1998 KENWORTH W900
6 recalls, 4 complaints - 13 TSBs
03V125000 Apr 1, 2003
SUSPENSION:FRONT:HUB
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Consequence
SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
Remedy
DEALERS WILL REPLACE ALL FRONT AXLE HUBS. NOTIFICATION BEGAN JULY 16, 2003. THE MANUFACTURER HAS ADVISED US THAT PARTS WILL NOT BE AVAILABLE UNTIL SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITH A REASON... Read more
02V061001 Feb 27, 2002
SUSPENSION:REAR
Defect Description
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH REPLACEMENT DANA SPICER TANDEM DRIVE AXLE MODELS DS463 AND DS521, INSTALLED ON VEHICLES FROM MAY 1, 2001 THROUGH FEBRUARY 1, 2002, AN UNDERSIZED ATTACHMENT WELD MAY FRACTURE WITHOUT WARNING.
Consequence
THE LOSS OF THIS ATTACHMENT TO THE VEHICLE CHASSIS CAN ADVERSELY AFFECT VEHICLE HANDLING OR DRIVER CONTROL.
Remedy
DANA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE DEALERS WILL REMOVE THE SUSPECT BRACKET, INSPECT THE AXLE HOUSING, AND REWELD THE BRACKET TO THE AXLE HOUSING. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FR... Read more
01V142000 Apr 24, 2001
EQUIPMENT:OTHER:LABELS
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR FG941 STEER AXLES. THE GROSS AXLE WEIGHT RATING (GAWR) WAS DETERMINED INCORRECTLY AND OVER-STATED ON THE VEHICLE CERTIFICATION LABEL. WITH THE INCORRECT GAWR LISTED, THESE LABELS DO NOT MEET THE CERTIFICATION REQUIREMENTS OF PART 567, "... Read more
Consequence
THESE VEHICLES WOULD NOT BE IN COMPLIANCE WITH FEDERAL REGULATIONS.
Remedy
VEHICLES WILL BE REMEDIED EITHER BY ASSIGNING THE PROPER WEIGHT RATING OR, IF POSSIBLE, BY CHANGING THE NECESSARY COMPONENTS TO MEET THE CURRENTLY ASSIGNED WEIGHT RATING. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE ... Read more
01V051000 Feb 20, 2001
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Defect Description
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 54" REAR AXLE SPACING CONFIGURATION OF THE AIRGLIDE 200 SUSPENSION WITH THE SERVICE APPLICATION IDENTIFIED AS LOGGER, DUMP TRUCK, OR TANKER. THE REAR SUSPENSION IS REGULARLY SUBJECTED TO EXTREME ARTICULATION, RESULTING IN FLEXING OF THE JOINT.
Consequence
FAILURE OF THE LOWER SWAY ARM ATTACHING BOLTS COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy
DEALERS WILL REPLACE THE LOWER SWAY ARM BRACKETS. OWNER NOTIFICATION BEGAN MARCH 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000.
99V181001 Jul 9, 1999
ELECTRICAL SYSTEM:IGNITION:MODULE
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR ENGINES AND EATON AUTOSHIFT TRANSMISSIONS. THE ENGINES CAN STALL BECAUSE OF SOFTWARE PROBLEMS.
Consequence
INCREASED STEERING EFFORT CAN OCCUR.
Remedy
DEALERS WILL UPDATE THESE ENGINES WITH SOFTWARE CHANGES. CATERPILLAR IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY OF THIS RECALL.
98V129000 Jun 11, 1998
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Defect Description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR 3406E ENGINES. THE ROUTING OF THE ELECTRICAL AND FUEL LINES CAN CAUSE CHAFFING OF THE WIRING HARNESS ON THE FUEL LINE.
Consequence
THIS CHAFFING CAN CAUSE FUEL LEAKAGE AND A POTENTIAL FOR A FIRE IN THE ENGINE COMPARTMENT.
Remedy
DEALERS WILL INSPECT, ADJUST, AND REPAIR, IF NECESSARY, THE FUEL LINE AND ELECTRICAL HARNESS.
