2018 TOYOTA SIENNA

7 recalls — 84 complaints — 403 TSBs — 5/5 safety rating

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 20... Read more

Consequence

If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy par... Read more

1,525,742 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, ... Read more

Consequence

If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and... Read more

1,830,752 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.

Consequence

The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.

Remedy

Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.

303 vehicles affected

Manufacturer: Vantage Mobility International, LLC

STEERING

Defect Description

Braun Corporation (Braun) is recalling certain modified 2017-2020 Toyota Sienna vehicles. The steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture.

Consequence

If the steering shaft extension completely fractures, it can cause a loss of steering, increasing the risk of a crash.

Remedy

Braun has notified owners, and dealers will replace the steering shaft extensions, free of charge. The recall began July 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.

595 vehicles affected

Manufacturer: Braun Corporation

EQUIPMENT:OTHER:LABELS

Defect Description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirement... Read more

Consequence

An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.

Remedy

SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.

1,325 vehicles affected

Manufacturer: Southeast Toyota Distributors, LLC

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.

Consequence

The reduction in the braking system pressure may cause a loss of braking power in the rear braking system, increasing the risk of crash.

Remedy

Braun has notified owners, and dealers will install an adaptor to correct the issue, free of charge. The recall began June 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.

705 vehicles affected

Manufacturer: Braun Corporation

WHEELS

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018 Toyota Sienna vehicles built with a specific lot of 10-spoke alloy wheels from one production facility. These wheels may not have been properly cooled during manufacturing. As a result, the wheels may crack in the spokes f... Read more

Consequence

If the wheels crack at the spokes, the wheel may separate from the hub assembly causing a loss of vehicle control and increasing the risk of a crash.

Remedy

Toyota began notifying owners initially by phone on February 26, 2018 and will mail letters to any unnotified owner starting on April 20, 2018. Dealers will inspect the wheels and replace them if necessary depending on their production location, free of charge. Owners may contact Toyota customer s... Read more

55 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

Complaint Statistics

84 total complaints 4 crashes 2 injuries

Top Reported Components

Component	Complaints
UNKNOWN OR OTHER	13
ENGINE	8
POWER TRAIN	7
FUEL/PROPULSION SYSTEM	6
VEHICLE SPEED CONTROL	6
STRUCTURE:BODY	5
SERVICE BRAKES	5
FUEL SYSTEM, GASOLINE	4
SEATS	4
ELECTRICAL SYSTEM	4

Incident date: Feb 1, 2026

Received a low pressure warning and got off the freeway at the next exit, less than 1/2 mile. Unable to stop on freeway. Before even changing lanes the tire blew out all pressure, total failure. Within 15 seconds of low pressure warning. Stopped immediately after exiting freeway and observed the... Read more

Incident date: Nov 1, 2025

The 2025 and 2026 dually 3500 Ram trucks with the 12" AAM rear axle are having issues with the rear wheel speed sensors (different sensor for each side). They apparently fail or are not able to properly communicate to the computer. When this happens, the following are disabled: -ABS -Auto Emergency ... Read more

Incident date: Jan 14, 2026

Oil filter housing assembly- Resulted in very low engine oil with no warning lights or engine lights potentially leading to engine damage. Yes the component was inspected and replaced by dealership. This was after getting the oil plan repaired for leaking oil as well

Incident date: Oct 29, 2025

Telematics unit in my Chevrolet equinox EV 2025 has failed. GPS/navigation/wifi does not work anymore. Calls to onStar for collision data / support in emergencies also do not work anymore. Also, basic features on the myChevrolet app to unlock/lock the car do not work. This happened gradually over ti... Read more

Incident date: Aug 4, 2025

Issue Description: While driving during daylight hours, especially when the sun is positioned at a certain angle, I have observed an intense reflection from the dashboard onto the inside of the windshield. This reflection is bright and widespread, directly obstructing my field of vision and making i... Read more

Incident date: Jul 9, 2025

The vehicle was in PARK and the IGN was in the ON/RUN position and the air conditioning was on. There was no one in the driver's seat but there was an occupant sitting buckled in the front passenger seat. The passenger heard a sound (possibly the ICE turning on) and he felt the vehicle move forward ... Read more

Incident date: Jun 4, 2025

Since purchasing this vehicle we have had catalytic converter issues that have persisted even after having the dealer "fix" the issue.we have also had ABS/Traction control module issues.this is the 2nd identical vehicle owned with the exact same problems.

