2019 CHEVROLET CORVETTE
1 recalls, 151 complaints - 909 TSBs
18V360000 May 31, 2018
AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE
Defect Description
General Motors LLC (GM) is recalling certain 2019 Chevrolet Corvette ZR1 vehicles. Hard braking or acceleration may cause the sensing diagnostic module (SDM) to enter a fault state. As a result, the SDM will not provide crash sensing or deploy the necessary air bags in the event of a crash.
Consequence
In the event of a crash, if the air bags do not deploy as designed, the occupants have an increased risk of injury.
Remedy
GM will notify owners, and dealers will reprogram the SDM with updated software, free of charge. The recall began on June 29, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18195.
Complaint Statistics
151 total complaints
1 crashes 1 fires 2 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| WHEELS | 101 |
| WHEELS:RIM | 9 |
| POWER TRAIN | 6 |
| ELECTRICAL SYSTEM | 6 |
| STEERING | 5 |
| ENGINE | 5 |
| SERVICE BRAKES | 3 |
| VEHICLE SPEED CONTROL | 2 |
| ENGINE AND ENGINE COOLING | 2 |
| SEAT BELTS | 1 |
ELECTRICAL SYSTEM
Apr 8, 2026
Incident date: Aug 20, 2024
On 3/27/026 at approximately 1800 hrs, I was driving my 2025 VW Atlas w/8500 miles southbound on the Florida Turnpike in the left hand land. Traffic was at a standstill at mm 76. We sat for 2-3 minutes without moving. When traffic started to roll forward, I moved my foot to apply the gas but the car... Read more
STEERING
Mar 7, 2026
Incident date: Jul 1, 2022
Around 6,000 miles I started noticing a weird sticking sensation in the steering wheel when making small corrections at highway speeds. It feels like the wheel catches on a point near center and needs a little extra force to push through. It's subtle but it's happened enough times to startle me whil... Read more
POWER TRAIN
Feb 9, 2026
Incident date: Feb 5, 2026
The vehicle experienced a catalytic converter efficiency failure that was confirmed by an authorized dealership in January 2025. The dealer indicated the catalytic converter required replacement; however, the replacement was not performed, and the vehicle was returned to service with an unresolved e... Read more
UNKNOWN OR OTHER
Sep 24, 2025
Incident date: Jul 1, 2022
Backup camera is obscured and has lines in it and sometimes it don't even work
ENGINE AND ENGINE COOLING
Sep 2, 2025
Incident date: Aug 7, 2025
The contact owns a 2021 GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasona... Read more
SERVICE BRAKES
Aug 15, 2025
Incident date: Mar 21, 2019
Component Failed: Electric transmission/drive unit failed twice before 150,000 miles. Still in vehicle, available for inspection. Safety Risk: Loss of propulsion while driving creates risk of being rear-ended or stranded in dangerous traffic conditions. Right now the car is not drivable Confirmed... Read more
Fire
ENGINE
Aug 12, 2025
Incident date: Aug 2, 2025
There is a known issue by Nissan regarding many issues with the XD Diesel platform trucks. Mine is a castrophic engine failure at 76,237 miles. There was a recall previously on turbos for many 2016s & 2017s. One is not showing up for mine and as I bought the truck used can not confirm or deny my t... Read more
LATCHES/LOCKS/LINKAGES
Jun 26, 2025
Incident date: Feb 2, 2025
See attached document for complaint. Please let me know how quickly the service parts for these two recalls are physically located in your shop and how soon the required recalls will be performed. I have been getting periodic recall notices for years and have yet to obtain the satisfaction of an ad... Read more
ENGINE
Apr 28, 2025
Incident date: Apr 28, 2025
Coolant leak on engine leading to white smoke coming out of exhaust engine is on brink of ruin. This model is not covered underneath any of the recalls, even though it has the eco-boost. Diagnosed by Ford dealership.
EXTERIOR LIGHTING:HEADLIGHTS
Mar 28, 2025
Incident date: Jan 1, 2025
The contact owns a 2017 Subaru Impreza. The contact stated that the "Check Headlight Assembly" message was displayed, and the front passenger’s side headlight occasionally turned off or on, while attempting to start the vehicle and while driving at various speeds. The vehicle was taken to a local ... Read more
ELECTRICAL SYSTEM
Mar 13, 2025
Incident date: Jan 1, 2025
Software malfunction left the primary dashboard and all associated systems inoperable and in an unresposive state.
