EXTERIOR LIGHTING:HEADLIGHTS
Defect Description
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES
... , AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.Read moreConsequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
42,540 vehicles affected
Manufacturer: DOPE, INC.
EXTERIOR LIGHTING
Defect Description
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES
... , AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.Read moreConsequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
16,270 vehicles affected
Manufacturer: SABERSPORT
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Defect Description
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FRONT SAFETY BELT BUCKLES MAY EMIT A "CLICK" SOUND DURING THE BUCKLING PROCESS THAT IS SIMILAR TO THE SOUND EMITTED WHEN A BUCKLE IS BEING LATCHED, WHEN IT IS NOT.
Consequence
THE LATCH CAN THEN PULL OUT OF THE BUCKLE WHEN TENSION IS APPLIED.
Remedy
DEALERS WILL REPLACE BOTH FRONT SEAT BELT BUCKLES. THE RECALL BEGAN AUGUST 16, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
251,594 vehicles affected
Manufacturer: KIA MOTORS AMERICA, INC.
ELECTRICAL SYSTEM
Defect Description
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLE. THESE VEHICLES WERE DISTRIBUTED WITH OWNERS MANUALS WITH AN INCORRECT JUMP START DIAGRAM. THE WRITTEN INSTRUCTIONS FOR JUMP STARTING ARE ACCURATE. HOWEVER, THE DIAGRAM DEPICTS THE JUMPER CABLES ATTACHED TO THE WRONG POLARITY TERMINALS. IF THE DIAGRAM
... WERE FOLLOWED WITHOUT REFERENCE TO THE INSTRUCTIONS, THE RESULTING IMPROPER CONNECTIONS COULD CAUSE THE BATTERY TO RUPTURE AGGRESSIVELY DUE TO INCREASED INTERNAL PRESSURES.Read moreConsequence
THIS COULD CAUSE POTENTIAL SERIOUS INJURY TO BYSTANDERS.
Remedy
OWNERS WILL BE PROVIDED WITH AN ADHESIVE LABEL WITH THE CORRECT ILLUSTRATION TO PERMANENTLY AFFIX TO THEIR RESPECTIVE OWNERS MANUALS.
66,482 vehicles affected
Manufacturer: KIA MOTORS AMERICA, INC.
Complaint Statistics
462 total complaints
27 crashes 8 fires 20 injuries
Top Reported Components
| Component | Complaints |
|---|
| FUEL SYSTEM, GASOLINE | 33 |
| FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | 22 |
| ELECTRICAL SYSTEM | 13 |
| VISIBILITY:POWER WINDOW DEVICES AND CONTROLS | 13 |
| SERVICE BRAKES, HYDRAULIC | 13 |
| FUEL/PROPULSION SYSTEM | 12 |
| STRUCTURE:FRAME AND MEMBERS | 12 |
| POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) | 12 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | 11 |
| UNKNOWN OR OTHER | 11 |
Incident date: Apr 4, 2020
FUEL TANK LEAKING GAS I BELIEVE THE FUEL TANK IS NO GOOD ANYMORE I PURCHASE A VEHICLE FILL UP THE TANK AND START TO LEAK GAS I THOUGHT IT WAS A GASKET SO GASKET WAS PLACED AND IT'S STILL LEAKING
Incident date: May 3, 2017
NOTICED A STRONG GAS SMELL, LOOKED UNDER CAR AND NOTICED GAS DRIPPING FROM UNDER CAR. UPON FURTHER LOOKING I NOTICED THE GAS TANK PROTECTIVE PLATE IS ROTTING OUT WHICH MAKES ME BELIEVE THE GAS TANK IS TOO.
Incident date: Feb 23, 2017
NO AIRBAG IN STEERING WHEEL, BRAKES GOES DOWN TO FLOOR, OXYGEN SENSOR BAD IN BANK ONE, POPPING IN TIRES. MY FRAME CAN BREAK FROM CAR AT ANY TIME, DEALER KNEW I HAD KIDS, WE COULD GET SERIOUSLY HURT RIDING IN THIS CAR.
Incident date: Feb 23, 2017
NO AIRBAG IN STEERING WHEEL, BRAKES GOES DOWN TO FLOOR, OXYGEN SENSOR BAD IN BANK ONE, POPPING IN TIRES. MY FRAME CAN BREAK FROM CAR AT ANY TIME, DEALER KNEW I HAD KIDS, WE COULD GET SERIOUSLY HURT RIDING IN THIS CAR.
Incident date: Feb 23, 2017
NO AIRBAG IN STEERING WHEEL, BRAKES GOES DOWN TO FLOOR, OXYGEN SENSOR BAD IN BANK ONE, POPPING IN TIRES. MY FRAME CAN BREAK FROM CAR AT ANY TIME, DEALER KNEW I HAD KIDS, WE COULD GET SERIOUSLY HURT RIDING IN THIS CAR.
Incident date: Nov 28, 2016
2000 KIA SPORTAGE RECALL - HYDRAULIC ELECTRONIC CONTROL UNIT
Incident date: May 3, 2016
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. WHILE DRIVING 35 MPH, THERE WAS A LOUD NOISE UNDER THE HOOD. THE CONTACT PARKED THE VEHICLE AND NOTICED WATER LEAKING FROM THE RADIATOR. THE FAN BLADE DETACHED AND WENT THROUGH THE RADIATOR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NO
... TIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,477.Read more
Incident date: Mar 7, 2015
2000 KIA SPORTAGE HEADLIGHTS GO OUT, RIGHT FRAME HAS A HUGE HOLE, MY CHILD IS AT RISK CAR NEEDS TO BE RECALLED ALSO LOCKS DON'T WORK, BATTERY DIES, SEATBELTS SUCK, RADIO GOES OFF ...
Incident date: Mar 7, 2015
2000 KIA SPORTAGE HEADLIGHTS GO OUT, RIGHT FRAME HAS A HUGE HOLE, MY CHILD IS AT RISK CAR NEEDS TO BE RECALLED ALSO LOCKS DON'T WORK, BATTERY DIES, SEATBELTS SUCK, RADIO GOES OFF ...
Incident date: Mar 7, 2015
2000 KIA SPORTAGE HEADLIGHTS GO OUT, RIGHT FRAME HAS A HUGE HOLE, MY CHILD IS AT RISK CAR NEEDS TO BE RECALLED ALSO LOCKS DON'T WORK, BATTERY DIES, SEATBELTS SUCK, RADIO GOES OFF ...
