2012 FORD EXPEDITION

3 recalls, 163 complaints - 110 TSBs - 4/5 safety rating

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.

Consequence

An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.

Remedy

Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.

153,581 vehicles affected

Manufacturer: Ford Motor Company

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Defect Description

FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRA... Read more

Consequence

IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP... Read more

Remedy

FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

10,500 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SEATS:MID/REAR ASSEMBLY

Defect Description

FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE W... Read more

Consequence

IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.

Remedy

FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

569 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

163 total complaints 12 crashes 2 fires 38 injuries

Top Reported Components

Component	Complaints
POWER TRAIN	51
ELECTRICAL SYSTEM	19
ENGINE	17
STRUCTURE:BODY	15
VEHICLE SPEED CONTROL	12
UNKNOWN OR OTHER	12
SERVICE BRAKES	6
AIR BAGS	4
FUEL/PROPULSION SYSTEM	4
SEAT BELTS	4

Incident date: Apr 4, 2026

The vehicle's engine has suffered a catastrophic internal failure at approximately 56,000 miles. The engine is the 6.4-liter HEMI V8. The issue began with a loud ticking noise from the engine. I brought the vehicle to Stoneridge Chrysler Jeep Dodge of Pleasanton for diagnosis. At that visit, the de... Read more

Incident date: Apr 4, 2026

One of my backseat seatbelt buckles is completely broken and the other side has a crack in the plastic casing in the same spot but not as big. And the insides of the buckle where it locks in there is nothing for it to lock onto. One still works as the other one has nothing for it to lock into. Yes ... Read more

Incident date: Feb 23, 2026

Component/System Affected: UNKNOWN – suspected fuel system or related component due to strong gasoline odor. Vehicle is available for inspection upon request. What Happened: There is a strong gasoline odor specifically at the front driver’s side wheel well/tire area. The odor is also noticeable... Read more

Incident date: Nov 9, 2025

While driving at approximately 50 MPH with no other vehicles around, there was a loud bang and then the sound of air. We identified that the panoramic sunroof had exploded. We pulled over immediately and took photos of the sunroof which at that time was shattered but intact. There was a clear bul... Read more

Incident date: Oct 13, 2025

There have been many times when driving, specifically over bumpy ground, but it has also happened over smooth/dry ground, where it feels like the anti-lock brakes suddenly kick in when they are not supposed to causing an inability to brake. You have to take your foot off the brake and brake again. ... Read more

Incident date: Sep 10, 2024

The contact owns a 2009 Mercedes-Benz ML350. The contact stated upon starting the vehicle, the vehicle lost power steering functionality, and the steering wheel locked. The battery warning light was illuminated. The dealer was contacted and informed the contact that the VIN was not included under re... Read more

Incident date: Aug 11, 2025

Dear Sir/Madam, I own a 2016 Ford F-150. Over the past few months the vehicle will suddenly hesitate and downshift while driving and the mechanics symbol will appear on the dashboard. This happened to me a few times. At the end of June I had two different mechanics look at the vehicle and both kept ... Read more

Incident date: Aug 11, 2025

I am writing to report a serious safety concern regarding my vehicle’s front passenger seat belt, which unexpectedly came unlatched. Although Hyundai replaced that one seatbelt, I remain very concerned that other seatbelts in the vehicle could have the same defect. I was informed that the warrant... Read more

Incident date: Jun 15, 2025

The clock spring has failed. There is a current recall for the clock spring mechanisms in the 2011-2016 Jeep Wranglers. The vehicle has been inspected by a mechanic who informed me of the recall to begin with. The fuse for the clock spring (along with all the other fuses) are working as normal. Ther... Read more

Incident date: Jun 15, 2025

On [XXX], my wife and I were driving northbound on [XXX] in Georgia, pulling our Jayco Feather Micro 166FBS travel trailer. It was early afternoon on a sunny day with moderately heavy traffic; we were traveling in the outside lane at approximately 65 mph. We were approximately 40 miles south of the... Read more

Incident date: Jul 24, 2025

Dodge has a recall U87 over pcm not letting car to start and many other problems i have a 2015 dodge dart sxt 2.4l MultiAir with same engine as the 2017 jeeps and others stated in the U87 recall and my pcm is going out my car will start intermittently and when the car won't start the pcm feels hot w... Read more

Incident date: Jul 24, 2025

Right after picking up my 2015 Ford Mustang from dealer service on July 23, 2025, the hood suddenly flew open while I was driving, completely blocking my view and creating a serious risk of collision. The dealership had performed multiple recalls and a multi-point inspection but did not flag any hoo... Read more

