2008 BMW X5 Recalls, Complaints & Safety

Last night my 2008 BMW X5 caught fire while parked in a parking lot - the fire was in the engine compartment and appeared to be an electrical fire - police and fire were at the scene and a report was made.

Fire

Last night my 2008 BMW X5 caught fire while parked in a parking lot - the fire was in the engine compartment and appeared to be an electrical fire - police and fire were at the scene and a report was made.

Fire

Airbag light is on for passenger and fuel injectors messed up. This is a 2008 and other ones had recalls. I don’t understand why mine did not lights are flickering a little bit and before it was smoking really bad and I had to get that fixed.

The contact owns a 2008 BMW X5. The contact stated while driving 50 MPH, several unknown warning lights illuminated. The contact stated that two minutes later the instrument panel went blank. The contact stated that the infotainment system failed to display an image and a dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V683000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 147,644.

Component Malfunctioned, All dashboard light are on. service check needed immediately. PCV heater not working ,cruise control not working, loose suspensions, knocking noise from the front and rear of the car. Air bags driver and passenger. All other UNKnown problems. I was told my Casey BMW of Newport News Va. That my car had no recalls? I am spending so much money just to try to keep my car updated. I can no longer do it. I am on a fixed income. If you can be of any assistance, please help! Thanks

Seat Calibration; Airbag/Seat Belt Tensioner, level control system malfunction etc

Drivers side rear tire 255/50R19 tire sidewall split out going 60 MPH leading to rapid loss of tire pressure.

My 2008 bmw x5 4.8i almost caught fire. The fuel pump connector is burnt into the fuel pump harness. My local mechanic said this was like a ticking time bomb. The issue is these trucks are known for this problem and there was a recall for this but my vin coming up with no recalls when this truck is clearly apart of the bad batch , I have pictures for proof.

X5 was off, parked and the engine compartment burst into flames. Car was totaled There was apparently a recall issues in 2022 in which I was unaware and had no direct contact from the BMW dealer I purchased it from. The recall states that in some vehicles, this part could cause a fire. Well, I had a fire and there was zero indication of anything wrong with the car.

Fire

X5 was off, parked and the engine compartment burst into flames. Car was totaled There was apparently a recall issues in 2022 in which I was unaware and had no direct contact from the BMW dealer I purchased it from. The recall states that in some vehicles, this part could cause a fire. Well, I had a fire and there was zero indication of anything wrong with the car.

Fire

My 2008 BMW X5 was taken to a shop to be diagnosed due to Diagnosis as followed:( low coolant light coming on) “coolant crossover pipe from timing belt cover leaking” it is available for inspection, although it is not safe to drive. The low coolant light went off after I put more in it and did not come back on. Me and my then 10 month old were picking my 14 year old up from school and I noticed smoke pouring out of the hood. There was no warning lights or anything. Then the air conditioner started to blow smoke out as well. I cut the car off and it continued to smoke for approximately an hour. The car was about to catch on fire with no warning lights and the hazardous smoke out of the vents. The problem was diagnosed by Dan’s Auto Center. I can not move my car because it will smoke at the engine and cause a fire risk. The low coolant sensor came on a few days after purchased. I took it to get it diagnosed and the cost from that place quoted approximately 3,000 dollars. I put coolant in it and did not drive it for awhile. The sensor went off and the coolant was still full. There were no signs, no sensor, no overheating, just all the sudden huge clouds of smoke coming from my hood of the car. BMW has a lot of recalls for this same situation, but my car (year) is not listed.I do not understand this. Please add my car to the list, this is a 2000 to 3000 job and I have to get my car towed to a place if I ever can. Can I take this to a BMW Place and ask them to fix due to other recalls? This was very scary for me and my children. “The EGR cooler may leak internally, causing coolant to mix with diesel engine soot, which could result in smoldering particles, a melting intake manifold, and potentially fire,”according to BMW.

