2002 VOLKSWAGEN GOLF

7 recalls, 98 complaints - 322 TSBs

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/s... Read more

Consequence

A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy

Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

50 vehicles affected

Manufacturer: The Gates Corporation

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Defect Description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI... Read more

Consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

13,128 vehicles affected

Manufacturer: CARDONE INDUSTRIES, INC.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Defect Description

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence

THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy

DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR... Read more

1,002,000 vehicles affected

Manufacturer: VOLKSWAGEN OF AMERICA, INC

EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.

Consequence

THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.

Remedy

DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

410,000 vehicles affected

Manufacturer: VOLKSWAGEN OF AMERICA, INC

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).

Consequence

THIS CAN RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

55,000 vehicles affected

Manufacturer: VOLKSWAGEN OF AMERICA,INC

Complaint Statistics

98 total complaints 5 crashes 13 injuries

Top Reported Components

Component	Complaints
AIR BAGS:SIDE/WINDOW	16
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH	8
AIR BAGS	6
ENGINE AND ENGINE COOLING:ENGINE	6
ELECTRICAL SYSTEM	6
SEAT BELTS	3
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH	3
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	3
ENGINE AND ENGINE COOLING	3
ELECTRICAL SYSTEM:IGNITION	2

Incident date: May 28, 2025

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. No warning lights were illuminated. The vehicle was take... Read more

Incident date: Mar 24, 2017

WHILE DRIVING AT ABOUT 45 MILES PER HOUR, THE SIDE CURTAIN AND SEAT BOLSTER AIRBAGS DEPLOYED ON THEIR OWN. THERE WAS NO IMPACT TO THE VEHICLE THAT PRECEDED THIS INCIDENT. THE AIRBAGS SIMPLY DEPLOYED BY THEMSELVES. THIS SEEMS TO BE A RECURRING PROBLEM WITH THIS GENERATION OF VOLKSWAGENS: HTTP:/... Read more

Incident date: Jul 21, 2013

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF WITH A TDI ENGINE. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT HAD TO POP THE CLUTCH AND KILL THE IGNITION, BUT THE ENGINE CONTINUE TO OPERATE UNTIL THE VEHICLE RAN OUT OF FUEL. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND STAT... Read more

Incident date: Mar 8, 2011

TL* THE CONTACT OWNS 2002 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START IN RAINY WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE IGNITION COIL WOULD NEED TO BE REPLACED. THE CONTACT LOCATED A VOLUNTARY MANUFACTURERS RECALL FOR THE FAILURE BUT WAS ADVISED BY T... Read more

Incident date: Aug 7, 2010

ON SATURDAY AUG 7TH I WAS DRIVING MY 2002 VW GOLF ON THE HIGHWAY WHEN THE PASSENGER SIDE AIRBAG DEPLOYED. THE ROAD WAS SMOOTH WITH NO BUMPS OR POTHOLES, NOTHING HIT THE CAR, IT WAS TOTALLY SPONTANEOUS. LUCKILY THERE WERE NO PASSENGERS IN THE CAR. I HAVE CONTACTED MY LOCAL VW SERVICE SHOP AND WILL... Read more

Incident date: Jun 14, 2009

PASSENGER SIDE CURTAIN AIRBAG DEPLOYED WHILE TRAVELING DOWN THE HIGHWAY. NO COLLISION, CONSEQUENCES RINGING IN EARS. VOLKSWAGEN MADE REPAIR AT NO COST TO ME $3212.00. *TR

Incident date: Oct 2, 2007

AIR BAG LIGHT CAME ON. WHEN TAKEN IN FOR FIX IT WAS FOUND TO BE A FAULTY SWITCH IN THE DRIVER SIDE SEAT BELT BUCKLE. IT WAS JUST RECENTLY REPLACED AND SO FAR NO FURTHER PROBLEMS. *TR

Incident date: Apr 26, 2009

WHILE DRIVING MY WIFE WAS DRIVING OUR 2002 VW GOLF THE DRIVER SIDE WINDOW DROPPED. TURNS OUT ALL OVER THE INTERNET THERE ARE COMPLAINTS OF THE TABS HOLDING THE WINDOWS BREAKING. IN FACT WHEN I WAS AT THE DEALER I FELLOW OVERHEARD ME AND SAID HE HAD THE EXACT SAME PROBLEM ON HIS 2001 VW GTI. VW ... Read more

