2011 FORD EXPEDITION

0 recalls — 91 complaints — 78 TSBs

No recalls found for this vehicle.

Complaint Statistics

91 total complaints 3 crashes 1 fires 4 injuries

Top Reported Components

Component	Complaints
POWER TRAIN	21
ENGINE	11
STRUCTURE:BODY	9
SEATS	8
UNKNOWN OR OTHER	8
VEHICLE SPEED CONTROL	7
ELECTRICAL SYSTEM	6
FUEL/PROPULSION SYSTEM	4
WHEELS	3
VISIBILITY/WIPER	2

Incident date: Mar 4, 2026

Hard, delayed, jump from idle when accelerator is pressed. Hard shift from park to reverse.

Incident date: Jul 10, 2023

I bought this vehicle early 2023. From the moment I bought it I’ve had a loud ticking sound come from the dash or the motor when I start the car also when it’s really hot out. It also didn’t blow cold air. So I had to save up enough money to replace the AC components in my 2011 expedition. Aft... Read more

Incident date: Jul 10, 2023

Incident date: Sep 9, 2024

The contact owns a 2011 Ford Expedition. The contact stated while driving at an undisclosed speed, the front blower system was seized. The vehicle was driven to the residence. The vehicle was towed to the dealer where it was diagnosed with a failed HVAC blower motor. The contact was informed that th... Read more

Incident date: Apr 27, 2024

So my 2011 expedition has a lead frame problem it is stuck in 4th gear and all the warning lights are on associating the lead frame. The shop I left told me it Is the lead frame. The problem is the ford f150 with the exact same transmission as mine has a recall for that exact part. But no recall on ... Read more

Incident date: Dec 5, 2022

The contact owns a 2011 Ford Expedition. The contact stated that the locking assembly on the driver’s side door was frozen and failed to operate as designed. Due to the issue, the contact was unable to enter the vehicle without using a hair dryer to warm up the lock. However, once the door was ope... Read more

Incident date: Dec 20, 2019

The engine is blown at 125k miles when all servicing and maintenance was done at the dealership. Somewhere around 50k to 60k miles, I complained to the dealership about a ticking noise from the engine and was told multiple times it was "normal with this engine". Well this engine blew while I was on... Read more

Incident date: Apr 4, 2022

While getting tires replaced (Discount Tire), the representative pointed out that the aluminum-shelled lug nuts had swollen and become so deformed that the correctly sized socket could not be used. FUrthermore they could not be accurately torqued. The lug nuts had to be replaced, which cost $175.

Incident date: Mar 16, 2022

2 piece lug nuts swelled creating a dangerous situation where the lugs were extremely difficult to remove. If the vehicle experienced a flat tire, they would be difficult if not impossible to remove on the road.

Incident date: Feb 20, 2022

The contact owns a 2011 FORD Expedition. The contact stated that while driving, there was a burning odor coming from the vehicle. The contact stated at the time she did not see any smoke coming from her vehicle, so she assumed it was the outside. The contact stated that once she parked her vehicle, ... Read more

Fire

Incident date: Mar 4, 2021

NO REVERSE LIGHTS, NO BACK UP LIGHTS, NO POWER TO THE REVERSE LIGHT BULBS.

Incident date: Sep 1, 2020

TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY SHUT-OFF AND WENT INTO LIMP MODE. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE. THE CONTACT CONTINUED DRIVING TO HIS DESTINATION. THE CONTACT TOOK THE VEHICLE TO A CERTI... Read more

Incident date: Aug 9, 2020

LLOSS OF STEERING CONTROL WHILE DRIVING ON A HIGHWAY

Incident date: Oct 1, 2019

CHECK ENGINE LIGHT COMES ON AND IT READS CHECK FUEL FILL INLET? IF I CAN FIND SOMEONE TO TURN IT OFF THEY WILL CLEAR IT BUT WITHIN A WEEK IT IS BACK ON. *TR

Incident date: Oct 1, 2019

CHECK ENGINE LIGHT COMES ON AND IT READS CHECK FUEL FILL INLET? IF I CAN FIND SOMEONE TO TURN IT OFF THEY WILL CLEAR IT BUT WITHIN A WEEK IT IS BACK ON. *TR

