2004 FORD ESCAPE

8 recalls, 715 complaints - 68 TSBs

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Defect Description

Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one ... Read more

Consequence

If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehic... Read more

Remedy

Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-43... Read more

57 vehicles affected

Manufacturer: Ford Motor Company

SUSPENSION:FRONT:WHEEL BEARING

Defect Description

The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have... Read more

Consequence

Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.

Remedy

Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.

576 vehicles affected

Manufacturer: Timken Company

STRUCTURE:FRAME AND MEMBERS

Defect Description

Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New... Read more

Consequence

A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.

Remedy

Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.

348,950 vehicles affected

Manufacturer: Ford Motor Company

ENGINE AND ENGINE COOLING

Defect Description

Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a st... Read more

Consequence

A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.

Remedy

Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim re... Read more

529,719 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.

Consequence

AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS... Read more

Remedy

DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN... Read more

446,460 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Defect Description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI... Read more

Consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

13,128 vehicles affected

Manufacturer: CARDONE INDUSTRIES, INC.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Description

CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LI... Read more

Consequence

IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.

Remedy

DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

262,113 vehicles affected

Manufacturer: FORD MOTOR COMPANY

VEHICLE SPEED CONTROL:CABLES

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.

Consequence

AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.

470,245 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

715 total complaints 46 crashes 21 fires 21 injuries 1 deaths

Top Reported Components

Component	Complaints
SUSPENSION	148
STRUCTURE:BODY	111
VEHICLE SPEED CONTROL	74
AIR BAGS	41
WHEELS	33
ENGINE	31
ELECTRICAL SYSTEM	27
STEERING	26
POWER TRAIN	16
SERVICE BRAKES	15

Incident date: Feb 20, 2026

The contact owns a 2017 Ford Edge. The contact received notifications of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention). The contact stated that the rear-view camera had stopped showing an image for over a year. The contact called the local dealer s... Read more

Incident date: Mar 20, 2024

The contact owns a 2022 BMW R 18. The contact received notification of NHTSA Campaign Number: 23V884000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The de... Read more

Incident date: Jan 15, 2024

Rear window exploded/shattered while driving. There was no impact from any other source to cause the issue.

Incident date: Jan 15, 2024

The snuglock technology is a joke on this seat. It doesn’t matter if it’s latch or seatbelt installed the lock off isn’t holding it in position. Over time it becomes loose and the seat is moving more than an inch at the base. I’m having to tighten my seat every other day to ensure that my ch... Read more

Incident date: Jan 15, 2024

Incident date: Mar 15, 2023

Horn intermittently works. Some times it works and sometimes it doesn't work. This is a safety hazard if horn does not work. I cannot warn others before collision resulting in many close calls or evasive maneuvers. Other owners experiencing similar issue in Carnival Facebook group. Irvine Kia ... Read more

Incident date: Oct 2, 2022

I just bought the car, it was brand new off the lot. The check engine light came on followed by every emergency warning on my dash. After this my power steering failed, I was able to move over to the right lane a bit, but that’s it. I tried turning the car off at this point and turning it back on,... Read more

Incident date: Oct 2, 2022

UNKNOWN

Crash

Incident date: Jan 3, 2022

I have a 2004 Ford Escape which I absolutely love knocking on the door of almost 300,000 miles. Go Ford. But lately my airbag light blinks and my escape beeps 5 times every 8 seconds or so and then it repeats itself with a total of 20 beeps. After the beeping is finished my airbag light stays illumi... Read more

Incident date: Feb 1, 2022

The contact owns a 2004 Ford Escape. The contact stated while driving 45 MPH, he heard an abnormal noise coming from the rear of the vehicle and started to smell fuel in the vehicle. The contact stated no warning light was illuminated. The contact was able to park on the side of the road and noticed... Read more

Incident date: Nov 11, 2021

The body panel around the rear driver side shock mount has almost completely rusted away. Driving one day, I started to hear a loud clunking noise from the rear driver side. It started to get louder the more I drove it. Upon inspection, I found the body panel had completely rusted around the shock m... Read more

Incident date: Nov 11, 2021

Incident date: Oct 1, 2021

There seems to be a wiring grounding problem. I have had to replace multiple alternators over the length of time that I've had this vehicle. Whenever I have to use my windshield wipers during mid to heavy rain, along with lights, and heat/ac. The next day my alternator doesn't respond properly and... Read more