Incident date: Apr 26, 2009

Incident date: Jan 23, 2009

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF. WHILE DRIVING 70 MPH ON THE FREEWAY, THE PASSENGER SIDE AIR BAG SPONTANEOUSLY DEPLOYED. THERE WERE NO INJURIES, BUT THE CONTACT WAS CONCERNED ABOUT THE SUDDEN EXPLOSION. HE STATED THAT THE DEPLOYMENT OCCURRED WHILE HE WAS USING HIS CELLULAR PHONE. THE ... Read more

Incident date: Dec 18, 2008

THERE WAS A BRAKE SWITCH SHORT THAT CAUSED THE CAR TO BE STUCK IN PARK. SO IT HAD TO BE DRAGGED OUT AND WAS SENT TO VOLKSWAGEN SERVICE. *TR

Incident date: Oct 12, 2008

THE DRIVER'S SIDE WINDOW REGULATOR RECENTLY FAILED ON MY 2002 VW GOLF. THIS PART SECURES THE WINDOW TO THE POWER WINDOW MECHANISM, AND KEEPS THE WINDOW UP. THE FAILURE OCCURRED WHILE I WAS LEAVING A TOLL BOOTH. I PRESSED THE BUTTON TO RAISE THE WINDOW, HEARD A CRACK, AND THEN THE ENTIRE WINDOW VI... Read more

Incident date: Oct 8, 2008

HIGHWAY ON RAMP ENGINE REVVED UNCONTROLLABLY UNTIL FAILURE NEW ENGINE NEEDED. *TR

Incident date: Sep 15, 2008

AIR BAG LIGHT IS ON IN VEHICLE BECAUSE OF A POOR ELECTRICAL CONNECTION IN THE DRIVER'S SIDE SEAT BELT CLASP, WHICH WAS ALREADY REPLACED ONCE WHILE VEHICLE WAS STILL UNDER FACTORY WARRANTY, ABOUT 2YRS AND 30K MILES AGO. THE LOCKING MECHANISM OF THE SEAT BELT CLASP ITSELF STILL WORKS, HOWEVER, WHILE T... Read more

Incident date: Sep 15, 2008

Incident date: May 9, 2008

MY 2002 VW GOLF HAS A DEFECT IN THE IMMOBILIZER THAT DEALERS CAN NOT DIAGNOSE OR REPAIR. ONCE THE KEY IS TURNED OFF, THE CAR SOMETIMES WILL NOT RESTART. IT HAS BEEN TOWED TO THE DEALER ON MULTIPLE OCCASIONS - BUT AFTER A VARIABLE TIME INTERVAL THE CAR STARTS AGAIN. SINCE IT STARTS - THREE DEALER... Read more

Incident date: Oct 2, 2007

I HAVE A 2002 GOLF TDI WITH MANUAL WINDOWS. THE WINDOW REGULATOR CLIPS BROKE AND THE WINDOW DROPPED INTO THE DOOR. THIS IS A KNOWN ISSUE WITH VW'S THAT A SERVICE BULLETIN, (0603), IS OUT ON, BUT ONLY FOR POWER WINDOWS. THE PART THAT OS DEFECTIVE IS COMMON TO BOTH TYPES BUT SINCE MY WINDOWS ARE MANUA... Read more

Incident date: Aug 11, 2007

2002 VOLKSWAGEN GOLF HAS HAD NUMEROUS PROBLEMS. THE MOST RECENT PROBLEM IS THAT THE COIL SPRING BROKE WHILE THE CONSUMER WAS DRIVING CAUSING DAMAGE TO THE STRUT. NOW THE CONSUMER HAS TO PAY TO GET THE VEHICLE FIXED. *KB THE CONSUMER STATED THE PROBLEMS STARTED AFTER THE WARRANTY ENDED. THE BATTER... Read more

