2004 CHEVROLET CORVETTE Recalls, Complaints & Safety

- Fuel tank leaks - gasoline puddles under car, heavy fumes - Fire / explosion hazard - Confirmed by local mechanic as existing problem in that year - Inspected and confirmed by selling dealer - trying to repair - No auto warning, smell of fumes and gas on garage floor day after delivery of car

When I start my vehicle, the steering wheel locking system does not disengage and the steering wheel stays locked.

The contact owns a 2004 Chevrolet Corvette. The contact stated while driving, the vehicle failed to move farther than five feet before the vehicle stalled and lost motive power. The pull-out key and wait-ten-seconds message were displayed. The contact had to release the key from the ignition and restart the vehicle. The contact called an independent mechanic and was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified about the failure. The failure mileage was approximately 30,000.

A month after I purchased the car with approximately 40k miles, I took the car in for an oil change at the dealership and was told there was a major leak in the left fuel tank and at the crossover tube. This leaking fuel is leaking onto the exhaust. It would cost at least $4,000 to repair. I can not afford this. It is too dangerous to drive. I have no other car. Supposedly, my vin number is 200 numbers away from being included in the recall for the same issue and that you have 43 pages of complaints about. Did I mention that the crossover tube is a backordered part because so many are needed because when you pull the current one out, it breaks and a new one is needed?

Strong Fuel smell near the fuel filler when car is parked in the garage.

Fuel tank leaking/fumes. Appeara to be crossover tube connection connecting the 2 tanks.

The contact owns a 2004 Chevrolet Corvette. The contact stated while driving approximately 35 MPH, the odor of gasoline was detected by the contact and his wife. The contact stated no warning light was illuminated. The contact stated that the odor of gasoline was strongest in the cabin after refueling the vehicle to a full tank. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a cross fill tube needed to be installed. The vehicle had been repaired. The contact stated that the gasoline odor was again detected while driving at various speeds. The contact researched online and related the failure to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The manufacturer had not been informed of the failure. The failure mileage was approximately 44,000.

In 2011 Chevrolet acknowledged an issue with the fuel system as the the attached letter states. I was not the owner of the vehicle in 2011 and since the issue was not elevated to an official recall it did not show up on the car fax report and I thus was unaware of this potential safety hazard. My car has now developed all the symptoms of the fuel tank leak with fumes in the car and gas dripping on the garage floor when parked. Although my car only has 30,000 miles the end date for GM to provide repair was August 11, 2011. The significant risk to passengers, the car, and my home when the car is parked in the attached garage is unacceptable as caused by a faulty engineered fuel modification in this model year. The fuel leak is both a safety and environmental risk and should warrant a recall and GM to mitigate the costs. Their liability for a faulty engineered system should not have a time limit.

Purchased the vehicle in 2015. That same purchased date I filled the vehicle with fuel. The following day my garage was totally covered with gas fumes. No tech could find the problem. On Feb 22 2023 while filling up, gas was pouring out the bottom left side . This is very dangerous. Come to find out that many others have had the same problem. There is a manufacturer defect of the gas tank housing tube . I cannot drive the vehicle because it’s to dangerous and to costly to repair.

Drivers side fuel tank/system leak Leaking fuel in this area can/will result in a catastrophic fire which could lead to injury or death The problem just occurred but is a common problem for this generation Z06 Corvette The odd thing is no warning light, check engine light or messages displayed, just the smell of fuel and 18 inch puddle on the floor beneath the drivers side fuel tank. The fuel level according to the gauge is 1/2 tank.

I have owned this vehicle the last 6 years. When the amount of fuel is over one-half tank, there is an abnormal odor of fuel. When pulling into the garage, there's fuel leaking if over one-half tank. Once the engine is cut off the fuel leak ceases. To control the issue, I keep the fuel level at less than one-half tank. A certified local mechanic determined the fuel tank and crossover tube cross connector needed to be replaced. The vehicle has not been repaired. The mechanic stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 26,500, when i bought the car. The mechanic stated that GM did issue a service bulletin around 2010 stating that GM would make repairs if the failure occurred within 10 years/100,000 miles. The local GM dealer will not repair my vehicle since it is out of time frame window. It's not fair to those who bought the car after the 10-year cutoff point. or do not drive these vehicles very much.

