2023 FORD ESCAPE

11 recalls, 154 complaints - 90 TSBs - 5/5 safety rating

ELECTRICAL SYSTEM

Defect Description

Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is pa... Read more

Consequence

An overheated engine block heater can increase the risk of a fire.

Remedy

Dealers will replace the block heater element and inspect the electrical cord, replacing it if necessary, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug coupled, and remove the block heater electrical cord. Owner notifi... Read more

6,781 vehicles affected

Manufacturer: Ford Motor Company

ENGINE

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine ... Read more

Consequence

An engine compartment fire increases the risk of injury.

Remedy

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners... Read more

1,809 vehicles affected

Manufacturer: Ford Motor Company

ENGINE

Defect Description

Ford Motor Company (Ford) is recalling certain 2023-2025 Escape, and 2025 Bronco Sport vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.

Consequence

An oil leak can result in loss of drive power, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy

Dealers will replace the cylinder head assembly as necessary, free of charge. Owner notification letters were mailed August 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S61.

404 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION:SOFTWARE

Defect Description

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicle... Read more

Consequence

A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety... Read more

1,076,138 vehicles affected

Manufacturer: Ford Motor Company

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Consequence

Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy

Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may conta... Read more

20,484 vehicles affected

Manufacturer: Ford Motor Company

EQUIPMENT:OTHER:LABELS

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requiremen... Read more

Consequence

Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy

Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

27,678 vehicles affected

Manufacturer: Ford Motor Company

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

Defect Description

Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.

24 vehicles affected

Manufacturer: Ford Motor Company

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Defect Description

Ford Motor Company (Ford) is recalling certain 2023-2024 Escape two-wheel drive vehicles equipped with adaptive cruise control. The cruise control radar module was misaligned during production.

Consequence

Misalignment of the radar module can result in the Adaptive Cruise Control (ACC) misclassifying an overhead object as an object in the vehicle's path, causing the vehicle to unexpectedly slow and/or stop. Other safety systems that depend on the radar model (Pre-Collision Assist, Forward Collision W... Read more

Remedy

Dealers will adjust the angle of the radar module, free of charge. Owner notification letters were mailed July 3, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S39.

209 vehicles affected

Manufacturer: Ford Motor Company

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

Ford Motor Company (Ford) is recalling certain 2023 Escape, Super Duty F-250, Super Duty F-350, Super Duty F-450, and Super Duty F-550 vehicles equipped with a digital instrument panel cluster. The module may have been improperly soldered, preventing the instrument panel from illuminating. As such... Read more

Consequence

An inoperable instrument panel cannot show critical safety information, such as the speedometer or warning lights, which may increase the risk of a crash.

Remedy

Dealers will replace the module or instrument panel as necessary, free of charge. Owner notification letters were mailed on November 4, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C25.

38,695 vehicles affected

Manufacturer: Ford Motor Company

ENGINE

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources s... Read more

Consequence

An engine compartment fire increases the risk of injury.

Remedy

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powert... Read more

125,322 vehicles affected

Manufacturer: Ford Motor Company

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Consequence

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy

Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. ... Read more

521,746 vehicles affected

Manufacturer: Ford Motor Company

Complaint Statistics

154 total complaints 7 crashes 4 fires 3 injuries

Top Reported Components

Component	Complaints
ENGINE	28
POWER TRAIN	18
ELECTRICAL SYSTEM	17
UNKNOWN OR OTHER	15
STEERING	11
FUEL/PROPULSION SYSTEM	11
SERVICE BRAKES	8
SUSPENSION	6
VEHICLE SPEED CONTROL	5
EXTERIOR LIGHTING	3

Incident date: Aug 21, 2026

**On August 19, 2026, while driving my 2023 Ford Escape on Interstate 57 (I-57), with approximately 35,575 miles on the vehicle, the vehicle suddenly accelerated unexpectedly. I immediately attempted to apply the brakes, but the vehicle did not respond as expected and I could not stop it immediately... Read more

Incident date: Aug 21, 2026

Incident date: Jan 27, 2026

The vehicle has 38000 miles now. At about 34000 miles I began to notice a slight rumble from the read end of the car when starting from a stop and making a turn. It has become more noticeable recently. It is only noticeble from a stop and below about 10 mph.After doing some searches online, I hav... Read more

Incident date: Jun 10, 2026

The contact owns a 2018 Lincoln Navigator. The contact stated that while driving at 70 MPH, the transmission seized, and the vehicle failed to accelerate. The contact stated that several unknown warning lights were illuminated during the failure. Additionally, the brake warning light was illuminated... Read more

Incident date: Jun 25, 2026

There was an intersection, I hit a car head on and no airbags went off

Crash 1 injured

Incident date: Jun 22, 2026

While driving at highway speeds, the vehicle experienced a sudden and total loss of engine power and stalled in active traffic. I lost motive power and had to safely coast through traffic to the shoulder. The vehicle would not restart and had to be towed to a repair facility. The failure matches the... Read more

Incident date: Jun 1, 2026

I was driving in 4 lane town traffic going under 10 MPH and the hazard lights came on by themselves, and the car died. Propulsion stopped. Fortunately I was able to pull onto a striped median, and once I was over shock, 3-5 ish minutes, I started the car and drove to the dealership. I don’t reme... Read more

Incident date: Feb 2, 2026

I was driving on the highway and I wanted to pass someone the car cut power and was not accelerating and the car slowed down. I went to a mechanic shop and they said there was an internal brake sensor failed and brake booster failure.

