2015 HYUNDAI VELOSTER

2 recalls, 189 complaints - 196 TSBs - 5/5 safety rating

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock B... Read more

Consequence

An engine compartment fire while parked or driving can increase the risk of injury.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyun... Read more

1,649,478 vehicles affected

Manufacturer: Hyundai Motor America

ENGINE

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.

Consequence

A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Remedy

Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. ... Read more

128,948 vehicles affected

Manufacturer: Hyundai Motor America

Complaint Statistics

189 total complaints 4 crashes 8 fires 10 injuries

Top Reported Components

Component	Complaints
ENGINE	54
POWER TRAIN	26
ELECTRICAL SYSTEM	25
UNKNOWN OR OTHER	23
FUEL/PROPULSION SYSTEM	7
STEERING	7
STRUCTURE:BODY	6
VEHICLE SPEED CONTROL	6
SERVICE BRAKES	6
VISIBILITY:SUN/MOON ROOF ASSEMBLY	4

Incident date: Dec 10, 2024

My car is a 2019 not 2020 and white not gray. The gas gauge doesn’t read pressure and drops by 1/4 up or down. I don’t have all the features which were supposed to be on the car. The rear door doesn’t close. I have ice inside my front windshield in the winter. I took the car back immediately. ... Read more

Incident date: Dec 10, 2024

When driving on the highway vehicle suddwnly brakes on its own when it detects cars on side lane not directly in front of me creating a noticeable slowdown being somewhat unsafe. The wiper blades dont come up they hit the hood of the car which i believe shouldnt be this way. The seatbelt sensors g... Read more

Incident date: Jan 15, 2026

At approximately 130,000 miles, vehicle developed and internal coolant leak caused by a failed Exhaust Heat Recovery System (EHRS) in the center muffler assembly, matching TSB 23-EM-009H - a known manufacturing defect documented by Hyundai. Coolant has been slowly leaking internally into the exhaust... Read more

Incident date: Apr 18, 2026

Bad parts in the transmission the cdf drum part is not good. While on the highway I was driving and my car lost all power and for about 5-6 seconds lost all power to the car until the transmission kicked into gear. I have has it in for a warranty and they keep saying it nothing then final it went ba... Read more

Incident date: Apr 10, 2026

I am reporting a safety-related engine defect involving sudden internal engine failure, excessive oil consumption, persistent bearing knock, and overheating of the catalytic converter. The vehicle repeatedly triggered Bank 1&2O2 sensor fault codes due to oil blow-by and thermal overload. A certified... Read more

Incident date: Dec 28, 2025

Ford does not have the parts to repair my car; my rear camera gets fuzzy at times

Incident date: Sep 14, 2025

We discovered severe mold contamination and water intrusion in our 2023 Toyota RAV4 Hybrid. My wife, our [XXX] child, and I have been experiencing dizziness and nausea for months whenever we were inside the vehicle, but we did not know the cause until the dealer (DLL) showed us extensive mold throu... Read more

3 injured

Incident date: Oct 27, 2024

Odometer Fraud. The contact purchased a 2013 Ford Explorer. The contact stated that it was discovered that there was a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 106,796. It was later discovered that the mileage on the Title was 1... Read more

Incident date: Oct 14, 2025

While waiting at a light, then the car shut off. Lossing all power. I could not get out of the vehicle, no hazards, no lights, nothing. After several pulls of the door handle I was able to open the door but the hazard light was not able to come one. After 4 attempts to engage break to push start th... Read more

Incident date: Jul 17, 2025

The steering wheel sticks when you try to turn it. The best example of what happens is when you're driving on a fairly straight road, you typically make small steering adustments to keep your car in it's lane. What happens is, when you try to turn the steering wheel it "sticks" and doesn't move a... Read more

Incident date: Jul 17, 2025

I am submitting this supplemental complaint regarding a repeated and dangerous brake failure in my 2025 Hyundai Palisade. This is a follow-up to my original complaint submitted in July 2025. On multiple occasions while driving at low speeds (around 5 mph), including turning into driveways or approa... Read more

Crash

Incident date: Jun 24, 2025

Safety Issue Company Fleet Vehicle Error Message on the DASHBOARD Cluster: "Engine Malfunction Power Reduced Service Now" And will suddenly stop in the middle of the road or Freeway.

