THIS IS FOR TIRE SIZE P265 75 16. To start, I've seen multiple other complaints describing the same scenario and type of incident. Driving along the highway at appropriate speeds, I hear a whoosh/deep pitch rumble, then my vehicle began to vibrate violently. I was luckily able to pull over but had to swerve to regain control of my vehicle once the rumbling and vibration got too severe since it happened so quickly. Witnessed my driver side rear tire completely shredded, no damage along tread material, only on sidewall with multiple tears/punctures. This was a center lane on the highway with no debris. I'm now noticing other similar "tear/wear" signs on my other 3 tires on the vehicle. All specifically on the sidewall along the aggressive tread that the AT3W tires were known to have for extra grip. It just seems to be separating over time.
The contact owns a 2002 Toyota 4Runner. The contact stated that while inspecting underneath the vehicle, he noticed that there was a hole in the subframe and that the subframe and sway bar were corroded. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
The contact owns a 2002 Toyota 4Runner. The contact stated that while inspecting underneath the vehicle, he noticed that there was a hole in the subframe and that the subframe and sway bar were corroded. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
The contact owns a 2002 Toyota 4Runner. The contact stated while pulling the door handle to unlock the doors, the auto unlock function failed to unlock the doors. The contact had to press the unlock button to unlock the vehicle. The vehicle was taken to the dealer to be diagnosed and the dealer stated that a failure was not found. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 150,000.
Frame is excessively rusted. The recall that already exists for this issue only covers certain frames from Japan made with this steel. However, the same frames were imported to America and a large percentage of 4Runners were made with the same steel and didn’t receive a recall. Mine is one of them.
frame rust saftey hazardous? midas mechanic pointed out to me while work being done on exhaust march 2022
The contact owns a 2002 Toyota 4Runner. The contact stated that while driving 60 MPH through a slight right curve, the vehicle independently shifted from side to side without warning nearly causing the vehicle to flip. The contact had an independent mechanic inspect the vehicle and the mechanic discovered severe corrosion throughout the entire subframe of the vehicle. The mechanic informed him that the entire subframe needed to be replaced to ensure safe driving. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 115,000.
The contact owns a 2002 Toyota 4Runner. The contact stated that while driving 60 MPH through a slight right curve, the vehicle independently shifted from side to side without warning nearly causing the vehicle to flip. The contact had an independent mechanic inspect the vehicle and the mechanic discovered severe corrosion throughout the entire subframe of the vehicle. The mechanic informed him that the entire subframe needed to be replaced to ensure safe driving. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 115,000.
Frame rusted through from the inside out. There isnt even any surface rust where the hole started. Its just a hole in the middle of clean metal. The rest of the frame rail is solid. Rear suspension arm mount is also rusted out and starting to come off. The entire structural integrity of the frame is in question, even though externally, theres only slight surface rust. The frame should not be rusting this way.
Premature rusted frame throughout, vehicle is garaged and well maintained 117,000 miles on my 2002 Toyota 4Runner. Auto body specialist estimates $3k-$4k to restore, at least.
Frame and rear passenger control arm bracket, rotted out .only there, 2 nd time this has happened, same spot but on my previous 2001 4runner
Frame and rear passenger control arm bracket, rotted out .only there, 2 nd time this has happened, same spot but on my previous 2001 4runner
Had vehicle inspected on Oct. 1 ,2021 for road trip to North Carolina from Washington, DC. Was informed that my vehicle is unsafe by the automotive shop (name withheld) due to [rusting] frame front suspension components' threads rusted off on bolts that hold suspension, control arms, and shocks on both front and rear areas + body of vehicle located where shocks bolt to the body. I also had two other shops (names withheld) assess the state of the frame and suspension + and was told that the vehicle has maybe 1 year or so until the frame falls apart. Given I am the original owner, have gargage-kept my vehicle, have very low-mileage - 74,000 miles, and have maintained the vehicle immaculately and am aware of rusting problems with other Toyota [truck] frames, etc. this seems to be a defect in the manufacturing process. I know there have been recalls on Toyota's other trucks due to Toyota's failure to add [enough?] rust inhibitor/preventative to the molten steel when forming the frame for many models of their trucks.
