EXTERIOR LIGHTING
Defect Description
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D
... EVICES, AND ASSOCIATED EQUIPMENT.Read moreConsequence
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
61,944 vehicles affected
Manufacturer: PRO-A MOTORS, INC.
VEHICLE SPEED CONTROL
Defect Description
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence
A FIRE AT THE SWITCH COULD OCCUR.
Remedy
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO
... RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)Read more4,500,000 vehicles affected
Manufacturer: FORD MOTOR COMPANY
TIRES:TREAD/BELT
Defect Description
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN
... OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.Read moreConsequence
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
13,000,000 vehicles affected
Manufacturer: FORD MOTOR COMPANY
PARKING BRAKE:CONVENTIONAL
Defect Description
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence
WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy
A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE I
... N GEAR WHEN THE VEHICLE IS PARKED.Read more835,791 vehicles affected
Manufacturer: FORD MOTOR COMPANY
STRUCTURE:BODY:BUMPERS
Defect Description
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence
IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy
INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
370,000 vehicles affected
Manufacturer: FORD MOTOR COMPANY
Complaint Statistics
114 total complaints
6 crashes 14 fires 3 injuries
Top Reported Components
| Component | Complaints |
|---|
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 18 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | 9 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | 8 |
| ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | 5 |
| VEHICLE SPEED CONTROL | 5 |
| AIR BAGS:FRONTAL | 5 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC | 4 |
| VEHICLE SPEED CONTROL:CRUISE CONTROL | 4 |
| AIR BAGS | 4 |
| SEATS | 3 |
Incident date: Dec 1, 2007
PARKING BRAKE DOES NOT HOLD. I CAN NOT PARK ON INCLINE. IF PARKING BRAKE IS APPLIED FULLY AT 15 MPH IT TAKES 45 YARDS TO STOP. EXTREMELY UNSAFE!!! *TR
Incident date: Jan 22, 2015
THE VEHICLE WAS PARKED IN MY SCHOOL PARKING LOT AND CAUGHT FIRE HOURS AFTER PARKING IT. VEHICLE IS A TOTAL LOSS. *TR
Fire
Incident date: Jan 22, 2015
THE VEHICLE WAS PARKED IN MY SCHOOL PARKING LOT AND CAUGHT FIRE HOURS AFTER PARKING IT. VEHICLE IS A TOTAL LOSS. *TR
Fire
Incident date: Jan 22, 2015