Incident date: Jun 24, 2025

Is anything being done about the known oil consumption issues with the 2019 Sonatas? My daughter bought the car used -- it currently has 70,000 -- but Hyundai won't do anything because she is the second owner and those cars don't get 100,000 protection, they only get 60,000. It just doesn't seem ... Read more

Incident date: Jun 24, 2025

Safety Issue Company Fleet Vehicle Error Message on the DASHBOARD Cluster: "Engine Malfunction Power Reduced Service Now" And will suddenly stop in the middle of the road or Freeway.

Incident date: Feb 25, 2025

The lower control arm of the passenger front wheel separated from the vehicle entirely while the vehicle was in motion. There are two bolts which attach the bushing to the front sub-frame assembly. These bolts pass through the frame and are secured into nuts which are affixed to the frame. The bo... Read more

Incident date: Apr 8, 2025

Car had scheduled routine maintenance done on February 15, 2025 where tires were rotated and balanced. About a month later, the rear differential failed. Car only has 87,000 miles on it and was not driven in any excessive manner. Wheel bearings made noise for two days and then the differential faile... Read more

Incident date: Jun 3, 2023

AWD module not working was on screen after starting vehicle plus other codes about adaptive cruise control

Incident date: Jan 30, 2025

The components in the N28 / NHTSA 13V-234 recall did exactly what they were recalled for. My check engine light came on a few months back so I brought it to be diagnosed at a parts store and diagnostic scanner listed P codes for possible O2 sensor. I brought my 2013 Jeep Wrangler Sport into a Jeep d... Read more

Incident date: Jan 30, 2025

Incident date: Dec 22, 2024

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.

Fire

Incident date: Oct 5, 2024

I was on the highway when my car started to light up on the dashboard and the car started to slow down and wouldn’t move. Took it to ford and they had to replace the whole engine but now even after the replacement the car is slow, doesn’t heat up and shakes.

Incident date: Oct 5, 2024

Incident date: Oct 9, 2024

The contact owned a 2024 RAM 2500. The contact stated that while her husband was driving at 40 MPH, he attempted to slowly bring the vehicle to a complete stop upon approaching a stop sign. However, with the brake pedal depressed all the way to the floorboard, the vehicle failed to stop or even slow... Read more

Fire

Incident date: Oct 5, 2024

On Thursday October 3rd I was driving in stop and go city traffic. After accelerating to leave from a light my jeep died in the middle of the intersection. Total loss of power and slammed to a stop almost causing the person behind me to hit me. It started I drove it back to work. Later that day I le... Read more

Incident date: Sep 3, 2024

My spark plugs need to be changed every 6 months. Eventually had to get a new engine because of it. I have 5000 miles on the new engine and already had to get new spark plugs today again. Please recall this!!

Incident date: Aug 14, 2024

Unknown

Incident date: Apr 25, 2024

I received a critical safety recall regarding side air bags from Rivian regarding my 2023 R1S on June 14. After multiple attempts by me to connect with their Customer Service, I was informed that a mobile service technician would come to fix the issue on August 26, 2024. This would be more than 60 d... Read more

Incident date: Apr 25, 2024

The contact owns a 2017 Honda Accord. The contact stated while driving at an undisclosed speed, the Forward Collision Avoidance Dynamic Brake Assist activated unexpectedly. The contact stated that the message “BRAKE” was displayed. The vehicle was taken to a dealer to be diagnosed. The contact w... Read more

Incident date: May 22, 2024

For years my truck starts vibrating excessively, shaking the entire vehicle when driving over certain sections of roadway or bumps. Sometimes, my steering is difficult to maintain when this happens. This occurs at speeds around 50 mph+. I always assumed it was just a bad road section and never purs... Read more

Incident date: Jun 24, 2024

The contact owns a 2012 Ford Explorer. The contact stated that after receiving a map update on the main control panel, the display screen immediately blacked out. The contact stated that when updating the ATI system map, the main control panel screen completely blacked out. The contact was unable to... Read more

Incident date: Jan 1, 1999

The contact owns a 2015 Ford Fusion. The contact stated that while the vehicle was turned off with the gear shifter in park(P), the vehicle began to roll forward while the contact was in front of the vehicle. The vehicle was on an incline and independently stopped after rolling forward. The vehicle ... Read more