Had vehicle inspected on Oct. 1 ,2021 for road trip to North Carolina from Washington, DC. Was informed that my vehicle is unsafe by the automotive shop (name withheld) due to [rusting] frame front suspension components' threads rusted off on bolts that hold suspension, control arms, and shocks on both front and rear areas + body of vehicle located where shocks bolt to the body. I also had two other shops (names withheld) assess the state of the frame and suspension + and was told that the vehicle has maybe 1 year or so until the frame falls apart. Given I am the original owner, have gargage-kept my vehicle, have very low-mileage - 74,000 miles, and have maintained the vehicle immaculately and am aware of rusting problems with other Toyota [truck] frames, etc. this seems to be a defect in the manufacturing process. I know there have been recalls on Toyota's other trucks due to Toyota's failure to add [enough?] rust inhibitor/preventative to the molten steel when forming the frame for many models of their trucks.
Had vehicle inspected on Oct. 1 ,2021 for road trip to North Carolina from Washington, DC. Was informed that my vehicle is unsafe by the automotive shop (name withheld) due to [rusting] frame front suspension components' threads rusted off on bolts that hold suspension, control arms, and shocks on both front and rear areas + body of vehicle located where shocks bolt to the body. I also had two other shops (names withheld) assess the state of the frame and suspension + and was told that the vehicle has maybe 1 year or so until the frame falls apart. Given I am the original owner, have gargage-kept my vehicle, have very low-mileage - 74,000 miles, and have maintained the vehicle immaculately and am aware of rusting problems with other Toyota [truck] frames, etc. this seems to be a defect in the manufacturing process. I know there have been recalls on Toyota's other trucks due to Toyota's failure to add [enough?] rust inhibitor/preventative to the molten steel when forming the frame for many models of their trucks.
The contact owns a 2002 Toyota 4Runner. The contact stated that while receiving routine maintenance repair on the vehicle, the independent mechanic informed the contact that the subframe was rusted. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 136,000.
After having my 4 runner in for routine maintenance, my mechanic informed me that my frame was in bad condition and rusting through. Doubtful it has a year left and he advised me to junk it as fast as I can. 180;000 miles - so much for Toyota’s lasting a long time.
After having my 4 runner in for routine maintenance, my mechanic informed me that my frame was in bad condition and rusting through. Doubtful it has a year left and he advised me to junk it as fast as I can. 180;000 miles - so much for Toyota’s lasting a long time.
After having my 4 runner in for routine maintenance, my mechanic informed me that my frame was in bad condition and rusting through. Doubtful it has a year left and he advised me to junk it as fast as I can. 180;000 miles - so much for Toyota’s lasting a long time.
FRAME IS SHOWING EXCESSIVE RUST ALL OVER, A KNOWN PROBLEMS WITH 4RUNNERS AND TOYOTA TRUCKS. AUTO REPAIR SHOP SAYS VEHICLE PROBABLY HAS ONLY 1 YEAR OF LIFE LEFT BEFORE UNSAFE AND UNDRIVABLE. CAR HAS ONLY 100000 MILES ON IT, 1998 4RUNNER WE HAD MADE IT TO 250000 MILES- UNACCEPTABLE.
I RECENTLY HAD MY VEHICLE IN FOR SERVICE AND TO GET NEW TIRES. WHILE ON THE LIFT, THE MECHANIC POINTED OUT TO ME THAT THE FRAME ON THE PASSENGER'S SIDE IS BEGINNING TO RUST THROUGH. THIS IS AN OBVIOUS POTENTIAL SAFETY ISSUE AND AS I HAVE RESEARCHED POSSIBLE REPAIRS, IT APPEARS THAT THIS IS A VERY COMMON PROBLEM FOR THIS YEAR AND MODEL. THIS SHOULD BE RECALLED.