Incident date: Apr 24, 2025

2018 Mazda CX5 2.5 ltr engine. Major oil leak that has been diagnosed as cracked or porous aluminum casting on the cylinder block. Oil is dripping consistently out of the problem area onto the manifold, causing smoke to flow into the cabin of the car and out of the hood as well. Car is currently at ... Read more

Incident date: Feb 8, 2025

Known issue and has been attributed to a manufacturing defct, but no recall- Leaking headlight caused damage to headlight- now turn signal and headlight do not work. Entire assembly needs to be replaced, GM / Extended Warranty Company will not cover, this safety part. Head light and turn signal w... Read more

Incident date: Sep 9, 2024

The Anti-Lock Brake(ABS) & Electronic Stability Control(ESC) warning lights will come on and off during normally driving conditions. When The ESC light comes on the cruise control is non functioning. If the cruise control is set when the warning light is off, the cruise will disengage when it comes... Read more

Incident date: Jul 30, 2024

Steering wheel feels loose. able to wiggle the wheel top to bottom and side to side at leas 1/4-1/2 inch of play. According to research on the internet dues to a possible broken plastic bushing in the steering column [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S... Read more

Incident date: Jun 23, 2024

The contact owns a 2015 Ford F-150. The contact stated while driving 60 MPH, the vehicle abruptly downshifted with the transmission warning light illuminated. The contact stated that the vehicle shuddered and hesitated while depressing the accelerator pedal. The vehicle was taken to a dealer on seve... Read more

Incident date: Mar 8, 2019

The contact owns a 2018 Toyota Sierra equipped with a Joysceer USA Inc, Hand Control Unit. The contact stated that while operating the vehicle, the message advising to "Stop immediately" was displayed with the error code: 4209 BSM. The contact stated that later a second error code: 1069 SAM was disp... Read more

Incident date: Mar 8, 2019

On the evening of [XXX], I was making a left hand turn onto [XXX] from [XXX]. I was the second car in line on the left turn green arrow. The first car went to the right lane. I went into the left lane. My car immediately flashed the light in the front window, the alarm went off, and slammed the b... Read more

Incident date: Apr 5, 2024

On April 4, 2024 while driving southbound on I-95 in Connecticut between exit 3 and 2 in Greenwich, all of the dashboard warning indicators lit up, and the brakes failed. I was able to slow to a stop avoiding hitting other vehicles, and moved to the shoulder. I turned the vehicle on and off several ... Read more

Incident date: Feb 19, 2024

The head rest in the passenger seat basically popped open when we were driving. My fiancé said her head and neck hurt bad after that instance.

Incident date: Feb 19, 2024

The contact owns a 2017 Ford Escape. The contact stated that while his son was driving at an undisclosed speed, the engine seized. The vehicle failed to restart, and the contact's son was stranded on the side of the road. The vehicle was towed to the residence. The contact’s son checked the coolan... Read more

Incident date: Oct 15, 2021

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle briefly shuddered. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an i... Read more

Incident date: Sep 4, 2023

On the radio in cars there are always ads that play and it forces people to be distracted during driving to turn off the music or use their phone to use bluetooth. The car radio could potentially be a safety risk

Incident date: Sep 4, 2023

Engine stalled in the middle of the highway. Could not get speed over 30mph to get out of the way of oncoming traffic even with the gas peddle pushed to the floor. Engine light flashing. Finally was able to get over to the side of the road with care bucking and jerking the whole way and stuttered to... Read more

Incident date: Apr 13, 2023

The contact owns a 2023 Honda HR-V. The contact stated while in stop and go traffic there was an abnormal explosion heard. The contact pulled over on the side of the road and noticed that the rear windshield had shattered without impact. The vehicle was taken to the dealer, but no assistance was pro... Read more

Incident date: Mar 17, 2023

The adaptive cruise control slammed the brake when driving over a highway overpass. Tesla slammed the brake from 75 mph to 50 mph. Luckily there was no car behind. Clear sky around noon time.