Incident date: Aug 11, 2007

Incident date: Jul 21, 2007

2002 VW GOLF WITH CRUISE CONTROL PROBLEM CUSTOMER STATES THAT THE CAR ACCELERATED INTO FIFTH GEAR WHEN SHE TOOK HER FOOT OFF THE BRAKE**CC THE CONSUMER DETERMINED THAT STEPPING ON THE BRAKE DID NOT DISENGAGE THE CRUISE CONTROL. THE CONSUMER STATED THE FOLLOWING DAY, WHEN HE BACKED HIS VEHICLE UP TO... Read more

Incident date: May 16, 2007

VEHICLE SLOWED DRAMATICALLY AT HIGHWAY SPEED DOWN TO 35 MPH, I HAD TO USE THE EMERGENCY BLINKERS TO GET TO THE SLOW LANE, A VERY DANGEROUS SITUATION ON A CONGESTED HIGHWAY. CLUTCH AND FLYWHEEL REPLACED, AND THE SAME FAILURE HAPPENED AGAIN WITH OEM PARTS ONLY 3 WEEKS LATER. *AK

Incident date: Jan 15, 2007

TL* - THE CONTACT STATED THAT THERE WAS DAMAGE TO THE CEILING ON THE FRONT DRIVERS SIDE AND THE REAR LEFT PASSENGER SIDE. ALSO, THE DRIVER'S SIDE SEAT BELT DID WORK ANYMORE. *AK

Incident date: Jan 15, 2007

TL* - THE CONTACT STATED THAT THERE WAS DAMAGE TO THE CEILING ON THE FRONT DRIVERS SIDE AND THE REAR LEFT PASSENGER SIDE. ALSO, THE DRIVER'S SIDE SEAT BELT DID WORK ANYMORE. *AK

Incident date: Dec 19, 2006

BRAKE LIGHTS ON MY 2002 VOLKSWAGEN GOLF ALL FAILED TO OPERATE. VW DEALER (CLASSIC VOLKSWAGEN IN ESCONDIDO, CA) DETERMINED THE PROBLEM WAS A DEFECTIVE BRAKE LIGHT SWITCH. VW DEALER REPLACED THE BRAKE LIGHT SWITCH. *JB

Incident date: Dec 24, 2006

TL* - THE CONTACT'S VEHICLE WOULD NOT GO INTO GEAR. THE CONTACT HAD THE CAR TOWED TO THE DEALER, AND THEY TOLD HIM THAT HE HAD A FAULTY BRAKE SWITCH WHICH KEPT THE CAR IN PARK. THE DEALER TOLD HIM THAT THEIR WAS A RECALL O FOR THIS PROBLEM, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK UP... Read more

Incident date: Dec 24, 2006

THERE IS A FAULTY BRAKE SWITCH WHICH CAUSES THE CAR TO BE LOCKED IN PARK. IT HAD TO BE TOWED TO A DEALER FOR REPAIRS. OTHER MODELS OF THE 2002 GOLF HAVE A RECALL FOR THE SAME PROBLEM.

Incident date: Dec 24, 2006

THERE IS A FAULTY BRAKE SWITCH WHICH CAUSES THE CAR TO BE LOCKED IN PARK. IT HAD TO BE TOWED TO A DEALER FOR REPAIRS. OTHER MODELS OF THE 2002 GOLF HAVE A RECALL FOR THE SAME PROBLEM.

Incident date: Dec 3, 2006

ROLL PIN THAT RETAINS DIFFERENTIAL SPIDER GEAR PIN BACKED OUT CAUSING LARGER PIN TO CONTACT INSIDE OF CASE. THE FAILURE INCLUDED A LARGE HOLE IN TRANSMISSION/ DIFFERENTIAL CASE, GEAR AND BEARING DAMAGE. *NM

Incident date: Nov 20, 2006

THE PASSENGER SIDE AIR BAGS IN MY '02 VW GOLF DEPLOYED FOR NO REASON WHEN I WENT FROM A STOP TO A START, BARELY GOING OVER 5 MPH. *NM

1 injured

Incident date: Nov 30, 2006

ALL BRAKE LIGHTS INOPERABLE. BULBS ARE FINE. THIS WILL LEAD TO AN ACCIDENT WHERE THE CAR IS REAR ENDED. THERE IS AN EXISTING RECALL, NHTSA CAMPAIGN ID NUMBER : 04V096000 HOWEVER, IT APPLIES TO THE 1999 TO 2002 VW JETTA ONLY. I DRIVE A GOLF, WHICH IS NOT COVERED BY THE RECALL CAMPAIGN, HOWEVER ... Read more

