2002 DODGE DAKOTA

12 recalls, 946 complaints - 64 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

SUSPENSION:FRONT:HUB

Defect Description

SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEE... Read more

Consequence

IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEH... Read more

Remedy

SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.

2,805 vehicles affected

Manufacturer: SKF USA, INC.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Defect Description

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY... Read more

Consequence

EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Remedy

DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

576,418 vehicles affected

Manufacturer: CHRYSLER LLC

EXTERIOR LIGHTING

Defect Description

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIAT... Read more

Consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy

AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

3,593 vehicles affected

Manufacturer: AJ MOTORSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

ENGINE AND ENGINE COOLING

Defect Description

CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999,... Read more

Consequence

A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.

Remedy

K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.

44,386 vehicles affected

Manufacturer: K&N ENGINEERING, INC.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE AR... Read more

Consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Remedy

AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.

7,291 vehicles affected

Manufacturer: AIRTEX PRODUCTS

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOI... Read more

Consequence

EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Remedy

DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

592,707 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

VISIBILITY:WINDSHIELD WIPER/WASHER

Defect Description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence

DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

320,188 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

EQUIPMENT:OTHER:LABELS

Defect Description

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence

IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Remedy

OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

35,692 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

ELECTRICAL SYSTEM:WIRING

Defect Description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.

Consequence

THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

50,082 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

Complaint Statistics

946 total complaints 71 crashes 23 fires 37 injuries 3 deaths

Top Reported Components

Component	Complaints
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT	162
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT	69
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	68
SERVICE BRAKES, HYDRAULIC	58
POWER TRAIN:AUTOMATIC TRANSMISSION	40
ELECTRICAL SYSTEM	39
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	28
SUSPENSION:FRONT	28
SERVICE BRAKES	25
POWER TRAIN	23

Incident date: Jul 21, 2025

While driving home from a shop, my Tesla Model Y suddenly stopped in middle of busy road and became unable to move forward. I had to press the accelerator hard, which caused a loud noise before the car moved slightly and I was able to pull over to side of road. I narrowly avoided being hit by anothe... Read more

Incident date: Jun 10, 2022

My 2002 Dodge Dakota sometime will not go into park. other times it will jump out and go into reverse. this has caused my vehicle to roll backwards and destroyed neighbors mailbox. to get it into park takes several tries. I now must use my parking brake anytime I am parked.

Crash

Incident date: Jun 10, 2022

Crash

Incident date: Apr 20, 2021

II HAVE REPLACE FRONT ROTORS, FRONT CALIPERS, REAR WHEEL CYLINDERS AND SHOES, THE BRAKES HAVE BEEN BLEED SEVERAL TIMES, AND BRAKE SYSTEM WAS LOOKED AT SEVERAL TIMES BY ASE MASTER MECHANIC. GOING DOWN THE ROAD ON THE INITIAL PUSH ON THE PEDDLE THE PEDDLE GOES MORE THAN HALF WAY DOWN TO THE FLOOR, YOU... Read more

Incident date: Jan 2, 2020

THIS 2001 DODGE DAKOTA COMES UP WITH CODE P0601 IT SAYS IT IS A MEMORY CHECK SUM ERROR. IT COMES ON INTERMITTENT IN COLD WEATHER. IF YOU CLEAR THE CODE IT MIGHT COME RIGHT BACK OR IT MIGHT STAY OFF IT IS ANNOYING SOMETIMES IT MESSES WITH THE ABS MAKING THE FRONT RIGHT BRAKE HANG UP

Incident date: Jan 2, 2020

Incident date: Apr 10, 2018

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHEN ATTEMPTING TO DRIVE THE VEHICLE, THE GEAR SHIFTER FAILED TO SHIFT OUT OF GEAR. WHEN THE SHIFTER FINALLY SHIFTED OUT OF GEAR AND INTO DRIVE, IT WOULD SHIFT BACK INTO PARK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO KEFFER CHRY... Read more

Incident date: Jan 25, 2019

THE CAR GOES INTO PARK, BUT PARK DOES NOT ENGAGE. I'M ABLE TO REMOVE THE KEY. THE COLUMN SHOWS PARK BUT THE CAR CONTINUES TO ROLL. I SEE THAT 2002 DAKOTAS HAVE A RECALL FOR THIS PROBLEM BUT MY VIN # DOESN'T SHOW A RECALL FOR THIS PROBLEM.

