2022 FORD RANGER Recalls, Complaints & Safety

What component or system failed or malfunctioned, and is it available for inspection upon request? Inspection available if needed. The ignition coils and spark plugs failed due to Ford’s negligence to provide an engine cover. Water has gotten in to the engine and caused these systems to fail How was your safety or the safety of others put at risk? The engine violently shakes and causes you to lose speed. I was going 20 under the limit on the highway due to this and could have caused an accident. The vehicle felt as if it was shutting off and I got off at the next available exit. It placed my family at risk and others as it could have caused a bad accident if someone would have rear ended me due to the slow speed. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, this is a known issue and Ford refuses to repair the vehicle and advises it is out of pocket. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by a repair facility. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The check engine light was flashing and then stayed solid. This first appeared on 1/27/26

Engine Valve Cover has Cracked. High Pressure Pump Seals and gaskets needed to be replaced. Confirmed by 2 dealerships It has been inspected No warning lamps messages.

Several occasions, pulling out into traffic and giving it gas the truck jerks repeatedly and won't go and then we'll kick into normal speed several times driving out of nowhere RPM shoot up truck almost comes to a complete stop in the middle of traffic but no Code is popping up saying there's anything wrong with the vehicle and in order to have Ford looking at it. It's gonna cost $399 since as of now there is no recall on anything for this.

I have developed severe chronic neck and back pain due to the shape and position of the headrests in this vehicle (as well as my wife’s 2024 Hyundai Kona). There is no position that does no cause pain, and I am forced to remove them entirely, or lean forward and not use them, causing a lack of support and different muscle tension. This has been confirmed by my physical therapist. Due to NHTSA requirements, I cannot buy a newer vehicle that does not cause this condition, nor even purchase aftermarket replacements. Being forced to drive without a headrest at all is much more dangerous than having a comfortable option. I have to drive a lot to work and shop because I live in the mountains. Please help. I’m one of millions with this problem.

99 injured

Wiper arm stops working or stays in up position. Intermittent issue.

The ACM (Audio Control Module) failed, causing a network failure in the CAN system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic warning. Additionally, while the turn signals worked, there was no inside audio or visual confirmation that it was functioning. Also no high beam headlight indicator and no automatic high-low beams. Cost of repair was $739.00 and the dealer had to order the part.

We where driving down the PA Turnpike Pike when the transmission began to shift between 8 and 9th gears. A wrench icon turned on. I pulled over and the transmission stayed stuck in 9th gear even when parked. I turned off the truck and opened the door which turned the ignition off. When I opened the door I heard a click from the transmission. Turned the truck back on and it ran normal and the wrench went away. I use a code reader at all times and was able to record the code. This occurred while overtaking another car and almost caused a multi car and semi accident.

While driving my 2022 Ford Ranger, the transmission failed to engage Drive. I started my morning as usual, letting the vehicle warm up and the RPMs settle before leaving my neighborhood. As I pulled onto the main road, the truck began acting strangely—I noticed it wasn’t accelerating normally and felt constant gear shifting without gaining speed. To avoid blocking traffic, I pulled over at a local store and shifted into Park. When I tried to shift back into Drive, the transmission would not engage. Pressing the gas felt like the truck was in Neutral. I turned the vehicle off for about a minute and restarted it, but the same issue occurred. I then called my local dealer, who suggested using Sport mode and manually selecting gear 2. This worked, and I was able to drive home safely since I was only about a minute away. After that, I contacted the warranty company and arranged for a tow. Component/System: Transmission Safety Risk: Loss of acceleration on a main road created a risk of collision with other vehicles. Reproduced/Confirmed: UNKNOWN until December 15th if the issue has been reproduced or confirmed by the dealer. Inspection: Dealer is scheduled to inspect the vehicle on December 15. Warning Lamps/Messages: None appeared prior to the failure. None After. Until repairs are completed, I am without a vehicle and will only be reimbursed for a rental while repairs are worked on

Started having issues with 10R80 transmission at 40k then a complete replacement at 53k, nothing but continued problems, now back at shop a week later for knocking and transmission.

The contact owns a 2022 Ford Ranger. The contact stated while driving on several occasions, the infotainment system screen turned black intermittently. Additionally, the contact stated that upon starting the vehicle and accelerating, the vehicle failed to accelerate as intended. The vehicle was taken to an unknown dealer on several occasions, but the failure could not be replicated. The vehicle was taken to AutoZone, where it was diagnosed that an unknown O2 sensor located behind the glove box, and the sensors connected to the catalytic converter had failed. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 300.

Harsh/Delayed Engagement and Harsh/Delayed Shifting from 3rd to 4th and sometimes 5th to 6th There's a Ford service bulletin out for this #25-2134 My truck was built on 08/26/2022 but this bulletin only covers trucks built before 08/15/2022 It occurs daily. My dealer tells me to live with it.