Incident date: Feb 2, 2026

For my 2019 BMW X5 SDRIVE40i, The A/C evaporator core failed and began leaking refrigerant, resulting in complete loss of cold air from the A/C system. The vehicle had approximately 50,000 miles. The repair required full dashboard removal and cost approximately $4,500 including a rental vehicle. Th... Read more

Incident date: Feb 2, 2026

Incident date: May 12, 2026

After my Hyundai dealership performed a recall on emissions my Santa Fe Sport started having problems on cold starts. After it has set for a few hours when I would put into gear and start to driving the car acted as though it was trying to flood out. I have to feather the accelerator and drive ver... Read more

Incident date: May 12, 2026

The contact owns a 2026 Mazda CX-5. The contact stated while driving at an undisclosed speed, the instrument cluster displayed a black screen. The contact stated that several warning lights were illuminated. The dealer was made aware of the failure. In addition, the contact was informed that the fai... Read more

Incident date: Apr 1, 2026

While driving the vehicle information system (speedometer, tach, fuel, etc.) goes dark for several minutes. It comes back then it goes out again.

Incident date: Apr 1, 2026

I am getting the known P0128 code. My engine says it's cold when it's not, my AC isn't working, and I am getting a message that says "Steer assist reduced. Drive with care". This is a known problem and complaint of the GMC Acadia.

Incident date: Apr 1, 2026

The contact owns a 2017 Land Rover Range Rover. The contact received a recall notification, NHTSA Campaign Number: 25V514000 (Steering) however the parts were unavailable. The dealer was contacted, however the contact was informed that the parts were unavailable. The manufacturer was contacted, the ... Read more

Incident date: May 14, 2026

Safety recall was issued on November 2024. As of May15, 2026, there is no fix or parts available. Having a vehicle disabled for an unresolved safety recall for this amount of time is unacceptable.

Incident date: May 14, 2026

The steering is tight/sticking when I back out of my driveway or drive slowly around turns. It does seem stiff on highway speeds as well. Also my auto stop start check light is on about 2 months after replacing both batteries and I did have the recall somewhat associated with this completed

Incident date: Mar 1, 2025

The contact owns a 2012 Honda CR-V. The contact stated that while driving at 30 MPH approaching a red light, the rear trailing arm detached from the tire. No warning lights were illuminated. The driver was able to dive to a parking lot. The vehicle was transported on a trailer by her father. The fro... Read more

Incident date: May 1, 2026

While pulling into a residential parking space at low speed, the vehicle (2023 Ford Escape) suddenly accelerated unexpectedly without additional throttle input. The acceleration was abrupt and forceful, and I was unable to stop the vehicle before it struck the structure in front of the parking space... Read more

Crash

Incident date: May 1, 2026

Crash

Incident date: May 1, 2026

Crash

Incident date: Apr 23, 2026

I own a 2016 Ram 1500 EcoDiesel, VIN [XXX] . The vehicle has been in and out of Rydell Jeep & Ram dealership over 3 times in the last few months for fuel pump issues. It has been at the dealership for over a month total (in and out). Each time I have had to pay for towing and rental cars. I have not... Read more

Incident date: Mar 28, 2026

When driving a message popped up to "Service Shifter" and all the red lights turned on the shifter. I was unable to switch out of thus screen to bring the digital odometer back up like when other service message appear. When I was able to pull over and turn off the car and wait and turn it back o... Read more

Incident date: Mar 20, 2026

I can't unscrew 4 lug nuts on my rear wheel. I was able to remove just one bought extra tool try to remove them all. Material is like butter, not steel. How engineering could let material like that to be used. I found on the web that a dealer wonna $400 to remove that lugs....

Incident date: Dec 5, 2025

The contact owns a 2024 Ford F-150. The contact stated that while driving at 30 MPH, there was a strong vibration coming from the vehicle while decelerating from 30 MPH to 20 MPH. The contact stated that the failure was previously repaired but reoccurred and became worsened. The vehicle remained at ... Read more

Incident date: Mar 20, 2026

In January 2026 I received a recall notice (NHSTA # 25V900) from Audi USA regarding a potential malfunction in the rear-view camera system of my 2019 Audi A7. The notice stated this would be corrected by a dealer of my choice making a software update, and that the work would take a maximum of one-h... Read more

Incident date: Nov 20, 2023

I had parked my car in a spot at an office building. As I was about to put the vehicle in park it lurched forward going over a standard curb across a sidewalk and then into the brick wall of the building. The air bag did not deploy. The car lurched about ten feet total before hitting the wall.

Crash

Incident date: Mar 21, 2026

Suspected ICCU failure. Progressed rapidly to car being immobile. Known issue not being addressed by Hyundai.

Incident date: Mar 21, 2026

Suspected ICCU failure. Progressed rapidly to car being immobile. Known issue not being addressed by Hyundai.