THE VEHICLE WAS PARKED IN MY SCHOOL PARKING LOT AND CAUGHT FIRE HOURS AFTER PARKING IT. VEHICLE IS A TOTAL LOSS. *TR
Fire
Incident date: Jul 2, 2012
THE 1994 FORD BRONCO EQUIPPED WITH SPEED CONTROL HAD FORD RECALL NO. 05S28 ACCOMPLISHED IN 2008. IN 2012 THE WIRING OVERHEATED AND CAUSED DAMAGE AND A LEAK TO THE MASTER CYLINDER RESERVOIR AND HAD TO BE DISCONNECTED. WHEN FORD WAS CONTACTED THEY INSTRUCTED THAT THE RECALL HAD BEEN ACCOMPLISHED AND
... THEY COULD NOT WARRANTY THE PART. *TRRead more
Incident date: Jul 2, 2012
THE 1994 FORD BRONCO EQUIPPED WITH SPEED CONTROL HAD FORD RECALL NO. 05S28 ACCOMPLISHED IN 2008. IN 2012 THE WIRING OVERHEATED AND CAUSED DAMAGE AND A LEAK TO THE MASTER CYLINDER RESERVOIR AND HAD TO BE DISCONNECTED. WHEN FORD WAS CONTACTED THEY INSTRUCTED THAT THE RECALL HAD BEEN ACCOMPLISHED AND
... THEY COULD NOT WARRANTY THE PART. *TRRead more
Incident date: Jul 2, 2012
THE 1994 FORD BRONCO EQUIPPED WITH SPEED CONTROL HAD FORD RECALL NO. 05S28 ACCOMPLISHED IN 2008. IN 2012 THE WIRING OVERHEATED AND CAUSED DAMAGE AND A LEAK TO THE MASTER CYLINDER RESERVOIR AND HAD TO BE DISCONNECTED. WHEN FORD WAS CONTACTED THEY INSTRUCTED THAT THE RECALL HAD BEEN ACCOMPLISHED AND
... THEY COULD NOT WARRANTY THE PART. *TRRead more
Incident date: Oct 13, 2010
1994 FORD BRONCO DRIVER SEAT (BUCKET) BACK FRAME HAS BROKEN. HAVE SPOKEN TO NUMEROUS SOURCES THAT ALL CLAIM THIS IS A COMMON OCCURRENCE. WAS ADVISED NOT TO REPLACE WITH BRONCO SEAT, THAT ALL HAVE EITHER ALREADY FAILED OR WILL FAIL EVENTUALLY. THAT SOUNDS TERRIBLY UNSAFE, ESPECIALLY IN THE EVENT O
... F A CRASH. *TRRead more
Incident date: Feb 16, 2000
TL*THE CONTACT OWNS A 1994 FORD BRONCO. THE CONTACT STATED THAT THE PARKING BRAKE DOES NOT HOLD. ON SEVERAL OCCASIONS, HE APPLIED THE PARKING BRAKE AND THE VEHICLE ROLLED IN THE DIRECTION OF THE HILL ON WHERE IT WAS PARKED. THE DEALER STATED THAT NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE:
... CONVENTIONAL) WAS NOT AN ACTIVE RECALL. THE MANUFACTURER STATED THAT THE RECALL WAS NOT IN THEIR DATABASE AND REFUSED TO PERFORM THE REPAIR. THE CURRENT MILEAGE WAS 180,781 AND FAILURE MILEAGE WAS APPROXIMATELY 105,000. UPDATED 03/09/09. *LJ UPDATED 03/11/09. *JBRead more
Incident date: Sep 15, 2008
TL*THE CONTACT OWNS A 1994 FORD BRONCO. THE CONTACT IS ABLE TO START THE ENGINE WITH OR WITHOUT THE KEY IN THE IGNITION. HE SIMPLY GRABS AND TURNS THE METAL PIECE WHERE THE KEY IS PLACED. HE IS CONCERNED THAT ANYONE CAN START AND STEAL THE VEHICLE. HE HAS A FRIEND WITH THE SAME VEHICLE WHO ALSO
