2008 TOYOTA HIGHLANDER HYBRID

8 recalls, 272 complaints - 129 TSBs

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Defect Description

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vib... Read more

Consequence

If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-... Read more

1,814,284 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

HYBRID PROPULSION SYSTEM: INVERTER

Defect Description

Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module m... Read more

Consequence

The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.

133,081 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Defect Description

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less preci... Read more

Consequence

If the switch overheats, it may melt, possibly resulting in a fire.

Remedy

Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their T... Read more

2,519,424 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

AIR BAGS

Defect Description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, T... Read more

Consequence

INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.

Remedy

TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331... Read more

307,848 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

EQUIPMENT:OTHER:LABELS

Defect Description

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE S... Read more

Consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

27,080 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

EQUIPMENT

Defect Description

SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EX... Read more

Consequence

THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Remedy

SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.

3,499 vehicles affected

Manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS, LLC

EQUIPMENT

Defect Description

TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO... Read more

Consequence

THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Remedy

TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM THROUGH 4:00 PM PACIFIC TIME.

39,100 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

SEAT BELTS:REAR/OTHER

Defect Description

TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP)... Read more

Consequence

HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DU... Read more

Remedy

DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

90,189 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

Complaint Statistics

272 total complaints 6 crashes 7 fires 7 injuries

Top Reported Components

Component	Complaints
SERVICE BRAKES	94
ELECTRICAL SYSTEM	34
ELECTRONIC STABILITY CONTROL (ESC)	25
VEHICLE SPEED CONTROL	18
SERVICE BRAKES, HYDRAULIC	12
POWER TRAIN	11
ENGINE	10
UNKNOWN OR OTHER	10
TIRES	9
HYBRID PROPULSION SYSTEM: INVERTER	7

Incident date: Aug 12, 2025

I am writing to you today with an urgent and serious safety concern regarding my 2016 Ford Explorer XLT. My vehicle is affected by the A-pillar molding inspection recall, Campaign 24S02/24V031. Last week, while I was driving on the interstate, the passenger side A-pillar molding detached from my veh... Read more

Incident date: Mar 1, 2025

The air bag light is illuminated as a result of a worn/damaged connection to the rear inflatable seat belt connector.

Incident date: Nov 10, 2021

The contact owns a 2008 Toyota Highlander Hybrid. The contact stated while driving 45 MPH, the brake malfunction and ABS warning lights were illuminated. The contact stated that when she started the vehicle, she was unable to depress the brake pedal to the floor and started to hear an abnormal noise... Read more

Incident date: Nov 10, 2021

Incident date: Aug 14, 2019

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER HYBRID. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 13V396000 (HYBRID PROPULSION SYSTEM: INVERTER). WHILE IN A PARKING LOT, THE VEHICLE WENT INTO FAIL SAFE LIMP HOME MODE AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUM... Read more

Incident date: May 1, 2019

ALL WARNING LIGHTS ARE ON TO CHECK BRAKES, ABS. ABNORMAL LEAK IN ACUMULATOR - ABS BRAKE ACTUATOR NEEDS TO BE REPLACED. I WAS SENT A RECALL ON THIS PROBLEM WITH MY 2012 PRIUS (ALTHOUGH IT IS FINE) BUT THE HIGHLANDER HAS THE EXACT PROBLEM. WHEN GOOGLING THIS I FOUND MANY 2008 HIGHLANDERS WITH THE E... Read more

Incident date: Apr 4, 2019

BRAKE ACTUATOR ASSEMBLY ON MY 2008 TOYOTA HIGHLANDER HYBRID HAS BEEN FAILING. KNOW ISSUE. I'VE TAKEN EXCELLENT CARE OF THIS VEHICLE AND HAD IT SERVICED AT THE DEALERSHIP. THE MANUFACTURING IS REPLACE THE PREVIOUS YEARS, BUT NOT THE 2008 WHICH IS THE EXACT SAME COMPONENT. PLEASE LET ME KNOW WHY THIS ... Read more