Incident date: Jun 9, 2020

DRIVERS RETRACTABLE RUNNING BOARD MALFUNCTIONS GOING UP AND EXTENDING. THE RUNNING BOARD HAS STOPPED MIDWAY DURING EXTENSION AND HAVE CAUSED OCCUPANTS TO FALL DUE TO THE RUNNING BOARD SUDDENLY COLLAPSING TO NORMAL HEIGHT WITH WEIGHT OF THE OCCUPANT ON THE RUNNING BOARD. RETRACTION OF THE RUNNING BOA... Read more

Incident date: Aug 5, 2019

CAMSHAFT ROLLER BEARINGS SEIZED AND SCORED THE CAMSHAFT, REQUIRING A TOP END REPLACEMENT. THE VEHICLE HAD LESS THAN 95000 MILES. THIS THE SECOND EXPEDITION REQUIRING THIS ENGINE WORK. MY FIRST EXPEDITION REQUIRED A COMPLETE ENGINE REPLACEMENT DUE TO THE SAME ISSUE

Incident date: Mar 1, 2019

WINTER 2019, PASSENGER SIDE DOOR WOULD NOT STAY CLOSED. APPEARS TO ONLY HAPPEN WHEN TEMPERATURES ARE BELOW FREEZING. STARTED TO HAPPEN ON DRIVERS SIDE A DAY LATER. I'VE NOTICED WATER INSIDE ON THE SILL PLATE OF THE VEHICLE AFTER IT RAINS. I SUSPECT WATER IS MAKING IT'S WAY INTO THE DOOR. THE ISSUE H... Read more

Incident date: Mar 1, 2019

DOOR CLOSED SENSOR IS FAULTY AND SOUNDS LIKE THIS IS A KNOWN ISSUE WITH FORD BUT A RECALL WON'T HAPPEN TILL MORE PEOPLE COMPLAIN. I AM MAKING MY COMPLAINT OFFICIAL. ALSO SEEKING WARRANTY REPAIRS FROM THE ORIGINAL DEALERSHIP SINCE THE ISSUE HAS RETURNED.

Incident date: May 16, 2019

THE VEHICLE WAS IN MOTION ON AN EXIT RAMP AND THE SUNROOF SHATTERED.

Incident date: Apr 12, 2019

UPON ENGAGING THE CRUISE CONTROL WHILE IN MOTION AT 65MPH (HIGHWAY) AND GOING UP A BRIDGE THE VEHICLE ACCELERATED WITH ACCELERATOR BEING STUCK ON THE FLOOR (BOTTOMED OUT) BRAKING BECAME INEFFECTIVE AT THAT SPEED. AFTER A MAJOR EFFORT WAS ABLE TO PULL OVER. PUTTING IN NEUTRAL MADE THE VEHICLE IDLE AT... Read more

Incident date: Aug 17, 2015

ALUMINUM LIFT GATE PAINT IS CRACKING AND PEELING SIMIAR TO ALL OTHER YEARS OF EXPEDITION. PREVIOUS AND POST YEARS CONTINUE TO HAVE THE SAME ISSUE. NOT A FLUKE OR ONE OFF IN PAINT PREPARATION DEFECTS.

Incident date: Dec 12, 2018

ON DECEMBER 12, 2017, WHILE TRAVELING AT 75 MPH ON THE INTERSTATE WITH THE CRUISE CONTROL SET, THE VEHICLE SURGED FORWARD. WITHIN SECONDS FOLLOWING THE SURGE, THE VEHICLE UNEXPECTEDLY DOWNSHIFTED CAUSING LOSS OF CONTROL AND NEARLY A ROLL OVER ACCIDENT. THE VEHICLE WOULD NOT MOVE IN ANY GEAR. TURNING... Read more

Incident date: Feb 6, 2019

TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE CONTACT LOST CONTROL OF ALL FUNCTIONALITY EXCEPT THE BRAKES. THE CONTACT STOPPED THE VEHICLE, KEPT THE ENGINE RUNNING, AND WAITED A FEW SECONDS BEFORE ATTEMPTING TO DRIVE HOME. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VE... Read more

Incident date: Feb 6, 2019

Incident date: Sep 14, 2018

WHILE MY WIFE WAS DRIVING ON THE INTERSTATE WITH THE CRUISE CONTROL SET AT 78MPH, THE REAR TIRES ON OUR 2011 EXPEDITION SUDDENLY LOCKED UP, SKIDDING THE TIRES AND CAUSED THE VEHICLE TO FISHTAIL SHE HAD NO CONTROL OF STEERING OR ACCELERATION. WHEN THE VEHICLE REACHED APPROXIMATELY 35MPH THE TIRES REL... Read more

