2002 SUBARU OUTBACK
5 recalls, 172 complaints - 71 TSBs
13E065000 Nov 29, 2013
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Defect Description
Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermark... Read more
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.
04V128000 Mar 16, 2004
VEHICLE SPEED CONTROL:CABLES
Defect Description
ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AN... Read more
Consequence
IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
03V153000 Apr 22, 2003
SUSPENSION:REAR
Defect Description
THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND... Read more
Consequence
IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
02V282000 Oct 30, 2002
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHI... Read more
Consequence
THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WI... Read more
02V079000 Mar 12, 2002
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Defect Description
ON CERTAIN PASSENGER VEHICLES, THE BRAKE MASTER CYLINDERS MAY NOT FUNCTION PROPERLY IN AMBIENT TEMPERATURES BELOW FREEZING 32 DEGREES FAHRENHEIT AND LOWER).
Consequence
AT THESE TEMPERATURES, THE BRAKES MAY NOT RELEASE AFTER BEING APPLIED, EVEN WHEN THE DRIVER'S FOOT IS NO LONGER ON THE BRAKE PEDAL. THIS CAN OCCUR WITHOUR PRIOR WARNING, POSSIBLY RESULTING IN A CRASH.
Remedy
DEALERS WILL REPLACE THE MASTER CYLINDERS. OWNER NOTIFICATION BEGAN MARCH 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Complaint Statistics
172 total complaints
14 crashes 15 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| FUEL SYSTEM, GASOLINE | 20 |
| SERVICE BRAKES, HYDRAULIC | 12 |
| ENGINE AND ENGINE COOLING | 9 |
| FUEL/PROPULSION SYSTEM | 8 |
| VEHICLE SPEED CONTROL | 8 |
| POWER TRAIN:MANUAL TRANSMISSION | 7 |
| POWER TRAIN:CLUTCH ASSEMBLY | 6 |
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 5 |
| ENGINE | 5 |
| VEHICLE SPEED CONTROL:ACCELERATOR PEDAL | 4 |
UNKNOWN OR OTHER
Oct 3, 2018
Incident date: Jun 12, 2015
THE AIR CONDITIONER BEGINS TO BLOW HOT MOIST AIR AFTER SEVERAL MINUTES OF WORKING PROPERLY. MULTIPLE MECHANICS INCLUDING A SPECIALTY SHOP CAN'T DIAGNOSE, AND THE ONLY OPTION IS TO REPLACE THE ENTIRE A/C COMPRESSOR BECAUSE THE CLUTCH ISN'T SOLD SEPARATELY. I'VE READ MANY ACCOUNTS OF THE SAME "INTERMI... Read more
ENGINE
Apr 9, 2018
Incident date: Apr 2, 2018
I AM THE ORIGINAL OWNER OF THIS VEHICLE AND I HAVE HAD FOUR SEPARATE INCIDENTS THAT MY HEAD GASKET HAS HAD TO BE REPLACED. THIS IS A COSTLY REPAIR AND GIVEN MY CAR HAS 190,000 MILES ON IT I BELIEVE FOUR ISSUES DEALING WITH THIS SAME SITUATION NEEDS TO BE PROPERLY ADDRESSED. NOT ONLY DOES THIS ISSU... Read more
FUEL/PROPULSION SYSTEM
Dec 4, 2017
Incident date: Dec 4, 2017
WHEN THE TEMPERATURE OUTSIDE GETS BELOW 35 DEGREES, MY CAR SMELLS VERY STRONGLY OF GAS INSIDE. I HAVE TO ROLL THE WINDOWS DOWN FOR VENTILATION. WHEN THE TEMPERATURE WARMS UP, THE SMELL GOES AWAY. IT IS WORSE WHEN I FIRST STARTED MY CAR IN THE MORNING. MECHANICS HAVEN'T BEEN ABLE TO FIGURE OUT THE PR... Read more
STRUCTURE:BODY
Jul 26, 2016
Incident date: Jul 7, 2016
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS BEING SERVICED, THE INDEPENDENT MECHANIC OBSERVED THAT THE ENTIRE FRAME WAS SEVERELY CORRODED AND HOLES WERE FORMING. THE VEHICLE NEEDED A NEW CROSS MEMBER. THE VEHICLE WAS NOT REPAIRED. ALSO, WHEN THE VEHICLE WAS SHIFTED INTO THE PAR... Read more
POWER TRAIN
Jul 26, 2016
Incident date: Jul 7, 2016
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS BEING SERVICED, THE INDEPENDENT MECHANIC OBSERVED THAT THE ENTIRE FRAME WAS SEVERELY CORRODED AND HOLES WERE FORMING. THE VEHICLE NEEDED A NEW CROSS MEMBER. THE VEHICLE WAS NOT REPAIRED. ALSO, WHEN THE VEHICLE WAS SHIFTED INTO THE PAR... Read more
SUSPENSION
Jul 26, 2016
Incident date: Jul 7, 2016
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS BEING SERVICED, THE INDEPENDENT MECHANIC OBSERVED THAT THE ENTIRE FRAME WAS SEVERELY CORRODED AND HOLES WERE FORMING. THE VEHICLE NEEDED A NEW CROSS MEMBER. THE VEHICLE WAS NOT REPAIRED. ALSO, WHEN THE VEHICLE WAS SHIFTED INTO THE PAR... Read more
FUEL/PROPULSION SYSTEM
Jan 11, 2016
Incident date: Jan 6, 2016
TERRIBLE GAS SMELL. FUEL IS LEAKING BECAUSE IT IS COLD OUTSIDE.
