2000 CHEVROLET ASTRO Recalls, Complaints & Safety

WHILE DRIVING THE 2000 CHEVY ASTRO THE ENGINE SHUT OFF AND NO BRAKES. HAPPENED TO ME IN TWO WEEKS. LIFE OR DEATH SITUATION.

I ENTERED A PARKING LOT AT 10 MPH AND SLOWED TO 5 MPH AND TURNED LEFT INTO A PARKING SPACE AND TRIED TO STOP. THE BRAKES DID NOT WORK AND I CRASHED INTO THE VEHICLE NEXT TO ME. I IMMEDIATELY CHECKED THE BRAKE FLUID LEVEL AND IT WAS FULL. NO ABS LIGHT HAS EVER BEEN ON, AND I JUST RECENTLY PASSED MY VEHICLE SAFETY CHECK WITH NO CODES ON THE SYSTEM. *TR

Crash

TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT STATED THE HORN ACTIVATED INDEPENDENTLY WHILE PARKED OR WHEN MAKING TURNS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FAILURE WAS DUE TO THE HORN AND THE AIRBAG INTERACTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE AND THE CURRENT MILEAGE WAS 98,000. UPDATED 09/22/2014*LJ THE CONSUMER STATED THAT THE HORN WAS DEACTIVATED. UPDATED 2/12/15*JS

HI, I WAS DRIVING THIS VAN WHEN ALL OF A SUDDEN IT STOPS. I HAD A VERY HARD PROBLEM OF TRYING TO GET OFF THE ROAD WITH NO BRAKES OR STEERING. I HAD IT TOWED INTO SERVICE. THEY REPLACED EVERYTHING FUEL PUMP, SENDING UNIT, FUEL FILTER, PLUGS, PLUG WIRES, DISTRIBUTOR AND RESET THE TIMING. IT NEVER DID SHOW UP A CHECK ENGINE LIGHT OR SHOWED A CODE THAT SOMETHING WAS WRONG. I DROVE IT TWO DAYS LATER AND IT DID THE SAME THING. THEY CHECKED IT OUT AND DROVE IT AGAIN FOR A WEEK AND IT HAPPEN AGAIN. I SPENT $1200 TRYING TO GET THIS SAFE TO DRIVE. IT IS AS IF THE KEY WAS SHUT OFF. FINALLY WITH SOME OF MY KNOWLEDGE ABOUT WHAT CAN CAUSE THIS TO HAPPEN I CHECKED THE BATTERY. IT WAS ONLY ONE YEAR OLD. IT SHOWED UP AS BAD UNDER A LOAD. WHEN I TOOK THE VAN BACK TO THE REPAIR SHOP THEY SAID BATTERY SHOWED GOOD. FINALLY I TOOK THE BATTERY BACK TO AUTO ZONE THEY SHOWED IT AS BAD ALSO AND REPLACED IT. NEVER HAD A PROBLEM AFTER THAT. SO THE PROBLEM YOU ARE HAVING WITH THE KEY SWITCH IN ALL THOSE CARS YOU MAY HAVE TO DOUBLE CHECK THE BATTERY'S. VOLTAGE TO THE MICROPROCESSOR SHOULD STAY WITHIN LIMITS OF APX 8 VOLTS. THIS MIGHT BE MORE OF A PROBLEM THAN THE KEY SWITCH. THANKS FOR READING THIS LETTER. *TR

VAN SHUT DOWN WHILE DRIVING AND WE LOSS BRAKES. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE ATTEMPTED TO ENGAGE THE BRAKES BUT THE BRAKE PEDAL SUNK INTO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE BRAKES LINES WERE ALSO CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 82,257 AND THE CURRENT MILEAGE WAS 88,000. UPDATED 12/30/13*CN THE CONSUMER ALSO STATED RUST CAUSED THE ABS TO ENGAGE AT LOW SPEEDS ON DRY PAVEMENT, CAUSING THE VEHICLE TO CONTINUE TO MOVE, EVEN THOUGH THE BRAKE PEDAL WAS DEPRESSED.