... EXPERIENCES THIS FAILURE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO A SHOP OR MECHANIC. IT HAS NEVER BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 107,000 AND CURRENT MILEAGE WAS 180,000. UPDATED 01/21/09. *JBRead more
Incident date: Sep 15, 2008
TL*THE CONTACT OWNS A 1994 FORD BRONCO. THE CONTACT IS ABLE TO START THE ENGINE WITH OR WITHOUT THE KEY IN THE IGNITION. HE SIMPLY GRABS AND TURNS THE METAL PIECE WHERE THE KEY IS PLACED. HE IS CONCERNED THAT ANYONE CAN START AND STEAL THE VEHICLE. HE HAS A FRIEND WITH THE SAME VEHICLE WHO ALSO
... EXPERIENCES THIS FAILURE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO A SHOP OR MECHANIC. IT HAS NEVER BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 107,000 AND CURRENT MILEAGE WAS 180,000. UPDATED 01/21/09. *JBRead more
Incident date: Nov 2, 2004
THE VEHICLE WAS PARKED OUTSIDE OUR HOME AT 3:50 AM THE HORN STARTED TO BLOW, I LOOKED OUTSIDE AND FLAMES WERE COMING FROM UNDER THE HOOD. WE DROVE THE CAR EARLIER THAT DAY AROUND NOON FOR A COUPLE OF HOURS. *JB
Fire
Incident date: Jun 30, 2006
I OWN A FULL SIZE 1994 FORD BRONCO 351 5.8L EDDIE BAUER. AFTER DRIVING AT NIGHT FOR 5-10 MINUTES THE LIGHTS FLASH OFF AND ON INTERMITTENTLY. I NOTICED A VERY STRONG BURNING ELECTRICAL SMELL EMITTING FROM THE DASHBOARD AROUND THE HEADLIGHT/DIMMER SWITCH. I REMOVED THE DASH TO EXAMINE THE SWITCH, CONT
... ACT BLADES, AND WIRING HARNESS PLUG. THE PLASTIC CONNECTOR AT THE END OF WIRING HARNESS THAT PLUGS INTO THE HEADLIGHT/DIMMER SWITCH WAS BURNED, MELTED AND EXTREMELY HOT TO TOUCH. AFTER RESEARCH ON INTERNET I FEEL VERY STRONGLY THAT THIS PROBLEM WILL OCCUR MORE FREQUENTLY AS VEHICLES GET OLDER AND THE SWITCH FAILS DUE TO DEFECT. I'M NO AUTOMOTIVE GENIUS, BUT CONCERNED THAT OTHERS MAY CONTINUE TO DRIVE VEHICLE AND FAULTY SWITCHES WILL START FIRES. I SAW INFORMATION FROM WALTERS FORENSIC ENGINEERING - TORONTO ONTARIO THAT LAB SITUATIONS SHOWED THESE SAME SWITCHES CAUSE FIRES FROM ELECTRICAL RESISTANCE PROBLEMS. I HAVE THE MELTED PARTS FOR EXAMINATION. CONSEQUENCES CAN BE SERIOUS INJURY OR DEATH. FORD MOTOR CORPORATION SHOULD REPLACE/RECALL THESE FAULTY ITEMS. RECENT FORD FIRES MAY ALSO BE RELATED TO THIS SWITCH DUE TO CLOSE PROXIMITY OF CRUISE CONTROL FIRES SOURCE. THE HEADLIGHT SWITCH MAY MELT AND BURN BEHIND THE DASH AREA FROM HIGH HEAT. PART# STAMPED ON THE DIMMER SWITCH IS MOTORCRAFT E77B-11654-AA. THERE IS A SECONDARY NUMBER IN NON-REMOVABLE INK OR PAINT THAT APPEARS ALSO. MAY BE A FORD PLANT OR PART IDENTIFICATION# USED DURING