2001 KENWORTH W900
9 recalls, 1 complaints - 13 TSBs
03V234000 Jul 1, 2003
UNKNOWN OR OTHER
Defect Description
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH VERTICAL TAIL PIPES, THE FRAME ACCESS GRABHANDLE IS MOUNTED TOO HIGH.
Consequence
THIS CONDITION COULD CAUSE A PERSON TO SLIP AND/OR FALL AND COULD LEAD TO PERSONAL INJURY.
Remedy
DEALERS WILL INSPECT THE GRABHANDLE LOCATION AND IF DETERMINED TO BE MOUNTED TOO HIGH, THE HANDLE WILL BE RELOCATED TO THE PROPER HEIGHT. OWNER NOTIFICATION BEGAN JULY 29, 2003. OWNERS SHOULD CONTACT KENWORTH AT 1-425-828-5440.
03V168000 May 5, 2003
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
Consequence
IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.
Remedy
DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. PETERBILT'S OWNER NOTIFICATION BEGAN JUNE 20, 2003. KENWORTH'S OWNER NOTIFICATION BEGAN JUNE 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE RE... Read more
03V125000 Apr 1, 2003
SUSPENSION:FRONT:HUB
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Consequence
SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
Remedy
DEALERS WILL REPLACE ALL FRONT AXLE HUBS. NOTIFICATION BEGAN JULY 16, 2003. THE MANUFACTURER HAS ADVISED US THAT PARTS WILL NOT BE AVAILABLE UNTIL SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITH A REASON... Read more
02V061001 Feb 27, 2002
SUSPENSION:REAR
Defect Description
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH REPLACEMENT DANA SPICER TANDEM DRIVE AXLE MODELS DS463 AND DS521, INSTALLED ON VEHICLES FROM MAY 1, 2001 THROUGH FEBRUARY 1, 2002, AN UNDERSIZED ATTACHMENT WELD MAY FRACTURE WITHOUT WARNING.
Consequence
THE LOSS OF THIS ATTACHMENT TO THE VEHICLE CHASSIS CAN ADVERSELY AFFECT VEHICLE HANDLING OR DRIVER CONTROL.
Remedy
DANA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE DEALERS WILL REMOVE THE SUSPECT BRACKET, INSPECT THE AXLE HOUSING, AND REWELD THE BRACKET TO THE AXLE HOUSING. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FR... Read more
01V335000 Oct 25, 2001
POWER TRAIN:DRIVELINE:UNIVERSAL JOINT
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE DRIVELINE U-JOINT FASTENERS AT THE OUTPUT YOKE OF THE TRANSMISSION WERE IMPROPERLY TIGHTENED.
Consequence
UNDER-TIGHTENED FASTENERS CAN LEAD TO THE DRIVELINE BECOMING DETACHED FROM THE VEHICLE RESULTING IN PROPERTY DAMAGE OR PERSONAL INJURY.
Remedy
DEALERS WILL TIGHTEN THE DRIVELINE FASTENERS TO THE PROPER SPECIFICATION. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-8... Read more
01V305000 Sep 26, 2001
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Defect Description
VEHICLE DESCRIPTION: CERTAIN HEAVY DUTY TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS." THE MODE DOOR IN AN HVAC SYSTEM CAN BECOME INOPERABLE. THE MODE DOOR CAM AND ACTUATOR COULD BIND, CAUSING THE CAM RETAINING TABS TO SHEAR OFF.
Consequence
THIS FAILURE MAY INHIBIT THE ABILITY TO DIRECT AIR BLOWING FROM THE HVAC SYSTEM TO THE WINDSHIELD, POTENTIALLY REDUCING THE DRIVER'S VISIBILITY.
Remedy
DEALERS WILL INSPECT THE MODE DOOR OPERATION AND REPLACE THE HVAC CAB MODE HOUSING ASSEMBLY IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHO... Read more
01V142000 Apr 24, 2001
EQUIPMENT:OTHER:LABELS
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR FG941 STEER AXLES. THE GROSS AXLE WEIGHT RATING (GAWR) WAS DETERMINED INCORRECTLY AND OVER-STATED ON THE VEHICLE CERTIFICATION LABEL. WITH THE INCORRECT GAWR LISTED, THESE LABELS DO NOT MEET THE CERTIFICATION REQUIREMENTS OF PART 567, "... Read more
Consequence
THESE VEHICLES WOULD NOT BE IN COMPLIANCE WITH FEDERAL REGULATIONS.
Remedy
VEHICLES WILL BE REMEDIED EITHER BY ASSIGNING THE PROPER WEIGHT RATING OR, IF POSSIBLE, BY CHANGING THE NECESSARY COMPONENTS TO MEET THE CURRENTLY ASSIGNED WEIGHT RATING. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE ... Read more
01V051000 Feb 20, 2001
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Defect Description
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 54" REAR AXLE SPACING CONFIGURATION OF THE AIRGLIDE 200 SUSPENSION WITH THE SERVICE APPLICATION IDENTIFIED AS LOGGER, DUMP TRUCK, OR TANKER. THE REAR SUSPENSION IS REGULARLY SUBJECTED TO EXTREME ARTICULATION, RESULTING IN FLEXING OF THE JOINT.
Consequence
FAILURE OF THE LOWER SWAY ARM ATTACHING BOLTS COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy
DEALERS WILL REPLACE THE LOWER SWAY ARM BRACKETS. OWNER NOTIFICATION BEGAN MARCH 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000.
01V021000 Feb 5, 2001
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AN OPTIONAL FIREWALL-MOUNTED CIRCUIT BREAKER. THE MAIN CAB POWER AND BATTERY POWER LEADS WERE ATTACHED INCORRECTLY. THIS CONDITION CAN RESULT IN THE MAIN CAB POWER BEING UNPROTECTED.