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Mar 6, 2025
Incident date: Jan 1, 2025
Back up camera repeatedly fails. Often when put in reverse it says “camera temporarily unavailable “. Sometimes while actively backing up the camera fails. Service center says Volvo is aware but unable to fix.
VEHICLE SPEED CONTROL
Feb 6, 2025
Incident date: Feb 6, 2025
the blue cruise hands free driving feature does not work and has guided the vehicle off of the road. It also asks the driver to take the steering wheel, but will not register that has happened without a very hard pull on the wheel, which pulls the vehicle into other lanes of traffic. this is a very ... Read more
ELECTRONIC STABILITY CONTROL (ESC)
Nov 19, 2024
Incident date: Jan 1, 2023
The contact owns a 2024 BMW I7. The contact stated while driving approximately 45 MPH, the "Inability to Drive" message was displayed on the instrument panel and the vehicle suddenly lost motive power. The contact received notification of NHTSA Campaign Number: 24V104000 (Electronic Stability Contro... Read more
SUSPENSION
Sep 18, 2024
Incident date: Jul 19, 2024
A combination of the lower control arm alignment adjustment bolt, it is just a slot and standard bolt. The alignment becomes loose over time and begins to work side to side in the slot, so retightening the bolt is the only solution to keep it from moving. The main issue is the subframe being made fr... Read more
SERVICE BRAKES
Sep 16, 2024
Incident date: Sep 6, 2024
The contact owns a 2024 Honda Accord Sedan. The contact stated that on several occasions while driving at various speeds, the brakes were engaged inadvertently. On two occasions the vehicle braked abruptly, the vehicle hit a curb, and punctured the front and rear passenger tires. A police report was... Read more
Crash
1 injured
VEHICLE SPEED CONTROL
Sep 2, 2024
Incident date: Aug 17, 2024
The Distronic Cruise Control stops working and then will start working again several times on long trips. After research it appears if the radar doesn't detect anything in front of your vehicle for an hour it thinks it is inoperable and and shuts the Distronic Cruise Control off and it cannot be re... Read more
ELECTRICAL SYSTEM
Jul 9, 2024
Incident date: Jul 8, 2024
The contact owns a 2019 Toyota Highlander. The contact stated that while the vehicle was parked and attempting to start the vehicle, the vehicle failed to respond as intended. The contact stated that the failure had been recurring, and the battery was replaced, as recommended by the local dealer; ho... Read more
ELECTRICAL SYSTEM
Jun 29, 2024
Incident date: Jun 29, 2024
Sunroof drain lines leaked and filled the rear compartment with water which is also where the body control module is. The water damaged the body control module which affected vehicle lighting and abs system. Upon further investigation, this is a very common issue with Audi.
STEERING
Apr 20, 2024
Incident date: Apr 1, 2024
Dear NHTSA, I am writing to report a safety issue with my 2023 Land Rover Discovery Metropolitan that occurred on April [XXX] 2024. VIN: [XXX] The issue involved the steering wheel locking unexpectedly. After parking the car overnight for 15 hours, I returned to find a message indicating lane dep... Read more
ENGINE
Mar 18, 2024
Incident date: Mar 18, 2024
While driving engine suddenly turns off. After getting vehicle to side of road and placing in park, car will start again. This has happened several times. Battery, oil levels checked and there is no engine code that shows up on OBD II reader. Very Dangerous!
LANE DEPARTURE: ASSIST
Dec 11, 2023
Incident date: Sep 9, 2023
After reviewing my owner’s manual on my newly purchased vehicle, I was shocked at how quickly and unexpectedly I was propelled from 75mph to 105mph because of a new-to-me feature on this model. I was surprised and moreover shocked that a system like this is mass-produced and sold worldwide. Seems ... Read more
ENGINE
Sep 10, 2023
Incident date: Aug 24, 2023
Car engine stalling while driving and failure of the EPS/EPC light comes on When attempted to start the car warning start stop system malfunctioning unable to start at times
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Sep 6, 2023
Incident date: Aug 30, 2023
Trailer brakes going on sporadically. Known problem…right turn lamp fault as well. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ELECTRICAL SYSTEM
Sep 5, 2023
Incident date: Sep 5, 2023
Driving through a parking lot when the van said shift to park and completely shut off while moving. Lost power steering and acceleration. Car then would not restart. Husband came and we hooked to his battery and somehow it cranked and we got it home.
