1993 FLEETWOOD SOUTHWIND

2 recalls — 6 complaints

STRUCTURE

Defect Description

THE FRONT LEFT JACK ON THESE MOTORHOMES MAY BE IMPROPERLY INSTALLED.

Consequence

IMPROPERLY INSTALLED JACKS CAN JAM THE STEERING ARMWHICH IS ATTACHED TO THE STEERING GEAR BOX. THIS CAN RESULT IN THE FAILURE TOTURN THE VEHICLE TO THE LEFT.

Remedy

A STOP WILL BE ADDED TO THE REAR TWO MOUNTING BOLTS OF THE JACK.

1,190 vehicles affected

Manufacturer: HWH CORPORATION

VEHICLE SPEED CONTROL

Defect Description

WHILE OPERATING THE ENGINE IN REVERSE GEAR, ENGINE TORQUE CAUSES THE ENGINE TO ROLL, CAUSING THE THROTTLE MODULATOR CABLE ASSEMBLY TO CONTACT THE FLOOR AND BIND THE THROTTLE CABLE HOLDING THE THROTTLE IN AN OPEN POSITION.

Consequence

THE THROTTLE CABLE BINDING WHILE THE THROTTLE IS IN ANOPEN POSITION CAUSES LOSS OF ENGINE SPEED CONTROL WHICH COULD RESULT IN ANACCIDENT.

Remedy

RELOCATION OF RAISED FLOOR SUPPORT HARDWARE ON THE BOX PORTION OF THE MOTORHOME.

359 vehicles affected

Manufacturer: FLEETWOOD ENT., INC.

Complaint Statistics

6 total complaints 1 fires 4 injuries

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	2
STEERING	1
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS	1
PARKING BRAKE	1
ENGINE AND ENGINE COOLING	1

Incident date: Jul 28, 2001

ANTIFREEZE LEAK CAUSED ENGINE FIRE WHILE DRIVING(OHIO TRAFFIC CRASH REPORT). NLM

Fire

Incident date: Oct 18, 2000

VEHICLE WAS COMING AROUND A CURVE AND THE BRAKES FAILED, THERE WAS NEVER AN EMERGENCY BRAKE INSTALLED, THE VEHICLE CRASHED AND 2 PEOPLE WERE INJURED. *SLC

2 injured

Incident date: Oct 18, 2000

VEHICLE WAS COMING AROUND A CURVE AND THE BRAKES FAILED, THERE WAS NEVER AN EMERGENCY BRAKE INSTALLED, THE VEHICLE CRASHED AND 2 PEOPLE WERE INJURED. *SLC

2 injured

Incident date: Jun 4, 1999

WHEN APPLYING THE BRAKES THERE WAS LITTLE BRAKING ABILITY BECAUSE OF THE COLLAPSING OF THE BRAKE LINE. BRAKE LINE WAS REPLACED BY THE OWNER. PLEASE PROVIDE ANY FURTHER DETAILS.

Incident date: Apr 2, 1993

WHEN DRIVING AND APPLYING THE BRAKES THEY ARE VERY HARD AND AREN'T STOPPING THE VEHICLE. VEHICLE HAS BEEN TO THE DEALER THREE TIMES, AND THE DEALER CAN'T DETERMINE THE PROBLEM. *AK

Incident date: Apr 22, 1995

DIFFICULT TO MAINTAIN LANE POSITION DUE TO STEERING PROBLEMS.

