2001 TOYOTA TUNDRA

5 recalls, 542 complaints - 140 TSBs

STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Defect Description

TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND,... Read more

Consequence

SEPARATION OF THE SPARE TIRE AND DIMINISHED BRAKE CAPACITY COULD INCREASE THE RISK OF A CRASH.

Remedy

TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPL... Read more

110,000 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIAT... Read more

Consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy

AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

3,593 vehicles affected

Manufacturer: AJ MOTORSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

WHEELS

Defect Description

ON CERTAIN 4X2 VEHICLES EQUIPPED WITH AN ALLOY WHEEL TIRE UPGRADE (OPTIONS WM4, WM8, ZL1-ZL4, DH4, OR DH5) INSTALLED BY THE PROCESSING CENTERS IN JACKSONVILLE, FLORIDA OR COMMERCE, GEORGIA, A LABEL IDENTIFYING THE SPARE TIRE AS A TEMPORARY USE SPARE TIRE WAS NOT INSTALLED. THE UPGRADE INCLUDES 4 LA... Read more

Consequence

DIFFERENT OPERATING CHARACTERISTICS CAN BE EXPERIENCED WHEN THE SPARE TIRE IS INSTALLED ON THE VEHICLE.

Remedy

OWNERS WILL BE PROVIDED WITH A CAUTION LABEL AND AN INSERT FOR THEIR OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

3,041 vehicles affected

Manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS

Complaint Statistics

542 total complaints 37 crashes 4 fires 41 injuries 2 deaths

Top Reported Components

Component	Complaints
STRUCTURE:FRAME AND MEMBERS	81
STRUCTURE:BODY	46
SUSPENSION	44
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	33
SERVICE BRAKES, HYDRAULIC	30
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS	28
STEERING	24
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	17
POWER TRAIN:AUTOMATIC TRANSMISSION	15
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT	14

Incident date: Mar 14, 2025

Vehicle: 2024 Ford Bronco Outer Banks Mileage: Approx. 15,000 The molded-in-color (MIC) composite hardtop panels have developed significant cracking across all four removable roof sections. Cracks are present on the driver-side front, mid, rear, and passenger-side panels. The cracking appears to ori... Read more

Incident date: Mar 14, 2025

The contact owns a 2015 Kia Optima. The contact stated that while driving at 40 MPH, there was smoke coming from underneath the hood, and the engine overheated. The check engine warning light was illuminated. The contact was able to pull over to the side of the road and add coolant to the coolant re... Read more

Incident date: Mar 14, 2025

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that while driving at slower speeds, the vehicle hesitated to accelerate while the accelerator pedal was depressed. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a valve bo... Read more

Incident date: Sep 30, 2025

The grommet that goes into the plastic oil pan failed and came out with the oil plug.

Incident date: Sep 30, 2025

The K5 - as soon as I began driving it at 0 miles, I noticed it shifted at lower speeds extremely hard. Head-jerking hard during the first drive of each day at speeds below 25mph. Once the vehicle warmed up, the problem would go away and wouldn't appear until the next day - after the vehicle cooled ... Read more

1 injured

Incident date: Sep 30, 2025

Front Windshield wipers randomly go on causing a distraction almost resulting in a accident. The vehicle was taken in for this problem to Colonial VW located at 200 W Street RD, Feasterville PA 19053. Service rep stated he knows of the issue but there is currently no fix for it. This problem fir... Read more

Incident date: Apr 25, 2025

The contact owns a 2019 Mercedes-Benz C300. The contact stated that while at a stoplight, there was an abnormal odor of fuel inside the vehicle. The contact stated that the vehicle failed to respond as needed. The vehicle was restarted and shut off independently. The check engine warning light was i... Read more

Incident date: Jan 28, 2025

Passenger sliding door jammed and would not open! Serious safety hazard as passengers unable to rapidly exit in an emergency!

