2016 HYUNDAI VELOSTER

1 recalls, 300 complaints - 179 TSBs - 5/5 safety rating

ENGINE

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.

Consequence

A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Remedy

Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. ... Read more

128,948 vehicles affected

Manufacturer: Hyundai Motor America

Complaint Statistics

300 total complaints 30 crashes 5 fires 29 injuries

Top Reported Components

Component	Complaints
ENGINE	89
POWER TRAIN	41
UNKNOWN OR OTHER	36
ELECTRICAL SYSTEM	25
FUEL/PROPULSION SYSTEM	19
AIR BAGS	14
SERVICE BRAKES	13
VEHICLE SPEED CONTROL	10
STRUCTURE:BODY	9
SEAT BELTS	6

Incident date: Sep 27, 2022

The contact owns a 2016 Hyundai Veloster. The contact stated that gas fumes were entering inside the vehicle and exhaust fumes were present while driving the vehicle and while the vehicle was parked. The vehicle was taken to an independent mechanic on several occasions and to several dealers; howeve... Read more

Incident date: Jul 31, 2023

Complaint regarding 2016 Hyundai Veloster engine oil consumption and warranty denial. In late 2023, at approximately 70,000–80,000 miles, my vehicle began experiencing excessive oil consumption. I reported this issue to Hyundai and authorized dealerships while the vehicle was still under warranty... Read more

Incident date: Jun 8, 2026

While driving home, the engine began to run very rough with decreased acceleration, obvious overall loss of power and a significant amount of white smoke being emitted from exhausts. Several alarm indicators and codes started flashing on instrument panel including Check Engine, Service ESC, Steering... Read more

Incident date: Apr 28, 2026

Car is consuming oil every three weeks. Engine is going to burn if it does not stop. It’s not in a class action but probably should be. It’s been 4 months and over 1,000 spent.

Incident date: Mar 20, 2026

There is a continual problem with this car. Randomly, about every 1-2 weeks, my entire infotainment center, customer settings, and seat preferences will reset to Italian and the metric system. When this happens, the front collision warning system turns off. The radio screen also begins to flash on a... Read more

Incident date: Apr 12, 2026

I was driving and car suddenly reduced speed,engine light came on and message came across dash “engine power reduced” and a text was sent to tell me I have a transmission issue. Now car won’t drive past 25-30mph dealership indicated this is a faulty gas pedal which cost over $600 to repair. ... Read more

Incident date: Dec 31, 1969

I was driving and out of no where my brakes “ all four wheels “ locked up as if I was hauling a heavy load . I put on my hazard lights to warn the semi behind me. So I maintained control of my line until the cargo van slowed down to a safe speed for me to pull over . I thought the semi was goin... Read more

Incident date: Dec 31, 1969

While accelerating from a light that had just turned green, after passing through an intersection the vehicle seized up and came to a complete stop. There were no warning lights or any indication of a malfunction. The vehicle did not shut off, the wheels just stopped spinning. After a few seconds it... Read more

1 injured

Incident date: Feb 19, 2026

I own a 2023 Hyundai Palisade Limited that currently has confirmed active safety recalls affecting critical passenger safety systems, including the third-row side-curtain airbag recall and the second-row seat belt buckle recall. We have experienced firsthand the seat belts coming unbuckled during dr... Read more

Incident date: Oct 1, 2025

While driving at approximately 20mph, the front passenger-side steering knuckle suffered a catastrophic structural failure, snapping completely in two. This resulted in an immediate loss of steering and suspension control. Inspection of the fractured part by a mechanic revealed significant orange ox... Read more

Incident date: Oct 1, 2025

The contact owns a 2022 Hyundai Tucson. The contact stated that while stopped, the vehicle hesitated to respond, with the check engine warning light illuminated. The contact stated that while the vehicle was parked, it was shaking unexpectedly with a misfire coming from the engine, and the check eng... Read more

Incident date: Dec 8, 2025

Had the ABS Module repaired due to recall last week. Next, I have had 3 instances of the Accelerator sticking when shifting gears and, this never happened before this service.

Incident date: Jul 19, 2025

Replaced front multi plate transfer clutch at 96,987 miles.

Incident date: Jul 4, 2025

The contact owns a 2025 Honda Accord. The contact received notification of NHTSA Campaign Number: 25V785000 (Electrical System). The contact called the local dealer, who confirmed that the repair instructions were not available. The vehicle was not diagnosed or repaired. The manufacturer was not con... Read more

Incident date: Dec 1, 2025

February 2023: horn failure. Pressed the car's horn, and it FAILED to produce the loud sound that it is SUPPOSED TO make to warn others of possible danger. It continued to not work and needed to be replaced. Part 96611-J9500 was replaced.