Incident date: Jan 1, 1999

The air bag light started blinking. We took the car to our local Nisan dealership. We had to pay $220.77 just to have them look at it. They said there was an occupant sensor unit malfunction and it needed the bottom seat pad replaced. We were then told “that it is discontinued “! We are left wi... Read more

Incident date: Jan 1, 1999

The contact owns a 2017 Ford Escape. The contact stated while driving 55 MPH, the turbo charger became inoperable. The contact noticed smoke emerging from the vehicle, and the vehicle started losing motive power, and decelerated to 35 MPH. The contact checked the oil and noticed that the oil level w... Read more

Incident date: Mar 23, 2024

The automatic windows open when the car is parked without being initiated by anyone. Think of it as phantom window opening. The vehicle occasionally reports a window being open when in fact they are all closed. When the phantom opening occurs there is not notice of a window being open.

Incident date: Mar 15, 2024

On several occasions and almost never under similar circumstances, my entire Brake System suddenly shows there is a problem and flashes warnings on my dashboard - parking brake, power steering, vehicle stability assist, hill start assist, adaptive cruise control, collision mitigation, road departure... Read more

Incident date: May 1, 2024

Cruise control would not disengage. Instead it accelerated me to 85 mph is rush hour traffic. The car continued to accelerate will out responding to any commands to turn off cruise control. Second time this has happened. It was supposed to be fixed by doing an update to the car. This did not work. T... Read more

Crash 1 injured

Incident date: May 1, 2024

STEERING IS JERKY WILL . PULL TO THE RT AND LEFT WHILE DRIVING AT MODERATE SPEEDS, STEERING IS NOT SMOOTH AND DIRECT TURNING. ISSUE HAS BEEN REPORTED TO HONDA AND THEY ARE GOING TO ORDER A POWER STEERING ASSEMBLY. UP TO 4 + MONTHS WAITING TO GET REPLACED .... CAN THIS BE SAFE TO DRIVE FOR NEXT 4+ ... Read more

Incident date: May 1, 2024

The steering wheel locks momentarily at cruising speed of 35-45 MPH. This results in the need of over or under compensating the steering with extra effort. The steering is generally locked in the same position and it also frequently moves the direction of the vehicle to the point that I fear this is... Read more

Incident date: Sep 22, 2022

For no reason the truck would not start. No electric signal at all inside the truck either. Also the ignition and steering were locked. Called Ford to send out someone to jump the truck. It then started right away. Also took to the Ford dealer to have them check it out. They could find nothin... Read more

Incident date: Sep 22, 2022

I had 2 recalls fixed about 3 weeks ago. Today I was driving & my Maverick malfunctioned. (Maybe it's what they call Limp mode.) Many alerts & icons started flashing, I was prompted to pull over & call a dealer. I pulled over, was able to take some pics but some icons were no longer showing. I tri... Read more

Incident date: Mar 28, 2024

The right rear tail light housing harness melted due to an electrical issue. Wire tends to heat up too much. This caused my right rear tail light, right break light and right side turn signal not to function.

Incident date: Mar 28, 2024

Regenerative breaking skips and propels the car forward while driving.

Incident date: Mar 28, 2024

Regenerative breaking skips and propels the car forward while driving.

Incident date: Mar 20, 2024

The contact owns a 2017 FORD Escape. The contact stated while driving the vehicle, it ran rough and the contact noticed the cooling level was low. No warning lights was illuminated. The vehicle was taken to the dealer and the water pump was replaced. However the failure persisted. The contact r... Read more

Incident date: Mar 20, 2024

The car was experiencing the Mazda Ghost Touch in which the navigation/infotainment screen randomly pushes buttons resulting in distracted driving. Mazda has authorized repairs for 2014-2016 models, but refuses to fix later models. For reference, see [XXX] INFORMATION REDACTED PURSUANT TO THE F... Read more

Incident date: Jan 1, 2022

The contact owns a 2020 Ram 2500. The contact stated while driving at approximately 45 MPH, the contact swerved to the left to avoid crashing into a deer. The contact stated that when he attempted to return the vehicle to the right lane the vehicle's front end continued to turn to the left as the re... Read more

Crash 1 injured

Incident date: Mar 12, 2024

2020 Ford Escape. Front driver door made a lot of creaking noise, hard to open and close, couldn't roll window down because hinge had broken was loose in door. Discussed with Mel Hamilton Ford, Wichita KS, while it was there getting another issue addressed. Said it was not covered under warranty. ... Read more

Incident date: Mar 12, 2024

Showing 50 of 189 complaints.