Incident date: Jul 17, 2024

Paint The paint issue with hyundai is ridiculous. I have a 2016 Hyundai sonata. No matter if i’m driving, going through a car wash, or just sitting in the yard. It’s absolutely ridiculous. Corporate and a lawyer has been contacted and the said there wasn’t anything they could do. There is tho... Read more

Incident date: Apr 3, 2024

12-11-23 Vehicle was not accelerating when pressing gas pedal then began violently shaking and shut off in middle of roadway.

Incident date: Dec 31, 2023

Driving normal then suddenly power loss, jeep went into acceleration then loss of power, the ETC , traction control, and check engine lights came on, got a uo4o1 code, I was on the interstate with my son in the car. We were lucky to exit before horrible consequences. The electronic throttle control... Read more

Incident date: Nov 1, 2023

The contact owns a 2015 Hyundai Accent. The contact stated that after parking the vehicle in the garage, approximately four hours later the contact was awakened by the dog and discovered flames coming from the garage. The fire department was called to the home and extinguished the flames. During the... Read more

Fire 1 injured

Incident date: Sep 7, 2023

I WAS TRAVELING 55 MPH IN 5TH GEAR WHEN MY MOTORCYCLE SUDDENLY STOPPED ACCELERATING, AND THE CHECK-ENGINE LIGHT CAME ON. THE VEHICLE AUTOMATICALLY WENT INTO LIMP-MODE AND WOULD NOT TRAVEL ANY FASTER THAN 25 MPH. I WAS NEAR A SERVICE STATION, SO I PULLED OVER AND STOPPED. I WAS ABLE TO RETURN HOME... Read more

Incident date: Sep 3, 2023

ABS, brake light on dashboard. Malfunctioning ABS solenoid valve. Brakes locking up.

Incident date: Aug 5, 2023

Steering binds. You feel resistance to turning the wheel in either direction before it steers when added force is put on the steering wheel.

Incident date: Jul 1, 2023

I would like to report a safety issue with my wife’s new 2023 VW Jetta sedan with standard transmission. It has a hill hold feature that clamps the brakes on for approximately three seconds after you remove your foot from the brake pedal, if you are on a hill. Three seconds is way too long and oft... Read more

Incident date: Oct 20, 2022

The contact owns a 2013 Ford Explorer. The contact stated that while his wife was driving 20 MPH, the power steering seized. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The... Read more

Incident date: Oct 20, 2022

Brakes started grinding at 13,000 miles. Determined they were metal to metal, caliper, overheated, excessively, and rotor needed replaced. Problem happened again now, at 22,000 miles.

Incident date: Oct 21, 2022

The contact owns a 2001 Toyota Tundra. The contact stated that upon taking the vehicle to an independent mechanic for servicing, he was informed that the chassis was severely corroded. The independent mechanic diagnosed that the undercarriage needed to be replaced and referred the contact to the NHT... Read more

Incident date: Oct 21, 2022

Incident date: May 28, 2022

Lower ball joints(right and left hand sides) very serious safety concern. this is my family vehicle and has been with the family since 2005-06. members from the tundra forums are concerned about this issue with toyota tundras. yes toyota has a recall for their 02-06 tundras and tacomas and sequioas ... Read more

Incident date: Nov 15, 2021

My frame is broke . Right at the passenger front tire

Incident date: Nov 8, 2018

The contact owns a 2001 Toyota Tundra. The contact stated that the sub frame of the vehicle was severely corroded. The dealer was notified of the failure and advised the contact that they could not repair the vehicle. The manufacturer was notified of the failure and did not provide any assistance. T... Read more

Incident date: Aug 3, 2021

2001 Tundra (4.7 Engine); frame badly rusted in rear. Told on Aug. 3, 2021 that it would fail the next inspection. I put my VIRIN into the NHTSA site but couldn't find any recalls.

