1990 FLEETWOOD SOUTHWIND

1 recalls — 8 complaints

STEERING: STEERING WHEEL/HANDLE BAR

Defect Description

THE STEERING COLUMN SHAFT NUT RETAINING CLIP MAY BE MISSING. UNDER CERTAIN CONDITIONS, THE LACK OF A RETAINING CLIP WILL ALLOW THE NUT TO WORK LOOSE AND THE STEERING WHEEL TO SEPARATE FROM THE STEERING COLUMN.

Consequence

STEERING WHEEL SEPARATION FROM THE STEERING COLUMN CANRESULT IN COMPLETE LOSS OF STEERING CONTROL AND A VEHICLE ACCIDENT.

Remedy

INSPECT STEERING ASSEMBLY FOR A STEERING WHEEL NUT RETAINING CLIP. IF CLIP IS MISSING, INSTALL A STEERING WHEEL NUT RETAINING CLIP, OR HAVE A DEALER INSPECT AND INSTALL A CLIP. FLEETWOOD ADVISES OWNERS NOT TO OPERATE THE MOTORHOMES UNTIL A STEERING WHEEL NUT INSPECTION AND CLIP INSTALLATION IS COMPL... Read more

20,413 vehicles affected

Manufacturer: FLEETWOOD ENT., INC.

Complaint Statistics

8 total complaints 1 fires

Top Reported Components

Component	Complaints
SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:SPRINGS/BAGS	1
SUSPENSION	1
VISIBILITY:WINDSHIELD	1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM	1
STRUCTURE:BODY	1
EXTERIOR LIGHTING	1
ENGINE AND ENGINE COOLING:ENGINE	1
ELECTRICAL SYSTEM:WIRING	1

Incident date: Jul 24, 1998

HAD STARTED MOTORHOME WHEN MOTORHOME CAUGHT FIRE. FIRE DEPT WAS CALLED & PUT FLAMES OUT. MOTORHOME TOTALED. FIRE DEPT REPORT & INSURANCE INSPECTOR CONCURRED THAT ELECTRICAL WIRING WAS CAUSE OF THE FIRE. *AK *SLC

Fire

Incident date: Jan 1, 1992

BOLTS AND BRACKETS THAT HOLD ENGINE KEEP BREAKING.

Incident date: Oct 31, 1991

VEHICLE HAS HAD CONTINUOUS SUSPENSION PROBLEMS SINCE OWNERSHIP, BREAKS LOOSE FROM THE FRAME, THE VEHICLE IS VERY HARD TO CONTROL ON THE ROAD.

Incident date: Dec 8, 1997

WINDSHIELD IS TOO AND LEAKS WATER.

SMOG PUMP FAILED, IT FROZE UP.

ROOF LEAKS, CRACK IN THE CORNERS.

BEDROOM LIGHT FAILED DUE TO RUSTING OF THE SWITCH/LEAKING.