I've been experiencing drive train problems with my vehicle and upon research I've concluded that not just only me but many people with the same vehicle as mine have been having transfer case/driveshaft/differential problems and the scary part is that no codes pop up for this issue!! I've already took it to many shops I've even took it to an official BMW dealership and they don't seem to help but the real reason I'm reaching out is because I nearly had a near death experience related to this issue on the freeway.. the vehicle seemed to shake violently and felt like it wanted to seize up while driving and had to do an emergency pull over but once again it doesn't throw no codes and not only that I've already spent thousand of dollars into this car for it to react like that while driving! Please 🙏🏻 hear me out and help me resolve this as soon as possible.. thank you [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2008 BMW X5. The contact stated while driving at various speeds, she noticed an abnormally strong burning plastic odor inside the vehicle. There was no warning light illuminated. The contact was able to drive to the residence. The contact stated that she had stopped driving the vehicle. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling); however, the parts to do the recall repair were not yet available. An unknown local dealer was contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 167,964. Parts distribution disconnect.

The contact owns a 2008 BMW X5. The contact received notification of the NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that she started to notice a burning odor throughout the vehicle. No warning lights were illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer however, the contact was informed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 115,000.

Open recall since March of 2022, no remedy yet still available

On 12/10/2022 I was driving to work and my BMW started smelling of like electrical fire. I pulled over on a exit in Sweetwater, TN and upon exiting the vehicle I noticed flames under the hood of the car. The car was on fire somewhere in the engine. A passerbuyer stopped and called 911 for me Christianburg, TN fire Dept. done the report. But BMW has a recall on this vehicle for over 1yr with no remedy to fix knowing the car can catch on fire. Luckily I was not injured but I suffered a total loss from my vehicle. Engine and engine cooling: exhaust system: emission control: crankcase (pcv) NHTSA CAMPAIGN ID: 22V119000 Report Date: Mar 02, 2022 Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked. What You Should Do: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417. Summary: BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X

Fire

On 12/10/2022 I was driving to work and my BMW started smelling of like electrical fire. I pulled over on a exit in Sweetwater, TN and upon exiting the vehicle I noticed flames under the hood of the car. The car was on fire somewhere in the engine. A passerbuyer stopped and called 911 for me Christianburg, TN fire Dept. done the report. But BMW has a recall on this vehicle for over 1yr with no remedy to fix knowing the car can catch on fire. Luckily I was not injured but I suffered a total loss from my vehicle. Engine and engine cooling: exhaust system: emission control: crankcase (pcv) NHTSA CAMPAIGN ID: 22V119000 Report Date: Mar 02, 2022 Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked. What You Should Do: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417. Summary: BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X

Fire

when cold car will hesitate to start.

The contact owns a 2008 BMW X5. The contact stated that while driving at approximately 65 MPH, there was a plastic smell while the heater was in use. The check engine warning light was illuminated. The vehicle was then taken to an independent mechanic where the failure could not be duplicated. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 152,000. VIN tool confirms parts not available.

This car is not safe to drive, when you accelerate lots of black smoke come from tail pipe and loose power at the same time, Its burning through spark plugs Im having to change them at least every 2 wks plugs cost 15$ a piece, Its burning through oil oil leaks popping up random all over every 2 weeks its burning through 5 quarts of oil ,oil is 18$ a quart, Do to the lose of power i have to take the access roads to and from work. Its causing me to miss a lot of work Im afraid for my wife and kids to be in the car with me its just not safe we got the letter from BMW 2 months ago about the recall what is considered a timely manner because 2 months is a ling time we need this resolved asap bmw just giving us the run arounds verses solving this issue. This car has been riding this unsafe way for at least 6 months and its getting worst by the day, its costing us to much money plus lose of work

PCV MY safety of my self and my 5 yr 17 yr I use my BMW X5 to take my kids or doctors and school and I work too and something need to be happen about this bc My family are AT RISK OF GETTING CAUGHT ON FIRE when iam starting up the car black smoke or white smoke comes out and when iam driving and people who are behind in they car get smoke out my lots of smoke that comes from my car in back and yes ita a RECALL on my car Manufactuer NO warning just smoke and driving very and had it look at then i was told

The contact owns a 2008 BMW X5. The contact stated while pulling into a parking space, he saw smoke coming through the vents. There was no warning light illuminated. The contact then parked and opened the hood but could not find any issues. The contact was able to continue driving however, the failure recurred while driving. The contact stated while driving the vehicle stalled. The check engine warning light was illuminated. The contact veered to the side of the road. The contact was unable to restart the vehicle after several attempts. The vehicle was towed to the residence. The vehicle was then towed to the dealer where it was diagnosed that the valve cover gasket needed to be replaced and the failure was associated to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 107,000. VIN tool confirms parts not available.