Incident date: Feb 21, 2023

The contact owns a 2010 Toyota Prius. The contact stated that while driving at various speeds, the vehicle started to hesitate. The ABS and traction control warning lights were illuminated. The contact stated that there was brake message displayed. During the failure the brake pedal had to be depres... Read more

Incident date: Jul 18, 2022

Car stalled, sputtered and died. At first, I thought I was out of gas. After several tries, the car started and went 3 miles to gas station. After getting gas, the car wouldn’t start several times and that same day the check engine light came on. We took it to Autozone to check the code and they s... Read more

Incident date: Apr 7, 2022

The contact owns a Baby Trend car seat, Model Number: CS661232H-SB-00137, Manufactured Date: 07/05/2021, installed in a 2018 Toyota Sienna. The contact stated that the buckle handle on the left was hard to operate. The contact also stated that the harness connection was defective. The manufacturer w... Read more

Incident date: Oct 2, 2021

The last week of September 2021 my husband notice a sound like water runing and a leak on the driver and passenger seats, we take the vehicle to the Dealer for an inspection on October 2nd. They said the AC hose was clogged for a spiderweb and the leak can create a mold. This mold can affect my fam... Read more

Incident date: Oct 2, 2021

Incident date: Aug 30, 2021

Driver side automatic sliding door won’t stay open , upon opening and reach all the way , it will quickly close. My child safety is a big concern.

Incident date: Jul 3, 2020

The front passenger side bumper snap(s) comes undone, by air flow, as vehicle travels down the road - this causes further tearing of the supporting plastic frame. Local Toyota dealership says this initially was caused by a driver of the vehicle hitting a concrete curb. Note: Bottom of the bumper is ... Read more

Incident date: Jun 27, 2021

The contact owned a 2018 Toyota Sienna. The contact stated while driving at 74 mph, a deer ran across the freeway, and as a result, the contact crashed into the deer. The air bags failed to deploy. A police report was filed. The contact sustained a sore shoulder but did not require medical treatment... Read more

Crash 1 injured

Incident date: Jun 1, 2021

When turning left in a busy intersection, our van was struck by another vehicle on the front passenger corner of the car. The strike occurred with my van going about 10 mph, the other car going about 45 mph. All of the airbags deployed. When the airbags deployed, the coverings on the lights came of... Read more

Crash

Incident date: Nov 1, 2019

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING 70 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER HANLEES DAVIS TOYOTA (4202 CHILES RD, DAVIS, CA 95616, (53... Read more

Incident date: Mar 17, 2021

APPEARS ALL THE TIME THE TIRE PRESSURE WARNING LIGHT .

Incident date: Jan 20, 2021

WE RECEIVED A SAFETY RECALL NOTICE FROM TOYOTA FOR A DEFECTIVE LOW-PRESSURE FUEL PUMP ON OUR 2018 TOYOTA SIENNA. BUT THE DEALERSHIP, FOWLER TOYOTA OF TULSA, WOULD NOT REPLACE THE RECALLED PART FREE OF CHARGE BECAUSE OF THE VEHICLE BEING CONVERTED BY A NON-AUTHORIZED MOBILITY CONVERSION COMPANY. SO... Read more

Incident date: Nov 15, 2020

I HAD TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL CIRCUIT AND WHEN I RICH 85 SPEED THE CAR CHECK AND MY FRIEND HAVE THE SAME CAR SAM MODEL HE HAD THE SAME ISSUE

Incident date: Nov 15, 2020

I HAD TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL CIRCUIT AND WHEN I RICH 85 SPEED THE CAR CHECK AND MY FRIEND HAVE THE SAME CAR SAM MODEL HE HAD THE SAME ISSUE

Incident date: Jan 27, 2021

MOBILITY WORKS SOLD ME A CAR,THAT HAD A RECALL,DESIGNED FOR SPECIAL NEEDS,THEY KNEW AVOUT IT PLUS THE RAMP WASNT WORKING PROPERLY,MADE ME PAY FOR AN EXPENSIVE WARRANTY THAT DOESNT COVER THE PROBLEM THAT ALREADY HAS,THEY ARE BLAMING ME FOR MISUSE I GOT IT 4 MONTHS AGO MY SON DOESNT WEIGHT MORE THAN 1... Read more

Incident date: Jan 27, 2021

Incident date: Oct 25, 2020

POWER DOOR CABLE BROKE,DOOR DOES NOT OPEN

Incident date: Oct 25, 2020

POWER DOOR CABLE BROKE,DOOR DOES NOT OPEN

Incident date: Oct 9, 2020

ORIGINAL TIRES AT 17K, MY 2018 SIENNA IS SHOWING EXCESSIVE WEAR ON THE OUTSIDE OF THE FRONT TIRES. ALIGNMENT CHECKED, IT IS FINE.