ASSEMBLY. IT IS 3L 0912. THERE ARE 9 BLADES ON THE SWITCH THAT CONNECT TO WIRING HARNESS. THESE PRONGS HAVE IDENTIFICATION LETTERS NEXT TO THEM DOWN INSIDE THE SWITCH. (FOR EXAMPLE: TO NAME A FEW THERE ARE D1, D2, AND IGN) THE AREA OF CONCERN HAS B2 NEXT TO IT. IT'S AT THE BOTTOM OF THE THIRD ROWS OF BLADES IN THE CENTER. MOTORCRAFT APPARENTLY HAS A DIFFERENT OR NEW IDENTIFICATION# FOR THIS SWITCH. I HAVE NOT PURCHASED A REPLACEMENT YET, BUT IT LOOKS LIKE THE NEW PART # FOR MY VEHICLE AS DESCRIBED MAY BE SW2103. PLEASE RESPOND! *JBRead more
Incident date: Feb 13, 2002
1994 FORD BRONCO CAUGHT ON FIRE UNDER THE HOOD WHILE PARKED. THE VEHICLE WAS A TOTAL LOSS. *TS ***NO ANSWER REQUIRED*** THREE AND A HALF YEARS AFTER THE FIRE THE CONSUMER RECEIVED RECALL 05V388000 FROM THE MANUFACTURER. THE RECALL WAS FOR THE CRUISE CONTROL DEACTIVATION SWITCH. THE RECALL STATED
... THAT THE SWITCH COULD OVERHEAT AND RESULT IN A UNDERHOOD FIRE. THE LETTER ALSO STATED THAT A REPLACEMENT PART WOULDN'T BE AVAILABLE UNTIL 11/2005. THE CONSUMER REQUEST REIMBURSEMENT FOR THE VALUE OF HIS VEHICLE AT THE TIME OF THE FIRE. *NMRead more
Fire
Incident date: Feb 28, 2004
DT: THE CONTACT CALLED FORD ON 10-03-05 ABOUT THE RECALL LETTER SHE RECEIVED ON FRIDAY 9-28-05. T A FIRE BROKE OUT ON 2-28-04 ON 1994 FORD BRONCO. THE CONTACT TOLD FORD ABOUT THE FIRE, AND FORD CLAIMED THAT THE CONTACT'S INSURANCE TOOK CARE OF THE ISSUE AND THEY COULD NOT DO ANYTHING ELSE
... . ALSO, FORD TOLD THE CONTACT THAT BECAUSE SHE DID NOT HAVE A FORD DEALER LOOK AT THE CAR AND DETERMINE THAT THE CAUSE OF THE FIRE WAS THE SCDS THEY COULD NOT DO ANYTHING FOR HER. ON 2-28-04 WHILE DRIVING AT 70 MPH SHE SAW SMOKE IN REAR VIEW MIRROR. SHE PULLED OVER AND SAW A FIRE COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED, BUT CANCELLED AFTER A TRUCKER PUT THE FIRE OUT. NO ONE EVER DETERMINED THE CAUSE OF THE FIRE. SHE DID HAVE THE TRUCK REPAIRED AND WAS DRIVING IT NOW. SHE REPORTED OF HAVING NO PROBLEMS WITH THE CRUISE CONTROL OR ANY PROBLEMS WITH THE TRUCK STARTING PRIOR TO THE FIRE. AS OF THIS DATE SHE HAS NOT HAD THE SCDS DISCONNECTED, BUT PLANNED TO HAVE IT DISCONNECTED.*AKRead more
Fire
Incident date: Aug 5, 2005
CLOCK SPRING ASSEMBLY BEHIND STEERING WHEEL FOR AIRBAG AND STEERING WHEEL CONTROLS IS FAILING. COULD CAUSE AIRBAG TO NOT DEPLOY DURING AN ACCIDENT OR TO PREMATURELY DEPLOY UNDER REGULAR DRIVING CONDITIONS. *JB
Incident date: Sep 1, 2005
SUFFERED FROM THE FORD CRUISE CONTROL FIRE. 94 BRONCO 5.0 LITER. *JB
Fire
Incident date: Sep 26, 2004