The contact owns a 2004 Chevrolet Corvette. The contact stated while driving at slow speeds and approaching a stop, an abnormal odor of fuel was detected. The contact noticed there was fuel leaking in the garage. The vehicle was taken to the local dealer where it was diagnosed that the fuel tank and crossover tube cross connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The contact stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 41,000. The contact stated that the vehicle was repaired and is seeking reimbursement from the manufacturer for the cost.

The contact's friend owns a 2004 Chevrolet Corvette. The contact stated that while his friend was starting the vehicle, the steering wheel seized. The dealer was made aware of the failure but informed the contact that they were unable to assist due to the age of the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 04V060000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 75,000.

Left side fuel tank developed a leak- this is a problem known to GM- they offered warranty repairs for ten years-I purchased the vehicle after this additional warranty had expired- my complaint is this is a known defective part which I would replace at my expense however GM has discontinued this part- I feel that while GM will no longer cover the cost of parts and labor the replacement parts should be available

The vehicle has a fuel leak. I just purchased this vehicle a few weeks ago, it's 16 years old and has only 36,000 miles on it. It smelled terribly of fuel when I purchased it. I had the vehicle looked at and it has a fuel leak where the quick connectors connect to the fuel tanks. Anyhow, there's a special coverage adjustment which extended the warranty to 10 yrs/100,000 miles. I'm obviously outside of those parameters, but I feel that since the manufacturer admitted fault and stated that my particular VIN is affected, they should be held accountable for fixing a safety issue with my vehicle. How they got away with issuing a special coverage adjustment for such an issue rather than a simple recall is beyond me.

leaking left fuel tank

Have been in contact with 2 employees from GM, called and left voicemails and sent emails. No reply after it was requested that I take the Corvette to my local dealership for diagnosis. The ECL motor is not working property, causing the steering wheel to lock up and fuel supply to shut off. Sent attachment with diagnosis; however, no reply. GM indicated that this was previously fixed, but it obviously was not. My assertion is that there should not be a expiration date on safety recalls, and the ECL motor is not working properly creating a very dangerous situation. This happens every time that I drive the car. There have been several instances of me starting the car, pulling into traffic, and then the car shuts down. It has been very scary as I pull the key and wait 10 seconds to restart the car. Sometimes I have to do it twice. It is my contention that GM should be responsible for fixing this problem that was previously identified by GM as an issue/concern.

THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE CONTACT SMELLED AN ABNORMAL FUEL ODOR COMING FROM THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL TANK CROSSOVER PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN MANUFACTURER’S RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

GAS SMELL COMING FROM REAR OF CAR AFTER DRIVING. NO VISIBLE LEAKS, BUT LEAKING FUEL VAPOR.

WHILE TRAVELING DOWN THE FREEWAY AT AROUND 80 MPH ON A STRAIGHT FLAT SURFACE, THE CORVETTE SHARPLY VEERED TO THE SIDE AS I HEARD A LOUD SCREECH FROM ONE OF THE BRAKES IT LASTED FOR ABOUT A SECOND. THE TURN WAS SO ABRUPT I THOUGHT I WAS GOING TO ROLL BUT AFTER FISHTAILING WAS ABLE TO GET THINGS GOING STRAIGHT. IMMEDIATELY A SERVICE ACTIVE HANDLING SYSTEM MESSAGE POPPED UP. HAPPENED ABOUT A WEEK LATER GOING ABOUT 60 MPH NOT QUITE AS ABRUPT. THIS CONDITION COULD HAVE LEAD TO A FATALITY.

