2004 FORD E-350 Recalls, Complaints & Safety

AT 68,450 MILES, SEVERAL ISSUES OCCURRED: 1) OIL PRESSURE SWITCH BLEW OUT OF THE HOUSING, 2) OIL WAS VISIBLE IN COOLANT, 3) OIL WAS LEAKING FROM ENGINE, 4) IDLE VACILLATED UP AND DOWN W/O ANY ACTION ON PART OF THE USER. TOOK VAN TO DEALER, WHO CLAIMED TO HAVE REPAIRED THESE ITEMS. INSPECTION OF THE "REPAIRED VEHICLE" REVEALED OIL STILL DRIPPING OFF ENGINE ONTO GROUND. WAS TOLD THAT THIS WAS "NORMAL" AND WOULD DISAPPEAR. HOWEVER, THIS DID NOT HAPPEN. ENGINE HAS CONTINUED TO LEAK AND OIL CONTINUES TO MIX WITH COOLANT FLUID, EVEN AFTER FLUSHING SYSTEM TWICE SINCE REPAIR. DESPITE NUMEROUS CALLS TO DEALER, PROBLEM HAS NOT BEEN FIXED. ENGINE HAS LESS THAN 13K ADDITIONAL MILES ON IT SINCE "REPAIR" AND OIL IS STILL LEAKING. LEAK CONTINUES TO GET WORSE WITH TIME. I BELIEVE THIS IS A MANUFACTURER'S DEFECT AND SINCE THE ENGINE HAS FAR LESS THAN 100K MILES ON IT, SHOULD BE REPAIRED AS A WARRANTY ITEM. MIXING OF OIL AND COOLANT IS A SAFETY HAZARD AND NEEDS TO BE PROGRAMMATICALLY ADDRESSED BY FORD.

ALL GAUGES STOP WORKING WHEN IT RAINS BUT STARTS AND RUNS OK. POWER WINDOWS DO NOT WORK WHEN IT RAINS BUT STARTS AND RUNS OK.

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED BURNS ON BOTH FOREARMS, BUT DID NOT RECEIVE MEDICAL ATTENTION. THERE WAS NO POLICE REPORT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 177,000. THE VIN WAS UNAVAILABLE.

1 injured

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR, FUEL TANK, FUEL PUMP, AND THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN ALSO STATED THAT THE SILVER COATING IN THE FUEL TANK WAS FROM ONE OF THE DAMAGED PARTS. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. UPDATED 04/07/15*LJ UPDATED 11/3/15*JS

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. BOTH TECHNICIANS ADVISED THE CONTACT THAT THE EGR COOLER AND THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

Fire

SIDEWALL SEPARATED COMPLETELY ON ONE TIRE AND THE TREAD IS SEPARATING FROM THE BODY IF ANOTHER TIRE. BOTH TIRES ARE THE SAME MAKE AND MODEL. DEAN MUD TERRAIN SXT M+S LT245/75-R16 DOT ON TIRE WITH SIDEWALL SEPARATION UP11-DNW-0108 DOT ON TIRE WITH TREAD LUG SEPARATION UP11-DNW-0108 FAILURES OCCURRED AT THE SAME TIME ON A 2004 FORD E350 ECONOLINE. DURING FREEWAY OPERATION, OPERATOR FELT A RUMBLE AND SLOWED AND PULLED OVER TO THEN NOTICE THE SIDEWALL HAD SEPARATED. HE THEN ALSO NOTICED THE REAR. CHANGED TIRES TO A DIFFERENT BRAND AND CONTACTED COOPER THE PARENT COMPANY OF DEAN TO SEE IF THERE WAS A RECALL. NO RECALL WAS STATED UNDER THEIR COMPANY. FOUR OF THE TIRES ON THE VAN ARE UNDER WARRANTY AND THEY DIRECTED ME TO CONTACT A LOCAL DISTRIBUTOR TO CHANGE THEM. STILL HAVE THE TIRES AND HAVE YET TO CHANGE THEM OUT. *TR