ELECTRICAL FIRE UNDER HOOD AND DASH TOTALS BRONCO. MORNING OF FIRE THE BRAKE LIGHT FUSE HAD TO BE REPLACED BEFORE LEAVING WORK OFF THE NIGHT SHIFT FROM RIVER BEND STATION NUCLEAR POWER PLANT. 15 AMP FUSE REPLACED LIKE FOR LIKE. AT CHURCH LATER THAT MORNING (SUNDAY 9-26-04) THE TRUCK CAUGHT ON FIRE
... AFTER BEING IN THE PARKING LOT FOR ABOUT 1 1/2HRS. SOMEONE DRIVING BY CALLED 911 AND NOTIFIED THE CHURCH STAFF WHO STOPPED THE SERVICE TO FIND THE OWNER OF THE TRUCK, ME! ABOUT 4 DRY CHEM. FIRE EXT. WERE USED TO TRY AND BRING THE FIRE UNDER CONTROL BEFORE THE FIRE DEPT. PUT THE TRUCK OUT WITH AFFF FOAM. FIRE STARTED UNDER THE HOOD DRIVERS SIDE AROUND THE MASTER CYL. FIRE MARSHAL WROTE UP THE REPORT AND TOLD ME THE DEPT. HAS SEEN MANY OF THIS TYPE FIRE ON FORD TRUCKS IN THE LAST FEW YEARS AND JUST WONDERED WHEN SOMEONE IS GOING TO BE KILLED! WE GOT ALL OTHER CARS IN THE PARKING LOT AWAY FROM THE FIRE BUT MY TRUCK IS A TOTAL LOSS. *NMRead more
Fire
Incident date: May 24, 2004
SEAT BELT DANGERS TO OBESE PASSENGERS. SEAT BELT COMES ACROSS NECK, NOT CHEST. SUDDEN BRAKING PUTS STRAIN ON NECK. COMMENT: CRASH DUMMIES DO NOT RESEMBLE THE MAJORITY OF AMERICAN WOMEN IN SIZE OR SHAPE. MY NECK WAS BRUISED AND THROAT INJURED. THIS WAS JUST FROM HARD BRAKING, NOT A CRASH. UNLESS TH
... E SHOULDER HARNESS IS MADE MORE ADJUSTABLE WOMEN ARE GOING TO BE INJURED NOW THAT MORE STATES ARE GETTING TOUGH ON WEARING BELTS. I WEAR MINE TWISTED IN FRONT TO PLACE THE SHOULDER STRAP IN THE CENTER, OR WITH MY ARM THOUGH THE STRAP. *JBRead more
1 injured
Incident date: Dec 15, 2003
PARKING BRAKE SLIPPED WHEN APPLIED, CAUSING THE VEHICLE TO ROLL FREELY. THIS VEHICLE WAS MANUFACTURED ON MARCH 1994. DEALER AND MANUFACTURER STATED WE DIDN'T CARE WHEN IT WAS MANUFACTURED IN 1994, THERE WAS NOT RECALL ON THIS VEHICLE.*AK
Incident date: Dec 23, 2002
INTERMITTENT HEADLIGHT FAILURE, SIMILAR TO THE 1998 RECALL OF FORD CARS
Incident date: Aug 24, 2002
THE TREAD OF THE TIRE COMPLETELY CAME OFF. THERE WAS LITTLE WARNING BEFORE IT HAPPENED, WE WERE DRIVING AT A STEADY SPEED OF APPROXIMATELY 50 MPH ON A STRAIGHT AWAY. NO TURNING OR BRAKING WAS TAKING PLACE AT TIME OF FAILURE. THE TREAD WAS NOT WARN AND HAD PLENTY TREAD LEFT BEFORE THE TREAD WEAR L
... IMITS. THERE ARE SIGNS THAT THE OTHER THREE TIRES TREAD WAS DELAMINATING. DTRead more
Incident date: Jan 10, 2000
IN EARLY JANUARY OF 2000, I NOTICED THE RIGHT FRONT INSULATOR (BUSHING) ON THE RIGHT FRONT RADIUS ARM HAD ALMOST BEEN COMPLETELY DESTROYED. I LOOKED ON WEBSITE WWW.ALLDATA.COM AND FOUND A LISTING FOR A TECHNICAL SERVICE BULLETIN, #95259, ISSUE DATE 12/95, TITLE : PULL OR DRIFT LEFT- RADIUS ARM REP