Incident date: Apr 4, 2019

Incident date: Mar 2, 2019

ABS PUMP AND ACTUATOR FAILURE. WARNING LIGHTS ON THE DASH BUZZER, AND NEARLY COMPLETE LOSS OF STOPPING POWER, REDUCED FUEL ECONOMY. WE OWN A 2008 TOYOTA HIGHLANDER HYBRID WHICH CONFIRMED BY THE DEALER HAS A 100% FAILURE RATE WHICH IS THE EXACT FAILURE PREVIOUSLY RECALLED ON 2006-07 HIGHLANDER HYBRID... Read more

Incident date: Mar 2, 2019

Incident date: Mar 26, 2019

I AM TOLD I NEED TO REPLACE THE BRAKE ACTUATOR ASSEMBLY ON MY 2008 TOYOTA HIGHLANDER HYBRID. MY RESEARCH INDICATES THAT THIS COMPONENT FAILURE WAS A KNOWN PROBLEM FOR YEARS AND WAS ACTUALLY COVERED IN A RECALL FOR 2006-7 MODELS. FOR REASONS UNKNOWN THE RECALL DOES NOT COVER 2008 EVEN THOUGH IT IS ... Read more

Incident date: Mar 16, 2019

TAKATA RECALL .. MY CAR START GETTING AN ERROR LIGHT IN MY DASHBOARD.. IT SAYS BRAKE MALFUNCTION , VSC SYSTEM AND ABS SYSTEM .. MY CAR RUNS FINE BUT SOMETIME WHEN I PRESS THE PHRASE PEDAL CAR DOESN'T BREAK RIGHT AWAY AND MAKING NOISE.

Incident date: Mar 16, 2019

Incident date: Mar 4, 2019

VSC, ABS, TRACTION CONTROL ERROR LIGHT. MY MECHANIC IDENTIFIED THIS AS A FAILER ACCUMULATOR (ABS MODULE), HE SAID THERE IS A TSB FROM TOYOTA. I KNOW THERE WAS A RECALL ON THIS ISSUE ON THIS VEHICLE THROUGH YEAR 2007. CONCERNED ABOUT POSSIBILITY OF TOTAL BRAKE FAILURE.

Incident date: Mar 4, 2019

Incident date: Feb 25, 2019

WE WERE DRIVING THE CAR NORMALLY ON CITY STREETS, NOT EVEN BRAKING AT THE TIME WHEN SUDDENLY THE ABS LIGHT AND A COUPLE OTHERS LIT UP ON THE DASHBOARD ALONG WITH A WARNING MESSAGE ON THE SCREEN ABOUT THE ABS AND VCS SYSTEMS. BRAKING STILL WORKED AS DID EVERYTHING ELSE (LESS THE ABS I ASSUME). *JB

Incident date: Feb 25, 2019

Incident date: Feb 17, 2019

THE BRAKE MALFUNCTION LIGHT CAME ON WHILE DRIVING. TOYOTA SAYS ITS THE BRAKE ACTUATOR ASSEMBLY AND IT WILL COST ME $4700 TO REPLACE THE PART. THEY RECALLED TOYOTA HIGHLANDER 06-07, PRIUS 04-09 AND LEXUS WITH THE SAME PROBLEM. THE RESULT CAN BE TOTAL BRAKE FAILURE. SINCE TOYOTA KNOWS THIS IS AN IS... Read more

Incident date: Oct 18, 2018

THE BRAKES STARTED MAKING A WEIRD "BURPING / BARKING" NOISE AND THEN THE DREADED C1391 CODE POPPED UP. THERE WAS A RECALL FOR THE ABS ACTUATORS ON THE 2005-7 YEARS BUT YET HERE WE ARE WITH PEOPLE REPORTING THIS FAILURE ON THE 2008-11 YEARS IN DROVES. CLEARLY THERE IS THE SAME MANUFACTURING ISSUE. IR... Read more

Incident date: Dec 21, 2018

I RECENTLY HAD A NUMBER OF SERVICE LIGHTS APPEAR ON THE DASHBOARD OF MY 2008 TOYOTA HIGHLANDER HYBRID, INCLUDING THE BRAKE,VSC, AND ABS. THERE WAS A MESSAGE STATING THAT I SHOULD TAKE IT TO A DEALER FOR SERVICE IMMEDIATELY. WHEN I TOOK IT TO THE DEALERSHIP, THEY DETERMINED IT WAS AN OPEN CIRCUIT IN... Read more

