2022 FORD BRONCO
23 recalls, 508 complaints - 244 TSBs
26V468000 Jul 20, 2026
ENGINE
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence
A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy
Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will n... Read more
26V403000 Jun 24, 2026
STRUCTURE:BODY
Defect Description
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Consequence
A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy
Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 11, 2026. Additional letters will be sent once the remedy is available, anticipated in late August 2026. Owners may contact Ford custo... Read more
26V299000 May 12, 2026
STRUCTURE:BODY:ROOF AND PILLARS
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The 3-door and 5-door Molded-In-Color (MIC) hardtop roof panels may have been manufactured improperly, which can allow sections of the outer roof panel to separate and detach from the vehicle.
Consequence
A detached section of roof can create a road hazard, increasing the risk of a crash.
Remedy
Dealers will inspect and replace the hard top as necessary, free of charge. Interim letters, notifying owners of the safety risk were mailed May 28, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436... Read more
26V236000 Apr 14, 2026
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Consequence
Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy
Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle I... Read more
26V124000 Mar 3, 2026
BACK OVER PREVENTION:SOFTWARE
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Consequence
A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy
The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) inv... Read more
25V888000 Dec 18, 2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously repaired incorrectly under recall number 23V165. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fai... Read more
Consequence
A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy
Dealer will update the SYNC module software ,free of charge. Owner notification letters were mailed January 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C72. Vehicle Identification Numbers (VINs) involved in this recall will be searchable o... Read more
25V721000 Oct 23, 2025
SEATS:CRITICAL FASTENERS
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Consequence
A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy
Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this ... Read more
25V685000 Oct 10, 2025
EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER
Defect Description
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it t... Read more
Consequence
An electrical short circuit can increase the risk of a fire.
Remedy
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Int... Read more
25V455000 Jul 7, 2025
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence
An engine stall increases the risk of a crash.
Remedy
Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's numb... Read more
25V315000 May 14, 2025
BACK OVER PREVENTION:SOFTWARE
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicle... Read more
Consequence
A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy
The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety... Read more
25V273000 May 14, 2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.
Consequence
Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.
25V312000 May 9, 2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were repaired incorrectly under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with... Read more
Consequence
A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy
Dealers will update SYNC module software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C14.
25V025000 Jan 17, 2025
SUSPENSION:REAR:SHOCK ABSORBER
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Consequence
An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Remedy
Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
24V635000 Aug 23, 2024
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive p... Read more
Consequence
A loss of drive power increases the risk of a crash.
Remedy
Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
23V379000 May 26, 2023
EQUIPMENT:OTHER:LABELS
Defect Description
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with ... Read more
Consequence
An overloaded vehicle increases the risk of a crash.
Remedy
Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford cu... Read more
23V358000 May 18, 2023
SEAT BELTS:CRITICAL FASTENERS
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standa... Read more
Consequence
Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Remedy
Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners... Read more
23V165000 Mar 10, 2023
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously remedied under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with ... Read more
Consequence
A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy
The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 28, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C05.
23V155000 Mar 8, 2023
STEERING
Defect Description
Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.
Consequence
A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.
23V070000 Feb 10, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter p... Read more
Consequence
The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy
Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
22V928000 Dec 14, 2022
AIR BAGS:SENSOR:SIDE IMPACT
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The right or left side impact sensors may not be properly secured to the vehicle.
Consequence
An improperly secured side impact sensor may cause the air bags to unintentionally deploy, or not to deploy as intended, increasing the risk of injury in a crash.
Remedy
Dealers will inspect the side impact sensor attachments and repair, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S77.
22V825000 Nov 3, 2022
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with rearview camera systems and 8-inch screen displays. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor... Read more
Consequence
A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Remedy
The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 25, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C27.
22V451000 Jun 24, 2022
VISIBILITY:WINDSHIELD
Defect Description
Ford Motor Company (Ford) is recalling certain 2022 Bronco and Ranger vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numb... Read more
Consequence
A windshield that separates from a vehicle during a crash can increase the risk of injury.
Remedy
Dealers will remove and reinstall the windshield, free of charge. Owner notification letters were mailed July 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C12.
22V411000 Jun 10, 2022
LATCHES/LOCKS/LINKAGES:DOORS:LOCK
Defect Description
Ford Motor Company (Ford) is recalling certain four-door 2021-2022 Bronco vehicles. The passenger-side rear door may be opened from inside of the vehicle when the child safety lock is in the "ON" position.
Consequence
A malfunctioning child safety lock increases the risk of injury to a child occupant.
Remedy
Dealers will inspect the passenger-side child safety locks door child safety lock and latch, and replace them, if necessary, free of charge. Owner notification letters were mailed June 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S44.
Complaint Statistics
508 total complaints
17 crashes 5 fires 9 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ENGINE | 83 |
| ELECTRICAL SYSTEM | 60 |
| POWER TRAIN | 50 |
| UNKNOWN OR OTHER | 40 |
| SERVICE BRAKES | 32 |
| FUEL/PROPULSION SYSTEM | 26 |
| STEERING | 24 |
| VISIBILITY/WIPER | 21 |
| STRUCTURE:BODY | 13 |
| SUSPENSION | 10 |
FUEL/PROPULSION SYSTEM
Sep 10, 2026
Incident date: Aug 8, 2026
Was driving on highway with cruise control set. Vehicle started slowing down, so pressed on gas pedal and no response from vehicle, had to navigate to shoulder and was unable to drive vehicle. No warning that there was any issue. Vehicle has been at dealership for a month. Low pressure fuel pump fai... Read more
POWER TRAIN
Sep 7, 2026
Incident date: Aug 8, 2026
Clutch pedal went to floor and didn't return. The accumulator on part # MB3Z-7A512-A failed and broke apart causing a complete loss of brake fluid in the clutch hydraulic system rendering the clutch completely inoperable.
STRUCTURE:BODY
Sep 6, 2026
Incident date: Dec 31, 1969
I am writing to formally complain about a serious and increasingly concerning problem with the hardtop on my 2022 Ford Bronce four-door. I began noticing cracks in the hardtop after becoming aware of numerous complaints from other Bronco owners regarding similar cracking problems. Once I knew what ... Read more
FUEL/PROPULSION SYSTEM
Sep 4, 2026
Incident date: Jul 8, 2026
Simply filing a complaint for the recall on the fuel pump that still has not been remedied over a year ago. I’m hearing stories of people having to replace their fuel pumps and ford not covering it even though it’s an open recall. Hoping to get more pressure on them to get a remedy. Thank you fo... Read more
SEATS
Sep 3, 2026
Incident date: Aug 12, 2026
Headrest on rear passenger side will not stay up.
