SEATS
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
4 vehicles affected
VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
1,657 vehicles affected
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
24,358 vehicles affected
AIR BAGS
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
955,344 vehicles affected
EQUIPMENT:OTHER:LABELS
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
35,692 vehicles affected
FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
Remedy: WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.
68,563 vehicles affected
STRUCTURE
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
3,674 vehicles affected
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
1,163,000 vehicles affected
The contact owns a 2000 Dodge Grand Caravan. The contact stated that while driving at 55 MPH, there was an abnormal noise and noticed that the vehicle's windshield wiper and blinkers had become inoperable. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty wiper transmission linkage, a relay, and a switch. The relay and switch were replaced however, the wiper transmission linkage was not repaired due to parts not being available. The manufacturer was made aware of the failure and determined that parts were not available. The failure mileage was approximately 110.000
The contact owns a 2000 Dodge Grand Caravan. The contact stated that while driving at 55 MPH, there was an abnormal noise and noticed that the vehicle's windshield wiper and blinkers had become inoperable. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty wiper transmission linkage, a relay, and a switch. The relay and switch were replaced however, the wiper transmission linkage was not repaired due to parts not being available. The manufacturer was made aware of the failure and determined that parts were not available. The failure mileage was approximately 110.000
Fuel leak under vehicle. Possible fire. There are several recalls on 2000 dodge caravan, but none supposedly associated with this VIN. The van only has 45,000 miles on it.
At 65+ the back door alarm sounds and keeps sounding when doing freeway speeds.
2 injured
I was driving at 75 MPH on an Interstate Highway. The 3.3 liter V6 engine, with 120,800 miles on it, threw a rod and cracked a 3 to 4" diameter hole in the block. I have cared for this car religiously for 14 years. It had full oil level. It is available for the next couple of weeks for examination if desired. I was able to get off the highway onto the shoulder safely.
AIRBAG WARNING LIGHT STAYS ON WHEN ENGINE STARTS.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. IN ADDITION, THE BATTERY AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK THE VEHICLE IN A NEARBY PARKING LOT. WHEN THE IGNITION WAS STARTED, THE TEMPERATURE GAUGE INCREASED. THE CONTACT TURNED OFF THE IGNITION AND ALLOWED THE VEHICLE TO COOL DOWN FOR AWHILE. AFTERWARDS, THE VEHICLE WAS RESTARTED AND THE CONTACT CONTINUED DRIVING 15 MPH TO HIS RESIDENCE. THE CONTACT NOTICED THAT THE STEERING WHEEL BELT WAS LOOSE. THE CONTACT CALLED LITHIA CHRYSLER JEEP OF RENO (LOCATED AT 1050 E PLUMB LN #100, RENO, NV 89502, (775) 501-8593) AND INFORMED THEM OF THE FAILURE. THE CONTACT SCHEDULED AN APPOINTMENT WITH AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000.
THE CHECK ENGINE LIGHT AND ABS LIGHT KEEP COMING ON AND THE LIGHT KEEP GOING OFF ON THE DASH BOARD FOR I BOUGHT THE VEHICLE WHILE DRIVING
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 50 MPH WITH A FULL TANK OF FUEL, THE FUEL GAUGE DISPLAYED AS EMPTY. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND DEPRESSED THE RESET BUTTON SINCE THE VEHICLE HAD JUST BEEN FUELED. THE VEHICLE WAS RESTARTED AND OPERATED NORMALLY, BUT THE FAILURE RECURRED APPROXIMATELY EIGHT OTHER TIMES IN A FOUR MONTH PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RADIATOR NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AND THE REVOLUTIONS PER MINUTE DECREASED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 180,000.
STRUT TOWERS ON MY 2000 DODGE GRAND CARAVAN HAVE RUSTED THROUGH. VISIBLE, SIGNIFICANT RUST HAS BEEN PRESENT FOR AT LEAST 7 YEARS, HOWEVER, IT IS NOW NOT DRIVEABLE. I DID NOT REALIZE THIS IS SUCH A BROADSCALE, SIGNIFICANT PROBLEM TO MOST OWNERS OF 1996-2000 VANS. PLEASE RECALL THIS MESS! STRUT TOWERS ARE NOT COSMETIC!