Incident date: May 3, 2018

I WAS DRIVING 70MPH ON HWY 290 WHEN MY CAR SUDDENLY DOWNSHIFTED TO FIRST GEAR AND THEN THE WHEELS TOTALLY LOCKED UP. THIS CAUSED ME TO START SLIDING SIDEWAYS DOWN THE ROAD UNTIL I CAME TO A STOP. IT TURNED OUT THAT A COMPUTER MODULE REGULATING SHIFTING HAD GONE BAD. THIS ALSO CAUSED MY TRANSMISSI... Read more

Incident date: May 3, 2018

Incident date: Jun 10, 2018

I WAS TRAVELING AT ABOUT 70 MPH WITH CRUISE CONTROL ON WHEN THE VEHICLE SUDDENLY DOWNSHIFT TWICE (FROM 6TH GEAR TO I THINK 3RD THEN 1ST GEAR) AND THE RPMS RED LINED CAUSING THE VEHICLE TO JERK AND SLOW DOWN RAPIDLY. I LOST ALL ACCELERATION POWER AND WAS BARELY ABLE TO MAKE IT TO THE SHOULDER OF THE... Read more

Incident date: May 3, 2018

I WAS DRIVING 70 MPH ON THE HIGHWAY ON A STRAIGHT AWAY WHEN MY CAR SUDDENLY DOWNSHIFTED TO 2ND GEAR, THEN IMMEDIATELY TO 1ST GEAR AND THEN THE WHEELS LOCKED UP

Incident date: May 3, 2018

I WAS DRIVING 70 MPH ON THE HIGHWAY ON A STRAIGHT AWAY WHEN MY CAR SUDDENLY DOWNSHIFTED TO 2ND GEAR, THEN IMMEDIATELY TO 1ST GEAR AND THEN THE WHEELS LOCKED UP

Incident date: Mar 16, 2018

TIMING CHAIN NEEDS REPLACED AGAIN AFTER HAVING IT REPLACED 18 MONTHS AGO

Incident date: Aug 21, 2017

ON 8/21/17, THE LATCHING BACK WINDOW OF OUR 2011 FORD EXPEDITION BLEW OUT WHILE MY HUSBAND WAS PARKING ON A PRIVATE LOT. WE DID NOT HIT ANYTHING, AND THE GLASS BLEW OUT, NOT IN. FORTUNATELY NO ONE WAS IN THE PATH OF THE FLYING GLASS. FORD REFUSES TO REIMBURSE US FOR ITS REPLACEMENT.

Incident date: Jul 1, 2016

THE PAINT FINISH ON THE REAR LIFTGATE HAS SEVERAL "BUBBLING" AREAS AND HAS STARTED TO FLAKE OFF IN SEVERAL AREAS. THIS ISSUE WAS FIRST NOTICED WHEN THE VEHICLE WAS LESS THAN 5 YEARS OLD. THERE HAS NEVER BEEN ANY PHYSICAL DAMAGE TO THIS AREA NOR HAS IT BEEN REPAINTED. I HAVE RESEARCHED ONLINE AND DI... Read more

Incident date: Jun 1, 2017

I EXPERIENCE HEADACHES AND DIZZINESS WHEN DRIVING THERE HAS BEEN TIMES I HAVE TO PULL OVER TO AVOID CRASHING. I BELIEVE CARBON MONOXIDE MAY BE THE RESULT OF THESE SYMPTOMS.

1 injured

Incident date: Jun 1, 2017

I EXPERIENCE HEADACHES AND DIZZINESS WHEN DRIVING THERE HAS BEEN TIMES I HAVE TO PULL OVER TO AVOID CRASHING. I BELIEVE CARBON MONOXIDE MAY BE THE RESULT OF THESE SYMPTOMS.