1 injured

Incident date: Nov 20, 2006

VW GOLF 2002 60K TURN SINGALS KEEP ON CLICKING. POSSIBLE LINK TO USING ARMORALL POLISH? *JB

Incident date: Sep 16, 2006

I HAVE A 2002 VW GOLF, THE BRAKE LIGHT SWITCH ON MY CAR HAS BROKEN 4 TIMES IN THE 4 YEARS I HAVE OWNED THIS CAR. THE LAST TIME IT HS HAPPENED MY CAR WOULDN'T SHIFT OUT OF PARK AND I HAD TO GET MY CAR TOWED. EACH TIME THE BRAKE LIGHT SWITCH WAS FOUND TO BE FAULTY AND IT WAS REPLACED. THIS IS A VERY F... Read more

Incident date: Aug 2, 2006

FRONT PASSENGER SIDE WINDOW COMES OFF TRACK. WINDOW FALLS INTO DOOR AND WINDOW CAN NOT BE CLOSED. THIS HAPPENED TO ME AS I WAS DRIVING WITH MY 8 WEEK OLD DAUGHTER AND 3 YEAR OLD SON. IT IS VERY DANGEROUS BECAUSE IT HAPPENED ON HIGHWAY AND THERE WAS ALOT OF WIND COMING INTO CAR ON YOUNG CHILDREN. ... Read more

Incident date: Jun 9, 2006

TO WHOM IT MAY CONCERN, MY WIFE AND I OWN A WHITE, 2002, VOLKSWAGEN GOLF. MY WIFE HAS HAD THE OIL CHANGED ON THE VEHICLE AT A JIFFY LUBE IN NAPA, CA. SINCE OWNING THE VEHICLE. RECENTLY SHE NOTICED AN OIL LEAK. MY WIFE TOOK HER VEHICLE TO A MECHANIC IN CLEARLAKE, CA. THE MECHANIC FOUND THE OIL F... Read more

Incident date: Jul 9, 2002

THE BRAKE LIGHT SWITCH ON THE GOLF IS THE SAME BRAKE LIGHT SWITCH ON THE JETTA. THEY HAVE THE SAME PART NUMBER AND EVERYTHING. THEY ALSO FAIL AT THE SAME RATE, BUT ONLY THE JETTA BRAKE LIGHT SWITCH WAS RECALLED. WHEN IT FAILS, YOU CANNOT GET THE CAR OUT OF PARK AND YOUR BRAKE LIGHTS WORK INTERMITTE... Read more

Incident date: Jan 31, 2006

I HAD AN OIL CHANGE DONE ON MY CAR AND THE DRAIN PLUG STRIPED OUT THE THREADS. THE OIL PAN IS MADE OF ALUMINUM AND THE PLUG IS MADE OF STEEL. *NM

Incident date: Jun 16, 2006

I WAS DRIVING DOWN THE PARKS HIGHWAY NEAR TALKEETNA, ALASKA IN MY 2002 VW GOLF AND HAD THE SIDE-CURTAIN AND PASSENGER SEAT AIRBAGS DEPLOY SUDDENLY FOR NO APPARENT REASON. 5 PERSONS WERE IN THE CAR, ALL EXPERIENCED A LOUD BANG AND A CAR FULL OF ACRID SMOKE, TWO WERE STRUCK AS THE BAG DEPLOYED. I STOP... Read more

1 injured

Incident date: May 25, 2006

SPONTANEOUS AIR BAG DEPLOYMENT ON RIGHT SIDE OF MY 2 DOOR 2002 VW GOLF TDI WHILE DRIVING ON A SMOOTH BLACKTOP ROAD. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE LEFT SIDE CURTAIN AND SEAT AIR BAGS DEPLOYED BY THEM SELVES. THE VEHICLE DID NOT HIT A BUMP OR POTHOLE OR ANYTHING ELSE IN THE ROAD. THE VEHI... Read more