Crash
FUEL GAGE DON'T WORK AFTER FUEL PUMP REPLACEMENT,,,,GASOLINE SPILLED ALL OVER ROAD
FUEL GAGE DON'T WORK AFTER FUEL PUMP REPLACEMENT,,,,GASOLINE SPILLED ALL OVER ROAD
THE SERPENTINE BELT ON 96-2000 CHRYSLER MINIVANS SLIPPING OFF IS A KNOWN ISSUE AND HAS BEEN FOR YEARS. TIME AND TIME AGAIN CHRYSLER HAS REFUSED TO ISSUE A RECALL FOR IT. IT IS DUE TO A MANUFACTURING DEFECT IN ONE OF THE ENGINE MOUNTS CAUSING A PULLEY MISALIGNMENT. THE BELT SLIPPING OFF CAUSES LOSS OF POWER STEERING, WATER PUMP, AND ALTERNATOR. THE POWER STEERING LOSS CAN CAUSE A DRIVER TO NOT BE ABLE TO CORRECT IN TIME AND CAUSE AN ACCIDENT. THE LOSS OF THE WATER PUMP CAN CAUSE OVERHEATING RESULTING IN ENGINE DAMAGE. THE LOSS OF THE ALTERNATOR CAN CAUSE THE CAR TO EVENTUALLY STOP RUNNING WHEN THE BATTERY IS DRAINED, CAUSING MOTORISTS TO BE STRANDED. I LIVE IN ALASKA AND I'M NOT ALWAYS IN CELLULAR SIGNAL WHEN DRIVING AND TEMPERATURES IN THE WINTER GET DOWN TO -30 F AT TIMES. I CAN'T WAIT SOMETIMES SEVERAL HOURS FOR A TOW TRUCK TO GET TO ME WITHOUT RISKING HYPOTHERMIA AT THOSE TEMPERATURES. THIS NEEDS TO BE MADE INTO A RECALL SO IT CAN GET FIXED.
THE SERPENTINE BELT ON 96-2000 CHRYSLER MINIVANS SLIPPING OFF IS A KNOWN ISSUE AND HAS BEEN FOR YEARS. TIME AND TIME AGAIN CHRYSLER HAS REFUSED TO ISSUE A RECALL FOR IT. IT IS DUE TO A MANUFACTURING DEFECT IN ONE OF THE ENGINE MOUNTS CAUSING A PULLEY MISALIGNMENT. THE BELT SLIPPING OFF CAUSES LOSS OF POWER STEERING, WATER PUMP, AND ALTERNATOR. THE POWER STEERING LOSS CAN CAUSE A DRIVER TO NOT BE ABLE TO CORRECT IN TIME AND CAUSE AN ACCIDENT. THE LOSS OF THE WATER PUMP CAN CAUSE OVERHEATING RESULTING IN ENGINE DAMAGE. THE LOSS OF THE ALTERNATOR CAN CAUSE THE CAR TO EVENTUALLY STOP RUNNING WHEN THE BATTERY IS DRAINED, CAUSING MOTORISTS TO BE STRANDED. I LIVE IN ALASKA AND I'M NOT ALWAYS IN CELLULAR SIGNAL WHEN DRIVING AND TEMPERATURES IN THE WINTER GET DOWN TO -30 F AT TIMES. I CAN'T WAIT SOMETIMES SEVERAL HOURS FOR A TOW TRUCK TO GET TO ME WITHOUT RISKING HYPOTHERMIA AT THOSE TEMPERATURES. THIS NEEDS TO BE MADE INTO A RECALL SO IT CAN GET FIXED.