FUEL/PROPULSION SYSTEM
Jan 1, 2016
Incident date: Jan 1, 2016
WHEN TEMP. OUTSIDE GO BELOW 32 DEGREES, THE INSIDE OF MY CAR FILLS WITH RAW GAS SMELL, THIS HAPPENS EVERY WINTER. I LIVE IN WI. WHEN IT IS ABOVE FREEZING IT IS FINE AND ALL SUMMER IT IS FINE. I AM SO AFFRAID TO HAVE MY GRAND KIDS IN THE CAR. NOT SURE IF THE FUMES WILL EXPLODE.WHEN I AM DRIVING I DO ... Read more
ENGINE
Oct 21, 2015
Incident date: Oct 6, 2015
I BOUGHT CAR OCT 6; FIRST INSPECTION APPOINTMENT AT MY USUAL GARAGE MON OCT 12- FAILED DUE TO RUSTY SUSPECT BRAKE CONNECTION. SELLER HAD ME TAKE TO HIS DEALER- MASTRIA SUBARU IN RAYNHAM. THEY PUT A PAINT/COATING OVER RUSTY AREA. I WAS PRETTY SKEPTICAL BUT BROUGHT CAR TO MY GARAGE IN VT MONDAY OCT 1... Read more
SERVICE BRAKES
Oct 21, 2015
Incident date: Oct 6, 2015
I BOUGHT CAR OCT 6; FIRST INSPECTION APPOINTMENT AT MY USUAL GARAGE MON OCT 12- FAILED DUE TO RUSTY SUSPECT BRAKE CONNECTION. SELLER HAD ME TAKE TO HIS DEALER- MASTRIA SUBARU IN RAYNHAM. THEY PUT A PAINT/COATING OVER RUSTY AREA. I WAS PRETTY SKEPTICAL BUT BROUGHT CAR TO MY GARAGE IN VT MONDAY OCT 1... Read more
UNKNOWN OR OTHER
Oct 21, 2015
Incident date: Oct 6, 2015
I BOUGHT CAR OCT 6; FIRST INSPECTION APPOINTMENT AT MY USUAL GARAGE MON OCT 12- FAILED DUE TO RUSTY SUSPECT BRAKE CONNECTION. SELLER HAD ME TAKE TO HIS DEALER- MASTRIA SUBARU IN RAYNHAM. THEY PUT A PAINT/COATING OVER RUSTY AREA. I WAS PRETTY SKEPTICAL BUT BROUGHT CAR TO MY GARAGE IN VT MONDAY OCT 1... Read more
STRUCTURE:BODY
Oct 5, 2015
Incident date: Oct 2, 2015
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS BEING SERVICED FOR ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE REAR SUSPENSION SUBFRAME HAD FRACTURED DUE TO SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAI... Read more
SUSPENSION:REAR
Oct 5, 2015
Incident date: Oct 2, 2015
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS BEING SERVICED FOR ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE REAR SUSPENSION SUBFRAME HAD FRACTURED DUE TO SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAI... Read more
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Apr 15, 2015
Incident date: Apr 15, 2015
WHEN GETTING THE CAR INSPECTED WE FOUND OUT THE FRAME OF THE CAR WAS RUSTED SO BADLY IT WAS CRACKED. IT WAS IN SUCH A KEY SPOT THAT IT WASN'T FIXABLE AND THE CAR COULD HAVE EASILY LOST A WHEEL ON THE ROAD WITH LITTLE TO NO WARNING (A SMALL BUMP COULD HAVE BEEN ENOUGH TO TRIGGER AN ACCIDENT). THE CAR... Read more
ENGINE
Jan 31, 2015
Incident date: Aug 1, 2005
DRIVERS SIDE HEAD GASKET LEAKED. ONLY THAT SIDE WAS REPLACED. ON 1/14 BOTH HEAD GASKETS STARTED LEAKING AT 59000 MILES. WITH SUBARUS HELP THE DEALER CHARGED $ 855.00. THE PROBLEM IS SUBARU HAS A DESIGN DEFECT IN THIS ENGINE SO THOSE OF US WHO OWN THESE CARS ARE GOING TO HAVE TO PAY FOR GASKET REPLA... Read more
FUEL/PROPULSION SYSTEM
Jan 13, 2015
Incident date: Jan 13, 2015
IN 10 DEGREE WEATHER, MY 2002 SUBARU OUTBACK WAGON DEVELOPED A FUEL LEAK WHILE BEING DRIVEN BY MY 17-YEAR-OLD CHILD. THIS IS MY SECOND SUBARU WAGON AND THE SECOND TO HAVE COLD WEATHER FUEL LEAKS. I TIGHTENED THE CLAMP ON THE OFFENDING FUEL LINE AND I HOPE THAT IS AN ADEQUATE FIX. BUT IT IS SIMPLY U... Read more
ENGINE
Jan 13, 2015
Incident date: Jan 13, 2015
IN 10 DEGREE WEATHER, MY 2002 SUBARU OUTBACK WAGON DEVELOPED A FUEL LEAK WHILE BEING DRIVEN BY MY 17-YEAR-OLD CHILD. THIS IS MY SECOND SUBARU WAGON AND THE SECOND TO HAVE COLD WEATHER FUEL LEAKS. I TIGHTENED THE CLAMP ON THE OFFENDING FUEL LINE AND I HOPE THAT IS AN ADEQUATE FIX. BUT IT IS SIMPLY U... Read more
FUEL/PROPULSION SYSTEM
Nov 18, 2014
Incident date: Dec 19, 2013