1 injured

Incident date: May 22, 2006

HELLO, MY WIFE HAS A VOLKSWAGEN GOLF. HER VOLKSWAGEN IS HAVING CERTAIN PROBLEMS WITH THE ELECTRICAL SYSTEM. THE SUNROOF IS OPERATING WHEN THE CAR IS ON OR OFF BY ITSELF. RAIN IS SOME HOW GETTING INTO THE CAR AND INTO THE OVERHEAD LIGHT. HER TAIL LIGHTS HAVE A MIND OF THERE OWN. SO DAYS THE TAI... Read more

Incident date: Feb 18, 2006

THE CAR HAS A TILT/TELESCOPE STEERING COLUMN, AFTER ADJUSTING THE COLUMN THE TURN SIGNALS QUIT WORKING. COULD NOT RESTART THE CAR AFTER TURNING IT OFF BECAUSE IMMOBILIZER WOULD NOT RECOGNIZE THE KEY. MULTIPLE FUSES WERE BLOWN OUT, INCLUDING THE ONE FOR THE HAZARD FLASHER. UPON INVESTIGATION THE F... Read more

Incident date: Feb 18, 2006

Incident date: Dec 14, 2005

BURNING SMELL OCCURRED ON OFF-HIGHWAY ROAD, TRAVELING AT SPEEDS UNDER 5 MPH. HOT SENSATION ON THIGH PROMPTED QUICK ACTION TO TURN OFF VEHICLE / SEAT HEATER WHILE GETTING OUT OF THE VEHICLE A 1/4" HOLE WAS FOUND ON THE LEFT SIDE OF THE DRIVERS SEAT. HARNESS WAS DISCONNECTED AND SERVICE WAS SCHEDULED.... Read more

1 injured

Incident date: Jan 10, 2002

1. TRANSMISSION CONTROL MODULE FAILURE. CAR WAS NOT ABLE TO START. WAS TOWED FOR REPAIR. THIS CHIP HAS BEEN REPLACED TWICE. 2. CAR BEGAN MAKING SEVERE JERKING MOVEMENTS, RANDOMLY. USUALLY THESE JUMPS OCCUR WITHIN THE FIRST 10 MINUTES OF DRIVING THE VEHICLE BUT CAN OCCUR LATER. THE SEVERITY O... Read more

Incident date: Jan 10, 2002

Showing 50 of 98 complaints.

EPA Fuel Economy, 2002 VOLKSWAGEN GOLF

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.9L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	29.0	40.0	33.0	Diesel	$2,350
1.9L 4-cyl, Manual 5-spd (Front-Wheel Drive)	35.0	44.0	38.0	Diesel	$2,050
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	20.0	27.0	23.0	Regular	$2,700
2.0L 4-cyl, Manual 5-spd (Front-Wheel Drive)	21.0	28.0	24.0	Regular	$2,600

CO2 Emissions: -1.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2002 VOLKSWAGEN GOLF

322 manufacturer communications from 191 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	39
110000 ELECTRICAL SYSTEM	30
350000 EQUIPMENT	28
060000 ENGINE AND ENGINE COOLING	19
118000 ELECTRICAL SYSTEM:SOFTWARE	14
060000 ENGINE (PWS)	14
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	13
980000 UNKNOWN OR OTHER	10

060000 ENGINE AND ENGINE COOLING

Update to Volkswagen engine oil standards

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

Volkswagen Engine oil quality standards, update to attachments.

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

Engine oil quality standards, update to attachments.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update model year applicability to include 2023.

110000 ELECTRICAL SYSTEM

Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.

118000 ELECTRICAL SYSTEM:SOFTWARE

This bulletin contains general instructions for software updates.

060000 ENGINE AND ENGINE COOLING

Update engine oil quality standard lists (attachments)

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Tool number added to table. Removal of Behr Flush Kit. VAS 6337/1A

353000 EQUIPMENT:ELECTRICAL

Updated to include additional models and model year applicability.

980000 UNKNOWN OR OTHER

Parts are currently blocked from sale at this time.

350000 EQUIPMENT

Quick Reference Update Guide.

110000 ELECTRICAL SYSTEM

Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Update vehicle metadata.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Update vehicle metadata.

350000 EQUIPMENT

The part number listed in the document is to be returned if it meets the criteria provided.

350000 EQUIPMENT

Alternative method for radio code retrieval.