Incident date: Jun 20, 2021

RECENTLY MY MECHANIC BROUGHT TO MY ATTENTION FRAME DAMAGE. I WENT FOR AN INSPECTION FROM A LOCAL FRAME SPECIALIST, WHO TOLD ME MY FRAME WAS COMPLETED RUSTED THROUGH. COST FOR REPLACEMENT MATERIALS AND LABOR TOTAL COST 9227.30. TOYOTA EARLY ON IDENTIFIED KNOWN RUST ISSUES WITH THE TUNDRA WITH A RECAL... Read more

Incident date: Aug 19, 2020

LOW MILEAGE, TWO YEAR OLD FRONT TIRES BEGINNING TO SEPARATE AT INNER SIDEWALLS, MAKING VIBRATIONS ABOVE 50+ MPH AND SHAKING VEHICLE SO BAD ALMOST UNDRIVEABLE AT HIGHWAY SPEEDS. ALIGNMENT SHOP SAID GET THEM CHECKED. RE-BALANCING TIRES HAD NO EFFECT, MOVED FRONT TIRES TO REAR THEN BED OF TRUCK WOULD V... Read more

Incident date: Feb 9, 2021

BROUGHT MY TRUCK IN WITH 4 WHEEL DRIVE ISSUES AND BROKEN LEAF SPRING AND THEY TOLD ME MY FRAME WAS CRACKED.

Incident date: Dec 8, 2020

CHASSIS RUST AND HOLES IN THE FRAME. OBVIOUSLY LARGE RUST HOLES IN THE DIRECTION OF THE FRAME BEHIND THE FRONT DRIVER SIDE WHEEL. FRAME HOLES CAUSE GREAT CONCERN FOR THE OVERALL OPERATIONAL SAFETY OF THE VEHICLE. I CONSIDER THIS DEGREE OF RUST DEGRADATION EXCESSIVE AND A CRAFTSMANSHIP DEFECT. HEAVY ... Read more

Incident date: Sep 14, 2020

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT HE HAD TAKEN HIS VEHICLE TO TOYOTA OF GRAND RAPIDS (2555 28TH ST SE, GRAND RAPIDS, MI 49512) FOR NHTSA CAMPAIGN NUMBER: 09V444000(STRUCTURE). THE CONTACT WAS THEN INFORMED BY THE MECHANIC THAT THERE WAS SEVERE CORROSION ON THE VEHICL... Read more

Incident date: Sep 1, 2020

MY VEHICLE WAS SUPPOSED TO HAVE BEEN REPAIRED UNDER A PREVIOUS RECALL FOR FRAME RUST, WITH A COATING, BUT IT IS APPARENT THAT TOYOTA DID NOT REPAIR ALL AREA'S AS TODAY DRIVING DOWN THE HIGHWAY MY SHOCKMOUNT COMPLETELY RUSTED AWAY, CAUSING ME TO ALMOST HIT SEVERAL CARS, AND PIECES OF THE MOUNT FLEW B... Read more

Incident date: Sep 1, 2020

Incident date: May 2, 2020

I WAS DRIVING AND I HEARD LOUD NOISE WHEN I HIT A BUMP IN THE ROAD, PULLED OVER TO LOOK AND SAW THAT THE RIGHT REAR SHOCK RUSTED THROUGH THE CROSSMEMBER AND HIT THE BOTTOM OF THE BED.I WAS DRIVING AT 35 MPH WHEN THIS OCCURRED, I WAS ABLE TO MAKE IT HOME SLOWLY,NO INJURIES. THE VEHICLE HAS 157,000 MI... Read more

Incident date: Nov 5, 2019

ON 11-5-2019 I WAS DRIVING MY 2001 TOYOTA TUNDRA, DOWN A CITY STREET AT APPROXIMATELY 30 MPH WHEN I HEARD A LOUD SNAPPING, BREAKING NOISE AND THE RIGHT FRONT OF MY TRUCK COLLAPSED AND TRUCK VEERED TO THE RIGHT. MY FIRST INSTINCT WAS THAT I HAD A BLOWOUT. THERE WAS ENTRANCE TO CIRCLE K APPROXIMATELY ... Read more

Incident date: Dec 1, 2019

HORN CIRCUIT RELIES ON GROUNDING (COMPLETING THE CIRCUIT WHEN HORN IS PRESSED) THROUGH STEERING SHAFT/COLUMN ASSEMBLY. THIS CONNECTION TO GROUND BECOMES UNRELIABLE AS THE VEHICLE AGES LEAVING YOU WITH A NON-FUNCTIONING HORN (IN AN EMERGENCY).

