1994 CHEVROLET CAPRICE

10 recalls, 185 complaints - 19 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIAT... Read more

Consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy

AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

3,593 vehicles affected

Manufacturer: AJ MOTORSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

SUSPENSION:REAR

Defect Description

THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.

Consequence

THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.

Remedy

DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.

154,214 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Description

DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.

Consequence

IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.

Remedy

DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.

308 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

VEHICLE SPEED CONTROL:SPRINGS

Defect Description

THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.

Consequence

CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.

87,039 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Defect Description

THE FUEL TANK ATTACHMENT STRAP FASTENERS WERE NOT PROPERLY TIGHTENED. THE FASTENERS CAN COMPLETELY DETACH, EVENTUALLY ALLOWING THE FUEL TANK TO SAG AND THE BOTTOM OF THE TANK TO STRIKE THE ROADWAY.

Consequence

THIS CAN RESULT IN A FUEL TANK LEAK AND FIRE IF THE LEAKING FUEL IS EXPOSED TO A SOURCE OF IGNITION.

Remedy

DEALERS WILL RETIGHTEN THE FUEL TANK STRAP FASTENERS.

130,581 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

WHEELS:LUGS/NUTS/BOLTS/STUDS

Defect Description

PAINT ON THE WHEEL MOUNTING SURFACES CAN ACT AS A SHIM BETWEEN THE WHEEL AND THE ROTOR/DRUM. AS THE VEHICLE IS DRIVEN, THE WHEEL IMBEDS INTO THE PAINT, LOOSENING THE LUG NUT AND CAUSING A LOSS OF CLAMP LOAD.

Consequence

ONCE CLAMP LOAD IS LOST, ALL TIRE LOADS ARE TAKEN BY THE WHEEL STUDS RESULTING IN A FRACTURE OF THE WHEEL STUDS. THIS COULD CAUSE THE WHEEL TO SEPARATE FROM THE VEHICLE AND COULD RESULT IN A VEHICLES CRASH WITHOUT PRIOR WARNING.

Remedy

DEALERS WILL CLEAN THE WHEEL MOUNTING SURFACES FOR ALL FOUR WHEELS. ALSO, THE WHEEL STUDS WILL BE INSPECTED FOR DAMAGE AND WILL BE REPLACED AS NECESSARY.

139 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Defect Description

THE ENGINE OIL COOLER INLET HOSE MAY HAVE BEEN INSTALLED TOO CLOSE TO THE STEERING GEAR CAUSING CHAFING. THE CHAFING CAN EVENTUALLY WEAR THROUGH THE HOSE'S PROTECTIVE SLEEVE RESULTING IN ENGINE OIL LEAKING ONTO THE ENGINE.

Consequence

IF THIS OCCURS, THE OIL LEAK ONTO THE ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE.

8,475 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

185 total complaints 17 crashes 11 fires 9 injuries

Top Reported Components

Component	Complaints
LATCHES/LOCKS/LINKAGES:DOORS:LATCH	27
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	10
VEHICLE SPEED CONTROL	8
ELECTRICAL SYSTEM	6
STEERING: STEERING WHEEL/HANDLE BAR	6
ELECTRICAL SYSTEM:HORN	5
SUSPENSION:FRONT	5
TIRES	5
ELECTRICAL SYSTEM:WIRING	5
ELECTRICAL SYSTEM:IGNITION	4

Incident date: Dec 17, 2017

TL* THE CONTACT OWNS A 1994 CHEVROLET CAPRICE. WHILE DRIVING 55 MPH, THE ENTIRE FRONT END OF THE VEHICLE SHOOK AND THE CONTACT LOST CONTROL. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT CONTINUED TO DRIVE SLOWLY. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO TH... Read more

Incident date: Dec 17, 2017

Incident date: Aug 12, 2011

FIRESTONE TIRE FR380 WS P225/75R15 55,000 MILE TIRE. AFTER 12,000 MILES TIRE S ARE SHOWING STEEL BELTS THROUGH THE TREAD. INDEPENDENT MECHANIC AND ALIGNMENT VERIFIED THAT THERE IS NO PROBLEM WITH ALIGNMENT OR SUSPENSION. TIRES PURCHASED MARCH 13, 2008. *TR