SUSPENSION
Aug 29, 2026
Incident date: Aug 26, 2026
On August 26, 2026, my 2022 Ford Bronco experienced a serious safety related failure while I was driving. The vehicle displayed a sway bar disconnect system warning and became disabled, leaving me stranded on the side of the road. The Bronco had to be towed to a Ford dealership, where it is availabl... Read more
SEATS
Aug 29, 2026
Incident date: Jul 1, 2025
3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a ... Read more
ELECTRICAL SYSTEM
Aug 29, 2026
Incident date: Jul 1, 2025
3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a ... Read more
WHEELS
Aug 29, 2026
Incident date: Aug 26, 2026
On August 26, 2026, my 2022 Ford Bronco experienced a serious safety related failure while I was driving. The vehicle displayed a sway bar disconnect system warning and became disabled, leaving me stranded on the side of the road. The Bronco had to be towed to a Ford dealership, where it is availabl... Read more
FUEL/PROPULSION SYSTEM
Aug 29, 2026
Incident date: Jul 1, 2025
3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a ... Read more
UNKNOWN OR OTHER
Aug 26, 2026
Incident date: Aug 26, 2026
Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or crac... Read more
VISIBILITY/WIPER
Aug 26, 2026
Incident date: Aug 26, 2026
Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or crac... Read more
STRUCTURE:BODY
Aug 21, 2026
Incident date: Jul 18, 2026
Fender flares (2) have detached. Flare 1: Passenger side, front wheel - it flew off while driving. Flare 2: Partially breaking / cracking off - on the drivers side, back wheel.
ELECTRICAL SYSTEM
Aug 20, 2026
Incident date: Aug 1, 2026
The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that ... Read more
ENGINE
Aug 20, 2026
Incident date: Aug 1, 2026
The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that ... Read more
FUEL SYSTEM, GASOLINE
Aug 20, 2026
Incident date: Aug 1, 2026
The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that ... Read more
FUEL/PROPULSION SYSTEM
Aug 19, 2026
Incident date: Jun 4, 2025
Loss of power or acceleration randomly, when pressing on the pedal. A recall was issued that it was a fuel pump failure June of 2025. One year and two months later there is still no solution to this recall. I am mostly submitting this covering all bases and am filing a complaint with Ford motor comp... Read more
ENGINE
Aug 19, 2026
Incident date: Jun 4, 2025
Loss of power or acceleration randomly, when pressing on the pedal. A recall was issued that it was a fuel pump failure June of 2025. One year and two months later there is still no solution to this recall. I am mostly submitting this covering all bases and am filing a complaint with Ford motor comp... Read more
FUEL/PROPULSION SYSTEM
Aug 13, 2026
Incident date: Jul 1, 2025
There is a manufacture recall for the low pressure fuel pump malfunctioning #25S75/NHTSA#25V455. There has been no action by the manufacturer to remedy this issue in a timely manner. This issue has been ongoing for over 1 year now with no corrective measures.
SEAT BELTS
Aug 11, 2026
Incident date: Aug 11, 2026
The contact owns a 2021 Hyundai Palisade. The contact received notifications of NHTSA Campaign Numbers: 25V607000 (Seat Belts) and 26V034000 (Air Bags); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of ti... Read more
ELECTRICAL SYSTEM
Aug 11, 2026
Incident date: Aug 11, 2026
Went to my car on Saturday @630p to put items in my car for church the next morning. I couldn't get into my car and my car wasn't responding to my key fobs. I called the Lexus service and was closed. I got on my app and called roadside service. As I was walking (pacing) in my garage, I noticed my r... Read more
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Aug 7, 2026
Incident date: May 21, 2024
The LKAS, ACC, AEB, Automatic High Beams, and other safety features that rely on the front camera all became inoperable for no apparent reason. The front facing camera seems to be the culprit. This is a known issue and Honda should submit a recall to replace the faulty camera.
PARKING BRAKE
Aug 4, 2026
Incident date: Jul 27, 2026
The parking brake system on my 2023 Dodge Charger has repeatedly become loose and does not hold the vehicle securely. The vehicle has been taken to a Dodge dealership multiple times for adjustment or repair of the parking brake. After the most recent dealership service, the parking brake worked temp... Read more
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Aug 4, 2026
Incident date: Aug 4, 2026
The contact owns a 2022 Hyundai Palisade. The contact stated that while driving 70 MPH, the vehicle unexpectedly decelerated. The contact stated that there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The contact stated that the vehicle was consuming ... Read more
ENGINE
Aug 4, 2026
Incident date: Jul 24, 2026
There is a safety recall on GM’s 6.2L V8 L87 engine model years 2021-2024. My vehicle is a 2020 Suburban with a 6.2L V8 L87 engine. My engine recently experienced the same failure as cited in the recall, but because it is outside the 2021-2024 window it is not covered by this recall. I ask that th... Read more
UNKNOWN OR OTHER
Aug 4, 2026
Incident date: Jul 24, 2026
Backup camera only works sometimes which is a safety risk when backing up. Other year models have had a recall for this same reason. It has been doing it for at least 6 months now.
TIRES
Aug 3, 2026
Incident date: Jul 26, 2026
The contact owns a 2025 Honda CR-V. The contact received notification of NHTSA Campaign Number: 26V366000 (Tires); however, the part to do the recall repair was not yet available. The local dealer and a second dealer were contacted several times, but no assistance was provided. The contact stated th... Read more
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Aug 2, 2026
Incident date: Jun 3, 2026
NHTSA Vehicle Safety Complaint Vehicle: 2019 Subaru Ascent VIN: [XXX] Mileage: 72,093 miles I am submitting this complaint because my 2019 Subaru Ascent experienced a serious transmission-related electrical failure that may represent a broader safety defect. Sewell Subaru of Dallas diagnosed an i... Read more
ELECTRICAL SYSTEM
Jul 30, 2026
Incident date: Jul 8, 2025
I received a factory recall notice from Volkswagen regarding the high-voltage battery in my ID.4 (Recall 93EA). I brought the vehicle to Volkswagen South Coast ([XXX]) for the recall repair on XXX completed XXX where the dealer found the battery testing "not OK" and replaced Modules 1, 5, and 12. On... Read more
ENGINE
Jul 28, 2026
Incident date: Jul 25, 2026
The vehicle was running when it overheated and started smoking from the gasket area, with no warning lights appearing on the dashboard; the car will not start now.