ENGINE AND ENGINE COOLING
May 9, 2023
Incident date: May 8, 2023
My car had been consuming 2 quarts every 1,000 miles for the past 3-4 months and the kia dealership told me that the best thing i could do is keep getting an oil change. So one day i tried starting my car and it starting shaking and turned off so i turned it back on and it shut off again. I jump sta... Read more
POWER TRAIN
Mar 26, 2023
Incident date: Nov 4, 2022
The left rear weld of the subframe on my 2012 C300 4matic has rotted through and appears to be a manufacture's part defect. I found out about this issue from a brake inspection and told it is a safety concern, which Mercedes Benzes is aware of but has no recalls for the defect.
EQUIPMENT
Mar 16, 2023
Incident date: Mar 6, 2023
The contact owns a 2021 Phoenix Cruiser RV built on a 2021 Ford E-450 chassis, equipped with a 6400 Series window vent. The contact stated that he became aware that the side window was delaminating. The contact became aware of NHTSA Campaign Number: 21E047000 (Structure, Equipment). The RV was taken... Read more
ENGINE
Feb 10, 2023
Incident date: Dec 30, 2022
The contact owns a 2017 Hyundai Tucson. The contact stated while driving 25 MPH, the engine made abnormal knocking sounds. Several unknown warning lights were illuminated. The contact veered to the side of the road and turned off the vehicle. The vehicle failed to restart. The vehicle was towed to t... Read more
POWER TRAIN
Jan 10, 2023
Incident date: Jan 10, 2023
Transmission failed while driving in traffic. Car decelerated from 45MPH to 0, gas peddle would not accelerate, break was locked in place, steering wheel locked, no warning lights appeared, flashing D on gear shift (was in drive), alert appeared on screen “Shift to P then desired gear”, car wou... Read more
WHEELS
Dec 21, 2022
Incident date: Dec 21, 2022
I have 32,800 miles on my 2019 Corvette Grand Sport. Each year during my annual service, I have had to have wheels repaired that were bent. Today, during my regular service, both of my rear wheels were identified as cracked and must be replaced. Cracked wheels on the 2017 to 2019 Corvette Grand S... Read more
WHEELS:RIM
Dec 19, 2022
Incident date: Dec 19, 2021
The contact owns a 2019 Chevrolet Corvette. The contact stated that on several occasions, the tires started to deflate without warning. The contact then stated that he noticed that the rear driver’s and passenger’s side rims had started to crack. The vehicle was taken to the dealer where the con... Read more
WHEELS
Dec 7, 2022
Incident date: Nov 28, 2022
Rear Wheels cracked begot flat tire
WHEELS
Nov 14, 2022
Incident date: Nov 10, 2022
My corvette developed a cracked wheel. We took it to the Dealership that put new tires on a week ago because the low air alarm came on. They informed me the wheel was cracked and denied damaging it when putting on the new tires. “It just happens” was their claim. Now we learn there is a class... Read more
WHEELS:RIM
Sep 30, 2022
Incident date: Aug 30, 2022
The contact owns a 2019 Chevrolet Corvette. The contact stated that while the vehicle was at the dealer for all four-tire replacement, the dealer informed him that all four rims were warped and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and inform... Read more
WHEELS
Aug 30, 2022
Incident date: Aug 25, 2022
My factory wheel cracked in two places while traveling to the Corvettes at Carlisle event. I have a little over 18000 miles on my car at this point. I have taken great care of my car and have not hit and rough potholes or obstacles in the road. I have not “tracked” my car either. I have read abo... Read more
ELECTRICAL SYSTEM
Jun 8, 2022
Incident date: Oct 14, 2021
Vehicle : 2019 Grand Sport Corvette Here’s what happened On or about Oct 14, 2021 I was driving on a multi-lane highway in an 50 mph zone, when the following occurred: -brakes suddenly slammed full-on, then immediately released …e.g., on/off in 0.25 of a second -windshield-wipes made one swish a... Read more
1 injured
WHEELS
Jun 5, 2022
Incident date: Apr 2, 2022
Both rear wheels bent. No damage to tires. Damage caused by normal driving on surfaced roads. Several unmarked bridge transitions and minor potholes. Damage detected when wheels were checked with laser on Hunter Road Force balancer. Front wheels were OK.
