2025 TOYOTA TUNDRA Recalls, Complaints & Safety

I own a 2025 Toyota Tundra SR5 non-hybrid. The vehicle has transmission hesitation/delayed throttle response after a rolling stop. When I slow down but do not come to a complete stop, then press the accelerator again, the truck sometimes has a 1–2 second delay before it responds and begins moving/accelerating. After the delay, acceleration can come in suddenly, which makes the vehicle feel unpredictable and dangerous. This happens in normal driving situations such as rolling through turns, slowing for traffic, approaching intersections, or merging into traffic. The delay creates a potential safety concern because the vehicle does not respond immediately when throttle input is applied, which could increase the risk of being hit by cross traffic or not being able to accelerate as expected. I had two close calls so far where the vehicle wouldn't accelerate through a cross traffic intersection. The issue is intermittent but repeatable and has occurred at least a dozen times over my one year ownership (purchased brand-new in March 2025). There are no warning lights present on the dash. The issues started to be apparent almost immediately and has been continuing. During a 5k mile service visit at Bobby Rahal Toyota in Mechanicsburg, PA, I explained my concern to a service advisor, and they advised me that Toyota is aware of this problem but there is not fix for it. This was approximately 6 months ago. As of today, March 30, there is still no fix for this issues that I am aware of.

The same thing that I reported in incident number XXX happened again recently. From a stop. I went to make a right turn on Red in a four way intersection. The oncoming traffic to my left was also stopped. When I started to proceed the truck felt like it was in like 5th gear, moving barely but no real power, then it dropped into what felt like 1st gear and lurched me forward. I almost hit a car to my right that was stopped and traveling West bound and the power loss also was concerning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This is a leased vehicle through Enterprise. We have had a recall on the reverse lamps since 7-17-2025. Every time our driver take the vehicle in for service they say the parts haven't arrived or they cant get them to replace. There was no wreck or damage to the vehicle its just a simple recall we are trying to get fixed.

I own a 2025 Toyota Tundra 1794 with the 3.4L twin-turbo engine. The engine failed at approximately 53,000 miles while I was driving on the freeway in Houston, Texas. I was traveling at highway speed when the engine suddenly lost power and the truck became unsafe to continue driving. I had to pull over to the shoulder of the freeway with traffic moving at high speed. My [XXX] daughter was in the vehicle with me at the time. The sudden loss of engine power at highway speed created a serious safety hazard because it left the vehicle disabled in active freeway traffic. The vehicle had been properly maintained with regular oil changes and normal driving conditions. After the failure the truck had to be towed to the Toyota dealership, which I had to pay for out of pocket. The dealership performed an engine teardown that took about one week. They informed me that the engine block and most internal components that come into contact with oil will need to be replaced. The dealership told me the failure is not currently related to the existing Toyota Tundra engine recall. The truck is currently at the dealership and they estimate approximately 30 days to complete the repair. The dealer also informed me they have multiple Toyota Tundra trucks waiting for engine repairs and that no truck loaner vehicles were available. My understanding is that a Toyota case number has been opened for this failure and that the diagnostic details are recorded in that report. I am concerned that sudden engine failures at highway speed represent a serious safety risk INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Tundra Truck is having throttle lag. I pull out into traffic and there is no power. I put the throttle all the way to the floor and still nothing. After 2 to 3 seconds the engine starts to slowly throttling up, but very slow and no turbo. This has happened at least 15 times now since I owed it in July of 2025. That scared me so bad I now have it at the dealer for diagnostics. They had better fix it, I almost got into a wreck.

Bad factory alignment caused OEM tires (Falken Wildpeak A/T, 265/60 R20) to wear prematurely. Tread depth reduced to 3/32 on all 4 tires at 10,500 miles. Clearly a safety risk as no reasonable person would expect new tires to last only 10,000 miles and; therefore, likely not check tread depth presenting significant safety risk in any inclement weather.