ELECTRICAL SYSTEM
Jul 25, 2026
Incident date: Jul 25, 2026
When driving the vehicle the on board screen randomly shuts down and restarts while in motion. During this process it changes all of the driving settings and turns off the automatic braking, and the vehicle accelerates with out touching the accelerator. This has happened numerous times and it has b... Read more
UNKNOWN OR OTHER
Jul 24, 2026
Incident date: Jul 24, 2026
Speedometer quit working. Then comes on intermittently and then quits again.
POWER TRAIN
Jul 24, 2026
Incident date: Jul 23, 2026
See attached document for complaint.
STEERING
Jul 23, 2026
Incident date: Jul 23, 2026
With increasing frequency, at seemingly any condition or speed, a cluster of dashboard warnings, including power steering EPS, ABS, tire pressure TPMS, and others, flash on and stay on. Shortly after, the warnings appear power steering assist fails completely. This leads to uneasy and potentially da... Read more
FUEL/PROPULSION SYSTEM
Jul 23, 2026
Incident date: Jul 15, 2025
SEVERE THROTTLE DELAY & UNPREDICTABLE ACCELERATION When applying pressure to the accelerator pedal at intersections or traffic lights, there is a substantial "dead zone" delay where the vehicle fails to respond or move forward. To prompt movement in normal traffic flow, I am forced to depress the ac... Read more
ENGINE
Jul 20, 2026
Incident date: Jul 20, 2026
We were driving on [XXX] coming from [XXX] going to [XXX] pulling a trailer within weight limits when the engine went out. We had it towed and looked at a dealership in [XXX]. They said it would.need engine replacement. We had it shipped to michigan spartan Toyota in Lansing who quoted us 30k for... Read more
SEAT BELTS
Jul 17, 2026
Incident date: Jul 15, 2025
I am reporting a potential safety defect involving my leased 2023 Infiniti Q50, VIN [XXX]. In 2024, I brought the vehicle to the dealership because the passenger seatbelt warning activated even when the passenger seat was unoccupied. I was told the condition was caused by objects triggering the pas... Read more
STRUCTURE:BODY
Jul 17, 2026
Incident date: Jun 2, 2026
Premature paint delamination on a 2019 Honda Pilot. Notifying NHTSA to track factory paint adhesion defects correlating with active Attika v. American Honda Motor Co. litigation.
STEERING
Jul 11, 2026
Incident date: May 20, 2026
Driving on highway with winding roads the steering wheel would stick on a slight turn. It would happen at the 11oclock & 1oclock position, mostly on a right curve. When correcting back you get a slight over steer. This happened over the 4 of July holiday 2026. At slower speeds it did not seem to hap... Read more
UNKNOWN OR OTHER
Jul 1, 2026
Incident date: Jun 15, 2026
My 2025 Honda Odyssey has experienced the same problem 4 times when stopped at a light. The engine shuts off when stopped at a light but then fails to restart and instead the vehicle automatically shifts to park and stalls; the battery light illuminates and the whole vehicle has to be shut off befor... Read more
ENGINE
Jun 28, 2026
Incident date: Jun 16, 2026
While operating with the Auto Shut Off enabled, vehicle stalled. Warning lights came on directing the driver to put into Park. Vehicle would not turn off/on, could not take out of park. At the time, vehicle was in bumper to bumper traffic in a construction zone causing a very dangerous situation fo... Read more
ELECTRICAL SYSTEM
Jun 28, 2026
Incident date: Jun 16, 2026
While operating with the Auto Shut Off enabled, vehicle stalled. Warning lights came on directing the driver to put into Park. Vehicle would not turn off/on, could not take out of park. At the time, vehicle was in bumper to bumper traffic in a construction zone causing a very dangerous situation fo... Read more
SERVICE BRAKES
Jun 27, 2026
Incident date: Jun 15, 2026
While driving, the red "BRAKE" light remains illuminated on the dashboard, and a "service brakes" warning message appears on the screen. This can be dismissed and the vehicle drives normally, except under sudden/heavy braking conditions. Under these conditions, the brakes make a grinding, thumping n... Read more
POWER TRAIN
Jun 26, 2026
Incident date: Mar 11, 2026
While traveling at highway speed during rush hour commute, the vehicle lost engine power and stalled. While coasting, I tried to restart the engine several times without success. Before coming to a stop, I attempted to get to the shoulder safely. Unfortunately, a portion of the vehicle was left part... Read more
POWER TRAIN
Jun 16, 2026
Incident date: Jun 7, 2026
The bolts holding the axle together to the driveshaft failed on the rear right wheel, nearly causing an accident but fortunately it was 6am with little traffic on the interstate. The axle came out and destroyed our driveshaft, requiring a full replacement. We have had the vehicle serviced regularly... Read more
POWER TRAIN
Jun 16, 2026
Incident date: Jun 7, 2026
On Friday, June 12, 2026, the check engine light illuminated on my vehicle. I took it to my local Ford dealer on Saturday, June 13, 2026. The dealer diagnosed the issue as a defective Gear Shift Module (GSM) and quoted approximately $1,000 for replacement. The service advisor informed me that failur... Read more
ENGINE
Jun 16, 2026
Incident date: Jun 7, 2026
As is clearly a very common defect, my exhaust manifold bolts broke and the manifold warped. This is the second time this has happened. RAM knows about this problem. In fact, it is so well known that it is called "the HEMI tick". The fact that such a shoddy part has continued to be put on millio... Read more
STEERING
Jun 16, 2026
Incident date: Jun 7, 2026
The contact owns a 2024 Jeep Wrangler 4XE. The contact received an email notification of NHTSA Campaign Number: 26V363000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The co... Read more
UNKNOWN OR OTHER
Jun 16, 2026
Incident date: Jun 11, 2026
Engine fails to restart after the Auto Idle System shuts it down, leaving vehicle stranded in traffic. The issue is sudden and unpredictable, and may not appear in inspection. A stalled car in live traffic is a safety concern. The vehicle is at a dealer for diagnosis and repair. No warning appeared... Read more
ELECTRICAL SYSTEM
Jun 15, 2026
Incident date: Feb 18, 2026
Manufacturer Recall Number 2026020004 NHTSA Recall Number26V073 Recall Status: Recall Incomplete, remedy not yet available Due to the combination of certain production and use conditions, an internal short circuit of a battery cell in the high-voltage battery, might lead to a thermal event. Subseque... Read more
Showing 50 of 508 complaints.