Incident date: Jun 11, 2021

after experiencing steering issues with this vehicle I had it inspected by a mechanic and was told the sub frame was rusted out. my research indicated repairs may be covered under a recall for this issue but found no recalls for this vin. the problem is exactly as described on the Ford web site yet ... Read more

Incident date: May 25, 2020

in an attempt t improve the safety and drivability of m 2004 ford escape I went to have my shocks, struts, control arms, sway bar end links and ball joints and steering arms replaced. upon the installation I was informed that the rust on the sub frame is at a critical level and in danger of catastro... Read more

Incident date: May 25, 2020

Incident date: Mar 29, 2021

THE WHOLE UNDERBODY IS RUSTING AWAY ESPECIALLY THE FRAME, COULDN'T EVEN GET REGULAR MAINTENCE DONE SINCE THE RUST SO BAD. WE ALWAYS WASHED THE UNDERBODY AFTER IT SNOWED AND THAT DIDN'T STOP THE RUST FROM EATING AWAY THE SUV. I SEE THERE IS A RECALL FOR MY YEAR BUT WHEN I DO A VIN CHECK IT SAYS NO ... Read more

Incident date: Mar 29, 2021

Incident date: Mar 17, 2020

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO ASHEVILLE FORD LOCATED AT (611 BREVARD RD ASHEVILLE NC 28806 828 253 2731) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT REFERENCED THE FAI... Read more

Incident date: Feb 27, 2020

COLLEGE AGE DAUGHTER RECEIVED A CAR FROM GRANDPARENTS, 2004 FOR ESCAPE GARAGED ITS ENTIRE LIFE. RECEIVED AT 88,000 MILES. OVER THE PAST FEW DAYS, NOTICED A BANGING IN TRUNK AREA. REAR PASSENGER WHEEL WELL AND SHOCK TOWER MOUNTING AREA HAS RUSTED OUT AND THE SHOCK IS "FLOATING" IN PLACE. CAR CURR... Read more

Incident date: Feb 19, 2020

JUST BOUGHT MY 2004 FORD ESCAPE K FRAME FRONT PASSENGER LOWER CONTROL ARM MOUNT RUSTED OUT EXACTLY THE WAY IT IS DESCRIBED IN RECALL CODE 14S02 AND MY CAR VIN IS NOT ON THE RECALL LIST FOR LOWER CONTROL ARM

Incident date: Feb 19, 2020

Incident date: Jul 7, 2019

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STARTED TO VEER TO THE RIGHT AND THE FRONT PASSENGER WHEEL STARTED TO MAKE A LOUD NOISE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND DISCOVERED THAT THE PASSENGER SIDE LOWER CONTROL ARM HOUSI... Read more

Incident date: May 26, 2019

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. AN INDEPENDENT MECHANIC STATED THAT THE LOWER CONTROL ARM WAS RUSTED THROUGH ON THE FRONT PASSENGER SIDE WHEEL. THE MECHANIC ALSO STATED THAT A USED SUBFRAME WOULD BE NEEDED TO REPAIR THE VEHICLE. THE CONTACT CALLED JACK MADDEN FORD (825 BOSTON-PROVIDENCE TUR... Read more

Incident date: Mar 13, 2019

AS WITH ALL OTHER POSTINGS THE REAR PASSENGER WHEEL WELL HAS COMPLETELY RUSTED OUT.AND THE CAR STARTED MAKING VERY LOUD CLUNKING NOISES. I DO NOT KNOW THE EXACT MOMENT THE WHEEL WELL COMPLETELY DEGRADED. THE REPAIR SHOP SAID IT IS NOT REPAIRABLE. SO WE ARE JUST NOW OUT A CAR. I JUST SPENT WAY TOO L... Read more

Incident date: Mar 13, 2019

Incident date: Mar 4, 2019

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 65 MPH ON THE HIGHWAY, THE REAR DRIVE AXLE FRACTURED CAUSING THE REAR DRIVERS SIDE WHEEL TO DETACH. AS A RESULT, THE VEHICLE SPUN OUT OF CONTROL AND BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS UNABLE TO BE DRIVEN. A POLICE OFFICER ASSISTED WIT... Read more

Incident date: Mar 4, 2019

Incident date: Mar 10, 2018

VEHICLE WAS U ABLE TO CONTROL,CONSTANT ISSUES WITH TRANSMISSION AND IDLE KEPT GETTING STUCK,SPEED UP ON ITS OWN AND WAS UNABLE STOP WITHOUT THROWING CAR IN PARK WHILE DRIVING