ABS SYSTEM ACTIVATED ON DRY PAVEMENT WHILE PARKING THE CAR. BRAKE PEDDLE WENT TO THE FLOOR CAR KEPT MOVING IT SEEM TO WANT TO ACCELERATE. IT HIT THE OPPOSING PARKED VEHICLE. THIS HAS BEEN A INTERMITTENT PROBLEM. MECHANICS COULD NOT FIND PROBLEM PRIOR TO ACCIDENT AFTER ACCIDENT HAD VEHICLE REPAIRED AT CHEVY DEALER HUBS AND SENSORS REPLACED THIS VEHICLE IS VERY SCARY TO DRIVE.EVEN AFTER REPAIRS THE ABS SYSTEM CAN STILL FUNCTION INAPPROPRIATELY WITHOUT ANY WARNING. *TR

Crash

OEM CARPET COVERING THE INTERIOR ENGINE COWLING IS CURLING UP, CAUSING IT TO INTERFERE WITH THE TRAVEL OF THE GAS PEDAL. GAS PEDAL CANNOT COME BACK TO ITS RESTING POSITION, CAUSING THE VEHICLE TO CONTINUE TO ACCELERATE. *KB

REAR A/C SWITCH BURNED UP. SMELLED PLASTIC BURNING , SAW SMOKE CAME OUT OF REAR A/C SWITCH ON DASH. POPPED OFF SWITCH AND FOUND BURNED SWITCH AND WIRES. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT STATED WHEN BRAKING ON ANY UNEVEN ROAD SURFACE, THE ANTI-LOCK BRAKE SYSTEM WOULD ACTIVATE INDEPENDENTLY WITH THE ILLUMINATION OF THE ABS WARNING LIGHT MAKING IT DIFFICULT TO STOP THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN THREE SEPARATE CRASHES AS A RESULT OF THE FAILURE. ON ONE OCCASION WHILE TRAVELING 45 MPH, THE BRAKES WERE APPLIED ABRUPTLY BUT DID NOT RESPOND AND THE CONTACT CRASHED INTO ANOTHER VEHICLE. THERE WAS ONE REPORTED INJURY AND A POLICE REPORT WAS FILED. THE CONTACT STATED THAT THE ABS WAS ACTIVATED AT THE TIME OF THE CRASH. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE 151,000.

Crash 1 injured

2000 CHEVY ASTRO VAN ABS PROBLEM. WHILE TRAVELING AT LOW SPEED CITIES, PARKING LOTS ETC... WHEN ATTEMPTING TO STOP THE ABS APPEARS TO KICK ON CAUSING FAILURE TO STOP. I HAVE HAD SEVERAL NEAR ACCIDENTS WITH MY CHILDREN IN THE VAN RECENTLY. MECHANICS SAY MAYBE MASTER CYLINDER, MAYBE BELTS, MAYBE???? CAN ANYONE SAY RECALL??? *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT WAS UNABLE TO PULL THE FRONT PASSENGER SEAT BELT OUT OF THE RETRACTOR. THE DEALER AND WANTED $250 TO REPAIR IT. THE CONTACT STATED THAT SINCE THIS WAS A SAFETY ISSUE IT SHOULD BE REPAIRED AT NO COST. THE FAILURE MILEAGE WAS 72,000. THE CURRENT MILEAGE WAS 80,000. THE VIN UNKNOWN.