WHEELS:RIM
Mar 14, 2022
Incident date: Feb 1, 2019
The contact owns a 2019 Chevrolet Corvette. The contact stated that while driving at various speeds, the low tire pressure warning light would illuminate on the instrument panel. The contact stated that she added air to the tires however, the low tire pressure warning light remained illuminated. The... Read more
WHEELS
Jan 30, 2022
Incident date: Jan 30, 2022
2019 Corvette Grand Sport August 2021 - Driver side rear wheel cracked losing pressure rapidly making continued driving dangerous. Instructed by a local dealership to drive at minimum speed to the dealership to prevent the degradation and potential catastrophic failure of the wheel and/or tire. D... Read more
WHEELS:RIM
Dec 15, 2021
Incident date: May 25, 2021
The contact owns a 2019 Chevrolet Corvette. The contact stated while driving 65 MPH, the passenger’s side rear tire low-pressure warning light illuminated. The contact stopped at a service station and added air to the tire and proceeded to drive however, the warning light illuminated again. The co... Read more
WHEELS:RIM
Nov 24, 2021
Incident date: Nov 24, 2021
The contact owns a 2019 Chevrolet Corvette. The contact stated that while driving at 25 MPH, the low tire pressure warning light illuminated. The contact stated that he added air to the tires however, the low tire pressure warning light illuminated again. The contact stated that he then took the veh... Read more
WHEELS
Nov 4, 2021
Incident date: Oct 26, 2021
During routine service at my Chevy dealership, both passenger side wheels were bent (out-of-round), requiring repair, at 20,793 miles. This is the send time the passenger rear wheel was found to be bent, requiring repair.
WHEELS:RIM
Oct 27, 2021
Incident date: Oct 7, 2021
The contact owns a 2019 Chevrolet Corvette. The contact stated while driving 45 MPH, the RPM decreased to 1,200 and the vehicle started to shudder and shake. The contact was able to continue to drive the vehicle to the residence. The contact took the vehicle to a local dealer to be inspected. The de... Read more
POWER TRAIN
Oct 27, 2021
Incident date: Oct 7, 2021
The contact owns a 2019 Chevrolet Corvette. The contact stated while driving 45 MPH, the RPM decreased to 1,200 and the vehicle started to shudder and shake. The contact was able to continue to drive the vehicle to the residence. The contact took the vehicle to a local dealer to be inspected. The de... Read more
WHEELS
Oct 16, 2021
Incident date: Oct 15, 2021
The front rims are bent
WHEELS
Oct 4, 2021
Incident date: Sep 28, 2021
OEM wheels fail. Thousands of online reports of 2015-2019 Corvette C7 Grand Sport and Z06 models wheels cracking without incident. My wheel is available for inspection. Safety was risked by having a wheel crack, loose air pressure and fail under normal operating load, potentially causing a crash. Th... Read more
WHEELS
Sep 21, 2021
Incident date: Sep 12, 2021
Vehicle has 6900 miles on it, started to vibrate badly while driving on highway. Car has not been in any accidents and carefully driven. Dealer says the two rear wheels are bent.This could lead to cracking of wheels and/or loss of control of the vehicle. Vehicle is still under 36 month/36,000 mile b... Read more
FUEL/PROPULSION SYSTEM
Sep 17, 2021
Incident date: Sep 14, 2021
Bad smell of gas while parked in garage. Looked underneath and was leaking fuel. Looked online early c7 corvette 15-18 has a special recall for the fuel receiver and tank because it was leaking. Gm actually extended one of the warranties because of it. Brought my car to the dealer and said it's n... Read more
WHEELS
Aug 7, 2021
Incident date: Aug 3, 2021
The rim cracked from the outside edge and progressed until air begin to leak. The dealer will not replace the rim unless you bought a tire and rim policy. But the manufacture of the tire does warrantee the tire and the dealer knows that to be the case. So the dealer knows the rims are the problem. I... Read more
Showing 50 of 151 complaints.