Truck cut off at an intersection without warning and would not turn back over. After multiple attempts and AAA service members checking batter car would not start. Has power but will not turn over dealership is saying there is a module issue but is not sure.

The contact owns a 2022 Ford Ranger equipped with Bridgestone Tires, Tire Line: Dueler HT685, Tire Size: 255/70/R16, DOT Number: 1VN0KDH2 3422. The contact stated that the driver’s side front inner tire was excessively worn. The contact noticed that the steel belts were showing through. The contact replaced the tire with a spare. There was no warning light illuminated. The vehicle was taken to an independent mechanic, who informed him that the alignment bolt s could not be adjusted. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The vehicle and tire failure mileage were approximately 38,000.

Five separate incidents where the truck suddenly accelerated to 4500 rpm while in drive. Usually at low speeds. Last incident occurred in driveway where the truck left skid marks on the pavers.

The contact owns a 2022 Ford Ranger. The contact stated while the vehicle was parked, the vehicle failed to start with the key in the ignition. The contact stated that the vehicle started after the battery was recharged. The contact was able to start the vehicle using the key instead of the key fob. The vehicle was taken to a local dealer to be diagnosed; however, no cause for the failure was found. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 14,000.

The contact owns a 2022 Ford Ranger. The contact stated while driving 2 MPH and exiting the driveway, the contact heard a loud bang coming from the vehicle. The contact stopped the vehicle and noticed that the rear windshield had fractured without impact. The vehicle was taken to the dealer. The contact was informed that the rear windshield was not defective. The contact was informed that the replacement of the windshield was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 27,000.

The contact owns a 2022 Ford Ranger. The contact stated while driving approximately 40 MPH, the vehicle was losing motive power. The contact depressed the accelerator pedal and the vehicle revved but failed to respond as needed. The contact stated that there were no warning lights illuminated. The contact came to a stop with the engine still running. The contact turned off and restarted the vehicle several times, but when the gear shifter was shifted into drive(D), the vehicle failed to respond. The contact had the vehicle towed to an independent mechanic who ran a scan on the vehicle and retrieved several transmission codes and referred the contact to a dealer for assistance. The contact had the vehicle towed to the dealer to be diagnosed. The diagnostic tests determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 80,000.

Went on a trip with the vehicle. When returning to home put the vehicle in the garage. Came out the next day and the Garage smelled like a gas can. Looked all around could not find signs of the gas. Got in the truck and was overwhelmed by gas smell. Moved the vehicle out of the garage. Googled the issue and found 170 pages of people with the same issue. The engine is filling with gas and overfilling the engine. Lots of people have taken vehicles to the dealer and ford is advising changing the oil more often and not drive short trips. This seems to be a possible fire hazard to me. If continued driving the gas will eventually come out and pour onto the hot engine resulting in a fire?

The trans mission just died on the middle of the road

The contact owns a 2022 Ford Ranger. The contact stated that the brake pedal and accelerator pedal were too close together. While driving at various speeds, the contact’s foot slid off the brake pedal onto the accelerator pedal and the vehicle lunged forward. While reversing, the vehicle automatically backed up, but after depressing the brake pedal, the vehicle jumped several feet. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 10,000.

The contact owns a 2022 Ford Ranger. The contact stated that while her son was driving at 40 MPH, he ran a red light at an intersection and T-boned another vehicle. The impact bent the frame into the front tires. The air bags did not deploy. There were no injuries, and medical attention was not received. A police report was filed. The vehicle was towed to the body shop; however, the vehicle was not diagnosed or repaired. The vehicle was not deemed totaled by the insurance company. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.

Crash

Modem cannot connect to update features nor use remote features.

Engine revolutions increased to 4500 rpm while waiting for a school bus to unload. Engine revolutions increased to 4500 rpm while waiting at intersection Engine increased to 4500 rpm’s while driving down road slowly in front of school. Safety of school children were put at risk in two of these instances. Dealer has not found code in computer to very incident and has not reproduced problem during road test. Dealer has had truck twice for a total of over three weeks. The dealer has not replaced any parts stating if code is not shown nothing will be replaced. No inspections of truck other than dealer, also no warnings. Problems first appeared in the first few hundred miles.

I purchased a new 2022 Ford Ranger it has 6000 miles. I had it back to the dealer twice it hesitate when taking off from start at red light- stop sign and entering highway this in my mind is a safety problem when a care/truck hesitate in traffic there seem a problem with there new ECO-BOOST engine/transmission my truck will return again on 8/1 for another service call for the same problem.

Had someone driving behind me flag me over. I had no tail lights, brake lights, turn signals front or rear or hazzard lights in the front or back. There is only 15,000kms on this truck. Head light low beam and high beam work. trying to get in contact with ford canada and a ford dealership. was scanned at a shop and showed multiple body control module faults and looks like a module. but not touching the vehicle as it has the max warranty they sell this vehicle is in nova scotia, but came from the michigan plant. it will not accept my canadian address

The contact owns a 2022 Ford Ranger. The contact stated while driving 35 MPH, the contact heard a clicking sound coming from the rear of the vehicle, but no warning light was illuminated. The contact pulled over on the side the roadway but found no failure with the rear of the vehicle. The vehicle was taken to the dealer, but no failure was found. The manufacturer was contacted but no assistance was provided. The failure mileage was 2,000.