Incident date: Mar 10, 2018

VEHICLE WAS U ABLE TO CONTROL,CONSTANT ISSUES WITH TRANSMISSION AND IDLE KEPT GETTING STUCK,SPEED UP ON ITS OWN AND WAS UNABLE STOP WITHOUT THROWING CAR IN PARK WHILE DRIVING

Incident date: Mar 10, 2018

VEHICLE WAS U ABLE TO CONTROL,CONSTANT ISSUES WITH TRANSMISSION AND IDLE KEPT GETTING STUCK,SPEED UP ON ITS OWN AND WAS UNABLE STOP WITHOUT THROWING CAR IN PARK WHILE DRIVING

Incident date: Dec 1, 2018

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE STARTING THE VEHICLE, THE STEERING WHEEL WAS DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED BOMMARITO FORD (675 DUNN RD, HAZELWOOD, MO 63042, (314) 895-0600) AND WAS INFORMED THAT THERE WERE NO RECALLS ASSOCIATED WIT... Read more

Incident date: Jan 18, 2019

RECENTLY PURCHASED CAR, CHECK ENGINE LIGHT CAME ON. DIAGNOSTICS SCAN SHOWS 2ND CYLINDER MISFIRE, IGNITION COIL FAULTY. WENT ONLINE TO CHECK COMMON ISSUES WITH THIS MODEL..IT IS A COMMON ISSUE WITH MOST 04 ESCAPES. LOTS OF COMPLAINTS FOR WHEEL WELL RUST..UPON INSPECTION, MINE TOO IS CORRODED AND THE ... Read more

Incident date: Jan 18, 2019

Incident date: Nov 15, 2018

ON THURSDAY 15 NOVEMBER 2018, I PARKED MY 2004 FORD ESCAPE LTD IN A PARKING-LOT AND WENT INTO MY OFFICE. WITHIN ONE HOUR, A FIRE BEGAN IN THE ENGINE COMPARTMENT THAT QUICKLY SPREAD TO THE REST OF THE VEHICLE. THE CAUSE OF THE FIRE IS UNKNOWN. THE VEHICLE WAS DETERMINED A TOTAL LOSS BY MY INSURANCE C... Read more

Fire

Incident date: Nov 16, 2018

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING WHEEL FAILED DUE TO SEVERE RUST AND CORROSION OF THE SUBFRAME. THE CONTACT ATTEMPTED TO REPLACE THE CONTROL ARMS AND NOTICED THAT A HUGE CHUNK ON THE SUBFRAME WAS ROTTED AND CORRODED WITH A LARGE HOLE NEAR THE ... Read more

Incident date: Nov 16, 2018

Incident date: Jan 9, 2012

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AUTO FORD (A, 3301 ... Read more

Incident date: Sep 19, 2018

WHEN HITTING A BUMP IN THE ROAD, CAR PULLS SIDEWAVS. GOT CHECKED OUT. THEY FOUND EXCESSIVE CORROSION ON ENGINE CRADLE AND STEERING COMPONENTS WERE LOOSE AND AFFECTED BY EXCESSIVE CORROSION ON ENGINE CRADLE. STABILIZER ROD IS ALMOST READY TO FALL OFF. THEY ADVISED US NOT TO DRIVE THE CAR UNTIL ALL C... Read more

Incident date: Sep 19, 2018

Incident date: Sep 11, 2018

THE VEHICLE WAS A 2004 FORD ESCAPE. IT WAS PARKED ON THE STREET, EVERYTHING WAS TURNED OFF AND THE VEHICLE WAS NOT RUNNING. I WAS IN WORK WHEN I WAS INFORMED THAT MY VEHICLE WAS ON FIRE. NOTHING WAS ON TO START THIS FIRE, IT HAPPENED SPONTANEOUSLY. THE FIRE SEEMS TO HAVE STARTED IN THE VICINITY OF T... Read more