1 injured

Incident date: Aug 3, 2017

UPON HARD ACCELERATION OVER 3000 RPM A BURNT EXHAUST ODOR ENTERS THE CABIN. AT ALL TIMES

Incident date: Aug 3, 2017

UPON HARD ACCELERATION OVER 3000 RPM A BURNT EXHAUST ODOR ENTERS THE CABIN. AT ALL TIMES

Incident date: Aug 3, 2017

UPON HARD ACCELERATION OVER 3000 RPM A BURNT EXHAUST ODOR ENTERS THE CABIN. AT ALL TIMES

Incident date: May 7, 2017

JUN OF 2016 BRAKES STARTED GOING ALL THE WAY TO THE FLOOR WHILE BACKING OUT OF THE GARAGE WHEN ENGINE WAS FIRST STARTED. VEHICLE WOULD ROLL DOWN DRIVEWAY AND BRAKES WOULD NOT STOP IT UNTIL PUMPED. TOOK VEHICLE TO FORD AND THEY COULD NOT DUPLICATE. THEY FINALLY REPLACED THE MASTER CYLINDER AND THE... Read more

Incident date: Jan 20, 2017

WHEN SLOWING DOWN AND SHIFTING FROM SECOND TO FIRST THE TRANSMISSION MAKES A LOUD STUTTERING NOISE EVERY TIME. THIS IS NOT A NORMAL NOISE A TRANSMISSION SHOULD MAKE. THIS IS A SAFETY CONCERN THAT FORD NEEDS TO FIX IN NEW AND OLDER MODELS. THIS IS A VERY COMMON ISSUE PEOPLE ARE REPORTING ON THE INT... Read more

Incident date: Dec 7, 2015

VISIBLE CORROSION AND BUBBLING PAINT ON ALUMINUM REAR LIFT GATE

Incident date: Dec 11, 2016

STABILITY CONTROL APPLIES BRAKES RANDOMLY IN NORMAL CONDITIONS. PRIMARILY THIS HAS BEEN AT SLOW SPEEDS. BRAKES PULSATE AND VEHICLE IS DIFFICULT TO STEER/CONTROL. ON 12/11/2016 THE STABILITY SYSTEM KICKED IN AT THE SAME TIME THE "RESUME" BUTTON WAS PRESSED FOR THE CRUISE CONTROL. THE FRONT BRAKES APP... Read more

Incident date: Dec 11, 2016

Incident date: Nov 23, 2016

I CAN SHUT OFF THE ENGINE AND TAKE OUT THE KEYS WHEN THE TRANSMISSION IS STILL IN D., NOT P.

Incident date: Sep 19, 2016

VEHICLE IS IN MOTION AT HIGH-SPEED AND CUTS OFF OR DOWN SHIFTS WITHOUT WARNING. SITTING AT IDLE ENGINE CUTS OFF

Incident date: Jul 16, 2016

TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT THE KEY FOB FAILED TO UNLOCK THE DOORS INTERMITTENTLY. IN ADDITION, THE CONTACT STATED THAT THE KEY PAD LOCATED ON THE DRIVER SIDE DOOR FAILED TO OPERATE. AS A RESULT, THE CONTACT WAS UNABLE TO ACCESS THE VEHICLE. THE VEHICLE WAS T... Read more

Incident date: Jul 16, 2016

Showing 50 of 91 complaints.

NHTSA Safety Ratings — 2011 FORD EXPEDITION

2011 Ford Expedition SUV 4x4

Category	Rating
Rollover	4 / 5 ★★★★☆
Rollover Risk	19.8%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins — 2011 FORD EXPEDITION

78 manufacturer communications from 35 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	8
110000 ELECTRICAL SYSTEM	6
100000 POWER TRAIN	5
060000 ENGINE (PWS)	4
160000 STRUCTURE	4
061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER	3
061000 ENGINE AND ENGINE COOLING:ENGINE	3
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	3

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

100000 POWER TRAIN

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IW

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Certain 2011 - 2013 Model Year F-150 and 2012- 2013 Model Year Expedition/Navigator Vehicles Equipped with A 6R80 Transmission Transmission Molded Leadframe Extended Coverage In some of the affected vehicles, an output shaft speed (OSS) se

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (

200000 WHEELS

350000 EQUIPMENT

160000 STRUCTURE

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi

132000 VISIBILITY:GLASS, SIDE/REAR

Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid

130000 VISIBILITY

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/tran

350000 EQUIPMENT

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo

160000 STRUCTURE

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

060000 ENGINE (PWS)

Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam

350000 EQUIPMENT

Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Linco

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No re

353000 EQUIPMENT:ELECTRICAL

The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

2009-2017 VEHICLES EQUIPPED WITH A 6R80, 6R100, 6R140 AUTOMATIC TRANSMISSION HAVE AN UPDATED MAIN CONTROL VALVE BODY OVERHAUL PROCEDURE. REFER TO WORKSHOP MANUAL (WSM), SECTION 307-01 FOR MAIN CONTROL VALVE BODY (7A100) OVERHAUL PROCEDURES.