Incident date: May 9, 1995

VEHICLE WENT OUT OF CONTROL DUE TO DESIGN OF SPRINGS, CAUSING VEHICLE TO SWAY/VIBRATE. *SKD

NHTSA Safety Investigations — FLEETWOOD SOUTHWIND

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 1990

FRONT BRAKES FAIL

There is no summary currently available

PE — Closed — Model Year: 1985

CO INTRUSION

SUMMARY OF INFORMATION FROM THE MANUFACTURER:THE MANUFACTURER ADVISEDTHAT THE AUXILIARY POWER UNITS (APU'S) AND THEIR EXHAUST SYSTEMS ARE ALLFACTORY INSTALLED.IN ADDITION, THE MANUFACTURER PROVIDED TWO INSTANCESOF CARBON MONOXIDE (CO) ASPHYXIATION WITH THREE FATALITIES.HOWEVER,THESE WERE NOT IN THE ... SUBJECT 1985 MODEL VEHICLES BUT IN EARLIER MODELS.IT WAS DISCLOSED THAT ONE HAD BEEN AN AFTERMARKET TAILPIPE REPLACEMENTPROBLEM AND THE OTHER RELATED TO PARKING IN A SNOWBANK.ANALYSIS:A MODEL 33 UNIT IN RICHLAND, WA, WAS EXAMINED.THE INVESTI-GATOR CONFIRMED THAT THE UNIT HAD NOT BEEN MODIFIED IN ACCORDANCE WITHINSTRUCTIONS CONTAINED IN THE MANUFACTURER'S SAFETY RECALL CAMPAIGN(85V-138).PICTURES TAKEN SHOWED THAT THE APU EXHAUST OUTLETS FOR BOTHTHE PRODUCTION AND MODIFIED VERSIONS SATISFY THE REQUIREMENTS EXPRESSED INTHE ANSI STANDARD FOR RECREATIONAL VEHICLES, CHAPTER 3, SECTION 4.3.TESTS FOR CO INTRUSION WITH THE APU IN OPERATION SHOWED OFF-SCALE (ABOVE500 PARTS PER MILLION) READINGS IN THE REAR CENTER TO LEFT REAR CORNERWHICH IS IMMEDIATELY ABOVE A TRANSVERSELY LOCATED BED.THE VEHICLECUSTODIAN WOULD PERMIT NO DISTURBANCE OF THE BED.PICTURES AND VISUALEXAMINATION OF THE UNDERBODY REVEALED THE APU TAIL PIPE TO BE CRUSHED ANDMISLOCATED INSIDE THE CORNER OF THE SKIRTING SURROUNDING THE BODY.THEVEHICLE WAS IDENTIFIED AS ONE TO WHICH THE MANUFACTURER'S RECALL APPLIED;THE ANGLED TAILPIPE SHOULD HAVE BEEN REPLACED BY ONE WHICH EXITS AT NINETYDEGREES FROM THE SIDE OF THE VEHICLE AND FORWARD OF THE APU.A SECOND ISSUE CONCERNING THIS VEHICLE WAS RAISED BY THE ATTORNEY REPRE-SENTING THE DECEASED'S ESTATE.HE CLAIMED THAT IMPACT WITH A FIXEDOBJECT CAUSED THE REAR WALL TO BE SEPARATED SO THAT THE LOWER SILL OF THEREAR WINDOW COULD BE OBSERVED FROM UNDER THE VEHICLE.INFORMATION FROMTHE MANUFACTURER REVEALED THAT AN OUTER COSMETIC SKIN HAD BEEN ADDEDTO THE REAR OF THE VEHICLE AS A BEAUTY TREATMENT.THE OBSERVED LOWERSILL WAS IN FACT PART OF THE METAL REINFORCEMENT FOR THE REAR WALL.THEMULTIPLICITY OF WITNESS MARKS ON THE UNDER SIDE OF THE BODY SKIRT INDICATESTHAT THE VEHICLE HAD BEEN GROUNDED MORE THAN ONCE.EXAMINATION OF THE CURBIN FRONT OF THE DECEASED'S RESIDENCE REVEALED A NUMBER OF SCRAPE MARKSRESULTING FROM CONTACT BY THE REAR OF THE MOTOR HOME.ANOTHER ISSUE CONCERNING A SOUTHWIND J MODEL WAS RAISED BY A FLORIDAATTORNEY.HE CORRECTLY POINTED OUT THAT THE DESIGNATION, J, HAD BEENOMITTED FROM THE MANUFACTURER'S SAFETY DEFECT NOTIFICATION.INQUIRY TO THEMANUFACTURER REVEALED THAT THE DESIGNATION HAD BEEN INADVERTENTLY OMITTEDFROM THE RECALL NOTICE BUT THAT ALL THE J MODELS HAD BEEN INCLUDED IN THERECALL BECAUSE THE J MODEL IDENTIFICATION NUMBERS WERE INCLUDED IN THELISTING USED FOR CONSUMER MAILINGS.RECOMMENDATION:CLOSE THIS PRELIMINARY EVALUATION.===Read more

FLEETWOOD SOUTHWIND — All Years Overview

Complete safety history for the FLEETWOOD SOUTHWIND across all model years (1979–2023).

119 Total Recalls

238 Total Complaints

2 Investigations

4 Reported Crashes

11 Reported Fires

2 Reported Deaths

FLEETWOOD SOUTHWIND — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2023	6	2	View
2022	5	1	View
2021	6	1	View
2020	5	3	View
2019	2	0	View
2018	4	0	View
2017	1	1	View
2016	3	2	View
2015	2	0	View
2014	3	1	View
2012	1	7	View
2011	4	0	View
2010	3	0	View
2009	1	0	View
2008	2	0	View
2007	3	3	View
2006	6	5	View
2005	4	12	View
2004	8	14	View
2003	8	24	View
2002	5	5	View
2001	4	6	View
2000	4	22	View
1999	2	17	View
1998	1	14	View
1997	2	11	View
1996	1	14	View
1995	0	20	View
1994	0	13	View
1993	2	6	View
1992	1	2	View
1991	1	7	View
1990 (current)	1	8
1989	2	3	View
1988	2	2	View
1987	2	5	View
1986	1	2	View
1985	3	1	View
1984	2	3	View
1983	2	1	View
1982	1	0	View
1981	1	0	View
1980	1	0	View
1979	1	0	View

Other FLEETWOOD Models

Model	Recalls	Complaints
5TD	0	0	View
ADVANTAGE	0	0	View
ALL MODELS	0	0	View
ALTITUDE	0	0	View
AMERICAN ALLEGIANCE	0	0	View
AMERICAN COACH	0	0	View
AMERICAN DREAM	0	0	View
AMERICAN EAGLE	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health