Incident date: Nov 1, 2009
FRAME RUSTED
Incident date: Oct 17, 2013
GAS TANK IS LEAKING GASOLINE. *TR
Incident date: Jul 22, 2014
FUEL TANK/PAN RUSTED OUT. STRONG GAS ODOR. RECALL FOUND ONLINE. NEITHER DEALER NOR KIA WOULD ACKNOWLEDGE. RECEIVING NUMEROUS MISFIRE MESSAGES AND HAVE CHANGED PLUGS, COILS, AND WIRES. MISFIRE CODE STATES FUEL/AIR RATIO IS WRONG. THERE IS NO HISS WHEN OPENING GAS CAP AND NO PRESSURE REGISTERING FROM
... TANK. SAFETY AND FIRE ISSUE. WAS WARNED NOT TO DRIVE UNTIL FIXED DUE TO GAS LEAKAGE. VERY UPSET AT KIA FOR TELLING ME THAT RECALL DID NOT APPLY TO MY 2000 SPORTAGE, HOWEVER SHE STATED IT WAS FOR 1996-2002 SPORTAGES. WAS INFORMED I COULD PAY $92/HOUR FOR IT TO BE INSPECTED BUT I WOULD BE RESPONSIBLE FOR ALL CHARGES. VERY DISTURBING, ESPECIALLY SINCE IT IS VEHICLE USED TO TRANSPORT MY FAMILY AND NOW I NO LONGER FEEL SAFE. *TRRead more
Incident date: Mar 12, 2014
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, HE FOUND THAT THE FUEL TANK AND FUEL GUARD WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 179,000.
Incident date: Feb 13, 2014
THE STRUCTURE IS ROTTEN AND UNSAFE TO DRIVE. I HAVE SEEN MANY REPORTS OF THIS AND CANNOT BELIEVE THAT IT HAS NOT BEEN RECALLED. *TR
Incident date: Feb 13, 2014
THE STRUCTURE IS ROTTEN AND UNSAFE TO DRIVE. I HAVE SEEN MANY REPORTS OF THIS AND CANNOT BELIEVE THAT IT HAS NOT BEEN RECALLED. *TR
Incident date: Dec 31, 2013
THE FUEL TANK IS LEAKING. I NEED TO HAVE KIA TO REPLACE THIS TANK. IT IS VERY DANGEROUS FOR ME TO KEEP DRIVING. I HAVE CHILDREN AND I AM CONCERN FOR THEIR SAFETY AS WELL AS MY OWN. *TR
Incident date: Sep 23, 2013
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 101,066.
Incident date: Jul 15, 2013
BRAKES FAILED DUE TO RUSTED FRONT BRAKE LINES. WHILE VEHICLE WAS ON THE LIFT THE FRAME WAS FOUND TO BE COMPLETELY RUSTED THRU IN MANY PLACES MAKING THE VEHICLE UNSAFE TO DRIVE. *TR
Incident date: Apr 12, 2013
ON APRIL 12, 2013 I GOT INTO MY 2000 KIA SPORTAGE TO GO TO WORK. AS SOON AS I GOT INTO THE CAR I HIT THE WINDSHIELD WIPERS TO GET THE DEW OFF OF THE WINDSHIELD AND INSTEAD OF JUST GOING ONCE THEY WENT OFF EXTREMELY FAST WITH OUT STOPPING FOR ABOUT 45 SECONDS. ONCE I GOT THEM TURNED OFF I WENT UP THE
... ROAD AND TURNED TO HEAD TO WORK VIA THE BACK ROADS. I DROVE ABOUT 1 MILES WHEN OUT OF THE BLUE MY WINDSHIELD WIPERS STARTED GOING OFF AGAIN THEN A SECOND LATER I HEARD A LOUD BANG AND 2 OF MY AIRBAGS HAD DEPLOYED AND I FELT A THROBBING PAIN IN MY RIGHT SHIN. THE PASSENGER AIRBAG AND THE LOWER AIRBAG ON THE DRIVER SIDE DEPLOYED. MY CAR WAS THE ONLY CAR INVOLVED AND HAS A CLEAR CARFAX. THE ROAD I WAS DRIVING ON WAS SMOOTH AND I DID NOT HIT ANYTHING. THE CAR HAD TO BE TOWED BACK TO MY HOUSE WHERE IT SITS. *TRRead more
Crash
1 injured
Incident date: Apr 12, 2013
ON APRIL 12, 2013 I GOT INTO MY 2000 KIA SPORTAGE TO GO TO WORK. AS SOON AS I GOT INTO THE CAR I HIT THE WINDSHIELD WIPERS TO GET THE DEW OFF OF THE WINDSHIELD AND INSTEAD OF JUST GOING ONCE THEY WENT OFF EXTREMELY FAST WITH OUT STOPPING FOR ABOUT 45 SECONDS. ONCE I GOT THEM TURNED OFF I WENT UP THE
... ROAD AND TURNED TO HEAD TO WORK VIA THE BACK ROADS. I DROVE ABOUT 1 MILES WHEN OUT OF THE BLUE MY WINDSHIELD WIPERS STARTED GOING OFF AGAIN THEN A SECOND LATER I HEARD A LOUD BANG AND 2 OF MY AIRBAGS HAD DEPLOYED AND I FELT A THROBBING PAIN IN MY RIGHT SHIN. THE PASSENGER AIRBAG AND THE LOWER AIRBAG ON THE DRIVER SIDE DEPLOYED. MY CAR WAS THE ONLY CAR INVOLVED AND HAS A CLEAR CARFAX. THE ROAD I WAS DRIVING ON WAS SMOOTH AND I DID NOT HIT ANYTHING. THE CAR HAD TO BE TOWED BACK TO MY HOUSE WHERE IT SITS. *TRRead more
Crash
1 injured
Incident date: Apr 1, 2013
THE GAS TANK SHIELD IS RUSTING TO PIECES. NOTICED A PIECE HANGING DOWN AND CHECKED UNDER THE CAR. IT IS ON THE RIGHT SIDE. *TR
Incident date: Apr 5, 2013
THE CAR HAD NOT BEEN DRIVEN IN 2 DAYS. MY DAUGHTER STARTED THE CAR, DROVE IT ABOUT 1/4 - 1/2 MILE WHEN SHE NOTICED SMOKE COMING FROM THE CONSOLE ON THE PASSENGER SIDE. SHE PARKED THE VEHICLE, GOT OUT AND RAN TO THE PASSENGER SIDE TO SEE IF SHE COULD TELL WHERE THE SMOKE WAS COMING FROM AND COULD S