Incident date: Oct 4, 2019

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO DUNNING TOYOTA (877-356-9318, LOCATED AT 3745 JACKSON RD, ANN ARBOR, MI 48103) WHERE IT WAS STATED THAT THE VEHICLE WAS TOO DANGEROUS TO BE REPAIRED ... Read more

Incident date: Oct 8, 2019

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE FRAME WAS RUSTED. THE CONTACT STATED THAT THE BRAKES AND POWER STEERING RACK WERE RUSTED BEFORE AND PREVIOUSLY REPAIRED. THE CONTACT CALLED LI... Read more

Incident date: Oct 6, 2019

LOWER BALL JOINT FAILURE DRIVERS SIDE WHEEL BROKE LOOSE FROM LOWER CONTROL ARM

Incident date: Oct 11, 2019

HI, I HAVE A 2001 TUNDRA THAT THE FRAME IS SHOT ON. I HAVE FIXED IT A FEW TIMES TO TRY TO KEEP IT ON THE ROAD BUT IT JUST KEEPS GETTING WORSE AND WORSE. ITS TO THE POINT WHERE I FEEL ITS NOT SAFE TO DRIVE ANYMORE BUT TOYOTA REFUSES TO FIX IT. THEY SAY IT DOESN'T QUALIFY FOR THEIR FRAME RECALL. I FIN... Read more

Incident date: Sep 9, 2019

MY BALL JOINTS ON THE DRIVER'S SIDE WHEEL CATASTROPHICALLY FAILED THIS MORNING WITHOUT WARNING (NO KNOCKING/RATTLING/VIBRATION/ETC.). LUCKILY I WAS ONLY GOING 15 MPH. I AM CONCERNED THAT TOYOTA IS AWARE OF AN ISSUE WITH THE BALL JOINTS THAT COULD CAUSE THIS FAILURE WITHOUT WARNING. I AM WORRIED FO... Read more

Crash

Incident date: Aug 16, 2019

BOUGHT TRUCK NEW IN 8/2001. BROUGHT TRUCK TO DEALER WHEN IT WAS RECALLED FOR RUST IN 2012 AND WAS TOLD RUST WASN'T BAD ENOUGH TO DO ANYTHING. BROUGHT TRUCK BACK TO DEALER MULTIPLE TIMES AFTER 2012 (LAST IN 11/18) AND WAS TOLD EVERYTHING WAS FINE ON EACH OCCASION. IN 8/2019 I HEARD A SQUEAK FROM U... Read more

Incident date: Aug 16, 2019

Incident date: Jul 13, 2019

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING 50 MPH AND MAKING A RIGHT TURN, THE CONTACT HEARD AN ABNORMAL NOISE AND THE FRONT PASSENGER SIDE WHEEL DETACHED FROM THE VEHICLE AND WAS STUCK ON THE SIDE. THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO STOP. THERE WERE NO WA... Read more

Incident date: Dec 18, 2018

THERE WAS A SAFETY RECALL ISSUED FOR CORROSION/RUSTED FRAMES ON 2000-2001 TOYOTA TUNDRAS IN WHAT TOYOTA DEFINED AS SEVERE COLD WEATHER STATES. IOWA WAS NOT INCLUDED. WHY? WE HAVE A 2001 TOYOTA TUNDRA WITH ONLY 120,000+MILES ON IT THAT NOW HAS A RUSTED OUT WHOLE THE SIZE OF MY FIST IN ITS FRAME. I DO... Read more