The contact owned a 2025 Toyota Tundra. The contact stated that while driving at approximately 60 MPH, there was an object in the road that he attempted to swerve around; however, the lane-keeping assist feature independently activated, causing the vehicle to jerk off the road, down the median, and crash into a ditch. The vehicle was not drivable. No warning lights were illuminated. The air bags were deployed. The contact could not recall if the vehicle was towed or not. The contact stated that his head crashed into the door frame and knocked him unconscious; the contact stated that when he woke up, he was in an ambulance on its way to the hospital. The contact discovered at the hospital that he had five broken ribs and bruises spread all over his body. Medical treatment was needed, and the contact was in the hospital for a few days. A police report was filed. The manufacturer was notified of the failure. The failure mileage was approximately 5800.

Crash 5 injured

The tailgate will not go down when you push the bottom that is on the tail light or when you push the button inside the truck it will not go down. It makes the noise like if it is going to but gets stuck.

All four tires are wearing unevenly. The outside of the tires are worn down much more than the middle and inside edge of tires. I noticed this six months ago, have called Toyota and brought the truck to the dealership and they stated there is no issue. I had the exact same Make/Model/Trim (3rd Generation Tundra TRD Pro) from 2022, and the tires wore out in the exact same manner. A safety recall was issued for this and all four tires were replaced and the alignment was adjusted to a "new standard" because it was determined that on this trim level, the original factory alignment was incorrect. This issue still hasn't been resolved as it is happening the exact same on the 2025 as it did on previous model years of the same trim. Toyota and dealership both refuse to even consider that this may be the same issue requiring a recall and replacement of tires and proper alignment. An internet search and an NHTSA search on this issue shows multiple instances of this complaint and nothing has been done to rectify.

The contact owns a 2025 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 26V038000 (BACK OVER PREVENTION). The contact stated that when the doors were locked, the side mirrors failed to fold inwards as intended. In addition, there was an abnormal grinding sound coming from the driver's side mirror. The contact stated that on a separate occasion, the driver's side mirror was stuck halfway. The contact stated that the driver’s side mirror then responded as intended. There was no warning light illuminated. The manufacturer was not notified of the failure. The failure mileage was approximately 5,500.

The contact owns a 2025 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the steering wheel was slightly locked while making a left or right turn. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure. The vehicle was scheduled for a diagnostic test in the upcoming days. The manufacturer was not made aware of the failure. The failure mileage was approximately 4,605.

Car is at dealer on stop sale. Toyota has not resolved since placing deposit on vehicle September 17, 2025.

Stall or hesitant acceleration which has caused many unsafe situations for me and my family. This happens frequently since the vehicle was purchased new.

Alignment issues from the factory that Toyota refuses to rectify.

Vehicle stalls after stopping often

Laggy throttle response, always a significant delay. This is dangerous, especially during heavy traffic situations. Drivers seat constantly pops and cracks under acceleration or braking.

Complete engine failure on 2025 Tundra. Left me stranded on the side of the highway.

This is a known issue on previous year vehicles. Gas pedal response is delayed excessively causing scenarios where one could become injured if attempting to pull out from a full stop or rolling stop expecting the vehicle to move and it doesn’t. Reference Toyota TSB-0111-22 for vehicle hesitation while accelerating. Brought my vehicle into a Toyota dealer in Scranton PA on 12/16/2025 with this info and they were unable to duplicate the issue along with stating that TSB does not apply to this year vehicle. Look online there are tons of forums stating this issue is still present in the newer year models like mine which is a 2025. This is a serious problem as it’s happened at random with no clear reasoning other than potential programming issue between the transmission and gas pedal coding.