THE SERPENTINE BELT ON 96-2000 CHRYSLER MINIVANS SLIPPING OFF IS A KNOWN ISSUE AND HAS BEEN FOR YEARS. TIME AND TIME AGAIN CHRYSLER HAS REFUSED TO ISSUE A RECALL FOR IT. IT IS DUE TO A MANUFACTURING DEFECT IN ONE OF THE ENGINE MOUNTS CAUSING A PULLEY MISALIGNMENT. THE BELT SLIPPING OFF CAUSES LOSS OF POWER STEERING, WATER PUMP, AND ALTERNATOR. THE POWER STEERING LOSS CAN CAUSE A DRIVER TO NOT BE ABLE TO CORRECT IN TIME AND CAUSE AN ACCIDENT. THE LOSS OF THE WATER PUMP CAN CAUSE OVERHEATING RESULTING IN ENGINE DAMAGE. THE LOSS OF THE ALTERNATOR CAN CAUSE THE CAR TO EVENTUALLY STOP RUNNING WHEN THE BATTERY IS DRAINED, CAUSING MOTORISTS TO BE STRANDED. I LIVE IN ALASKA AND I'M NOT ALWAYS IN CELLULAR SIGNAL WHEN DRIVING AND TEMPERATURES IN THE WINTER GET DOWN TO -30 F AT TIMES. I CAN'T WAIT SOMETIMES SEVERAL HOURS FOR A TOW TRUCK TO GET TO ME WITHOUT RISKING HYPOTHERMIA AT THOSE TEMPERATURES. THIS NEEDS TO BE MADE INTO A RECALL SO IT CAN GET FIXED.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING THE VEHICLE ON SEVERAL OCCASIONS, THE SERPENTINE BELT DETACHED FROM THE DRIVE PULLEY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC WAS ABLE TO PLACE THE SERPENTINE BELT BACK ON THE DRIVE PULLEY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE FAILURE RECURRED SEVERAL TIMES ONLY WHILE IT WAS RAINING. THE CONTACT ALSO STATED THAT THE CLOCK SPRING IN THE STEERING WHEEL FAILED, WHICH CAUSED THE HORN TO FAIL AND THE FRONT DRIVER'S AIR BAG TO BECOME INOPERABLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 186,425.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING THE VEHICLE ON SEVERAL OCCASIONS, THE SERPENTINE BELT DETACHED FROM THE DRIVE PULLEY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC WAS ABLE TO PLACE THE SERPENTINE BELT BACK ON THE DRIVE PULLEY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE FAILURE RECURRED SEVERAL TIMES ONLY WHILE IT WAS RAINING. THE CONTACT ALSO STATED THAT THE CLOCK SPRING IN THE STEERING WHEEL FAILED, WHICH CAUSED THE HORN TO FAIL AND THE FRONT DRIVER'S AIR BAG TO BECOME INOPERABLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 186,425.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING THE VEHICLE ON SEVERAL OCCASIONS, THE SERPENTINE BELT DETACHED FROM THE DRIVE PULLEY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC WAS ABLE TO PLACE THE SERPENTINE BELT BACK ON THE DRIVE PULLEY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE FAILURE RECURRED SEVERAL TIMES ONLY WHILE IT WAS RAINING. THE CONTACT ALSO STATED THAT THE CLOCK SPRING IN THE STEERING WHEEL FAILED, WHICH CAUSED THE HORN TO FAIL AND THE FRONT DRIVER'S AIR BAG TO BECOME INOPERABLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 186,425.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CLOCK SPRING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 238,000.