RUBBER FUEL LINKAGES CONTRACT IN LOW (BELOW 30F) TEMPERATURES, ALLOWING FUEL TO LEAK INTO THE ENGINE COMPARTMENT. THE LEAKING FUEL CREATES A VERY STRONG, AT TIMES INTOLERABLE, FUEL VAPOR SMELL IN THE CABIN. SOME LEAKS DRIP ONTO THE EXHAUST MANIFOLD AND ENGINE BLOCK SO ENGINE FIRE IS A POSSIBILITY. ... Read more
1 injured
AIR BAGS
Oct 22, 2014
Incident date: Oct 22, 2014
ALTHOUGH MY CAR IS NOT LISTED ON THE AIRBAG RECALL, I AM CONCERNED MY CAR MIGHT HAVE THE AIRBAGS FROM TAKATA. THE YEAR THE TAKATA AIRBAG RECALL STARTED IS 2000. MY CAR IS A 2002 SUBARU OUTBACK. THE 2003 SUBARU OUTBACK IS ON THE TAKATA AIRBAG RECALL LIST. HOW CAN I MAKE SURE MY CAR'S AIRBAGS WERE... Read more
SERVICE BRAKES
Feb 18, 2014
Incident date: Feb 17, 2013
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. THE CONTACT STATED THAT THE BRAKES WOULD NOT RELEASE AFTER BEING APPLIED, EVEN WHEN THE CONTACT'S FOOT WAS NO LONGER ON THE BRAKE PEDAL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE CURRENT MILEAGE WAS 135,... Read more
SERVICE BRAKES
Feb 17, 2014
Incident date: Feb 1, 2012
DATES ARE APPROXIMATE, PROBLEM IS ONGOING. UPON INITIAL START-UP, IN COOL/COLD WEATHER THE BRAKE PEDAL WILL BE VERY HARD AND BRAKES ARE VERY WEAK REQUIRING TREMENDOUS FOOT PRESSURE WITH STILL REDUCED BRAKING EFFECTIVENESS. AFTER A PERIOD OF TIME AND MULTIPLE STOPS BRAKE ASSIST SEEMS TO INCREASE AN... Read more
VEHICLE SPEED CONTROL
Feb 12, 2014
Incident date: Feb 11, 2014
UPPER FRONT FUEL LINE AND CONNECTION TO THROTTLE BODY? IS LEAKING RAW GAS AND FUEL IS POOLING ON TOP OF ENGINE JUST OUTWARD OF UPPER EXHAUST MANIFOLD AREA. *TR
FUEL SYSTEM, GASOLINE
Feb 12, 2014
Incident date: Feb 11, 2014
UPPER FRONT FUEL LINE AND CONNECTION TO THROTTLE BODY? IS LEAKING RAW GAS AND FUEL IS POOLING ON TOP OF ENGINE JUST OUTWARD OF UPPER EXHAUST MANIFOLD AREA. *TR
FUEL SYSTEM, GASOLINE
Jan 26, 2014
Incident date: Jan 8, 2010
OVER LAST FEW WINTERS, WHEN TEMPERATURES DROP TO FREEZING THERE HAS BEEN A BAD FUEL SMELL IN CABIN. ESPECIALLY WITH HEATER BLOWING, THOUGH IT STILL SMELLS INSIDE AND OUTSIDE THE CAR EVEN WITH THE HEAT OFF. ONCE THE WEATHER WARMS UP THERE IS NO NOTICEABLE SMELL. I HAVE TRIED TIGHTENING 5 CLAMPS AS... Read more
FUEL/PROPULSION SYSTEM
Jan 24, 2014
Incident date: Jan 17, 2014
SINCE THE RECENT TEMPERATURE DROP WHERE WE LIVE (MARYLAND, DC METRO REGION), WE'VE NOTICED A STRONG GASOLINE SMELL INSIDE THE CAR'S CABIN. THE SMELL IS STRONG ENOUGH THAT WE ARE UNCOMFORTABLE DRIVING LONG DISTANCES, FOR OUR OWN HEALTH AND THAT OF OUR CHILDREN. THE SMELL ONLY APPEARS WHEN THE CAR ... Read more
FUEL SYSTEM, GASOLINE
Jan 24, 2014
Incident date: Jan 17, 2014
SINCE THE RECENT TEMPERATURE DROP WHERE WE LIVE (MARYLAND, DC METRO REGION), WE'VE NOTICED A STRONG GASOLINE SMELL INSIDE THE CAR'S CABIN. THE SMELL IS STRONG ENOUGH THAT WE ARE UNCOMFORTABLE DRIVING LONG DISTANCES, FOR OUR OWN HEALTH AND THAT OF OUR CHILDREN. THE SMELL ONLY APPEARS WHEN THE CAR ... Read more
FUEL SYSTEM, GASOLINE
Jan 23, 2014
Incident date: Jan 3, 2014
THE SMELL OF RAW GAS PERMEATES THE PASSENGER CABIN WHEN THE CAR IS STARTED IN TEMPERATURES UNDER 10 DEGREES FAHRENHEIT. *TR
FUEL/PROPULSION SYSTEM
Dec 9, 2013
Incident date: Dec 6, 2013
MY WIFE DROVE HER CAR, A 2002 SUBARU OUTBACK, ABOUT 5 MILES HOME FROM WORK, AND TOLD ME IN THE EVENING HER CAR REEKED OF GASOLINE WHEN SHE ARRIVED AT HOME. WHEN I CHECKED HER CAR THE GAS ODOR HAD DISSIPATED, BUT WHEN I STARTED IT AND BACKED IT OUT OF THE GARAGE THE GAS ODOR WAS VERY STRONG. I MOVE... Read more
FUEL/PROPULSION SYSTEM
Jan 24, 2013
Incident date: Jan 1, 2005
THE CAR ALWAYS HAS A STRONG GAS SMELL INSIDE DURING WINTER. THE SMELL IS SO BAD THAT I GET HEADACHES. *TR
ENGINE