Vehicle: 2025 Toyota Tundra Component/System: Powertrain / Electronic Throttle Control / Transmission Response Complaint Description: I am reporting a serious safety defect involving delayed and inconsistent acceleration from a stop or low speed. What failed or malfunctioned: The vehicle exhibits a significant delay in throttle response. The electronic throttle and/or transmission fails to deliver engine power when the accelerator is pressed. The vehicle is available for inspection upon request. Safety risk: This failure creates a hazardous condition when entering intersections, turning across traffic, or merging. On multiple occasions, the truck failed to accelerate when commanded. In one incident, I pressed the accelerator approximately 75% and the vehicle did not respond for 2–3 seconds, nearly resulting in a collision. Reproduction/confirmation: The issue has occurred multiple times under normal driving conditions from a stop or slow roll. It is intermittent and unpredictable. Inspections: At this time, the issue has not yet been resolved and has not been successfully corrected. (Inspection pending / not yet corrected.) Warning indicators: No warning lights, messages, or fault indicators were present before or during the failure. The hesitation occurs without any dashboard alerts. Additional details: The delay is not typical turbo lag or minor hesitation — it is a complete loss of commanded acceleration for several seconds, followed by sudden engagement. This condition makes the vehicle unsafe to operate in traffic.

After dinner at a restaurant I went to pull out from the parking lot onto a road with a 40 mph speed limit. When I pressed the accelerator to turn, my truck felt like it was in a high gear and just barely moved forward. I let off the gas pedal and pressed again and the same thing. At this point I am drifting into on coming traffic without power. I hit the brake, moved to park, moved the setting to SPORT and then moved back into drive and only then was able to operated the vehicle properly and safely. Fortunately the person on the road did stop and did not hit me, but this is a VERY DANGEROUS situation and something is clearly not working properly.

Throttle response lag then sudden surge. Occurs occasionally not constant. Press on accelerator and no response, the next it’s wanting to take off. In stop and go traffic, the lag may not let vehicle get up to speed like merging, then with the surge, could accelerate too quickly reducing reaction time and cause an accident.

Ive been noticing a significant lag sometimes when I press the gas pedal. It last just a couple seconds. This could possibly become something bigger. Will update of it gets worse. Also the cruise control doesn't hold the set speed it stays 1 or 2 miles under.

Throttle lag When I accelerate from a stop, such as at a red light or stop sign, after I gently press down on the gas pedal, there is consistently a 1-2 second delay before the truck accelerates. This can cause potential delays in getting through an intersection, in turning in front of oncoming traffic, and getting going in traffic. This happens consistently since I’ve owned the vehicle since the summer of 2025.

Ive been noticing a significant lag sometimes when I press the gas pedal. It last just a couple seconds. This could possibly become something bigger. Will update of it gets worse. Also the cruise control doesn't hold the set speed it stays 1 or 2 miles under.

The gas pedal has no response when coming to a stop and pushing on the gas pedal. Multiple times I come to a stop, push the gas, no response, 1-3 seconds later; the vehicle jerks forward. On occasion it has nearly lead to an accident and I do not feel safe in my vehicle.

When accelerating from a standstill, the car hesitates for 1 to 2 seconds after I press the accelerator pedal. This is a safety concern, especially when merging onto the highway (we have stoplight-controlled merge lanes where I live), where accelerating the vehicle is essential to a safe merge into traffic going 65+ mph. There have been no warning lamps.

Continue getting a 1-2 second delay when accelerating from a dead stop after pushing on gas pedal with normal acceleration- not just an “lead foot” acceleration trying to quickly clear my intersection & merge into traffic. Happens when engine is at normal operating system or just pulling out of my neighborhood onto a 45mph road on a normal temp day.

Throttle lag When I accelerate from a stop, such as at a red light or stop sign, after I gently press down on the gas pedal, there is consistently a 1-2 second delay before the truck accelerates. This can cause potential delays in getting through an intersection, in turning in front of oncoming traffic, and getting going in traffic. This happens consistently since I’ve owned the vehicle since the summer of 2025.

When accelerating from a standstill, the car hesitates for 1 to 2 seconds after I press the accelerator pedal. This is a safety concern, especially when merging onto the highway (we have stoplight-controlled merge lanes where I live), where accelerating the vehicle is essential to a safe merge into traffic going 65+ mph. There have been no warning lamps.