I HAVE A DODGE RICON ACTIVAN WHEELCHAIR VAN. IT IS A 2000 MODEL. I PURCHASED IT WITH ONLY 29000 MILES. AFTER DRIVING THE VAN FOR 60 MILES IT WILL START STALLING, LOOSES POWER AND DIE. THIS HAS HAPPENED TO ME 3 TIMES. THE FIRST TIME IT HAPPENED I HAD MY SON WITH ME (HE HAS SPASTIC QUAD CEREBRAL PALSY) WE BROKE DOWN NEXT TO A DODGE DEALERSHIP. GETTING MY SON HOME WAS A NIGHTMARE. THE DODGE DEALERSHIP WORKED ON THE VAN. YET,THE PROBLEM IS STILL THERE. AFTER 60 MILES IT STALLS AND DIES. ON SATURDAY I WAS BROKEN DOWN WITH MY CHILD ON THE INTERSTATE.IT WAS 92 DEGREES OUT SIDE, HOW HORRIFIC. I CAN SEE IF THE VAN HAD 100,000 MILES TO HAVE ISSUES. I WAS FORTUNATE TO GET THE VAN PULLED TO THE SIDE OF THE ROAD, IF NOT WE WOULD HAVE BEEN HIT AND KILLED.THIS IS A ISSUE THAT NEEDS RECALLED. THIS IS A SAFETY ISSUE.
I HAVE A DODGE RICON ACTIVAN WHEELCHAIR VAN. IT IS A 2000 MODEL. I PURCHASED IT WITH ONLY 29000 MILES. AFTER DRIVING THE VAN FOR 60 MILES IT WILL START STALLING, LOOSES POWER AND DIE. THIS HAS HAPPENED TO ME 3 TIMES. THE FIRST TIME IT HAPPENED I HAD MY SON WITH ME (HE HAS SPASTIC QUAD CEREBRAL PALSY) WE BROKE DOWN NEXT TO A DODGE DEALERSHIP. GETTING MY SON HOME WAS A NIGHTMARE. THE DODGE DEALERSHIP WORKED ON THE VAN. YET,THE PROBLEM IS STILL THERE. AFTER 60 MILES IT STALLS AND DIES. ON SATURDAY I WAS BROKEN DOWN WITH MY CHILD ON THE INTERSTATE.IT WAS 92 DEGREES OUT SIDE, HOW HORRIFIC. I CAN SEE IF THE VAN HAD 100,000 MILES TO HAVE ISSUES. I WAS FORTUNATE TO GET THE VAN PULLED TO THE SIDE OF THE ROAD, IF NOT WE WOULD HAVE BEEN HIT AND KILLED.THIS IS A ISSUE THAT NEEDS RECALLED. THIS IS A SAFETY ISSUE.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING 5 MPH IN THE RAIN, THE BELT ON THE ENGINE OF THE VEHICLE DISENGAGED. THE CONTACT STATED THAT THE FAILURE RECURRED EVERY TIME IT RAINED OR WHEN THE VEHICLE WAS DRIVEN THROUGH WATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC; HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT 50 MPH, THE HORN AND CRUISE CONTROL FAILED TO FUNCTION AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT 50 MPH, THE HORN AND CRUISE CONTROL FAILED TO FUNCTION AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT 50 MPH, THE HORN AND CRUISE CONTROL FAILED TO FUNCTION AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SHOCK SUPPORT AND THE FRAMING NEAR THE FRONT OF THE VEHICLE WAS RUSTED TO THE POINT OF CORROSION. THE CONTACT MENTIONED THAT THE SPRINGS WERE FAULTY AND DETERIORATED NEAR THE SHOCK SUPPORT AND THE FRAMING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUPPORT SYSTEM ON THE DRIVER SIDE FAILED AND THE SUPPORT BRACKETS NEEDED TO BE REPLACED IN THE FRONT OF THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS); HOWEVER, THE CONTACT WAS NOT NOTIFIED OF THE SAFETY RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SHOCK SUPPORT AND THE FRAMING NEAR THE FRONT OF THE VEHICLE WAS RUSTED TO THE POINT OF CORROSION. THE CONTACT MENTIONED THAT THE SPRINGS WERE FAULTY AND DETERIORATED NEAR THE SHOCK SUPPORT AND THE FRAMING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUPPORT SYSTEM ON THE DRIVER SIDE FAILED AND THE SUPPORT BRACKETS NEEDED TO BE REPLACED IN THE FRONT OF THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS); HOWEVER, THE CONTACT WAS NOT NOTIFIED OF THE SAFETY RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HORN FAILED TO OPERATE AND THE AIRBAG LIGHT ILLUMINATED SPORADICALLY. ALSO, THE CRUISE CONTROL FEATURE WAS DISABLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 162,721.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HORN FAILED TO OPERATE AND THE AIRBAG LIGHT ILLUMINATED SPORADICALLY. ALSO, THE CRUISE CONTROL FEATURE WAS DISABLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 162,721.