Incident date: Mar 7, 2026

I was driving south on interstate 15 freeway I was on the 3 lane in the middle of the road I was driving around 65-70 mph when my 1500 Silverado 2016 loose engine power and started to slow down I couldn’t get out fast enough and I almost got hit by three cars because I was driving so slow I pulle... Read more

Incident date: Mar 5, 2026

Driving to work, going into a turn with no obstructions my car frequently alerts to a "collision warning" that is not there. Additionally, I have been driving on the highway, with no obstructions in front of me and my car emergency brake despite an emergency not being present. In both instances,... Read more

Incident date: Mar 5, 2026

Incident date: Feb 27, 2026

I rented this car from Fox Rental Cars at Seatac Airpot between 2/18/26 and returned 2/23/26. While in the AUTO setting for headlights, the high beams suddenly shut off and quick working. Then the tail lights quit working. I did not know the tail lights were inoperable until I was pulled over. W... Read more

Incident date: Jan 8, 2026

The contact owns a 2024 BMW I4. The contact stated that while driving 25-50 MPH in the intended lane, the vehicle vibrated and was drifting out of the intended lane. The contact was able to correct the vehicle back into the intended lane. Additionally, the contact stated while driving and approachin... Read more

Incident date: Feb 20, 2026

The contact owns a 2018 Ram 2500. The contact stated that while driving at an undisclosed speed, the traction control and the 4WD features were inoperable. The contact received notification of NHTSA Campaign Number: 24V896000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was... Read more

Incident date: Feb 20, 2026

I have had my car since January of 2023 and I have had no significant issues. I bought the car with roughly 30,000 miles, fast forward to February of 2026 it has about 123,000 miles and the engine is burning oil very fast. My car loses oil so fast the oil light comes on way early before my next oil ... Read more

Incident date: Feb 20, 2026

Incident date: Jul 1, 2024

I bought the equinox with 30,000 miles on it. It's at 67,000 now and I maintain the vehicle regularly. So why have I replaced the throttle body already because it gets dirty fast? And now I'm getting a check engine light for P2099 TurboCharger Underboost. When the vehicle is not old it's 5 years old... Read more

Incident date: Jul 1, 2024

The contact owns a 2026 Volvo VNL4. The contact stated that the front lift axle lowered unintendedly while in the travel position. The computer sensed the abnormal weight while driving in high winds. While driving in snow, rain, and wind, the contact was concerned about a crash while driving the veh... Read more

Incident date: Dec 15, 2025

Air bag front impact sensor are no longer available from manufacturer. Airbag system in inoperable.

Incident date: Dec 15, 2025

I am writing this letter to formally document a series of catastrophic safety failures and gross negligence regarding my 2018 Hyundai Tucson. On two separate occasions, including as recently as Wednesday, February 11, 2026, I narrowly escaped a fatal high-speed collision because this vehicle entered... Read more

Incident date: Dec 15, 2025

What component or system failed or malfunctioned, and is it available for inspection upon request? The passenger side wiper stopped wiping, the arm is not moving up and down, yes How was your safety or the safety of others put at risk? This is causing the passenger side windshield to not be cleaned ... Read more

Incident date: Jan 31, 2024

My 2016 dodge dart is losing all fluids after putting fluids in the car . My back calipers keep coming off the system , my hose keep detaching or blowing off. Losing power and it's not shifting . I have called dodge and ford where I purchased the car , I also made reports with corporate office of de... Read more

Incident date: Dec 7, 2025

I was driving my 2022 gmc Sierra with the 6.2 engine 10 speed transmission and I was at at a red light, the light turned green and I went to go and I could feel my rear wheels lock up and then it released went into limp mode was not shifting gears correctly and I had no reverse

Incident date: Jun 2, 2025

Truck def system error derates vehicle speed to 5mph in 85 miles. This is unacceptable as no dealerships are open on weekends or in the middle of nowhere. This EPA rule will get folks killed as folks driving 5mph on freeway towing a big trailer will get run into real quick. Vehicle should NOT cause ... Read more

Incident date: Jun 2, 2025

The contact owns a 2020 Jeep Cherokee. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The message "Service 4WD System" was displayed on the instrument panel. The vehicle was taken to the dealer; however, no cause for the failure was found. ... Read more

Incident date: Jun 2, 2025

the rear manual tailgate has opened 3 times while the vehicle was at highway speeds and the doors would be locked. the latest incident happened on 1-30-26, at highway speed (70mph) the tailgate opened completely without warning. the indicator on the dash did light up and an alarm did sound. I had... Read more

Incident date: Jan 22, 2026

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving at 65 MPH, the vehicle vibrated and failed to accelerate as intended while depressing the accelerator pedal. Additionally, the vehicle failed to exceed 40 MPH. The contact was able to pull over into a rest area. ... Read more

Incident date: Jan 21, 2026

Vehicle experiences intermittent but repeatable safety-related electrical failures affecting turn signals and blind spot monitoring. The left turn signal remains engaged after canceling and does not shut off unless the opposite turn signal is activated, causing incorrect signaling to other drivers. ... Read more

Showing 50 of 154 complaints.

NHTSA Safety Ratings, 2023 FORD ESCAPE

2023 Ford Escape SUV AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	17.4%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard & Optional
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2023 FORD ESCAPE

90 manufacturer communications from 58 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	17
350000 EQUIPMENT	8
100000 POWER TRAIN	7
060000 ENGINE AND ENGINE COOLING	5
980000 UNKNOWN OR OTHER	5
118000 ELECTRICAL SYSTEM:SOFTWARE	4
170000 LATCHES/LOCKS/LINKAGES	4
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	4

110000 ELECTRICAL SYSTEM

Software Update 23-PU0630-SX2-CLS for 2023 MY Escape vehicles is now available. Quality Improvements include: - SYNC screen will update after changing to next track from USB device. - Improves minor occurrence of gauge flicker once in

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

100000 POWER TRAIN

Some 2023-2024 Escape/Corsair vehicles equipped with a 1.5L or 2.0L EcoBoost engine, 2024 Mustang vehicles equipped with a 2.3L EcoBoost engine, and 2024 Nautilus vehicles may exhibit an engine misfire condition with diagnostic trouble code

110000 ELECTRICAL SYSTEM

Quality improvements include: Numerous minor quality fixes in ECG RC9 which are not customer facing.

