Service Bulletins, 1992 FORD TAURUS

Most Affected Components

NHTSA Safety Investigations, FORD TAURUS

FORD TAURUS - All Years Overview

FORD TAURUS - Year by Year

Other FORD Models