... LACEMENT. I TOOK MY BRONCO TO OURISMAN FORD DEALERSHIP IN BETHESDA MARYLAND WHERE I HAD BOUGHT TRUCK AND TOLD THEM THE BUSHING WAS ALMOST COMPLETELY GONE AND NEEDED TO BE REPLACED. AT THE TIME THE TRUCK WAS UNDER AN EXTENDED WARRANTY SO INSTED OF TRYING TO FIGHT WITH THEM ABOUT THIS BEING A SAFETY DEFECT THAT SHOULD BE FIXED FOR FREE BY FORD, I TOLD THEM THE WARRANTY COMPANY WOULD PAY FOR THE REPAIR AND THEY DID, BUT ONLY ON THE RIGHT SIDE. THE DEALERSHIP SERIVCE DEPT TOLD ME BOTH RAIDUS ARMS HAD TO BE REPLACED IN A PAIR AND THEY COULD NOT REPLACE ONE AT AT TIME, SO I HAD TO PAY FOR THE LEFT SIDE WHICH WAS NOT DAMAGED AT ALL. TODAY (8/30/02) WHILE I WAS CHECKING MY TRUCK OVER AGAIN WHILE CHANGING THE OIL AND ONCE AGAIN I FOUND THE RIGHT FRONT RADIUS ARM INSULATOR (BUSHING) HAS ALMOST DISINTEGRATED AGAIN AND NEEDS TO BE REPLACED AGAIN. THIS TIME THE TRUCK IS NO LONGER UNDER WARRANTY. CAN YOU PLEASE ADVISE ME IF YOUR STAFF AGREES THAT THIS REPEATED INSULATOR FAILURE IS DEFINITELY A MANUFACTURERS DESIGN DEFECT AND SINCE IT INVOLVES A CRITICAL COMPONENT OF THE VEHICLES SUSPENSION (THE RADIUS ARM), THAT IT SHOULD BE REPLACED FOR FREE (INCLUDING THE LEFT SIDE AND A FRONT END ALIGNMENT WHICH THEY DID LAST TIME AROUND? THE CURRENT MILEAGE ON THE TRUCK IS 85735 .*AKRead more
Incident date: May 27, 2002
VEHICLE CAUGHT ON FIRE UNDER THE DASH WHILE DRIVING 60 MPH. DEALER AND MANUFACTUERER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Fire
Incident date: Jun 17, 2002
CLOCKSPRING ON VEHICLE FAILED AND AIR BAG WARNING LIGHT STARTED TO FLASH. HORN WOULD INTERMITTENTLY WORK. CONTACTED DEALER. *AK THE HORN FAILED WHILE DRIVING AND WAS REPLACED. *YH
Incident date: Sep 1, 2001
EXHAUST PIPE HIT FUEL TANK WHICH MADE A HOLE IN TANK. HAD FUEL TANK REPLACED, AND EXHAUST PIPE IS RUBBING AGAINST THAT TANK. HAD NOT CONTACTED DEALER.*AK *SLC
Incident date: Jun 28, 2001
A FIRE DEVELOPED IN ENGINE COMPARTMENT NEAR STEERING COLUMN, CONSUMER WAS TOLD THAT FIRE WAS STARTED BY VEHICLE. CONSUMER ALSO STATED THAT VEHICLE AS IN EXCELLENT CONDITION PRIOR TO FIRE. *AK *TT
Fire
Incident date: May 18, 2001
CONSUMER WAS REARENDED BY ANOTHER VEHICLE, AND AIRBAG DID NOT DEPLOY. SINCE THAT TIME, AIRBAG LIGHT HAS BEEN FLASHING. DEALER STATED THAT WIRES CONNECTING CLOCK SPRING ASSEMBLY TO PANEL HAVE BROKEN, THIS HAPPENED ALL THE TIME. VEHICLE STILL AT DEALER AT THIS TIME. PLEASE ADD FURTHER COMMENTS.