980000 UNKNOWN OR OTHER

Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or la

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Customer Satisfaction Program 22N15 Certain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gatewa

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To co

060000 ENGINE AND ENGINE COOLING

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

Some 2021-2024 Bronco/F-150, 2023-2024 Escape/F-Super Duty vehicles equipped with SYNC 4 may experience a concern during accessory protocol interface module (APIM) programming where the vehicle's center display screen indicates USB Error. T

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

100000 POWER TRAIN

During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Some 2023 Escape vehicles built on or before 10-Jul-2023 and equipped with a 12 inch instrument panel cluster (IPC) display may exhibit a roundabout/traffic circle arrow directing the traffic to go to the left (clockwise) around the roundab

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

170000 LATCHES/LOCKS/LINKAGES

Advance Notice - Customer Satisfaction Program 23B56 Certain 2020 - 2023 Model Year Escape Vehicles - Front Door Check-Arm Reinforcement Broken Spot Welds

350000 EQUIPMENT

2022-2024 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2024 Expedition/Navigator vehicles built on or after 08-Jun-2022, 2022-2024 Escape vehicles built on or after 01-Jun-2022 and 2022 Corsair vehicles built on or after 01

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

353000 EQUIPMENT:ELECTRICAL

Some 2023 Escape vehicles may exhibit a Front Camera Fault and/or Pre-Collision Assist Fault message displayed in the instrumental panel cluster (IPC) with diagnostic trouble codes (DTCs) C1001:78 and U2107:68 stored in the image processing

110000 ELECTRICAL SYSTEM

Software Update 23-PU0630-RGT-PLO for 2023 MY Escape vehicles is now available. Quality Improvements include: - Liftgate opens fully open with exterior button press

280100 BACK OVER PREVENTION:SOFTWARE

Software Update 23-PU0630-RGT-PLO for 2023 MY Escape vehicles is now available. Quality Improvements include: - Liftgate opens fully open with exterior button press

110000 ELECTRICAL SYSTEM

Software Update 24-PU0122--SPB-PUP for 2023 MY Escape Gas vehicles is now available. Quality Improvements include: - Reduced no start events. - Quicker brake release when customer shifts to R - Remembers Auto Vehicle Hold status thr

280100 BACK OVER PREVENTION:SOFTWARE

110000 ELECTRICAL SYSTEM

Some 2023 Escape/Corsair vehicles built on or before 07-Sep-2023 may exhibit an intermittent no crank/no start condition with various lost communication diagnostic trouble codes (DTCs) stored in various modules and multiple illuminated warn

060000 ENGINE AND ENGINE COOLING

Some 2023-2024 Escape vehicles built on or before 11-Jan-2024 equipped with 1.5L engines may exhibit an Engine Coolant Over-Temperature Warning message displayed in the IPC and an illuminated malfunction indicator lamp (MIL) with diagnostic

110000 ELECTRICAL SYSTEM

Some 2023 Escape vehicles equipped with a head up display (HUD) built on or before 16-Oct-2023 may exhibit a condition where the speed limit sign indicator is not displayed in the HUD. This may be due to the software installed in the HUD mo

110000 ELECTRICAL SYSTEM

Software Update SU6 P1 for 2023 MY Escape vehicles is now available. Quality Improvements include: - Removal of BlueCruise map expiration - Allow Vehicle entry during OTA. - Adds a "some display features may be temporarily unavailabl

110000 ELECTRICAL SYSTEM

This article supersedes TSB 23-2275 to add Step 3 to the Service Procedure, add P0402 and remove the production fix date. Some 2023 Escape/Corsair vehicles equipped with a 2.0L EcoBoost engine may exhibit an illuminated malfunction indicato

280100 BACK OVER PREVENTION:SOFTWARE

980000 UNKNOWN OR OTHER

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

118510 ELECTRICAL SYSTEM:ADAS:PARKING ASSIST:SOFTWARE

980000 UNKNOWN OR OTHER

Some 2023 Escape vehicles equipped with 1.5L engines may exhibit an Engine Coolant Over-Temperature Warning message displayed in the instrumental panel cluster (IPC) and an illuminated malfunction indicator lamp (MIL) with diagnostic troubl

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

280000 BACK OVER PREVENTION

Various 2021-2024 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit a Please Check Surroundings For Safety or Full View Not Available message when the rear camera button is pressed and the vehicle is not

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Certain 2023 Model Year Escape Vehicles - Odometer Mileage Correction

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial (feet and miles) units and not being able to change to metric (meters and kilometers) uni

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

350000 EQUIPMENT

Some 2023 Escape vehicles may exhibit various warning messages displayed in FordPass such as: check fuel cap, glow plug pre-heater fault, exhaust system fault, change air filter soon, air suspension fault, clean the exhaust filter, check fu

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

Certain 2023 Model Year Escape and Corsair Vehicles Equipped with a 2.0L Engine - Seal Replacement for Turbocharger Coolant Return Tube to Cylinder Head

980000 UNKNOWN OR OTHER

Some 2023 Escape vehicles equipped with a 12 inch instrument panel cluster (IPC) display may exhibit a roundabout/traffic circle arrow directing the traffic to go to the left (clockwise) around the roundabout. This is incorrect and opposite