... EE FIRE THROUGH THE CRACK IN THE CONSOLE WHERE THE COVER OVER THE CONSOLE WAS JOINED TOGETHER. WITHIN SECONDS, THE ENTIRE INSIDE OF THE VEHICLE WAS ENGULFED IN FLAMES, WHICH LEADS ME TO BELIEVE THAT THERE MAY HAVE BEEN A GASOLINE LEAK. SHE WAS IN A RESIDENTIAL NEIGHBORHOOD WITH VERY LITTLE TRAFFIC. HAD SHE BEEN ON THE HIGHWAY OR IN TRAFFIC, THIS WOULD HAVE BEEN A VERY DIFFERENT SCENARIO. SHE AND OTHERS WOULD HAVE BEEN HURT OR WORSE. HER POCKETBOOK HAD FALLEN ON THE FLOOR AND SHE REACHED OVER TO PICK IT UP AND THAT IS WHEN SHE SAW THE SMOKE. SHE HAD TIME TO GET OUT BEFORE THE CAR IMPLODED. THE ENTIRE INTERIOR OF THE CAR WAS GUTTED AND THE PAINT WAS BURNED OFF THE DRIVERS SIDE AND ROOF OF THE CAR. ALL THAT IS LEFT OF THE INSIDE IS SOOT, METAL AND CHARCOAL FROM FRONT TO REAR. WE BOUGHT THE CAR FROM A DEALER ON DECEMBER 21, 2012. IT RAN GREAT, WAS IN GOOD SHAPE AND WE HAD NO PROBLEMS OR WARNING SIGNS PRIOR TO THIS INCIDENT. I AM GOING TO NOTIFY KIA, BUT AM NOT VERY HOPEFUL OF ANY RESOLUTION WITHOUT SOME INTERVENTION FROM NHTSA. *TRRead more
Fire
Incident date: Apr 5, 2013
THE CAR HAD NOT BEEN DRIVEN IN 2 DAYS. MY DAUGHTER STARTED THE CAR, DROVE IT ABOUT 1/4 - 1/2 MILE WHEN SHE NOTICED SMOKE COMING FROM THE CONSOLE ON THE PASSENGER SIDE. SHE PARKED THE VEHICLE, GOT OUT AND RAN TO THE PASSENGER SIDE TO SEE IF SHE COULD TELL WHERE THE SMOKE WAS COMING FROM AND COULD S
... EE FIRE THROUGH THE CRACK IN THE CONSOLE WHERE THE COVER OVER THE CONSOLE WAS JOINED TOGETHER. WITHIN SECONDS, THE ENTIRE INSIDE OF THE VEHICLE WAS ENGULFED IN FLAMES, WHICH LEADS ME TO BELIEVE THAT THERE MAY HAVE BEEN A GASOLINE LEAK. SHE WAS IN A RESIDENTIAL NEIGHBORHOOD WITH VERY LITTLE TRAFFIC. HAD SHE BEEN ON THE HIGHWAY OR IN TRAFFIC, THIS WOULD HAVE BEEN A VERY DIFFERENT SCENARIO. SHE AND OTHERS WOULD HAVE BEEN HURT OR WORSE. HER POCKETBOOK HAD FALLEN ON THE FLOOR AND SHE REACHED OVER TO PICK IT UP AND THAT IS WHEN SHE SAW THE SMOKE. SHE HAD TIME TO GET OUT BEFORE THE CAR IMPLODED. THE ENTIRE INTERIOR OF THE CAR WAS GUTTED AND THE PAINT WAS BURNED OFF THE DRIVERS SIDE AND ROOF OF THE CAR. ALL THAT IS LEFT OF THE INSIDE IS SOOT, METAL AND CHARCOAL FROM FRONT TO REAR. WE BOUGHT THE CAR FROM A DEALER ON DECEMBER 21, 2012. IT RAN GREAT, WAS IN GOOD SHAPE AND WE HAD NO PROBLEMS OR WARNING SIGNS PRIOR TO THIS INCIDENT. I AM GOING TO NOTIFY KIA, BUT AM NOT VERY HOPEFUL OF ANY RESOLUTION WITHOUT SOME INTERVENTION FROM NHTSA. *TRRead more
Fire
Incident date: Sep 7, 2012
THE CHASSIS, AND THE AUTO BODY FOR THIS PARTICULAR VEHICLE IS NOT SAFE DETERIORIZE AND COMPLETE HODEN I JUST TALK THE CAR TO THE MECHANIC WHEN WAS FIND OUT. WE BELIEVE THAT IS MANUFACTURE PROBLEMS. *TR
Incident date: Sep 7, 2012
THE CHASSIS, AND THE AUTO BODY FOR THIS PARTICULAR VEHICLE IS NOT SAFE DETERIORIZE AND COMPLETE HODEN I JUST TALK THE CAR TO THE MECHANIC WHEN WAS FIND OUT. WE BELIEVE THAT IS MANUFACTURE PROBLEMS. *TR
Incident date: Sep 7, 2012
THE CHASSIS, AND THE AUTO BODY FOR THIS PARTICULAR VEHICLE IS NOT SAFE DETERIORIZE AND COMPLETE HODEN I JUST TALK THE CAR TO THE MECHANIC WHEN WAS FIND OUT. WE BELIEVE THAT IS MANUFACTURE PROBLEMS. *TR
Incident date: Nov 17, 2012
I TOOK MY VEHICLE TO A SHOP TO GET THE OIL CHANGED AND THEY NOTICED THAT THE DRIVER SIDE REAR OF THE FRAME IS SEVERELY RUSTED OUT AND NEEDS REPLACEMENT. ALSO THE FUEL TANK IS LEAKING AT ONE OF THE SEAMS IN THE CORNER OF THE TANK. I HAVE BEEN TOLD BY PEOPLE IN THE AUTO INDUSTRY THAT THIS IS A COMMON
... PROBLEM WITH THE KIA SPORTAGE. I HAVE ALSO SEEN NUMEROUS REPORTS ON THE INTERNET AS WELL. IT'S ONLY A 12 YEAR OLD VEHICLE. I HAVE HAD PLENTY OF OTHER VEHICLES MUCH OLDER WITHOUT ALL OF THIS KIND OF RUST ISSUE. THIS IS RIDICULOUS. OBVIOUSLY THERE IS SOME KIND OF DEFECT WITH THE MATERIALS BEING USED. I SURELY HOPE THE NHTSA WILL MAKE KIA MOTORS RECALL THESE VEHICLES. BECAUSE IT IS A MAJOR SAFETY HAZARD. *TRRead more
Incident date: Nov 17, 2012
I TOOK MY VEHICLE TO A SHOP TO GET THE OIL CHANGED AND THEY NOTICED THAT THE DRIVER SIDE REAR OF THE FRAME IS SEVERELY RUSTED OUT AND NEEDS REPLACEMENT. ALSO THE FUEL TANK IS LEAKING AT ONE OF THE SEAMS IN THE CORNER OF THE TANK. I HAVE BEEN TOLD BY PEOPLE IN THE AUTO INDUSTRY THAT THIS IS A COMMON