Incident date: Jul 24, 2025

The component that failed is the left front driver side headlight of the vehicle, resulting in low visibility and inability to see or drive the vehicle in it's current condition at night. The only "warning" that could potentially have been a "warning", was the blinker began rapidly blinking the day... Read more

Incident date: Jul 24, 2025

Honda has known for years that the 1.5L engines installed in 2018 or newer Honda Accords have issues with oil dilution causing major catastrophic engine failures, head gasket damage, fluids leaking into the cylinders, and costly repairs to cars with less than 86000 miles on them. Honda Corporation n... Read more

Incident date: Jul 24, 2025

We are told by Audi dealer service that our entire water pump system is defective and needs to be replaced at a cost of $5000+. We've had Audis subject to past recall and class action settlements. This is an ongoing, known issue for Audi for over a decade. Frustratingly, our 2020 SQ7 model is not in... Read more

Incident date: Jul 24, 2025

MMI Constant Rebooting - Follow up My 2020 Audi A4 Quattro's MMI system constantly reboots (~60 seconds), causing the screen to go black/blank. Component Failed: MIB3 infotainment software. This persistent issue leads to reboots and loss of digital display. System available for inspection. Safety ... Read more

Incident date: Jul 24, 2025

While driving the road whether highway our town… my vehicle will stall out. I can’t safely pass because my car loses power.. check engine light starts blinking then traction control lights come on and then battery light. I have to turn the car off after turning flashers on put it in park and res... Read more

Incident date: Jul 24, 2025

Incident date: May 17, 2025

When applying the brakes at speeds less than 40 miles per hour, the car will surge forward at a point during braking process. This happens regularly but not every time brakes are applied. This is an issue as the car surges forward during braking.

Incident date: Jul 1, 2024

The shifter failed. It won’t come out of park.

Incident date: Jun 29, 2024

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the rear and blind spot camera failed to work. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the... Read more

Incident date: May 24, 2024

While in the process of pulling into marked stall in parking lot car accelerated unexpectedly jumping over a concrete stop and crashing into the wall of a building. Car sustained eleven thousand dollars worth of damage and the wall that was hit was caved in. Cost of wall repair is unknown at this ti... Read more

Crash

Incident date: Sep 2, 2023

* According to the different computers codes the issue is Secondary Air Injection Pump failure. *Driving on the highway I had the limp mode which created a drastic velocity drop from 70 mph to 40 mph which created a situation that almost ended up in having another car hitting me from behind. this ... Read more

Incident date: Sep 2, 2023

Incident date: Sep 5, 2023

According to the dealership, if the car is not started every 3 days, it will shut itself down. The car was towed 6 times, I'm a business woman, my coworkers, friends drives Mercedes Benz, and no one have heard of any such issues. Any cheaper cars, after 2 weeks at the airport, the car starts. Someth... Read more

Incident date: Sep 5, 2023

Low engine oil level since I bought it in September 2021. I’ve had it at the dealer three times and they’ve said there are no codes on the car but they are on my Mazda app. They want me to drive it over a hour away with low oil to prove to them that the engine oil is low. I did this, shut the ca... Read more

Incident date: Jun 23, 2023

Faulty design of rear right hand passenger seatbelt buckle prevents use while the left side of the split seat is folded down for cargo.

Incident date: Nov 14, 2022

The contact owns a 2022 Hyundai Sonata. The contact stated that while driving approximately 35 MPH up a ramp leading to the freeway, the vehicle suddenly started losing motive power. The contact stated that the vehicle would no longer accelerate while depressing the accelerator pedal. The vehicle wa... Read more

Incident date: Nov 14, 2022

Incident date: Dec 5, 2022

The contact owns a 2012 Ford Expedition. The contact stated while driving approximately 45 MPH, the vehicle suddenly failed to accelerate while depressing the accelerator pedal. The vehicle independently decelerated and nearly caused the vehicle to be rear ended by a tractor trailer. The contact ind... Read more

Incident date: Sep 7, 2022

Uncommanded downshift to first gear in 6R80 transmission. While driving at approximately 30mph, transmission downshifted into 1st gear. Problem repeated itself several times. No "codes" or warning lights. I put the transmission in "3" and drove slowly back home. This is the same issue that has o... Read more

Incident date: Jun 6, 2022

My vehicle suddenly shifted downward, my gas pedal had no effect, my speedometer stopped working and my fuel and tire sensor lights came on. This happened multiple times on my drive this morning and would have caused an accident if I was being tailgated.

