2016 GMC SIERRA 3500

6 recalls, 27 complaints - 749 TSBs

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Defect Description

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence

A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy

Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May... Read more

410,019 vehicles affected

Manufacturer: General Motors, LLC

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Description

General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.

Consequence

If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

Remedy

GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.

18,574 vehicles affected

Manufacturer: General Motors LLC

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Defect Description

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.

Consequence

If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.

Remedy

GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall... Read more

42,280 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Subur... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadi... Read more

40,683 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Poli... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Ca... Read more

3,640,162 vehicles affected

Manufacturer: General Motors LLC

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Defect Description

General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC S... Read more

Consequence

Remedy

GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for ... Read more

430,771 vehicles affected

Manufacturer: General Motors LLC

Complaint Statistics

27 total complaints 1 injuries

Top Reported Components

Component	Complaints
STEERING	7
SERVICE BRAKES	6
ENGINE	5
POWER TRAIN	2
ELECTRICAL SYSTEM	2
AIR BAGS	1
SUSPENSION	1
UNKNOWN OR OTHER	1
LANE DEPARTURE: BLIND SPOT DETECTION	1
LATCHES/LOCKS/LINKAGES	1

Incident date: Jul 24, 2025

Driving and a service trailer brake code popped up and wouldn’t turn off it is a very distracting ding

Incident date: Jul 24, 2025

Coolant leak in cylinder 3 due to faulty head gasket. Based on the blogs, this is an issue with all Pacifica not just 2018. This requires a full engine replacement which most families cannot afford nor afford to replace the vehicle. If we keep driving it with this issue it becomes a safety issue. Qu... Read more

Incident date: Jul 16, 2024

At 48,000 to 49,000 my vehicle started experiencing PTU issues and Auto start/stop feature issues. My PTU unit started grinding and making loud noises while driving. I contacted my local Chrysler/Jeep/Dodge dealership and they said my PTU and the sensor for the PTU was going out and needed to be rep... Read more

Incident date: Dec 29, 2024

Excessive oil consumption. I have 110,000 on my vehicle. Every 1000 miles I need to add 1 quart of oil. My vehicle is not leaking oil. This matter is very a common problem, well-documented issue for this Honda engine. Honda will not respond to my complaint.

Incident date: Jan 15, 2024

Vehicle has warnings for EPB and lane assist along with active recall for roll away. Cruise control does not work as well. Wheel jerks out of your hand while driving Has been to appointment 7/1 in which vehicle was not repaired. Dealer claiming they had no record of a “diagnosis appointment... Read more

Incident date: Jan 15, 2024

Battery is dying repeatedly due to electric system failure. Dealership mechanics suspect a parasitic drain but have not been able to identify the cause. There are many other 2025 Kia Carnival owners reporting the same issue. Our car has been at the dealer multiple times for 17 days (so far) without ... Read more

Incident date: May 6, 2024

The contact owns a 2016 Kia Sedona. The contact stated that while driving at an undisclosed speed at night going downhill, the headlights to the vehicle shut off inadvertently and the contact to almost struck a pedestrian. The contact stated that the vehicle struck a curb, and he became disoriented.... Read more

1 injured

Incident date: May 6, 2024

I am unsure of what to say about my car. I saw a check oil light flicker and it went away. The car had oil when I checked on it so it didn't seem to be a problem. There was no sign of leakage and no sign of burning oil or fuel. Several days later, the check oil light came on permanently. Before I c... Read more

Incident date: Jan 27, 2024

The contact owns a 2020 Jeep Wrangler. The contact stated while driving at 53 MPH, the vehicle was uncontrollably shaking for about a minute. The contact stated that after the shaking ceased, the contact was able to drive to the destination. The contact also stated that the failure had occurred thre... Read more

Incident date: Jul 28, 2023

The contact owns a 2013 Ford Mustang. The contact stated that while driving at high speeds, the vehicle downshifted unintendedly. The transmission warning light, the check engine warning light and other unknown warning lights were illuminated. The vehicle was taken to the dealer, where it was diagno... Read more

Incident date: May 12, 2023

The contact owns a 2018 Ford Escape. The contact stated while driving 65 MPH, the steering wheel seized. Additionally, the steering assist fault warning light was illuminated. The vehicle was towed to the dealer, who informed the contact that the ECU was defective, and the check engine warning light... Read more

Incident date: May 12, 2023

Power Rear lift gate does not work on a consistent basis. It will work normally for several days, then without warning, not work. Will not work with remote or interior opening mechanism. Only the manual release in the rear will unlatch the rear gate, which is quite heavy to lift and not designe... Read more