... PROBLEM WITH THE KIA SPORTAGE. I HAVE ALSO SEEN NUMEROUS REPORTS ON THE INTERNET AS WELL. IT'S ONLY A 12 YEAR OLD VEHICLE. I HAVE HAD PLENTY OF OTHER VEHICLES MUCH OLDER WITHOUT ALL OF THIS KIND OF RUST ISSUE. THIS IS RIDICULOUS. OBVIOUSLY THERE IS SOME KIND OF DEFECT WITH THE MATERIALS BEING USED. I SURELY HOPE THE NHTSA WILL MAKE KIA MOTORS RECALL THESE VEHICLES. BECAUSE IT IS A MAJOR SAFETY HAZARD. *TRRead more
Incident date: Jul 27, 2012
(1) NOTICED THAT THE FUEL TANK SHIELD IS SEVERELY ROTTED OUT AND IS BARELY CONNECTED. (2) SMELL FUEL VAPORS PERIODICALLY WHILE IN THE VEHICLE. (3) FUEL TANK APPEARS TO BE RUSTING, AFRAID TO MESS WITH TANK IN FEAR OF DISTURBING THE RUST AND RUPTURING A HOLE IN TANK. (4) BRAKE LINES WERE SO S
... EVERELY RUSTED IN ONE AREA THAT IT BLEW A HOLE IN THE LINE AND PREVENTED THE VEHICLE FROM STOPPING AND REQUIRED THE PROMPT ACTION FOR REPAIR. OTHER BRAKE LINES LOOK LIKE THEY MAY FAIL IN NEAR FUTURE. (5) STEEL PORTION OF POWER STEERING LINE RUSTED OUT AND BLEW FLUID EVERYWHERE PREVENTING THE ABILITY TO TURN THE WHEEL WHILE DRIVING. (6) THE FRAME HAS HEAVY RUST SCALE AND APPEARS TO BE ROTTING IN SEVERAL PLACE. (7) PAINT IS STARTING TO BUBBLE WHICH IS INDICATING BODY IS RUSTING UNDER PAINT JOB. THIS IS A 12 YEAR OLD VEHICLE WITH VERY BAD ROTTING OF METAL FROM SALT CORROSION. HAVE NEVER SEEN THIS MUCH RUST ON 20+ OLD VEHICLES THAT ARE IN THE SAME NORTHERN REGIONS OF THE US. *TRRead more
Incident date: Jul 27, 2012
(1) NOTICED THAT THE FUEL TANK SHIELD IS SEVERELY ROTTED OUT AND IS BARELY CONNECTED. (2) SMELL FUEL VAPORS PERIODICALLY WHILE IN THE VEHICLE. (3) FUEL TANK APPEARS TO BE RUSTING, AFRAID TO MESS WITH TANK IN FEAR OF DISTURBING THE RUST AND RUPTURING A HOLE IN TANK. (4) BRAKE LINES WERE SO S
... EVERELY RUSTED IN ONE AREA THAT IT BLEW A HOLE IN THE LINE AND PREVENTED THE VEHICLE FROM STOPPING AND REQUIRED THE PROMPT ACTION FOR REPAIR. OTHER BRAKE LINES LOOK LIKE THEY MAY FAIL IN NEAR FUTURE. (5) STEEL PORTION OF POWER STEERING LINE RUSTED OUT AND BLEW FLUID EVERYWHERE PREVENTING THE ABILITY TO TURN THE WHEEL WHILE DRIVING. (6) THE FRAME HAS HEAVY RUST SCALE AND APPEARS TO BE ROTTING IN SEVERAL PLACE. (7) PAINT IS STARTING TO BUBBLE WHICH IS INDICATING BODY IS RUSTING UNDER PAINT JOB. THIS IS A 12 YEAR OLD VEHICLE WITH VERY BAD ROTTING OF METAL FROM SALT CORROSION. HAVE NEVER SEEN THIS MUCH RUST ON 20+ OLD VEHICLES THAT ARE IN THE SAME NORTHERN REGIONS OF THE US. *TRRead more
Incident date: Jul 27, 2012
(1) NOTICED THAT THE FUEL TANK SHIELD IS SEVERELY ROTTED OUT AND IS BARELY CONNECTED. (2) SMELL FUEL VAPORS PERIODICALLY WHILE IN THE VEHICLE. (3) FUEL TANK APPEARS TO BE RUSTING, AFRAID TO MESS WITH TANK IN FEAR OF DISTURBING THE RUST AND RUPTURING A HOLE IN TANK. (4) BRAKE LINES WERE SO S
... EVERELY RUSTED IN ONE AREA THAT IT BLEW A HOLE IN THE LINE AND PREVENTED THE VEHICLE FROM STOPPING AND REQUIRED THE PROMPT ACTION FOR REPAIR. OTHER BRAKE LINES LOOK LIKE THEY MAY FAIL IN NEAR FUTURE. (5) STEEL PORTION OF POWER STEERING LINE RUSTED OUT AND BLEW FLUID EVERYWHERE PREVENTING THE ABILITY TO TURN THE WHEEL WHILE DRIVING. (6) THE FRAME HAS HEAVY RUST SCALE AND APPEARS TO BE ROTTING IN SEVERAL PLACE. (7) PAINT IS STARTING TO BUBBLE WHICH IS INDICATING BODY IS RUSTING UNDER PAINT JOB. THIS IS A 12 YEAR OLD VEHICLE WITH VERY BAD ROTTING OF METAL FROM SALT CORROSION. HAVE NEVER SEEN THIS MUCH RUST ON 20+ OLD VEHICLES THAT ARE IN THE SAME NORTHERN REGIONS OF THE US. *TRRead more
Incident date: Jul 27, 2012
(1) NOTICED THAT THE FUEL TANK SHIELD IS SEVERELY ROTTED OUT AND IS BARELY CONNECTED. (2) SMELL FUEL VAPORS PERIODICALLY WHILE IN THE VEHICLE. (3) FUEL TANK APPEARS TO BE RUSTING, AFRAID TO MESS WITH TANK IN FEAR OF DISTURBING THE RUST AND RUPTURING A HOLE IN TANK. (4) BRAKE LINES WERE SO S
... EVERELY RUSTED IN ONE AREA THAT IT BLEW A HOLE IN THE LINE AND PREVENTED THE VEHICLE FROM STOPPING AND REQUIRED THE PROMPT ACTION FOR REPAIR. OTHER BRAKE LINES LOOK LIKE THEY MAY FAIL IN NEAR FUTURE. (5) STEEL PORTION OF POWER STEERING LINE RUSTED OUT AND BLEW FLUID EVERYWHERE PREVENTING THE ABILITY TO TURN THE WHEEL WHILE DRIVING. (6) THE FRAME HAS HEAVY RUST SCALE AND APPEARS TO BE ROTTING IN SEVERAL PLACE. (7) PAINT IS STARTING TO BUBBLE WHICH IS INDICATING BODY IS RUSTING UNDER PAINT JOB. THIS IS A 12 YEAR OLD VEHICLE WITH VERY BAD ROTTING OF METAL FROM SALT CORROSION. HAVE NEVER SEEN THIS MUCH RUST ON 20+ OLD VEHICLES THAT ARE IN THE SAME NORTHERN REGIONS OF THE US. *TRRead more