THE FRAME HAS RUSTED AT THE PASSENGER SIDE REAR CONTROL ARM MOUNT TO THE POINT OF NOT PASSING INSPECTION.
THE FRAME IS RUSTED OUT AND IS MAKING THE VEHICLE UNSAFE TO BE ON THE ROAD. THIS IS A KNOWN PROBLEM WITH THIS FRAME, IT'S ALREADY BEEN RECALLED ON THE TOYOTA TACOMA AND IT'S THE SAME IDENTICAL FRAME. IT SHOULD HAVE BEEN RECALLED YEARS AGO. JUST MAKING A NORMAL TURN ON A BEND IN THE ROAD MAKES IT DIFFICULT TO KEEP THE VEHICLE UNDER CONTROL.
THE FRAME IS RUSTED OUT AND IS MAKING THE VEHICLE UNSAFE TO BE ON THE ROAD. THIS IS A KNOWN PROBLEM WITH THIS FRAME, IT'S ALREADY BEEN RECALLED ON THE TOYOTA TACOMA AND IT'S THE SAME IDENTICAL FRAME. IT SHOULD HAVE BEEN RECALLED YEARS AGO. JUST MAKING A NORMAL TURN ON A BEND IN THE ROAD MAKES IT DIFFICULT TO KEEP THE VEHICLE UNDER CONTROL.
EXCESSIVE RUST ON THE FRAME. HAVE HEARD OF OTHER TOYOTAS FROM THE SAME TIME THAT WERE RECALLED BUT NOT THE 4RUNNER EVEN THOUGH IT SUFFERS THE SAME ISSUES.
EXCESSIVE RUST ON THE FRAME. HAVE HEARD OF OTHER TOYOTAS FROM THE SAME TIME THAT WERE RECALLED BUT NOT THE 4RUNNER EVEN THOUGH IT SUFFERS THE SAME ISSUES.
HAD THE 4RUNNER WV STATE INSPECTED. NEEDED TO REPLACE THE MUFFLER. NOTICED THE FRAME CRACKED ON FRAME RAIL NEAR MUFFLER LOCATION.
FRAME IS RUSTED. DEEMED UNSAFE TO DRIVE
2002 TOYOTA 4RUNNER, ORIGINAL OWNER WITH ONLY 110,900 ORIGINAL MILES ON IT! VEHICLE HAS SEVERE RUST/ROT DAMAGE TO PASSENGER AND DRIVER SIDE FRAME. EXTENDS FROM MIDDLE CROSS MEMBER TO REAR CROSS MEMBER. THE REST OF THE CAR IS IN EXCELLENT CONDITION AND WELL MAINTAINED. SAFETY ISSUE FOR MY FAMILY. REPAIR WILL BE NECESSARY SOON, AS I'M STARTING TO NOT FEEL SAFE DRIVING LONG DISTANCES OR AT HIGHWAY SPEEDS (70+ MPH). THANK YOU!
THE VEHICLE IS IN IMPECCABLE CONDITION. THE FRAME IS RUSTED THROUGH IN THE AREA OF THE PASSENGER SIDE ABOVE THE TRAILING ARMS AND THE MIDDLE SECTION OF THE RAIL. I BOUGHT THE VEHICLE IN 2006 AND HAVE BABIED THE VEHICLE.
I FOUND FRAME RUST WITH PERFORATION ON MY 02 TOYOTA 4RUNNER
I FOUND FRAME RUST WITH PERFORATION ON MY 02 TOYOTA 4RUNNER
FRAME WAS RUSTED THROUGH AND TRUCK WAS NOT SAFE TO DRIVE
FRAME HAS RUSTED THROUGH TO THE POINT OF BEING A DANGER TO DRIVE MY VEHICLE. FRAME DID NOT EASILY APPEAR RUSTED WHEN I PURCHASED MY VEHICLE 4 YEARS AGO. IT APPEARS THAT THE FRAME RUSTED FROM THE INSIDE OUT AND THE COATING CONCEALED THE DAMAGE UNTIL IT WAS TOO LATE TO REPAIR. MY VEHICLE DRIVES PERFECTLY BUT IS NOT SAFE DUE TO THE FRAME DAMAGE. *TR
TL* THE CONTACT OWNS A 2002 TOYOTA 4RUNNER. THE CONTACT BECAME AWARE THAT THE SUBFRAME UNDERNEATH THE VEHICLE WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE REPAIR WAS STILL PENDING. TOYOTA OF LINCOLN PARK (1561 N FREMONT ST, CHICAGO, IL 60642) WAS CONTACTED BY PHONE AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE DEALER WAS UNABLE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS NOT AVAILABLE.