Incident date: Dec 19, 2018

I WAS DRIVING SLOWLY IN TRAFFIC WHEN SEVERAL DASHBOARD LIGHTS CAME ON AND ERROR MESSAGE BEGAN ROTATING THROUGH THE CENTER SCREEN. "BRAKE MALFUNCTION - STOP THE VEHICLE IN A SAFE PLACE IMMEDIATELY, AND CONTACT A DEALER,' "CHECK ABS - HAVE YOUR VEHICLE CHECKED BY A DEALER," AND "CHECK VSC SYSTEM - HA... Read more

Incident date: Nov 17, 2018

CAR HAS BEEN KEPT ON A GARAGE AND WELL TAKEN CARE OF. WE HAVE FOLLOWED THE MAINTENANCE SCHEDULE ON IT METICULOUSLY. HOWEVER, TODAY WE FOUND OUT THAT THE BRAKE ACTUATOR IS LEAKING AND COULD CAUSE CATASTROPHIC FAILURE. THIS SEEMS TO BE A PROBLEM ON MANY CARS FROM THIS YEAR, AND OBVIOUSLY FROM PREVIOU... Read more

Incident date: Mar 23, 2018

MY 2008 HIGHLANDER ABS IS FAILED AND THAT PUT OUR FAMILY AND OTHERS IN DANGER BECAUSE OF THE ABS IS NOT WORKING PROPERLY. THE LIGHTS KEEP STAYING ON, DOESN'T MATTER WHAT YOU DO, RESET IT OR NOT. THE BRAKES STOPPED WORKING, THE SIREN INSIDE THE VEHICLE MAKING BUZZY NOISE WHEN OPENING THE DOOR OR ATTE... Read more

Incident date: Sep 26, 2018

MY 2008 HIGHLANDER HYBRID HAS BEEN MAKING A 'BARKING' SOUND EACH TIME I DEPRESS OR RELEASE THE BRAKE. I TOOK IT INTO THE DEALERSHIP TO FIND OUT THAT IT'S NOT A RECALL ITEM. THE SAME BRAKE ACTUATOR PART IS COVERED BY A RECALL BY TOYOTA UP TO 2007 AND LEXUS UP TO 2012. I'VE BEEN TOLD THAT IT'S NOT A '... Read more

Incident date: Oct 21, 2018

BRAKE SAFETY BRAKE ACTUATOR ASSEMBLY FALIAR TO FUNCTION AND ALMOST LOCKED WHEN I AM DRIVING IN THE HIGHWAY THANK

Incident date: Sep 15, 2018

I HAVE A 2008 TOYOTA HIGHLANDER HYBRID . HAS 200K MILES AND THE ABS LIGHT CAME TWICE IN ONE WEEK WHILE VEHICLE WAS IN MOTION BEFORE APPLYING THE BRAKES. AFTER RESETTING ABS LIGHT, HAD PULLED C1252, C1256, C1319 & C1391 FOR ABS ACCUMULATOR/ACTUATOR LEAK.VERY UNSAFE TO DRIVE DUE TO MY VEHICLE IS BRAKI... Read more

Incident date: Sep 15, 2018

Incident date: Oct 5, 2018

I WAS DRIVING MY CAR ALL OF A SUDDEN EMERGENCY LIGHTS WENT ON, BRAKES LIGHTS, 4WD SYSTEM LIGHTS TOO TELLING ME TO PULL OVER ONCE I PULLED OVER ON TO SIDE OF THE ROAD I PUT IT IN PARK SHUT THE CAR OFF ,TURNED IT BACK OFF TO SEE A CHANGE PUT IT IN DRIVE THE CAR WAS STUCK AND ALL LIGHTS PREVIOUSLY STAT... Read more

Incident date: Oct 5, 2018

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING 60 MPH, AN INTERNAL ALARM SOUNDED. ALSO, THE BRAKES WERE INOPERABLE AND THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ABS ACTUATOR FAILED AND FAILURE CODES: C1241, C13... Read more

