2000 FLEETWOOD SOUTHWIND

4 recalls — 22 complaints — 1 TSBs

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Defect Description

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy

FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICY... Read more

167,096 vehicles affected

Manufacturer: FLEETWOOD ENTERPRISES, INC.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Defect Description

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING A... Read more

Consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN F... Read more

60,877 vehicles affected

Manufacturer: FLEETWOOD ENTERPRISES, INC.

SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP

Defect Description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy

DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.

11,194 vehicles affected

Manufacturer: FLEETWOOD ENTERPRISES, INC.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Defect Description

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THE GENERATOR EXHAUST GASES CAN ACCUMULATE BENEATH THE SLIDE OUT PORTION OF THE MOTOR HOME AND CAN SEEP INTO THE VEHICLE INTERIOR.

Consequence

THIS SEEPAGE CAN POSSIBLY CAUSE CARBON MONOXIDE POISONING TO PERSONS INSIDE.

Remedy

DEALERS WILL REPLACE THE GENERATOR EXHAUST PIPE WITH A NEW EXHAUST PIPE DESIGNED TO TERMINATE AT A LOCATION OTHER THAN UNDER THE EXTENDED SLIDE OUT ROOM.

276 vehicles affected

Manufacturer: FLEETWOOD ENT., INC.

Complaint Statistics

22 total complaints

Top Reported Components

Component	Complaints
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER	2
VISIBILITY:WINDSHIELD	2
PARKING BRAKE	2
EXTERIOR LIGHTING	1
SEATS	1
AIR BAGS:FRONTAL	1
STRUCTURE:BODY	1
EQUIPMENT	1
STRUCTURE:BODY:DOOR	1
FUEL SYSTEM, GASOLINE:STORAGE	1

Incident date: Jul 8, 2014

PURCHASED SIX SAMSON GL 283 245/70/R/19.5 TIRES (DOT OD J D 22 ------) THROUGH WILKE TIRE SERVICE IN CORPUS CHRISTI, TEXAS FROM AMERICAN TIRE DISTRIBUTORS ON HORNE ROAD IN CORPUS CHRISTI, TEXAS. I HAD REQUESTED FROM WILKE TO RECORD ALL MANUFACTURERS DATE ON THE TIRES, HOWEVER, AFTER THE TIRES W... Read more

Incident date: Jul 8, 2014

Incident date: Jul 17, 2004

JULY 2004 WINDSHIELD STARTED TO SEPARATE FROM FRAME IN MY 2000 SOUTHWIND MOTOR HOME. ALSO THE RIGHT FRONT LEAF SPRING LOST TENSION. THE WINDOW WAS RESET TWICE AND AFTER THE THIRD TIME IT BROKE WHEH LEVELING THE MOTOR HOME. THE RIGHT FRONT SPRING HAD BUSHINGS ADDED TO BRING IT UP TO LEVEL

Incident date: Jul 17, 2004

Incident date: Aug 1, 2003

WHILE DRIVING 55 MPH AND WITH CRUISE CONTROL ENGAGED ENGINE SIMPLY STALLED, AND WOULD NOT TURN OVER. BRAKES FAILED AS WELL AS THE POWER STEERING. AFTER VEHICLE COOLED OFF FOR A HALF HOUR IT STARTED UP AFTER ENGAGING THE IGNITION. *AK

Incident date: Aug 1, 2003

EXHAUST GASES FROM THE RUNNING GENERATOR FLOW UNDER THE EXTENDED SIDEWALLS OF THE VEHICLE. THIS IS ESPECIALLY SERIOUS ON THE LEFT SIDE OF THE VEHICLE WHERE THE GENERATOR IS LOCATED. THERE IS EV IDENCE OF SOOT-LIKE MATERIAL AT A NUMBER OF POINTS INSIDE THE MOTORHOME'S LIVING SPACE. CO LEVELS UP TO 14... Read more

Incident date: Oct 20, 2001

INCIDENT VEHICLE IS SOUTHWIND STORM MOTORHOME ON A P22 WORKHORSE CHASSIS AND GM 6.8 LITER VORTEC ENGINE. ELECTRO-HAYDRAULIC DRIVELINE MOUNTED PARKING BRAKE/AUTOPARK SYSTEMS ENGAGED ON ITS OWN FOUR TIMES IN TRAFFIC AFTER HITTING A ROUGH STRETCH OF ROAD WITH SLECTOR KNOB IN OFF POSITION THEN LOCKED U... Read more

Incident date: Oct 20, 2001

Incident date: Jul 14, 2001

WHEN LEVELING THE MOTORHOME WITH THE FACTORY SUPPLIED LEVELING JACKS, THE WINDSHIELD BUCKELS AND EXPLODES, CAUSING GLASS CHIPS TO FLY ONTO PEOPLE SITTING IN THE FRONT PASSENGER SEATS. THIS IS ALL DONE WHILE THE MOTORHOME WAS STATIONARY.*AK