GASOLINE LEAK FROM A CROSSOVER PIPE CONNECTION CONNECTING THE TWO GAS TANKS. DRIPPIG RAW FWEL ONTO A HOT EXHAUST SYSTEM AND TRANSMISSION. COMMOM PROBLEM ON TNIS YEAR AND MODEL. REPAIR WAS COVERED FOR FIRST 10 YEARS AND 100,000 MILES BY MANUFACTURER. STILL AND ISSUE WITH CARS NOT REPAIRED.

WHEN USING TELESCOPING STEERING WHEEL THE ACTIVE HANDLING LIGHT A CAME ON AND THE CAR PULLED HARD TO THE LEFT INTO ONCOMING TRAFFIC LANE WHILE DRIVING . I HAD NEVER USED THE TELESCOPING STERLING WHEEL FEATURE PRIOR TO THIS .*DT*JB

AFTER TELESCOPING STEERING WHEEL, ACTIVE HANDLING SYSTEM WARNING LIGHT CAME ON AND WHILE DRIVING CAR PULLED LEFT INTO ONCOMING TRAFFIC LANE

THE EBCM DOES NOT WORK I'VE TRIED TO HAVE IT REPAIRED 3 TIMES NOW TOLD UNREPAIRABLE GM NO LONGER MAKES THE PART WITH SO MANY VETTE OWNERS HAVING THIS PROBLEM YOU WOULD WONDER WHY THERE ISN'T SOMETHING BEING DONE CAUSE NOW WE ARE DRIVING VEHICLE NOT THE WAY IT WAS INTENDED SPOKE TO GM MANY TIMES PRETTY TOLD DISCONTINUED SORRY TOO BAD YOUR ON YOUR OWN

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.

PREPURCHASE RECALL SEARCH.

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED OUTSIDE THE GARAGE AND THE IGNITION WAS STARTED, THE CLUTCH WAS RELEASED AND THE VEHICLE SEIZED. ALSO, THE STEERING COLUMN LOCK WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE CONTACT CALLED MAGUIRE CHEVROLET CADILLAC OF ITHACA (LOCATED AT 35 CINEMA DR, ITHACA, NY 14850, (607) 272-9292) AND NOTIFIED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,890. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN WAS MALFUNCTIONING. THE LOCKING PIN FOR THE ANTI-THEFT DEVICE FOR THE STEERING COLUMN WAS NOT WORKING AND STOPPED THE VEHICLE FROM MOVING. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 33,200.

THE FUEL TANK LEAKS WHEN THE ENGINE IS RUNNING. IN 2010, THIS CONDITION RESULTED IN AN ADDITIONAL WARRANTY FOR THE ISSUE THAT EXPIRED IN 2014, BUT I HAVE A LOWER MILEAGE CAR (LESS THAN 18,000 MILES) SO THE ISSUE DID NOT OCCUR UNTIL NOW. THE PROBLEM EMERGED SUDDENLY AFTER FULLY REFILLING THE FUEL TANK RECENTLY.

TL* THE CONTACT CALLED ON BEHALF OF AN OWNER OF A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO A FUEL LEAK. THE MECHANIC DETERMINED THAT THE PLASTIC OPENING OF THE FUEL TANK, WHICH CONNECTED A PRIMARY TANK TO THE SECONDARY TANK HOSE, WAS FRACTURED AND FUEL WAS LEAKING. THE VEHICLE NEEDED A NEW FUEL TANK AND CROSSOVER COMPONENTS. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

I BOUGHT A 2004 CORVETTE USED WITH 67K MILES ON IT. THE DEALERSHIP HAD ONLY FILLED THE TANK TO LESS THAN HALF FULL.,AFTER MY FIRST FILL UP GAS POURED OUT FROM UNDERNEATH, BEHIND DRIVERS SIDE TIRE. I PAID $ 16,500 FOR THE CAR , SO I TOOK IT BACK TO DEALER AND THEY SAID THEY WOULD REPAIR. AFTER ABOUT 10 DAYS I WENT TO DEALER AND NOTICED THE CAR HAD NOT EVEN MOVED. HE SAID THEY DID NOT KNOW HOW TO FIX IT AND THEY HAD ANOTHER DEALERSHIP IN ANOTHER STATE THAT THEY WOULD NEED TO TAKE IT TO. I LEFT WITH THE CAR UNREPAIRED.IS THERE ANYTHING I CAN DO ? I BELIEVE IT IS A RECALL ON THE CROSSOVER TUBE AND THE RECALL HAS EXPIRED. CLOSE TO A $1500 TO $1800 REPAIR