I HAVE A 2000 DODGE GRAND CARAVAN SPORT, THE SERPENTINE BELT HAS FALLEN OFF 4 TIMES SINCE I HAVE HAD THE VEHICLE. THE FIRST TIME IT CAME OFF I WAS GOING 35 MPH IN A RESIDENTIAL AREA, A FRIEND HELPED MY DAD PUT THE BELT BACK ON, THEN A FEW DAYS LATER IT CAME OFF AGAIN GOING 55/60 MPH, TOOK IT TO A LOCAL MECHANIC AND HAD THE WATER PUMP, SERPENTINE BELT AND TENSIONER PULLEY REPLACED. ABOUT ONE TO TWO WEEK(S) LATER THE BELT FALLS OFF AGAIN DURING EXCELLERATION TO GET ONTO AN EXPRESS WAY, THIS TIME TOOK IT BACK IN AND THEY REPLACED THE TENSIONER ITSELF. I THOUGHT THE PROBLEM WAS FIXED, BUT IT HAPPENED AGAIN ON AUGUST 12, 2014, IT WAS RAINING AND I WAS ONLY GOING 25 MPH AS I TURNED ONTO MY STREET, LUCKILY I WAS ABLE TO PULL INTO THE DRIVE WAY BEFORE MY VAN STARTED TO OVERHEAT. *TR
I BOUGHT A 2000 DODGE GRAND CARAVAN NEW IN NOVEMBER OF 2000. IT NOW HAS 244,000 MILES AND STILL RUNS VERY GOOD. I TAKE CARE OF IT AND DO MOST NEEDED REPAIRS MYSELF. I NOTICED A FEW YEARS AGO, SOME RUST FORMING AT THE TOP OF THE STRUT TOWERS NEVER KNOWING OF THE SERVICE BULLETIN ISSUED BY CHRYSLER/DODGE ON OCTOBER 14, 2002 - BULLETIN # 23-044-02. I WOULD HAVE PAID MORE ATTENTION TO THIS ISSUE IF I WOULD HAVE KNOWN ABOUT THE BULLETIN AT THE TIME IT WAS ISSUED. LAST FRIDAY JUNE 20TH, I WAS PULLING INTO THE PARKING LOT AT MY OFFICE AND THE STRUT TOWER ACTUALLY SNAPPED IN HALF, NOT AT THE TOP WHERE THE RUST WAS! I'VE NEVER SEEN THIS HAPPEN ON ANY VEHICLE BEFORE. THANK GOODNESS I WAS ONLY TRAVELING ABOUT 10 MPH WHEN IT HAPPENED. THE BOTTOM LINE IS THAT I SHOULD HAVE BEEN MADE AWARE OF THIS VERY SERIOUS SAFETY ISSUE 12 YEARS AGO AND THIS SHOULD HAVE BEEN A RECALL, NOT A SERVICE BULLETIN. *TR
I BOUGHT A 2000 DODGE GRAND CARAVAN NEW IN NOVEMBER OF 2000. IT NOW HAS 244,000 MILES AND STILL RUNS VERY GOOD. I TAKE CARE OF IT AND DO MOST NEEDED REPAIRS MYSELF. I NOTICED A FEW YEARS AGO, SOME RUST FORMING AT THE TOP OF THE STRUT TOWERS NEVER KNOWING OF THE SERVICE BULLETIN ISSUED BY CHRYSLER/DODGE ON OCTOBER 14, 2002 - BULLETIN # 23-044-02. I WOULD HAVE PAID MORE ATTENTION TO THIS ISSUE IF I WOULD HAVE KNOWN ABOUT THE BULLETIN AT THE TIME IT WAS ISSUED. LAST FRIDAY JUNE 20TH, I WAS PULLING INTO THE PARKING LOT AT MY OFFICE AND THE STRUT TOWER ACTUALLY SNAPPED IN HALF, NOT AT THE TOP WHERE THE RUST WAS! I'VE NEVER SEEN THIS HAPPEN ON ANY VEHICLE BEFORE. THANK GOODNESS I WAS ONLY TRAVELING ABOUT 10 MPH WHEN IT HAPPENED. THE BOTTOM LINE IS THAT I SHOULD HAVE BEEN MADE AWARE OF THIS VERY SERIOUS SAFETY ISSUE 12 YEARS AGO AND THIS SHOULD HAVE BEEN A RECALL, NOT A SERVICE BULLETIN. *TR