WHILE TRAVELING AT HIGHWAY SPEEDS THE ACCELERATOR PEDAL BECAME STUCK. VEHICLE CONTINUED TO ACCELERATE IN A RUN-AWAY MODE. VEHICLE WAS EVENTUALLY STOPPED THROUGH COMBINATION OF BRAKES AND TRAVELING INTO MUD. UPON STOPPING IT WAS NOTICED THAT THE FRONT BRAKES WERE FLAMING - MOST LIKELY DUE TO EXCESSIVE HEAT. *TR

Fire

WHILE TRAVELING AT HIGHWAY SPEEDS THE ACCELERATOR PEDAL BECAME STUCK. VEHICLE CONTINUED TO ACCELERATE IN A RUN-AWAY MODE. VEHICLE WAS EVENTUALLY STOPPED THROUGH COMBINATION OF BRAKES AND TRAVELING INTO MUD. UPON STOPPING IT WAS NOTICED THAT THE FRONT BRAKES WERE FLAMING - MOST LIKELY DUE TO EXCESSIVE HEAT. *TR

Fire

WHILE TRAVELING AT HIGHWAY SPEEDS THE ACCELERATOR PEDAL BECAME STUCK. VEHICLE CONTINUED TO ACCELERATE IN A RUN-AWAY MODE. VEHICLE WAS EVENTUALLY STOPPED THROUGH COMBINATION OF BRAKES AND TRAVELING INTO MUD. UPON STOPPING IT WAS NOTICED THAT THE FRONT BRAKES WERE FLAMING - MOST LIKELY DUE TO EXCESSIVE HEAT. *TR

Fire

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. WHILE THE CRUISE CONTROL WAS SET AT SPEEDS OF 65 MPH, THE BRAKE PEDAL WAS APPLIED TO DISENGAGE THE CRUISE CONTROL. HOWEVER, THERE WAS NO RESPONSE. THE VEHICLE CONTINUED TO ABNORMALLY ACCELERATE WHILE THE BRAKES WERE APPLIED. THERE WAS AN EXTREMELY LOUD ROARING NOISE COMING FROM THE ENGINE WITH AN INCREASE IN THE RPMS. THE VEHICLE WAS RAPIDLY APPROACHING A TRAFFIC LIGHT AND THE GEAR WAS SHIFTED INTO NEUTRAL POSITION. THE ENGINE WAS TURNED OFF. THE VEHICLE WAS COASTED TO A STOP WITH VERY LIMITED BRAKING POWER. AFTER SEVERAL MOMENTS, THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS ABLE TO RESUME OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER. THE CPU (CENTRAL PROCESSING UNIT) AND OPTICAL WHEEL SENSORS WERE INTERMITTENTLY FAULTY WHICH REQUIRED REPLACEMENT. THE SENSORS WERE CLEANED TO CORRECT THE PROBLEM. THE IDENTICAL FAILURE OCCURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN BACK TO THE DEALER THAT ADVISED THE REPLACEMENT OF THE ENTIRE CPU. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000. UPDATED 4/26/10 *CN UPDATED 06/17/10*JB

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN WITH DELTA ESTEEM XLE TIRES. WITHIN A MONTH AFTER TWO TIRES WERE PURCHASED BY THE SAME MANUFACTURE. HE WAS TRAVELING AT 75 MPH THE VEHICLE STARTED TO SEVERELY SHAKE. HE PULLED OVER TO INSPECT THE TIRES BUT WAS UNABLE TO FIND THE FAILURE. HE THEN PRECEDED TO DRIVE AT 50 MPH AND TOOK THE VEHICLE STRAIGHT TO A DEALER. THE MECHANIC THERE INSPECTED THE VEHICLE AND NOTICED SEVERE THREAD SEPARATION AND BUBBLES ON THE SIDE OF THE FRONT DRIVER SIDE TIRE. THE TIRE WAS THEN REPLACED. A FEW MONTHS LATER HE WAS TRAVELING AT 75MPH WHEN THE VEHICLE STARTED SHAKING. BEFORE ATTEMPTING TO PULL OVER TO THE SIDE OF THE ROAD THE REMAINING DELTA TIRE THAT WAS LOCATED ON THE FRONT PASSENGER SIDE BLEW OUT. HE REPLACED THE TIRE BUT HE BELIEVES THAT THE TIRES WHERE DEFECTED AND SHOULD BE RECALLED. THE FAILURE MILEAGE WAS 370,000. THE CURRENT MILEAGE IS 380,000. -