Incident date: Aug 9, 2020

LIGHT, MODERATE TO TOO MUCH VIBRATION ON THE FRONT BRAKE WHEN DRIVING DOWNHILL. I WAS DRIVING DOWNHILL AND I FELT MODERATE VIBRATION ON THE FRONT BRAKE. I WAS SO SCARED THAT I HAVE TO RELEASE THE BRAKE HOPING TO STOP THE VIBRATION. ON THE WAY BACK HOME, I HAVE TO DRIVE ANOTHER DOWNHILL AND THIS TIME... Read more

Incident date: Nov 1, 2019

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE AND EXITING THE DRIVEWAY, THE VEHICLE SURGED FORWARD WHILE IDLE, WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT THEN RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE)... Read more

Incident date: Jun 20, 2020

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE MASTER WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONT... Read more

Incident date: Jun 7, 2020

THERE IS A RECALL NOTICE ON MY VAN AND TOYOTA HAS NO SOLUTION FOR IT AS OF YET AND IT IS CAUSING ME TO BE UNABLE TO RENEW MY REGISTRATION ONLINE AND I WILL NOW HAVE TO PAY A LATE FEE. *TR

Incident date: May 7, 2020

UNINTENDED ACCELERATION WHILE REVERSING VEHICLE. VAN WENT FULL THROTTLE AND SPED UP IN REVERSE WHILE BACKING UP FROM MY DRIVE WAY AT HOME. *TR

Crash

Incident date: May 25, 2020

TL* THE CONTACT OWNS A 2018 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUF... Read more

Showing 50 of 84 complaints.

NHTSA Safety Ratings — 2018 TOYOTA SIENNA

2018 Toyota Sienna VAN FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash — Driver	5 / 5 ★★★★★
Frontal Crash — Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash — Driver	5 / 5 ★★★★★
Side Crash — Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	14.0%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins — 2018 TOYOTA SIENNA

403 manufacturer communications from 212 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	70
110000 ELECTRICAL SYSTEM	43
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	39
353000 EQUIPMENT:ELECTRICAL	30
162300 STRUCTURE:BODY:DOOR	22
118000 ELECTRICAL SYSTEM:SOFTWARE	20
160000 STRUCTURE	20
060000 ENGINE (PWS)	14

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

060000 ENGINE AND ENGINE COOLING

980000 UNKNOWN OR OTHER

TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used w

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

138500 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REFRIGERANT HOSES AND FITTINGS

TSB: The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. Follow the procedures outlined in this service bulletin to aid in locating, inspecting, and repair

346000 COMMUNICATION:MANUFACTURER TELEMATICS

TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. These resources, in conjunction with the Repair Manual, are for dealership personnel to assis

980000 UNKNOWN OR OTHER

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re

180000 VEHICLE SPEED CONTROL

140000 AIR BAGS

350000 EQUIPMENT

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

110000 ELECTRICAL SYSTEM

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for

280000 BACK OVER PREVENTION

TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, and 2017 ? 2020 model year Sienna vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise from the vacuum pump at idle.

070000 FUEL SYSTEM, GASOLINE

140000 AIR BAGS

DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Toyota?s agreement to provide a Customer Support Program for certain 2014-2020 model year (MY) v

030000 SERVICE BRAKES, HYDRAULIC

350000 EQUIPMENT

TSB: Some 2014 ? 2020 model year Toyota vehicles may exhibit a hard start and/or MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): ?DTC P0171 and/or P0174 (System Too Lean Bank 1/Bank 2) ?DTC P0087 Fuel

030000 SERVICE BRAKES, HYDRAULIC

070000 FUEL SYSTEM, GASOLINE

TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, 2017 ? 2020 model year Sienna, and 2016 ? 2023 model year Tacoma vehicles equipped with a 2GR-FKS engine may exhibit a knocking noise

060000 ENGINE AND ENGINE COOLING

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE December 08, 2022: This bulletin is now obsolete. Please see T-SB-0106-22.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System, require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used

140000 AIR BAGS

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Vehicles listed above equipped with a Denso Ten radio (Entune Audio Plus or Premium Audio) may exhibit a condition in which the radio screen continues to show a Bluetooth phone call in progress after the call has ended. This condition h

110000 ELECTRICAL SYSTEM

TT: Some 17-22MY Highlander and 17-20MY Sienna vehicles may experience a MIL ON condition with DTC(s) P042000, and/or P043000. This issue could involve deteriorated catalyst material from the bank 1 or bank 2 catalytic converter.