NHTSA Safety Ratings, 2022 FORD BRONCO
2022 Ford Bronco 2DR SUV 4WD
| Category | Rating |
|---|---|
| Rollover | 3 / 5 ★★★☆☆ |
| Rollover Risk | 25.6% |
Safety Technology
| Feature | Status |
|---|---|
| Electronic Stability Control | Standard |
| Forward Collision Warning | Standard |
| Lane Departure Warning | Standard |
Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.
Technical Service Bulletins, 2022 FORD BRONCO
244 manufacturer communications from 168 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 32 |
| 100000 POWER TRAIN | 23 |
| 110000 ELECTRICAL SYSTEM | 23 |
| 160000 STRUCTURE | 15 |
| 280100 BACK OVER PREVENTION:SOFTWARE | 13 |
| 980000 UNKNOWN OR OTHER | 11 |
| 060000 ENGINE AND ENGINE COOLING | 10 |
| 162900 STRUCTURE:BODY:ROOF AND PILLARS | 9 |
TSB 24-2112
Apr 24, 2024
100000 POWER TRAIN
Some 2021-2023 Bronco vehicles equipped with a 2.7L or 3.0L engine may exhibit an illuminated MIL with DTC P25B4, P25B6, and/or P0299 stored in the powertrain control module (PCM). This may be due to a loose nut on the turbo actuator arm ca
SSM 52476
Apr 24, 2024
350000 EQUIPMENT
All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini
SSM 52470
Apr 23, 2024
980000 UNKNOWN OR OTHER
Some 2021-2024 Bronco vehicles may experience a repeat loss of window initialization which results in a loss of short drop and/or one-touch up and one-touch down feature operation. This may be due to a recent short drop enhancement that is
SSM 52447
Apr 15, 2024
060000 ENGINE AND ENGINE COOLING
Some 2020-2024 F-150 and 2021-2024 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours
TSB 24-2107
Apr 15, 2024
280100 BACK OVER PREVENTION:SOFTWARE
Some 2022-2024 Bronco Raptor vehicles may exhibit an intermittent no crank/no start/discharged battery due to the presence of a parasitic battery drain. This may be due to the instrument panel cluster (IPC) software.
TSB 24-2104
Apr 11, 2024
020000 SUSPENSION
This article supersedes TSB 23-2400 to update the parts list. Some 2021-2023 Bronco vehicles may encounter a Sta-bar Disconnect Service Required message in the instrument panel cluster and an illuminated warning light with diagnostic troubl
OTAPU10246CHAUDB
Apr 9, 2024
110000 ELECTRICAL SYSTEM
Quality improvements include: -Fix the infrequent random audio noises issue and improve the audio quality of the vehicle
SSM 52410
Apr 3, 2024
980000 UNKNOWN OR OTHER
Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or la
TSB 24-2086
Mar 25, 2024
110000 ELECTRICAL SYSTEM
Some 2021-2023 Bronco vehicles equiped with a 2.7L engine may exhibit an ilumintated MIL with DTC P0456 stored in the powertrain control module (PCM). This may be due to the software level of the PCM and has no effect on vehicle operation.
TSB 24-2080
Mar 20, 2024
350000 EQUIPMENT
This article supersedes 23-2024 to update parts list to include rivets. Some 2021-2023 Bronco vehicles equipped with a factory soft top roof may exhibit a headliner that is detaching from the soft top material. This may be due to the factor
TSB 24-2080
Mar 20, 2024
162900 STRUCTURE:BODY:ROOF AND PILLARS
This article supersedes 23-2024 to update parts list to include rivets. Some 2021-2023 Bronco vehicles equipped with a factory soft top roof may exhibit a headliner that is detaching from the soft top material. This may be due to the factor
TSB 24-2080
Mar 20, 2024
160000 STRUCTURE
This article supersedes 23-2024 to update parts list to include rivets. Some 2021-2023 Bronco vehicles equipped with a factory soft top roof may exhibit a headliner that is detaching from the soft top material. This may be due to the factor
SSM 52364
Mar 14, 2024
118000 ELECTRICAL SYSTEM:SOFTWARE
2021-2023 Bronco vehicles built on or before 9-Jul-2023 may have new version software in their driver door module (DDM) and passenger door module (PDM) that contains noticeable enhancements to the window short drop operation. This software
SSM 52364
Mar 14, 2024
162300 STRUCTURE:BODY:DOOR
2021-2023 Bronco vehicles built on or before 9-Jul-2023 may have new version software in their driver door module (DDM) and passenger door module (PDM) that contains noticeable enhancements to the window short drop operation. This software
SSM 52342
Mar 7, 2024
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Some 2022-2024 Broncos Raptors built on and before 13-Feb-2024 and 2021-2024 Broncos equipped with a 2.3L EcoBoost engine may exhibit an illuminated MIL with ignition system DTC(s) P0352, P0353, P0354, P0355, P0357, P2303, P2306, P2309, P23
SSM 52335
Mar 6, 2024
060000 ENGINE AND ENGINE COOLING
For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg
SSM 52333
Mar 6, 2024
115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
Many body control module C (BCMC) warranty return parts are coming back with no trouble found. To verify that the BCMC is at fault prior to replacing, perform the following. First, disconnect the battery then check all BCMC connectors for t
SSM 52328
Mar 4, 2024
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
Some 2021-2024 Bronco/F-150, 2023-2024 Escape/F-Super Duty vehicles equipped with SYNC 4 may experience a concern during accessory protocol interface module (APIM) programming where the vehicle's center display screen indicates USB Error. T
SSM 52328
Mar 4, 2024
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
Some 2021-2024 Bronco/F-150, 2023-2024 Escape/F-Super Duty vehicles equipped with SYNC 4 may experience a concern during accessory protocol interface module (APIM) programming where the vehicle's center display screen indicates USB Error. T
SSM 52314
Mar 1, 2024
100000 POWER TRAIN
During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim
TSB 24-2042
Feb 22, 2024
100000 POWER TRAIN
This article supersedes TSB 23-2019 to update the model years affected, add an additional labor operation, and correct the part number called out in the Service Procedure. Some 2021-2024 Bronco vehicles equipped with a MT88 manual transmiss
SSM 52278
Feb 21, 2024
100000 POWER TRAIN
Some 2021-2023 Bronco (non-Raptor) vehicles built on or before 09-Jul-2023 may exhibit a fluid leak from the front drive axle pinion seal. This may be due to operating the vehicle under high load. If leaking, replace the pinion seal followi
TSB 24-2040
Feb 16, 2024
350000 EQUIPMENT
Some 2021-2024 Bronco vehicles may exhibit paint damage on the rear quarter panel due to contact with the soft top rear window. This may be due to a contact condition that can occur during extreme off-road driving between the soft top rear
SSM 52258
Feb 13, 2024
171200 LATCHES/LOCKS/LINKAGES:DOORS:LOCK
Some 2021-2024 Bronco vehicles may exhibit a parasitic battery draw. This may be due to an interior door lock switch on the driver's and passenger's interior door panels. Prior to normal Workshop Manual (WSM) diagnostics, check both front d
SSM 52258
Feb 13, 2024
110000 ELECTRICAL SYSTEM
Some 2021-2024 Bronco vehicles may exhibit a parasitic battery draw. This may be due to an interior door lock switch on the driver's and passenger's interior door panels. Prior to normal Workshop Manual (WSM) diagnostics, check both front d
OTAPU0605STBRDSC
Feb 9, 2024
280100 BACK OVER PREVENTION:SOFTWARE
Software Update 23- PU0605-STBR-DSC for 2022 MY BRONCO vehicles is now available. Quality Improvements include: - Address incorrectly setting the Sta-Bar Disconnect DTC issue.