MY 2000 CHEVROLET ASTRO HAS AN ACCELERATOR THAT DOES NOT STOP ITS ACCELERATION WHEN THE GAS PEDAL IS RELEASED. DEPENDING ON THE SLOPE OF THE ROAD, THE VEHICLE MAY GAIN SPEED UNTIL IT IS SHIFTED INTO NEUTRAL. IT IS NOT A BIG EVENT ON DRY ROADS, BUT YESTERDAY WHEN IT HAPPENED IN THE SNOW, IT ALMOST CAUSED A CRASH. I HAVE HAD IT SERVICED BY DIFFERENT DEALERS 3 TIMES AND AM STILL HAVING THE SAME PROBLEM. IT IS READY TO BE PICKED UP AFTER TAKING IT IN AGAIN YESTERDAY FOR THE SAME PROBLEM. IT DOES THIS ON OCCASION, BUT VERY OFTEN AFTER BEING ON CRUISE CONTROL. *TR

TL*THE CONTACT OWNS 2000 CHEVROLET ASTRO VAN. THE DEFECTIVE TIRE WAS A PEP BOYS FUTURA, SCRAMBLER AP, TIRE SIZE P215/75R/15. THE DOT NUMBER IS 3DHFPANM3104. WHILE DRIVING APPROXIMATELY 55 MPH, THE TIRE TREAD SEPARATED FROM THE LEFT REAR TIRE. THE TIRE SEPERATED FROM THE VEHICLE AND LEFT RUBBER MARKS IN THE MIDDLE OF THE REAR PANEL. THERE WAS NO TRACTION WHEN THE INCIDENT OCCURRED. THERE WERE NO INJURIES OR PRIOR WARNINGS TO THE FAILURE. THE TIRE MANUFACTURER STATED THAT THE FAILURE WAS RELATED TO TIRE TREAD SEPARATION. THE TIRE WAS REPLACED. THE DOT AND ADDITIONAL TIRE INFORMATION WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 151,547.

MY AC FAILED TO BLOW COLD AFTER I NOTED SOME OIL (NOT MOTOR OIL) UNDER THE FRONT PASSENGER SIDE OF THE VEHICLE. THE DEALERSHIP RECHARGED THE SYSTEM WHICH WAS APPARENTLY EMPTY INCLUDING DYE FOR WHICH I BORE THE COST ($200+). LESS THAN 12 HRS LATER THE SYSTEM NO LONGER BLEW COLD AND NO FLUID WAS NOTED UNDER THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP FOR INSPECTION OF THE DYE. THE MECHANIC REMOVED THEN INTERIOR ENGINE HOOD AND FOUND THAT THE AC LINE HAD RUBBED AGAINST THE TRANSMISSION FILLER TUBE (NOW METAL ON METAL). A HOLE THE SIZE OF A DIME TO NICKEL WAS IN THE FILLER TUBE AND THE AC LINE ALSO HAD A HOLE IN IT. I ALSO HAVE ANOTHER 2K CHEVY ASTRO THAT WAS DIAG'D SEVERAL YEARS AGO FOR THE SAME HOLE IN THE AC LINE BUT IT HAD NOT WORN A HOLE IN THE TRANSMISSION FILLER TUBE. THE MECHANIC HAD INDICATED THAT THE AC LINE WAS "RUN THAT WAY FROM THE FACTORY". AT THIS POINT FOREIGN MATTER HAS FALLEN INTO THE TRANSMISSION INCLUDING THE METAL FROM THE FILLER TUBE, THE BLACK FOAM COVER ON THE AC LINE AND APPARENTLY THE FREON FROM THE DYE RECHARGE. I HAVE TO PRESUME OTHER FOREIGN MATTER HAS MADE ITS WAY IN TO FILLER TUBE AS WELL. I AM NOW ATTEMPTING THE HAVE GM COVER THE $1K REPAIR TO THE AC LINE AND TRANSMISSION FILLER TUBE. *TR