162900 STRUCTURE:BODY:ROOF AND PILLARS

SOME 2011-2016 EXPEDITION AND NAVIGATOR VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE ROOF OPENING PANEL SHIELD WHILE DRIVING OVER BUMPS. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION.

030000 BRAKES (PWS)

SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. IF THE

030000 BRAKES (PWS)

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

060000 ENGINE (PWS)

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

060000 ENGINE AND ENGINE COOLING

061000 ENGINE AND ENGINE COOLING:ENGINE

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

FORD 2011-2015 F-150 EXPEDITION , TRANSIT,2015 LINCOLN NAVIGATOR: SOME VEHICLES EQUIPPED WITH 3.5L GASOLINE TURBOCHARGED ARE EXPERIENCING MULTIPLE DIAGNOSTIC CODES & NOISES OR SURGING DRIVING SYMPTOMS. *LJ

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR SUNROO

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

FORD 2011-2015 F150, 2015 EXPEDITION, TRANSIT, 2015 LINCOLN NAVIGATOR: CERTAIN VEHICLES EQUIPPED WITH A 3.5 L GASOLINE TURBOCHARGED DIRECT INJECTED ENGINE BUILT ON 2/28/2015 MAY HAVE DIAGNOSTIC CODES OR DRIVEABILITY SYMPTOMS. *LJ

100000 POWER TRAIN

FORD: AFTER POWERTRAIN CONTROL MODULE REPROGRAMMING, THE MALFUNCTION INDICATOR LAMP (MIL) IS ON WITH SEVERAL DIAGNOSTIC TROUBLE CODES (DTC) P06B8, P068A, P2610, IF KEY NOT LEFT FOR 30 SECONDS IN OFF POSITION FOLLOWING PROGRAMMING ON SOME M

118000 ELECTRICAL SYSTEM:SOFTWARE

356000 EQUIPMENT ADAPTIVE/MOBILITY

FORD/LINCOLN: THERE WILL BE 2 NEW PIECE RECEIVER DRYER DESICCANT BAG THAT WILL REPLACE 1 PIECE RECEIVER DRY CARTRIDGE, WHICH ARE INTERCHANGABLE, FULLY, DO NOT AFFECT FORM, FIT, OR FUNCTION. MODEL 2011-14 F-SUPER DUTY, 2009-14 F150, 2007-1

060000 ENGINE (PWS)

LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE

060000 ENGINE (PWS)

FORD/LINCOLN: SOME TRUCKS ARE EXPERIENCING DIAGNOSTIC TROUBLE CODES (DTC) P2270 OR P2272, MALFUNCTION INDICATOR LAMP (MIL) COMES ON. MODEL 2010-2011 RANGER, 2010-2012 E SERIES, EXPEDITION, F-150, F-SUPER DUTY, NAVIGATOR. *PE

110000 ELECTRICAL SYSTEM

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

LINCOLN/FORD: AFTER VEHICLE/TRUCK HAS BEEN PARKED SEVERAL HOURS, THERE IS A DELAYED ENGAGEMENT OF PARK TO FORWARD OR REVERSE TRANSMISSION ON INITIAL START UP. MODEL 2011-2014 EXPEDITION, MUSTANG, F-150, NAVIGATOR. *PE

204000 WHEELS:HUB

FORD: THERE IS A NOISE COMING FROM THE FRONT HUB INTEGRATED WHEEL END (IWE) AREAS AND WHEN SHIFTED INTO 4X4 MODE, THE NOISE WILL CEASE. MODELS 2008-2013 F-150, EXPEDITION, NAVIGATOR, MARK LT. *PE

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

LINCOLN/FORD: ON CERTAIN VEHICLES AND TRUCKS, THE MULTIFUNCTION INDICATOR LAMP (MIL), WILL ILLUMINATE WITH DIAGNOSTIC TROUBLE CODE (DTC) P1636 (INDUCTIVE SIGNATURE CHIP COMMUNICATION ERROR) PRESENT IN PCM OR TCM. MODELS 2011-2013 F-150 E

356000 EQUIPMENT ADAPTIVE/MOBILITY

FORD: ON VARIOUS VEHICLES WITH MY TOUCH,AFTER ANY APIM PROGRAMMING, REPLACEMENT OR DISCONNECT FROM FRONT DISPLAY INTERFACE MODULE (FDIM), TOUCHSCREEN CALIBRATION MUST BE PERFORMED. MODEL YEARS 2011-2013. NO MODELS LISTED.

