2012 FLEETWOOD SOUTHWIND

1 recalls — 7 complaints — 5 TSBs

ELECTRICAL SYSTEM:WIRING

Defect Description

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2011 BOUNDER CLASSIC, STORM AND TERRA CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 21, 2010, THROUGH FEBRUARY 11, 2011. CERTAIN MODEL YEAR 2011 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM ... Read more

Consequence

A DAMAGED WIRE HARNESS CAN RESULT IN AN ELECTRICAL SHORT, RESULT IN INTERMITTENT OPERATION OF ELECTRICAL SYSTEMS VEHICLE "SHUT DOWN", AND/OR LEAD TO A FIRE, AND MAY RESULT IN LOSS OF VEHICLE CONTROL, INJURY, OR DEATH.

Remedy

DEALERS WILL INSPECT AND REROUTE THE WIRE HARNESS AWAY FROM THE HEAT SHIELD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.

703 vehicles affected

Manufacturer: FLEETWOOD RV, INC.

Complaint Statistics

7 total complaints 3 crashes

Top Reported Components

Component	Complaints
STEERING	2
ELECTRICAL SYSTEM	2
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS	1
SUSPENSION	1
ENGINE	1

Incident date: Jun 19, 2021

Component failed: Unanticipated without warning complete engine power failure, loss of steering assist, ABS braking system failure, electrical gages on dash erratic. The vehicle is available for inspection at anytime. Safety: The event has occurred seven(7) times between 7/24/2020 and 6/17/2021 whi... Read more

Crash

Incident date: Jun 19, 2021

Crash

Incident date: Jun 19, 2021

Crash

Incident date: May 10, 2020

WIRING HARNESS NEXT TO EXHAUST IS MELTING, STARTER SOLENOID NEXT TO EXHAUST MELTS.

Incident date: Aug 13, 2012

WHILE TRAVELING ON RT 70 EAST AT APROX, 60 MPH I HEAR A CLUNK FROM UNDER THR VEHICHLE. I PULLED OVER AND WAS ABLE TO GET UNDER THE VEHICHLE AND FOUND ONE BOLT MISSING FROM THE DRIVERS SIDE "U " BRACKET HOLDING THE STABILIZER BAR TO THE FRAME AND THE OTHER BOLT ONLY HAND TIGHT. WHEN I CHECKED THE PAS... Read more

Incident date: Aug 13, 2012

Technical Service Bulletins — 2012 FLEETWOOD SOUTHWIND

5 manufacturer communications from 5 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
980000 UNKNOWN OR OTHER	3
350000 EQUIPMENT	2

350000 EQUIPMENT

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for April 2021 for REV Recreation Group.

350000 EQUIPMENT

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for July 2021 for REV Recreation Group.

980000 UNKNOWN OR OTHER

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for November 2021 for REV Recreation Group.

980000 UNKNOWN OR OTHER

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for March 2023 for REV Recreation Group.

980000 UNKNOWN OR OTHER

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for June 2023 for REV Recreation Group.