Consequence
IF A WIRING SHORT OCCURRED ANYWHERE ALONG THE CAB POWER CIRCUIT, THE AVAILABLE BATTERY POWER COULD ARC AND CAUSE SUBSEQUENT DAMAGE TO THE VEHICLE OR A FIRE.
Remedy
DEALERS WILL INSPECT AND CORRECT THE PROBLEM, AS NEEDED. OWNER NOTIFICATION BEGAN FEBRUARY 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000.
Complaint Statistics
1 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | 1 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Jan 30, 2002
Incident date: Jan 29, 2002
CONSUMER STATED THE FUEL TANK BRACKET IS NOT STRONG ENOUGH TO KEEP TANK FROM TWISTING, THE STRAPS APPARENTLY ARE TOO BIG AND LOOSEN FROM WEAR, CAUSING FUEL TANK TO TWIST AND LEAK TO FUEL, DEALER AND MANUFACTURER WERE NOTIFIED.*AK *YH
Technical Service Bulletins, 2001 KENWORTH W900
13 manufacturer communications from 9 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 2 |
| 350000 EQUIPMENT | 2 |
| 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL | 1 |
| 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
| 061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER | 1 |
| 023000 SUSPENSION:MULTIPLE AXLE | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
| 110000 ELECTRICAL SYSTEM | 1 |
02-160
Feb 10, 2021
130000 VISIBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
136000 VISIBILITY:WINDSHIELD WIPER/WASHER
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
350000 EQUIPMENT
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
32-015
Jun 8, 2020
110000 ELECTRICAL SYSTEM
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplet
32-016
Mar 17, 2020
350000 EQUIPMENT
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
01-075
Nov 6, 2019
060000 ENGINE AND ENGINE COOLING
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
TIB-13-040
Feb 27, 2015
023000 SUSPENSION:MULTIPLE AXLE
KENWORTH: SOME TRUCKS FAILED TO MEET COMPANY STANDARDS FOR AIR VOLUME LIFT AXLE AND THE COMPANY WILL INCREASE AIR VOLUME FOR WORTHWHILE IMPROVEMENT TO EXCEED GOVERNMENT FMVSS 121. MODEL T800, W900. *PE SEE DOCUMENT SEARCH BUTT
TIB-E-055
Jul 9, 2012
061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
KENWORTH: OIL COLLECTION AT CAC INTAKE PIPE IS CAUSED BY AN IMBALANCE IN TURBOCHARGER PRESSURES. MODELS T660, T800, T700, AND W900. *PE
TIB-E011
Dec 15, 2010
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
PACCAR: ENGINEERING STANDARDS HAVE CHANGED AND THERE ARE NOW ENGINES WITH HEAT TREATED BOLTS. *RM
TIB-E-009
Dec 2, 2010
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PACCAR: A SOFTWARE UPDATE IS CAUSING THE CHECK ENGINE LIGHT TO COME ON. *RM
TIB-44-17
Oct 23, 2008
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
KENWORTH TRUCKS: REDUCED ENGINE POWER FROM FUEL STARVATION. ANY MODEL KENWORTH EQUIPPED WITH THE 2007 EMISSIONS COMPLIANT ISX ENGINE AND OPTIONAL DAVCO 382 FUEL FILTER, BUILT PRIOR TO 8/11/08, *PE
TIB-44-17
Oct 23, 2008
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
KENWORTH TRUCKS: REDUCED ENGINE POWER FROM FUEL STARVATION. ANY MODEL KENWORTH EQUIPPED WITH THE 2007 EMISSIONS COMPLIANT ISX ENGINE AND OPTIONAL DAVCO 382 FUEL FILTER, BUILT PRIOR TO 8/11/08, *PE
KENWORTH W900 - All Years Overview
Complete safety history for the KENWORTH W900 across all model years (1975, 2025).
258
Total Recalls
42
Total Complaints
0
Investigations
1
Reported Crashes
4
Reported Fires
0
Reported Deaths
KENWORTH W900 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 2 | 0 | View |
| 2024 | 2 | 1 | View |
| 2023 | 4 | 0 | View |
| 2022 | 4 | 3 | View |
| 2021 | 3 | 1 | View |
| 2020 | 6 | 0 | View |
| 2019 | 7 | 0 | View |
| 2018 | 9 | 0 | View |
| 2017 | 6 | 0 | View |
| 2016 | 11 | 0 | View |
| 2015 | 9 | 0 | View |
| 2014 | 9 | 0 | View |
| 2013 | 7 | 0 | View |
| 2012 | 8 | 0 | View |
| 2011 | 10 | 0 | View |
| 2010 | 9 | 0 | View |
| 2009 | 17 | 0 | View |
| 2008 | 20 | 1 | View |
| 2007 | 17 | 2 | View |
| 2006 | 11 | 1 | View |
| 2005 | 9 | 2 | View |
| 2004 | 12 | 2 | View |
| 2003 | 6 | 1 | View |
| 2002 | 4 | 1 | View |
| 2001 (current) | 9 | 1 | |
| 2000 | 9 | 12 | View |
| 1999 | 10 | 6 | View |
| 1998 | 6 | 4 | View |
| 1997 | 5 | 1 | View |
| 1996 | 6 | 0 | View |
| 1995 | 2 | 1 | View |
| 1994 | 1 | 1 | View |
| 1991 | 1 | 0 | View |
| 1983 | 1 | 1 | View |
| 1982 | 1 | 0 | View |
| 1978 | 2 | 0 | View |
| 1977 | 1 | 0 | View |
| 1976 | 1 | 0 | View |
| 1975 | 1 | 0 | View |