Incident date: Jun 6, 2022

Incident date: Apr 29, 2022

The contact owns a 2012 Ford Expedition. The contact stated while driving at approximately 30 MPH, the vehicle independently slowed to approximately 2 MPH. The contact observed that the check engine warning light illuminated. Additionally, the speedometer went blank. The contact stated that when she... Read more

Incident date: Mar 28, 2022

My wife backed my vehicle out of the garage and began her drive to work. She stopped a few times at stop light through town before she got to the freeway. Driving on the highway she notice/got a message on the dash that stated Low Brake Fluid. She wasn't sure what that meant as the brakes were worki... Read more

Incident date: Sep 29, 2021

The speedometer went to zero when the vehicle was driven on the highway at 70MPH and the transmission would shift down the wrench symbol came on the LCD display. Had to pull over and shut the vehicle off and open the drivers door to make sure that the vehicle was fully off/reset. Started the vehic... Read more

Incident date: Aug 17, 2021

My gear shaft gets stuck in park as if it’s not recognizing that the break is getting pressed. It gets stuck for a while. There is no sticky substance that is causing this.

Incident date: Jul 13, 2021

The contact owns a 2012 Ford Expedition. The contact stated while driving 60 mph, the vehicle independently down shifted to first gear causing both rear tires to lock up. The contact stated that there was no warning light illuminated. The vehicle was not taken to the local dealer nor an independent ... Read more

Incident date: Jun 1, 2021

unexpected transmission downshift for no reason and it hesitate and it chugs along down shifts drops out and kicks back in

Incident date: Apr 15, 2021

The contact owns a 2012 Ford Expedition. The contact stated while driving at 45 mph, the vehicle lost motive power and stalled. The contact had to restart the vehicle and continued to drive. However, when leaving work the failure occurred again which at that time the contact had pulled the vehicle o... Read more

Incident date: Jun 1, 2021

The contact owns a 2012 Ford Expedition. The contact stated that while driving at 30 mph, there was an unexpected transmission downshift and the vehicle speed decelerated inadvertently. The vehicle was not diagnosed nor repaired. The dealer and manufacturer were not made aware of the failure. The fa... Read more

Incident date: May 8, 2021

WHILE DRIVING, THE VEHICLE SUDDENLY DOWNSHIFTED INTO 1ST GEAR, RPMS REVVED UP, SPEEDOMETER STOPPED WORKING, PUSHING THE GAS PEDAL TEMPORARILY HAD NO EFFECT, "FUEL LEVEL LOW" LIGHT CAME ON AND "TIRE PRESSURE SENSOR FAULT" LIGHT CAME ON. I WAS STILL ABLE TO DRIVE THE VEHICLE, THOUGH THE SPEEDOMETER W... Read more

Incident date: May 8, 2021

Incident date: Apr 5, 2021

TL* THE CONTACT OWNS A 2012 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 55 MPH, THE VEHICLE INADVERTENTLY DOWNSHIFTED TO FIRST GEAR CAUSING THE VEHICLE TO ABRUPTLY SLOW. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC, THE CONTACT WAS REFERRE... Read more

Incident date: Feb 3, 2021

RANDOMLY DROPS INTO FIRST GEAR WHILE DRIVING AND WILL NOT GO OUT OF FIRST GEAR AFTER THAT UNLESS DISCONNECTING BATTERY AND RESETTING EVERYTHING. NO CHECK ENGINE LIGHT OR ANYTHING. THIS CANNOT HAPPEN WITH THREE KIDS IN THE CAR. WHAT IF THIS HAPPENED AT 70MPH ON THE HIGHWAY? OCCURRED 2/3/21 AND 2/... Read more

Incident date: Jan 3, 2021

VEHICLE IS DOWNSHIFTING GEAR WHILE DRIVING. IT CAUSED JERKS IN THE SUV AS IT TRIED TO SHIFT GEARS AND THEN BECAME STUCK ON FIRST GEAR. THIS HAPPENED WHILE DRIVING IN THE HIGHWAY AND AGAIN ON A CITY STREET. FORD DEALERSHIP REPORTING IT IS NOT COVERED UNDER THEIR CURRENT RECALL ALTHOUGH OTHER 2012 FOR... Read more

Showing 50 of 163 complaints.