Incident date: May 6, 2023

I recently got the EGR cooler replaced as part of the recall campaign safety issue, after my repair, a very strong smell of fuel and exhaust was coming into my car cabin, when I reported to BMW they said it should burn off - that it wasn’t an issue. I took it a master technician to diagnose and in... Read more

Incident date: Feb 5, 2022

I had the rear defrost running, and began to hear a sizzling/hissing sound in the back seat. After a minute of hearing this noise, I noticed smoke coming from the rear sliding window. I immediately turned off the rear defrost. A few seconds later, I heard a loud pop and the passenger side of my r... Read more

Incident date: Nov 10, 2021

Incident date: May 6, 2021

BACKED IT OUT OF THE GARAGE TO GO SOMEWHERE, GOT ON THE MAIN ROAD AND IT WAS WONDERING WITH A LOT OF PLAY IN THE STEERING WHEEL, NEXT HIT A BUMP IN THE ROAD AND THE FRONT WHEELS STARTED SHAKING UNCONTROLLABLY UNTIL I SLOWED TO UNDER 40 MPH, HIT ANOTHER ROAD SEAM AND IT DID THE SAME THING.TOOK IT TO ... Read more

Incident date: Mar 5, 2019

EXCESSIVE PLAY IN STEERING WHEEL 2 TO 3" VERY UNSAFE, AT ALL TIMES WHEN DRIVING. GM IS AWARE OF PROBLEM BUT NOT DOING ANYTHING ABOUT A SERIOUS SAFETY ISSUE. SERVICE BULLETIN PIT5501D. SOMETHING NEEDS TO BE DONE.

Incident date: Sep 20, 2020

THE BRAKE BOOSTER CILYNDER HAVE A BAD LEAKING IT WAS PARKED WHEN I SAW THIS HAPPEN

Incident date: Dec 31, 2018

TL* THE CONTACT OWNS A 2016 GMC SIERRA 3500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH OR MORE, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE CONTACT STATED THE TRANSMISSION FAILURE WARNING LIGHT ILLUMINATED WITH A MESSAGE STATING THAT IN APPROXIMATELY 60 MILES THE VEHICLE WOULD ... Read more

Incident date: Dec 31, 2018

Incident date: Mar 25, 2016

STEERING WHEEL HAS SLOP/PLAY IN IT. WHEEL HAS 3-4 INCHES OF PLAY BEFORE IT CATCHES. CAN DRIVE DOWN ROAD AND 1 MIN WHEEL IS TO THE LEFT NEXT ITS TO RIGHT TO KEEP TRUCK GOING STRAIGHT.

Incident date: Jul 24, 2018

TL* THE CONTACT OWNS A 2016 GMC SIERRA 3500. WHILE PASSING A BOAT RAMP HAULING A BOAT TRAILER, THE BRAKES AND STEERING FAILED TO FUNCTION. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE AND NOTICED THAT THE SERPENTINE BELT BECAME DETACHED. THE CONTACT WAS ABLE TO RECONNECT THE SERPENTINE BELT. THE VEH... Read more

Incident date: Jul 24, 2018

Incident date: Dec 2, 2016

-ALL STARTED WITH LOUD POP, METAL FAILURE SOUND. -AT A STOP, WITH BRAKES APPLIED, THE POWER STEERING TURNS THE WHEEL TO THE RIGHT. I HAVE TO PULL TO THE LEFT TO KEEP THE WHEEL CENTERED. (NOT MOVING) THIS PRESSURE ISSUE WILL FINALLY STOP AND THE WHEEL WILL CENTER ON IT'S OWN. -STEERING HAS SLOP, F... Read more

Incident date: Dec 2, 2016

Incident date: Oct 10, 2016

SIDE THORAX AND HEAD CURTAIN AIRBAGS ARE LISTED AS STANDARD EQUIPMENT FOR THE 2016 GMC SIERRA TRUCK LINE. I DISCOVERED AFTER MY PURCHASE THAT MY VEHICLE DOES NOT HAVE SIDE AIRBAGS. AFTER RESEARCH I LEARNED THAT WHEN YOU SELECT THE DURAMAX ENGINE OPTION, GMC DELETES ALL SIDE AIRBAGS AND DOES NOT NOTI... Read more

NHTSA Safety Ratings, 2016 GMC SIERRA 3500

2016 GMC Sierra 3500 PU/CC 4WD

Category	Rating
Rollover Risk	0.0%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2016 GMC SIERRA 3500

749 manufacturer communications from 482 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	92
350000 EQUIPMENT	87
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	70
110000 ELECTRICAL SYSTEM	70
100000 POWER TRAIN	53
060000 ENGINE (PWS)	29
200000 WHEELS	27
070000 FUEL SYSTEM, GASOLINE	20

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

200000 WHEELS

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

118000 ELECTRICAL SYSTEM:SOFTWARE

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.