Fire

Incident date: Sep 11, 2018

Fire

Incident date: Sep 11, 2018

Fire

Incident date: Aug 9, 2018

I WAS DRIVING DOWN THE HIGHWAY AND I LOST CONTROL OF MY VEHICLE I HAD NO STEERING TRUCK WAS SHIMMYING ALL OVER THE ROAD. WAS ABLE TO GET IT SLOWED DOWN AND UNDER CONTROL OVER TO THE SHOULDER OF THE ROAD AND WAS ABLE TO DRIVE IT SLOWLY OFF OF THE HIGHWAY WAS ABOUT 1 MILE FROM MY HOUSE. IT HAS NO STEE... Read more

Incident date: Jul 12, 2018

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A DITCH. THE STEERING WHEEL AIR BAG DEPLOYED. A POLICE REPORT WAS NOT FILED. THE DRIVER SUSTAINED BRUISING TO THE LEGS AND WAS UNCONSCIOUS. MEDICAL TREATMENT WAS RECEI... Read more

Crash 1 injured

Incident date: Jul 12, 2018

Crash 1 injured

Showing 50 of 715 complaints.

Technical Service Bulletins, 2004 FORD ESCAPE

68 manufacturer communications from 49 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	6
061000 ENGINE AND ENGINE COOLING:ENGINE	5
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	3
140000 AIR BAGS	3
100000 POWER TRAIN	3
030000 SERVICE BRAKES, HYDRAULIC	2
020000 SUSPENSION	2
138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT	2

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

060000 ENGINE (PWS)

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061000 ENGINE AND ENGINE COOLING:ENGINE

060000 ENGINE AND ENGINE COOLING

020000 SUSPENSION

Safety recall 14S02 - Corrosion at forward attachment of lower control arm - requests for recall service action

020000 SUSPENSION

2001-2004 Escape vehicles Safety Recall 14S02 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a corrosion-related separation of the forward attachment of the lower control arm (LCA) from

160000 STRUCTURE

021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

FORD: THE LOWER CONTROL ARM (LCA) FORWARD ATTACHMENT WILL SEPARATE FROM SUBFRAME, CAUSING DIMINISHING DIRECTIONAL CONTROL, DUE TO OPERATING IN HIGH CORROSION AREAS FOR EXTENDED PERIOD OF TIME. MODEL 2001-2004 ESCAPE. *PE

061000 ENGINE AND ENGINE COOLING:ENGINE

POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP. *TT

110000 ELECTRICAL SYSTEM

PCM FAILURE - ELECTRICAL ACCESSORIES INTERMITTENT - INOPERATIVE. *TT

100000 POWER TRAIN

NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP. *TT

210000 TRAILER HITCHES

NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS. *TT

060000 ENGINE AND ENGINE COOLING

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

110000 ELECTRICAL SYSTEM

RESTRAINT SYSTEM - SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877 AND/OR B1881. *TT

151300 SEAT BELTS:FRONT:RETRACTOR

SAFETY BELT RETRACTION SPEED. *TT

282100 BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT

FALSE PARKING AID WARNINGS. *TT

282100 BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT

FALSE PARKING AID WARNINGS. *TT UPDATE. *TT

150000 SEAT BELTS

SAFETY BELT WEB STOP BUTTON SERVICE. *EH

190000 TIRES

VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT

200000 WHEELS

VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT

140000 AIR BAGS

SIDE AIR BAG DIAGNOSTIC TROUBLE CODE (DTC) B1994 OR B1998. *TT

110000 ELECTRICAL SYSTEM

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT

160000 STRUCTURE

SERVICEABILITY OF INSTRUMENT PANEL REGISTER VENTS. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

138200 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT

150000 SEAT BELTS

SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877, B1881, B1885 OR B1886. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

WHEEL SPEED SENSOR REMOVAL TIP. *EH

124000 EXTERIOR LIGHTING:BACK UP LIGHTS

CONDENSATION INSIDE THE FOGLAMPS. *EH

010000 STEERING

STEERING DRIFT/PULL - IMPROVED DIAGNOSTIC AND REPAIR PROCEDURE - SERVICE TIP. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT

140000 AIR BAGS

AIR BAG WARNING LAMP ON . *EH

140000 AIR BAGS

HIGH AIRFLOW FROM DEFROSTER VENTS WHEN IN FLOOR OR FLOOR DEFROST MODES. *EH

110000 ELECTRICAL SYSTEM

AIRBAG LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) B1877 (DRIVER PRETENSIONER CIRCUIT OPEN) OR B1881 (PASSENGER PRETENSIONER CIRCUIT OPEN). *TT THIS BULLETIN SUPERSEDES TSB 03-20-11 DATED 2003. *TT

090000 FUEL SYSTEM, OTHER

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT

100000 POWER TRAIN

A FINAL DRIVE WHINE AT 25-45 MPH (40-72 KM/H). *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.