I RECENTLY HEARD OF A RECALL ON THE TAHOES AND GM TRUCKS REGARDING THE GAUGE PANEL OR CLUSTER PANEL. I DRIVE A 1990 CHEVY ASTRO VAN WHICH IS ON A TAHOE FRAME. I AM HAVING THE SAME TYPES OF PROBLEMS WITH MY GAUGE PANEL AS DESCRIBED IN THE RECALL. MY ABS/BRAKE LIGHT COMES ON AT VARIOUS TIMES FOR NO REASON. MY TEMP AND OIL GAUGES CHANGE FROM HOT TO COLD AND BACK AGAIN FOR NO REASON AND THE CHECK GAUGE LIGHT WILL LIGHT UP. NOW THE GAS HAD WILL CHANGE EVEN WHEN THE CAR IS NOT ON. AS A WOMAN I NEED TO BE ABLE TO DEPEND ON MY CARS GAUGES TO LET ME KNOW IF THERE IS A PROBLEM. I TOOK THE CAR TO THE SHOP YESTERDAY AND THEY COULD NOT FIND A REASON FOR MY CAR TO BE DOING THESE THINGS. I CALLED OUR CHEVY DEALER HERE IN GRIFFIN WHERE THE CAR WAS PURCHASED AND THEY DID NOT WANT TO HELP ME. I AM NOW ASKING YOU FOR HELP. SINCERELY, DANA D. HORTMAN *TR

UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSING INCREASED STOPPING DISTANCE. *TR

DOOR HANDLE ON RIGHT REAR DUTCH DOOR OF OUR 2000 ASTRO VAN BROKE SUDDENLY WHEN TRYING TO OPEN DOOR. WHILE THE DUTCH DOOR FEATURE IS OPERATIONALLY VERY HANDY, THE DOOR DESIGN ALWAYS HAD A FLIMSY FEEL TO IT - SO WE ALWAYS USED GREAT CARE WHEN OPENING AND CLOSING. AFTER IT BROKE, WE FOUND THE NHTSA #634576 WITH SIMILAR COMPLAINTS, SO FELT OBLIGATED TO ADD TO YOUR LIST. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE HAZARD LIGHT SWITCH AND BRAKE LIGHTS MALFUNCTIONED. THE DEALER STATED THAT THE SWITCH WAS FAULTY AND WAS THE SAME AS THE RECALLED SWITCH FOR THE 2001 CHEVROLET ASTRO (NHTSA CAMPAIGN ID NUMBER 05V099000 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CURRENT AND FAILURE MILEAGES WERE 90,000. UPDATED 02-14-08. *KB

CHEVY 2000 ASTRO, CUTS OUT WHILE DRIVING. WE EVEN PUSHED THE VAN INTO A CHEVY DEALER AND THEY COULD NOT TELL US WHAT IT WAS AFTER HOOKING IT UP TO DIAGNOSTICS. WE FIGURED IT WAS THE COIL WIRE. RECENTLY THE VAN HAS BEEN BOGGING DOWN WHEN IT IS UNDER LOAD. ALSO, WHEN IT RAINS IT RUNS ROUGH. WE TOOK IT TO A SHOP AND THEY REPLACED OUR FUEL FILTER. IT RAN FINE BUT STILL CUTS OUT SOMETIMES RUNNING UP HILL. SO WE CHANGED THE SPARK PLUGS. IF YOU LET THE VAN SIT OVER THE WEEKEND WITH OUT DRIVING IT, THE VAN WAS REALLY HARD TO START. UNTIL FINALLY IT JUST WOULDN'T START AT ALL. IN ADDITION THE DOOR LOCKS SOMETIMES WORK AND SOMETIMES DON'T . THE DRIVER SIDE WINDOW IS VERY SLUGGISH GOING UP YOU ACTUALLY HAVE TO HELP IT BY PULLING UP ON IT. WE KEEP BLOWING FUSES WHEN WE USE OUR CIGARETTE LIGHTER TO CHARGE OUR CELL PHONE. IT REALLY NEEDS HELP. *TR