Incident date: Sep 21, 2018

I HAVE A 2008 TOYOTA HIGHLANDER HYBRID . HAS 110K MILES AND THE ABS LIGHT CAME TWISE IN ONE WEEK WHILE VEHICLE WAS IN MOTION BEFORE APPLYING THE BRAKES.WHAT WOULD HAPPENS HAPPENED THEIR IS A NEED FOR A HARD STOP . ATTER RESETTING ABS LIGHT. HAD PULLED C1391 FOR ABS ACCUMULATOR LEAK.VERY UNSAFE TO DR... Read more

Incident date: Sep 21, 2018

Incident date: Sep 22, 2018

THE ABS ACTUATOR IS LEAKING FLUID AND NEEDS TO BE REPLACED. LUCKILY, I NOTICED A NOISE FROM THE SLIPPING ABS WHILE IDLING AT TRAFFIC LIGHTS, AND BROUGHT IT IN FOR SERVICE BEFORE A WARNING LIGHT CAME ON, OR MY BRAKES FAILED. THOUGH MANY ONLINE ACCOUNTS OF THIS SAME FLUID LEAK ISSUE ON THIS VEHICLE MA... Read more

Incident date: Aug 15, 2018

Incident date: Aug 27, 2018

FAILURE OF BRAKE ACCUATOR AND ACCUMULATOR

Incident date: May 16, 2018

LOST ALL BRAKING ABILITY DUE TO A ABS BRAKE ACUATOR INTERNAL LEAK ON HYBRID VEHICLE

Incident date: Mar 15, 2018

ABS BRAKE SYSTEM FAILURE DRIVING DOWN THE HIGHWAY LEAVING THE CAR 100% WITH NO BRAKES AS DRIVING DOWN THE HIGHWAY IN HEAVY TRAFFIC NEARLY CAUSING A MAJOR ACCIDENT AND POTENTIAL RISK OF LIFE. CAR REGULARLY MAINTAINED AND WELL CARED FOR. DEALER CALLING FOR $5,200 REPAIR WITH NO ALTERNATIVE. PARTS ... Read more

Incident date: Aug 14, 2018

BRAKING POWER ASSIST FAILURE CAUSED FENDER BENDER IN PARKING LOT, LEAKING BRAKE FLUID FOUND AT BRAKE PUMP. DASH WARNING LIGHTS APPEARED THE NEXT DAY.

Crash

Incident date: Jul 23, 2018

VEHICLE HYBRID/ENGINE SHUT OFF WHILE DRIVING. VARIOUS WARNING LIGHTS LIT UP INCLUDING VSC, HYBRID SYSTEM, AND CHECK ENGINE. I WAS FORCED TO CHANGE LANES WITH THE CAR OFF BUT MOVING AT ABOUT 40 MPH AND PULL OVER ON A SIDE STREET. I AS ABLE TO RESTART THE VEHICLE AND CONTINUE MY DRIVE. THE FOLLOWIN... Read more

Incident date: Jul 23, 2018

Incident date: Jul 28, 2018

THIS IS THE SECOND FAILURE WARNING ABOUT THE BRAKE SYSTEM (ABS WARNING) SINCE WE PURCHASED THE VEHICLE NEW. REPAIRS COST US IN EXCESS OF $5000.00 THE FIRST TIME THE SYSTEM FAILED. I PLACED A PHONE CALL TO TOYOTA'S NATIONAL CUSTOMER SUPPORT AND WAS TOLD THEY HAVE NO RECORDS OF ANY REPAIRS TO THE ... Read more

Incident date: Jul 22, 2018

LIGHTS APPEARED ON DASH "BRAKE MALFUNCTION", "CHECK BRAKE SYSTEM", "CHECK VSC SYSTEM". TOOK MY 2008 TOYOTA HIGHLANDER HYBRID TO MY LOCAL TOYOTA DEALERSHIP. THEY SAID THAT IT WAS THE ABS BRAKE SYSTEM AND IT WOULD COST $6000 TO REPAIR. I HAD THE EXACT SAME PROBLEM IN MY 2007 TOYOTA HIGHLANDER HYBR... Read more