980000 UNKNOWN OR OTHER

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

100000 POWER TRAIN

This Preliminary information communicates to have the dealer contact TAC with the transmission TUN number prior to transmission installation.

100000 POWER TRAIN

This Preliminary information communicates Diagnostic aids for a no start or DTC'S following a transmission replacement

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnosti

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

030000 BRAKES (PWS)

This Preliminary Information communication provides information to the technician about fluid leaking from the brake caliper piston area found during a service of the vehicle. The substance is actually excess assembly grease from the calipe

190000 TIRES

This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire and Loading Label" w

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary information communicates to dealers of a known issue with failed map update

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a l

160000 STRUCTURE

This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

071000 FUEL SYSTEM, GASOLINE:STORAGE

This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition is a normal operating

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

280000 BACK OVER PREVENTION

This Preliminary Information communication provides information to the technician about vehicles that are found to have a back-up alarm inoperative during the Pre-Delivery Inspection. On trucks equipped with the Back Up Alarm (RPO 8S3), the

110000 ELECTRICAL SYSTEM

110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

980000 UNKNOWN OR OTHER

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

060000 ENGINE AND ENGINE COOLING

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

100000 POWER TRAIN

This information bulletin advises the technician the difference between a welch cap leak and the output seal of the t-case or transmission leaking ATF, causing the customer concern of a Red Fluid Leak from Center of Vehicle Located by Rear

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.

350000 EQUIPMENT

This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

190000 TIRES

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

110000 ELECTRICAL SYSTEM

This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains the difference in oil filters for gas engines with new oil pump control systems and the possibilities of what may happen using the incorrect filter.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

060000 ENGINE AND ENGINE COOLING

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressive

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

350000 EQUIPMENT

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

030000 BRAKES (PWS)

This technical bulletin provides information and a solution to a condition of Brake Pedal Moves or Self Applies at Full Turns.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on the proper use of the labor operation 0600014.

350000 EQUIPMENT

This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.

110000 ELECTRICAL SYSTEM

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

060000 ENGINE AND ENGINE COOLING

This informational bulletin advised the technician that the engine and related parts will be debited if found that the tech didn't properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged b

020000 SUSPENSION

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

100000 POWER TRAIN

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

010000 STEERING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

350000 EQUIPMENT

This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

100000 POWER TRAIN

This service bulletin provides information for automatic transmission Oil Cooler Flush and flow test.

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

This service bulletin provides information for automatic transmission Oil Cooler Flush and flow test.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

Showing 100 of 749 bulletins.

GMC SIERRA 3500 - All Years Overview

Complete safety history for the GMC SIERRA 3500 across all model years (1997, 2026).

111 Total Recalls

768 Total Complaints

0 Investigations

43 Reported Crashes

25 Reported Fires

1 Reported Deaths

GMC SIERRA 3500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	2	5	View
2025	1	25	View
2024	3	66	View
2023	1	45	View
2022	3	43	View
2021	5	28	View
2020	8	72	View
2019	7	20	View
2018	6	20	View
2017	7	18	View
2016 (current)	6	27
2015	7	40	View
2014	3	10	View
2013	4	15	View
2012	4	15	View
2011	5	24	View
2010	5	2	View
2009	5	8	View
2008	3	28	View
2007	3	19	View
2006	0	14	View
2005	1	29	View
2004	1	29	View
2003	1	9	View
2002	3	29	View
2001	3	44	View
2000	4	30	View
1999	3	25	View
1998	4	12	View
1997	3	15	View
1996	0	2	View

Other GMC Models

Model	Recalls	Complaints
SIERRA 1500	233	10,607	View
YUKON	224	6,198	View
SIERRA 2500	169	2,217	View
YUKON XL	157	2,899	View
SAVANA	142	448	View
SIERRA	133	4,904	View
ACADIA	84	7,520	View
JIMMY	71	3,791	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 GMC SIERRA 3500

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2016 GMC SIERRA 3500

Safety Technology

Technical Service Bulletins, 2016 GMC SIERRA 3500

Most Affected Components

GMC SIERRA 3500 - All Years Overview

GMC SIERRA 3500 - Year by Year

Other GMC Models