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

110000 ELECTRICAL SYSTEM

Some 2023 Escape/Corsair vehicles built on 6-Apr-2023 and through 11-May-2023 and 2023 Bronco Sport/Maverick vehicles built on 30-Jan-2023 and through 6-Jun-2023 may exhibit an illuminated air bag warning indicator with DTC B0082:1A stored

140100 AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

140110 AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE:SOFTWARE

274100 LANE DEPARTURE: LANE KEEP: AUTOMATIC STEERING

Some 2020-2023 Escape/Corsair vehicles may exhibit a condition where the vehicle drifts left and right within the vehicle's lane while the lane keeping assist is active. The lane keeping aid assists the driver by providing steering torque t

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

Software Update SU4 P2 for Escape is now available. Quality Improvments include: - Various Apple Carplay quality improvements

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

Software Update SU4 P2 for Escape is now available. Quality Improvments include: - Various Apple Carplay quality improvements

103910 POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:BEARINGS/BUSHINGS

Some 2020-2023 Escape and 2021-2023 Bronco Sport vehicles may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity. This may be due to the suspension sensitivity of the vehicle. To correct this

350000 EQUIPMENT

045100 SERVICE BRAKES, AIR:DISC:CALIPER

046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

Some 2023 Escape, Corsair, Bronco Sport and Maverick vehicles built on 01-May-2023 and through 22-Sep-2023 may exhibit a squeal and/or grinding noise and/or vibration from the front brakes while braking. This may be due to excessive wheel h

350000 EQUIPMENT

080000 FUEL SYSTEM, DIESEL

2022-2023 Escape and Bronco Sport vehicles equipped with 1.5L engines should add local fuel once the vehicle arrive to the dealership to reduce the risk of driving performance issues such as: rough operation, idle quality, engine misfires,

162800 STRUCTURE:BODY:HOOD

Some 2020-2023 Escape/Corsair vehicles may exhibit a door ajar warning indicator or higher than expected efforts to fully close doors. Verify the hood/liftgate are not open. Confirm all doors are fully closed and latches are fully engaged.

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

162300 STRUCTURE:BODY:DOOR

170000 LATCHES/LOCKS/LINKAGES

110000 ELECTRICAL SYSTEM

Some 2021-2023 Ford and Lincoln vehicles may exhibit DTCs U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detect

060000 ENGINE AND ENGINE COOLING

Some 2022-2023 Bronco Sport/Escape vehicles equipped with a 1.5L engine and 2022-2023 Corsair vehicles equipped with a 2.5L engine, built on 01-Sep-2022 and through 06-Apr-2023, may exhibit a low coolant level with engine oil in the coolant

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Some 2023 Escape/Corsair vehicles built on or before 25-May-2023 equipped with a 2.0L EcoBoost engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0300 and/or P0316. This may be due to th

170000 LATCHES/LOCKS/LINKAGES

Some 2023 Escape vehicles built on or before 03-May-2023 and not equipped with a keyless entry keypad may exhibit the door keypad code menu item being shown in vehicle settings menu of the center display screen. This may be due to the confi

110000 ELECTRICAL SYSTEM

118000 ELECTRICAL SYSTEM:SOFTWARE

110000 ELECTRICAL SYSTEM

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Some 2021-2023 Bronco Sport and 2020-2023 Escape vehicles may exhibit a rattle or flapping noise coming from the rear air extractors while driving. This may be due to the normal operation of the rear air extractors. To determine if this is

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Some 2023 Escape vehicles equipped with a 12 inch instrument panel cluster (IPC) display may exhibit a roundabout/traffic circle arrow directing the traffic to go to the left (or clockwise) around the roundabout. This is incorrect and oppos

110000 ELECTRICAL SYSTEM

In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app thr

100000 POWER TRAIN

Some 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contaminat

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

980000 UNKNOWN OR OTHER

100000 POWER TRAIN

Some 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with the 1.5L engine may exhibit a lugging vibration and/or boom noise while driving in gears 5-8 at approximately 1500 engine revolutions per minute (RPM). This may be felt

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

Some 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (D

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial units and not being able to change to metric. This may be due to the software level of th

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Some 2023 Escape vehicles built on or before 6-May-2023 may exhibit a condition where the power liftgate does not close when using the power liftgate control switches. The vehicle may exhibit diagnostic trouble codes B1454 and/or B1455. Pri

160000 STRUCTURE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical serv

100000 POWER TRAIN

Some 2022-2023 F-150/Bronco/Expedition/Navigator/Escape/Corsair/Bronco Sport/Edge/Mustang vehicles built on 04-Sep-2022 and through 30-Dec-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC)

110000 ELECTRICAL SYSTEM

2020-2023 Escape/Explorer, 2021-2023 F-150 and 2022-2023 Maverick vehicles equipped with a full hybrid electric vehicle (FHEV) powertrain may exhibit a cable connection error screen from the Midtronics xRC-3363 High Voltage Battery Rescue C

170000 LATCHES/LOCKS/LINKAGES

Some 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles may exhibit a condition where the door(s) do not open using the exterior door handle(s). This may be due to an enabled permanent engagement inertia lock w

350000 EQUIPMENT

This article supersedes TSB 22-2278 to update the vehicle model years affected and the part list. For 2020-2023 Escape/Corsair vehicles, the roof opening panel frame mechanism kits have been released for service. These components can now be