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

160000 STRUCTURE

TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and

160000 STRUCTURE

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

060000 ENGINE AND ENGINE COOLING

TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2022 model year Toyota vehicles equipped with an FKS engine

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

TT: Some 17-22MY Highlander, and 17-20MY Sienna vehicles with engine serial numbers that start with F or G may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Please take detailed

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: When customers have a concern about a discharged battery, no start, or general battery concern, the DCA-8000 is the only appropriate tool to use for diagnosis

060000 ENGINE AND ENGINE COOLING

TT: The purpose of this Tech Tip is to provide diagnostic tips to prevent misdiagnosis of the following DTC?s and prevent repeat repairs. One or more of the Heated Oxygen Sensors (O2) or Air Fuel ratio sensor (A/F) DTCs below could set due

060000 ENGINE (PWS)

TT: Some 2017-2022 Highlander, and 2017-2020 Sienna vehicles may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Please take detailed pictures of the oil pan leak condition before

220000 SEATS

114000 ELECTRICAL SYSTEM:WIRING

TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year El

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

200000 WHEELS

190000 TIRES

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TSB: Some 2018 ? 2020 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used w

160000 STRUCTURE

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may experience echoing on the line calling the vehicle when using Bluetooth Hands Free. This is caused by the phone Hands Free volume being too low. These settings may need to be reapplied any time the phone is paired to

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth? Audio function

353000 EQUIPMENT:ELECTRICAL

TSB: Some 2018 ? 2020 model year Sienna (XLE, Limited); 2019 model year Avalon, Avalon Hybrid, Corolla Hatchback, Highlander (Platinum only), Highlander Hybrid (Platinum only), RAV4, and RAV4 Hybrid; and 2020 model year Corolla, Corolla Hyb

270000 LANE DEPARTURE

TT: When used in conjunction with the Repair Manual, these Blind Spot Monitor, Forward Recognition Camera, and Front Millimeter Wave Radar tips leverage SSTs and readily available tools to support target placement in varying shop environmen

130000 VISIBILITY

353000 EQUIPMENT:ELECTRICAL

TT: NOTE: This document only applies to certain audio packages for the following vehicles. 2019 C-HR (Audio Plus & Premium Only) 2020 Prius (Audio Only) 2020 Prius Prime (Audio Plus Only) Head unit telematics services become inoperati

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX? Tip) is avai

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE July 09, 2021: This bulletin is now obsolete. Please see T-SB-0051-21.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE July 09, 2020: This bulletin is now obsolete. Please see T-SB-0053-21.

353000 EQUIPMENT:ELECTRICAL

TSB: Some 2018 ? 2019 model year Camry and Camry Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Abno

353000 EQUIPMENT:ELECTRICAL

TSB: Some 2019 model year RAV4 and RAV4 Hybrid and 2018 ? 2020 model year Sienna vehicles equipped with Audio Plus (version 1010) or Premium Audio (version 1010) or earlier may exhibit one or more of the following conditions: ?Toyota apps f

100000 POWER TRAIN

TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. In some cases, even an ?AWD System Message? with

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

TSB: Some 2017 ? 2018 model year Highlander and Sienna, 2018 model year Camry, and 2019 model year Avalon vehicles with and without the stop and start feature may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P07407E and/o

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

UPDATES TO THE 2014-2021 TOYOTA UNIVERSAL FLAT RATE MANUAL

356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: Some 2019 model year Avalon and Avalon Hybrid vehicles equipped with Entune? Audio Plus (version 1002) or Entune? Premium Audio (version 1002) or earlier may exhibit one or more of the following conditions: ?Incorrect GPS date and time

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

TSB: Some 2017 ? 2018 model year Highlander and Sienna vehicles may exhibit a whine noise while driving, a harsh shift, MIL ON, or reduced power. The following Diagnostic Trouble Codes (DTCs) may be present: P07457F, P07757F, P07957F, P2807

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

110000 ELECTRICAL SYSTEM

162300 STRUCTURE:BODY:DOOR

TSB: Some 2010 ? 2020 model year Sienna vehicles may exhibit a condition where the front door glass run on either the right-hand or left-hand side comes loose from the door channel during window operation. Follow the Repair Procedure in thi

132000 VISIBILITY:GLASS, SIDE/REAR

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: This Service Bulletin provides a procedure to properly perform the Techstream ?Control the Injection Mode? active test in some 2016 ? 2021 model year Toyota vehicles equipped with an FKS engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0012-21.