TL* THE CONTACT OWNS A 2004 FORD E350. EQUIPPED WITH BF GOODRICH T/A A/S TIRES, SIZE: LT245/75R16. THE CONTACT STATED THAT RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 12T019000 (TIRES: TREAD/BELT) WAS RECEIVED JULY OF TWO THOUSAND TWELVE. THE CONTACT BELIEVED THAT THE WAIT FOR THE REPAIRS HAD EXCEEDED A REASONABLE AMOUNT OF TIME. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE DOT NUMBER AND VIN WERE NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WOULD STUTTER AND THEN STALL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTION CONTROL PRESSURE SENSOR FAILED. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING) BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 93,000.

DVD PLAYER WILL NOT EJECT CD'S. *TR

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER WHEN ACCELERATING AND THEN STALL. THE CONTACT WOULD HAVE TO WAIT THIRTY MINUTES BEFORE THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT STATED THE FAILURE WOULD OCCUR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THERE WAS NO SOLUTION TO THE PROBLEM. THE CONTACT DID RESEARCH AND FEELS THE PROBLEM IS CAUSED BY THE FUEL TANK DELAMINATING. THE FAILURE MILEAGE WAS 50,800 AND THE CURRENT MILEAGE WAS 120,000.

I AM THE ORIGINAL OWNER OF A 2004 FORD E 350 DIESEL,IT HAS BEEN IN THE SHOP MANY OF TIMES FOR THE SAME PROBLEM TRUCK STOPS RUNNING IN MIDDLE OF INTERSECTIONS, HIGHWAYS ETC DOES NOT START AND NEEDS TO BE TOWED.FORD DEALERSHIP HAS NO IDEA WHAT IS WRONG WITH TRUCK, I GET TRUCK BACK SAME THING HAPPENS. REPEATEDLY. NOW THAT THE TRUCK IS OUT OF WARRANTY SAME THING HAPPENS RESULT: DELAMINATING FUEL TANK, LITTLE SLIVERS OF PAINT CLOGGING FUEL LINES, PUMPS AND INJECTORS. *TR

FUEL TANK DELAMINATION IN MY 2004 FORD E-350 HAS CAUSE A NEED FOR AN EXPENSIVE TOTAL FUEL SYSTEM REPLACEMENT. OBVIOUSLY IT IS A HUGE PROBLEM AS THERE ARE MANY COMPLAINTS ONLINE OF THE EXACT SAME PROBLEM ALL OVER THE COUNTRY. FORD SAYS ITS THE BIO DIESEL THAT IS CAUSING THE PROBLEM, BUT ITS FUNNY HOW DODGE AND CHEVY AREN'T HAVING ANY PROBLEMS... *TR

TL*THE CONTACT OWNS A 2004 FORD E350 SD. THE FUEL TANK DETERIORATED AND THE PARTICLES THAT COMES OFF OF THE TANK CLOGGED THE FUEL INJECTORS. THE FAILURE PREVENTED FUEL FROM GETTING INTO THE ENGINE WHICH MADE THE VEHICLE DRIVE 15 MPH TO INCLUDE A ROUGH START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT IT WOULD COST OF $4500 TO SEAL THE FUEL TANK. THE REPAIRS WERE NOT COVERED UNDER WARRANTY OR RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 113,000.

VEHICLE CUTS OUT DURING DRIVING . *TR

TL*THE CONTACT OWNS A 2004 FORD E350 ECONOLINE WITH 79800 MILES. THE CONTACT NOTICE THAT THE WARNING LIGHT ON HIS INSTRUMENT PANEL CAME ON STATING THAT THERE WAS WATER IN THE FUEL. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO STATED THAT THE LINING IN THE FUEL TANK HAD DELAMINATED. THE CONTACT WAS TOLD THAT HIS FUEL SYSTEM NEEDED TO BE REPLACED.