110000 ELECTRICAL SYSTEM

Alternative method for radio code retrieval.

060000 ENGINE (PWS)

Engine Oils Which Meet Volkswagen Oil Quality Standards

060000 ENGINE AND ENGINE COOLING

Gasoline Engine Misfire Diagnosis document

110000 ELECTRICAL SYSTEM

Battery Testing and Charging instruction. Updated to include model year 2019 applicability.

120000 EXTERIOR LIGHTING

Condensation and or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Update vehicle metadata.

060000 ENGINE (PWS)

Engine replacement tip

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

To include an additional model year applicability.

350000 EQUIPMENT

To include an additional model year applicability.

118000 ELECTRICAL SYSTEM:SOFTWARE

Update content and include additional models and model year applicability.

110000 ELECTRICAL SYSTEM

This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.

118000 ELECTRICAL SYSTEM:SOFTWARE

Tip for Scan tool concerns that may occur duing a test plan

353000 EQUIPMENT:ELECTRICAL

Update to model year applicability.

110000 ELECTRICAL SYSTEM

Update to model year applicability.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Updated to include model year 2014 thru 2018 applicability.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Updated to include model year 2014 thru 2018 applicability.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update to existing tip for fuel quality checking.

060000 ENGINE AND ENGINE COOLING

17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards

350000 EQUIPMENT

This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.

350000 EQUIPMENT

VAS 6154 Replacement Part Setup Guide

118000 ELECTRICAL SYSTEM:SOFTWARE

Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update model year applicability to include 2017.

350000 EQUIPMENT

Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Update to model year applicability.

060000 ENGINE (PWS)

Update to include additional model year applicability.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update model and model year applicability.

350000 EQUIPMENT

Contacting the parts helpline

160000 STRUCTURE

Contacting the parts helpline

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Data Link connector pin assignment chart that is applicable to all models. Update model year applicability.

162000 STRUCTURE:BODY

TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT.

162800 STRUCTURE:BODY:HOOD

Corrosion may be found on the folded edge of the hood. Supersedes TB V551603

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

To update Claim processing statement.

162200 STRUCTURE:BODY:BUMPERS

TO UPDATE CLAIM PROCESSING STATEMENT.

118000 ELECTRICAL SYSTEM:SOFTWARE

Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.

162000 STRUCTURE:BODY

Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi

180000 VEHICLE SPEED CONTROL

Corrosion on hood edge.

162800 STRUCTURE:BODY:HOOD

Corrosion on hood edge.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Fuel Additive to Help Prevent Sporadic Misfire Faults

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Quick reference update guide.

118000 ELECTRICAL SYSTEM:SOFTWARE

Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

Gasoline quality.

070000 FUEL SYSTEM, GASOLINE

Technical tips on what to do if improper gasoline has been added to the vehicle.

200000 WHEELS

Corrosion, Front fenders, at upper wheel opening.

162000 STRUCTURE:BODY

Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu

200000 WHEELS

350000 EQUIPMENT

Technical Bulletins.

160000 STRUCTURE

Technical Bulletins.

200000 WHEELS

Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only)

140000 AIR BAGS

Airbag Issues.

200000 WHEELS

Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.

162000 STRUCTURE:BODY

Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace

200000 WHEELS

Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace

130000 VISIBILITY

Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w

160000 STRUCTURE

Technical Bulletin (Corrosion on the Fold of the Front Inner Door): Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. This document contains information on how to diagnose, and service this

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin

132000 VISIBILITY:GLASS, SIDE/REAR

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

132000 VISIBILITY:GLASS, SIDE/REAR

Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes,

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document

120000 EXTERIOR LIGHTING

Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw

162300 STRUCTURE:BODY:DOOR

Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available

070000 FUEL SYSTEM, GASOLINE

Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers

200000 WHEELS

Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.

160000 STRUCTURE

Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.

060000 ENGINE AND ENGINE COOLING

VW Elsa Newsletter

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

VW Elsa Newsletter

346000 COMMUNICATION:MANUFACTURER TELEMATICS

Quick Reference Update Guide

160000 STRUCTURE

VW Elsa Newsletter

110000 ELECTRICAL SYSTEM

VW Elsa Newsletter

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

VW Elsa Newsletter

Showing 100 of 322 bulletins.