THERE IS A KNOWN LEAK IN THE LEFT FUEL TANK. MY VEHICLE HAS SYMPTOMS BUT WAS NEVER FIXED. VEHICLE IS 15 YEARS OLD BUT ONLY 76,000 MILES.

ONE DAY I NOTICED THAT MY GARAGE HAD A STRONG GAS SMELL. OVER TIME, I REALIZED THAT IF MY GAS TANK WAS APPROX. BELOW 1/3 FULL IT DID NOT SMELL. CHEVROLET INFORMED ME IT WAS COVERED FOR 100,000 MILES/10 YEARS WHICHEVER COMES FIRST. HOWEVER, I NEVER KNEW A RECALL COULD HAVE A TIME LIMIT BECAUSE OBVIOUSLY THIS IS A SAFETY ISSUE. I WROTE CHEVROLET A CERTIFIED LETTER DESCRIBING MY PROBLEM WITH NO RESPONSE. THIS IS A COMMON PROBLEM WHICH IS CONFIRMED BY LOOKING AT YOUR SITE.

GASOLINE VAPORS ARE LEAKING FROM FUEL VENT AND TRANSFER LINES, CREATING AN EXPLOSION HAZARD. THE PROBLEM IS MORE OF AN ISSUE WHEN PARKED ALLOWING A SPARK TO IGNITE THE FUEL VAPORS.

STRONG FUEL SMELL AFTER FILLING THE GAS TANK. GOES AWAY ONCE TANK IS LESS THAN 1/2 FULL AS READ BY THE GAUGE.

AFTER FILLING THE GAS TANK STRONG GAS SMELL COMING FROM FILL AREA BUT NO VISIBLE FUEL LEAK THE GAS SMELL DOES NOT GO AWAY AFTER DAYS AND MANY MILES DRIVEN.

TAKATA RECALL VISIBLE GASOLINE LEAKAGE AFTER VEHICLE HASN'T BEEN PARKED OVER A PERIOD OF MONTHS. THEN I BEGAN TO TAKE NOTES OF WHAT , WHEN , WHERE THIS LEAK WAS OCCURRING, I WOULD FILL THE TANK, PARK THE AUTO IN THE GARAGE . THE NEXT TIME I USED THE VEHICLE, A NOTICEABLE GAS ODOR, SPOT ON THE GARAGE FLOOR WAS NOTED. I STARTED TO PLACE A CARDBOARD UNDER THE FRONT END TO MORE READILY BE ABLE TO OBSERVE THE SUBSTANCE LEAKING. THE ODOR WAS UNMISTAKABLE. SEVERAL OCCURRENCES N SPOTTING IS EVIDENT AFTER HAVING PARKED IN MY GARAGE . THE AUTO WAS PARKED OVERNIGHT IN MY GARAGE. I AM LISTING THE LATEST CALENDAR DATE AND PHOTO. I HAVE OTHER DATES IN MY NOTEPAD. 2) MY SEATBELT OCCASIONALLY WILL NOT LOCK. I HEAR THE CLICK OF A SEATBELT LOCK THEN UPON DRIVING AWAY FROM MY HOME ~ ,25 MILES ~ MY SEATBELT UNLOCKED THROUGH NO FAULT OF MY OWN. 3) AIRBAG CANNOT BE CHECKED FOR EFFECTIVENESS .

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GALLES CHEVROLET (2801 UNIVERSITY BLVD NE, ALBUQUERQUE, MN 87107) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. THE VIN WAS NOT AVAILABLE.