VAN STOPPED RUNNING IN FREEWAY 2004 FORD E-350 DIESEL PROBLEM WITH TANK DELAMANATION 4 VANS SAME THING ALL CAME TO A STOP IN THE ROADWAY. *TR

5 SPEED AUTOMATIC TRANSMISSION OCCASIONALLY JUMPS OUT OF DRIVE DURING NORMAL OPERATION OF VEHICLE, ENGINE REVS FOR A SECOND OR TWO, THEN TRANSMISSION SLAMS BACK INTO DRIVE. *TR

VEHICLE LOST POWER 4 DIFFERENT TIMES. FUEL PUMP EXCESS NOISE, FUEL PUMP CLOGGED. DEALER CONTACTED FORD MOTOR CORP WHO BLAMED CONDITION ON DIESEL FUEL. FUEL PUMP WAS REPLACED AS WELL AS FUEL FILTERS AND FUEL TANK. WE ARE OUT $3000.00 FOR THE REPAIRS.

I HAVE A FORD E-350 SUPER DUTY VAN THAT HAS HAD DRIVABLE PROBLEMS SINCE IT WAS NEW. AFTER MANY TRIPS TO DEALERSHIPS I WAS TOLD THAT THERE WAS NO FIX AT THIS TIME AND FORD SHOULD COME OUT WITH A FIX IN THE FUTURE. THE ENGINE DIES WHEN HOT AT TIMES CAUSING HARD BRAKING AND LOSS OF STEERING. AT 100699 MILES, JUST 699 MILES OUT OF WARRANTY THE ENGINE QUITE RUNNING WHEN HOT. IF IT SITS FOR 6 OR MORE HOURS IT WILL RESTART AND RUN FOR ONLY 20 MINUTES. FORD TOLD ME IT WAS NO LONGER UNDER WARRANTY AND WOULD PROVIDE NO ASSISTANCE. *TR

FUEL TANK LINER IS SEPARATING CAUSING CORROSION AND RUST IN THE FUEL TANK. FORD REFUSES TO WARRANTY THE PROBLEM. THEY ARE BLAMING IT ON THE DIESEL FUEL, WHICH IS INACCURATE. I HAVE ONE CONFIRMATION FROM A CUSTOMER THAT THEY FINALLY COVERED HIS REPAIR, HOWEVER, HE HAD TO LODGE COMPLAINTS WITH BOTH THE NHTSA AND THE BBB. SO I AM OFFICIALLY LODGING A COMPLAINT AGAINST FORD MOTOR COMPANY, STEVEN'S FORD (THE DEALER), AND THE WARRANTY COMPANY. THE SAFETY ASPECT OF THIS IS THE TRUCK STALLS WHILE DRIVING AND DOES NOT RESTART. THE TRUCK ALSO EXPERIENCED A LOSS OF POWER WHEN GOING UPHILL. BOTH OF WHICH CAN CAUSE A DANGEROUS SITUATION WHEN IN HEAVY TRAFFIC. THIS IS A CHRONIC PROBLEM THAT FORD IS AWARE OF AND IS DENYING RESPONSIBILITY. I PERSONALLY KNOW OF AT LEAST 5 PEOPLE WHO HAVE HAD SIMILAR PROBLEMS WITH THEIR E350 VANS DUE TO CORROSION IN THE FUEL TANK. THIS IS NOT AN ISOLATED INCIDENT AND SHOULD BE COVERED UNDER THE WARRANTY. (PLEASE NOTE THERE IS LESS THAN 36,000 MILES ON THIS, BUT FORD IS NOT TAKING RESPONSIBILITY, NEITHER IS THE WARRANTY COMPANY FROM WHICH AN EXTENDED WARRANTY WAS PURCHASED) . FORD IS TRYING TO BLAME THE REASON ON USE OF MORE THAN 5% MIXTURE OF BIODIESEL AND IS SAYING THAT THE REASON THEY ARE NOT COVERING THE PROBLEM IS THAT THERE IS RUST IN THE FUEL TANK. THE RUST IS A REACTION FROM THE FUEL IN A POORLY DESIGNED FUEL TANK. IF IT WERE A DIESEL FUEL PROBLEM THIS WOULD OCCUR IN DIFFERENT MAKES OF TRUCKS, NOT JUST FORD. THERE IS A HUGE PROBLEM, THAT IS NOT ONLY A SAFETY, BUT AN ENVIRONMENTAL ONE AS WELL. *TR