138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT

138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

CLUTCH CHATTER WHEN COLD. *TT

015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

LOW PRESSURE POWER STEERING LINE LEAK AFTER COLD SOAK IN TEMPERATURES OF -23C (-10) OR LOWER. *MJ

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P1783 AND/OR P0733 COLD CLIMATE SHIFT/ENGAGEMENT CONCERNS WITH A CD4E TRANSAXLE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

HARSH SHIFTS AND ENGAGEMENTS WITH ONLY DIAGNOSTIC TROUBLE CODE (DTC) P1502. *TT

030000 SERVICE BRAKES, HYDRAULIC

EXCESSIVE FRONT ROTOR WEAR AND/OR BRAKE DUST. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17. REVISED SMOG EMISSIONS INFORMATION. *TT

100000 POWER TRAIN

FINAL DRIVE WHINE MOST NOTICEABLE AT 25-45 MPH DURING LIGHT ACCELERATION OR DECELERATION. *TT

151000 SEAT BELTS:FRONT

FRONT SAFETY BELT SLOW TO RETRACT AND/OR MISSING WEB STOP BUTTON. *TT

090000 FUEL SYSTEM, OTHER

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT

110000 ELECTRICAL SYSTEM

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT

017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

TIE ROD END INSPECTION PROCEDURE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT

030000 SERVICE BRAKES, HYDRAULIC

EXCESSIVE BRAKE PAD/LINING DUST AND WEAR. *TT

NHTSA Safety Investigations, FORD ESCAPE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2020

Failed Door Check Arm Attachment Point

On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. T... o date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

AQ, Open , Model Year: 2021

Healey Brothers Ford / Open Recall Sale

NHTSA is opening this audit query to investigate whether Healey Brothers Ford, LLC of Beacon, New York, has complied with the requirements of the National Traffic and Motor Vehicle Safety Act. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to m... Read more