... *AKRead more
Crash
Incident date: Aug 15, 1994
VEHICLE WAS PULLING SHARPLY TO THE LEFT WHEN BRAKING AT HIGHWAY SPEED. VEHICLE BEEN IN DEALER SHOP ON TWO OCCASIONS, AND PROBLEM STILLOCCURRING. PLEASE FEEL FREE TO PROVIDE US WITH ANY FURTHER INFORMATION CONCERNING THIS MATTER. *AK
Incident date: May 4, 2001
FULL-SIZE BRONCO PULLS HARD LEFT (INTO ONCOMING TRAFFIC LANE) UPON BRAKING. WORSE ON HARD BRAKING BUT OCCURS AT ALL SPEEDS. BRAKES WERE JUST REPLACED BY DEALER 6 WEEKS AGO - SAME THING. DEALER SAID THERE IS TSB ADVISING TO SWAP WHEELS AND BRAKE PADS. IT REDUCED PROBLEM, BUT LEFT PULL STILL BAD E
... NOUGH TO PULL VEHICLE INTO ONCOMING TRAFFIC UPON HARD BRAKING - UNSAFE. DRIVER MUST STEER RIGHT TO MAINTAIN STRAIGHT COURSE UPON ALL TYPES OF BRAKING. FORD AND NHTSA KNOWS ABOUT THIS SAFETY ISSUE - DOES SOMEONE HAVE TO DIE TO GET A REAL FIX? THIS TRUCK IS HUGE AND IT MAY BE INNOCENT VICTIM GETS HIT IN HEAD-ON COLLISION. PLEASE REVIEW AND SEE IF THERE IS A REAL FIX, NOT SWAPPING DISK PADS TO MASK THE REAL DESIGN FLAW ISSUE. *AKRead more
Incident date: Apr 29, 2001
TIRE TREAD SEPARATION AT HIGH SPEED. *AK (DOT NUMBER: 7B82PUB227 TIRESIZE: 31X10.5R15)
Incident date: Jan 20, 2001
CONSUMER NOTICED THAT BUMPER WAS LOOSE, AND WOULD TIGHTEN IT LATER. RECALL 94 V 018 000 FOR BUMPER HAS ALREADY BEEN USED FOR REPAIRS. *AK
A DEFECT IN STEERING COLUMN CAUSED HORN/AIR BAG, AND CRUISE CONTROL TO BECOME INOPERATIVE. DEALER HAS BEEN CONTACTED.*AK
A DEFECT IN STEERING COLUMN CAUSED HORN/AIR BAG, AND CRUISE CONTROL TO BECOME INOPERATIVE. DEALER HAS BEEN CONTACTED.*AK
A DEFECT IN STEERING COLUMN CAUSED HORN/AIR BAG, AND CRUISE CONTROL TO BECOME INOPERATIVE. DEALER HAS BEEN CONTACTED.*AK
A DEFECT IN STEERING COLUMN CAUSED HORN/AIR BAG, AND CRUISE CONTROL TO BECOME INOPERATIVE. DEALER HAS BEEN CONTACTED.*AK
Incident date: Oct 13, 2000
VEHICLE FIRE WHILE PARKED IN THE DRIVEWAY. LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE, AND BELIEVED FIRE STARTED FROM A ELECTRICAL SHORT FROM THE DRIVER SIDE UNDER THE HOOD, NEAR THE FIRE WALL. DEALER/MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DET
... AILS. *AKRead more
Fire
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
Incident date: Mar 20, 1996
CRACK AND RUST RAIN GUTTER LEFT AND RIGHT SIDE ABOVE DOORS. THIS IS THE SECOND BRONCO I HAVE OWNED THAT DID THE SAME THING. THE OTHER BRONCO WAS A 1987 (?) OR SO IT WAS FIXED AT LEAST 2 TIMES BY FORD BUT CRACK CAME BACK. THIS BRONCO DID SAME THING FORD SAID THERE IS NO FIX. THERE SHOULD BE ONE
... OR MONETARY COMPENSATION AS IT IS A KNOWN REOCCURRING PROBLEM. THE RUST IS GETTING BAD NOW AND THEY DON'T WANT TO KNOW ANYTHING. THEY WERE NOTIFIED OF IT WHILE IT WAS UNDER WARRANTY THEY PUT BODY SEALER ON THE CRACKS TO SEAL THEM UNTIL IT PEELED AND FLAKED OFF. *AKRead more
Incident date: Nov 14, 1999