I OWN 4 DIESEL POWERED FORD E350 VANS. IN 2008 I HAVE HAD A FUEL TANK REPLACED IN A 2000 AND 2004 VAN. I DECIDED TO HAVE MY 2007 CHECKED AND FOUND THAT THE FUEL FILTERS WERE CLOGGED. I HAVE SPENT OVER $7000.00 SO FAR. ALTHOUGH FORD DID NOT REPLACE THE TANK IN MY 2007 I AM STARTING TO WONDER WHEN I WILL HAVE TO HAVE THIS DONE. I HAVE ONE OTHER 2000 THAT JUST STARTED HAVING PROBLEMS. I DON'T NEED TO SPEND ANOTHER $7000.00. I ASKED FOR ABOUT DELAMINATION BUT THEY SAID ITS THE FUEL I'M USING. I SAW THE FUEL FILTERS THAT CAME OUT OF THE VEHICLES AND IT WAS A GRAY/ SILVER MATERIAL. *TR

TL*THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING 30 MPH, THE VEHICLE STALLED TWICE WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THE INJECTORS CAUSED THE FAILURE. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE HAS BEEN REPAIRED MORE THAN 20 TIMES AND THEY ALWAYS REPLACE THE INJECTORS; HOWEVER, THE MECHANIC STATED THAT THE CONTROL MODULE WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 332,000.

I WAS A PASSENGER IN A 15 PASSENGER VAN COMING TO TRANSPORT ME FROM THE AIRPORT. IT WAS A WHITE FORD CLUB WAGON (YEAR UNKNOWN). WE WERE GOING AT 70 MILES PER HOUR ON CRUISE CONTROL. THE REAR TIRE BLEW OUT AND WE BEGAN TO SWERVE AND THEN STARTED TO DO 360 DEGREE TURNS AND THEN HIT A GUARDRAIL AND FLIPPED 1.5 TIMES. ONE PERSON WAS KILLED AND SEVERAL MORE WERE INJURED SEVERELY. THE FRONT PASSENGER HAD TO HAVE THE JAWS OF LIFE TO REMOVE HER FROM THE VEHICLE. *TR

Crash 16 injured 1 deaths

I WAS A PASSENGER IN A 15 PASSENGER VAN COMING TO TRANSPORT ME FROM THE AIRPORT. IT WAS A WHITE FORD CLUB WAGON (YEAR UNKNOWN). WE WERE GOING AT 70 MILES PER HOUR ON CRUISE CONTROL. THE REAR TIRE BLEW OUT AND WE BEGAN TO SWERVE AND THEN STARTED TO DO 360 DEGREE TURNS AND THEN HIT A GUARDRAIL AND FLIPPED 1.5 TIMES. ONE PERSON WAS KILLED AND SEVERAL MORE WERE INJURED SEVERELY. THE FRONT PASSENGER HAD TO HAVE THE JAWS OF LIFE TO REMOVE HER FROM THE VEHICLE. *TR