Incident date: Oct 1, 2009

GM HAS PUT THE PROBLEM UNDER TSB 94-C-59 OR 94V049 IT SPECIFICALLY STATES THAT THEY WILL REPAIR THE PROBLEM AT NO COST REGARDLESS OF AGE, OWNERSHIP, OR MILEAGE. THIS PROBLEM DOES NOT FALL UNDER A RECALL LISTING. THE CAR CONSTANTLY STALLS BECAUSE OF THE PROBLEM, AND I AM UNABLE TO USE ANY OF THE... Read more

Incident date: Jun 10, 2004

DIGITAL DASH SPEEDOMETER GOES AWAY, DOES NOT SHOW SPEED OF TRAVEL. WHEN THIS HAPPENS OPPERATOR DOES NOT KNOW THE RATE OF SPEED BEING TRAVELED. I HAVE REPLACED THE UNIT ONCE BEFORE AT 99,000 MILES WITH A RECONDITIONED UNIT AT A COST OF $300.00. RECENTLY AT 140,000 MILES THIS UNIT HAS FAILED ALSO. THI... Read more

Incident date: Jul 31, 2005

DT: CABLE FROM BATTERY TO JUNCTION BOX OVERHEATED AND STARTED A FIRE. IT MELTED THE STUD THAT BATTERY CABLE WAS CONNECTED TO, THE JUNCTION BOX AND THE AREA AROUND THE JUNCTION BOX. CALLER WAS AT A CAR WASH AND THE ATTENDENT SAW SMOKE AND ALERTED CONSUMER. THEY OPENED THE HOOD AND DISCONNECTED THE B... Read more

Fire

Incident date: Jul 28, 2005

DT: GENERAL MOTORS REFUSED TO HONOR A RECALL 94-C-59 ON 1994 CHEVROLET CAPRICE CLASSIC. CAR OVERHEATED IN THE ELECTRICAL CENTER, THE COVER MELTED. THIS CAN HAPPEN AT ANY TIME, AND NO INDICATOR LIGHTS CAME ON PRIOR TO THE CAR STALLING. THE CAR LOST POWER COMPLETELY THE CAR WILL NOT START BACK ... Read more

Incident date: Sep 13, 2004

VEHICLE PURCAHSED USED FROM A CHEVY DEALER. EXPERIENCED COMPLETE LOSS OF ELECTRICAL POWER, EVEN HAZARD LIGHTS INOPERATIVE. MECHANIC THOUGHT IT WAS ALTERNATOR, PROBLEM EXPERIENCED AGAIN. MECHANIC FOUND "BATTERY STUD" LOCATED AT "ELECTRICAL CENTER" WAS LOOSE. HE "PATCHED" IT UP. I HAVE FOUND THROUGH "... Read more

Incident date: Sep 26, 2004

I STARTED MY 1994 CHEVY CAPRICE CLASSIC AND BEFORE I COULD GET IT INTO GEAR, MY CAR TOOK OFF AND SLAMMED INTO THE BACK OF A HONDA.

Crash

Incident date: Jun 29, 2004

VEHICLE LOST POWER AND STALLED DUE TO BATTERY CABLE CONNECTION OVERHEATING AT THE UNDER HOOD ELECTRICAL CENTER STUD. THIS OCCURRED BECAUSE THE BATTERY CABLE PLASTIC COVER, T PLASTIC STUD HOUSING, AND/OR THE STUD ITSELF MELTED. THERE WAS GENERAL RECALL 94C59 FOR THE ELECTRICAL CENTER BATTERY STUD. T... Read more

Incident date: Jul 1, 2004

PROBLEMS WITH FIRESTONE TIRE EQUIPMENT ON VEHICLE.*MR THE CONSUMER HAD NEW FIRESTONE TIRE INSTALLED ON THE VEHICLE. WHILE DRIVING THE CONSUMER HEARD A THUMPING NOISE AND RETURNED THE VEHICLE TO THE DEALER. THE VEHICLE WAS TAKEN TO THE DEALER FIVE TIMES AND EACH TIME THE DEALER INDICATED THAT THE ... Read more

Incident date: Apr 6, 2004

MY WIFE'S 1994 CAPRICE HAS HAD INTERMITTENT NON WORKING POWER STEERING SINCE WE BOUGHT THE CAR NEW. IT IS A TOTAL LOST OF STEERING AS IF THE BELT HAD BROKEN OR THE MOTOR WAS TURNED OFF. AFTER SEVERAL LENGTHY SERVICE TRIPS TO THE DEALER, WHO ACTED LIKE WE WERE CRAZY, NOTHING WAS EVER DONE TO THE CAR... Read more