Incident date: Nov 28, 2025

The tailgate on my 2016 Dodge Ram will not stay locked and falls open during cold weather. I've contacted the dealer but they said this particular vin is not included in a recall. I've accessed the inside panel on the tailgate several times to clean and lubricate, but it only works for a short tim... Read more

Incident date: Nov 28, 2025

The contact owned a 2017 Chrysler Pacifica. The contact stated that while the contact's husband was driving at an undisclosed speed, the contact's vehicle was involved in a crash. The contact stated that a nearby vehicle drove in front of the contact's vehicle and then suddenly applied the brakes. I... Read more

Crash 2 injured

Incident date: Sep 21, 2025

Traffic stopped very quickly. The automatic breaking did not engage, resulting in a crash and a total loss of the vehicle. I bought the Audi due to quality safety features so this incident was very disappointing and costly for our family.

Crash

Incident date: Nov 28, 2025

Crash 2 injured

Incident date: Nov 6, 2025

The contact owns a 2015 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V695000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The local dealer was contacted and confirmed that parts were not yet av... Read more

Incident date: Sep 1, 2024

The contact owns a 2019 Ford Expedition. The contact stated that while driving at approximately 35 MPH with the driver's seat belt fastened, she observed a loud explosion inside the vehicle, and then she felt what she thought was an impact to her chest, and the wind was knocked out of her as she beg... Read more

1 injured

Incident date: Sep 26, 2025

While driving on the road the vehicle suddenly loses power and shuts down. The check engine light illuminates and a message saying shift to park appears on the dashboard. You have no control of speed at this point. The vehicle stops and stalls in the middle of the road. Once you shift to park you ha... Read more

Incident date: Aug 12, 2025

Reverse light not working properly unable to clear see while reversing

Incident date: Jul 20, 2025

Driving VA Interstate 64. Traveling right side travel lane approximately 70 mph. Had ADAS engaged. Car entering highway, moved to center travel lane to pass. As I approached entering highway car, suddenly, my car stalled, engine off and I was stopped in center travel lane. Able to start car by p... Read more

Incident date: Aug 29, 2025

This model year truck has an oil consumption problem. I had the truck repaired under the Ford bulletin, but I’ll still need an oil consumption test after 1000 miles and continued frequent oil changes.

Incident date: Jun 6, 2025

In the past 2 weeks my 2025 Honda CRV has automatically braked four times while driving on the road at about 45 miles an hour. Nothing else was around me - no vehicles, no animals, etc.

Incident date: Feb 8, 2025

While driving on the freeway my sunroof suddenly imploded sending glass everywhere. No warning whatsoever it was like a bomb went off out of nowhere. Nothing hit the car and temps were not high and it just imploded This is a serious matter and extremely dangerous. The pain and ringing in my ears is ... Read more

Incident date: Jun 18, 2025

The Powertrain of this Ford Bronco Sport (2024) with only 12,000 miles on it malfunctioned while the driver was on a major highway. No control over gears, engine power, etc. Had to pull over in heavy traffic. Fortunately there was a shoulder, or this would have been a major safety risk for the dri... Read more

Incident date: Jun 23, 2025

All Polestar 2 cars including mine have a critical failure in the cpu which prevents the backup camera from working correctly. When the car is placed into reverse the backup camera appears but flickers and ultimately goes out with a message stating “backup camera unavailable.” This is extremely ... Read more

Incident date: Jun 4, 2025

When putting my car in park and turning the car off I get a shift to park message.

Incident date: Jun 4, 2025

Check engine light with P1098 code for engine coolant control valve failure. This part has been on back order for months and manufacturer hasn’t declared a recall or provide any update to their customers.

Incident date: Jun 4, 2025

When putting my car in park and turning the car off I get a shift to park message.

Incident date: Jul 1, 2023

The contact owns a 2022 Ford F-250. The contact stated that upon starting the vehicle, there was an abnormal tapping sound coming from the engine and the vehicle was idling rough. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it... Read more

Incident date: Apr 8, 2025

The contact owns a 2017 Infiniti Q50. The contact stated while driving 40 MPH and attempting to accelerate, the RPM increased quickly; however, the vehicle lost motive power, prompting the contact to discontinue driving the vehicle. Upon arriving at the residence, the contact shifted the vehicle int... Read more

Incident date: Apr 8, 2025

The contact owns a 2022 Honda Passport. The contact stated that while driving 40 MPH, the transmission shuddered. There was no warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the fuel injectors needed to be flushed. The vehicle w... Read more

Incident date: Dec 23, 2024

The contact owns a 2016 Jeep Patriot. The contact stated while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The vehicle was able to be restarted, but the failure persisted. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the... Read more

Incident date: Feb 27, 2025

My Gas tank does not fill up properly. It seems to trigger the automatic shut off at gas stations when it is only 3/4 full. I then have to keep putting gas it with about 6 more shut offs to get the tank full.