PE, Closed , Model Year: 2013

Loss of Motive Power

On July 16, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) to investigate alleged instances of sudden stalling without warning on model year (MY) 2013 Ford Escape vehicles equipped with 1.6L GTDI turbocharged engines. Complaints alleged that vehicles stalled ... due to engine overheating, resulting in a delayed or no restart condition. When the investigation was opened, ODI had received 40 Vehicle Owner Questionnaires (VOQs). At this time, ODI has received 173 VOQs with five reported fires and no reported crashes. In investigating the incidents alleged in the VOQs, ODI revisited an apparently related recall that Ford had issued in November 2013 (Recall 13V-583). In Recall 13V-583, Ford recalled all MY 2013 Ford Escape vehicles equipped with the 1.6L engines, built from October 5, 2011, to June 2, 2013. This recall addressed potential engine compartment ﬁres due to localized overheating of the engine cylinder head leading to cracks that can cause oil leaks onto a hot engine surface. The remedy was to provide several enhancements to the engine shielding, cooling and control systems, which involved recalibration of the powertrain calibration module and the instrument cluster system. The recalibration implemented a “Failure Mode Eﬀects Management” (FMEM) strategy to alert the driver of a low coolant state and limit the power to the engine to prevent overheating to the point of cracking the cylinder head. The FMEM strategy includes a “Low Engine Coolant – Service Required” message in the instrument cluster when the coolant reaches a prescribed low level and the engine continues to perform normally, and a coolant level sensor that was incorporated such that if the coolant level is further reduced, the engine enters a reduced power mode (vehicle speed limited to about 40 mph). If the vehicle is driven farther and coolant is not added to the vehicle, the vehicle enters a further reduced power mode and audible and visual alerts will appear and sound, and the engine will be limited to operation at idle speeds. ODI sent Ford an information request letter in August 2018, and, in April 2021, additionally required that Ford provide an update of its ﬁeld and warranty data. In response, Ford provided 4,047 customer complaints, ﬁeld reports, and legal claims, consisting of 3,865 unique VINs, and 47,214 warranty claims, consisting of 33,684 unique VINs. Having had repeated discussions with ODI, Ford eventually binned all 4,047 post-recall reports and all 47,214 warranty claims to those that relate to loss of motive power due to coolant loss. Having so binned these reports and claims, Ford reported that the relevant number dropped to 227 reports with 222 unique VINs and 2,774 warranty claims with 1,875 unique VINs. In analyzing its own responsive data, Ford maintained that the remedy for Recall 13V-583 adequately addresses the risk of loss of motive power resulting from an engine overheat due to low coolant by providing clear warnings and progressive reduced power FMEM strategies. Ford further maintained that some complaints imply that the vehicles properly displayed the advanced and progressive warnings and reduced engine power modes, but that complainants ignored them. Ford, therefore, reported that it has not identiﬁed any further defect in the coolant system and that it believes the rate of complaints of reduced motive power (which some customers perceive reduced power as vehicle stalls) due to low coolant is low for the subject vehicles. Ford further states it believes that it has not identiﬁed any other related unreasonable risk to motor vehicle safety due to loss of motive power due to coolant loss or engine overheat. In addition to analyzing the vast amount of responsive data provided by Ford, ODI worked with NHTSA’s Vehicle Research and Test Center to review 1,462 VOQs with 1,347 unique VINs that were potentially related to this investigation. ODI found that 997 VOQs were relevant post-recall complaints. Of these, 161 VOQs included instances of stalling, sometimes preceded by warnings (low engine coolant message, audible/beeping sound, engine malfunction indicator lamp (MIL) illumination, etc.) and/or drivability issues (reduced power, vehicle jerking or shuddering, etc.). The other categories of complaints/failures were less severe or unrelated/undetermined: 73 related limp mode, nine related stall while vehicle stationary, 21 stalls unknown if related, 271 coolant failure without allegation of stalling, 64 engine MIL with no allegation of stalling, 267 not related to this investigation, 116 unknown if related, and 15 ﬁres (including the initial 5 reports) that were ultimately determined to not be related to this investigation. ODI found that a relatively small percentage of the post-recall complaints involved loss of motive power (161 out of 997 VOQs; and 222 out of 3,865 Ford reports), while the remaining complaints involved vehicles in the early stages of FMEM mode, or were unrelated or undetermined if related to this investigation. ODI has further found that the number of complaints has declined significantly since mid-2021. Based on the analysis of the failure data indicating a declining trend of VOQs of loss of motive power, and in consideration of the remedy for Recall 13V-583 and NHTSA’s ongoing consent order with Ford, ODI is closing this Preliminary Evaluation. The agency will continue to monitor this issue under the heightened oversight pursuant to the consent order and the agency reserves the right to take additional action if warranted. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

DP, Closed , Model Year: 2008

Loss of power steering while driving

On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equ... Read more

PE, Closed , Model Year: 2009

Electronic Throttle Body Malfunction

On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. Du... ring this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding thatRead more

DP, Closed , Model Year: 2005

Electronic Throttle Body Malfunction

In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 200... 5 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.Read more

DP, Closed , Model Year: 2002

Cruise Control Cable

On July 8, 2012, The Center for Auto Safety has petitioned NHTSA to open defect investigations on Model Year (MY) 2002 ? 2004 Ford Escape and Mazda Tribute vehicles with certain cruise control cables.The Center for Auto Safety has also petitioned for a hearing to address whether Ford Motor Company (... Read more

PE, Closed , Model Year: 2001

Stuck Throttle

In a letter dated July 25, 2012 Ford Motor Company (Ford) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-353 to NHTSA identifying a safety defect involving inadequate clearance between the engine cover and the speed control cable connector, which could result in a stuck throttle c... Read more