140000 AIR BAGS

Toyota Safety Recall and Service Campaign - Technician Certification Requirements

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

220000 SEATS

TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water an

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

110000 ELECTRICAL SYSTEM

TSB: Some 2017 ? 2018 model year Highlander and Sienna, 2018 model year Camry, and 2019 model year Avalon vehicles with and without the stop and start feature may exhibit a flex lock-up concern and MIL ON with Diagnostic Trouble Codes (DTCs

180000 VEHICLE SPEED CONTROL

050000 PARKING BRAKE

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

110000 ELECTRICAL SYSTEM

353640 EQUIPMENT:ELECTRICAL:AUX AUDIO JACK/PLUG

110000 ELECTRICAL SYSTEM

TSB: When completing a transaxle assembly replacement, Engine Control Module (ECM) (SAE term: Powertrain Control Module [PCM]) replacement, or ECM (PCM) reprogram, ensure the correct ECM (PCM) software is matched with the transaxle assemb

110000 ELECTRICAL SYSTEM

TSB: Some 2016 ? 2018 model year Prius and Tacoma, 2017 ? 2018 model year Prius Prime and Sienna, and 2018 model year Camry and Camry Hybrid vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P261093 (ECM/PCM Engin

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE December 11, 2020: This bulletin is now obsolete. Please see T-SB-0119-20.

030000 BRAKES (PWS)

TSB: Some 2011 ? 2020 model year Sienna vehicles may exhibit a vibration/pulsation from the front brakes that can be felt in the brake pedal while lightly applying the brake pedal. Follow the Repair Procedure in this bulletin to address thi

353630 EQUIPMENT:ELECTRICAL:INFOTAINMENT:BLUETOOTH/WIFI

118000 ELECTRICAL SYSTEM:SOFTWARE

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

TT: HVAC drain tube is found to be blocked/clogged.

280000 BACK OVER PREVENTION

062400 ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP

TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Toyota vehicles.

350000 EQUIPMENT

TSB: This Service Bulletin provides updated non-electric water pump leak inspection and diagnostic tips for some 2008 ? 2021 model year Toyota vehicles.

110000 ELECTRICAL SYSTEM

010000 STEERING

Showing 100 of 403 bulletins.

NHTSA Safety Investigations — TOYOTA SIENNA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA — Closed — Model Year: 2004

STEERING INTERMEDIATE SHAFT BINDING

ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA H... Read more

EA — Closed — Model Year: 2004

ACCELERATOR PEDAL INTERFERENCE

IN A JUNE 25, 2008, LETTER RESPONDING TO AN INFORMATION REQUEST FROM ODI, TOYOTA PROVIDED INFORMATION ABOUT AN ACCELERATOR PEDAL INTERFERENCE INCIDENT THAT OCCURRED DURING PRODUCTION DYNAMOMETER TESTING AT THE ASSEMBLY PLANT FOR AN EARLY PRODUCTION MY 2004 SIENNA MINIVAN.THE INCIDENT WAS CAUSED BY A... Read more

PE — Closed — Model Year: 2004

STEERING INTERMEDIATE SHAFT BINDING

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION, PE08-041, TO INVESTIGATE ALLEGATIONS OF STEERING BINDING OR INCREASED STEERING EFFORT CAUSED BY CORROSION OF STEERING INTERMEDIATE UNIVERSAL JOINTS IN MODEL YEAR (MY) 2004 TOYOTA SIENNA VEHICLES.TOYOTA'S RESPONSE TO ODI'S REQ... Read more

PE — Closed — Model Year: 2004

ACCELERATOR PEDAL INTERFERENCE

IN A JUNE 25, 2008, LETTER RESPONDING TO AN INFORMATION REQUEST FROM ODI, TOYOTA REPORTED AN APRIL 2003 UNWANTED ACCELERATION INCIDENT THAT OCCURRED DURING PRODUCTION DYNAMOMETER TESTING.ACCORDING TO THE LETTER THE INCIDENT WAS CAUSED BY A MISSING RETAINING CLIP THAT ALLOWED THE CENTER CONSOLE TRIM ... Read more