Crash

Incident date: Jul 2, 2018

I WAS DRIVING ON THE HIGHWAY AND THE BRAKE LIGHT AND ABS CAME ON AND STARTED BEEPING. WHEN THE BRAKE IS ENGAGED, IT'S HARD TO STOP AND VERY HARD TO DEPRESS THE PEDAL, INSPECTION FOR THE OPERATION OF THE BRAKING SYSTEM- FAIL. THE MECHANIC STATED WE HAVE TO REPLACE POWER BRAKE BOOSTER AND THE ABS ACTU... Read more

Incident date: Jul 7, 2018

THE ABS ,VSC ,CHECK ENGINE LIGHT COMING ON WHEN ACCELERATING. STATING TO PARK VEHICLE AND TAKE IT TO THE DEALER.

Incident date: May 1, 2018

I HAVE A 2008 TOYOTA HIGLANDER HYBRID. DASH WARNINGS APPEARED SUDDENLY: CHECK VSC SYSTEM, CHECK ABS, BRAKE MALFUNCTION. I TOOK THE VEHICLE TO MY LOCAL DEALER AND WAS TOLD THAT THE REPAIR WOULD COST $6000. I PREVIOUSLY OWNED A 2007 TOYOTA HIGHLANDER HYBRID. SAME THING HAPPENED IN THAT VEHICL... Read more

Incident date: Jul 7, 2018

THE ABS ,VSC ,CHECK ENGINE LIGHT COMING ON WHEN ACCELERATING. STATING TO PARK VEHICLE AND TAKE IT TO THE DEALER.

Incident date: Jul 7, 2018

THE ABS ,VSC ,CHECK ENGINE LIGHT COMING ON WHEN ACCELERATING. STATING TO PARK VEHICLE AND TAKE IT TO THE DEALER.

Incident date: Jun 25, 2018

BRAKE MALFUNCTION WARNING AND ABS WARNING LIGHTS CAME ON UNEXPECTEDLY WHILE DRIVING. UPON INSPECTION AT THE TOYOTA DEALERSHIP, I WAS TOLD THAT THE VEHICLE HAS A MAJOR SYSTEM FAILURE, THE ABS ACTUATOR HAD FAILED AND WOULD NEED TO BE REPLACED AT A COST OF OVER $4000. IT APPEARS THAT, LIKE WITH THE 200... Read more

Incident date: Apr 26, 2018

BRAKE SYSTEM MALFUNCTION LIGHTS CAME ON, CHECK ABS SYSTEM LIGHTS CAME ON WHILE DRIVING ON THE FREEWAY AND I LOST FUNCTION OF MY ANTILOCK BRAKES WHICH FELT VERY UNSAFE AT HIGH SPEEDS. BROUGHT IT TO THE MECHANIC WHO TOLD ME THE BRAKE ACCUMULATOR WAS LEAKING INTERNALLY AND WILL NOT HOLD PRESSURE AND TH... Read more

Showing 50 of 272 complaints.

Technical Service Bulletins, 2008 TOYOTA HIGHLANDER HYBRID

129 manufacturer communications from 70 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
353000 EQUIPMENT:ELECTRICAL	15
110000 ELECTRICAL SYSTEM	13
350000 EQUIPMENT	12
162300 STRUCTURE:BODY:DOOR	10
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	9
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	7
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	7
160000 STRUCTURE	7

060000 ENGINE AND ENGINE COOLING

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE January 22, 2024: This bulletin is now obsolete. Please see T-SB-0057-18.