Incident date: Jul 27, 2012
(1) NOTICED THAT THE FUEL TANK SHIELD IS SEVERELY ROTTED OUT AND IS BARELY CONNECTED. (2) SMELL FUEL VAPORS PERIODICALLY WHILE IN THE VEHICLE. (3) FUEL TANK APPEARS TO BE RUSTING, AFRAID TO MESS WITH TANK IN FEAR OF DISTURBING THE RUST AND RUPTURING A HOLE IN TANK. (4) BRAKE LINES WERE SO S
... EVERELY RUSTED IN ONE AREA THAT IT BLEW A HOLE IN THE LINE AND PREVENTED THE VEHICLE FROM STOPPING AND REQUIRED THE PROMPT ACTION FOR REPAIR. OTHER BRAKE LINES LOOK LIKE THEY MAY FAIL IN NEAR FUTURE. (5) STEEL PORTION OF POWER STEERING LINE RUSTED OUT AND BLEW FLUID EVERYWHERE PREVENTING THE ABILITY TO TURN THE WHEEL WHILE DRIVING. (6) THE FRAME HAS HEAVY RUST SCALE AND APPEARS TO BE ROTTING IN SEVERAL PLACE. (7) PAINT IS STARTING TO BUBBLE WHICH IS INDICATING BODY IS RUSTING UNDER PAINT JOB. THIS IS A 12 YEAR OLD VEHICLE WITH VERY BAD ROTTING OF METAL FROM SALT CORROSION. HAVE NEVER SEEN THIS MUCH RUST ON 20+ OLD VEHICLES THAT ARE IN THE SAME NORTHERN REGIONS OF THE US. *TRRead more
Incident date: Sep 1, 2012
THE FRAME WHERE THE REAR STABILIZER ARM CONNECTS HAS COMPLETELY RUSTED ALLOWING THE ARM TO FALL AWAY. THE ONLY THING SUPPORTING THE ARM NOW APPEARS TO BE THE FUEL LINE WHICH IS ATTACHED TO IT. THE REST OF THE FRAME IS RUSTED OUT AS WELL. THERE IS NOT ENOUGH METAL LEFT TO WELD OR REPAIR. HAD THE ARM
... BROKEN THE FUEL LINE AND SPARKED WHEN IT DRAGGED ON THE ROAD, THIS PROBLEM COULD HAVE TURNED DEADLY. THIS IS A VERY SERIOUS PROBLEM FOR A VEHICLE WITH ONLY TWELVE YEARS AND 84K MILES ON THE ROAD. *TRRead more
Incident date: Sep 1, 2012
THE FRAME WHERE THE REAR STABILIZER ARM CONNECTS HAS COMPLETELY RUSTED ALLOWING THE ARM TO FALL AWAY. THE ONLY THING SUPPORTING THE ARM NOW APPEARS TO BE THE FUEL LINE WHICH IS ATTACHED TO IT. THE REST OF THE FRAME IS RUSTED OUT AS WELL. THERE IS NOT ENOUGH METAL LEFT TO WELD OR REPAIR. HAD THE ARM
... BROKEN THE FUEL LINE AND SPARKED WHEN IT DRAGGED ON THE ROAD, THIS PROBLEM COULD HAVE TURNED DEADLY. THIS IS A VERY SERIOUS PROBLEM FOR A VEHICLE WITH ONLY TWELVE YEARS AND 84K MILES ON THE ROAD. *TRRead more
Incident date: Sep 5, 2012
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR MUFFLER REPAIRS WHEN THE MECHANIC ADVISED HER THAT THE UNDERCARRIAGE OF THE FRAME WAS RUSTING. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY, PROVIDING NO ADDITIONAL
... ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGE WAS 80,048.Read more
Incident date: Aug 20, 2012
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT STATED THAT THE FUEL TANK WAS CORRODED CAUSING A FUEL LEAK . THE CONTACT MENTIONED THAT FUEL FUMES WERE EMITTED AROUND THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO VERIFIED THAT THE FUEL TANK WAS IN FACT CORRODED AND CAUSED T
... HE FUEL LEAK. AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 101,835.Read more
Incident date: Jun 13, 2012
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. WHILE PARKED, THE CONTACT NOTICED AN OVERPOWERING FUEL SMELL. THE CONTACT INSPECTED THE VEHICLE AND NOTICED A FUEL LEAK COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THAT THE FUEL TANK WOULD HAVE TO
... BE REPLACED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE.THE APPROXIMATE FAILURE MILEAGE WAS 100,000.Read more
Incident date: Jun 15, 2012
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT STATED THAT HE WAS NOTIFIED BY A CONCERNED CITIZEN THAT HIS VEHICLE WAS LEAKING FUEL. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THAT THERE WAS A PUDDLE OF FUEL UNDERNEATH. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS, BUT WAS INFORMED T
... HAT THE FAILURE WAS NOT A DEFECT AND THAT THE VEHICLE WAS JUST OLD. THE VEHICLE WAS NOT ABLE TO BE PARKED ON RENTAL PROPERTY DUE TO THE HAZARD AND POTENTIAL FOR A FIRE. THE FUEL FUMES ALSO MADE THE DRIVER FEEL DIZZY, CONTRIBUTING TO UNSAFE DRIVING. THE FAILURE AND CURRENT MILEAGES WERE 120,000. THE VIN WAS UNAVAILABLE.Read more