NHTSA Safety Ratings, 2015 HYUNDAI VELOSTER

2015 Hyundai VELOSTER 3 C FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	4 / 5 ★★★★☆
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	10.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2015 HYUNDAI VELOSTER

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.6L 4-cyl, Automatic (AM6) (Front-Wheel Drive)	27.0	35.0	30.0	Regular	$2,050
1.6L 4-cyl, Manual 6-spd (Front-Wheel Drive)	26.0	34.0	29.0	Regular	$2,100
1.6L 4-cyl, Automatic (S6) (Front-Wheel Drive)	24.0	31.0	26.0	Regular	$2,350
1.6L 4-cyl, Manual 6-spd (Front-Wheel Drive)	24.0	33.0	27.0	Regular	$2,300

CO2 Emissions: 292.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2015 HYUNDAI VELOSTER

196 manufacturer communications from 99 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	29
060000 ENGINE AND ENGINE COOLING	29
350000 EQUIPMENT	16
100000 POWER TRAIN	12
356000 EQUIPMENT ADAPTIVE/MOBILITY	11
118000 ELECTRICAL SYSTEM:SOFTWARE	10
010000 STEERING	5
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	5

100000 POWER TRAIN

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

130000 VISIBILITY

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY/WIPER (PWS)

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

A class action lawsuit against Hyundai Motor America (a??HMAa??) alleges that certain Hyundai vehicles (a??Class Vehiclesa??) were manufactured, marketed, sold, and/or leased with an engine defect that can result in sudden engine seizure,

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

160000 STRUCTURE

In certain areas, a vehiclea??s underbody may exhibit corrosion due to road-salt usage. As a preventative measure, a cavity wax coating is applied to the internal surfaces of underbody components and an undercoating spray is applied to exte

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, wh

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

060000 ENGINE AND ENGINE COOLING

Certain vehicles may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise, or no crank/no start condition related to connecting rod bearing wear or damage. This Dealer Best Practice ou

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

061400 ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

060000 ENGINE AND ENGINE COOLING

Certain vehicles that have completed Service Campaign 966 may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspe

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator La

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL)

060000 ENGINE AND ENGINE COOLING

The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

118000 ELECTRICAL SYSTEM:SOFTWARE

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a product improvement campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction

060000 ENGINE AND ENGINE COOLING

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

Consult the Hyundai Warranty Policy & Procedures and the below tables to determine New or Reman engine usage. Please note that a Reman engine may not be available for certain vehicle models/model years listed in this TSB.

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage, defect, or failure is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original r

100000 POWER TRAIN

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

190000 TIRES

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

200000 WHEELS

010000 STEERING

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

350000 EQUIPMENT

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

012000 STEERING:COLUMN

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

110000 ELECTRICAL SYSTEM

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

Showing 100 of 196 bulletins.

NHTSA Safety Investigations, HYUNDAI VELOSTER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2012

Panoramic Sunroof Breakage

The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints o... f sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171Read more

HYUNDAI VELOSTER - All Years Overview

Complete safety history for the HYUNDAI VELOSTER across all model years (2012, 2021).

18 Total Recalls

1,780 Total Complaints

1 Investigations

80 Reported Crashes

68 Reported Fires

0 Reported Deaths

HYUNDAI VELOSTER - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022	0	9	View
2021	1	15	View
2020	1	29	View
2019	2	63	View
2017	0	70	View
2016	1	301	View
2015 (current)	2	189
2014	2	116	View
2013	3	580	View
2012	6	408	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2015 HYUNDAI VELOSTER

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2015 HYUNDAI VELOSTER

Safety Technology

EPA Fuel Economy, 2015 HYUNDAI VELOSTER

Technical Service Bulletins, 2015 HYUNDAI VELOSTER

Most Affected Components

NHTSA Safety Investigations, HYUNDAI VELOSTER

HYUNDAI VELOSTER - All Years Overview

HYUNDAI VELOSTER - Year by Year

Other HYUNDAI Models