NHTSA Safety Investigations, VOLKSWAGEN GOLF

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2019

Vehicle Stalling - Manual Transmission

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited o... ccurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.Read more

DP, Closed , Model Year: 2000

ENGINE STALLING

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MU... LTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2001

INADVERTENT SIDE-AIRBAG DEPLOYMENT

THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE... Read more

PE, Closed , Model Year: 1999

FUEL PUMP LEAKS

THIS INVESTIGATION WAS OPENED ON NOVEMBER 29, 2004, BASED ON FIVE CONSUMER REPORTS ALLEGING FUEL LEAKING FROM THE FUEL PUMP.BY LETTER OF APRIL 14, 2004, VOLKSWAGEN OF AMERICA (VOLKSWAGEN) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 35,000 GOLF AND GTI VEHICLES MANUFACTURED IN WOLFSBU... Read more

PE, Closed , Model Year: 2000

TURN SIGNAL/HAZARD FLASHER FAILURE

THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF T... Read more

PE, Closed , Model Year: 1995

HOOD LATCH FAILURE

ODI HAS RECEIVED THREE REPORTS, INCLUDING THE PETITIONERS, REGARDING ALLEGED HOOD LATCH FAILURES.ALL OF THE ODI REPORTS INDICATE THE HOOD FLEW UP WHILE DRIVING.FOLLOWING A TELEPHONE INQUIRY, VOLKSWAGEN PROVIDED ODI WITH SOME LIMITED INFORMATION REGARDING SIX ADDITIONAL REPORTS OF HOOD FLY-UP FOR MOD... Read more

DP, Closed , Model Year: 1995

HOOD FLY-UP

There is no summary currently available

EA, Closed , Model Year: 1990

DETACHMENT OF BUMPER COVER

There is no summary currently available

PE, Closed , Model Year: 1990

DETACHMENT OF BUMPER COVER

There is no summary currently available

EA, Closed , Model Year: 1986

WINDSHIELD WIPERS

===

PE, Closed , Model Year: 1987

HEATER CORE RUPTURE

There is no summary currently available

PE, Closed , Model Year: 1986

WINDSHIELD WIPER FAILURE

There is no summary currently available

VOLKSWAGEN GOLF - All Years Overview

Complete safety history for the VOLKSWAGEN GOLF across all model years (1985, 2021).

169 Total Recalls

2,099 Total Complaints

12 Investigations

91 Reported Crashes

48 Reported Fires

1 Reported Deaths

VOLKSWAGEN GOLF - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2023	0	22	View
2022	0	132	View
2021	1	11	View
2020	2	8	View
2019	6	88	View
2018	6	38	View
2017	5	145	View
2016	9	115	View
2015	12	183	View
2014	5	14	View
2013	5	67	View
2012	6	68	View
2011	6	151	View
2010	4	97	View
2009	0	5	View
2008	0	1	View
2007	0	2	View
2006	3	16	View
2005	4	27	View
2004	6	33	View
2003	6	33	View
2002 (current)	7	98
2001	9	152	View
2000	8	118	View
1999	7	76	View
1998	1	28	View
1997	0	25	View
1996	1	74	View
1995	5	84	View
1994	5	57	View
1993	5	11	View
1992	2	6	View
1991	3	11	View
1990	5	10	View
1989	4	41	View
1988	6	9	View
1987	4	4	View
1986	5	20	View
1985	6	15	View

Other VOLKSWAGEN Models

Model	Recalls	Complaints
JETTA	249	14,075	View
PASSAT	185	10,492	View
BEETLE	157	3,629	View
GTI	116	1,926	View
ID.4	115	1,606	View
ATLAS	101	2,700	View
TIGUAN	78	3,173	View
ATLAS CROSS SPORT	73	701	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2002 VOLKSWAGEN GOLF

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2002 VOLKSWAGEN GOLF

Technical Service Bulletins, 2002 VOLKSWAGEN GOLF

Most Affected Components

NHTSA Safety Investigations, VOLKSWAGEN GOLF

VOLKSWAGEN GOLF - All Years Overview

VOLKSWAGEN GOLF - Year by Year

Other VOLKSWAGEN Models