Jan 24, 2013
Incident date: Jan 1, 2005
THE CAR ALWAYS HAS A STRONG GAS SMELL INSIDE DURING WINTER. THE SMELL IS SO BAD THAT I GET HEADACHES. *TR
STRUCTURE:BODY
Aug 2, 2012
Incident date: Aug 2, 2012
WE WERE DRIVING ON HIGHWAY I-95 GOING BETWEEN 55 AND 60 MILES AN HOUR AND THE HOOD LATCH FAILED. THE HOOD CAME UP BLOCKING OUR VISION AND BROKE THE WINDSHIELD. EXTENSIVE DAMAGE TO CAR. WE WERE TRAVELING IN THE FAR RIGHT LANE AND WERE LUCKY THAT WE COULD PULL THE CAR OFF THE HIGHWAY INTO THE BREAK... Read more
Crash
LATCHES/LOCKS/LINKAGES
Aug 2, 2012
Incident date: Aug 2, 2012
WE WERE DRIVING ON HIGHWAY I-95 GOING BETWEEN 55 AND 60 MILES AN HOUR AND THE HOOD LATCH FAILED. THE HOOD CAME UP BLOCKING OUR VISION AND BROKE THE WINDSHIELD. EXTENSIVE DAMAGE TO CAR. WE WERE TRAVELING IN THE FAR RIGHT LANE AND WERE LUCKY THAT WE COULD PULL THE CAR OFF THE HIGHWAY INTO THE BREAK... Read more
Crash
STRUCTURE:FRAME AND MEMBERS
Apr 18, 2012
Incident date: Apr 17, 2012
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK SPORT. WHILE HAVING THE VEHICLE EXAMINED, THE CONTACT WAS INFORMED THAT THE SUB FRAME HAD BEGUN TO RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT SERVICED. THE CURRENT AND FAILURE MILEAGES WERE 152,000. UPDATED 05/09/12 *BF
SUSPENSION:REAR
Apr 18, 2012
Incident date: Apr 17, 2012
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK SPORT. WHILE HAVING THE VEHICLE EXAMINED, THE CONTACT WAS INFORMED THAT THE SUB FRAME HAD BEGUN TO RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT SERVICED. THE CURRENT AND FAILURE MILEAGES WERE 152,000. UPDATED 05/09/12 *BF
FUEL SYSTEM, GASOLINE
Mar 6, 2012
Incident date: Dec 17, 2011
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. THE CONTACT STATED THAT WHENEVER THE HEAT WAS ACTIVATED, THE CONTACT WOULD NOTICE A GASOLINE ODOR COMING THROUGH THE VENTS. THE VEHICLE WAS TAKEN TO THE DEALER ON FOUR OCCASIONS WHERE THE HEAD GASKETS WERE REPLACED EACH TIME. HOWEVER, ONE YEAR AFTER THE RE... Read more
SUSPENSION
Feb 16, 2012
Incident date: Jan 30, 2012
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT CORROSION WAS ON THE REAR SUB FRAME. THE MECHANIC ADVISED THE CONTACT OF A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER:03V153000(SUSPENSION:REA... Read more
ENGINE AND ENGINE COOLING
Jan 15, 2012
Incident date: Jan 13, 2012
WHEN WEATHER TURNS COLD, THE SMELL OF RAW GAS COMES INTO THE CAR, AS WELL AS IN THE GARAGE AFTER PARKING. SO FAR THE DEALER HAS JUST TIGHTENED A CLAMP, BUT WHAT HAPPENS IF I'M ON A HI-WAY AND THAT HAPPENS? I CAN'T DRIVE THE CAR WITH A GAS LEAK IN THE ENGINE AND TO FAR AWAY FROM A FIRE STATION SO... Read more
FUEL SYSTEM, GASOLINE
Jan 15, 2012
Incident date: Jan 13, 2012
WHEN WEATHER TURNS COLD, THE SMELL OF RAW GAS COMES INTO THE CAR, AS WELL AS IN THE GARAGE AFTER PARKING. SO FAR THE DEALER HAS JUST TIGHTENED A CLAMP, BUT WHAT HAPPENS IF I'M ON A HI-WAY AND THAT HAPPENS? I CAN'T DRIVE THE CAR WITH A GAS LEAK IN THE ENGINE AND TO FAR AWAY FROM A FIRE STATION SO... Read more
ENGINE AND ENGINE COOLING
Jan 12, 2012
Incident date: Jan 10, 2012
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK WAGON. THE CONTACT STATED DURING ROUTINE MAINTENANCE WITH A PRIVATE MECHANIC, THE MECHANIC ADVISED THAT RADIATOR FLUID WAS LEAKING INTO THE EXHAUST. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE... Read more
FUEL SYSTEM, GASOLINE
Jan 7, 2012
Incident date: Jan 2, 2012
IN COLD WEATHER, MY 2002 SUBARU OUTBACK CABIN GETS FILLED WITH VERY STRONG RAW FUEL SMELL AS THE CAR WARMS UP WITH THE HEATER ON. IT HAS GOTTEN SO BAD, THAT MY DAUGHTER NEARLY THROWS UP EVERY MORNING ON OUR WAY TO SCHOOL IN COLD WEATHER. THIS IS AN ISSUE THAT MY LOCAL DEALER EXPLAINED AWAY HAS A TYP... Read more