THE DRIVERS SIDE STRUT TOWER STARTING SHOWING SIGNS OF RUST. INSTALLED THE STRUT TOWER REPAIR KIT. NOW, THE DRIVERS SIDE STRUT TOWER IS COMPLETELY RUSTED THROUGH. *TR
THE DRIVERS SIDE STRUT TOWER STARTING SHOWING SIGNS OF RUST. INSTALLED THE STRUT TOWER REPAIR KIT. NOW, THE DRIVERS SIDE STRUT TOWER IS COMPLETELY RUSTED THROUGH. *TR
WHEN DRIVING (USUALLY ACCELERATING) THE ENGINE WILL STOP RUNNING CAUSING DIFFICULT BREAKING AND STEERING. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND GETTING WORSE!!!!! THE STEERING WHEEL MUST BE TILTED UP BEFORE IT WILL RESTART. *TR
WHEN DRIVING (USUALLY ACCELERATING) THE ENGINE WILL STOP RUNNING CAUSING DIFFICULT BREAKING AND STEERING. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND GETTING WORSE!!!!! THE STEERING WHEEL MUST BE TILTED UP BEFORE IT WILL RESTART. *TR
WHEN DRIVING (USUALLY ACCELERATING) THE ENGINE WILL STOP RUNNING CAUSING DIFFICULT BREAKING AND STEERING. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND GETTING WORSE!!!!! THE STEERING WHEEL MUST BE TILTED UP BEFORE IT WILL RESTART. *TR
SIGNIFICANT RISK ? COMPLETE LOSS OF CONTROL DUE TO POOR DESIGN (UNRESOLVED MANUFACTURER KNOWN ISSUE): DURING A MODERATE RAIN STORM, THE SERPENTINE BELT ONCE AGAIN SLIPPED OFF THE PULLEYS, WHICH DISABLED POWER STEERING, CAUSING A COMPLETE LOSS OF CONTROL OF THE VEHICLE AS IT WAS ACCELERATING FROM A STOP (MY WIFE WAS UNABLE TO FIGHT THE WEIGHT OF THE VEHICLE). LUCKILY, THE VEHICLE HAD JUST LEFT A STOPLIGHT AND HAD ONLY ATTAINED ABOUT 20 - 25 MPH. THE VEHICLE WAS STOPPED BEFORE HITTING ANYONE OR ANYTHING IN A VERY CROWDED PEDESTRIAN AREA OF DOWNTOWN SAN DIEGO'S HISTORIC GASLAMP QUARTER. GIVEN THE REDUCED VISIBILITY FROM THE RAIN AND NIGHTTIME CITY ILLUMINATION, IT?S AMAZING THIS DID NOT RESULT IN PEDESTRIAN INJURIES OR EVEN DEATHS OR DAMAGE TO WAITING TAXIS OR PARKED CARS. THIS IS THE SECOND TIME THIS HAS HAPPENED TO THIS VEHICLE IN THE RAIN, BUT THE FIRST IN WHICH TOTAL LOSS OF CONTROL OCCURRED. THE FIRST INSTANCE ALSO OCCURRED AT NIGHT, IN THE RAIN, WHILE WAITING IN HEAVY AIRPORT TERMINAL TRAFFIC. NUMEROUS REPORTS OF DODGE GRAND CARAVAN SERPENTINE BELTS SLIPPING OFF IN THE RAIN CAN BE FOUND ONLINE IN DODGE FORUMS. A TECHNICAL BULLETIN WAS ISSUED FOR PRIOR MODEL YEARS BUT DOES NOT INCLUDE THE 2000 MODEL YEAR. ALSO OF NOTE, AFTER THE VEHICLE STOPPED IT BEGAN TO OVERHEAT AS THE WATER PUMP WAS ALSO DISABLED BY THE LOSS OF THE SERPENTINE BELT. *TR