There’s a delay in throttle response. Especially when making a turn across traffic. Throttle would not respond for at least 1 to 2 seconds. Even at full throttle the truck did not respond while cars were coming towards me. This has happened to several tundra owners. Check Facebook tundra group and you’ll find others with same issue.

When accelerating from a standstill, the car hesitates for 1 to 2 seconds after I press the accelerator pedal. This is a safety concern, especially when merging onto the highway (we have stoplight-controlled merge lanes where I live), where accelerating the vehicle is essential to a safe merge into traffic going 65+ mph. There have been no warning lamps.

Unknown. The truck often lags when the accelerator is pressed. Coming from a stop seems to make it worse. It takes 1-2 seconds more than you would expect as normal for the truck to start to move. This gives you enough time to think something is wrong and cover the brake to prevent you from entering an intersection if there is a problem. The result is that you end up halfway into an intersection slower than you expected, possibly causing an accident. It seems like a combination of electronic throttle control lag, and the 10 speed transmission never knowing what gear to select causes the issue.

Advanced driving system - Truck with leave a lane unprovoked and will fight you to recover manually. I have another Toyota with the same system (2024 Grand Highlander) and it works perfect. Not confirmed by dealer yet. It will be next week. Not inspected yet. Automatic lane centering just stops working, display changes to "not tracking'. Blue lines disappear on display. Truck has done this since new. I was very disappointed when I first used it since I expected it to work like our Highlander.

Unknown. The truck often lags when the accelerator is pressed. Coming from a stop seems to make it worse. It takes 1-2 seconds more than you would expect as normal for the truck to start to move. This gives you enough time to think something is wrong and cover the brake to prevent you from entering an intersection if there is a problem. The result is that you end up halfway into an intersection slower than you expected, possibly causing an accident. It seems like a combination of electronic throttle control lag, and the 10 speed transmission never knowing what gear to select causes the issue.

Advanced driving system - Truck with leave a lane unprovoked and will fight you to recover manually. I have another Toyota with the same system (2024 Grand Highlander) and it works perfect. Not confirmed by dealer yet. It will be next week. Not inspected yet. Automatic lane centering just stops working, display changes to "not tracking'. Blue lines disappear on display. Truck has done this since new. I was very disappointed when I first used it since I expected it to work like our Highlander.

Bad hesitation when first depressing the throttle. I drive the truck in the Sport + mode and it does help.

Advanced driving system - Truck with leave a lane unprovoked and will fight you to recover manually. I have another Toyota with the same system (2024 Grand Highlander) and it works perfect. Not confirmed by dealer yet. It will be next week. Not inspected yet. Automatic lane centering just stops working, display changes to "not tracking'. Blue lines disappear on display. Truck has done this since new. I was very disappointed when I first used it since I expected it to work like our Highlander.

When pulling out on the highway I have lag in the powertrain

While trying to quickly accelerate there is a very noticeable lag between accelerator pedal and vehicle response. I would say ~250-500ms, which in certain situations is extremely dangerous.

All four tires on my 2025 Toyota Tundra experienced severe and abnormal outside edge wear at approximately 13,000 miles. The vehicle was purchased new and maintained according to manufacturer recommendations, including tire rotations every 5,000 miles at authorized Toyota dealerships. An authorized Toyota dealership inspected the vehicle, documented the abnormal tire wear, and performed alignment measurements. The dealership issued a written recommendation stating that a four-wheel alignment was needed to extend tire life and/or correct drivability concerns. Alignment measurements showed values outside specification. The tire manufacturer reviewed photos and documentation and confirmed the wear pattern is caused by vehicle alignment and not a tire manufacturing defect. The condition affected all four tires and required premature replacement, creating a potential safety concern due to reduced tread depth and handling stability. The issue appears to be related to steering or suspension geometry rather than normal tire wear.