OTAPU0605STBRDSC
Feb 9, 2024
110000 ELECTRICAL SYSTEM
Software Update 23- PU0605-STBR-DSC for 2022 MY BRONCO vehicles is now available. Quality Improvements include: - Address incorrectly setting the Sta-Bar Disconnect DTC issue.
TSB 24-2032
Feb 5, 2024
350000 EQUIPMENT
Some 2021-2023 Bronco vehicles built on or before 28-Feb-2023 may exhibit water entry into the rear trunk. This may be due to a lack of body seam sealer at the floor panel to trunk sheet metal joint. This repair procedure addresses water en
TSB 24-2032
Feb 5, 2024
162700 STRUCTURE:BODY:TRUNK LID
Some 2021-2023 Bronco vehicles built on or before 28-Feb-2023 may exhibit water entry into the rear trunk. This may be due to a lack of body seam sealer at the floor panel to trunk sheet metal joint. This repair procedure addresses water en
TSB 24-2021
Jan 24, 2024
350000 EQUIPMENT
This article supersedes TSB 23-2213 to revise Figure 1, add 2024 vehicles and the part list. Some 2021-2024 Bronco vehicles may exhibit a whistle noise below the lower left windshield area at the bottom of the A-pillar. This may be due to a
SSM 52197
Jan 23, 2024
980000 UNKNOWN OR OTHER
Some 2021-2024 Bronco vehicles equipped with 4x4 with part time engagement and built on or before 12-Jan-2024 may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD
SSM 52197
Jan 23, 2024
200000 WHEELS
Some 2021-2024 Bronco vehicles equipped with 4x4 with part time engagement and built on or before 12-Jan-2024 may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD
SSM 52197
Jan 23, 2024
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
Some 2021-2024 Bronco vehicles equipped with 4x4 with part time engagement and built on or before 12-Jan-2024 may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD
SSM 52178
Jan 15, 2024
Some 2021-2024 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps. This condition is currently under investigation and repairs and/or
SSM 52178
Jan 15, 2024
060000 ENGINE (PWS)
Some 2021-2024 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps. This condition is currently under investigation and repairs and/or
SSM 52178
Jan 15, 2024
980000 UNKNOWN OR OTHER
Some 2021-2024 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps. This condition is currently under investigation and repairs and/or
SSM 52166
Jan 9, 2024
061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
Some 2021-2024 Bronco vehicles equipped with SYNC 4 may experience a concern during SYNC module (APIM) programming where the vehicle's center display screen indicates: USB Error. This may be due to a lack of memory space available to perfor
SSM 52166
Jan 9, 2024
980000 UNKNOWN OR OTHER
Some 2021-2024 Bronco vehicles equipped with SYNC 4 may experience a concern during SYNC module (APIM) programming where the vehicle's center display screen indicates: USB Error. This may be due to a lack of memory space available to perfor
TSB 23-2437
Jan 8, 2024
110000 ELECTRICAL SYSTEM
This article supersedes 23-2105 to update the vehicle model years affected and customer symptoms. Some 2021-2023 Bronco vehicles may experience at least one of the following symptoms: intermittent blank/frozen center display screen that res
TSB 23-2409
Dec 11, 2023
100000 POWER TRAIN
This article supersedes TSB 23-2219 to update the Parts List. Some 2021-2023 Bronco vehicles may exhibit no 3rd gear engagement and/or a grinding noise going into 3rd and/or 4th gear. This may be due to the transmission shifting system and
TSB 23-2400
Dec 6, 2023
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
This article supersedes TSB 23-2086 to update the parts list. Some 2021-2023 Bronco vehicles may encounter a Sta-bar Disconnect Service Required message in the instrument panel cluster and an illuminated warning light with any of the follow
TSB 23-2400
Dec 6, 2023
110000 ELECTRICAL SYSTEM
This article supersedes TSB 23-2086 to update the parts list. Some 2021-2023 Bronco vehicles may encounter a Sta-bar Disconnect Service Required message in the instrument panel cluster and an illuminated warning light with any of the follow
TSB 23-2368
Nov 23, 2023
110000 ELECTRICAL SYSTEM
This article supersedes TSB 23-2196 to update the Service Procedure. Some 2021-2022 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit various charging system error messages and/or illuminated charging system indicator
TSB 23-2355
Nov 21, 2023
350000 EQUIPMENT
This article supersedes TSB 23-2163 to update the Parts List. Some 2021-2022 Bronco vehicles built on or before 25-Jul-2022 may exhibit a rattle noise from the tailgate when driving on rough roads. The rattle may diminish with the spare tir
TSB 23-2345
Nov 14, 2023
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial (feet and miles) units and not being able to change to metric (meters and kilometers) uni
TSB 23-2345
Nov 14, 2023
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial (feet and miles) units and not being able to change to metric (meters and kilometers) uni
TSB 23-2345
Nov 14, 2023
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial (feet and miles) units and not being able to change to metric (meters and kilometers) uni
TSB 23-2352
Nov 14, 2023
100000 POWER TRAIN
Some 2020-2023 Explorer/Aviator and 2021-2023 Bronco vehicles equipped with a 10R60 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code
SSM 52036
Nov 2, 2023
104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Some 2021-2023 Bronco vehicles equipped with 4x4 with part time engagement may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD) module. Make sure the proper proc
SSM 52036
Nov 2, 2023
980000 UNKNOWN OR OTHER
Some 2021-2023 Bronco vehicles equipped with 4x4 with part time engagement may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD) module. Make sure the proper proc
SSM 52036
Nov 2, 2023
118000 ELECTRICAL SYSTEM:SOFTWARE
Some 2021-2023 Bronco vehicles equipped with 4x4 with part time engagement may exhibit a condition of the vehicle being stuck in neutral tow mode. This may be due to a concern with the all-wheel drive (AWD) module. Make sure the proper proc
23B35
Nov 1, 2023
136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Certain 2021-2023 Model Year Bronco Vehicles - Wiper Motor Software Update
TSB 23-2340
Oct 31, 2023
350000 EQUIPMENT