MY 2000 CHEVROLET ASTRO VAN WITH ALL WHEEL DRIVE INTERMITTENTLY FAILS TO STOP AT LOW SPEEDS DUE TO INAPPROPRIATE ACTIVATION OF THE ANTI LOCK BRAKING SYSTEM. THIS CONDITION HAS NEARLY RESULTED IN SEVERAL ACCIDENTS THAT JEOPARDIZED THE SAFETY OF PEOPLE AND PROPERTY, SUCH AS WHEN TRAVELING IN PARKING LOTS AND CROWDED CITY STREETS. THE ABS SYSTEM FAILURE DOES NOT REGISTER A SERVICE CODE, AND THE PROBLEM WAS NOT RECOGNIZED BY SERVICE DEPARTMENT AT THE LOCAL GM DEALERSHIP, WHO REPLACED TRANSFER CASE FLUID IN THE ABSENCE OF HAVING A CLUE. THROUGH SELF DIAGNOSIS, THE PROBLEM WAS CONFIRMED TO BE THE ABS SYTEM BECAUSE THE BRAKES OPERATE NORMALLY WHEN THE FUSE IS REMOVED FROM THE WIRING BLOCK SLOT LABELED ABS. DUE TO THE ABSENCE OF ANY PHYSICAL DAMAGE TO THE VEHICLE, AND THE FAILURE OF THE VEHICLES DIAGNOSTIC SYSTEM TO DETECT THIS PROBLE, IT IS CLEARLY A DEFECT IN THE VEHICLE OR COMPONENTS DESIGN OR CONSTRUCTION. OWNERS SHOULD NOT HAVE TO PULL FUSES ON SAFETY SYSTEM IN ORDER FOR THE BRAKES TO WORK WHEN NECESSARY. NHTSA SHOULD EVALUATE THE AGGREGATE NUMBER OF COMPLAINTS ALREADY ISSUED WITH THIS PROBLEM, AND UNDERSTAND THAT THE GM TRAINED SERVICE TECHNICIANS ARE NOT HELPING OWNERS REMEDY OR UNDERSTAND THIS DEFECT EXISTS. A RECALL NOTICE SHOULD BE ISSUED. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO. THE CONTACT STATED THAT AS THE VEHICLE COMES TO A ROLLING STOP, THE ANTILOCK BRAKES ACTIVATE AND HE LOSES CONTROL OF THE BRAKES. THE FAILURE ONLY OCCURS WHEN DRIVING AT LOW SPEEDS SUCH AS 5 MPH AND APPROACHING A STOP. HE STATED THAT THE FAILURE BEGAN A FEW DAYS AGO AND HAS GRADUALLY INCREASED IN SEVERITY. THE CURRENT MILEAGE WAS 108,225 AND FAILURE MILEAGE WAS 108,175.