Incident date: Feb 27, 2012
THE STEERING GEAR SECTOR SHAFT HAD BROKEN ENTIRELY THROUGH.THE WHEEL AND INNER AND OUTER STEERING TIE RODS DID NOT SUFFER SIGNIFICANT IMPACT. WHEEL AND STEERING TIE RODS DO NOT APPEAR TO BE BENT. FRONT SUSPENSION COMPONENTS DO NOT APPEAR TO HAVE PHYSICAL DAMAGE. IT IS UNCOMMON FOR THE STEERING GEAR
... SECTOR SHAFT TO BREAK AND MAY INDICATE POSSIBLE FLAW IN THE MECHANICAL COMPONENT. EVIDENCE SUPPORTS POSSIBLE FLAW AND POTENTIAL SAFETY ISSUE. *TRRead more
Crash
Incident date: Feb 9, 2010
I NOTICE THERE WAS SOMETHING GOING ON WITH THE WAY I WAS TURNING THE WHEEL OF MY CAR I TOOK IT TO MY GARAGE AND MY MECHANIC TOLD ME TO TAKE THE CAR HOME AND CALL KIA THE PERSON THAT MADE CAR STATED THE WHOLE FRAME WAS ROTTEN OUT AND CRACK IT COULD NOT BE REPAIRED THE CAR SHOULD OF NOT BEEN ON THE RO
... AD WHEN SPOKE TO KIA THEY STATED I NEEDED TO BRING THE CAR TO THE SERVICE CENTER TO LOOK AT IT TOLD THEM THE SAME THING THAT MY GARAGE TOLD THEM THAT THE FRAME WAS CRACK AND WAS UNSAFE TO DRIVE KIA CORP MADE ME PAID THEM $100 DOLLARS TO LOOK AT IT AND THERE MECHANIC DID NOT WANT TO PUT IT ON LIFT BECAUSE HE FELT THAT IS WAS GOING TO FALL APART HE EVEN ADVISE ME NOT TO DRIVE THE CAR OUT THEY SAID THEY COULD DO NOTHING ABOUT IT BECAUSE THE CAR HAD OVER 100,000 HUNDRED THOUSAND MILES ON IT. THIS VEHICLE IS ONLY 10 YRS OLD WHEN THIS HAPPEN I FEEL THAT THIS KIA PROBLEM MY FRIEND ALSO HAS KIA SPORTAGE AND THE SAME THING HAPPEN TO HIS CAR IS THAT WHY KIA IS SO CHEAP ON THERE MOTORS FOR SALE BECAUSE OF THE PARTS THAT THEY SELL. *KBRead more
Incident date: Jan 3, 2012
I TOOK MY 2000 KIA SPORTAGE IN TO MY MECHANIC TO HAVE THE BRAKES REDONE. AS HE WAS OUT TESTING TO MAKE SURE THE BRAKES WORKED HE NOTICED THAT THE REAR END WAS MOVING AROUND QUITE A BIT. HE TAKES IT BACK TO THE SHOP TO LOOK UP UNDERNEATH AND NOTICED THAT THE CHASSIS WAS RUSTED AWAY SO BAD THAT THERE
... WAS S FIST SIZED HOLE IN IT. HE TOLD ME THIS NEEDED TO BE FIXED ASAP! THIS IS A SERIOUS CONCERN NOT ONLY FOR ME BUT FOR EVERYONE ELSE WHO OWNS THE VEHICLE. ITS A SCARY THOUGHT TO KNOW THAT AT ANY GIVEN TIME MY CHASSIS CAN LITERALLY FALL APART ON ME. WE NEED THIS TO BE RECALLED DUE TO THE AMOUNT OF COMPLAINTS THAT IT ALREADY AS AND THE EXTREMELY POOR DESIGN OF THIS CHASSIS. *TRRead more
Incident date: Oct 24, 2011
SOME OF THE MAJOR PROBLEMS INCLUDE THE FOLLOWING;FUEL TANK LEAK, HEAVY RUST, FRAME RUSTED OUT. TOOK IT TO A KIA DEALERSHIP & WAS TOLD I NEEDED TO HAVE THE FUEL PUMP, TANK&SENSOR REPLACED. PER THE ADVISOR AT THE KIA DEALERSHIP, MY CAR DID PASS INSPECTION IN REGARDS TO THE"EXTENDED WARRANTY"ON THE FUE
... L TANK.I WAS CHARGED APPROX.$800 FOR THE REPAIRS DUE TO IT BEING ONLY 1 YR PAST THE TIME FOR KIA TO COVER THE REPAIR.I AM UNDER THE MILEAGE.THE KIA DEALERSHIP GAVE ME A LIST OF ADDITIONAL REPAIRS NEEDED. ONE OF THEM BEING"FRAME RUSTED OUT IN REAR REQUIRES IMMEDIATE ATTENTION"THEY DID NO EXPLAIN ANY OF THIS TO ME! MY CAR STARTED TO JERK&SHAKE WHILE SLOWLY STEPPING ON THE BRAKES AS I PREPARED TO STOP AT A RED LIGHT,IT WAS DIFFICULT TO BRING THE CAR TO A COMPLETE STOP:'( IT MADE A LOUD NOISE AS IF SOMETHING HAD FALLEN OF MY CAR. PER THE MECHANIC THAT I HAD TO GET MY CAR TOWED TO, I NEED TO FIND A GOOD WELDER TO REPAIR ALL OF THIS RUST ASAP. HE STATED THAT THIS IS VERY UNSAFE AND THIS CAUSES ME TO HAVE NO CONTROL OF MY CAR. THE KIA DEALERSHIP SOLD ME $800 WORTH OF WORK WHILE KNOWING/NOT TELLING ME THAT MY CAR WAS UNSAFE TO DRIVE:( WHO DOES THAT?! I HAVE HAD SO MANY PROBLEMS WITH THIS CAR:( I DIDN'T LIST ALL OF THEM. FROM LITTLE THINGS TO MAJOR. I FEEL SO UNSAFE DRIVING IT. I ONLY WISH THAT PEOPLE TRULY CARED & TRIED TO PICTURE HOW THEY WOULD FEEL IF THIS HAD HAPPENED TO THEM OR THEIR FAMILY/FRIENDS. I AM CURRENTLY LAID OFF AND SEARCHING FOR WORK . I HAVE BEEN LAID OFF 2X WITHIN THE PAST 2 YRS, FIRST TIME WAS RIGHT AFTER I PURCHASED MY CONDO. I'M TRYING TO TELL MYSELF TO JUST BREATHE AND KEEP THE FAITH. IT IS GOING TO BE A MUCH MORE DIFFICULT ROAD TO FACE NOW WITHOUT A CAR:'( I TRIED TO EXPLAIN MY SITUATION,SAFETY/CONCERN ISSUES AND HARDSHIP TO KIA CUSTOMER CARE, BUT THEY WILL NOT HELP WITH ANYTHING NOR WILL THE DEALERSHIP. TOYOTA STEPPED UP, WHAT WILL IT TAKE FOR KIA TO?? *TRRead more