SIGNIFICANT RISK ? COMPLETE LOSS OF CONTROL DUE TO POOR DESIGN (UNRESOLVED MANUFACTURER KNOWN ISSUE): DURING A MODERATE RAIN STORM, THE SERPENTINE BELT ONCE AGAIN SLIPPED OFF THE PULLEYS, WHICH DISABLED POWER STEERING, CAUSING A COMPLETE LOSS OF CONTROL OF THE VEHICLE AS IT WAS ACCELERATING FROM A STOP (MY WIFE WAS UNABLE TO FIGHT THE WEIGHT OF THE VEHICLE). LUCKILY, THE VEHICLE HAD JUST LEFT A STOPLIGHT AND HAD ONLY ATTAINED ABOUT 20 - 25 MPH. THE VEHICLE WAS STOPPED BEFORE HITTING ANYONE OR ANYTHING IN A VERY CROWDED PEDESTRIAN AREA OF DOWNTOWN SAN DIEGO'S HISTORIC GASLAMP QUARTER. GIVEN THE REDUCED VISIBILITY FROM THE RAIN AND NIGHTTIME CITY ILLUMINATION, IT?S AMAZING THIS DID NOT RESULT IN PEDESTRIAN INJURIES OR EVEN DEATHS OR DAMAGE TO WAITING TAXIS OR PARKED CARS. THIS IS THE SECOND TIME THIS HAS HAPPENED TO THIS VEHICLE IN THE RAIN, BUT THE FIRST IN WHICH TOTAL LOSS OF CONTROL OCCURRED. THE FIRST INSTANCE ALSO OCCURRED AT NIGHT, IN THE RAIN, WHILE WAITING IN HEAVY AIRPORT TERMINAL TRAFFIC. NUMEROUS REPORTS OF DODGE GRAND CARAVAN SERPENTINE BELTS SLIPPING OFF IN THE RAIN CAN BE FOUND ONLINE IN DODGE FORUMS. A TECHNICAL BULLETIN WAS ISSUED FOR PRIOR MODEL YEARS BUT DOES NOT INCLUDE THE 2000 MODEL YEAR. ALSO OF NOTE, AFTER THE VEHICLE STOPPED IT BEGAN TO OVERHEAT AS THE WATER PUMP WAS ALSO DISABLED BY THE LOSS OF THE SERPENTINE BELT. *TR
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHEN THE SEAT BELT BUCKLE WAS SLIGHTLY TOUCHED, THE SEAT BELT WOULD ERRONEOUSLY RELEASE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN STATED THAT THE SEAT BELT BUCKLE WAS FUNCTIONING AS DESIGNED HOWEVER, THE DEALER OFFERED TO REPLACED THE SEAT BELT BUCKLE AT THE CONTACT'S EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT HE WAS DISPLEASED WITH THE PLACEMENT OF THE SEAT BELT RELEASE BUCKLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. UPDATED 03/31/14*LJ.....UPDATED12/07/15*BF
WHENEVER IT RAINS, AND WATER IS SPRAYED UNDER THE VEHICLE, THE SERPENTINE BELT IS KNOCKED OFF. VEHICLE LOOSES POWER STEERING AND ENGINE TEMPERATURE GETS VERY HOT. *TR