VEHICLE WAS MAKING LOUD HUMMING NOISES. WHILE DRIVING ON THE HIGHWAY AND GOING UP HILL, ALL OF A SUDDEN THE VEHICLE WOULD NOT MOVE. APPLIED BRAKES AND PUT VEHICLE IN PARK AND LEFT IT THERE. CONTACTED THE MECHANIC WHO REPLACED THE TRANSMISSION IN MARCH 1998, BUT WARRANTY WAS UP. *AK
Incident date: Aug 30, 1999
THIS APPEARS TO BE A DESIGN DEFECT. THE CATALYTIC CONVERTER IS MELTING THE RADIUS ARM BUSHINGS. FORD HAS HAD SIMILAR PROBLEMS WITH FORD EXPLORER AND PROBABLY F150. IF YOU TALK TO THE PARTS FOLKS THIS IS A COMMEN PROBLEM. I HAVE WRITTEN AND CALLED FORD SEVERAL TIMES ABOUT THIS. THE RADIUS ARM BUSHING
... S HELP HOLD THE FRONT AXLE IN PLACE, WHEN THEY MELT IT CAUSES THE VEHICLE TO STEER AND BRAKE DANGEROUSLY.Read more
Incident date: Jul 7, 1999
TOTAL LOSS OF BRAKING DUE TO MALFUNCTIONING OF MASTER CYLINDER. DEALER NOTIFIED AND MAD E REPAIRS. EPORTING THIS INCIDENT TO NHTSA. *AK
Incident date: Jul 7, 1999
TOTAL LOSS OF BRAKING DUE TO MALFUNCTIONING OF MASTER CYLINDER. DEALER NOTIFIED AND MAD E REPAIRS. EPORTING THIS INCIDENT TO NHTSA. *AK
THE CLOCK SPRING IS LOOSE WITHIN AIRBAG ASSEMBLY, CAUSING A RATTLING NOISE WHEN TURNING THE STEERING WHEEL. *AK
VEHICLE SEAT TRACKS/ANCHORS FAILED RESULTING IN STABILITY PROBLEMS WITH SEATS, RECALL ON COMPONENT HOWEVER VEHICLE DENIED DUE TO VIN #.
Incident date: Nov 4, 1998
THIS IS THE MAIN HARNESS THAT REVEALS HEATING AT THE 120 PLUS PIN CONNECTOR AT THE ENGINE WALL AND CONNECTED TO THE COMPUTER MODULE UNDER THE HOOD ADJACENT TO THE STEERING COLUMN. CONTACT JOHN AT SUPERIOR INVESTIAGTIONS AT THE ABOVE NUMBERS FOR ADDITIONAL INFORMATION
Fire
Incident date: Jan 1, 1999
BUSHINGS APPEAR TO HAVE MELTED. THE RIGHT BUSHING IS NEAR THE EXHAUST, SO WHEN IT FAILED I ASSUMED IT WAS THE PROXIMITY TO HEAT. THE LEFT IS NO WHERE NEAR ANY HEAT SOURCE. THE REPLACEMENT ON THE RIGHT SIDE AND ALL OTHER SUSPENSION COMPONEMTS SHOW NO SIGNS OF WEAR. ONLY THE ORIGIONAL BUSHINGS HAVE
... DETERIORATED. *AKRead more
Incident date: Dec 28, 1998
WAS TOLD OVERHEATED CATALYTIC CONVERTER BURNED THROUGH TRANSMISSION FLUID LINE, CAUSING FIRE. MY HUSBAND AND I WERE DRIVING ON A TRIP (ON 12-28-98) WHEN OUR 1994 FORD BRONCO CAUGHT ON FIRE. AFTER THE FIRE TRUCKS ARRIVED AND THE FLAMES WERE PUT OUT, TH
Fire
Incident date: Nov 4, 1998
THIS RISK WAS PARKED IN AN ENCLOSED GARAGE FOR APPROX. TWOO HOURS BEFORE CATCHING FIRE DOING DAMAGE TO THIS PLUS ANOTHER VEHICLE PLUS SMOKE AND HEAT DAMAGE THROUGHOUT THE STRUCTURE. THIS LOSS IS AN ELECTRICAL COMPONENT FAILURE OVER THE DRIVERS SIDE FRONT FENDER IN THE AREA OF THE PRIMARY FUSE PANEL
... . CALL JOHN AT SUPERIOR INVESTIGATIONS FOR DETAILS 727-848-3923.Read more
Fire
Incident date: Oct 2, 1998
DRIVER'S SEAT SHIFTED, RECALL ON COMPONENT HOWEVER VEHICLE WAS NOT COVERED IN RECALL DUE TO VIN#.
Showing 50 of 114 complaints.