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 1990

FRONT BRAKES FAIL

There is no summary currently available

PE — Closed — Model Year: 1985

CO INTRUSION

SUMMARY OF INFORMATION FROM THE MANUFACTURER:THE MANUFACTURER ADVISEDTHAT THE AUXILIARY POWER UNITS (APU'S) AND THEIR EXHAUST SYSTEMS ARE ALLFACTORY INSTALLED.IN ADDITION, THE MANUFACTURER PROVIDED TWO INSTANCESOF CARBON MONOXIDE (CO) ASPHYXIATION WITH THREE FATALITIES.HOWEVER,THESE WERE NOT IN THE ... SUBJECT 1985 MODEL VEHICLES BUT IN EARLIER MODELS.IT WAS DISCLOSED THAT ONE HAD BEEN AN AFTERMARKET TAILPIPE REPLACEMENTPROBLEM AND THE OTHER RELATED TO PARKING IN A SNOWBANK.ANALYSIS:A MODEL 33 UNIT IN RICHLAND, WA, WAS EXAMINED.THE INVESTI-GATOR CONFIRMED THAT THE UNIT HAD NOT BEEN MODIFIED IN ACCORDANCE WITHINSTRUCTIONS CONTAINED IN THE MANUFACTURER'S SAFETY RECALL CAMPAIGN(85V-138).PICTURES TAKEN SHOWED THAT THE APU EXHAUST OUTLETS FOR BOTHTHE PRODUCTION AND MODIFIED VERSIONS SATISFY THE REQUIREMENTS EXPRESSED INTHE ANSI STANDARD FOR RECREATIONAL VEHICLES, CHAPTER 3, SECTION 4.3.TESTS FOR CO INTRUSION WITH THE APU IN OPERATION SHOWED OFF-SCALE (ABOVE500 PARTS PER MILLION) READINGS IN THE REAR CENTER TO LEFT REAR CORNERWHICH IS IMMEDIATELY ABOVE A TRANSVERSELY LOCATED BED.THE VEHICLECUSTODIAN WOULD PERMIT NO DISTURBANCE OF THE BED.PICTURES AND VISUALEXAMINATION OF THE UNDERBODY REVEALED THE APU TAIL PIPE TO BE CRUSHED ANDMISLOCATED INSIDE THE CORNER OF THE SKIRTING SURROUNDING THE BODY.THEVEHICLE WAS IDENTIFIED AS ONE TO WHICH THE MANUFACTURER'S RECALL APPLIED;THE ANGLED TAILPIPE SHOULD HAVE BEEN REPLACED BY ONE WHICH EXITS AT NINETYDEGREES FROM THE SIDE OF THE VEHICLE AND FORWARD OF THE APU.A SECOND ISSUE CONCERNING THIS VEHICLE WAS RAISED BY THE ATTORNEY REPRE-SENTING THE DECEASED'S ESTATE.HE CLAIMED THAT IMPACT WITH A FIXEDOBJECT CAUSED THE REAR WALL TO BE SEPARATED SO THAT THE LOWER SILL OF THEREAR WINDOW COULD BE OBSERVED FROM UNDER THE VEHICLE.INFORMATION FROMTHE MANUFACTURER REVEALED THAT AN OUTER COSMETIC SKIN HAD BEEN ADDEDTO THE REAR OF THE VEHICLE AS A BEAUTY TREATMENT.THE OBSERVED LOWERSILL WAS IN FACT PART OF THE METAL REINFORCEMENT FOR THE REAR WALL.THEMULTIPLICITY OF WITNESS MARKS ON THE UNDER SIDE OF THE BODY SKIRT INDICATESTHAT THE VEHICLE HAD BEEN GROUNDED MORE THAN ONCE.EXAMINATION OF THE CURBIN FRONT OF THE DECEASED'S RESIDENCE REVEALED A NUMBER OF SCRAPE MARKSRESULTING FROM CONTACT BY THE REAR OF THE MOTOR HOME.ANOTHER ISSUE CONCERNING A SOUTHWIND J MODEL WAS RAISED BY A FLORIDAATTORNEY.HE CORRECTLY POINTED OUT THAT THE DESIGNATION, J, HAD BEENOMITTED FROM THE MANUFACTURER'S SAFETY DEFECT NOTIFICATION.INQUIRY TO THEMANUFACTURER REVEALED THAT THE DESIGNATION HAD BEEN INADVERTENTLY OMITTEDFROM THE RECALL NOTICE BUT THAT ALL THE J MODELS HAD BEEN INCLUDED IN THERECALL BECAUSE THE J MODEL IDENTIFICATION NUMBERS WERE INCLUDED IN THELISTING USED FOR CONSUMER MAILINGS.RECOMMENDATION:CLOSE THIS PRELIMINARY EVALUATION.===Read more

FLEETWOOD SOUTHWIND — All Years Overview

Complete safety history for the FLEETWOOD SOUTHWIND across all model years (1979–2023).

119 Total Recalls

238 Total Complaints

2 Investigations

4 Reported Crashes

11 Reported Fires

2 Reported Deaths

FLEETWOOD SOUTHWIND — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2023	6	2	View
2022	5	1	View
2021	6	1	View
2020	5	3	View
2019	2	0	View
2018	4	0	View
2017	1	1	View
2016	3	2	View
2015	2	0	View
2014	3	1	View
2012 (current)	1	7
2011	4	0	View
2010	3	0	View
2009	1	0	View
2008	2	0	View
2007	3	3	View
2006	6	5	View
2005	4	12	View
2004	8	14	View
2003	8	24	View
2002	5	5	View
2001	4	6	View
2000	4	22	View
1999	2	17	View
1998	1	14	View
1997	2	11	View
1996	1	14	View
1995	0	20	View
1994	0	13	View
1993	2	6	View
1992	1	2	View
1991	1	7	View
1990	1	8	View
1989	2	3	View
1988	2	2	View
1987	2	5	View
1986	1	2	View
1985	3	1	View
1984	2	3	View
1983	2	1	View
1982	1	0	View
1981	1	0	View
1980	1	0	View
1979	1	0	View

Other FLEETWOOD Models

Model	Recalls	Complaints
5TD	0	0	View
ADVANTAGE	0	0	View
ALL MODELS	0	0	View
ALTITUDE	0	0	View
AMERICAN ALLEGIANCE	0	0	View
AMERICAN COACH	0	0	View
AMERICAN DREAM	0	0	View
AMERICAN EAGLE	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2012 FLEETWOOD SOUTHWIND

Complaint Statistics

Top Reported Components

Technical Service Bulletins — 2012 FLEETWOOD SOUTHWIND

Most Affected Components

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

FLEETWOOD SOUTHWIND — All Years Overview

FLEETWOOD SOUTHWIND — Year by Year

Other FLEETWOOD Models