Incident date: Jun 13, 2017

THE LOWER BALL JOINTS ON THESE FIRST GENERATION TUNDRAS ARE ALL PRONE TO EARLY FAILURE WHEN USING ANY OTHER BRAND THAN OEM. I HAVE TALKED TO DOZENS OF FIRST GEN OWNERS AND ALL AGREE THE LOWER BALL JOINTS ON THE TRUCKS ARE A HUGE WEAK POINT. I HAD MY DRIVER'S SIDE FRONT WHEEL COME OFF OF MY TRUCK WHI... Read more

Crash

Incident date: Sep 28, 2018

VEHICLE FRAME HAS SUFFICIENT RUST INCLUDING HOLES IN THE FRAME. THERE WERE TWO RECALLS DEALING WITH THIS RUST ISSUE, NEITHER FIXED THE PROBLEM. THIS HAS BEEN AN ON GOING ISSUE FOR TOYOTA INCLUDING CLASS ACTION LAWSUITS - BUT THOSE DIDN'T INCLUDE 2001 TUNDRA. I HAVE CONTACTED THE DEALERSHIP WHERE PUR... Read more

Incident date: Jan 1, 2018

THE SEATBELT ON THE PASSENGER SIDE FRONT SEAT WILL NO LONGER LATCH. THIS HAPPENS AT ANY TIME THE PASSENGER TRIES TO BUCKLE UP. THE ISSUE IS WITH THE CATCH AND NOT THE BUCKLE. THERE IS NO DAMAGE TO THE EXTERIOR OF THE CATCH AND WHEN YOU STICK THE BUCKLE INSIDE, IT SIMPLY WILL NOT CATCH TO LOCK THE... Read more

Incident date: Oct 15, 2018

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. UPON INSPECTION, IT WAS DISCOVERED THAT THE SUBFRAME SUSTAINED SEVERE RUSTING AND CORROSION. THE VEHICLE WAS TAKEN TO CURRY TOYOTA (832 STRAITS TURNPIKE, WATERTOWN, CT) WHO CONFIRMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE).... Read more

Incident date: Sep 26, 2018

FRONT LOWER LEFT BALL JOINT BROKE AT 40 MPH WHILE CROSSING RR TRACKS.THE TIRE/HUB COMPLETELY TORE LOOSE TEARING OFF BRAKE LINE.AND JUST LUCKILY AVOIDED A DEADLY HEAD-ON COLLISION.THIS IS THE MOST DANGEROUS VEHICLE I HAVE EVER OWNED.THIS PROBLEM MUST BE ADDRESSED.MY PROBLEM IS L ALSO OWN A 2001 TOYOT... Read more

Crash 1 injured

Incident date: Aug 23, 2018

FRAME ROT HOLES AND PARTS OF FRAME ROTTED THU ALSO POWER STERRING RACK AND ALL LINES LEAKING THU PUMP RAN OUT OF FLUID ALSO THE FRAME ON DRIVERS SIDE AT FT MOUNT FOR STEP RAIL HOLES RIGHT THU FRAME AND AT FRONT LE4FT FROME RAL HOLE BIG HOLE

Showing 50 of 542 complaints.

Technical Service Bulletins, 2001 TOYOTA TUNDRA

140 manufacturer communications from 92 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	19
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	11
110000 ELECTRICAL SYSTEM	9
060000 ENGINE (PWS)	8
140000 AIR BAGS	7
030000 SERVICE BRAKES, HYDRAULIC	5
061000 ENGINE AND ENGINE COOLING:ENGINE	5
118000 ELECTRICAL SYSTEM:SOFTWARE	5

060000 ENGINE AND ENGINE COOLING

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE January 22, 2024: This bulletin is now obsolete. Please see T-SB-0057-18.