WHEN STEERING IS TILTED IN A CERTAIN DIRECTION A FUSE WOULD BLOW OUT. *AK THE FUSE THAT BLOWS IS FOR THE WINDSHIELD WIPERS. CONSUMER THINKS IT A PINCHED WIRE IN THE STEERING COLUMN WHEN THE WHEEL IS TITLED AND THE WIPERS ARE TURNED ON. A LIGHT MOVEMENT OF THE TILTED WHEEL WILL BLOW THE FUS... Read more

DIGITAL SPEEDOMETER WAS 35 MPH OFF WHICH RESULTED IN A REAR END COLLISION BECAUSE VEHICLE WAS GOING FASTER THAN THE SPEEDOMETER INDICATED. DIGITAL GAS GAUGE ALSO FAILED TO FUNCTION WHICH RESULTED IN VEHICLE RUNNING OUT OF GAS WHILE DRIVING ALTHOUGH THE GAUGE READ HALF OF TANK. THE CAUSE OF BOTH F... Read more

Crash

THE VEHICLE DIED AT 65 MPH,AND WOULD NOT RESTART. HAD TO BE TOWED. *AK

Incident date: Apr 19, 2003

FUEL PUMP FAILURE. WIRE CONNECTED TO FUEL PUMP MELTED BARE. WIRE CONNECTOR MELTED ONTO FUEL PUMP. WIRE HARNESS MELTED. *JB

THERE'S A DESIGN FLAW IN VEHICLES' CAP ROTOR DISTRIBUTOR. IT IS LOCATED IN THE BOTTOM OF THE ENGINE CLOSE TO THE GROUND, SO WHEN VEHICLE IS BEING DRIVEN IN THE RAIN, WATER GOES INTO THE ROTOR AND MOISTURE IS ACCUMULATED. THIS RESULTS IN THE VEHICLE STALLING WHILE DRIVING WITHOUT WARNING. MANUFACT... Read more

Incident date: Feb 3, 2000

A DESCRIPTIVE LETTER REGARDING THE STEERING COLUMN CORROSION FAILURE WAS SENT TO THE MANUFACTURERE WITH NO REPLY. DT

WHILE DRIVING, BATTERY GAUGE GOES DOWN. CONNECTOR TO FUSE PANEL UP AGAINST FIREWALL HAS MELTED. *AK

Incident date: Jun 8, 2000

IN THE FIRST INCIDENT THE TREAD SEPARATED AND THEN THE TIRE BLEW OUT. HAD THE TIRES VISUALLY INSPECTED; THEY SAW NO PROBLEMS. IN THE SECOND INCIDENT THE TREAD SEPARATED ALMOST COMPLETELY AND DAMAGED THE LEFT FRONT WHEEL WELL AND QUARTER PANEL. WHILE RETURNING FROM THIS INCIDENT ANOTHER TREAD SEPA... Read more

Incident date: Dec 15, 2000

METAL AROUND LATCH THAT HOLDS DOOR IS CRACKED, AND IS NOT CATCHING PROPERLY, DOOR DOES NOT SHUT TIGHTLY. *AK

Incident date: Nov 21, 2000

ABS VALVE ROTTED OUT, CAUSING TOTAL FAILURE OF BRAKES. *AK

CONSUMER IS BEING REFUSED RECALL 94V049, VEHICLE IS EXPERIENCING MANY PROBLEMS DUE TO THIS RECALL RELATED COMPONENT: SUDDEN AND INCREASING CHARGING SYSTEM DISCHARGE, INTERMITTENT STARTER MALFUNCTION, PERIODIC OVERHEATING, AND MELTING AT THE CENTER STUD OF THE BATTER JUNCTION BOX, CONSUMER WANTS REI... Read more

Incident date: Oct 3, 2000

NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK

Incident date: Sep 20, 2000

GENERAL RADIAL RIGHT REAR TIRE P215/75R15 DOT A3HFBBH054 EXPERIENCED TREAD SEPARATION, CONSUMER HEARD A FLAPPING NOISE AND WHEN INSPECTED TIRE ALSO FOUND IT WAS STILL INFLATED. *SLC

Incident date: Aug 20, 2000

WHILE DRIVING ON THE FREEWAY AT 65 MPH, I ATTEMPTED TO OPEN THE DRIVER'S SIDE WINDOW USING THE POWER WINDOW CONTROLLER AND HEARD A LOUD CRACK. THE WINDOW HAD TWISTED AND WAS OFF IT'S TRACK. THE WINDOW WAS TWISTED SO MUCH THAT THE UNDER LEFT CORNER OF THE WINDOW WAS TOUCHING THE OUTER DOOR SKIN, AN... Read more