Incident date: Jan 25, 2019

Incident date: Dec 5, 2018

CENTRAL TIME MODULE CAUSING MY LIGHTS TO CUT OFF WHILE DRIVING COULD CAUSE ACCIDENT

Incident date: Dec 5, 2018

CENTRAL TIME MODULE CAUSING MY LIGHTS TO CUT OFF WHILE DRIVING COULD CAUSE ACCIDENT

Incident date: Dec 1, 2015

FRONT DRIVER SIDE TIRE AND HUB ASSEMBLY COMPLETELY BROKE FREE FROM THE VEHICLE THIS IS A FOLLOW UP FROM MY FIRST INTIAL REPORT TO CHRYSLER AND ALSO NHTSA PHONE CONVERSATION IN WHICH I DID A REPORT TO BOTH AND PAID 2500.00 WHICH I STILL HAVE RECEIPT OF PAYING TO HAVE FIXED...FATHER HAD A 2000 DODGE... Read more

Incident date: Jul 24, 2018

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO MOVE WITH OUT THE IGNITION BEING STARTED. THE CONTACT ALSO STATED THAT THE KEY COULD BE REMOVED FROM THE IGNITION AND THE VEHICLE COULD STILL BE MOVED OR PUSHED WITHOUT THE ENGINE BEING STARTED OR WITHOUT THE G... Read more

Incident date: Jul 24, 2018

Incident date: Oct 24, 2018

THIS IS THE SECOND TIME ONE OF THE BREAK LINES HAS RUSTED THRU. THIS TIME I HIT THE BRAKES HARD TO MISS TWO DEAR AND THE PEDAL WENT TO THE FLOOR. I ONLY COULD STOP THE TRUCK WITH THE EMERGENCY BREAK. THE TRUCK HAS NOT BEEN USED OFF ROAD AND HAS BEEN DRIVEN IN VIRGINIA IS HOLE LIFE. THE FIRST TIME MY... Read more

Incident date: Nov 16, 2017

RECALL G38 / THE TRANS SHIFTER STARTED TO NOT GO INTO PARK AT TIMES AND THEN SLIP OUT NOW IT WILL NOT GO INTO PARK AT ALL..SHIFTER STOPS AT REVERSE AND I HAVE LOOKED AT SHIFTER AJUSTMENT AND NO PROBLEM THERE, THE RECALL SAID IT DID NOT APPLY TO MY VIN .BUT I AM HAVING SAME PROBLEMS LISTED AS THE R... Read more

Incident date: Nov 16, 2017

Incident date: Apr 26, 2018

"TAKATA RECALL" HIGH BEAMS COME ON ON BOTH SIDES LOW BEAM DOES NOT COME ON PASSENGER SIDE BUT ON THE DRIVER SIDE

Incident date: Feb 23, 2018

THE LIGHTS STOOPED WORKING WIPER RELAY NOT FUNCTIONAL. VERY IRRITATING

Incident date: Sep 7, 2017

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING 50 MPH ON THE HIGHWAY, THE STEERING WHEEL SEIZED AND THE VEHICLE STALLED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO GALEANA'S VAN DYKE DODGE (28400 VAN DYKE AVE, WARREN, MI 48093... Read more

Incident date: Sep 7, 2017

Incident date: Jan 1, 2016

TAKATA RECALL - MY FATHER OWNED A 2005 DODGE DAKOTA TRUCK. ON JANUARY 1, 2016 HE RAN HIS CAR OFF THE SIDE OF THE ROAD AND HIT A LAMP POST OFF A HIGHWAY IN FLORIDA AND DIED ON IMPACT. THE CAR WAS TOTALLED OUT. I AM TRYING TO SEE IF WE QUALIFY FOR THIS RECALL. I DO NOT HAVE THE POLICE RECORD AND DEATH... Read more

Crash 1 deaths

Incident date: Mar 21, 2003

WATER LEAKING IN FLOOR BOARD. WATER WILL BE STANDING ABOUT AN INCH DEEP. CHECK TSB #2301004. IT LEAKS EVERYTIME IT RAINS. DODGE KNOWS ABOUT THE PROBLEM BUT THEY HAVEN'T DONE A RECALL.

Incident date: Jun 30, 2017

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING 45 MPH, THE BACK PART OF THE SEAT FRAME FAILED TO STAY UPWARD WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 186,000.