350000 EQUIPMENT

061000 ENGINE AND ENGINE COOLING:ENGINE

FORD: AFTER REFUELING VEHICLE, WOULD BE HARD TO START, RUNS ROUGH AND AN AUDIBLE CLICKING NOISE CAN BE HEARD. *PE

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

FORD: THERE MAY BE HIGH STEERING EFFORT OR LACK OF ASSIST. *RM

016000 STEERING:ELECTRIC POWER ASSIST SYSTEM

FORD: THERE MAY BE HIGH STEERING EFFORT OR LACK OF ASSIST. *RM

010000 STEERING

FORD: THERE MAY BE HIGH STEERING EFFORT OR LACK OF ASSIST. *RM

118000 ELECTRICAL SYSTEM:SOFTWARE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

100000 POWER TRAIN

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

061000 ENGINE AND ENGINE COOLING:ENGINE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

046000 SERVICE BRAKES, AIR:ANTILOCK

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

FORD: THERE MAY BE A LOSS OF POWER, HESITATION, SURGE, OR LACK OF THROTTLE RESPONSE WHILE DRIVING. THE BRAKE OVER ACCELERATOR FEATURE MAY BE ACTIVATING. *RM

NHTSA Safety Investigations — FORD EXPEDITION

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

RQ — Closed — Model Year: 2013

Unexpected Transmission Downshift

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports rel... ated to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.Read more

PE — Closed — Model Year: 2004

STEEL WHEEL FRACTURE

FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-200... 6 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER CRead more

EA — Closed — Model Year: 2001

WINDSHIELD LEAK CAUSES ELECTRIC FAILURES

CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN... Read more

PE — Closed — Model Year: 2000

ELECTRICAL SYSTEM FAILURE

ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).... Read more

PE — Closed — Model Year: 2000

SPEED CONTROL DEACTIVATION SWITCH FIRE

IN ITS LETTER DATED JANUARY 27, 2005 TO ODI, FORD INDICATED THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL # 05V-017) TO REMEDY AN OVERHEATING SPEED CONTROL DEACTIVATION SWITCH IN APPROXIMATELY 738,490 SUBJECT VEHICLES.THE VEHICLES AFFECTED BY THE RECALL ARE CERTAIN 2000 MODEL YEAR (MY) FORD F1... Read more

RQ — Closed — Model Year: 2001

FRONT SEAT BELT BUCKLE ASSEMBLY

UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUC... Read more

PE — Closed — Model Year: 1998

FRONT STABILIZER LINK

PE — Closed — Model Year: 1998

TIE ROD END FAILURES

There is no summary currently available

FORD EXPEDITION — All Years Overview

Complete safety history for the FORD EXPEDITION across all model years (1997–2027).

1,032 Total Recalls

11,534 Total Complaints

8 Investigations

729 Reported Crashes

834 Reported Fires

56 Reported Deaths

FORD EXPEDITION — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2027	16	0	View
2026	16	3	View
2025	36	32	View
2024	34	89	View
2023	106	81	View
2022	124	143	View
2021	112	242	View
2020	178	441	View
2019	112	537	View
2018	122	434	View
2017	34	455	View
2016	26	268	View
2015	30	227	View
2014	0	93	View
2013	0	113	View
2012	8	161	View
2011 (current)	0	91
2010	0	74	View
2009	1	42	View
2008	4	179	View
2007	2	267	View
2006	6	395	View
2005	5	452	View
2004	4	381	View
2003	6	800	View
2002	4	415	View
2001	10	739	View
2000	11	1,134	View
1999	9	1,137	View
1998	7	1,022	View
1997	9	1,065	View
1996	0	3	View
1995	0	1	View
1994	0	4	View
1993	0	1	View
1991	0	1	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-150	692	46,142	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View