Complaint Statistics
4 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| STRUCTURE:FRAME AND MEMBERS | 2 |
| ELECTRICAL SYSTEM:WIRING | 1 |
| FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS | 1 |
STRUCTURE:FRAME AND MEMBERS
Feb 16, 2012
Incident date: Jan 5, 2012
REFERENCE VOQ#10259426. I FILED A COMPLAINT IN FEBRUARY 2009 FOR A FRAME RAIL THAT CRACKED ON MY 1998 KENWORTH W900. I SPENT $11,470 TO HAVE THE RAIL REPLACED AT AN AUTHORIZED KENWORTH DEALER. I PURCHASED THIS TRUCK NEW, WITH NO EXTRAS OR ADD-ONS SINCE OWNING THE TRUCK. ALL SERVICING HAS BEEN DONE ... Read more
STRUCTURE:FRAME AND MEMBERS
Feb 20, 2009
Incident date: Feb 6, 2009
TL*THE CONTACT OWNS A 1998 KENWORTH W900. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE HOOD WAS KNOCKING ON THE MAIN CAB AND WAS NOT ALIGNED PROPERLY. THE VEHICLE WAS DRIVEN TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE CHASSIS WAS CRACKED AND DEFECTIVE. THE MANUFACTU... Read more
ELECTRICAL SYSTEM:WIRING
Sep 8, 1998
Incident date: Sep 7, 1998
WHILE DRIVING THE FUEL LINE CHAFED A HOLE, CAUSING FUEL LEAKAGE. A RECALL WAS ORDERED ON MAKE MODEL AND YEAR. THIS PARTICULAR TRUCK WAS NOT INCLUDED UNDER RECALL 98V-129000. THE DEALER HAS BEEN NOTIFIED. *AK
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Sep 8, 1998
Incident date: Sep 7, 1998
WHILE DRIVING THE FUEL LINE CHAFED A HOLE, CAUSING FUEL LEAKAGE. A RECALL WAS ORDERED ON MAKE MODEL AND YEAR. THIS PARTICULAR TRUCK WAS NOT INCLUDED UNDER RECALL 98V-129000. THE DEALER HAS BEEN NOTIFIED. *AK
Technical Service Bulletins, 1998 KENWORTH W900
13 manufacturer communications from 9 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 2 |
| 350000 EQUIPMENT | 2 |
| 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL | 1 |
| 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
| 061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER | 1 |
| 023000 SUSPENSION:MULTIPLE AXLE | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
| 110000 ELECTRICAL SYSTEM | 1 |
02-160
Feb 10, 2021
130000 VISIBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
136000 VISIBILITY:WINDSHIELD WIPER/WASHER
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
350000 EQUIPMENT
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
32-015
Jun 8, 2020
110000 ELECTRICAL SYSTEM
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplet
32-016
Mar 17, 2020
350000 EQUIPMENT
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
01-075
Nov 6, 2019
060000 ENGINE AND ENGINE COOLING
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
TIB-13-040
Feb 27, 2015
023000 SUSPENSION:MULTIPLE AXLE
KENWORTH: SOME TRUCKS FAILED TO MEET COMPANY STANDARDS FOR AIR VOLUME LIFT AXLE AND THE COMPANY WILL INCREASE AIR VOLUME FOR WORTHWHILE IMPROVEMENT TO EXCEED GOVERNMENT FMVSS 121. MODEL T800, W900. *PE SEE DOCUMENT SEARCH BUTT
TIB-E-055
Jul 9, 2012
061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
KENWORTH: OIL COLLECTION AT CAC INTAKE PIPE IS CAUSED BY AN IMBALANCE IN TURBOCHARGER PRESSURES. MODELS T660, T800, T700, AND W900. *PE
TIB-E011
Dec 15, 2010
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
PACCAR: ENGINEERING STANDARDS HAVE CHANGED AND THERE ARE NOW ENGINES WITH HEAT TREATED BOLTS. *RM
TIB-E-009
Dec 2, 2010
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PACCAR: A SOFTWARE UPDATE IS CAUSING THE CHECK ENGINE LIGHT TO COME ON. *RM
TIB-44-17
Oct 23, 2008
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
KENWORTH TRUCKS: REDUCED ENGINE POWER FROM FUEL STARVATION. ANY MODEL KENWORTH EQUIPPED WITH THE 2007 EMISSIONS COMPLIANT ISX ENGINE AND OPTIONAL DAVCO 382 FUEL FILTER, BUILT PRIOR TO 8/11/08, *PE
TIB-44-17
Oct 23, 2008
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
KENWORTH TRUCKS: REDUCED ENGINE POWER FROM FUEL STARVATION. ANY MODEL KENWORTH EQUIPPED WITH THE 2007 EMISSIONS COMPLIANT ISX ENGINE AND OPTIONAL DAVCO 382 FUEL FILTER, BUILT PRIOR TO 8/11/08, *PE
KENWORTH W900 - All Years Overview
Complete safety history for the KENWORTH W900 across all model years (1975, 2025).
258
Total Recalls
42
Total Complaints
0
Investigations
1
Reported Crashes
4
Reported Fires
0
Reported Deaths
KENWORTH W900 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 2 | 0 | View |
| 2024 | 2 | 1 | View |
| 2023 | 4 | 0 | View |
| 2022 | 4 | 3 | View |
| 2021 | 3 | 1 | View |
| 2020 | 6 | 0 | View |
| 2019 | 7 | 0 | View |
| 2018 | 9 | 0 | View |
| 2017 | 6 | 0 | View |
| 2016 | 11 | 0 | View |
| 2015 | 9 | 0 | View |
| 2014 | 9 | 0 | View |
| 2013 | 7 | 0 | View |
| 2012 | 8 | 0 | View |
| 2011 | 10 | 0 | View |
| 2010 | 9 | 0 | View |
| 2009 | 17 | 0 | View |
| 2008 | 20 | 1 | View |
| 2007 | 17 | 2 | View |
| 2006 | 11 | 1 | View |
| 2005 | 9 | 2 | View |
| 2004 | 12 | 2 | View |
| 2003 | 6 | 1 | View |
| 2002 | 4 | 1 | View |
| 2001 | 9 | 1 | View |
| 2000 | 9 | 12 | View |
| 1999 | 10 | 6 | View |
| 1998 (current) | 6 | 4 | |
| 1997 | 5 | 1 | View |
| 1996 | 6 | 0 | View |
| 1995 | 2 | 1 | View |
| 1994 | 1 | 1 | View |
| 1991 | 1 | 0 | View |
| 1983 | 1 | 1 | View |
| 1982 | 1 | 0 | View |
| 1978 | 2 | 0 | View |
| 1977 | 1 | 0 | View |
| 1976 | 1 | 0 | View |
| 1975 | 1 | 0 | View |