Incident date: Oct 28, 2000

FRONT SPRINGS VERY WEAK, OVER 4" SAGGING IN FRONT, SO MUCH THAT RIGHT FRONT TIRE HAS RIPPED RIGHT FRONT FENDER. HAVE CONTACTED DEALER, FLEETWOOD, AND FORD (FORD'S CHASSIS). IT IS HAZZARDOUS TO DRIVE IN THIS CONDITION.*AK

Incident date: Feb 29, 2000

CONSUMER NOTICED STOP LIGHT ON REAR WAS INOPERABLE, LATER NOTICED RIGHT FRONT PARKING LIGHT AND TURN SIGNAL WERE ALSO INOPERABLE, THE STOP LIGHT'S BULB HAD EXPLODED DUE TO IMPROPER BULB SIZE BEING INSTALLED, PARKING LIGHT AND TURN SIGNAL WERE FAULTY DUE TO BEING IMPROPERLY INSTALLED. *SLC CONSUME... Read more

CONSUMER STATES THAT LP GAS DETECTOR FREQUENTLY ACTIVATES, DEALER INFORMED CONSUMER THAT FOR THE FIRST 3 YEARS, DETECTOR COULD ANTICIPATE FALSE ALARMS DUE TO NEW CARPET VAPORS AND RESIDUAL OIL VAPORS FROM DUCTING. *SLC

ALL DOORS ARE SUPPOSED TO COME EQUIPPED WITH 2 GAS STRUTS, HOWEVER CONSUMER FOUND ONLY 1. *SLC

HEADBOARD WAS BROKEN, ORDERED 3 MORE TIMES DUE TO FIRST 2 REORDERS WERE ALSO BROKEN, SHOWER AREA HAD A LEAK, DEALER SEALED INTERIOR OF SHOWER WHICH HAD TO BE DONE TWICE, GLASS OF ONE OF THE SHOWER PANELS HAD WEBBED, REPLACEMENT OF THIS TOOK 2 AND A HALF MONTHS. *SLC

LARGE HOLES WERE FOUND IN THE UPPER WALLS OF COMPARTMENTS UNDER THE BODY OF THE COACH BEHIND REAR WHEELS, WHEN IT WOULD RAIN, WATER WOULD FILL THE BASEMENT COMPARTMENTS. *SLC

VEHICLE WAS SUPPOSED TO BE EQUIPPED WITH DRIVER'S SIDE AIRBAG, HOWEVER UPON INSPECTION FOUND THAT VEHICLE WAS EQUIPPED WITH NO AIRBAG. *SLC

Incident date: Feb 29, 2000

Technical Service Bulletins — 2000 FLEETWOOD SOUTHWIND

1 manufacturer communications from 1 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
072200 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS	1

072200 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

FLEETWOOD SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CONSUMER MAINTENANCE ADVISORY, GENERATOR FUEL LINES. FLEETWOOD MOTOR HOME OWNERS. CSC WAS RECEIVED. *PE