Crash 16 injured 1 deaths

GAS FILL LINE CLOSES AND CAN ONLY FILL AT A RIDICULOUSLY SLOW RATE OR NOT AT ALL WITH SOME OF THE FASTER GAS PUMPS. *TR

2004 E-350 FORD DIESEL VAN ..IN 06 FUEL TANK DELAMINATION FORD REPLACED TANK..08 FUEL TANK DELAMINATION AGAIN @ 14000 MI. COST TO ME 2200.00. DEALER SAID FORD WILL NOT ADMIT TO A TANK PROBLEM AND COULD NOT ASSURE ME THE DELAMINATION PROBLEM HAS BEEN CORRECTED TO DATE..I CAN'T AFFORD 2,200.00 EVERY 14000 MI. I USE ONLY HESS DIESEL FUEL. I KNOW I AM NOT ALONE WITH THIS PROBLEM, THE DEALERSHIP SAID THEY DO AT LEAST TWO A MONTH. THIS IS A DANGEROUS CONDITION..THE TRUCK LOSES POWER AND STALLS. *TR

VEHICLE LOST POWER 3 DIFFERENT TIMES, ONCE ON INTERSTATE, TWICE IN HIGHWAY TRAFFIC, AND IN ONE CASE THE ENGINE DIED. TURNS OUT CAUSE WAS FAILURE OF TANK LINING CLOGGING UP THE FUEL SYSTEM. EACH OF THE 3 TIMES I REPLACE FUEL FILTERS BEFORE FINALLY CLEANING OUT THE TANK AND DETERMINING ACTUAL PROBLEM. FORD KNOWS THERE IS A PROBLEM WITH THE TANK LINING, AS SHOWN ON FORD TECHNICAL SERVICE BULLETINS 19728, BUT HAS DONE AND WILL DO NOTHING ABOUT THE PROBLEM EXCEPT TELL ME TO REPLACE MY TANK AT ALMOST $600 + LABOR. *TR

AUTOMATIC TRANSMISSION WILL SLIP OUT OF GEAR WITHOUT WARNING DURING ON-ROAD OPERATION. *TR

TL*- THE CONTACT STATED THAT AT EACH TIME HE SPRAYED THE WASHER ON THE WINDOWS FROM THE 2005 FORD E350 WITH 100 FAILURE MILEAGE THE WASHER WENT ONTO THE ROOF OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER TWICE, AND THE DEALER REPLACED A TRIPLE PANEL TWICE, BUT THE PROBLEM STILL EXISTED. THE CURRENT MILEAGE WAS 17,000.*AK

TL*- THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT LATCH ON THE 2004 FORD E350 WILL NOT STAY LATCHED. THE FAILURE MILEAGE WAS 60000. THE SEAT BELT LATCH WOULD POP OUT OF THE BUCKLE WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP, AND THEY INFORMED HIM HE SHOULD REPLACE THE SEAT BELT LATCH ASSEMBLY. THE VEHICLE CURRENTLY HAD 82000 MILES. *AK UPDATED 03/30/07. *JB

DT*: THE CONTACT STATED WHILE DRIVING 25 MPH, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER 20 MINUTES, AND WAS TAKEN TO A SERVICE DEALER WHERE THE PROBLEM WAS UNABLE TO BE DETERMINED. THERE WAS A NHTSA RECALL # 05V270000, WHICH PERTAINS TO THE WIRING. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