140000 AIR BAGS

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re

180000 VEHICLE SPEED CONTROL

350000 EQUIPMENT

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

050000 PARKING BRAKE

TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai

190000 TIRES

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

200000 WHEELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

140000 AIR BAGS

Toyota Safety Recall and Service Campaign - Technician Certification Requirements

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

350000 EQUIPMENT

TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a

350000 EQUIPMENT

TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b

100000 POWER TRAIN

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. T-SB-0043-14 is obso

350000 EQUIPMENT

Mis-Built For frames that are suspected to have been mis-built, dealers should: 1. Contact the Parts Technical Support Group (PTSG) at [email protected] with information on the condition and status of repair. a. Include the original par

160000 STRUCTURE

Dealer Daily Message: Frame Programs. Extension of Warranty Coverage for Frame Corrosion/Frame Replacement. Frame Ordering/Repair/Administration Updates Mis-Built. For frames that are suspected to have been mis-built, dealers should: 1. Co

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg

350000 EQUIPMENT

TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

140000 AIR BAGS

TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

110000 ELECTRICAL SYSTEM

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed

118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.

060000 ENGINE (PWS)

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

Update on Technician Certification Requirements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update on Technician Certification Requirements.

160000 STRUCTURE

THIS CAMPAIGN EXPIRED ON DECEMBER 31, 2012.

350000 EQUIPMENT

THIS CAMPAIGN EXPIRED ON DECEMBER 31, 2012.

160000 STRUCTURE

THIS CAMPAIGN EXPIRED ON DECEMBER 31, 2012.

350000 EQUIPMENT

THIS CAMPAIGN EXPIRED ON DECEMBER 31, 2012.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Campaign Expired on December 31, 2012.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Campaign Expired on December 31, 2012.

110000 ELECTRICAL SYSTEM

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

060000 ENGINE (PWS)

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

060000 ENGINE (PWS)

TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

060000 ENGINE (PWS)

TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

100000 POWER TRAIN

TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

353000 EQUIPMENT:ELECTRICAL

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

110000 ELECTRICAL SYSTEM

"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL

060000 ENGINE (PWS)

118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull

060000 ENGINE (PWS)

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

100000 POWER TRAIN

TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Use the information in this bulletin when insta

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

118000 ELECTRICAL SYSTEM:SOFTWARE

060000 ENGINE (PWS)

Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft Position

280000 BACK OVER PREVENTION

Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft Position

030000 SERVICE BRAKES, HYDRAULIC

A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general

350000 EQUIPMENT

140000 AIR BAGS

Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the

130000 VISIBILITY

The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.

130000 VISIBILITY/WIPER (PWS)

This bulletin is now obsolete. Please see T-SB-0185-13.

140000 AIR BAGS

Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT

220000 SEATS

350000 EQUIPMENT

100000 POWER TRAIN

The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when

050000 PARKING BRAKE

A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

350000 EQUIPMENT

California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide

355100 EQUIPMENT:OTHER:LABELS

This bulletin is now obsolete. Please see T-SB-0054-13.

110000 ELECTRICAL SYSTEM

The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.

118000 ELECTRICAL SYSTEM:SOFTWARE

Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin is now obsolete. Please see T-SB-0012-13.

140000 AIR BAGS

Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi

118000 ELECTRICAL SYSTEM:SOFTWARE

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE

161000 STRUCTURE:FRAME AND MEMBERS

TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN CERTAIN COLD CLIMATE AREAS, WITH HIGH USAGE OF ROAD SALT, FRAMES OF TRUCKS WOULD EXHIBIT MORE THAN NORMAL RUST CORROSION, CAUSING PERFORATION OF METAL. MODELS 2000-03 TUNDRA.