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

2023 F-150/Escape/Explorer/Maverick vehicles equipped with a full hybrid electric vehicle (FHEV) powertrain may exhibit diagnostic trouble codes (DTCs) P0A7D and/or P0DE6 and the vehicle identification number (VIN) is not recognized by the

100000 POWER TRAIN

Some 2018-2022 Ford and Lincoln vehicles equipped with the 8F35 transmission built on or before 16-Mar-2022 may exhibit transmission slip during acceleration from a stop when hot. This may be due damaged internal case half pump seals (7N265

NHTSA Safety Investigations, FORD ESCAPE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2020

Failed Door Check Arm Attachment Point

On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. T... o date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

AQ, Open , Model Year: 2021

Healey Brothers Ford / Open Recall Sale

NHTSA is opening this audit query to investigate whether Healey Brothers Ford, LLC of Beacon, New York, has complied with the requirements of the National Traffic and Motor Vehicle Safety Act. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to m... Read more

PE, Closed , Model Year: 2013

Loss of Motive Power

On July 16, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) to investigate alleged instances of sudden stalling without warning on model year (MY) 2013 Ford Escape vehicles equipped with 1.6L GTDI turbocharged engines. Complaints alleged that vehicles stalled ... due to engine overheating, resulting in a delayed or no restart condition. When the investigation was opened, ODI had received 40 Vehicle Owner Questionnaires (VOQs). At this time, ODI has received 173 VOQs with five reported fires and no reported crashes. In investigating the incidents alleged in the VOQs, ODI revisited an apparently related recall that Ford had issued in November 2013 (Recall 13V-583). In Recall 13V-583, Ford recalled all MY 2013 Ford Escape vehicles equipped with the 1.6L engines, built from October 5, 2011, to June 2, 2013. This recall addressed potential engine compartment ﬁres due to localized overheating of the engine cylinder head leading to cracks that can cause oil leaks onto a hot engine surface. The remedy was to provide several enhancements to the engine shielding, cooling and control systems, which involved recalibration of the powertrain calibration module and the instrument cluster system. The recalibration implemented a “Failure Mode Eﬀects Management” (FMEM) strategy to alert the driver of a low coolant state and limit the power to the engine to prevent overheating to the point of cracking the cylinder head. The FMEM strategy includes a “Low Engine Coolant – Service Required” message in the instrument cluster when the coolant reaches a prescribed low level and the engine continues to perform normally, and a coolant level sensor that was incorporated such that if the coolant level is further reduced, the engine enters a reduced power mode (vehicle speed limited to about 40 mph). If the vehicle is driven farther and coolant is not added to the vehicle, the vehicle enters a further reduced power mode and audible and visual alerts will appear and sound, and the engine will be limited to operation at idle speeds. ODI sent Ford an information request letter in August 2018, and, in April 2021, additionally required that Ford provide an update of its ﬁeld and warranty data. In response, Ford provided 4,047 customer complaints, ﬁeld reports, and legal claims, consisting of 3,865 unique VINs, and 47,214 warranty claims, consisting of 33,684 unique VINs. Having had repeated discussions with ODI, Ford eventually binned all 4,047 post-recall reports and all 47,214 warranty claims to those that relate to loss of motive power due to coolant loss. Having so binned these reports and claims, Ford reported that the relevant number dropped to 227 reports with 222 unique VINs and 2,774 warranty claims with 1,875 unique VINs. In analyzing its own responsive data, Ford maintained that the remedy for Recall 13V-583 adequately addresses the risk of loss of motive power resulting from an engine overheat due to low coolant by providing clear warnings and progressive reduced power FMEM strategies. Ford further maintained that some complaints imply that the vehicles properly displayed the advanced and progressive warnings and reduced engine power modes, but that complainants ignored them. Ford, therefore, reported that it has not identiﬁed any further defect in the coolant system and that it believes the rate of complaints of reduced motive power (which some customers perceive reduced power as vehicle stalls) due to low coolant is low for the subject vehicles. Ford further states it believes that it has not identiﬁed any other related unreasonable risk to motor vehicle safety due to loss of motive power due to coolant loss or engine overheat. In addition to analyzing the vast amount of responsive data provided by Ford, ODI worked with NHTSA’s Vehicle Research and Test Center to review 1,462 VOQs with 1,347 unique VINs that were potentially related to this investigation. ODI found that 997 VOQs were relevant post-recall complaints. Of these, 161 VOQs included instances of stalling, sometimes preceded by warnings (low engine coolant message, audible/beeping sound, engine malfunction indicator lamp (MIL) illumination, etc.) and/or drivability issues (reduced power, vehicle jerking or shuddering, etc.). The other categories of complaints/failures were less severe or unrelated/undetermined: 73 related limp mode, nine related stall while vehicle stationary, 21 stalls unknown if related, 271 coolant failure without allegation of stalling, 64 engine MIL with no allegation of stalling, 267 not related to this investigation, 116 unknown if related, and 15 ﬁres (including the initial 5 reports) that were ultimately determined to not be related to this investigation. ODI found that a relatively small percentage of the post-recall complaints involved loss of motive power (161 out of 997 VOQs; and 222 out of 3,865 Ford reports), while the remaining complaints involved vehicles in the early stages of FMEM mode, or were unrelated or undetermined if related to this investigation. ODI has further found that the number of complaints has declined significantly since mid-2021. Based on the analysis of the failure data indicating a declining trend of VOQs of loss of motive power, and in consideration of the remedy for Recall 13V-583 and NHTSA’s ongoing consent order with Ford, ODI is closing this Preliminary Evaluation. The agency will continue to monitor this issue under the heightened oversight pursuant to the consent order and the agency reserves the right to take additional action if warranted. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