Incident date: Jul 5, 2016

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS APPLIED AND BEGAN TO GRIND AND SQUEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE BRAKE CALIPER AND BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, B... Read more

Incident date: Apr 9, 2017

RECALL WAS DRIVING AND ALL OF MY BREAKS AND CALIBERS SEIZED UP..HAD TO STOP AND SPRAY THEM DOWN

Incident date: Apr 9, 2017

RECALL WAS DRIVING AND ALL OF MY BREAKS AND CALIBERS SEIZED UP..HAD TO STOP AND SPRAY THEM DOWN

Incident date: Apr 9, 2017

RECALL WAS DRIVING AND ALL OF MY BREAKS AND CALIBERS SEIZED UP..HAD TO STOP AND SPRAY THEM DOWN

Incident date: Jan 2, 2017

LIGHT ON AIR BAG

Incident date: Dec 15, 2016

, I WAS IN A CAR ACCIDENT ON DECEMBER 15 BECAUSE MY BRAKES FAILED AND WAS HURT ACROSS MY CHEST. THE IMPACT WAS STRONG BECAUSE FOR A MOMENT I LOST TIME, BUT THE HOSPITAL DIDN'T GIVE ANY BRAIN SCANS. MY CHEST HURT SEVERELY FOR A MONTH AND I STILL FEEL PAIN WHEN I LIFT OR MOVE A CERTAIN WAY. ANYWAY I A... Read more

Crash 1 injured

Incident date: Sep 1, 2016

THE BODY CONTROL MODULE HAS FAILED, WHICH CONTROLS ALL THE INTERIOR LIGHTS AND THE HEADLIGHTS. AS OF A MONTH AGO THERE WERE OVER 150 PEOPLE WAITING ON THIS PART IN CHRYSLER'S SYSTEM. CHRYSLER HAS NOW INFORMED ME THIS PART IS NO LONGER AVAILABLE AND WILL NOT BE MADE AGAIN, WHICH RENDERS MY TRUCK ONLY... Read more

Incident date: Dec 28, 2016

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE ENTIRE REAR STEP BUMPER WAS CORRODED. WHILE DRIVING APPROXIMATELY 60 MPH, THE DRIVER'S SIDE PORTION BAR FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FA... Read more

Incident date: Dec 28, 2016

Incident date: Dec 1, 2016

MY TRUCK WILL NOT GO INTO PARK ALL OTHER GEAR SELECTIONS ARE AVAILABLE BUT NO PARK. ADDITIONALLY I'M ABLE TO TURN THE KEY BACK TO THE OFF POSITION & TAKE THE KEY OUT. I PULLED INTO WORK & WAS UNABLE ONCE I PULLED INTO A PARKING PLACE TO PUT MY TRUCK INTO PARK. I ENDED UP HAVING TO STAY WITH MY VEHIC... Read more

Incident date: Dec 1, 2016

Incident date: Jul 20, 2014

I BOUGHT THE SUBJECT PICKUP IN 2014, I FOUND AFTER DRIVING IT THAT THE ENGINE WOULD LOSE POWER, WOULDN'T IDLE SMOOTHLY, AND IT WOULD BACKFIRE THRU THE THROTTLE BODY ELECTRONIC FUEL INJECTION. THE PROBLEM WAS AND IS INTERMITTENT, IT SOMETIMES HAPPENS WHEN PULLING INTO TRAFFIC, MAKING ME TRYING TO PUL... Read more

Incident date: Mar 10, 2016

BOUGHT A 2002 DODGE DAKOTA BRAKES AREN'T STRONG ENOUGH TO DRIVE ON INTERSTATE OR IN CITY , WENT TO DODGE DARCARS DEALERSHIP IN MARYLAND THEY LOOKED AT THE TRUCK , SAID THIS IS FINE THIS IS THE WAY DODGE BRAKES ARE TERRIBLY WRONG . WENT TO REPAIR THE EMERGENCY BRAKE CABLES DODGE DON'T MAKE THE PARTS ... Read more

Incident date: Feb 12, 2016

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. ON SEVERAL OCCASIONS, THE VEHICLE FAILED TO DISENGAGE FROM THE PARK POSITION. THE CONTACT ALSO STATED THAT, WHEN PLACED IN PARK POSITION, THE VEHICLE WOULD ROLL FORWARDS OR BACKWARDS ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER... Read more