WHEN I HAD MY STATE INSPECTION IN JANUARY OF 2020, THE MACHANIC TOLD ME THE FRAME OF THE VEHICLE WILL NOT PASS INSPECTION AGAIN. IT IS SEVERELY RUSTED THROUGH AND IN HIS OPINION IS UNSAFE TO DRIVE. A FEW WEEKS LATER, I WAS TRAVELLING TO MY FATHER'S RESIDENCE AND THE BRAKES GAVE OUT. THE TECHNICIAN THAT REPAIRED MY BRAKE LINE ALSO TOLD ME AND DOCUMENTED ON THE BILL THAT THE TRUCK IS REALLY NOT SAFE TO DRIVE. I HAVE OWNED THIS VEHICLE FOR 18 YEARS, AND ONLY DRIVEN IT FIVE WINTERS. I WASH THE TRUCK NUMEROUS TIMES DURING THE WINTER TO REMOVE SALT. IT IS MY ONLY VEHICLE, AND I CANNOT AFFORD A NEW ONE. WHY WASN'T THIS INCLUDED IN THE FRAME RECALL FROM TOYOTA?!? NOW I'M NERVOUS ABOUT MY SAFETY AND THOSE ON THE ROADWAYS.
WHEN I HAD MY STATE INSPECTION IN JANUARY OF 2020, THE MACHANIC TOLD ME THE FRAME OF THE VEHICLE WILL NOT PASS INSPECTION AGAIN. IT IS SEVERELY RUSTED THROUGH AND IN HIS OPINION IS UNSAFE TO DRIVE. A FEW WEEKS LATER, I WAS TRAVELLING TO MY FATHER'S RESIDENCE AND THE BRAKES GAVE OUT. THE TECHNICIAN THAT REPAIRED MY BRAKE LINE ALSO TOLD ME AND DOCUMENTED ON THE BILL THAT THE TRUCK IS REALLY NOT SAFE TO DRIVE. I HAVE OWNED THIS VEHICLE FOR 18 YEARS, AND ONLY DRIVEN IT FIVE WINTERS. I WASH THE TRUCK NUMEROUS TIMES DURING THE WINTER TO REMOVE SALT. IT IS MY ONLY VEHICLE, AND I CANNOT AFFORD A NEW ONE. WHY WASN'T THIS INCLUDED IN THE FRAME RECALL FROM TOYOTA?!? NOW I'M NERVOUS ABOUT MY SAFETY AND THOSE ON THE ROADWAYS.
WHEN I HAD MY STATE INSPECTION IN JANUARY OF 2020, THE MACHANIC TOLD ME THE FRAME OF THE VEHICLE WILL NOT PASS INSPECTION AGAIN. IT IS SEVERELY RUSTED THROUGH AND IN HIS OPINION IS UNSAFE TO DRIVE. A FEW WEEKS LATER, I WAS TRAVELLING TO MY FATHER'S RESIDENCE AND THE BRAKES GAVE OUT. THE TECHNICIAN THAT REPAIRED MY BRAKE LINE ALSO TOLD ME AND DOCUMENTED ON THE BILL THAT THE TRUCK IS REALLY NOT SAFE TO DRIVE. I HAVE OWNED THIS VEHICLE FOR 18 YEARS, AND ONLY DRIVEN IT FIVE WINTERS. I WASH THE TRUCK NUMEROUS TIMES DURING THE WINTER TO REMOVE SALT. IT IS MY ONLY VEHICLE, AND I CANNOT AFFORD A NEW ONE. WHY WASN'T THIS INCLUDED IN THE FRAME RECALL FROM TOYOTA?!? NOW I'M NERVOUS ABOUT MY SAFETY AND THOSE ON THE ROADWAYS.