EA — Closed — Model Year: 2004

UNEXPECTED CLOSING OF POWER LIFTGATE

ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BA... Read more

PE — Closed — Model Year: 2004

UNEXPECTED LIFTGATE CLOSING

THE LIFTGATE GAS STRUTS FOR THE SUBJECT VEHICLES MAY HAVE DAMAGED GAS SEALS THAT ALLOW THE LIFTGATE TO DROP UNEXPECTEDLY.THE RATES FOR COMPLAINTS, ALLEGED INJURIES AND WARRANTY CLAIMS ARE HIGHER FOR VEHICLES WITH THE POWER LIFTGATE OPTION.THE POWER LIFTGATE MAY AUTOMATICALLY POWER-CLOSE AT THE COMPL... Read more

PE — Closed — Model Year: 2004

TIRE PRESSURE WARNING SYSTEM FAILURE

ODI OPENED PE06-010 BASED ON 12 REPORTS OF ALLEGED TIRE PRESSURE WARNING SYSTEM (TPWS) FAILURE ON THE SUBJECT VEHICLES.ALL REPORTS ALLEGED THAT THE TPWS WARNING LIGHT DID NOT ILLUMINATE ON THE DRIVER INFORMATION PANEL WHEN THE TIRE PRESSURE WAS LOW OR THE TIRE WAS FLAT.IN SOME INCIDENTS, THE CONSUME... R REPORTED THAT TPWS LIGHT DID NOT ILLUMINATE WHEN THE TIRE PRESSURE IN 1 TIRE WAS AT 15-20 PSI AND THE OTHER TIRES WERE AT OR NEAR THE RECOMMENDED TIRE PRESSURE.DURING PE06-010, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.AS OF JULY 25, 2006, ODI WAS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A CRASH, AN INJURY, OR A FATALITY IN THE SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE A TIRE WAS REPORTED TO HAVE CAUGHT ON FIRE DURING THE INCIDENT.IN BOTH INCIDENTS, FIRE DAMAGE WAS LIMITED TO THE REAR PASSENGER TIRE AND TIRE WELL AND/OR SMOKE DAMAGE TO ITEMS IN THE VEHICLE.ODI'S ANALYSIS SHOWED THE FOLLOWING:(1) THE SUBJECT VEHICLES USE AN INDIRECT TPWS SYSTEM WITH P225/60R17BRIDGESTONE B380 OR DUNLOP SP SPORT 4000 DSST RUN FLAT TIRES(RFTS). (2) THERE IS A LARGE VARIABILITY IN THE PRESSURE AND DRIVING TIME ATWHICH THE TPWS WILL TRIGGER THE TPWS WARNING LIGHT TOILLUMINATE. (3) THE TPWS MAY NOT MAKE AN ACCURATE JUDGMENT UNDER A VARIETY OFROAD OR DRIVING CONDITIONS, INCLUDING IF THE VEHICLE IS DRIVENOVER 62 MPH, THE OUTSIDE TEMPERATURE IS BELOW 32 DEGREESFAHRENHEIT, THE TREAD WEAR IS UNEVEN, THE LOADING IS OVERTHE LIMIT, OR THE PRESSURE OF 2 OR MORE TIRES DROPS AT THE SAMETIME. (SEE TOYOTA'S APRIL 10, 2006 INFORMATION REQUEST RESPONSEFOR MORE DETAILS.) (4) SOME CONSUMERS REPORTED THAT THEIR TIRE PRESSURE WAS BELOW 15PSI OR EVEN AS LOW AS 0 PSI BEFORE THEY REALIZED THAT THEY HAD ATIRE PRESSURE ISSUE AND AS A RESULT HAD TO REPLACE THE TIRE. NOTE: TOYOTA STATES THAT IF THE TIRE PRESSURE DROPS TO BELOW 15PSI, THE TIRE CAN NOT BE REPAIRED. (5) IN APRIL 2006, IN RESPONSE TO REPORTS OF PREMATURE OR UNEVEN TIREWEAR, TOYOTA ISSUED A CUSTOMER SUPPORT PROGRAM TO PROVIDESUPPLEMENTAL TIRE WARRANTY COVERAGE FOR 2004-EARLY 2006 MYSIENNA VEHICLES WITH RFTS. (6) FIELD DATA AND NHTSA TESTING SHOWED THAT THE TPWS ON THE 2004-2005 MY TOYOTA SIENNA 2WD VEHICLES, WHICH USE THE SAME TPWS AS THE SUBJECT VEHICLES, BUT HAVE STANDARD TIRES, PERFORMED BETTERTHAN TPWS ON THE SUBJECT VEHICLES.DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: (1) ONLY A VERY SMALL PERCENTAGE OF TPWS AND TIRE RELATED COMPLAINTS AND WARRANTY CLAIMS CITED THAT THE TPWS DID NOT ILLUMINATE ON THE SUBJECT VEHICLE DURING THE INCIDENT.IN THE REMAINING TIRE RELATED INCIDENTS, IT WAS NOT POSSIBLE TO DETERMINE IF THE TPWS CONTRIBUTED TO THE TIRE RELATED FAILURE. (2) ODI IS NOT AWARE OF ANY INCIDENTS THAT WERE REPORTED THATRESULTED IN THE DRIVER LOSING VEHICLE CONTROL. (3) THE FIELD DATA DID NOT ESTABLISH A RELATIONSHIP BETWEEN POORTPWS PERFORMANCE AND TIRE INCIDENTS WITH SAFETY CONSEQUENCESACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.Read more