Incident date: Feb 27, 2025

My 2016 Range Rover has been identified in a recall for knuckle which may crack without warning leading to catastrophic failure of the vehicle which could result in injury or death of passengers. I learned of the recall in December of 2024 at which time I discontinued driving the vehicle and contac... Read more

Incident date: Feb 27, 2025

Instrument cluster went completely dark. It flickered a few times while driving, then went completely dark.

Incident date: Aug 14, 2024

Car is hesitating alot from a stop and has locked up. Engine light came on. Had it diagnosed and the codes came up Transmission control module (Tcm). Cant find the part and the ine i did find was 800. It's only 6 years old and should not have Transmission problems and be locking up on me.

Incident date: Dec 28, 2024

Seat belt on front passenger seat randomly comes unlatched while driving. I asked my dealership to review this in May 2024 and then again in 1/2025 as it keeps happening. The seat belt is clicked and suddenly comes loose and then the seatbelt alarms start going off. Dealership has not been able to ... Read more

Incident date: Dec 28, 2024

When approaching a turn, I let off the accelerator but the car didn’t stop accelerating. Instead, it gently kept accelerating. I applied the brakes and the car started slowing down but not at the same rate I was applying brake pressure. Therefore I floored the brakes to try coming to a complete st... Read more

Crash

Incident date: Dec 28, 2024

Tailgate opens up in Park and/or when Truck is shut off. Tailgate continues to click after it opens itself. I have found my truck battery dead if left connected overnight. For the last week i disconnect the battery when i shut the truck off, and reconnect when i want to start it to insure getting to... Read more

Incident date: Jun 22, 2023

Powertrain malfunction/ reduce power. My safety was fine, it just gave me really bad anxiety when the the gears shift shifted on its own. The problem was finally fixed it started literally less than five days after I bought my car and I bought my car brand new it took the dealership almost 2 years... Read more

Incident date: Jul 1, 2024

Blown head gasket

Incident date: Oct 25, 2024

The contact's friend owned a 2020 Chevrolet Impala E. The contact stated that while her friend was driving at 25 MPH and approaching a curve, he inadvertently lost control of the vehicle. As a result, the vehicle left the roadway, rolled, and came to a complete stop with all four wheels facing upw... Read more

Crash 1 injured

Incident date: Aug 1, 2024

2023 f350 4x4 6.7 powerstroke diesel and engine is knocking and seems to a spun bearing metal.shaving all in my oil

Incident date: Aug 1, 2024

Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: dur... Read more

Incident date: Oct 11, 2024

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated tha... Read more

Crash 3 injured

Incident date: Jun 15, 2024

Fuel injector failure. UTC code PO030300 detected at 27500 miles. Car is shaky and loss of power in idle. Code showing on infortainment screen. Taken to dealership on 9/17/24 with appointment and vehicle was not "diagnosed" until 9/19/24. From loss of power, with children in car it is a safety issue... Read more

Showing 50 of 300 complaints.

NHTSA Safety Ratings, 2016 HYUNDAI VELOSTER

2016 Hyundai VELOSTER 3 C FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	4 / 5 ★★★★☆
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	10.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2016 HYUNDAI VELOSTER

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.6L 4-cyl, Automatic (AM6) (Front-Wheel Drive)	28.0	35.0	31.0	Regular	$2,000
1.6L 4-cyl, Manual 6-spd (Front-Wheel Drive)	27.0	34.0	30.0	Regular	$2,100
1.6L 4-cyl, Automatic (AM6) (Front-Wheel Drive)	26.0	32.0	29.0	Regular	$2,150
1.6L 4-cyl, Manual 6-spd (Front-Wheel Drive)	25.0	33.0	28.0	Regular	$2,200

CO2 Emissions: 290.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2016 HYUNDAI VELOSTER

179 manufacturer communications from 91 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	30
110000 ELECTRICAL SYSTEM	27
350000 EQUIPMENT	11
100000 POWER TRAIN	9
010000 STEERING	8
118000 ELECTRICAL SYSTEM:SOFTWARE	7
356000 EQUIPMENT ADAPTIVE/MOBILITY	7
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	5

130000 VISIBILITY

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY/WIPER (PWS)

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

A class action lawsuit against Hyundai Motor America (a??HMAa??) alleges that certain Hyundai vehicles (a??Class Vehiclesa??) were manufactured, marketed, sold, and/or leased with an engine defect that can result in sudden engine seizure,