NHTSA Safety Ratings, 2019 CHEVROLET CORVETTE
2019 Chevrolet Corvette C RWD
| Category | Rating |
|---|---|
| Rollover Risk | 0.0% |
Safety Technology
| Feature | Status |
|---|---|
| Electronic Stability Control | Standard |
| Forward Collision Warning | No |
| Lane Departure Warning | No |
Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.
EPA Fuel Economy, 2019 CHEVROLET CORVETTE
| Trim / Engine | City MPG | Highway MPG | Combined MPG | Fuel Type | Annual Fuel Cost |
|---|---|---|---|---|---|
| 6.2L 8-cyl, Manual 7-spd (Rear-Wheel Drive) | 16.0 | 25.0 | 19.0 | Premium | $4,050 |
| 6.2L 8-cyl, Automatic (S8) (Rear-Wheel Drive) | 15.0 | 25.0 | 18.0 | Premium | $4,300 |
CO2 Emissions: 465.0 g/mile (Two Seaters)
Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.
Technical Service Bulletins, 2019 CHEVROLET CORVETTE
909 manufacturer communications from 471 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 165 |
| 060000 ENGINE AND ENGINE COOLING | 128 |
| 100000 POWER TRAIN | 83 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 79 |
| 110000 ELECTRICAL SYSTEM | 63 |
| 060000 ENGINE (PWS) | 48 |
| 200000 WHEELS | 44 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 43 |
00-03-10-006P
Apr 18, 2024
200000 WHEELS
This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
20-NA-132
Apr 10, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Apr 10, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
17-NA-052
Apr 8, 2024
350000 EQUIPMENT
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
17-NA-052
Apr 8, 2024
200000 WHEELS
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
20-NA-132
Mar 26, 2024
118000 ELECTRICAL SYSTEM:SOFTWARE
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
23-NA-103
Mar 21, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).
20-NA-166
Mar 21, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
23-NA-170
Mar 11, 2024
110000 ELECTRICAL SYSTEM
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
23-NA-170
Mar 11, 2024
100000 POWER TRAIN
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
23-NA-170
Mar 11, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
07-00-89-037S
Mar 11, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
11-00-89-005X
Mar 10, 2024
350000 EQUIPMENT
This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).
PIP5596A
Mar 4, 2024
030000 BRAKES (PWS)
This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
PIP5596A
Mar 4, 2024
070000 FUEL SYSTEM, GASOLINE
This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
24-NA-040
Mar 4, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
17-NA-073
Mar 1, 2024
980000 UNKNOWN OR OTHER
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
PIP5968
Feb 27, 2024
100000 POWER TRAIN
This Preliminary information communicates to have the dealer contact TAC with the transmission TUN number prior to transmission installation.
PIP5966
Feb 23, 2024
100000 POWER TRAIN
This Preliminary information communicates Diagnostic aids for a no start or DTC'S following a transmission replacement
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
16-NA-003
Feb 15, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides repair information to correct a customer concern of a chirp, squeak noise heard coming from the rear of vehicle.
16-NA-222
Feb 7, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.
19-NA-044
Feb 7, 2024
070000 FUEL SYSTEM, GASOLINE
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
19-NA-044
Feb 7, 2024
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
16-NA-338
Feb 2, 2024
100000 POWER TRAIN
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
16-NA-338
Feb 2, 2024
060000 ENGINE AND ENGINE COOLING
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
PIT6122
Jan 31, 2024
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
This Preliminary information communicates to dealers of a known issue with failed map update
PI0281K
Jan 18, 2024
160000 STRUCTURE
This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
22-NA-246
Jan 18, 2024
100000 POWER TRAIN
This service bulletin advises the technician that the possible cause may not be from a faulty clutch piston or extension housing and to perform testing on transmission for other possible issues, but it still may be possible on high mileage
23-NA-170
Jan 16, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the tech to inspect deeper into what may be to main cause of an engine failure.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PI0592I
Jan 8, 2024
110000 ELECTRICAL SYSTEM
This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
19-NA-218
Dec 22, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a service procedure to correct a condition of a Ticking Noise from the Engine.
16-NA-361
Dec 20, 2023
350000 EQUIPMENT
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
16-NA-361
Dec 20, 2023
100000 POWER TRAIN
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
PIT5074P
Dec 18, 2023
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking
PIT5962A
Dec 15, 2023
110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS
This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.