This article supersedes TSB 22-2146 to update the parts list. Some 2021-2022 Bronco vehicles equipped with a soft top roof may experience paint scratches on the sports tube paint due to contact with the soft top roof frame during the open a
SU4 P4 BRONCO
Oct 19, 2023
030000 BRAKES (PWS)
Software Update SU4 P4 for 2022-2023 Bronco is now available. Quality improvements include: - Prevent unintended Fuel level MIL after future OTA updates. -Various Apple Carplay quality improvements -Electronic Brake Boost (EBB) interact
SU4 P4 BRONCO
Oct 19, 2023
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
Software Update SU4 P4 for 2022-2023 Bronco is now available. Quality improvements include: - Prevent unintended Fuel level MIL after future OTA updates. -Various Apple Carplay quality improvements -Electronic Brake Boost (EBB) interact
SU4 P4 BRONCO
Oct 19, 2023
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
Software Update SU4 P4 for 2022-2023 Bronco is now available. Quality improvements include: - Prevent unintended Fuel level MIL after future OTA updates. -Various Apple Carplay quality improvements -Electronic Brake Boost (EBB) interact
TSB 23-2282
Oct 17, 2023
350000 EQUIPMENT
Some 2021-2022 Bronco vehicles built on or before 31-Mar-2022 and equipped with a factory hard top roof may have an older style latch decal installed that is no longer available to order. Replacement hard top roof panels will come with a ne
SSM 51989
Oct 13, 2023
110000 ELECTRICAL SYSTEM
Some 2021-2023 Bronco vehicles may exhibit a charging system lamp that illuminates briefly and/or intermittently, and/or diagnostic trouble code (DTC) B11DB:08 in the body control module (BCM). This may be due to a loose fuse terminal for t
23H05
Oct 4, 2023
980000 UNKNOWN OR OTHER
Harvest Program 23H05 Certain 2022 Model Year Navigator and 2022-2023 Model Year Mach-E, F150 Lightning, F150, Expedition and Bronco - Instrument Cluster Odometer Inspection
23H05
Oct 4, 2023
117110 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT
Harvest Program 23H05 Certain 2022 Model Year Navigator and 2022-2023 Model Year Mach-E, F150 Lightning, F150, Expedition and Bronco - Instrument Cluster Odometer Inspection
SSM 51961
Oct 3, 2023
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Some 2021-2023 Bronco vehicles may exhibit an illuminated MIL with DTCs P0096 and/or P007B in the powertrain control module (PCM), which may be more prevalent in high ambient air temperatures. For vehicles that meet this criateria, inspect
SSM 51961
Oct 3, 2023
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Some 2021-2023 Bronco vehicles may exhibit an illuminated MIL with DTCs P0096 and/or P007B in the powertrain control module (PCM), which may be more prevalent in high ambient air temperatures. For vehicles that meet this criateria, inspect
SSM 51939
Sep 21, 2023
100000 POWER TRAIN
Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmissi
23-PU0813-DORUP2
Sep 19, 2023
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
"Priority Update 23-PU0813-DOR-UP2 for 2022 Bronco vehicles is now available. Quality Improvements include: -Update the strategy to learn window travel hard stop at top and bottom to reduce unintended window bounce back and to prevent lo
TSB 23-2086
Sep 1, 2023
110000 ELECTRICAL SYSTEM
This article supersedes TSB 23-2006 to update the vehicle model years affected. Some 2021-2023 Bronco vehicles may encounter a Sta-bar Disconnect Service Required message in the instrument panel cluster and an illuminated warning light with
TSB 23-2219
Sep 1, 2023
100000 POWER TRAIN
Some 2021-2023 Bronco vehicles may exhibit no 3rd gear engagement and/or a grinding noise going into 3rd and/or 4th gear. This may be due to the transmission shifting system and clutch interaction such as a lack of full clutch disengagement
SSM 51863
Aug 15, 2023
250000 ELECTRONIC STABILITY CONTROL
During replacement of the electronic front stabilizer bar disconnect assembly on 2021-2023 Bronco vehicles, removal and replacement of the sta-bar harness is required. To assist engineering with root cause analysis of failed sta-bar disconn
SSM 51863
Aug 15, 2023
110000 ELECTRICAL SYSTEM
During replacement of the electronic front stabilizer bar disconnect assembly on 2021-2023 Bronco vehicles, removal and replacement of the sta-bar harness is required. To assist engineering with root cause analysis of failed sta-bar disconn
SSM 51863
Aug 15, 2023
021100 SUSPENSION:FRONT:STABILIZER BAR
During replacement of the electronic front stabilizer bar disconnect assembly on 2021-2023 Bronco vehicles, removal and replacement of the sta-bar harness is required. To assist engineering with root cause analysis of failed sta-bar disconn
TSB 23-2250
Aug 14, 2023
100000 POWER TRAIN
This article supersedes TSB 22-2428 and 23-2176 to update the Issue, Action and Service Procedure. Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehic
SSM 51850
Aug 8, 2023
134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
Some 2021-2022 Bronco vehicles equipped with a soft top roof may exhibit loose exterior fabric on the rear window assembly. This may be due to broken D-pillar clips on the rear window. To correct the condition, replace the rear window. Refe
SU4 P3 Bronco
Aug 3, 2023
280100 BACK OVER PREVENTION:SOFTWARE
Software Update 4 P3 for 2021-2023 Bronco Vehicles is now available. Quality improvements include: -Various Apple Carplay quality improvements
SSM 51838
Aug 2, 2023
110000 ELECTRICAL SYSTEM
In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app thr
SSM 51830
Aug 2, 2023
350000 EQUIPMENT
Some 2021-2023 Bronco vehicles equipped with a soft top roof may exhibit rear quarter window(s) that do not stay attached to the rear window after driving the vehicle or using the soft top quick access cargo function to raise the rear of th
TSB 23-2241
Jul 28, 2023
350000 EQUIPMENT
Some 2021-2023 Bronco vehicles equipped with a factory subwoofer and built on or before 20-Mar-2023 may exhibit a rattle from right loadspace trim panel at high audio system volumes. This may be due to poor retention from the right loadspac
TSB 23-2241
Jul 28, 2023
160000 STRUCTURE
Some 2021-2023 Bronco vehicles equipped with a factory subwoofer and built on or before 20-Mar-2023 may exhibit a rattle from right loadspace trim panel at high audio system volumes. This may be due to poor retention from the right loadspac