160000 STRUCTURE

DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the v

160000 STRUCTURE

350000 EQUIPMENT

TSB: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue c

119100 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

160000 STRUCTURE

350000 EQUIPMENT

CSP: Customer Support Program ZKG - Paint Repair Process Operation Flow Chart

160000 STRUCTURE

350000 EQUIPMENT

160000 STRUCTURE

DD: Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Toyota has added approximately 430,700 2008 ? 2018 model year Highlander and H

350000 EQUIPMENT

190000 TIRES

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

200000 WHEELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

160000 STRUCTURE

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth? Audio function

140000 AIR BAGS

Toyota Safety Recall and Service Campaign - Technician Certification Requirements

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

052310 PARKING BRAKE:DRIVELINE:HYDRAULIC:ACTUATOR

Dealer Package: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly on certain 2008 - 2010 model year Highlander Hybrid vehicles. These reports have indicated certain internal malfunctions of th

030000 BRAKES (PWS)

030000 SERVICE BRAKES, HYDRAULIC

Warranty Enhancement Program: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly indicating certain internal malfunctions.

052310 PARKING BRAKE:DRIVELINE:HYDRAULIC:ACTUATOR

Warranty Enhancement Program: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly indicating certain internal malfunctions.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

356000 EQUIPMENT ADAPTIVE/MOBILITY

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: OBSOLETE NOTICE July 9, 2019: This bulletin is now obsolete. Please see T-SB-0080-19.

100000 POWER TRAIN

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

030000 BRAKES (PWS)

Region Email: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly on certain 2008 - 2010 model year Highlander Hybrid vehicles. These reports have indicated certain internal malfunctions of the

030000 BRAKES (PWS)

Dealer Email: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly on certain 2008 - 2010 model year Highlander Hybrid vehicles. These reports have indicated certain internal malfunctions of the

030000 BRAKES (PWS)

Region Letter: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly on certain 2008 - 2010 model year Highlander Hybrid vehicles. These reports have indicated certain internal malfunctions of the

030000 BRAKES (PWS)

Customer Support Program: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly indicating certain internal malfunctions.

110000 ELECTRICAL SYSTEM

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

350000 EQUIPMENT

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

350000 EQUIPMENT

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE January 05, 2018 Rev1: ? Applicability has been updated to include 2012 ? 2017 Camry HV and Prius C, 2015 ? 2017 Prius V, 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, and 2016 ? 2017 RAV4 HV model year vehicles. ? Th

100001 HYBRID PROPULSION SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin POL17-04: Rev Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the ope

110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin POL17-04: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and then reverse to the open po

350000 EQUIPMENT

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Warranty Policy Bulletin POL17-04: REVISED March 01, 2017: Toyota has received reports of customer concerns in which the power back door does not close properly. In some cases, the power back door may reach the fully closed position and th

162300 STRUCTURE:BODY:DOOR

Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles.

162300 STRUCTURE:BODY:DOOR

Region Letter: Certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and th

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Dealer Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles.

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Dealer Package: Certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles may exhibit a condition where the Power Back Door does not close properly. In some cases, the Power Back Door may reach the fully closed position and t

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

350000 EQUIPMENT

Update on Technician Certification Requirements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update on Technician Certification Requirements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. HV BA

100001 HYBRID PROPULSION SYSTEM

110000 ELECTRICAL SYSTEM

100001 HYBRID PROPULSION SYSTEM

110000 ELECTRICAL SYSTEM

TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC.

350000 EQUIPMENT

TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC.

350000 EQUIPMENT

TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK.

110000 ELECTRICAL SYSTEM

TSB: THIS BULLETIN INCLUDES BASIC PROCEDURES FOR PERFORMING A RESCUE CHARGE ON NI-MH HIGH VOLTAGE (HV) BATTERIES. THIS BULLETIN SHOULD BE USED IN CONJUNCTION WITH THE REPAIR MANUAL WHILE PERFORMING RESCUE CHARGE. THE GRX-5100 SHOULD BE USED

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

110000 ELECTRICAL SYSTEM

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

060000 ENGINE (PWS)

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

350000 EQUIPMENT

TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

353000 EQUIPMENT:ELECTRICAL

162300 STRUCTURE:BODY:DOOR

TSB: Some 2008 - 2013 model year Highlander and Highlander HV vehicles may exhibit a condition where the Power Back Door does NOT close properly. The back door may get to the fully closed position and then reverse to the open position. In c

162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

353000 EQUIPMENT:ELECTRICAL

162300 STRUCTURE:BODY:DOOR