Incident date: Jun 15, 2000

TIRE TREAD SEPARATION: WHILE DRIVING ABOUT 60 MPH, HALF OF THE TREAD ON THE DRIVER'S SIDE FRONT TIRE PEELED OFF. ENTIRE TREAD PEELED OFF THE LEFT RIGHT TIRE 3 DAYS BEFORE. TIRE SIZE P225/75R15 AND DOT # HYHHF6A096, HYHHF6A535. TIRES WERE ON A 1994, CHEVROLET CAPRICE. NOT ORIGINAL TIRE EQUIPMENT.... Read more

Incident date: Jul 26, 2000

CONSUMER BELIEVED THAT WATER PUMP WAS FAULTY/DEFECTIVE. IT NEEDS REPLACEMENT AT LESS THEN 28,000 MILES OF WEAR. DEALER NOTIFIED. FEEL FREE TO PROVIDE FURTHER DETAILS. *AK

Incident date: Jul 5, 2000

CONSUMER WAS TRAVELING ABOUT 55 ON THE HIGHWAY AND THE ACCELLERATOR PEDAL GOT STUCK . THE CONSUMER APPLIED BOTH FEET ON THE BRAKE ANDTHE VEHICLE WAS STILL GOING. CONSUMER GOT THE SPEED DOWN TO TWENTY, AND SHIFT THE VEHICLE INTO NEUTRAL AND TURN THE VEHICLE OFF.*AK

Crash

Incident date: Dec 7, 1999

WHILE VEHICLE WAS RUNNING AND THEN SHIFTING INTO PARK, VEHICLE SUDDENLY ACCELERATED AND RAN INTO ANOTHER VEHICLE. NO INJURIES WERE SUSTAINED. DEALER NOTIFIED. *AK

Crash

Incident date: Mar 13, 2000

AFTER PARKING VEHICLE AND SHIFTING INTO PARK WITH ENGINE STILL RUNNING, WITHIN A FEW SECONDS, VEHICLE STARTED TO MOVE DUE TO AUTOMATIC TRANSMISSION INTERLOCK SYSTEM FAILURE. DEALER NOTIFIED. *AK

Incident date: Sep 15, 1999

HORN ASSEMBLY IS HARD TO USE, AND DOSEN'T WORK WHEN NEEDED. NEEDS TO BE RECALLED..SAFETY HAZARD ,MANY MORE WILL REPORT IN DUE TIME. *AK

Incident date: Nov 12, 1997

WHILE DRIVING VEHICLE AT 45MPH IT WOULD MAKE HOWLING NOISES IN THE REAR. TOOK VEHICLE TO DEALER & INFORMED BY MECHANIC THE PROBLEM WAS REAREND DIFFERENTIAL. ALSO, BRAKES WOULD PULL TO THE LEFT WHEN APPLIED. CANNOT LOCATE PROBLEM WITH NAKED EYE. TIRES WERE REPLACED & VEHICLE WAS ALIGNED, AND FRONT ... Read more

Incident date: Nov 12, 1997

Incident date: Nov 17, 1999

VEHICLE STOPPED RUNNING--DETERMINED IT WAS A FUEL PROBLEM. AFTER REMOVING THE FUEL TANK FROM A 1994 CHEVROLET CAPRICE POLICE PACKAGE VEHICLE, IT WAS DISCOVERED THAT THERE WAS EVIDENCE OF A SEVERE OVERHEATING/MINOR FIRE WHICH CAUSED THE MELTING OF THE INSULATION OF THE GRAY POWER WIRE AND CHAFING OF... Read more

Fire

Incident date: Apr 11, 1999

IN A SUDDEN ICE/SNOW STORM HIT A PATCH OF ICE & VEHICLE STARTED TO SLIDE TO LEFT TOWARDS TRAFFIC. SWERVED TO RIGHT & HIT A STUMP. NEITHER AIR BAGS DEPLOYED UPON IMPACT. PASSENGER'S SEAT BELT BROKE. DRIVER HIT KNEE ON DASHBOARD. DRIVER'S SEAT BELT REMAINED INTACT. NO EMERGENCY TREATMENT. INSURANCE TO... Read more