RUST/ROT DAMAGE TO PASSENGER SIDE FRAME. EXTENDS FROM MIDDLE CROSS MEMBER TO REAR CROSS MEMBER. ALSO SIGNIFICANT RUST DAMAGE TO REAR SHOCK MOUNTS. FAILED INSPECTION AS A RESULT. THE REST OF THE CAR IS IN EXCELLENT CONDITION AND WELL MAINTAINED. SAFETY ISSUE FOR MY FAMILY.
I HAVE A 2002 TOYOTA 4RUNNER WITH A SEVERELY RUSTED FRAME. MY VEHICLE HAS LESS THAN 70K ORIGINAL MILES ON IT, NO BODY RUST, BUT AN EXTREMELY RUSTED UNDERCARRIAGE AND FRAME. I FEEL IT IS UNSAFE TO CONTINUALLY DRIVE WITH THIS PROBLEM, AS IT WILL ONLY GET WORSE AND COULD AFFECT OTHER COMPONENTS SUCH AS STEERING, SUSPENSION, BRAKES, ETC. SEEING AS HOW TOYOTA HAS ALREADY HAD A CLASS ACTION LAWSUIT AGAINST THEIR TRUCKS OF THE SAME YEAR FOR UNSAFE RUSTED FRAMES, I FEEL MY 4RUNNER SHOULD BE INCLUDED IN THE FRAME REPLACEMENT RECALL.
I HAVE A 2002 TOYOTA 4RUNNER WITH A SEVERELY RUSTED FRAME. MY VEHICLE HAS LESS THAN 70K ORIGINAL MILES ON IT, NO BODY RUST, BUT AN EXTREMELY RUSTED UNDERCARRIAGE AND FRAME. I FEEL IT IS UNSAFE TO CONTINUALLY DRIVE WITH THIS PROBLEM, AS IT WILL ONLY GET WORSE AND COULD AFFECT OTHER COMPONENTS SUCH AS STEERING, SUSPENSION, BRAKES, ETC. SEEING AS HOW TOYOTA HAS ALREADY HAD A CLASS ACTION LAWSUIT AGAINST THEIR TRUCKS OF THE SAME YEAR FOR UNSAFE RUSTED FRAMES, I FEEL MY 4RUNNER SHOULD BE INCLUDED IN THE FRAME REPLACEMENT RECALL.
I HAVE A 2002 TOYOTA 4RUNNER WITH A SEVERELY RUSTED FRAME. MY VEHICLE HAS LESS THAN 70K ORIGINAL MILES ON IT, NO BODY RUST, BUT AN EXTREMELY RUSTED UNDERCARRIAGE AND FRAME. I FEEL IT IS UNSAFE TO CONTINUALLY DRIVE WITH THIS PROBLEM, AS IT WILL ONLY GET WORSE AND COULD AFFECT OTHER COMPONENTS SUCH AS STEERING, SUSPENSION, BRAKES, ETC. SEEING AS HOW TOYOTA HAS ALREADY HAD A CLASS ACTION LAWSUIT AGAINST THEIR TRUCKS OF THE SAME YEAR FOR UNSAFE RUSTED FRAMES, I FEEL MY 4RUNNER SHOULD BE INCLUDED IN THE FRAME REPLACEMENT RECALL.
WHEN THE CHECK ENGINE LIGHT IS ILLUMINATED, THE TRACTION CONTROL AND ANTI LOCK BRAKE FEATURES ARE AUTOMATICALLY DISABLED.