2004 FORD E-450 AMBULANCE 5/31/06 CREW STATED THE ENGINE WAS SURGING, EGR VALVE REPLACED BY DEALERSHIP. 5/31/06 CREW STATED A/C QUIT BLOWING AND GRINDING NOISE HEARD LARGER FUSE INSTALLED BY DEALERSHIP. DEALERSHIP STATED ALL OTHER A/C TEST CHECKED OUT OK. DEALERSHIP ADDED BOOSTER REPLACED TO DIESEL FUEL ALSO REPLACED FILTER, DRAINED WATER SEPARATOR. 9/1/06 ENGINE OIL LEAKING, CREW ALSO HAD A/C CONCERNS AGAIN DEALERSHIP REPLACED GEO ROTOR OIL PUMP COVER GASKET AND SEAL WEAR SLEEVE AND REASSEMBLE POST ROAD. DEALERSHIP FOUND COMPRESSOR SHAFT BROKE REPLACED A/C COMPRESSOR AND CLUTCH ASSEMBLE ACCUMULATOR AND FRONT ORIFICE TUBE. DEALERSHIP ALSO REPLACED FUEL INJECTOR CONTROL MODULE HARNESS, AND EXHAUST PRESSURE SENSOR SECONDARY TO RECALL. 10/12/05 CREW COMPLAINS THAT ENGINE SOUND LIKE IT IS "SUCKING AIR" DEALERSHIP STATED NOTHING WRONG, LATER THAT WEEK CREW MEMBERS FOUND AIR LEAK AT TURBO BRACKET CONTACTED DEALERSHIP THEY ADVISED THAT NOTHING WAS WRONG AND THAT WAS THE WAY IT SHOULD SOUND. WE STILL HAVE THIS EXTREME SURGING SOUND IN THE CAB ON ACCELERATION, THE SOUND IS SO LOUD THAT WE CAN NOT HEAR THE COMMUNICATION RADIO. THIS TRUCK IS A 2004 AMBULANCE WITH ONLY 24,964 MILES ON IT AND IS HOUSED INSIDE A CLIMATE CONTROLLED STATION. WE ARE AGAIN MAKING AN APPOINTMENT TO HAVE TURBO CHECK BECAUSE OF AIR LEAK. *NM

VEHICLE WAS PURCHASED ON OR AROUND SEPTEMBER 2003. ON MAY OF 2005 WE BEGAN TO HAVE MULTIPLE PROBLEMS CONCERNING THIS VEHICLE. THE MOST SIGNIFICANT OF THESE PROBLEMS IS AIR CONDITIONING COMPRESSORS LOCKING UP AND BREAKING THE DRIVE BELT. THIS VEHICLE IS AN AMBULANCE SO A FAILURE COULD CONTRIBUTE TO THE DEATH OF A PATIENT. WE HAVE TRIED VARIOUS REPAIRS TO THIS VEHICLE AS IT HAS FALLEN OUT OF WARRANTY AT THIS TIME. FIRST WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE AND THE BELTS THEN FLUSHED THE SYSTEM. THE 2ND OCCURRENCE WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM, THE 3RD OCCURRENCE WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. AT THIS TIME WE TRIED PLACING EXTERNAL FANS TO HELP LOWER THE HEAD PRESSURES THEN REPLACED THE FAN CLUTCH WITH A SNOW PLOW FAN CLUTCH AS DIRECTED BY OUR FORD DEALER. THE 4TH INCIDENT WE REPLACED THE COMPRESSOR THEN EXTENDED THE EVACUATION PERIOD FOR FEAR OF A POSSIBLE OIL OVERCHARGE. THE 5TH OCCURANCE ON 10/25/2006 WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. WE ARE NOW IN THE PROCESS OF TRYING A BETTER GRADE REFRIGERATION OIL IN PLACE OF THE USUAL PAG OIL. WE HAVE BEEN TRYING EVERYTHING WE CAN THINK OF TO COMBAT THIS PROBLEM WITH NO SUCCESS. *NM

THE CONSUMER'S TWO 2004 E350'S HAVE WEIGHT ISSUES. *TS ON 5/15/06 THE TRUCKS WERE TAKEN TO A REPAIR FACILITY AND THE CONSUMER WAS TOLD THAT THE GROSS VEHICLE WEIGH RATING ON THE SIDE DOOR OF THE VEHICLE IS 14,200 LBS. THE CONSUMER'S PAPER WORK READ 11,500 LBS. WHEN THE VEHICLE WAS WEIGHT EMPTY IT WEIGHED 9,988 LBS. THE REPAIR FACILITY INDICATED THAT THEY COULD NOT RELEASE THE VEHICLE'S TO THE CONSUMER UNTIL THEY RECEIVED AND ANSWER FROM DOT. 2004 FORD E350 22' GLAVAL UNIVERSAL 15 PASSENGER VEHICLE.