TSB 23-2238
Jul 25, 2023
110000 ELECTRICAL SYSTEM
Some 2021-2022 Bronco vehicles may exhibit a charging system fault message displayed in the instrument panel cluster (IPC), various diagnostic trouble codes (DTCs) related to charging system, and/or a charging system that has stopped functi
TSB 23-2229
Jul 14, 2023
134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
Some 2021-2022 Bronco vehicles equipped with a soft top may exhibit exterior wear on the sides of the soft top material above the B-pillar. This may be due to contact and rubbing between the soft top frame and soft top material. To correct
TSB 23-2229
Jul 14, 2023
350000 EQUIPMENT
Some 2021-2022 Bronco vehicles equipped with a soft top may exhibit exterior wear on the sides of the soft top material above the B-pillar. This may be due to contact and rubbing between the soft top frame and soft top material. To correct
SSM 51790
Jul 14, 2023
162800 STRUCTURE:BODY:HOOD
Some 2022-2023 Bronco vehicles built on 01-Sept-2022 and through 20-Mar-2023 may exhibit an intermittent illuminated hood ajar indicator on the instrument panel cluster and/or a false alarm activation caused by a hood ajar event. This may b
SSM 51790
Jul 14, 2023
170000 LATCHES/LOCKS/LINKAGES
Some 2022-2023 Bronco vehicles built on 01-Sept-2022 and through 20-Mar-2023 may exhibit an intermittent illuminated hood ajar indicator on the instrument panel cluster and/or a false alarm activation caused by a hood ajar event. This may b
SSM 51790
Jul 14, 2023
176100 LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Some 2022-2023 Bronco vehicles built on 01-Sept-2022 and through 20-Mar-2023 may exhibit an intermittent illuminated hood ajar indicator on the instrument panel cluster and/or a false alarm activation caused by a hood ajar event. This may b
TSB 23-2213
Jul 7, 2023
160000 STRUCTURE
Some 2021-2023 Bronco vehicles built on or before 31-May-2023 may exhibit a whistle noise below the lower left windshield area at the bottom of the A-pillar. This may be due to a missed body sealer application at the factory. To correct thi
OTASYNCLCReDBron
Jul 5, 2023
280100 BACK OVER PREVENTION:SOFTWARE
LC SYNC (8in screen) updates are being redeployed for 2021-2022 Broncos. Quality improvements include: - Management of memory space to allow future updates.
SSM 51762
Jul 3, 2023
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial units and not being able to change to metric. This may be due to the software level of th
SSM 51762
Jul 3, 2023
118000 ELECTRICAL SYSTEM:SOFTWARE
Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial units and not being able to change to metric. This may be due to the software level of th
TSB 23-2182
Jun 26, 2023
110000 ELECTRICAL SYSTEM
Some 2021-2022 Bronco vehicles may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) stored in the all-wheel drive (AWD) module. The setting of these DTCs result in an inoperative 4WD syst
TSB 23-2200
Jun 22, 2023
350000 EQUIPMENT
Some 2021-2023 Bronco vehicles equipped with a soft top roof may exhibit rear quarter window(s) that do not stay attached to the rear window after driving the vehicle or using the soft top quick access cargo function to raise the rear of th
TSB 23-2200
Jun 22, 2023
170000 LATCHES/LOCKS/LINKAGES
Some 2021-2023 Bronco vehicles equipped with a soft top roof may exhibit rear quarter window(s) that do not stay attached to the rear window after driving the vehicle or using the soft top quick access cargo function to raise the rear of th
TSB 23-2200
Jun 22, 2023
134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
Some 2021-2023 Bronco vehicles equipped with a soft top roof may exhibit rear quarter window(s) that do not stay attached to the rear window after driving the vehicle or using the soft top quick access cargo function to raise the rear of th
TSB 23-2196
Jun 20, 2023
110000 ELECTRICAL SYSTEM
This article supersedes TSB 23-2135 to update the Part List. Some 2021-2022 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit various charging system error messages and/or illuminated charging system indicator display
TSB 23-2196
Jun 20, 2023
060000 ENGINE AND ENGINE COOLING
This article supersedes TSB 23-2135 to update the Part List. Some 2021-2022 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit various charging system error messages and/or illuminated charging system indicator display
SSM 51726
Jun 16, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Some 2021-2023 Bronco vehicles may exhibit the HVAC switching out of recirculation without input. This may be due to the air flow mode door inlet strategy while in recirculation mode. This strategy periodically purges the cabin air every 30
SSM 51726
Jun 16, 2023
350000 EQUIPMENT
Some 2021-2023 Bronco vehicles may exhibit the HVAC switching out of recirculation without input. This may be due to the air flow mode door inlet strategy while in recirculation mode. This strategy periodically purges the cabin air every 30
SSM 51694
Jun 9, 2023
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Some 2021-2023 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps. This condition is currently under investigation and repairs and/or
SSM 51694
Jun 9, 2023
130000 VISIBILITY
Some 2021-2023 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps. This condition is currently under investigation and repairs and/or
TSB 23-2019
Jun 9, 2023
100000 POWER TRAIN
Some 2021-2023 Bronco vehicles equipped with a MT88 manual transmission may experience a rotational scraping noise while the transmission is in neutral, 1st or 2nd gear with the clutch pedal released and may be more noticeable in ambient te
TSB 23-2019
Jun 9, 2023
102650 POWER TRAIN:MANUAL TRANSMISSION:INTERNAL:GEARS
Some 2021-2023 Bronco vehicles equipped with a MT88 manual transmission may experience a rotational scraping noise while the transmission is in neutral, 1st or 2nd gear with the clutch pedal released and may be more noticeable in ambient te
SAN-Vol1 I1
Jun 8, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical serv
23OTASU4P2BRONCO
Jun 7, 2023
118000 ELECTRICAL SYSTEM:SOFTWARE
Software Update 4 P2 for 2021-2023 Bronco vehicles is now available. Quality improvements include: - Minimize time customer cannot enter the vehicle during future inhibit updates.