Crash

Incident date: Apr 11, 1999

Crash

Incident date: Sep 30, 1999

WHILE PULLING INTO THE DRIVER WAY UPPER CONTROL ARM SNAPPED IN HALF. *AK

Incident date: Sep 15, 1999

A COUPLE OF MONTHS AGO CONSUMER NOTICED A SMELL AND SAW SMOKE COMING FROM THE HOOD. WHILE INSPECTING THE PROBLEM CONSUMER'S FINGER WAS SUFFERELY BURNED. *AK

Fire 1 injured

Incident date: Apr 4, 1999

EXHAUST MANIFOLD MALFUNCTIONED, CAUSING CAR TO HESITATE. THEN PULLED OFF AND LEAKED EXHAUST FUMES INTO THE CAR. *AK

ANTI-LOCK BRAKES DO NOT WORK IN THE SNOW.

Incident date: Jun 15, 1998

CONSUMER WANTS TO REPORT THE DESIGN AND POOR MATERIALS USED ON THE CONNECTOR FROM BATTERY CABLE TO THE FUSE BOX. BELIEVED THIS CONDITION CAUSED POOR CIRCUIT FLOW AND POOR OPERATION OF VEHICLE. NHTSA NEEDS TO LOOK INTO THIS MATTER. (CONSUMER WILL PROVIDE FURTHER DETAILS. *AK

Incident date: Jul 20, 1999

ALTERNATOR: VEHICLE WAS BEING DRIVEN WHEN IT STARTED TO MAKE A LOUD NOISE FROM UNDER THE HOOD AREA, DRIVER PULLED INTO A DRIVEWAY WHEN IT START TO RAIN (DOWN POOR), SAT NAD WAITED FOR RAIN TO STOP ABOUT TEN MINUTES WHILE VEHICLE WAS SHUT-0FF AT THE KEY. RAIN STOPPED AND VEHICLE WAS REASTARTED WITH N... Read more

Incident date: Jul 20, 1999

PLASTIC LATCH HOUSING ON THE GLOVE COMPARTMENT BROKE, CAUSING THE LIGHT TO STAY ON INSIDE OF THE COMPARTMENT, RESULTING IN A FIRE HAZARD. *AK

Incident date: Apr 18, 1998

HORN DOESN'T WORK PROPERLY, AND IT'S VERY HARD TO USE THE HORN. ALSO, THERE IS A LEAKAGE WITHIN THE EXHAUST MANIFOLD. *AK

Incident date: Apr 18, 1998

HORN DOESN'T WORK PROPERLY, AND IT'S VERY HARD TO USE THE HORN. ALSO, THERE IS A LEAKAGE WITHIN THE EXHAUST MANIFOLD. *AK

Showing 50 of 185 complaints.

Technical Service Bulletins, 1994 CHEVROLET CAPRICE

19 manufacturer communications from 16 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
136000 VISIBILITY:WINDSHIELD WIPER/WASHER	2
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	2
350000 EQUIPMENT	2
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	2
116200 ELECTRICAL SYSTEM:IGNITION:MODULE	1
161000 STRUCTURE:FRAME AND MEMBERS	1
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)	1
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL	1

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EXPERIENCE ENGINE MISS/ POOR DRIVEABILITY SYMPTOMS. *YC

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

EXPERIENCING ENGINE NOISE. *YC

011000 STEERING: STEERING WHEEL/HANDLE BAR

EXPERIENCING INTERMITTENT STEERING COLUMN SNAP OR CLICK NOISE WHEN TURNING. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

WATER IN AIR PUMP AND/OR DTC P0410, P0412, P1415, P1416, P0100, P0101, P0102 AND DTC 48 (INSTALL AIR PUMP SERVICE KIT). *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE NOISE (INSTALL VALVE STEM OIL SEAL). *TW

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

MILD SHUTTER OR SAIL-ON BETWEEN 40 TO 60 MPH, STALL IN REVERSE. *TW

110100 ELECTRICAL SYSTEM:HORN

HORN MAY HONK WITHOUT DRIVER ACTIVATION (REPLACING STEERING WHEEL AND SIR MODULE ASSEMBLY). *SD

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

UNKNOWN

161000 STRUCTURE:FRAME AND MEMBERS

REAR WHEEL/TIRE POSITION IN WHEEL WELL OPENING. *TW

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

WIPER CHATTER DURING COLD WEATHER. *TW

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

NEW CALIIBRATION TO CORRECT SLUGGISH PERFORMANCE/SPEEDOMETER INACCURACY. *TW

NHTSA Safety Investigations, CHEVROLET CAPRICE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 1994

COOLANT FIRES