The contact owns a 2008 BMW X5. The contact stated while driving at various speeds, she smelled a strong burning plastic odor coming through the A/C vents. There was no warning light illuminated. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer who informed the contact that she would be responsible for the cost of the diagnostic test. The vehicle was not diagnosed or repaired. Additionally, the contact stated while driving 15 MPH, the engine emitted abnormal loud knocking sounds and the vehicle started shuddering. The check engine warning light illuminated. The contact drove to her residence and turned the vehicle off. Upon restarting the vehicle, the vehicle stalled. Additionally, the contact stated that oil was leaking from the vehicle onto the ground. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 75,000. VIN tool confirms parts not available. Consumer did reach out to BMW USA and they took the information and have asked the consumer to wait a week while they do their investigation. Consumer has reached out several times now since then and they have stated that there is nothing they can do at the moment. They say that it should be okay to drive the car until they are able to fix it. The car is not safe to drive and when turned on is very shaky, the engine is loud and gives off strong gas fumes.

The contact owns a 2008 BMW X5. The contact stated while driving at various speeds, between 5-70 MPH, she smelled a plastic burning odor. The contact saw smoke coming out from underneath the hood. The check engine warning light illuminated. The contact veered to the side of the road for thirty minutes. The contact then continued to drive. The vehicle was taken to an independent mechanic who informed the contact that oil may have dropped in the engine compartment during an oil replacement, which led to the failure. The vehicle was not repaired. The contact stated that the failure reoccurred several times while driving. The vehicle was taken back to the independent mechanic who informed the contact that they could not replicate the failure. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine And Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 175,000. VIN tool confirms parts not available.

Fire

The contact owns a 2008 BMW X5. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

this vehicle is dangerous and I cannot drive it without it smoking and overheating, exhaust or fumes get inside the vehicle not safe for my family, I bought it last year and have had problems since and I cant get it fixed. I tried to call the BMW office last year to no avail and no returned calls, I constantly had to fill coolant when driving and afraid to drive no more because smoke from engine and smell of smoke is frightening while on the road. can't drive this vehicle anymore

while driving in a highway far from any measure city, the car start slowing down and overheating signal showed up. fan start running like a jet engine. after towing it to a mechanic. it turns out the water pump failed a long with thermostat and the plastic resurve water leaked. it seams like a design fault to make a plastic resurve water that hold hot water. the car had 121000 mile. coast was $5400

oil leaked from the engine dripping over auxaust and casing fume to inter the capen. mechanick indicate the engine cover is made out of plastic and it warped and cause the oil to leak.

car will not start. towed over 120mil to the closest mechanics. starter was dead.

ear conditioning will not work while driving in the desert.

suspension warning came up. air suspension bags. and air pump fail while driving at 65m/h. car was hard to control. I had to slow down to 40m/h. to drive safely.

No warnings just went dead in traffic had it towed to a mechanic and his diagnosis is fuel pump is bad. A B160416 fuel pump was a recall and replaced thru BMW Chattanooga, TN on 12/08/18.

Car engine stalled. Needed to be jumped. The battery was brand new, was changed a few days ago.

The contact owns a 2008 BMW X5. The contact stated that the vehicle was taken to the dealer for the driver’s air bag replacement and the fuel pump replacement recall; however, after the recall repairs, the vehicle stalled inadvertently while driving. The vehicle was taken to the dealer who replaced the fuel pump twice. The contact stated that the failure recurred while at the stop light in the middle lane of a road. The contact was able to move the vehicle to the side of the road with the assistance of the police patrol. The vehicle was towed to the contact's residence. The contact stated that he was able to restart the vehicle the next day; however, the failure recurred while driving. The vehicle was towed to the dealer who installed a fuel pump relay switch; however, the failure persisted. The vehicle was towed to an independent mechanic who took the vehicle apart and diagnosed that the fuel pump needed to be replaced. The contact advised the dealer to forward the fuel pump for replacement; however, the dealer denied and advised the contact that he had to pay for the part if the repair was not completed at the dealer. The manufacturer was notified of the failure. The vehicle was repaired. The failure mileage was approximately 85,000.

I don't know 😕