PE, Closed , Model Year: 2010

Rear Liftgate Window Glass Breakage

In its response to the agency, Ford acknowledged a higher than normal level of glass breakage incidents in the model year (MY) 2010 to early-build MY 2011 subject vehicles.The incidentsoccurred when the liftgate glass was being opened, or more typically while being closed, but in both cases while th... e vehicle was stationery, i.e., not moving on the roadway.Additionally failures often occurred during early morning hours when ambient and/or liftgate glass temperatures may have been lower.Ford advised that it investigated the failures but failed to identify an anomaly in the glass manufacturing process (which is often a factor in glass breakage trends ODI investigates) that could explain the reports.It did however identify a potential thermal expansion/compression condition in the mounting of the rear wiper motor to the liftgate glass.Starting at MY 2008 vehicle production the motor was attached to the glass using an adhesive.Ford revised that design to a nut and bolt type attachment in October 2010, during MY 2011 vehicle production.ODI's review of Ford data indicates that vehicles built after this change exhibit lower glass breakage rates.Among the 296 consumer complaints on the subject vehicles, ODI identified 15 injury incidents resulting in a total of 18 alleged injuries.All the injuries were minor in nature and consisted mainly of superficial skin cuts or minor lacerations, with two of the injury incidents occurring when vehicle owners were cleaning up broken glass.Additionally both the injury rate and report rate (including warranty claims) are low in comparison to similar investigations resulting in safety recalls (see PE04-045, MY 2002 Ford explorer liftgate glass failure, which resulted in NHTSA safety recall 04V442). In November 2010 Ford issued Technical Service Bulletin (TSB) 10-22-10 to address reports of liftgate glass breakage on all MY 2010 vehicles, and MY 2011 vehicles built through 10/15/2010, the date the above design revision was implemented.The TSB enables owners of affected vehicles to have a broken liftgate glass replaced under normal vehicle warranty, which would not otherwise be a warrantable failure, with the revised design liftgate glass.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.Read more

EA, Closed , Model Year: 2001

Engine Compartment Fire

Ford and Mazda recalled model year (MY) 2001 through 2004 Ford Escape (07V-156) and Mazda Tribute (07V-157) vehicles due to non-crash fires or non-fire thermal events originating in the engine compartment at or near the ABS control module.Approximately 545,700 vehicles were subject to the initial sa... fety recalls and approximately 424,700 vehicles were serviced under those campaigns. The campaigns addressed potentially damaged, missing or misplaced seals in the ABS control module wiring harness electrical connector that could allow brake fluid to enter the connector, possibly resulting in corrosion, short-circuit, melting, smoke and/or fire.Since the recall, the agency is aware of 260 subject vehicles that have reportedly experienced non-crash fires or non-fire thermal events originating at or near the ABS control module in vehicles some time after being serviced under the campaign. The post-recall repair incident rates for MY 2001 and 2002 subject vehicles are 90.9 and 126.7 (normalized per 100,000 vehicles serviced under the recall campaigns), respectively.These rates are much higher than the post-recall repair incident rate for MY 2003 and 2004 subject vehicles, which are 5.0 and 3.7 per 100K, respectively.Similarly, the post-recall repair key-off fire incident rates in the MY 2001 and 2002 subject vehicles is 54.3 per 100K, compared to 0.5 per 100K for the MY 2003 and 2004 subject vehicles.The agency is aware of 12 key-off fire incidents, all involving MY 2001 and 2002 subject vehicles, where the vehicle was parked inside a structure when the fire started.In five of those incidents, the fire spread from the vehicle to the structure itself.Ford has identified the brake master cylinder reservoir cap in certain MY 2001 and 2002 subject vehicles as a potential source for brake fluid leaks that could affect ABS module connector integrity.The reservoir caps used on the MY 2003 and 2004 subject vehicles are reportedly an improved design from those used on the earlier models.By letter dated January 4, 2012, Ford notified the agency that it would conduct another safety recall (identified by NTHSA Recall No. 12V-005 and Ford Recall No. 11S24) of certain MY 2001 and 2002 Ford Escape vehicles to perform a more thorough remedy to address the risk of fire originating at the ABS control module.In addition to double-checking the ABS control module wiring harness electrical connector weather seal (which should have been addressed under the previous recall campaign), Ford will replace brake master cylinder reservoir caps to address the leaking cap problem and reduce the risk of brake fluid entering the subject electrical connector.Ford will also modify the electrical system such that the ABS control module is de-energized when the ignition key is switched off to further reduce the risk of an unattended vehicle fire in units that may have sustained some small loss of connector integrity that may not be evident upon visual examination.Similarly, Mazda notified the agency by letter dated January 19, 2012, that it would also conduct a safety recall (identified by NTHSA Recall No. 12V-016 and Mazda Recall No. 6712A) of certain MY 2001 and 2002 Mazda Tribute vehicles.Ford estimates repair parts will be available beginning the second quarter of 2012. Until recall repairs are made both Ford and Mazda are advising owners of affected vehicles to reduce the safety concern by parking their vehicles outdoors away from structures to prevent a potential fire from spreading.Accordingly, this investigation is closed.Read more