ENGINE AND ENGINE COOLING
Dec 30, 2011
Incident date: Dec 29, 2011
I RECENTLY TOOK MY OUTBACK IN TO A LOCAL SHOP FOR AN OIL CHANGE, AND THEY NOTIFIED ME THAT THE HEAD GASKET HAS STARTED TO LEAK. TOOK IT TO THE DEALERSHIP FOR A SECOND OPINION, AND THEY SAID THE SAME THING. CALLED FOUR DIFFERENT PLACES, AND GOT ESTIMATES FOR ANYWHERE FROM $1500-$2100 (AFTER SPENDIN... Read more
FUEL SYSTEM, GASOLINE
Nov 22, 2011
Incident date: Nov 13, 2010
PROMINENT GAS SMELL INSIDE CABIN WHEN TEMPERATURE IS BELOW 32 DEGREES F. IT IS A KNOWN SAFETY ISSUE ON SUBARU'S BUT NOTHING IS BEING DONE BY SUBARU TO RECTIFY THIS POOR ENGINEERING SAFETY ISSUE ON THEIR BEHALF. I HAVE TALKED TO SUBARU OF AMERICA VIA EMAIL AND ON PHONE AND THEY SAY THAT THERE IS NO... Read more
WHEELS
May 31, 2011
Incident date: Jan 5, 2011
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. THE CONTACT WAS DRIVING 55 MPH WHEN THE LUG NUTS DETACHED FROM THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 02V235000 (WHEELS) BUT WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE FAILURE WAS REPAIRED... Read more
SEAT BELTS
Apr 25, 2011
Incident date: Apr 25, 2011
WAS DRIVING MY RECENTLY BOUGHT 2002 SUBARU OUTBACK, WHEN MY CHILD WHO WAS SITTING IN THE MIDDLE SEAT IN THE BACK STARTED SCREAMING THAT THE SEATBELT WAS HURTING HER AND SHE COULDN'T BREATHE. I MADE AN EMERGENCY STOP AT A FULL SERVICE GAS STATION, JUMPED OUT AND TRIED GETTING THE SEATBELT UNDONE BUT ... Read more
FUEL SYSTEM, GASOLINE
Jan 28, 2011
Incident date: Jan 28, 2011
THERE IS A DOCUMENTED PROBLEM WITH OLDER MODEL SUBARU OUTBACKS (EARLY 2000S) LEAKING GAS INTO THE ENGINE COMPARTMENT IN COLD WEATHER. DEALERS AND REPAIR SERVICES CANNOT FULLY RESOLVE THE ISSUE BECAUSE IT APPEARS TO BE A DESIGN FLAW WITH THE FUEL LINES AND CLAMPS. INTERNET FORUMS PROVIDE COUNTLESS CA... Read more
EXTERIOR LIGHTING
Jan 10, 2011
Incident date: Jan 2, 2011
FUSE FOR TAIL LIGHTS BLEW DUE TO TAIL LIGHT SOCKET PARTIALLY MELTING (AREA WHERE THE TWO CONTACTS FOR BRAKE/TAIL LIGHT ARE LOCATED-LOCATION WAS THE DRIVER'S SIDE INSIDE BRAKE/TAIL LIGHT). WAS UNAWARE THAT THE TAIL LIGHTS WERE NOT WORKING FOR ABOUT 1 WEEK. *TR
ELECTRICAL SYSTEM
Jan 10, 2011
Incident date: Jan 2, 2011
FUSE FOR TAIL LIGHTS BLEW DUE TO TAIL LIGHT SOCKET PARTIALLY MELTING (AREA WHERE THE TWO CONTACTS FOR BRAKE/TAIL LIGHT ARE LOCATED-LOCATION WAS THE DRIVER'S SIDE INSIDE BRAKE/TAIL LIGHT). WAS UNAWARE THAT THE TAIL LIGHTS WERE NOT WORKING FOR ABOUT 1 WEEK. *TR
FUEL SYSTEM, GASOLINE
Nov 2, 2010
Incident date: Nov 4, 2004
2002 SUBARU OUTBACK SMELLS OF GAS EVERY TIME IT GETS COLD. A SHOP THAT WORKS ON JUST SUBARUS KNOWS THE PROBLEM WELL AND TRIED A FEW THINGS TO FIX IT. AFTER $175, IT DID NOT WORK. LAST YEAR, I HAD TO DRIVE WITH MY WINDOWS DOWN ON COLD NIGHTS THE SMELL WAS SO STRONG. ONE NIGHT IT WAS -20 DEGREES! ... Read more
FUEL SYSTEM, GASOLINE
Oct 26, 2010
Incident date: Jan 30, 2008
TL*THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE THE VEHICLE WAS IDLE SHE STATED THAT THERE WAS A STRONG FUEL SMELL IN THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO CLEANED THE EXHAUST SYSTEM. THE CONTACT STATED THAT THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO ANOTHER LOCAL... Read more
VEHICLE SPEED CONTROL
May 12, 2010
Incident date: May 9, 2010
TL* THE CONTACT OWNS A 2002 SUBARU OUTBACK. WHILE ATTEMPTING TO SHIFT INTO PARK, THE VEHICLE ABNORMALLY ACCELERATED WITHOUT WARNING, CAUSING THE CONTACT TO CRASH INTO A NEARBY FENCE. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR FURTHER TESTING TO DETERMINE THE CAUSE OF T... Read more
Showing 50 of 172 complaints.
