2002 ISUZU TROOPER

0 recalls — 12 complaints — 55 TSBs

No recalls found for this vehicle.

Complaint Statistics

12 total complaints 1 crashes

Top Reported Components

Component	Complaints
VEHICLE SPEED CONTROL	2
ENGINE AND ENGINE COOLING:ENGINE	2
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	1
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	1
POWER TRAIN:AUTOMATIC TRANSMISSION	1
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT	1
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS	1
ENGINE AND ENGINE COOLING	1
ELECTRICAL SYSTEM	1
TIRES:TREAD/BELT	1

Incident date: Jun 12, 2012

TL* THE CONTACT OWNS A 2002 ISUZU TROOPER EQUIPPED WITH BF GOODRICH MUD TERRAIN T/A KM2 TIRES, SIZE: LT265/75R16. WHILE DRIVING BETWEEN 55-65 MPH, THREE OF THE TIRES EXPERIENCED TREAD SEPARATION. THERE WERE MOMENTARY VIBRATIONS JUST BEFORE THE FAILURES. THE FAILURES OCCURRED ON THREE OCCASIONS. THE ... Read more

Incident date: Apr 4, 2014

I WAS DRIVING ABOUT 35 MPH ON A RURAL ROAD AND I NOTICED THAT UPON GIVING SOME GAS THE VEHICLE DID NOT RESPOND AT ALL. THEN I NOTICED THAT ALL MY INSTRUMENT PANEL LIGHTS WERE OUT....EVERYTHING GONE. I APPLIED THE BRAKES AND WITH DIFFICULTY IN STEERING (THERE WAS NO POWER), I PULLED TO STOP AT THE ... Read more

Incident date: May 18, 2007

ENGINE IN MY 2002 ISUZU TROOPER BURNED UP THE MAIN ROD BEARING IN PISTON ONE DUE TO INSUFFICIENT OIL PRESSURE. ENGINE HAD TO BE REPLACED. TRUCK HAS 79K MILES ON IT AND WAS OUT OF WARRANTY. ISUZU OF NORTH AMERICA STATED NOTHING WOULD BE DONE VIA THE MANUFACTURER. I REPLACED THE ENGINE MYSELF AT A... Read more

Incident date: Mar 23, 2007

EXCESSIVE OIL CONSUMPTION. 1 QT. EVERY 600 MILES OR SO. 5 QTS BETWEEN OIL CHANGES (3000 MILES!) *JB

Incident date: Mar 6, 2005

I TOOK MY 2002 ISUZU TROOPER LTD. TO THE DEALER (FITZGERALD DODGE ISUZU, ROCKVILLE, MARYLAND, COMPLAINING OF A GROWLING NOISE. WHILE IT WAS MIS-DIAGNOSED, THE DEALER INDICATED THAT THE UNDERPLATING ON THE CAR WAS SUFFERING FROM FAULTY WELDS, AND THAT IF I DIDN'T HAVE IT REMOVED IT WOULD FALL OFF WHI... Read more

Incident date: Jul 2, 2005

DT: CONSUMER OWNS A 2002 ISUZU TROOPER. CONSUMER SAYS THAT WHEN PUTTING THE VEHICLE IN PARK THE INDICATOR POSITION WILL READ PARK, BUT THE VEHICLE WILL BE IN A NEUTRAL POSITION. THE VEHICLE CAN ROLE FREELY FORWARD OR BACKWARDS. THIS PROBLEM HAS BEEN GOING ON FOR ABOUT A YEAR. VEHICLE HAD BEEN TO ... Read more

Incident date: Jul 15, 2004

WHEN THE CONSUMER APPROACHED A TRAIN TRACK, ANOTHER VEHICLE BEGAN TO APPROACH FROM THE OTHER DIRECTION. THE CONSUMER STOPPED AND SHIFTED FROM DRIVE TO REVERSE TO CLEAR UP THE ROAD WAY. THE TRANSMISSION JUMPED TO PARK AND LOCKED PREVENTING THE VEHICLE FROM MOVING. A TRAIN APPROACHED AND STRUCK TH... Read more

Crash

Incident date: Aug 5, 2003

WHEN CHANGING GEARS AND WITHOUT WARNING VEHICLE WOULD ACCELERATE. DEALER HAS BEEN NOTIFIED. *AK

Incident date: Nov 9, 2002

WHEN IN MOTION FOR LONG PERIODS OF TIME, THE VEHICLE WILL LOSE ACCELERATION POWER. THIS WILL CONTINUE UNTIL CONSUMER IS ABLE TO PULL OFF THE ROAD TO RESTART THE ENGINE. THE EGR VALVE HAS REPEATEDLY BEEN REPLACED, BUT THE PROBLEM IS STILL IN EXISTENCE. *JG TS

Incident date: Apr 7, 2000

WHILE DRIVING VEHICLE, IF YOU TRY TO PASS SOMEONE OR ACCELERATE, SOMETIMES THE VEHICLE WILL LOOSE POWER. CONSUMER STATES' ONCE WHEN VEHICLE LOSS POWER IT ALMOST RESULTED IN A REAR END COLLISION. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Incident date: Aug 2, 2002