EA — Closed — Model Year: 2004

SEATBELT MALFUNCTION

THE SHOULDER PORTION OF THE MIDDLE-ROW SEATBELT WEBBING FEEDS THROUGH AN OPENING IN THE SEATBELT BEZEL LOCATED AT THE TOP OF THE SEAT.THE BEZEL ALSO CONTAINS A CLIP THAT COVERS A NARROW SLOT IN THE BEZEL.THE CLIP MAY BECOME DISLODGED FROM USE AND ALLOW THE SEAT BELT TO BECOME STUCK IN THE NARROW SLO... Read more

PE — Closed — Model Year: 2004

SEATBELT MALFUNCTION

ODI RECEIVED TEN CONSUMER COMPLAINTS ALLEGING THAT THE MIDDLE-ROW PASSENGER SEATBELT WEBBING FREQUENTLY JAMS IN THE INTEGRATED SEATBELT GUIDE HOUSING SLOT.DURING NORMAL BODY MOVEMENT OF THE OCCUPANT, THE WEBBING JAMS IN THE SLOT DUE TO A DISLODGED COVER PLATE, THUS CAUSING EXCESS SLACK IN THE SEATBE... Read more

PE — Closed — Model Year: 2002

ENGINE COMPARTMENT FIRE

PE — Closed — Model Year: 1998

STEERING WHEEL TO RETURN TO CENTER

There is no summary currently available

TOYOTA SIENNA — All Years Overview

Complete safety history for the TOYOTA SIENNA across all model years (1998–2020).

153 Total Recalls

10,816 Total Complaints

11 Investigations

546 Reported Crashes

118 Reported Fires

11 Reported Deaths

TOYOTA SIENNA — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2020	2	46	View
2019	7	58	View
2018 (current)	7	84
2017	10	197	View
2016	5	98	View
2015	6	290	View
2014	6	207	View
2013	6	226	View
2012	9	331	View
2011	14	812	View
2010	8	227	View
2009	10	270	View
2008	9	570	View
2007	10	448	View
2006	11	1,284	View
2005	12	1,418	View
2004	10	2,588	View
2003	1	124	View
2002	1	225	View
2001	2	238	View
2000	1	459	View
1999	3	250	View
1998	3	352	View
1997	0	2	View
1996	0	3	View

Other TOYOTA Models

Model	Recalls	Complaints
TUNDRA	787	9,074	View
HIGHLANDER	677	6,756	View
RAV4	669	11,842	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
GRAND HIGHLANDER	388	332	View
PRIUS	365	15,456	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2018 TOYOTA SIENNA

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings — 2018 TOYOTA SIENNA

Safety Technology

Technical Service Bulletins — 2018 TOYOTA SIENNA

Most Affected Components

NHTSA Safety Investigations — TOYOTA SIENNA

TOYOTA SIENNA — All Years Overview

TOYOTA SIENNA — Year by Year

Other TOYOTA Models