PIT5962A
Dec 15, 2023
980000 UNKNOWN OR OTHER
This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
20-NA-132
Dec 8, 2023
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Dec 8, 2023
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Dec 8, 2023
060000 ENGINE AND ENGINE COOLING
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
PIP5700E
Nov 27, 2023
110000 ELECTRICAL SYSTEM
This Preliminary information communicates to the dealer technician that the part numbers for the internal wiring harnesses for the 8 speed RWD transmissions are not listed in the Electronic Parts Catalog. Technicians are to refer to the inf
17-NA-087
Nov 17, 2023
200000 WHEELS
This service bulletin provides information on Characteristics of Wide Low Aspect Ratio Tires, Vehicle Pulls Left or Right, Wanders, Follows Depressions in Road Surface, Tramlining.
17-NA-087
Nov 17, 2023
020000 SUSPENSION
This service bulletin provides information on Characteristics of Wide Low Aspect Ratio Tires, Vehicle Pulls Left or Right, Wanders, Follows Depressions in Road Surface, Tramlining.
17-NA-087
Nov 17, 2023
010000 STEERING
This service bulletin provides information on Characteristics of Wide Low Aspect Ratio Tires, Vehicle Pulls Left or Right, Wanders, Follows Depressions in Road Surface, Tramlining.
21-NA-135
Nov 16, 2023
350000 EQUIPMENT
This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.
21-NA-135
Nov 16, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.
21-NA-135
Nov 16, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.
21-NA-135
Nov 16, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.
PIT5214F
Nov 14, 2023
020000 SUSPENSION
This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer?s vehicles that exhibit vibration conditions without utilizing the
19-NA-046
Nov 9, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for dealers, technicians and customers on the eLSD Wheel Slip Display in DIC.
19-NA-046
Nov 9, 2023
100000 POWER TRAIN
This informational bulletin provides information for dealers, technicians and customers on the eLSD Wheel Slip Display in DIC.
17-NA-078
Nov 9, 2023
350000 EQUIPMENT
This service bulletin provides information on Corvette and Camaro Exhaust Tone During Wide Open Throttle while in Sport or Track Modes and that this is considered a normal characteristic.
17-NA-078
Nov 9, 2023
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
This service bulletin provides information on Corvette and Camaro Exhaust Tone During Wide Open Throttle while in Sport or Track Modes and that this is considered a normal characteristic.
17-NA-078
Nov 9, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information on Corvette and Camaro Exhaust Tone During Wide Open Throttle while in Sport or Track Modes and that this is considered a normal characteristic.
17-NA-040
Nov 9, 2023
030000 SERVICE BRAKES, HYDRAULIC
This service bulletin provides a procedure to correct a condition of Brake Squeal or Squeak Noise Intermittently on Initial Brake Applies.
16-NA-059
Nov 9, 2023
030000 SERVICE BRAKES, HYDRAULIC
This service bulletin provides information for cleaning the brake calipers that may have staining/discoloring on the paint of the brake caliper.
03-00-91-001I
Nov 6, 2023
010000 STEERING
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
020000 SUSPENSION
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
200000 WHEELS
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
100000 POWER TRAIN
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
20-NA-159
Oct 30, 2023
200000 WHEELS
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
19-NA-218
Oct 27, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a service procedure to correct a condition of a Ticking Noise from the Engine.
16-NA-361
Oct 19, 2023
100000 POWER TRAIN
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
19-NA-042
Oct 17, 2023
160000 STRUCTURE
This service bulletin provides information for dealers/technicians on a customer commenting on seeing a yellow tint appearance to hood and engine covera??s exposed carbon fiber parts.
19-NA-042
Oct 17, 2023
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on a customer commenting on seeing a yellow tint appearance to hood and engine covera??s exposed carbon fiber parts.
23-NA-065
Oct 16, 2023
350000 EQUIPMENT
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
23-NA-065
Oct 16, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
13-03-10-001K
Oct 12, 2023
200000 WHEELS
This service bulletin provides information on summer tire performance and tire cold weather cracking.
13-03-10-001K
Oct 12, 2023
350000 EQUIPMENT
This service bulletin provides information on summer tire performance and tire cold weather cracking.
17-NA-239
Oct 12, 2023
030000 SERVICE BRAKES, HYDRAULIC
This bulletin provides information on possible normal brake drag caused by the vehicle parked for an extended period of time.