I HAVE A 2000 CHEVROLET ASTRO MINI VAN. AT APPROXIMATELY 65000 MILES, JUST AFTER THE WARRANTY EXPIRED I STARTED HAVING TWO LIGHTS ILLUMINATE ON INSTRUMENT CLUSTER. ONE IS A RED BRAKE LIGHT , AND THE OTHER IS AN AMBER ABS LIGHT. I TOOK VEHICLE TO THE CHEVROLET DEALER. THEY TOLD ME IT WAS THE BRAKE CONTROL MODULE WHICH NEEDED TO BE REPLACED AT A COST OF $1000.00. ONCE THE UNIT HEATS UP AND THE LIGHTS COME ON THE ABS NO LONGER WORKS, AND THE BRAKES BECOME JERKY. ALSO THE TWO LIGHTS BLIND YOU AT NIGHT WHEN YOU DRIVE. THE UNIT IS ON THE OUTSIDE OF THE CAR UNDER THE DRIVER'S SEAT NEXT TO THE EXHAUST PIPE. I TOLD THEM THEY NEEDED TO FIX IT, AND THEY REFUSED, SAYING IT WAS OUT OF WARRANTY. I TOLD THEM THAT IT WAS A DESIGN FLAW BECAUSE IT WAS PLACED NEXT TO THE EXHAUST. THE INDIVIDUAL AT THE DEALER TOLD ME THIS WAS A COMMON PROBLEM WITH GM TRUCKS AND VANS. IT WAS SAFETY ISSUE AND GM REFUSED TO FIX IT. *AK

PAINT IS PEELING IN SEVERAL LOCATIONS. *JB

VAN WILL NOT START FOR ABOUT 15 MIN. AFTER BEING DRIVEN FOR A SHORT DISTANCE AND SHUT OFF. *JB

TL*THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. THE CONTACT HEARD A LOUD NOISE WHILE COMPLETING A RIGHT TURN AT 5 MPH. THE STEERING WHEEL BEGAN TO SHAKE UNCONTROLLABLY. THE CONTACT PULLED OVER, LOOKED UNDERNEATH THE VEHICLE, AND DISCOVERED THE IDLER ARM WAS DETACHED FROM THE VEHICLE'S FRAME. THE DEALER HAS NOT BEEN CONTACTED , AND THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGE WERE 63000.*AK

TL*- THE CONTACT STATED THAT 2000 CHEVROLET ASTRO VAN HAD UPPER BALL JOINT PROBLEMS . THE UPPER BALL JOINTS HAVE BEEN REPLACED TWICE. THE CONTACT STATED THAT HE FELT THIS WAS A SAFETY ISSUE BECAUSE THE UPPER BALL JOINTS COULD SEPARATE, AND THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, CAUSING A CRASH. THE VEHICLEWAS NOW AT DEALERSHIP FOR REPLACEMENT BALL JOINTS AT 130,000 MILES. THE FIRST TIME THIS HAPPEN THE BALL JOINT WAS SAVED, AND THE CONTACT WAS TOLD THAT THE BALL JOINT WAS COMPLETELY DRY. THE CONTACT DOES HAS ACCESS TO THE LAST BALL JOINTS THAT WERE REPLACED. THERE WERE NO CRASHES INVOLVING THE BALL JOINTS, BUT FELT THIS COULD CAUSE A CRASH. *AK