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 1990

FRONT BRAKES FAIL

There is no summary currently available

PE — Closed — Model Year: 1985

CO INTRUSION

SUMMARY OF INFORMATION FROM THE MANUFACTURER:THE MANUFACTURER ADVISEDTHAT THE AUXILIARY POWER UNITS (APU'S) AND THEIR EXHAUST SYSTEMS ARE ALLFACTORY INSTALLED.IN ADDITION, THE MANUFACTURER PROVIDED TWO INSTANCESOF CARBON MONOXIDE (CO) ASPHYXIATION WITH THREE FATALITIES.HOWEVER,THESE WERE NOT IN THE ... SUBJECT 1985 MODEL VEHICLES BUT IN EARLIER MODELS.IT WAS DISCLOSED THAT ONE HAD BEEN AN AFTERMARKET TAILPIPE REPLACEMENTPROBLEM AND THE OTHER RELATED TO PARKING IN A SNOWBANK.ANALYSIS:A MODEL 33 UNIT IN RICHLAND, WA, WAS EXAMINED.THE INVESTI-GATOR CONFIRMED THAT THE UNIT HAD NOT BEEN MODIFIED IN ACCORDANCE WITHINSTRUCTIONS CONTAINED IN THE MANUFACTURER'S SAFETY RECALL CAMPAIGN(85V-138).PICTURES TAKEN SHOWED THAT THE APU EXHAUST OUTLETS FOR BOTHTHE PRODUCTION AND MODIFIED VERSIONS SATISFY THE REQUIREMENTS EXPRESSED INTHE ANSI STANDARD FOR RECREATIONAL VEHICLES, CHAPTER 3, SECTION 4.3.TESTS FOR CO INTRUSION WITH THE APU IN OPERATION SHOWED OFF-SCALE (ABOVE500 PARTS PER MILLION) READINGS IN THE REAR CENTER TO LEFT REAR CORNERWHICH IS IMMEDIATELY ABOVE A TRANSVERSELY LOCATED BED.THE VEHICLECUSTODIAN WOULD PERMIT NO DISTURBANCE OF THE BED.PICTURES AND VISUALEXAMINATION OF THE UNDERBODY REVEALED THE APU TAIL PIPE TO BE CRUSHED ANDMISLOCATED INSIDE THE CORNER OF THE SKIRTING SURROUNDING THE BODY.THEVEHICLE WAS IDENTIFIED AS ONE TO WHICH THE MANUFACTURER'S RECALL APPLIED;THE ANGLED TAILPIPE SHOULD HAVE BEEN REPLACED BY ONE WHICH EXITS AT NINETYDEGREES FROM THE SIDE OF THE VEHICLE AND FORWARD OF THE APU.A SECOND ISSUE CONCERNING THIS VEHICLE WAS RAISED BY THE ATTORNEY REPRE-SENTING THE DECEASED'S ESTATE.HE CLAIMED THAT IMPACT WITH A FIXEDOBJECT CAUSED THE REAR WALL TO BE SEPARATED SO THAT THE LOWER SILL OF THEREAR WINDOW COULD BE OBSERVED FROM UNDER THE VEHICLE.INFORMATION FROMTHE MANUFACTURER REVEALED THAT AN OUTER COSMETIC SKIN HAD BEEN ADDEDTO THE REAR OF THE VEHICLE AS A BEAUTY TREATMENT.THE OBSERVED LOWERSILL WAS IN FACT PART OF THE METAL REINFORCEMENT FOR THE REAR WALL.THEMULTIPLICITY OF WITNESS MARKS ON THE UNDER SIDE OF THE BODY SKIRT INDICATESTHAT THE VEHICLE HAD BEEN GROUNDED MORE THAN ONCE.EXAMINATION OF THE CURBIN FRONT OF THE DECEASED'S RESIDENCE REVEALED A NUMBER OF SCRAPE MARKSRESULTING FROM CONTACT BY THE REAR OF THE MOTOR HOME.ANOTHER ISSUE CONCERNING A SOUTHWIND J MODEL WAS RAISED BY A FLORIDAATTORNEY.HE CORRECTLY POINTED OUT THAT THE DESIGNATION, J, HAD BEENOMITTED FROM THE MANUFACTURER'S SAFETY DEFECT NOTIFICATION.INQUIRY TO THEMANUFACTURER REVEALED THAT THE DESIGNATION HAD BEEN INADVERTENTLY OMITTEDFROM THE RECALL NOTICE BUT THAT ALL THE J MODELS HAD BEEN INCLUDED IN THERECALL BECAUSE THE J MODEL IDENTIFICATION NUMBERS WERE INCLUDED IN THELISTING USED FOR CONSUMER MAILINGS.RECOMMENDATION:CLOSE THIS PRELIMINARY EVALUATION.===Read more

FLEETWOOD SOUTHWIND — All Years Overview

Complete safety history for the FLEETWOOD SOUTHWIND across all model years (1979–2023).

119 Total Recalls

238 Total Complaints

2 Investigations

4 Reported Crashes

11 Reported Fires

2 Reported Deaths

FLEETWOOD SOUTHWIND — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2023	6	2	View
2022	5	1	View
2021	6	1	View
2020	5	3	View
2019	2	0	View
2018	4	0	View
2017	1	1	View
2016	3	2	View
2015	2	0	View
2014	3	1	View
2012	1	7	View
2011	4	0	View
2010	3	0	View
2009	1	0	View
2008	2	0	View
2007	3	3	View
2006	6	5	View
2005	4	12	View
2004	8	14	View
2003	8	24	View
2002	5	5	View
2001	4	6	View
2000	4	22	View
1999	2	17	View
1998	1	14	View
1997	2	11	View
1996	1	14	View
1995	0	20	View
1994	0	13	View
1993 (current)	2	6
1992	1	2	View
1991	1	7	View
1990	1	8	View
1989	2	3	View
1988	2	2	View
1987	2	5	View
1986	1	2	View
1985	3	1	View
1984	2	3	View
1983	2	1	View
1982	1	0	View
1981	1	0	View
1980	1	0	View
1979	1	0	View

Other FLEETWOOD Models

Model	Recalls	Complaints
5TD	0	0	View
ADVANTAGE	0	0	View
ALL MODELS	0	0	View
ALTITUDE	0	0	View
AMERICAN ALLEGIANCE	0	0	View
AMERICAN COACH	0	0	View
AMERICAN DREAM	0	0	View
AMERICAN EAGLE	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health