05-00-89-029F
Oct 11, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
01-06-01-011O
Oct 6, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
99-00-89-019Y
Oct 3, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.
20-NA-159
Sep 28, 2023
200000 WHEELS
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
20-NA-159
Sep 28, 2023
190000 TIRES
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
PIT5698D
Sep 26, 2023
110000 ELECTRICAL SYSTEM
This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
02-00-89-002W
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
PIC6378C
Sep 26, 2023
134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
This Preliminary Information communicates helpful information on diagnosing general customer concerns related to a power folding top.
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
23-NA-170
Sep 22, 2023
060000 ENGINE AND ENGINE COOLING
This bulletin advises the tech to inspect deeper into what may be to main cause of an engine failure.
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-154
Sep 21, 2023
350000 EQUIPMENT
This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).
Showing 100 of 909 bulletins.
NHTSA Safety Investigations, CHEVROLET CORVETTE
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA13007
Opened: Aug 23, 2013 , Closed: Jun 24, 2014
Simultaneous Loss of Low-Beam Headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announ... Read more
PE13013
Opened: May 6, 2013 , Closed: Aug 26, 2013
Loss of Low Beam Headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the re... Read more
PE10015
Opened: May 12, 2010 , Closed: Sep 10, 2010
Fuel Tank Leak
In its June 30, 2010 response to ODI's Information Request letter, General Motors (GM) identified the leak source as cracks in either the fuel tank cross-over tube quick connector (connector) and/or the hot-plate weld joint of the connector to the tank.The root causes are attributed to errors in con... Read more
EA09002
Opened: Jan 14, 2009 , Closed: May 11, 2010
Electronic Stability Control
On April 26, 2010, at NHTSA's request following this investigation, General Motors submitted a Defect Information Report to NHTSA to correct a defect associated with the Vehicle Stability Control (VSC) system in approximately 40,000 Model Year (MY) 2005 and 2006 Chevrolet Corvette vehicles (NHTSA Re... Read more
PE08056
Opened: Sep 17, 2008 , Closed: Jan 14, 2009
ELECTRONIC STABILITY CONTROL MALFUNCTION
ON SEPTEMBER 17, 2008, ODI OPENED PRELIMINARY EVALUATION PE08-056 TO INVESTIGATE ALLEGATIONS OF INAPPROPRIATE ACTIVATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM IN MODEL YEAR (MY) 2005 AND 2006 CHEVROLET CORVETTE VEHICLES.SOME REPORTS RECEIVED BY ODI AND SOME REPORTS TO GENERAL MOTORS (GM) ... Read more
EA02031
Opened: Nov 15, 2002 , Closed: Mar 11, 2004
STEERING COLUMN LOCKUP
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN... Read more
PE02054
Opened: Jul 1, 2002 , Closed: Nov 15, 2002
STEERING COLUMN LOCKUP
SEE RESUME IN REPOSITORY.
EA00009
Opened: Mar 16, 2000 , Closed: Apr 18, 2000
FRONT LAP BELT MALFUNCTION
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR... Read more
PE99076
Opened: Dec 10, 1999 , Closed: Mar 16, 2000
FRONT LAP BELT MALFUNCTION
There is no summary currently available
PE99066
Opened: Nov 8, 1999 , Closed: Jul 21, 2000
STEERING COLUMN LOCK MODULE
There is no summary currently available
DP96006
Opened: May 14, 1996 , Closed: Oct 18, 1996
BRAKE PULL
THE PETITIONS STATED THAT:WE REPRESENT THE OWNER OF A 1990 CHEVROLET CORVETTE WHICH, WHEN THE BRAKES WERE APPLIED, SUDDENTLY, VIOLENTLY, AND UNEXPECTEDLY PULLS TO THE LEFT.THIS IS A INTERMITTENT DEFECT WHICH DOES NOT OCCUR WITH AN REGULARITY.