Technical Service Bulletins, 2002 SUBARU OUTBACK
71 manufacturer communications from 39 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 20 |
| 110000 ELECTRICAL SYSTEM | 7 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 4 |
| 100000 POWER TRAIN | 4 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 3 |
| 103000 POWER TRAIN:AUTOMATIC TRANSMISSION | 3 |
| 060000 ENGINE AND ENGINE COOLING | 3 |
| 105400 POWER TRAIN:DRIVELINE:CENTER SUPPORT BEARING | 2 |
01-168-09R
Aug 1, 2023
350000 EQUIPMENT
The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
01-168-09R
Aug 1, 2023
170000 LATCHES/LOCKS/LINKAGES
The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
01-168-09R
Aug 1, 2023
110000 ELECTRICAL SYSTEM
The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
12-249-23R
Jul 11, 2023
350000 EQUIPMENT
This bulletin announces the recommended cleaning procedures to followed when encountering vehicles with long time exposure to pollen on painted surfaces on vehicles imported from Japan. This bulletin does not apply to SIA built vehicles.
01-167-08R
Aug 23, 2022
350000 EQUIPMENT
This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models.
15-302-22
Aug 23, 2022
350000 EQUIPMENT
This bulletin contains illustrations of exchange components and their manufacturer as well as a description of the proper exchange procedure.
15-302-22
Aug 23, 2022
110000 ELECTRICAL SYSTEM
This bulletin contains illustrations of exchange components and their manufacturer as well as a description of the proper exchange procedure.
15-192-22R
Mar 18, 2022
110000 ELECTRICAL SYSTEM
This bulletin has been developed to outline the steps for gathering basic essential information during diagnosis and repair of the Infotainment concerns. (Applicable to all models with Harman or Denso CP1 Infotainment).
01-167-08R
Jun 17, 2021
350000 EQUIPMENT
This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models
01-167-08R
Jun 17, 2021
110000 ELECTRICAL SYSTEM
This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models
09-51-08R
Jun 7, 2021
350000 EQUIPMENT
This bulletin is to advise of SOAa??s revised catalytic converter recycling program shipping procedure.
09-51-08R
Jun 7, 2021
060000 ENGINE AND ENGINE COOLING
This bulletin is to advise of SOAa??s revised catalytic converter recycling program shipping procedure.
14-22-16R
Feb 1, 2021
350000 EQUIPMENT
To help reduce confusion and increase technician efficiency, Subaru of America, Inc. (SOA) has developed the following cross reference list to help locate the appropriate Special Service Tool.
03-82-18R
Jan 12, 2021
101000 POWER TRAIN:CLUTCH ASSEMBLY
This bulletin announces a design change to the clutch release bearing.
03-82-18R
Jan 12, 2021
060000 ENGINE AND ENGINE COOLING
This bulletin announces a design change to the clutch release bearing.
03-82-18R
Jan 12, 2021
350000 EQUIPMENT
This bulletin announces a design change to the clutch release bearing.
03-82-18R
Jan 12, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin announces a design change to the clutch release bearing.
01-168-09R
Jan 4, 2021
350000 EQUIPMENT
The purpose of this bulletin is to provide replacement key and immobilizer information.
01-168-09R
Jan 4, 2021
110000 ELECTRICAL SYSTEM
The purpose of this bulletin is to provide replacement key and immobilizer information.
03-82-18R
Aug 26, 2020
060000 ENGINE AND ENGINE COOLING
This service information bulletin announces a design change to the clutch release bearing used on the models listed.
14-22-16R
Aug 4, 2020
350000 EQUIPMENT
Special Service Tools Cross Reference List.
01-181-20
Apr 30, 2020
350000 EQUIPMENT
All Models (Vehicle Cleaning- COVID-19Best Practices)
06-68-19R
Jul 11, 2019
030000 SERVICE BRAKES, HYDRAULIC
This Service Information bulletin announces instruction for application of additional lubrication between the brake caliper support and pad clips. This will prevent the pad from dragging due to corrosion buildup which may result in uneven o
Subaru Tech Tips
May 21, 2019
350000 EQUIPMENT
Subaru Service and Technical Support Line Newletter.
14-22-16R
May 6, 2019
350000 EQUIPMENT
To help reduce confusion and increase technician efficiency, Subaru of America, Inc. (SOA) has developed the following cross reference list to help locate the appropriate Special Service Tool.
04-13-09R
Nov 13, 2018
016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
This post was revised in error. It has been corrected back and removed from the posting list. The message was corrected on 04-13-14R posting dated 11/14/2018.
04-13-09R
Nov 13, 2018
010000 STEERING
This post was revised in error. It has been corrected back and removed from the posting list. The message was corrected on 04-13-14R posting dated 11/14/2018.
