FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
88,303 vehicles affected
ENGINE AND ENGINE COOLING:ENGINE
THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD FALL OFF THE AIR CLEANER ASSEMBLY AND LAND ON THE EXHAUST MANIFOLD CREATING A FIRE HAZARD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME THAT THE PLASTIC TRIM COVER FALLS OFF, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
Remedy: REMOVE THE TRIM COVER AND DISCARD.
87,174 vehicles affected
ENGINE AND ENGINE COOLING:ENGINE
THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD DETACH FROM THE AIR CLEANER ASSEMBLY AND FALL FORWARD ON THE EXHAUST MANIFOLD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME OF DETACHMENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
Remedy: REMOVE THE TRIM COVER AND DISCARD.
34,331 vehicles affected
FIRE ERUPTED IN THE DASH WERE THE RADIO WAS LOCATED RUINING THE VEHICLE, THE VEHICLE WAS OFF AND PARKED AND THE ENGINE WAS NOT AFFECTED. NLM
Fire
WHENEVER ACCELERATOR PEDAL IS DEPRESSED, THE THROTTLE CABLE WOULD STICK. WILL BE TAKING VEHICLE TO DEALER. *AK
WHILE DRIVING ABOUT (30) MPH ON DRY ROADS, THE BACK BRAKE ON THE RIGHT SIDE WENT OUT AND CAUSED THE FRONT BRAKE ON THE LEFT SIDE TO GO OUT. THIS ALMOST CAUSED AN INCIDENT. VEHICLE HAS NOT BEEN SEEN BY DEALER. *AK
ELECTRICAL FIRE.(OHIO STATE POLICE REPORT)
Fire