RQ, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

IN LETTERS DATED MARCH 30, 2007, FORD MOTOR COMPANY (FORD) AND MAZDA NORTH AMERICAN OPERATIONS (MAZDA) NOTIFIED THE AGENCY THAT THEY WILL CONDUCT RECALLS 07V-156 AND 07V-157, RESPECTIVELY, TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-20... Read more

DP, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A DEFECT PETITION DATED MARCH 5, 2009 ALLEGING THAT THE PETITIONER NEVER RECEIVED THE RECALL REMEDY FOR 07V-156 AND THAT, AS A RESULT, THE PETITIONER'S MY2003 FORD ESCAPE CAUGHT FIRE AT THE ABS CONTROL MODULE.IN RESPONSE TO ODI FOLLOW-UP, THE MANUFA... Read more

PE, Closed , Model Year: 2001

ENGINE COMPARTMENT FIRE

IN LETTERS DATED MARCH 30, 2007, FORD AND MAZDA NOTIFIED NHTSA THAT THEY WILL CONDUCT SAFETY RECALLS TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-2004 FORD ESCAPE AND MAZDA TRIBUTE SPORT UTILITY VEHICLES EQUIPPED WITH ABS.RECALL 07V-156... Read more

RP, Closed , Model Year: 2001

ENGINE STALLING

SUMMARY:THE PETITIONER ALLEGES THAT AFTER HAVING THE RECALL REMEDY PERFORMED ON HER MODEL YEAR (MY) 2001 FORD ESCAPE, IT CONTINUED TO EXHIBIT AN INTERMITTENT STALL CONDITION.CONSEQUENTLY, SHE PETITIONED THE AGENCY TO EXAMINE THE ADEQUACY OF THE RECALL REMEDY FOR SAFETY RECALL 04V-165.ON APRIL 5, 200... Read more

PE, Closed , Model Year: 2001

SAFETY BELT BUCKLE FAILURE

THIS INVESTIGATION WAS OPENED ON JULY 14, 2003 BASED ON 4 REPORTS ALLEGING THE DRIVER'S SAFETY BELT BUCKLE FAILED TO LATCH OR REMAIN LATCHED.MAZDA NOTIFIED ODI THAT IT TRANSFERRED ENGINEERING RESPONSIBILITY TO FORD WHEN THE VEHICLE DESIGN WAS BROUGHT TO THE UNITED STATES FOR PRODUCTION IN FORD'S ASS... Read more

EA, Closed , Model Year: 2001

ENGINE STALLING

FORD'S AND MAZDA'S LETTERS TO NHTSA DATED APRIL 5 AND APRIL 9, 2004, STATE THAT THEY WILL RECALL MODEL YEAR 2001-03 FORD ESCAPE AND MAZDA TRIBUTE VEHICLES WITH THE V6 ENGINE BUILT THRU SEPTEMBER 11, 2002.DEALERS WILL ADJUST ENGINE CALIBRATION IN THE PROGRAMMABLE CONTROL MODULE (PCM), WHICH IN ITS CU... Read more

PE, Closed , Model Year: 2001

ENGINE STALLING

RQ, Closed , Model Year: 2001

GASOLINE VAPOR INTRUSION

There is no summary currently available

FORD ESCAPE - All Years Overview

Complete safety history for the FORD ESCAPE across all model years (2001, 2026).

223 Total Recalls

35,911 Total Complaints

18 Investigations

1,412 Reported Crashes

799 Reported Fires

24 Reported Deaths

FORD ESCAPE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	2	7	View
2025	9	33	View
2024	8	136	View
2023	11	151	View
2022	19	302	View
2021	19	437	View
2020	23	2,043	View
2019	3	714	View
2018	4	2,118	View
2017	4	3,232	View
2016	4	1,273	View
2015	9	1,288	View
2014	16	2,650	View
2013	18	3,674	View
2012	2	792	View
2011	3	1,871	View
2010	5	3,183	View
2009	3	2,348	View
2008	5	2,404	View
2007	4	350	View
2006	5	627	View
2005	5	2,030	View
2004 (current)	8	715
2003	9	736	View
2002	10	1,397	View
2001	15	1,389	View
2000	0	5	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-150	692	46,142	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2004 FORD ESCAPE

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2004 FORD ESCAPE

Most Affected Components

NHTSA Safety Investigations, FORD ESCAPE

FORD ESCAPE - All Years Overview

FORD ESCAPE - Year by Year

Other FORD Models