03-82-18
Oct 26, 2018
100000 POWER TRAIN
This Service Information bulletin announces a design change to the clutch release bearing used on the models as listed above. During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases
03-82-18
Oct 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This Service Information bulletin announces a design change to the clutch release bearing used on the models as listed above. During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases
03-82-18
Oct 26, 2018
350000 EQUIPMENT
This Service Information bulletin announces a design change to the clutch release bearing used on the models as listed above. During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases
03-82-18
Oct 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This Service Information bulletin announces a design change to the clutch release bearing used on the models as listed above. During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases
03-82-18
Oct 26, 2018
100000 POWER TRAIN
This Service Information bulletin announces a design change to the clutch release bearing used on the models as listed above. During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases
01-168-09R
Nov 16, 2016
350000 EQUIPMENT
The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
01-168-09R
Sep 30, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
01-168-09R
Apr 12, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
Revised TSB. The Subaru Lock Information Site (SLIS) is located at http://lockinfo.subaru.com, and provides information on how to obtain immobilizer codes and key cut codes for Subaru vehicles from the 2000MY to present. This bulletin iden
01-168-09R
Apr 12, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Revised TSB. The Subaru Lock Information Site (SLIS) is located at http://lockinfo.subaru.com, and provides information on how to obtain immobilizer codes and key cut codes for Subaru vehicles from the 2000MY to present. This bulletin iden
01-168-09R
Apr 12, 2016
350000 EQUIPMENT
Revised TSB. The Subaru Lock Information Site (SLIS) is located at http://lockinfo.subaru.com, and provides information on how to obtain immobilizer codes and key cut codes for Subaru vehicles from the 2000MY to present. This bulletin iden
04-13-09R
Sep 18, 2015
010000 STEERING
IF YOU ENCOUNTER A VEHICLE THAT HAS A GROANING TYPE NOISE COMING FROM THE POWER STEERING PUMP WHEN THE WHEEL IS TURNED TO THE FULL RIGHT OR LEFT POSITION WHEN THE VEHICLE IS PARKED, IT MAY BE CAUSED BY THE RELIEF VALVE VIBRATING WITHIN THE
04-13-09R
Jul 6, 2015
351130 EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:TANK VALVE/GAUGE
IF YOU ENCOUNTER A VEHICLE THAT HAS A GROANING TYPE NOISE COMING FROM THE POWER STEERING PUMP WHEN THE WHEEL IS TURNED TO THE FULL RIGHT OR LEFT POSITION WHEN THE VEHICLE IS PARKED, IT MAY BE CAUSED BY THE RELIEF VALVE VIBRATING WITHIN THE
04-13-09R
Jun 17, 2015
350000 EQUIPMENT
If you encounter a vehicle that has a groaning type noise coming from the power steering pump when the wheel is turned to the full right or left position when the vehicle is parked, it may be caused by the relief valve vibrating within the
04-13-09R
Jun 17, 2015
015100 STEERING:HYDRAULIC POWER ASSIST:PUMP
If you encounter a vehicle that has a groaning type noise coming from the power steering pump when the wheel is turned to the full right or left position when the vehicle is parked, it may be caused by the relief valve vibrating within the
0116809R
Jul 17, 2014
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
Replacement Key and Immobilizer Info
037012R-1
Jan 15, 2014
095400 FUEL SYSTEM, OTHER:KINETIC:HOUSING/CASE
Repair Procedure for High-Pitched Sound from Extension Housing Area Using Latest Generation Production Parts
03-70-12R
Jan 15, 2014
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
REPAIR PROCEDURE FOR HIGH-PITCHED SOUND FROM EXTENSION HOUSING AREA USING LATEST GENERATION PRODUCTION PARTS - THIS BULLETIN PROVIDES PRODUCTION CHANGE, REPAIR PROCEDURE AND PARTS INFORMATION TO ADDRESS A CUSTOMER CONCERN OF A HIGH-PITCHED
03-70-12R
May 22, 2013
350000 EQUIPMENT
This Bulletin provides production change, repair procedure and parts information to address a customer concern of a high-pitched sound coming from the transmission extension housing area. In cold temperatures, thermal contraction causes shr
03-70-12R
May 22, 2013
100000 POWER TRAIN
This Bulletin provides production change, repair procedure and parts information to address a customer concern of a high-pitched sound coming from the transmission extension housing area. In cold temperatures, thermal contraction causes shr
0116809R
Apr 25, 2013
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
Replacement Key and Immobilizer info
037012R
Jan 3, 2013
060000 ENGINE (PWS)
Repair Procedure for High-Pitched Sound
03-70-12R
Jan 3, 2013
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
THIS BULLETIN PROVIDES PRODUCTION CHANGE, REPAIR PROCEDURE AND PARTS INFORMATION TO ADDRESS A CUSTOMER CONCERN OF A HIGH-PITCHED SOUND COMING FROM THE TRANSMISSION EXTENSION HOUSING AREA. IN COLD TEMPERATURES, THERMAL CONTRACTION CAUSES SHR
03-70-12
Dec 13, 2012
350000 EQUIPMENT
REPAIR PROCEDURE FOR HIGH-PITCHED SOUND FROM EXTENSION HOUSING AREA USING LATEST GENERATION PRODUCTION PARTS
037012
Dec 13, 2012
110000 ELECTRICAL SYSTEM
Repair Procedure for High-Pitched Sound from Extension Housing Area Using Latest Generation Production Parts
03-68-12R
Dec 11, 2012
105400 POWER TRAIN:DRIVELINE:CENTER SUPPORT BEARING
THIS BULLETIN REVIEWS A CHANGE TO THE PART NUMBERS USED FOR THE TRANSFER DRIVEN GEAR BEARINGS. THESE REVISED BEARINGS ARE TO BE USED TO ENHANCE DURABILITY.