071120 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

TOYOTA: SOME VEHICLES MAY EXPERIENCE EXCESSIVE CORROSION OF REAR CROSS MEMBER AND FUEL TANK MOUNTING SYSTEM AND STRAPS WHEN OPERATED IN COLD CLIMATE AREAS. *PE

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

TOYOTA: SOME VEHICLES MAY EXPERIENCE EXCESSIVE CORROSION OF REAR CROSS MEMBER AND FUEL TANK MOUNTING SYSTEM AND STRAPS WHEN OPERATED IN COLD CLIMATE AREAS. *PE

140000 AIR BAGS

TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE

Showing 100 of 140 bulletins.

NHTSA Safety Investigations, TOYOTA TUNDRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2000

FRAME CORROSION

THIS INVESTIGATION WAS OPENED BASED ON 20 REPORTS OF MODEL YEAR (MY) 2000 AND 2001 VEHICLES EXPERIENCING SEVERE CORROSION OF THE FRAME, RESULTING IN EITHER UNDER-BODY MOUNTED SPARE TIRE SEPARATION OR REAR BRAKE FAILURE.THE FAILURE REPORT COUNTS SHOWN ABOVE ARE FOR MY 2000 AND 2001 VEHICLES ONLY.BY L... ETTER OF NOVEMBER 16, 2009 TOYOTA HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (09V-444) OF APPROXIMATELY 110,000 MODEL YEAR (MY) 2000 THROUGH 2003 TUNDRA VEHICLES.THE AFFECTED RECALLED VEHICLES WERE SOLD OR ARE CURRENTLY REGISTERED IN THE DISTRICT OF COLUMBIA AND THE STATES OF CT, DE, IL, IN, KY, MA, MD, ME, MI, MN, NH, NJ, NY, OH, PA, RI, VA, VT, WI, WV.TOYOTA ALLEGES HIGH AMOUNTS OF ROAD SALTS ARE USED IN THESE AREAS AND EXCESSIVE CORROSION OF THE REAR CROSS-MEMBER (TO WHICH THE SPARE TIRE IS MOUNTED) CAN OCCUR AND CAUSE THE SPARE TIRE TO SEPARATE FROM THE VEHICLE AND CAN ALSO LEAD TO REAR BRAKE FAILURE.TOYOTA STATED: TOYOTA HAS TENTATIVELY CONCLUDED THAT THE ROOT CAUSE IS A COMBINATION OF FACTORS, INCLUDING USAGE IN AREAS WHERE ROAD SALT IS APPLIED, INADEQUATE VEHICLE MAINTENANCE (I.E., NOT FOLLOWING THE RECOMMENDATIONS IN THE OWNER'S MANUAL), THE DESIGN OF THE REAR CROSS-MEMBER, AND MANUFACTURING ISSUES.THE DESIGN OF THE REAR CROSS-MEMBER IS SUCH THAT IT IS OPEN ON THE TOP SIDE AND SUSCEPTIBLE TO ACCUMULATION OF DIRT, WATER AND ROAD SALT.MANUFACTURING ISSUES OF THE REAR CROSS-MEMBER RELATED TO THE COATING PROCESS ALSO AFFECT ITS CORROSION RESISTANCE.TOYOTA ALSO STATES THAT OWNERS OF MY 2000 THROUGH 2003 VEHICLES IN STATES NOT COVERED BY THE RECALL WILL BE NOTIFIED ON HOW TO OBTAIN THE SAME INSPECTION AND REPAIR AS THE RECALLED VEHICLES, FREE OF CHARGE.FURTHER TOYOTA STATES: PLEASE NOTE THAT WHILE TOYOTA HAS NOT DETERMINED A DEFECT EXISTS IN 2004 THROUGH 2006 MY TUNDRA VEHICLES, TOYOTA PLANS ON INITIATING A FIELD ACTION IN THE NEAR FUTURE TO PREVENT FUTURE CORROSION ON THOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE AFFECTED REGION AT NO COST TO THE OWNER.BY LETTER OF JANUARY 8, 2010 TOYOTA HAS NOTIFIED THE AGENCY THAT IT AMENDED ITS DEFECT INFORMATION REPORT FOR SAFETY RECALL 09V-444 TO INCLUDE THE FUEL TANK MOUNTING SYSTEM (I.E., FUEL TANK SUPPORT STRAPS AND FUEL TANK MOUNTING CROSS-MEMBERS) IN THE SAFETY RECALL.TOYOTA STATES: TOYOTA HAS NOT DECIDED THAT THE FUEL TANK MOUNTING SYSTEM IN THOSE VEHICLES CONTAINS A SAFETY-RELATED DEFECT WITHIN THE MEANING OF FEDERAL MOTOR VEHICLE SAFETY LAW.RATHER, TOYOTA IS TAKING THIS ACTION AT ODI'S REQUEST AND TO AVOID FUTURE DISAGREEMENT WITH ODI WITH RESPECT TO THIS ISSUE.MY 2007 AND NEWER TUNDRA VEHICLES ARE NOT INCLUDED IN ANY OF TOYOTA'S ACTIONS AS THE REAR CROSS-MEMBER IN THOSE VEHICLES HAVE BEEN REDESIGNED SO THAT IT IS OPEN ON THE BOTTOM.THE ACTIONS TAKEN BY TOYOTA ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE SUBJECT VEHICLES.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