Showing 100 of 244 bulletins.
NHTSA Safety Investigations, FORD BRONCO
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE24019
Opened: Jul 29, 2024 , Closed: Sep 19, 2025
Low-pressure fuel pump failure
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with ... Read more
EA23002
Opened: Sep 29, 2023 , Closed: Oct 31, 2024
Loss of Motive Power
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporti... Read more
PE22007
Opened: Jul 22, 2022 , Closed: Oct 2, 2023
Loss of motive power due to valve intake failure on Ford Bronco vehicles.
The Office of Defects Investigation (ODI) received a petition dated March 16, 2022, requesting an investigation regarding allegations of defective intake valves in model year (MY) 2021 Ford Bronco vehicles equipped with the 2.7L Eco-boost (“Nano”) engines. The petitioner alleged these vehicles... Read more
DP22001
Opened: May 27, 2022 , Closed: Jul 28, 2022
Loss of Motive Power
The Office of Defects Investigation (ODI) received three petitions on March 17, March 18, and March 29, 2022, which requested a defect investigation into an alleged defect of the valves on model year (MY) 2021 Ford Bronco vehicles equipped with the 2.7L Eco-boost engines. The petitioners alleged tha... Read more
EA05005
Opened: Mar 22, 2005 , Closed: Aug 2, 2006
ENGINE COMPARTMENT FIRES
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS ... Read more
RQ98021
Opened: Nov 10, 1998 , Closed: May 23, 2000
PARKING BRAKE
There is no summary currently available
EA93022
Opened: Jul 30, 1993 , Closed: Aug 31, 1994
IDLE AIR SPD CTRL VLV MALF
There is no summary currently available
EA93020
Opened: Jul 28, 1993 , Closed: Sep 23, 1994
PARKING BRAKE FAILURE
There is no summary currently available
PE93010
Opened: Mar 2, 1993 , Closed: Jul 30, 1993
IDLE AIR SPD CTRL VLV MALF
There is no summary currently available
EA93001
Opened: Jan 7, 1993 , Closed: Aug 20, 1993
FUEL EXPULSION
There is no summary currently available
PE92077
Opened: Sep 9, 1992 , Closed: Jan 7, 1993
FUEL EXPULSION
There is no summary currently available
EA92029
Opened: Aug 27, 1992 , Closed: Oct 29, 1993
FRONT SEAT BACK FAILURE
There is no summary currently available
PE92042
Opened: Apr 17, 1992 , Closed: Aug 27, 1992
FNT RECLNING SEAT BCK FAIL
There is no summary currently available
PE91017
Opened: Nov 27, 1990 , Closed: Apr 17, 1991
FORD TRUCK INCONSISTENT VEHICLE CONTROL.
SEE CLOSE RESUME
PE90117
Opened: Sep 12, 1990 , Closed: Dec 27, 1990
FUEL TANK CORROSION
There is no summary currently available
PE90036
Opened: Jan 23, 1990 , Closed: Jul 26, 1990
FLOORBOARD FRACTURE
There is no summary currently available
PE87015
Opened: Jan 15, 1987 , Closed: Nov 30, 1987
FRONT BRK CALIPER SEIZURE
ANALYSIS:ALLEGEDLY, DURING BRAKE APPLICATION THE DISC BRAKE CALIPERSSEIZE, RESULTING IN EXCESSIVE PULL AND/OR FRONT BRAKE LOCK-UP.SOMEREPORTS CITE A COMPLETE LOSS OF VEHICLE CONTROL RESULTING IN UNFOREWARNEDAND UNAVOIDABLE TRAVEL INTO OPPOSING TRAFFIC LANES.CONSUMERS CLAIM THATSERVICE PERSONNEL HAVE... Read more
FORD BRONCO - All Years Overview
Complete safety history for the FORD BRONCO across all model years (1967, 2026).
168
Total Recalls
2,194
Total Complaints
17
Investigations
104
Reported Crashes
192
Reported Fires
132
Reported Deaths
FORD BRONCO - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 7 | 9 | View |
| 2025 | 19 | 74 | View |
| 2024 | 16 | 111 | View |
| 2023 | 18 | 266 | View |
| 2022 (current) | 23 | 508 | |
| 2021 | 20 | 303 | View |
| 1999 | 0 | 5 | View |
| 1998 | 0 | 2 | View |
| 1997 | 1 | 1 | View |
| 1996 | 2 | 109 | View |
| 1995 | 2 | 131 | View |
| 1994 | 5 | 114 | View |
| 1993 | 7 | 45 | View |
| 1992 | 4 | 56 | View |
| 1991 | 2 | 37 | View |
| 1990 | 1 | 77 | View |
| 1989 | 2 | 118 | View |
| 1988 | 1 | 68 | View |
| 1987 | 1 | 61 | View |
| 1986 | 1 | 43 | View |
| 1985 | 1 | 24 | View |
| 1984 | 4 | 11 | View |
| 1983 | 2 | 4 | View |
| 1982 | 1 | 1 | View |
| 1981 | 1 | 2 | View |
| 1980 | 4 | 0 | View |
| 1979 | 6 | 2 | View |
| 1978 | 6 | 0 | View |
| 1977 | 2 | 1 | View |
| 1976 | 2 | 0 | View |
| 1975 | 2 | 0 | View |
| 1972 | 1 | 0 | View |
| 1971 | 1 | 0 | View |
| 1970 | 1 | 0 | View |
| 1969 | 0 | 1 | View |
| 1967 | 2 | 2 | View |