SEATS
BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
Remedy: BLUE BIRD WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 18, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.
37,095 vehicles affected
ELECTRICAL SYSTEM:IGNITION
BLUE BIRD IS RECALLING 2,203 MODEL YEAR 2003 THROUGH 2010 ALL AMERICAN REAR ENGINE SCHOOL BUSES EQUIPPED WITH OPTIONAL PLUG STYLE VANDAL LOCKS MANUFACTURED FROM JULY 16, 2003 THROUGH APRIL 10, 2009. THE PLUG STYLE VANDAL LOCK IS NOT WIRED TO INHIBIT THE STARTER AT THE IGNITION SWITCH WHEN THE VANDAL LOCK IS IN THE LOCKED POSITION. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."
Remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 25, 2009. OWNER MAY CONTACT BLUE BIRD AT 1-478-422-2242.
2,203 vehicles affected
STRUCTURE:BODY:ROOF AND PILLARS
BLUE BIRD IS RECALLING 23,464 MY 2005 THROUGH 2009 ALL AMERICAN AND VISION SCHOOL AND TRANSIT MODEL BUSES MANUFACTURED FROM JANUARY 22, 2004, AND MARCH 28, 2008, AND MY 2004 THROUGH 2007 ALL AMERICAN SCHOOL BUSES AND CONVENTIONAL MODEL SCHOOL BUSES MANUFACTURED FROM MARCH 6, 2003, THROUGH JUNE 16, 2006. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP. WITHOUT THE APPROPRIATE AMOUNT OF ROOF RIVETS, THE BUSES FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, "JOINT STRENGTH."
Remedy: BLUE BIRD WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES BY ADDING ADDITIONAL RIVETS. THE RECALL BEGAN ON SEPTEMBER 18, 2008. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
23,464 vehicles affected
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
BLUE BIRD IS RECALLING 607 MY 2004-2007 ALL AMERICAN REAR ENGINE SCHOOL BUSES AND MY 2006-2007 XCEL 102 COMMERCIAL SERIES TRANSIT BUSES EQUIPPED WITH CUMMINS ISC ENGINES. THE HIGH PRESSURE FUEL LINE MAY CRACK, ALLOWING HIGH PRESSURE DIESEL FUEL INTO THE ENGINE COMPARTMENT.
Remedy: OWNERS WILL BE ADVISED TO CONTACT THEIR CUMMINS DEALERS TO HAVE THE REPAIR WORK PERFORMED AS SOON AS POSSIBLE. THE RECALL BEGAN ON FEBRUARY 28, 2008. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.
607 vehicles affected
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.
Remedy: BLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
5,863 vehicles affected
OTHER:SCHOOL BUS STOP ARM ASSEMBLY
CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
8,894 vehicles affected
OTHER:SCHOOL BUS STOP ARM ASSEMBLY
CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
Remedy: BLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
3,121 vehicles affected
VEHICLE SPEED CONTROL
CERTAIN 2001 THROUGH 2005 ALL AMERICAN, COMMERCIAL SERIES, AND Q-BUS SCHOOL AND TRANSIT BUSES EQUIPPED WITH JOHN DEERE 8.1 CNG ENGINES. THE SUBJECT BUSES EQUIPPED WITH THE JOHN DEERE ENGINES MAY SURGE INAPPROPRIATELY DUE TO ERRACTIC OPERATION OF THE AIR THROTTLE IF THE ENGINE IS TAKEN FROM FULL TO ZERO LOAD.
Remedy: JOHN DEERE WILL NOTIFY BLUE BIRD'S CUSTOMERS AND REPAIR THE ENGINES FREE OF CHARGE. CUSTOMERS ARE BEING INSTRUCTED TO CONTACT JOHN DEERE AT 1-800-JD-ENGINE.
486 vehicles affected
ENGINE AND ENGINE COOLING
CERTAIN 2002-2006 MY BLUE BIRD ALL AMERICAN SCHOOL AND TRANSIT BUSES, CONVENTIONAL SCHOOL BUSES, AND COMMERCIAL SERIES TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 21, 2002, AND FEBRUARY 24, 2005. THESE BUSES ARE EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005. THE STAINLESS STEEL BURNER TUBE IS MADE OUT OF A MATERIAL THAT IS NOT TO SPECIFICATION AND COULD FAIL PREMATURELY.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE BURNER TUBES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
416 vehicles affected
EQUIPMENT ADAPTIVE/MOBILITY
CERTAIN BLUE BIRD 1999-2005 ALL AMERICAN, TC/2000, MICRO BIRD, VISION, CONVENTIONAL, AND COMMERCIAL SERIES SCHOOL BUSES EQUIPPED WITH SURE-LOC WHEELCHAIR SECUREMENT SYSTEMS AND MANUFACTURED BETWEEN FEBRUARY 17, 1999, AND AUGUST 13, 2004. CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN SEPTEMBER 21, 2004. OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT BLUE BIRD AT 478-822-2242.
372 vehicles affected
STRUCTURE:BODY:ROOF AND PILLARS
CERTAIN MY 2005 BLUE BIRD ALL AMERICAN MODEL SCHOOL BUSES MANUFACTURED FROM MAY 24 THROUGH JULY 12, 2004. THESE BUSES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, SCHOOL BUS BODY JOINT STRENGTH. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND PROVIDE INSTRUCTIONS AND PARTS TO ADD ADDITIONAL RIVETS AS NEEDED. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
233 vehicles affected
SEAT BELTS
SCHOOL AND TRANSIT BUSES EQUIPPED WITH DRIVER'S 3-POINT SEAT BELTS WITH INCORRECT FASTENERS.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS TO MAKE AN APPOINTMENT WITH THEIR BLUE BIRD DISTRIBUTOR TO HAVE THE DRIVER'S 3-POINT SEAT BELT UPPER ATTACHING FASTENERS REPLACED FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 8, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
291 vehicles affected
STRUCTURE
ALL AMERICAN SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 10 AND APRIL 20, 2004, WHICH THE INSIDE PANELS ADJACENT TO THE REAR CENTER EMERGENCY DOOR (OR REAR CENTER EMERGENCY WINDOW ON REAR ENGINE MODELS) DO NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. ADHESIVE WAS INADVERTENTLT OMITTED FROM THESE JOINTS ON THE AFFECTED POPULATION.
Remedy: OWNERS WILL BE NOTIFIED TO MAKE AN APPOINTMENT WITH THEIR BLUE BIRD DISTRIBUTOR TO HAVE THE INSIDE REAR PANELS REMOVED AND PROPERLY ADHERE THE PANELS. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 9, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
297 vehicles affected