EXTERIOR LIGHTING
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
27,176 vehicles affected
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
88,303 vehicles affected
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
61,944 vehicles affected
SEATS
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
604,207 vehicles affected
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
A PART OF THE STEERING GEAR HOUSING WHICH ATTACHES TO THE FRAME MAY BREAK. CONSEQUENCE OF DEFECT: STEERING DIFFICULTIES WILL OCCUR AND THE STEERING GEAR TO THE FRAME MAY FRACTURE RESULTING IN LOSS OF STEERING CONTROL. THIS COULD RESULT IN A VEHICLE CRASH.
Remedy: REPLACE BROKEN OR CRACKED STEERING GEAR OR INSTALL A BRACE IF STEERING GEAR IS NOT BROKEN OR CRACKED.
26,741 vehicles affected
PARKING BRAKE:DRIVELINE:AIR:CHAMBER
THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME. CONSEQUENCE OF DEFECT: TRACTORS FAIL TO MEET THE STOPPING DISTANCE SPECIFIED IN FMVSS 121 WHICH IS REQUIRED TO STOP THE TRUCK SAFELY.
Remedy: INSTALL A QUICK RELEASE VALVE IN THE TRAILER SERVICE AIR LINE AND INCREASE THE DIAMETER OF THE REAR SERVICE BRAKE LINE. ALSO INSPECT REAR SPRING BRAKE CHAMBER AND RELEASE IF NECESSARY.
4,870 vehicles affected
I HAD A RECALL DONE ON THIS AT THAT TIME THE DEALER JUST RELPLACED THE BUCKLE BUTTONS AND PUT SOME SPRING CLIP ON THE RETRACTOR, THE SPRING DID NOT HOLD AND THE RETRACTOR TOTALLY GAVE UP WORKING I HEARD IT SPRING ALL OVER IN THE PILLAR AND THE BUCKLE HAS TOTALLY DETRIORATED FROM THE UV LIGHT IF THE RECALL WOULD HAVE BEEN DONE RIGHT I WOULD NOT HAVE THESE PROBLEMS WITH THE SEAT BELTS.RAKES HAS NEVER WORKED PROPERLY AND THERE WAS A RECALL ON THIS BUT ONLY FOR MANUAL TRANSMISSIONS EVEN THOUGH THE SAME COMPONETS FAILED ON THE AUTOMATIC TRANSMISSION CARS AS WELL SEEN IT ALL THE TIME WHEN I WORKED AT A GM DEALER.*AK
I HAD A RECALL DONE ON THIS AT THAT TIME THE DEALER JUST RELPLACED THE BUCKLE BUTTONS AND PUT SOME SPRING CLIP ON THE RETRACTOR, THE SPRING DID NOT HOLD AND THE RETRACTOR TOTALLY GAVE UP WORKING I HEARD IT SPRING ALL OVER IN THE PILLAR AND THE BUCKLE HAS TOTALLY DETRIORATED FROM THE UV LIGHT IF THE RECALL WOULD HAVE BEEN DONE RIGHT I WOULD NOT HAVE THESE PROBLEMS WITH THE SEAT BELTS.RAKES HAS NEVER WORKED PROPERLY AND THERE WAS A RECALL ON THIS BUT ONLY FOR MANUAL TRANSMISSIONS EVEN THOUGH THE SAME COMPONETS FAILED ON THE AUTOMATIC TRANSMISSION CARS AS WELL SEEN IT ALL THE TIME WHEN I WORKED AT A GM DEALER.*AK
TRANSMISSION SLIPS OUT OF GEAR WHILE SITTING/RUNNING OR OFF. BUT TRANSMISSION STILL PULLS VAN REVERSE OR FORWARD. *AK
TILT STEERING COLUMN UNLATCHES AND BEGINS TO SWING WHILE DRIVING. *AK
THE BOLT INSIDE OF THE STEERING COLUMN COME LOOSE. TT