REAR BRAKE LINES HAVE RUSTED AND FAILED. THEY HAVE RUSTED AND FAILED IN THE AREA JUST BEHIND THE ABS MODULE WHERE THE BRAIDED LINES ARE CONNECTED TO THE RIGID LINES. THE REST OF THE BRAKE LINES ARE IN FINE SHAPE. THE ONLY AREAS WHERE THEY ARE BAD IS WHERE THE BRAIDED SECTIONS CONNECT TO THE RIGID SECTIONS. *TR
STRUT TOWERS HAVE COMPLETELY RUSTED THROUGH TO THE POINT WHERE I CAN SEE THE GROUND BY LOOKING THROUGH THE STRUT TOWERS FROM THE INSIDE OF THE ENGINE COMPARTMENT. THERE IS VERY LITTLE STRUCTURAL SUPPORT LEFT IN THE STRUT TOWERS. *TR
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE REPAIRED, IT WAS FOUND THAT THE STRUT TOWERS NEEDED TO BE REPLACED. THE STRUT TOWERS WERE UNABLE TO BE REPAIRED DUE TO EXCESSIVE RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 206,000.
LEFT STRUT TOWER COMPLETELY RUSTED OUT. MAJOR SAFETY PROBLEM THAT CHRYSLER KNOWS ABOUT AND SHOULD B RECALLED. *TR
LEFT STRUT TOWER COMPLETELY RUSTED OUT. MAJOR SAFETY PROBLEM THAT CHRYSLER KNOWS ABOUT AND SHOULD B RECALLED. *TR
DRIVER SIDE STRUT MOUNT DANGEROUSLY RUSTED AND COULD GIVE WAY. *TR
MILEAGE AT TIME OF INCIDENT: 123860 MILES. WHILE DRIVING THIS LOANER VEHICLE OF A FRIEND. I ENCOUNTERED A SUDDEN AND UNEXPECTED HYDRAULIC BRAKE FAILURE WHILE STOPPING. LOSS OF BRAKE FLUID. MECHANICAL BRAKING WAS AVAILABLE. ASSESSMENT OF SYSTEM SHOWED NO LEAKS ON OR AROUND BOOSTER, MASTER CYLINDER OR ABS DISTRIBUTION MODULE. APPROXIMATELY 50MM OF SEVERE CORROSION OF THE TWO, RIGID STEEL BRAKE TUBING SECTIONS, ORIGINATING FROM THE SECOND JUNCTIONS OF THE FLEXIBLE HOSES TO THE RESPECTIVE RIGID STEEL BRAKE TUBING, THAT RUN ALONG THE DRIVER SIDE FRAME. WHEN THE BRAKING SYSTEM WAS USED TO STOP, THE SUDDEN INCREASE OF HYDRAULIC PRESSURE CAUSED A STRUCTURAL FAILURE OF THE DEGRADED TUBING. THIS FAILURE CAUSED THE CATASTROPHIC LOSS OF HYDRAULIC BRAKE FLUID AND LOSS OF THE HYDRAULIC BRAKING SYSTEM. THIS FAILURE RESULTED IN A NEAR COLLISION WITH ANOTHER VEHICLE. PHOTOGRAPHS WERE TAKEN OF THE BRAKE LINE TUBING AND JUNCTION AND SHOW THE SEVERITY OF THE CORROSION. THIS COMPLAINT IS CONSISTENT WITH OTHER SIMILAR COMPLAINTS FOR THIS MODEL AND VEHICLE AND MODEL YEAR AS POSTED ON THE NHTSA.GOV WEBSITE. *TR
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT HE SMELLED A STRONG ODOR OF GASOLINE COMING FROM THE VEHICLE. THE CONTACT LATER NOTICED GASOLINE LEAKING ONTO THE FUEL RAIL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V268000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 205,000. *TR