DP, Closed , Model Year: 2008

Loss of power steering while driving

On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equ... Read more

PE, Closed , Model Year: 2009

Electronic Throttle Body Malfunction

On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. Du... ring this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding thatRead more

DP, Closed , Model Year: 2005

Electronic Throttle Body Malfunction

In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 200... 5 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.Read more

DP, Closed , Model Year: 2002

Cruise Control Cable

On July 8, 2012, The Center for Auto Safety has petitioned NHTSA to open defect investigations on Model Year (MY) 2002 ? 2004 Ford Escape and Mazda Tribute vehicles with certain cruise control cables.The Center for Auto Safety has also petitioned for a hearing to address whether Ford Motor Company (... Read more

PE, Closed , Model Year: 2001

Stuck Throttle

In a letter dated July 25, 2012 Ford Motor Company (Ford) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-353 to NHTSA identifying a safety defect involving inadequate clearance between the engine cover and the speed control cable connector, which could result in a stuck throttle c... Read more

PE, Closed , Model Year: 2010

Rear Liftgate Window Glass Breakage

In its response to the agency, Ford acknowledged a higher than normal level of glass breakage incidents in the model year (MY) 2010 to early-build MY 2011 subject vehicles.The incidentsoccurred when the liftgate glass was being opened, or more typically while being closed, but in both cases while th... e vehicle was stationery, i.e., not moving on the roadway.Additionally failures often occurred during early morning hours when ambient and/or liftgate glass temperatures may have been lower.Ford advised that it investigated the failures but failed to identify an anomaly in the glass manufacturing process (which is often a factor in glass breakage trends ODI investigates) that could explain the reports.It did however identify a potential thermal expansion/compression condition in the mounting of the rear wiper motor to the liftgate glass.Starting at MY 2008 vehicle production the motor was attached to the glass using an adhesive.Ford revised that design to a nut and bolt type attachment in October 2010, during MY 2011 vehicle production.ODI's review of Ford data indicates that vehicles built after this change exhibit lower glass breakage rates.Among the 296 consumer complaints on the subject vehicles, ODI identified 15 injury incidents resulting in a total of 18 alleged injuries.All the injuries were minor in nature and consisted mainly of superficial skin cuts or minor lacerations, with two of the injury incidents occurring when vehicle owners were cleaning up broken glass.Additionally both the injury rate and report rate (including warranty claims) are low in comparison to similar investigations resulting in safety recalls (see PE04-045, MY 2002 Ford explorer liftgate glass failure, which resulted in NHTSA safety recall 04V442). In November 2010 Ford issued Technical Service Bulletin (TSB) 10-22-10 to address reports of liftgate glass breakage on all MY 2010 vehicles, and MY 2011 vehicles built through 10/15/2010, the date the above design revision was implemented.The TSB enables owners of affected vehicles to have a broken liftgate glass replaced under normal vehicle warranty, which would not otherwise be a warrantable failure, with the revised design liftgate glass.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.Read more

EA, Closed , Model Year: 2001

Engine Compartment Fire

Ford and Mazda recalled model year (MY) 2001 through 2004 Ford Escape (07V-156) and Mazda Tribute (07V-157) vehicles due to non-crash fires or non-fire thermal events originating in the engine compartment at or near the ABS control module.Approximately 545,700 vehicles were subject to the initial sa... fety recalls and approximately 424,700 vehicles were serviced under those campaigns. The campaigns addressed potentially damaged, missing or misplaced seals in the ABS control module wiring harness electrical connector that could allow brake fluid to enter the connector, possibly resulting in corrosion, short-circuit, melting, smoke and/or fire.Since the recall, the agency is aware of 260 subject vehicles that have reportedly experienced non-crash fires or non-fire thermal events originating at or near the ABS control module in vehicles some time after being serviced under the campaign. The post-recall repair incident rates for MY 2001 and 2002 subject vehicles are 90.9 and 126.7 (normalized per 100,000 vehicles serviced under the recall campaigns), respectively.These rates are much higher than the post-recall repair incident rate for MY 2003 and 2004 subject vehicles, which are 5.0 and 3.7 per 100K, respectively.Similarly, the post-recall repair key-off fire incident rates in the MY 2001 and 2002 subject vehicles is 54.3 per 100K, compared to 0.5 per 100K for the MY 2003 and 2004 subject vehicles.The agency is aware of 12 key-off fire incidents, all involving MY 2001 and 2002 subject vehicles, where the vehicle was parked inside a structure when the fire started.In five of those incidents, the fire spread from the vehicle to the structure itself.Ford has identified the brake master cylinder reservoir cap in certain MY 2001 and 2002 subject vehicles as a potential source for brake fluid leaks that could affect ABS module connector integrity.The reservoir caps used on the MY 2003 and 2004 subject vehicles are reportedly an improved design from those used on the earlier models.By letter dated January 4, 2012, Ford notified the agency that it would conduct another safety recall (identified by NTHSA Recall No. 12V-005 and Ford Recall No. 11S24) of certain MY 2001 and 2002 Ford Escape vehicles to perform a more thorough remedy to address the risk of fire originating at the ABS control module.In addition to double-checking the ABS control module wiring harness electrical connector weather seal (which should have been addressed under the previous recall campaign), Ford will replace brake master cylinder reservoir caps to address the leaking cap problem and reduce the risk of brake fluid entering the subject electrical connector.Ford will also modify the electrical system such that the ABS control module is de-energized when the ignition key is switched off to further reduce the risk of an unattended vehicle fire in units that may have sustained some small loss of connector integrity that may not be evident upon visual examination.Similarly, Mazda notified the agency by letter dated January 19, 2012, that it would also conduct a safety recall (identified by NTHSA Recall No. 12V-016 and Mazda Recall No. 6712A) of certain MY 2001 and 2002 Mazda Tribute vehicles.Ford estimates repair parts will be available beginning the second quarter of 2012. Until recall repairs are made both Ford and Mazda are advising owners of affected vehicles to reduce the safety concern by parking their vehicles outdoors away from structures to prevent a potential fire from spreading.Accordingly, this investigation is closed.Read more