MOTOR WILL REV UP WHEN SITTING STILL AT A RED LIGHT AND TRY TO LUNGE FORWARD. I HAVE EVEN HAD IT GO 35 MILES AN HOUR WITHOUT MY FOOT EVEN BEING ON THE ACCELERATOR. I HAVE HAD MY TRUCK TO THE DEALER 3 TIMES NOW AND THEY KEEP SAYING THEY CAN NOT FIND ANYTHING WRONG. UNLESS THEY CAN SEE THE VEHICLE ... Read more

Incident date: Jun 2, 2002

WHEN AT A COMPLETE STOP VEHICLE WILL START TO REV. IF CONSUMER DOES NOT HAVE FOOT ON BRAKES VEHICLE WILL START TO MOVE FORWARD. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK

Technical Service Bulletins — 2002 ISUZU TROOPER

55 manufacturer communications from 44 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	9
060000 ENGINE AND ENGINE COOLING	8
353000 EQUIPMENT:ELECTRICAL	6
110000 ELECTRICAL SYSTEM	5
980000 UNKNOWN OR OTHER	3
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)	3
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	3
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL	2

980000 UNKNOWN OR OTHER

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may als

350000 EQUIPMENT

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

356000 EQUIPMENT ADAPTIVE/MOBILITY

The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find eq

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Technician will need to press the OnStar button and verify they have an active account and that t

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Ap

110000 ELECTRICAL SYSTEM

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This Preliminary Information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. Technician should obtain a hand-held GPS unit to test the odomete

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. AFTER THE VEHIC

350000 EQUIPMENT

060000 ENGINE (PWS)

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. TECHNICIAN WILL NEED

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

350000 EQUIPMENT

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

020000 SUSPENSION

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

161000 STRUCTURE:FRAME AND MEMBERS

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

353000 EQUIPMENT:ELECTRICAL

118000 ELECTRICAL SYSTEM:SOFTWARE

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

356000 EQUIPMENT ADAPTIVE/MOBILITY

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicle that has no XM audio on certain channels but XM channel info is displayed. Technician will need to contact XM and deactivate and activate the mo

060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This preliminary bulletin provides procedures on how to reset or refresh the XM radio receiver is the customers states that they only get a few channels.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Technician will need to use a scan tool and verify current Digital Radio Receiver Status un

350000 EQUIPMENT

070000 FUEL SYSTEM, GASOLINE

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

353000 EQUIPMENT:ELECTRICAL

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles may have a no power or no connect concern. Technician will find that the OnStar led is red and Diagnostic Trouble Code U1500 is set. Technician

060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. Dealer should send the correc

106000 POWER TRAIN:AXLE ASSEMBLY

This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the p

030000 BRAKES (PWS)

This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be

110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar

110000 ELECTRICAL SYSTEM

CIRCUIT SCHEMATIC (ELECTRONIC TROUBLESHOOTING MANUAL (ETM) REVISION). *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

THROTTLE BODY MOUNTING BOLT TORQUE SPECIFICATIONS. *TT

350000 EQUIPMENT

REAR CUP HOLDER DOES NOT STAY IN THE UP POSITION. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

CALIBRATION UPDATES. *TT

100000 POWER TRAIN

REPLACEMENT ODOMETER PROGRAMING. *JG

060000 ENGINE AND ENGINE COOLING

PROCEDURES TO CHANGE THE TEMPERATURE DISPLAY MODE. *JG

980000 UNKNOWN OR OTHER

INFORMATION ON KENT MOORE ESSENTIAL TOOLS. *TT

980000 UNKNOWN OR OTHER

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for March 2024 for Isuzu Motors Limited.

NHTSA Safety Investigations — ISUZU TROOPER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP — Closed — Model Year: 1990

ENGINE COMPARTMENT FIRES

DP — Closed — Model Year: 1984

DEFECTIVE HEATER CORES

EA — Closed — Model Year: 1984

REAR DOOR HINGE SEPARATION

There is no summary currently available

PE — Closed — Model Year: 1984

REAR DOOR HINGE SEPARATION

There is no summary currently available

PE — Closed — Model Year: 1986

DIESEL ENGINE SURGE

There is no summary currently available

ISUZU TROOPER — All Years Overview

Complete safety history for the ISUZU TROOPER across all model years (1984–2001).

31 Total Recalls

718 Total Complaints

5 Investigations

73 Reported Crashes

43 Reported Fires

3 Reported Deaths

ISUZU TROOPER — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2002 (current)	0	12
2001	1	42	View
2000	2	61	View
1999	0	105	View
1998	1	48	View
1997	2	18	View
1996	2	66	View
1995	1	65	View
1994	2	58	View
1993	2	41	View
1992	2	27	View
1991	3	71	View
1990	3	30	View
1989	1	17	View
1988	2	20	View
1987	3	9	View
1986	2	18	View
1985	1	5	View
1984	1	0	View

Other ISUZU Models

Model	Recalls	Complaints
FTR	82	9	View
NPR HD	64	14	View
NPR	58	66	View
NQR	56	7	View
NRR	55	3	View
RODEO	40	3,314	View
NPR XD	38	1	View
FVR	35	0	View