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

110000 ELECTRICAL SYSTEM

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

160000 STRUCTURE

In certain areas, a vehiclea??s underbody may exhibit corrosion due to road-salt usage. As a preventative measure, a cavity wax coating is applied to the internal surfaces of underbody components and an undercoating spray is applied to exte

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G)

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, wh

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

060000 ENGINE AND ENGINE COOLING

Certain vehicles may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise, or no crank/no start condition related to connecting rod bearing wear or damage. This Dealer Best Practice ou

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

061400 ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

060000 ENGINE AND ENGINE COOLING

Certain vehicles that have completed Service Campaign 966 may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspe

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator La

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL)

060000 ENGINE AND ENGINE COOLING

The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

118000 ELECTRICAL SYSTEM:SOFTWARE

060000 ENGINE AND ENGINE COOLING

Hyundai is conducting a product improvement campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction

100000 POWER TRAIN

Certain vehicles (listed below) equipped with 7-speed Dual Clutch Transmission (DCT) may exhibit abnormal vibration at low speeds. This bulletin outlines the procedures for diagnosing and replacing the Double Clutch, including a Transmissio

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

103110 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

060000 ENGINE AND ENGINE COOLING

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

Consult the Hyundai Warranty Policy & Procedures and the below tables to determine New or Reman engine usage. Please note that a Reman engine may not be available for certain vehicle models/model years listed in this TSB.

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage, defect, or failure is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original r

100000 POWER TRAIN

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

190000 TIRES

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

200000 WHEELS

010000 STEERING

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

350000 EQUIPMENT

This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.

Showing 100 of 179 bulletins.

NHTSA Safety Investigations, HYUNDAI VELOSTER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2012

Panoramic Sunroof Breakage

The Office of Defects Investigation (ODI) opened PE12-027 on October 2, 2012 to investigate allegations of spontaneous sunroof shatter on model year (MY) 2012 Hyundai Veloster vehicles. The MY2012 platform was the first to introduce the panoramic sunroof option. ODI received 26 consumer complaints o... f sunroof shatter, 15 occurring while the vehicle was being driven. The injury incidents noted were due to complainants who alleged minor cuts or abrasions from fallen glass. Sunroof glass shattering while operating the vehicle poses a risk of personal injury or a vehicle crash.In response to ODI's information request (IR), Hyundai provided 23 consumer complaints related to the alleged problem and 46 warranty claims for sunroof shatter and/or replacement.On December 6, 2012 Hyundai notified ODI that it would conduct a safety recall on model year 2012 Veloster vehicles equipped with panoramic sunroofs manufactured from November 1, 2011 through April 17, 2012. The panoramic sunroof assembly may have weakened during installation at the factory. An intermittent malfunction of a limit switch for the panoramic sunroof assembly's unloading station robot may have occurred, allowing forced contact between the mechanism and the sunroof glass. This contact could have caused damage to the sunroof glass, and lead to subsequent shattering of the glass in the field. The loading station robot was repaired in April 2012. The initial point in time for the malfunction of the station robot was not clearly defined through technical reasoning, therefore ODI challenged the proposed production scope for the safety recall. On February 14, 2013 Hyundai responded that they will conduct safety recall 13V-051 which expands the covered vehicles to those produced from the start of MY2012 production (July 4, 2011) through April 17, 2012. This investigation is closed on the basis of Hyundai's announcement of safety recalls 12V-568 and 13V-051.The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10462857, 10463570, 10465757, 10468816, 10468854, 10469144, 10471972, 10472742, 10473062, 10473640, 10477212, 10478075, 10478735, 10479487, 10479931, 10482027, 10482056, 10482561, 10482760, 10482933, 10483765, 10483770, 10484048, 10485802, 10487399, 10490171Read more

HYUNDAI VELOSTER - All Years Overview

Complete safety history for the HYUNDAI VELOSTER across all model years (2012, 2021).

18 Total Recalls

1,772 Total Complaints

1 Investigations

82 Reported Crashes

67 Reported Fires

0 Reported Deaths

HYUNDAI VELOSTER - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022	0	9	View
2021	1	15	View
2020	1	29	View
2019	2	62	View
2017	0	69	View
2016 (current)	1	300
2015	2	189	View
2014	2	114	View
2013	3	577	View
2012	6	408	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 HYUNDAI VELOSTER

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2016 HYUNDAI VELOSTER

Safety Technology

EPA Fuel Economy, 2016 HYUNDAI VELOSTER

Technical Service Bulletins, 2016 HYUNDAI VELOSTER

Most Affected Components

NHTSA Safety Investigations, HYUNDAI VELOSTER

HYUNDAI VELOSTER - All Years Overview

HYUNDAI VELOSTER - Year by Year

Other HYUNDAI Models