NHTSA Safety Ratings, 2012 FORD EXPEDITION

2012 Ford Expedition EXTENDED SUV 4x4

Category	Rating
Overall Rating	4 / 5 ★★★★☆
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	3 / 5 ★★★☆☆
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	19.8%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2012 FORD EXPEDITION

110 manufacturer communications from 55 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	15
100000 POWER TRAIN	12
110000 ELECTRICAL SYSTEM	9
060000 ENGINE (PWS)	7
160000 STRUCTURE	6
356000 EQUIPMENT ADAPTIVE/MOBILITY	5
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	4
353000 EQUIPMENT:ELECTRICAL	3

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

100000 POWER TRAIN

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IW

100000 POWER TRAIN

This program extends the warranty coverage of the automatic transmission molded leadframe to 10 years of service or 150,000 miles from the warranty start date of the vehicle, whichever occurs first. This is a one-time repair program.

100000 POWER TRAIN

Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped with A 6R80 Transmission Transmission Molded Leadframe Extended Coverage In some of the affected vehicles, an output shaft speed (OSS) se

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

110000 ELECTRICAL SYSTEM

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (

200000 WHEELS

350000 EQUIPMENT

160000 STRUCTURE

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi

130000 VISIBILITY

Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid

132000 VISIBILITY:GLASS, SIDE/REAR

110000 ELECTRICAL SYSTEM

For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA a

110000 ELECTRICAL SYSTEM

Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

100000 POWER TRAIN

Customer Satisfaction Program 19N01: Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Transmission Molded Leadframe Extended Coverage

100000 POWER TRAIN

On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/tran

100000 POWER TRAIN

Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Transmission Molded Leadframe Extended Coverage

100000 POWER TRAIN

Certain 2012 - 2013 Model Year Expedition/Navigator Vehicles Equipped With A 6R80 Transmission - Sudden Transmission Downshift - Powertrain Control Module Reprogramming

160000 STRUCTURE

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

160000 STRUCTURE

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

350000 EQUIPMENT

Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford

350000 EQUIPMENT

Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam

060000 ENGINE (PWS)

350000 EQUIPMENT

Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Linco

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No re

353000 EQUIPMENT:ELECTRICAL

The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use

110000 ELECTRICAL SYSTEM

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

2009-2017 VEHICLES EQUIPPED WITH A 6R80, 6R100, 6R140 AUTOMATIC TRANSMISSION HAVE AN UPDATED MAIN CONTROL VALVE BODY OVERHAUL PROCEDURE. REFER TO WORKSHOP MANUAL (WSM), SECTION 307-01 FOR MAIN CONTROL VALVE BODY (7A100) OVERHAUL PROCEDURES.

060000 ENGINE (PWS)

TO HELP DIFFERENTIATE ENGINE OIL LEAKS FROM OTHER POSSIBLE SOURCES, A NEW WHITE-COLORED FLUORESCENT ENGINE OIL DYE IS AVAILABLE. WORKSHOP MANUAL (WSM), SECTION 303-00 HAS BEEN REVISED TO REFERENCE THE NEW WHITE-COLORED DYE. THE NEW WHITE FL

162900 STRUCTURE:BODY:ROOF AND PILLARS

SOME 2011-2016 EXPEDITION AND NAVIGATOR VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE ROOF OPENING PANEL SHIELD WHILE DRIVING OVER BUMPS. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.

030000 BRAKES (PWS)

SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. IF THE

030000 BRAKES (PWS)

150000 SEAT BELTS

Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatb

151300 SEAT BELTS:FRONT:RETRACTOR

060000 ENGINE AND ENGINE COOLING

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

061000 ENGINE AND ENGINE COOLING:ENGINE

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

060000 ENGINE (PWS)

100000 POWER TRAIN

CERTAIN 2011-2012 MODEL YEAR F-150 AND 2012 MODEL YEAR EXPEDITION, NAVIGATOR AND MUSTANG VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION - MOLDED LEADFRAME EXTENDED COVERAGE

350000 EQUIPMENT

CERTAIN 2011-2012 MODEL YEAR F-150 AND 2012 MODEL YEAR EXPEDITION, NAVIGATOR AND MUSTANG VEHICLES EQUIPPED WITH A 6R80 TRANSMISSION - MOLDED LEADFRAME EXTENDED COVERAGE

110000 ELECTRICAL SYSTEM

Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (F

350000 EQUIPMENT

Touchscreen navigation system - arabic language - blank screen

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Touchscreen navigation system - arabic language - blank screen

100000 POWER TRAIN