Incident date: Oct 24, 2011
SOME OF THE MAJOR PROBLEMS INCLUDE THE FOLLOWING;FUEL TANK LEAK, HEAVY RUST, FRAME RUSTED OUT. TOOK IT TO A KIA DEALERSHIP & WAS TOLD I NEEDED TO HAVE THE FUEL PUMP, TANK&SENSOR REPLACED. PER THE ADVISOR AT THE KIA DEALERSHIP, MY CAR DID PASS INSPECTION IN REGARDS TO THE"EXTENDED WARRANTY"ON THE FUE
... L TANK.I WAS CHARGED APPROX.$800 FOR THE REPAIRS DUE TO IT BEING ONLY 1 YR PAST THE TIME FOR KIA TO COVER THE REPAIR.I AM UNDER THE MILEAGE.THE KIA DEALERSHIP GAVE ME A LIST OF ADDITIONAL REPAIRS NEEDED. ONE OF THEM BEING"FRAME RUSTED OUT IN REAR REQUIRES IMMEDIATE ATTENTION"THEY DID NO EXPLAIN ANY OF THIS TO ME! MY CAR STARTED TO JERK&SHAKE WHILE SLOWLY STEPPING ON THE BRAKES AS I PREPARED TO STOP AT A RED LIGHT,IT WAS DIFFICULT TO BRING THE CAR TO A COMPLETE STOP:'( IT MADE A LOUD NOISE AS IF SOMETHING HAD FALLEN OF MY CAR. PER THE MECHANIC THAT I HAD TO GET MY CAR TOWED TO, I NEED TO FIND A GOOD WELDER TO REPAIR ALL OF THIS RUST ASAP. HE STATED THAT THIS IS VERY UNSAFE AND THIS CAUSES ME TO HAVE NO CONTROL OF MY CAR. THE KIA DEALERSHIP SOLD ME $800 WORTH OF WORK WHILE KNOWING/NOT TELLING ME THAT MY CAR WAS UNSAFE TO DRIVE:( WHO DOES THAT?! I HAVE HAD SO MANY PROBLEMS WITH THIS CAR:( I DIDN'T LIST ALL OF THEM. FROM LITTLE THINGS TO MAJOR. I FEEL SO UNSAFE DRIVING IT. I ONLY WISH THAT PEOPLE TRULY CARED & TRIED TO PICTURE HOW THEY WOULD FEEL IF THIS HAD HAPPENED TO THEM OR THEIR FAMILY/FRIENDS. I AM CURRENTLY LAID OFF AND SEARCHING FOR WORK . I HAVE BEEN LAID OFF 2X WITHIN THE PAST 2 YRS, FIRST TIME WAS RIGHT AFTER I PURCHASED MY CONDO. I'M TRYING TO TELL MYSELF TO JUST BREATHE AND KEEP THE FAITH. IT IS GOING TO BE A MUCH MORE DIFFICULT ROAD TO FACE NOW WITHOUT A CAR:'( I TRIED TO EXPLAIN MY SITUATION,SAFETY/CONCERN ISSUES AND HARDSHIP TO KIA CUSTOMER CARE, BUT THEY WILL NOT HELP WITH ANYTHING NOR WILL THE DEALERSHIP. TOYOTA STEPPED UP, WHAT WILL IT TAKE FOR KIA TO?? *TRRead more
Incident date: Jul 11, 2011
I OWN A 2000 KIA SPORTAGE AND I HAVE BEEN SMELLING GAS OVER THE LAST COUPLE OF MONTHS. THE DEALERSHIP IS TELLING ME THAT MY CAR IS NOT ON THE RECALL LIST, DO YOU HAVE ANY SUGGESTIONS? *TT
Incident date: Jul 1, 2011
BRAKES NOT WORKING PROPERLY.,WHEN YOU STEP ON BRAKE YOU CAN FEEL THE BRAKE OR TIRE SPENDING AND YOUR CAR IS STILL ROLLING WHEN YOUR ARE STEPPING ON THE BRAKE. ENGINE, TURNING THE CAR ENGINE ON AND OFF. WHEN YOU START THE ENGINE THE ENGINES CLICKS BUT DOES NOT START. ITS NOT THE TRANSMISSION. I H
... AVE REPLACED THE BATTERY SEVERAL TIMES BUT STILL THE SAME PROBLEM. *TRRead more
Incident date: Jul 1, 2011
BRAKES NOT WORKING PROPERLY.,WHEN YOU STEP ON BRAKE YOU CAN FEEL THE BRAKE OR TIRE SPENDING AND YOUR CAR IS STILL ROLLING WHEN YOUR ARE STEPPING ON THE BRAKE. ENGINE, TURNING THE CAR ENGINE ON AND OFF. WHEN YOU START THE ENGINE THE ENGINES CLICKS BUT DOES NOT START. ITS NOT THE TRANSMISSION. I H
... AVE REPLACED THE BATTERY SEVERAL TIMES BUT STILL THE SAME PROBLEM. *TRRead more
Incident date: Jul 1, 2011
BRAKES NOT WORKING PROPERLY.,WHEN YOU STEP ON BRAKE YOU CAN FEEL THE BRAKE OR TIRE SPENDING AND YOUR CAR IS STILL ROLLING WHEN YOUR ARE STEPPING ON THE BRAKE. ENGINE, TURNING THE CAR ENGINE ON AND OFF. WHEN YOU START THE ENGINE THE ENGINES CLICKS BUT DOES NOT START. ITS NOT THE TRANSMISSION. I H
... AVE REPLACED THE BATTERY SEVERAL TIMES BUT STILL THE SAME PROBLEM. *TRRead more
Incident date: Jul 12, 2011
TL* THE CONTACT OWNS A 2000 KIA SPORTAGE. THE CONTACT SMELLED A GASOLINE ODOR AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC ADVISED HER THAT THERE WERE HOLES IN HER FUEL TANK AND THAT IT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE
... WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS APPROXIMATELY 130,000. UPDATED 10/19/11 *BF THE CONSUMER STATED THE FUEL PUMP IS LEAKING GAS. THE CONSUMER FOUND A RECALL FOR THE EXACT PROBLEM. HOWEVER, AFTER HAVING THE VEHICLE FOR SEVERAL HOURS, THE DEALER INFORMED THE CONSUMER HE WAS OVER THE MILEAGE OR WARRANTY FOR A FREE REPAIR. UPDATED 11/04/11.Read more
Showing 50 of 462 complaints.