TL* - THE CONTACT STATED THAT 2000 CHEVROLET ASTRO LS' LOCKS FAILED, NOT ALLOWING HER TO GAIN ENTRANCE TO THE VEHICLE ON OCTOBER 18, 2006. THE FAILURE WAS DUE TO THE DOOR LOCK ACTUATOR MELTING. THE CONTACT STATED THAT THE VEHICLE WAS TOWED TO EAGLE AUTOMOTIVE. THE MECHANIC REPLACED THE ACTUATOR, BUT REMOVED THE RELAY BECAUSE THE CIRCUIT WAS CONTINUOUSLY CLOSED. THE MECHANIC SAID THAT IF THEY DIDN'T REMOVE THE RELAY IT WOULD MELT THE ACTUATOR AGAIN. THE CONTACT STATED THAT SHE BELIEVED THE FAILURE WILL REOCCUR. THE CONTACT STATED THAT SHE WENT TO MONUMENT CHEVROLET AND ASKED FOR A PRINT OUT OF THE MAINTENANCE REPAIRS. THE CONTACT FOUND THAT THIS VEHICLE HAS BEEN REPAIRED ON APRIL 3, 2001 FOR BACK DOOR LOCKS AND AGAIN ON FEBRUARY 14, 2002 FOR THE SLIDING DOOR. THE ACTUATOR ASSEMBLY ON THE RIGHT WAS ALSO REPLACED ON THE DRIVER DOOR. THE CONTACT STATED THAT THE DRIVER DOOR AND THE SLIDING DOOR WERE THE ONLY DOORS ON THE VEHICLE THAT HAD FUNCTIONING LOCKS. THE CONTACT STATED THAT ALL OF THE OTHER DOOR LOCK HANDLES WERESTUCK AND COULDN'T BE PULLED TO LOCK OR UNLOCK THE DOORS. SHE HAS TRIED TO GET RESOLUTION FROM THE MANUFACTURER, AND THEY SAID THAT BECAUSE IT WAS NOT TOWED TO A DEALERSHIP THEY WOULD NOT REIMBURSE HER FOR ANY REPAIRS. THE MANUFACTURE WAS GIVEN A FILE #1-438966317. THE CONTACT ALSO SENT PICTURES TO THE MANUFACTURER OF THE BURNT OUT ACTUATORS AND WITH A CERTIFIED LETTER.*AK THE CONSUMER STATED THE BRAKES FAILED, HOWEVER SHE WAS TOLD NOTHING WAS WRONG. THE CONSUMER WAS TOLD THE BRAKES WERE DESIGNED TO FAIL ON UNEVEN PAVEMENT UNDER 25 MPH. THE TROQUED CONVERTER BURNED OUT. THE LOCKS HAD AN ELECTRICAL SHORT. UPDATED 03/19/07. *JB

2000 CHEVROLET ASTRO VAN LOST ALL STEERING CAPABILITIES, WHEELS TURNED IMMEDIATELY TO THE RIGHT AND THE STEERING WHEEL LOCKED. *KB THE MECHANIC INFORMED THE CONSUMER THAT THE DRS STEERING UNIT RIPPED OUT OF THE FRAME. *JB

DT*: THE CONTACT STATED THE PIN THAT HOLDS THE PASSENGER SIDE DOOR FELL OUT CAUSING THE DOOR TO FALL OFF. THE DEALER HAS NOT BEEN ALERTED. UPDATED 9/28/2006 - *NM

EVENTS LEADING UP TO THE FAILURE OF MY INCIDENTS WERE JUST NORMAL DRIVING CONDITIONS AND AT A VERY MINIMAL LOW SPEED, IN WHICH I WAS JUST DRIVING AND ALL OF A SUDDEN HAD NO POWER STEERING OR BRAKES. I WAS SCARED TO DEATH TO NO I HAD KNOW CONTROL OF MY VEHICLE ALL OF A SUDDEN. MY CONSEQUENCES WERE NONE OTHER THAN THE SCARE OF MY LIFE AND THE REALIZATION THAT THIS COULD HAVE BEEN FATAL HAD I BEEN GOING FASTER OR ON A HIGHWAY OR ANY OTHER ROAD THAN A SUBDIVISION ROAD. THIS SITUATION OCCURRED DUE TO THE POWER STEERING PUMP,WHICH HAS A HYDRAULIC VACUUM BOOSTER FOR THE BRAKES AND ALL WORKS TOGETHER . AFTER SPEAKING TO A SERVICE CLERK AT THE CAR DEALER AND STATING THIS WAS SOMETHING I THOUGHT WAS A SAFETY CONCERN TO BE JUST DRIVING ALONG AND LOSE CONTROL OF YOUR STEERING AND BRAKES, HE AGREED. THE PROBLEMS WAS FIXED BY INSTALLING A NEW POWER STEERING PUMP AND FLUID AND CLEANING CHEMISTRY ETC. TOTALING A TOTAL OF $636.32. *NM

DT*: THE CONTACT STATED THE ABS ACTIVATES AT SPEEDS BELOW 5 MPH. THIS CAUSES AN EXCESSIVE STOPPING DISTANCE. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 4/11/2006 - *NM