RQ, Closed , Model Year: 2004

LOWER BALL JOINT SEPARATION

THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED RQ06-005 BASED ON FOUR CONSUMER REPORTS OF ALLEGED BALL JOINT FAILURE. THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL. ALL OF THESE C... Read more

EA, Closed , Model Year: 2002

BALL JOINT SEPARATION

ODI RECEIVED 3 CONSUMER REPORTS OF ALLEGED BALL JOINT SEPARATION ON MY 2002 TUNDRA VEHICLES.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.BASED ON THESE COMPLAINTS, ODI OPENED PE02-0... Read more

PE, Closed , Model Year: 2002

FRONT SUSPENSION BALL JOINT BREAKAGE

ODI OPENED PE04-040 BASED ON THREE CONSUMER REPORTS OF ALLEGED BALL JOINT FAILURE.THE COMPLAINTS ALLEGE THAT A FRONT SUSPENSION BALL JOINT SEPARATED WHILE DRIVING, WHICH CAUSED THE SUSPENSION TO COLLAPSE AND RESULTED IN A LOSS OF VEHICLE CONTROL.ALL OF THESE COMPLAINTS INVOLVED THE FAILURE OF A LOWE... Read more

TOYOTA TUNDRA - All Years Overview

Complete safety history for the TOYOTA TUNDRA across all model years (1999, 2026).

236 Total Recalls

9,358 Total Complaints

4 Investigations

546 Reported Crashes

82 Reported Fires

30 Reported Deaths

TOYOTA TUNDRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	26	View
2025	4	217	View
2024	10	491	View
2023	13	585	View
2022	13	619	View
2021	3	30	View
2020	5	55	View
2019	10	103	View
2018	9	154	View
2017	6	112	View
2016	6	154	View
2015	5	58	View
2014	5	115	View
2013	6	105	View
2012	4	215	View
2011	11	184	View
2010	16	218	View
2009	13	53	View
2008	13	460	View
2007	14	535	View
2006	13	677	View
2005	14	491	View
2004	13	652	View
2003	10	524	View
2002	6	648	View
2001 (current)	5	542
2000	7	1,334	View
1999	1	1	View

Other TOYOTA Models

Model	Recalls	Complaints
HIGHLANDER	677	6,756	View
RAV4	669	11,842	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
GRAND HIGHLANDER	388	332	View
PRIUS	365	15,456	View
HIGHLANDER HYBRID	355	1,103	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2001 TOYOTA TUNDRA

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2001 TOYOTA TUNDRA

Most Affected Components

NHTSA Safety Investigations, TOYOTA TUNDRA

TOYOTA TUNDRA - All Years Overview

TOYOTA TUNDRA - Year by Year

Other TOYOTA Models