RQ, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

IN LETTERS DATED MARCH 30, 2007, FORD MOTOR COMPANY (FORD) AND MAZDA NORTH AMERICAN OPERATIONS (MAZDA) NOTIFIED THE AGENCY THAT THEY WILL CONDUCT RECALLS 07V-156 AND 07V-157, RESPECTIVELY, TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-20... Read more

DP, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A DEFECT PETITION DATED MARCH 5, 2009 ALLEGING THAT THE PETITIONER NEVER RECEIVED THE RECALL REMEDY FOR 07V-156 AND THAT, AS A RESULT, THE PETITIONER'S MY2003 FORD ESCAPE CAUGHT FIRE AT THE ABS CONTROL MODULE.IN RESPONSE TO ODI FOLLOW-UP, THE MANUFA... Read more

PE, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

IN LETTERS DATED MARCH 30, 2007, FORD AND MAZDA NOTIFIED NHTSA THAT THEY WILL CONDUCT SAFETY RECALLS TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-2004 FORD ESCAPE AND MAZDA TRIBUTE SPORT UTILITY VEHICLES EQUIPPED WITH ABS.RECALL 07V-156... Read more

RP, Closed , Model Year: 2001

ENGINE STALLING

SUMMARY:THE PETITIONER ALLEGES THAT AFTER HAVING THE RECALL REMEDY PERFORMED ON HER MODEL YEAR (MY) 2001 FORD ESCAPE, IT CONTINUED TO EXHIBIT AN INTERMITTENT STALL CONDITION.CONSEQUENTLY, SHE PETITIONED THE AGENCY TO EXAMINE THE ADEQUACY OF THE RECALL REMEDY FOR SAFETY RECALL 04V-165.ON APRIL 5, 200... Read more

PE, Closed , Model Year: 2001

SAFETY BELT BUCKLE FAILURE

THIS INVESTIGATION WAS OPENED ON JULY 14, 2003 BASED ON 4 REPORTS ALLEGING THE DRIVER'S SAFETY BELT BUCKLE FAILED TO LATCH OR REMAIN LATCHED.MAZDA NOTIFIED ODI THAT IT TRANSFERRED ENGINEERING RESPONSIBILITY TO FORD WHEN THE VEHICLE DESIGN WAS BROUGHT TO THE UNITED STATES FOR PRODUCTION IN FORD'S ASS... Read more

EA, Closed , Model Year: 2001

ENGINE STALLING

FORD'S AND MAZDA'S LETTERS TO NHTSA DATED APRIL 5 AND APRIL 9, 2004, STATE THAT THEY WILL RECALL MODEL YEAR 2001-03 FORD ESCAPE AND MAZDA TRIBUTE VEHICLES WITH THE V6 ENGINE BUILT THRU SEPTEMBER 11, 2002.DEALERS WILL ADJUST ENGINE CALIBRATION IN THE PROGRAMMABLE CONTROL MODULE (PCM), WHICH IN ITS CU... Read more

PE, Closed , Model Year: 2001

ENGINE STALLING

RQ, Closed , Model Year: 2001

GASOLINE VAPOR INTRUSION

There is no summary currently available

FORD ESCAPE - All Years Overview

Complete safety history for the FORD ESCAPE across all model years (2001, 2026).

223 Total Recalls

36,389 Total Complaints

18 Investigations

1,428 Reported Crashes

814 Reported Fires

25 Reported Deaths

FORD ESCAPE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	2	7	View
2025	9	37	View
2024	8	139	View
2023 (current)	11	154
2022	19	316	View
2021	19	464	View
2020	23	2,123	View
2019	3	746	View
2018	4	2,186	View
2017	4	3,284	View
2016	4	1,365	View
2015	9	1,351	View
2014	16	2,667	View
2013	18	3,684	View
2012	2	792	View
2011	3	1,878	View
2010	5	3,185	View
2009	3	2,349	View
2008	5	2,407	View
2007	4	350	View
2006	5	627	View
2005	5	2,030	View
2004	8	715	View
2003	9	736	View
2002	10	1,397	View
2001	15	1,389	View
2000	0	5	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-150	692	46,142	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2023 FORD ESCAPE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2023 FORD ESCAPE

Safety Technology

Technical Service Bulletins, 2023 FORD ESCAPE

Most Affected Components

NHTSA Safety Investigations, FORD ESCAPE

FORD ESCAPE - All Years Overview

FORD ESCAPE - Year by Year

Other FORD Models