SQ94015
Opened: Mar 11, 1994 , Closed: Mar 21, 1994
ENGINE WIRING HARNESS ROUTING
THIS CONDITION POSES NO SAFETY-RELATED CONSEQUENCE IF THE IDENTIFIED WIRING HARNESS WERE TO CONTACT THE EXHAUST SHIELD.ONLY ONE MONTH OF PRODUCTION WAS INVOLVED IN THIS CAMPAIGN.THE SUBJECT WIRING HARNESS CONTAINS THE GROUND WIRES FOR THE ENGINE OIL TEMPERATURE SENSOR, O2 SENSOR, KNOCK SENSOR, AND T... Read more
DP92011
Opened: May 22, 1992 , Closed: Oct 29, 1992
AIRBAG FAILED TO DEPLOY
AIRBAG FAILED TO DEPLOY
PE92025
Opened: Mar 4, 1992 , Closed: Jun 3, 1992
INCONSIS.BRK LGT OPERATION
There is no summary currently available
EA90033
Opened: Jun 11, 1990 , Closed: Sep 9, 1991
SAFETY BELT RETRACTOR FAIL
There is no summary currently available
PE90041
Opened: Feb 8, 1990 , Closed: Jun 11, 1990
SAFETY BELT RETRACTOR FAIL
There is no summary currently available
PE90040
Opened: Feb 6, 1990 , Closed: Jun 11, 1990
PARKING BRAKE FAILURE
There is no summary currently available
PE90038
Opened: Feb 2, 1990 , Closed: May 7, 1990
UNDER DASH FIRE
There is no summary currently available
PE90032
Opened: Jan 12, 1990 , Closed: Mar 22, 1990
TIE ROD SOCKET FAILURE
There is no summary currently available
CHEVROLET CORVETTE - All Years Overview
Complete safety history for the CHEVROLET CORVETTE across all model years (1965, 2025).
149
Total Recalls
6,333
Total Complaints
19
Investigations
245
Reported Crashes
56
Reported Fires
5
Reported Deaths
CHEVROLET CORVETTE - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 3 | 12 | View |
| 2024 | 2 | 31 | View |
| 2023 | 1 | 32 | View |
| 2022 | 1 | 23 | View |
| 2021 | 2 | 14 | View |
| 2020 | 4 | 43 | View |
| 2019 (current) | 1 | 151 | |
| 2018 | 1 | 53 | View |
| 2017 | 4 | 272 | View |
| 2016 | 2 | 114 | View |
| 2015 | 5 | 72 | View |
| 2014 | 5 | 79 | View |
| 2013 | 0 | 94 | View |
| 2012 | 1 | 71 | View |
| 2011 | 1 | 98 | View |
| 2010 | 0 | 90 | View |
| 2009 | 0 | 178 | View |
| 2008 | 0 | 625 | View |
| 2007 | 2 | 434 | View |
| 2006 | 5 | 441 | View |
| 2005 | 6 | 716 | View |
| 2004 | 4 | 257 | View |
| 2003 | 3 | 126 | View |
| 2002 | 3 | 191 | View |
| 2001 | 3 | 281 | View |
| 2000 | 4 | 359 | View |
| 1999 | 4 | 389 | View |
| 1998 | 4 | 466 | View |
| 1997 | 7 | 196 | View |
| 1996 | 1 | 63 | View |
| 1995 | 1 | 48 | View |
| 1994 | 1 | 38 | View |
| 1993 | 2 | 26 | View |
| 1992 | 2 | 8 | View |
| 1991 | 3 | 28 | View |
| 1990 | 4 | 41 | View |
| 1989 | 4 | 15 | View |
| 1988 | 5 | 26 | View |
| 1987 | 3 | 25 | View |
| 1986 | 5 | 16 | View |
| 1985 | 3 | 16 | View |
| 1984 | 6 | 16 | View |
| 1982 | 2 | 0 | View |
| 1981 | 2 | 11 | View |
| 1980 | 2 | 3 | View |
| 1979 | 2 | 13 | View |
| 1978 | 2 | 1 | View |
| 1977 | 3 | 2 | View |
| 1976 | 2 | 1 | View |
| 1975 | 2 | 6 | View |
| 1974 | 3 | 0 | View |
| 1973 | 1 | 0 | View |
| 1972 | 1 | 0 | View |
| 1971 | 1 | 0 | View |
| 1970 | 1 | 0 | View |
| 1969 | 2 | 0 | View |
| 1968 | 2 | 0 | View |
| 1967 | 1 | 0 | View |
| 1966 | 1 | 1 | View |
| 1965 | 1 | 0 | View |
| 1964 | 0 | 1 | View |
| 1960 | 0 | 1 | View |