036812R
Dec 11, 2012
105400 POWER TRAIN:DRIVELINE:CENTER SUPPORT BEARING
5MT Transfer Driven Gear Bearings
SB-05-50-10R
Feb 3, 2011
190000 TIRES
SUBARU: THERE IS A STEERING WHEEL VIBRATION AT HIGHWAY SPEEDS DUE TO AN IMPORPER WHEEL BALANCE. *RM
07
Jul 1, 2007
121000 EXTERIOR LIGHTING:HEADLIGHTS
HEADLIGHT BULB SOCKET REPAIRS. *KB
118006
Nov 8, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
THROTTLE POSITION SENSOR. VEHICLES EQUIPED WITH H-6 3.0L ENGINES. *KB
129406
Oct 3, 2006
135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
LOOSE DOOR MIRROR SCREWS. *KB
029605
Sep 9, 2005
061000 ENGINE AND ENGINE COOLING:ENGINE
2.5L REMANUFACTURED SOHC SHORT BLOCK RELEASE. *TT
063103
Dec 8, 2004
036100 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
REPLACEMENT OF THE ELECTRONIC CONTROL UNIT (ECU) FOR ANTI-LOCK BRAKE SYSTEM (ABS) REPAIR. *TT UPDATE. *TT
031004
Mar 10, 2004
183000 VEHICLE SPEED CONTROL:CABLES
IMMEDIATE STOP SALE ORDER FOR POSSIBLE CRUISE CONTROL CABLE MISLOCATION THAT COULD PREVENT THE THROTTLE FROM CLOSING. *TT
01
Mar 1, 2004
185000 VEHICLE SPEED CONTROL:CRUISE CONTROL
CRUISE CONTROL CABLE RETAINING CLIP. *TT
99
Feb 1, 2004
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
ENGINE COOLING SYSTEM CONDITIONER.*MR
041104
Jan 15, 2004
015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
POWER STEERING HOSE - NEW STYLE. *TT
127903
Apr 15, 2003
162300 STRUCTURE:BODY:DOOR
LOWER FRONT DOOR WEATHER STRIP DETACHED OR HANGING LOOSE. *TT
94
Dec 1, 2002
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
IMPROPERLY MANUFACTURED 4EAT TRANSMISSION PARKING PAWL ROD. *TT
090102
Sep 1, 2002
100000 POWER TRAIN
PARTS SUPERSESSION FOR FIRST DRIVEN GEAR. SUBARU NEWSLETTER. *TT
1510501
Jan 4, 2002
350000 EQUIPMENT
SUBJECT REGARDING AUTO DIMMING ELECTROCHROMIC COMPASS MIRROR TROUBLE SHOOTING GUIDE. *SLC
1510401
Nov 1, 2001
162000 STRUCTURE:BODY
INFORMATION REGARDING ROOF RACK/CROSSBAR WIND NOISE. *YH
090101
Sep 1, 2001
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
INFORMATION REGARDING CHANGE TO 2002MY LEGACY/OUTBACK A/C OPERATION. *ET
186901
Jul 1, 2001
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SUBJECT REGARDING SERVICE MANUAL CORRECTIONS. *JB
010701
Jul 1, 2001
110000 ELECTRICAL SYSTEM
SUBJECT REGARDING KEYLESS ENTRY. *JB
SUBARU OUTBACK - All Years Overview
Complete safety history for the SUBARU OUTBACK across all model years (1995, 2023).
199
Total Recalls
12,297
Total Complaints
0
Investigations
635
Reported Crashes
144
Reported Fires
9
Reported Deaths
SUBARU OUTBACK - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 0 | 11 | View |
| 2025 | 0 | 108 | View |
| 2024 | 0 | 131 | View |
| 2023 | 2 | 122 | View |
| 2022 | 4 | 543 | View |
| 2021 | 4 | 408 | View |
| 2020 | 6 | 1,128 | View |
| 2019 | 3 | 1,284 | View |
| 2018 | 3 | 986 | View |
| 2017 | 4 | 1,106 | View |
| 2016 | 4 | 770 | View |
| 2015 | 5 | 642 | View |
| 2014 | 10 | 276 | View |
| 2013 | 12 | 406 | View |
| 2012 | 16 | 367 | View |
| 2011 | 16 | 855 | View |
| 2010 | 18 | 466 | View |
| 2009 | 13 | 142 | View |
| 2008 | 8 | 281 | View |
| 2007 | 8 | 182 | View |
| 2006 | 7 | 404 | View |
| 2005 | 9 | 354 | View |
| 2004 | 11 | 108 | View |
| 2003 | 15 | 116 | View |
| 2002 (current) | 5 | 172 | |
| 2001 | 4 | 207 | View |
| 2000 | 2 | 247 | View |
| 1999 | 1 | 150 | View |
| 1998 | 2 | 165 | View |
| 1997 | 4 | 94 | View |
| 1996 | 2 | 57 | View |
| 1995 | 1 | 3 | View |