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 1990

FRONT BRAKES FAIL

There is no summary currently available

PE — Closed — Model Year: 1985

CO INTRUSION

SUMMARY OF INFORMATION FROM THE MANUFACTURER:THE MANUFACTURER ADVISEDTHAT THE AUXILIARY POWER UNITS (APU'S) AND THEIR EXHAUST SYSTEMS ARE ALLFACTORY INSTALLED.IN ADDITION, THE MANUFACTURER PROVIDED TWO INSTANCESOF CARBON MONOXIDE (CO) ASPHYXIATION WITH THREE FATALITIES.HOWEVER,THESE WERE NOT IN THE ... SUBJECT 1985 MODEL VEHICLES BUT IN EARLIER MODELS.IT WAS DISCLOSED THAT ONE HAD BEEN AN AFTERMARKET TAILPIPE REPLACEMENTPROBLEM AND THE OTHER RELATED TO PARKING IN A SNOWBANK.ANALYSIS:A MODEL 33 UNIT IN RICHLAND, WA, WAS EXAMINED.THE INVESTI-GATOR CONFIRMED THAT THE UNIT HAD NOT BEEN MODIFIED IN ACCORDANCE WITHINSTRUCTIONS CONTAINED IN THE MANUFACTURER'S SAFETY RECALL CAMPAIGN(85V-138).PICTURES TAKEN SHOWED THAT THE APU EXHAUST OUTLETS FOR BOTHTHE PRODUCTION AND MODIFIED VERSIONS SATISFY THE REQUIREMENTS EXPRESSED INTHE ANSI STANDARD FOR RECREATIONAL VEHICLES, CHAPTER 3, SECTION 4.3.TESTS FOR CO INTRUSION WITH THE APU IN OPERATION SHOWED OFF-SCALE (ABOVE500 PARTS PER MILLION) READINGS IN THE REAR CENTER TO LEFT REAR CORNERWHICH IS IMMEDIATELY ABOVE A TRANSVERSELY LOCATED BED.THE VEHICLECUSTODIAN WOULD PERMIT NO DISTURBANCE OF THE BED.PICTURES AND VISUALEXAMINATION OF THE UNDERBODY REVEALED THE APU TAIL PIPE TO BE CRUSHED ANDMISLOCATED INSIDE THE CORNER OF THE SKIRTING SURROUNDING THE BODY.THEVEHICLE WAS IDENTIFIED AS ONE TO WHICH THE MANUFACTURER'S RECALL APPLIED;THE ANGLED TAILPIPE SHOULD HAVE BEEN REPLACED BY ONE WHICH EXITS AT NINETYDEGREES FROM THE SIDE OF THE VEHICLE AND FORWARD OF THE APU.A SECOND ISSUE CONCERNING THIS VEHICLE WAS RAISED BY THE ATTORNEY REPRE-SENTING THE DECEASED'S ESTATE.HE CLAIMED THAT IMPACT WITH A FIXEDOBJECT CAUSED THE REAR WALL TO BE SEPARATED SO THAT THE LOWER SILL OF THEREAR WINDOW COULD BE OBSERVED FROM UNDER THE VEHICLE.INFORMATION FROMTHE MANUFACTURER REVEALED THAT AN OUTER COSMETIC SKIN HAD BEEN ADDEDTO THE REAR OF THE VEHICLE AS A BEAUTY TREATMENT.THE OBSERVED LOWERSILL WAS IN FACT PART OF THE METAL REINFORCEMENT FOR THE REAR WALL.THEMULTIPLICITY OF WITNESS MARKS ON THE UNDER SIDE OF THE BODY SKIRT INDICATESTHAT THE VEHICLE HAD BEEN GROUNDED MORE THAN ONCE.EXAMINATION OF THE CURBIN FRONT OF THE DECEASED'S RESIDENCE REVEALED A NUMBER OF SCRAPE MARKSRESULTING FROM CONTACT BY THE REAR OF THE MOTOR HOME.ANOTHER ISSUE CONCERNING A SOUTHWIND J MODEL WAS RAISED BY A FLORIDAATTORNEY.HE CORRECTLY POINTED OUT THAT THE DESIGNATION, J, HAD BEENOMITTED FROM THE MANUFACTURER'S SAFETY DEFECT NOTIFICATION.INQUIRY TO THEMANUFACTURER REVEALED THAT THE DESIGNATION HAD BEEN INADVERTENTLY OMITTEDFROM THE RECALL NOTICE BUT THAT ALL THE J MODELS HAD BEEN INCLUDED IN THERECALL BECAUSE THE J MODEL IDENTIFICATION NUMBERS WERE INCLUDED IN THELISTING USED FOR CONSUMER MAILINGS.RECOMMENDATION:CLOSE THIS PRELIMINARY EVALUATION.===Read more

FLEETWOOD SOUTHWIND — All Years Overview

Complete safety history for the FLEETWOOD SOUTHWIND across all model years (1979–2023).

119 Total Recalls

238 Total Complaints

2 Investigations

4 Reported Crashes

11 Reported Fires

2 Reported Deaths

FLEETWOOD SOUTHWIND — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2023	6	2	View
2022	5	1	View
2021	6	1	View
2020	5	3	View
2019	2	0	View
2018	4	0	View
2017	1	1	View
2016	3	2	View
2015	2	0	View
2014	3	1	View
2012	1	7	View
2011	4	0	View
2010	3	0	View
2009	1	0	View
2008	2	0	View
2007	3	3	View
2006	6	5	View
2005	4	12	View
2004	8	14	View
2003	8	24	View
2002	5	5	View
2001	4	6	View
2000 (current)	4	22
1999	2	17	View
1998	1	14	View
1997	2	11	View
1996	1	14	View
1995	0	20	View
1994	0	13	View
1993	2	6	View
1992	1	2	View
1991	1	7	View
1990	1	8	View
1989	2	3	View
1988	2	2	View
1987	2	5	View
1986	1	2	View
1985	3	1	View
1984	2	3	View
1983	2	1	View
1982	1	0	View
1981	1	0	View
1980	1	0	View
1979	1	0	View

Other FLEETWOOD Models

Model	Recalls	Complaints
5TD	0	0	View
ADVANTAGE	0	0	View
ALL MODELS	0	0	View
ALTITUDE	0	0	View
AMERICAN ALLEGIANCE	0	0	View
AMERICAN COACH	0	0	View
AMERICAN DREAM	0	0	View
AMERICAN EAGLE	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2000 FLEETWOOD SOUTHWIND

Complaint Statistics

Top Reported Components

Technical Service Bulletins — 2000 FLEETWOOD SOUTHWIND

Most Affected Components

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

FLEETWOOD SOUTHWIND — All Years Overview

FLEETWOOD SOUTHWIND — Year by Year

Other FLEETWOOD Models