5-2-06. 2004 ECONOLINE REAR SEAT BELTS AND SEAT BELT EXTENDERS ARE POORLY DESIGNED. *TS THE RECEIVING END OF THE SEAT BELTS ARE ATTACHED TO THE END OF THE STRAP, THE OTHER END IS BOLTED TO THE FLOOR. WITH USE THE RECEIVING END TENDS TO FALL BACK THROUGH THE HOLE AND HAS TO BE REINSERTED OFTEN. THE MANUFACTURER PROVIDED SEAT BELT EXTENDERS FOR THE FRONT TWO BUCKETS SEAT, BUT NOT FOR THE REAR SEATS. *NM

OIL LEAKING FROM 2004 F-350 6.0L DIESEL ENGINE. EGR FAILURE CAUSING TRUCK TO SHUT OFF ON ROAD. *JB

2004 FORD WAGON E350 WITH FLOOR LOWERED BY VANTAGE MOBILITY INT. FOR HANDICAP PEOPLE. DURING STOP AND GO DRIVING LIKE TRAFFIC JAMS WHILE PULLING A TRAILER THE FLOOR BETWEEN FRONT SEATS GETS MORE THAN HOT ENOUGH TO BURN YOUR FOOT. SLIDING DOOR OPENER HAS BROKEN 6 TIMES LEAVING THE DOOR FREE TO SLIDE OPEN AND SHUT. I KEEP A BUNGY CORD TO TIE IT UP BUT INTERIOR LIGHTS COME ON AND OFF WHEN USING BUNGY CORD. THE ORIGINAL LATCH BY FORD WAS REMOVED TO INSTALL THE DOOR OPENER. SPLIT DRIVE SHAFT INSTALLED TO MAKE ROOM FOR UNDER VEHICLE LIFT BY BRAUN CORP HAS A LOW ROAR TO IT. BICYCLE TYPE CHAIN FOR THE SLIDING DOOR OPENER AT WHEELCHAIR LIFT DRAGS ACROSS PART OF DOOR JAMB.(NO PULLEY OR SPROCKET). PAID $48,000 FOR THIS NEW 2004 MODEL IN APRIL, 2005 I'M ASKING FOR MY MONEY BACK. PLEASE HELP US. *NM

1 injured

2004 FORD WAGON E350 WITH FLOOR LOWERED BY VANTAGE MOBILITY INT. FOR HANDICAP PEOPLE. DURING STOP AND GO DRIVING LIKE TRAFFIC JAMS WHILE PULLING A TRAILER THE FLOOR BETWEEN FRONT SEATS GETS MORE THAN HOT ENOUGH TO BURN YOUR FOOT. SLIDING DOOR OPENER HAS BROKEN 6 TIMES LEAVING THE DOOR FREE TO SLIDE OPEN AND SHUT. I KEEP A BUNGY CORD TO TIE IT UP BUT INTERIOR LIGHTS COME ON AND OFF WHEN USING BUNGY CORD. THE ORIGINAL LATCH BY FORD WAS REMOVED TO INSTALL THE DOOR OPENER. SPLIT DRIVE SHAFT INSTALLED TO MAKE ROOM FOR UNDER VEHICLE LIFT BY BRAUN CORP HAS A LOW ROAR TO IT. BICYCLE TYPE CHAIN FOR THE SLIDING DOOR OPENER AT WHEELCHAIR LIFT DRAGS ACROSS PART OF DOOR JAMB.(NO PULLEY OR SPROCKET). PAID $48,000 FOR THIS NEW 2004 MODEL IN APRIL, 2005 I'M ASKING FOR MY MONEY BACK. PLEASE HELP US. *NM

1 injured