I have experienced the transmission hunting for a proper gear, skipping gears while driving and, at times, hear a clunk when the gear is put into place.

The contact owns a 2022 Ford Ranger. The contact received notification of NHTSA Campaign Number: 22V685000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

The transmission and or converter on the vehicle continue to have harsh vibrations in all gears. The unit has a difficult time finding the right gear for the traveling speed. Some times accelerates slightly from a stopped position which requires excessive force on the brake. At highway speeds downshifts are very slow and sometimes not at all when trying to pass slower vehicles. Employee's refuse to drive this vehicle due to excessive vibration felt through the steering wheel and foot pedal's when coming to a stop. They don't feel that the vehicle is going to come to a stop. I would agree. It's as if the transmission does not start downshifting as the vehicle slows, and then drops into first very hard as the vehicle is coming to a stop. The vehicle started doing this at 220 miles and continues to get worse. It has been to the Dealer four times, with the first being a driveshaft shim placement to the driveshaft per a TSB. Second visit, the dealer states there is nothing wrong with the vehicle. Third visit, complete drive shaft and components replaced, with no remedy. Fourth visit, an engineer from Ford came to the dealership and determined there is nothing wrong with the vehicle. These problems have been occurring since the vehicle had 220 miles on it. The vehicle has 1700 miles and note being driven very much.

I bought a rack from a company called Carid.com. It was a Torxe Model 40-1001620 Adjustable Truck Bed Carrier With Bend Mount Kayak Surf Canoe 2-Bar. https://www.carid.com/torxe/adjustable-truck-bed-carrier-rack-mpn-40-1001620.html It came with about 60 undecipherable parts with no instructions. I asked the company for instructions and they were non-responsive for a week. Called them again. Some photos came, but it still did not explain how to put it together. Many of the pieces did not seem to fit where they logically looked like they would. I am a licensed architect with over 30 years of experience, and I would not even attempt to put this together without instructions, as it would potentially pose a safety hazard running down the road. The company is now stating I cannot return the product. Just thought I would let you know. It appears this is not a DOT safe product, as one would expect some instructions to come with it in order to insure it is properly assembled.

When coming to a stop at a stop sign or light and your foot is a little off on the brake pedal you can simultaneously hit the brake and the accelerator pedal causing the vehicle to not stopping properly. The brake pedal is closer to the floor board when applied than the accelerator pedal.

The lighting on the shift lever that shows what mode the transmission is being selected is missing. Apparently Ford stopped installing the lighting that lights the "Park, Reverse, Neutral, Drive" in the shifter beginning in 2021. This is a serious safety issue because at night, the driver cannot look down at determine what mode is being selected. The dealer stated to me the selected mode is in the driver console at night. I'm a 5'9" male and any time the wheel is turned or my hand in on the wheel, I cannot see the mode selected. I quickly realized this the first time I drove the vehicle at night, none of the lighting on the shifter was on. I thought it was broken! Basically Ford has skimped a few dollars and NOT installed internal night lighting on the lettering. A simple correction for this is require ford to install the lighting in the unit as a retrofit kit (basically put back what they stopped installing). This would not incur a great expense or time, however, this could PREVENT the driver from selecting the wrong mode causing abrupt forward or backward movement injuring another person or vehicle when moving the vehicle out of park, in particular, backing in or out of parking spots for example that require you to turn the vehicle (AKA WHEEL NOT CENTERED). If not requiring a recall, FORD should make this retrofit available to owners because as of right now, I was told there is none. I included a short video showing the impeded view of the shift mode selected on the driver panel when the steering wheel is being moved and not at wheel centered. At night, this would be the only lighted shifting reference. I also included a day photo of the same view, a view of an earlier 2020 ranger (that had the shifter lighting standard) and my 2022 ranger shifter at night with no lighting. The current standard equipment lighting presents a safety hazard and is directly related to the movement of the vehicle so the likelihood of injury or occurrence are both HIGH.

This vehicle is brand new. 250 miles. Seat belt warning indicator remains on for rear passenger side and will not clear. No one is in the seat. Tried buckling seat belt for rear passenger seat - warning cleared. Unbuckled and warning appears again and won't clear. There are no objects on the seat. Shut vehicle off and dismounted. Got back in and restarted vehicle. Seat belt warning indicator remains on for rear passenger side and will not clear. FORD has nothing documented for clearing this. Dealership will not acknowledge this and does not have a 'fix'. The resulting warning may now affect how safety/collision systems will operate in an actual collision.

I was stopped at a red light, not moving, and the rear window completely shattered, the entire window, except the small center slider.