NHTSA Safety Investigations — KIA SPORTAGE
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA — Closed
— Model Year: 2002
FAN BLADE CRACKING/SEPARATION
KIA MOTORS AMERICA, INC. (KIA) HAS IDENTIFIED A DEFECT IN THE PLASTIC ENGINE COOLING FAN IN THE SUBJECT VEHICLES AND WILL CONDUCT A SAFETY RECALL.KIA'S DEFECT REPORT STATES, ...HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN...INITIATING CRACKS IN TH
... E FAN.THE CENTRIFUGAL FORCES GENERATED BY THE ROTATION OF THE BLADES CAN CAUSE THE CRACKS TO PROPAGATE UNTIL COMPLETE SEPARATION OCCURS...KIA ESTIMATES APPROXIMATELY 35,090 VEHICLES WILL BE SUBJECT TO THE RECALL, AS SOME OF THE 46,887 VEHICLES PRODUCED HAVE ALREADY HAD THE FAN REPLACED UNDER WARRANTY.KIA DEALERS WILL REPLACE THE ORIGINAL VERSION OF THE FAN WITH A FAN MADE OF IMPROVED MATERIAL.THIS INVESTIGATION WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042 AND UPGRADED TO ENGINEERING ANALYSIS EA07-001 ON JANUARY 22, 2007.PLEASE SEE NHTSA RECALL 07V161 FOR MORE DETAILED INFORMATIONRead more
PE — Closed
— Model Year: 2002
FAN BLADE CRACKING/SEPARATION
THE INVESTIGATION OF ENGINE COOLING FANS IN THE SUBJECT VEHICLES WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042.THE BASIS FOR OPENING WAS 10 CONSUMER REPORTS ALLEGING FAN BLADE CRACKING AND BLADE SEPARATION.SIX OF THE REPORTS INDICATED THE SEPARATED FAN BLADES CAUSED DAMAGE TO OTHER ENGINE COMPARTMENT
... COMPONENTS.KIA HAS PROVIDED ADDITIONAL CONSUMER REPORTS AND INFORMATION IN ITS RESPONSE TO PE06-042.THE INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS (EA07-001) TO CONTINUE TO ASSESS THE CONSEQUENCE OF FAN BLADE SEPARATION IN THE SUBJECT VEHICLES.Read more
EA — Closed
— Model Year: 1996
FUEL TANK LEAKAGE
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE
... .THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.Read more
PE — Closed
— Model Year: 1999
FUEL TANK LEAKAGE
ON JANUARY 4, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FUEL LEAKAGE FROM THE STEEL FUEL STORAGE TANK IN CERTAIN MODEL YEAR 1999-2000 KIA SPORTAGE VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON JANUARY 25, 2006 REQUESTING INFORMATION AB
... OUT THESE AND OTHER KIA SPORTAGE VEHICLES.ODI IS AWARE OF 40 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE FUEL STORAGE TANK LEAKAGE IN THE SUBJECT VEHICLES.ANALYSIS OF MANUFACTURER DATA INDICATES THAT ALLEGED FUEL LEAKAGE AT OR NEAR THE STORAGE TANK MAY BE ATTRIBUTED TO SEVERAL DIFFERENT FAILURE MODES INVOLVING THE FUEL CONTAINMENT AND DISTRIBUTION SYSTEM.KIA HAS IDENTIFIED CORROSION AS A PRIMARY CAUSAL FACTOR RELATED TO FUEL STORAGE TANK COMPLAINTS AND CONTINUED FUEL SYSTEM PART SALES.ACCORDING TO KIA, FUEL TANK CORROSION CLAIMS RELATED TO LEAKAGE CAN BE DIVIDED INTO TWO CATEGORIES: LOWER TANK CLAIMS ASSOCIATED WITH EXTERIOR CORROSION DUE TO DISRUPTION OF THE POLYVINYL CHLORIDE (PVC) PROTECTIVE COATING AND UPPER TANK CLAIMS ASSOCIATED WITH CORROSION AT THE FUEL SENDING UNIT MOUNTING PLATE AREA.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FUEL TANK CORROSION RESULTING IN LEAKAGE IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-007) TO FURTHER STUDY THE FREQUENCY, SCOPE, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.Read more
EA — Closed
— Model Year: 1999
SEAT BELT BUCKLE FALSE LATCH/MALFUNCTION
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
RQ — Closed
— Model Year: 2001
SEAT BELT BUCKLE FALSE LATCH/MALFUNCTION
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES IND
... ICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.Read more
RQ — Closed
— Model Year: 1998
ENGINE STALLING POST-RECALL
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED
... WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.Read more
PE — Closed
— Model Year: 1996
SAFETY BELT BUCKLE MALFUNCTION
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
DP — Closed
— Model Year: 2000
VEHICLE ROLLOVER
There is no summary currently available
PE — Closed
— Model Year: 1999
WINDSHIELD WIPER
PE — Closed
— Model Year: 2000
INCORRECT BATTERY JUMP-START
ALLEGE BATTETY MAY EXPLODE IF OWNER'S ATTEMPT TO JUMP-STATE THE VEHICLE BY FOLLOWING THE OWNER'S MANUAL DIAGRAM
EA — Closed
— Model Year: 1998
TURN SIGHAL
There is no summary currently available
SQ — Closed
— Model Year: 1997
CHECK ENGINE LIGHT STAYS ON
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
PE — Closed
— Model Year: 1998
WINDSHIELD WIPER
ALLEGED WINDSHIELD WIPER BECOMES INOPERATIVE WHEN THE WIPER ARM AND PIVOT SEPARATE