WHEN THE CHECK ENGINE LIGHT IS ILLUMINATED, THE TRACTION CONTROL AND ANTI LOCK BRAKE FEATURES ARE AUTOMATICALLY DISABLED.
VEHICLE HAS 188,400 MILES, RUNS FLAWLESSLY. BOUGHT 2005, 45K MILES,TOYOTA DEALER CERTIFIED USED SUV. ROTTED THRU REAR TRANSFER CASE 3 YRS AGO, REPLACED FROM A WRECK. SEVERE PROGRESSIVE ENTIRE FRAME RUST/ROT NOTED IN YEARLY PA INSPECTIONS, NOW CANT PASS INSPECTION & PILLARS ALMOST ROTTED THRU..UNSAFE TO DRIVE. EXTREMELY DISAPPOINTED CANT PULL TRAILER SAILBOAT & M'CYCLES, NOW SITS IN DRIVEWAY USELESS.
I PURCHASED THE 2002 4RUNNER IN 2014. AT THAT TIME, THE 4RUNNER ONLY HAD 79,000 MILES AND HAD BEEN CARED FOR METICULOUSLY. I HAVE TAKEN THE CAR IN FOR ROUTINE SERVICE OVER THE PAST 5 YEARS. UPON TAKING THE 4RUNNER IN DUE TO A VIBRATION AND CHECK OF THE DIFFERENTIAL, THE MECHANIC CALLED ME IN TO LOOK AT THE FRAME WHILE IT WAS UP ON THE LIFT. BELOW IN THE ATTACHED PHOTOS, THERE IS EXTENSIVE RUSTING OF THE REAR DIFFERENTIAL, AXLE AND FRAME. THE VEHICLE WAS STATIONARY AND THE ISSUE WAS FOUND DURING ROUTINE MAINTENANCE. THE RUSTED FRAME AND DIFFERENTIAL HAVE RENDERED THIS VEHICLE PRACTICALLY VALUELESS AND UNSAFE.
I PURCHASED THE 2002 4RUNNER IN 2014. AT THAT TIME, THE 4RUNNER ONLY HAD 79,000 MILES AND HAD BEEN CARED FOR METICULOUSLY. I HAVE TAKEN THE CAR IN FOR ROUTINE SERVICE OVER THE PAST 5 YEARS. UPON TAKING THE 4RUNNER IN DUE TO A VIBRATION AND CHECK OF THE DIFFERENTIAL, THE MECHANIC CALLED ME IN TO LOOK AT THE FRAME WHILE IT WAS UP ON THE LIFT. BELOW IN THE ATTACHED PHOTOS, THERE IS EXTENSIVE RUSTING OF THE REAR DIFFERENTIAL, AXLE AND FRAME. THE VEHICLE WAS STATIONARY AND THE ISSUE WAS FOUND DURING ROUTINE MAINTENANCE. THE RUSTED FRAME AND DIFFERENTIAL HAVE RENDERED THIS VEHICLE PRACTICALLY VALUELESS AND UNSAFE.
VERY EXCESSIVE RUSTING AND CORROSION ON THE FRAME NEAR WHERE THE LEADING ARM ATTACHES ON THE PASSENGER SIDE. HOLE HAS DEVELOPED VERY QUICKLY, ONLY IN THE SPAN OF A COUPLE YEARS. WHEN GOING AROUND LEFT CORNER >15MPH, A CLUNKING NOISE CAN BE HEARD FROM THE PROBLEM AREA. VERY OCCASIONALLY A SIMILAR NOISE CAN BE HEARD WHEN GOING THROUGH RIGHT TURNS. VEHICLE HAS SPENT MOST OF ITS LIFE IN SOUTHERN MINNESOTA, ALTHOUGH SOME TIME HAS BEEN SPENT IN SOUTH FLORIDA. REPAIR WILL BE NECESSARY SOON, AS I'M STARTING TO NOT FEEL SAFE DRIVING LONG DISTANCES OR AT HIGHWAY SPEEDS (70+ MPH). THANK YOU, HAVE A NICE DAY. *TR