Incident date: Nov 5, 2015

TL* THE CONTACT OWNED A 2002 DODGE DAKOTA. WHILE DRIVING 50 MPH, THE CONTACT WAS INVOLVED IN A CRASH THAT CAUSED THE DRIVER SIDE DOOR TO FLY OPEN. THE CONTACT SUFFERED A BROKEN LEG, SEVERAL BROKEN RIBS, AND BRUISES TO THE BODY. THE PASSENGER SUFFERED A BROKEN ARM. MEDICAL ATTENTION WAS REQUIRED. A P... Read more

Crash 2 injured

Incident date: Dec 19, 2015

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE ATTEMPTING TO SHIFT THE GEAR FROM PARK TO DRIVE, THE SHIFTER JAMMED. THE FAILURE RECURRED INTERMITTENLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Incident date: Nov 21, 2015

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO PARK. THE CONTACT HAD TO ENGAGE THE EMERGENCY BRAKE IN ORDER TO PREVENT THE VEHICLE FROM ROLLING AWAY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE V... Read more

Incident date: Sep 11, 2015

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE VEHICLE WAS UNABLE TO BE SHIFTED OUT OF PARK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED IN 2008 UNDER NHTSA CAMPAIGN NUMBER: 07V555000 (POWER TRAIN), BUT TH... Read more

Incident date: Jun 30, 2015

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE BRAKES SEIZED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE WHERE THE BRAKE WAS LOCATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT ME... Read more

Fire

Incident date: Jul 1, 2015

TL* THE CONTACT OWNS A 2002 DODGE DAKOTA. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE ENTIRE SUBFRAME UNDERNEATH THE VEHICLE WAS CORRODED AND THERE WERE FRACTURES IN FRONT OF THE SUBFRAME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAI... Read more

Incident date: Apr 14, 2015

I WAS DRIVING AND THE LIGHTS STARTED FLASHING AND THEN THEY WENT ALL THE WAY OUT AND THE DOME LIGHT AND KEYLESS ENTRY ISN'T WORKING. IT FINALLY WOULDN'T START AND SO WE BOUGHT A NEW BATTERY, AND THE LIGHTS CAME ON AND THEN THE NEXT DAY THE LIGHTS WERE OFF AGAIN. THE BATTERY THAT WAS IN THE TRUCK WAS... Read more

Incident date: Apr 14, 2015

Incident date: Oct 3, 2014

I HAD JUST PURCHASED THE CAR 2 WEEKS EARLIER. I WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND THE ACCELERATOR STUCK AT 60 MPH. NO MATTER WHAT I DID TO THE PEDAL, IT WAS STUCK AT 60 MPH. THE BRAKES WOULD NOT WORK EITHER. I WAS IN A RUNAWAY CAR ON A BUSY FREEWAY. I TRIED TO NEGOTIATE THE TRAFFIC FOR... Read more

Crash 1 injured

Incident date: Oct 14, 2014

RACK AND PINION SEAL BUSTED WHILE DRIVING AT SOME POINT RESULTING IN LOSS OF POWER STEERING FLUID. *TR

Showing 50 of 946 complaints.

Technical Service Bulletins, 2002 DODGE DAKOTA

64 manufacturer communications from 50 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	12
160000 STRUCTURE	10
110000 ELECTRICAL SYSTEM	5
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	5
100000 POWER TRAIN	5
980000 UNKNOWN OR OTHER	3
162000 STRUCTURE:BODY	2
135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR	2

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

160000 STRUCTURE

Disinfectant Solution Recommended for COVID-19

350000 EQUIPMENT

Disinfectant Solution Recommended for COVID-19

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

030000 BRAKES (PWS)

ABS Brake Module Code 82 and 83 Setting Within The Brake Module

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

060000 ENGINE AND ENGINE COOLING

Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. C

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

160000 STRUCTURE

Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacemen

160000 STRUCTURE

Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253

350000 EQUIPMENT

160000 STRUCTURE

350000 EQUIPMENT

160000 STRUCTURE

350000 EQUIPMENT

100000 POWER TRAIN

Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.

356000 EQUIPMENT ADAPTIVE/MOBILITY

56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch

350000 EQUIPMENT

56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch

100000 POWER TRAIN

56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch

116100 ELECTRICAL SYSTEM:IGNITION:SWITCH

56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

POWERTRAIN CONTROL MODULE INITIALIZATION. *KB

100000 POWER TRAIN

45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT. *SC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

POWERTRAIN CONTROL MODULE INITIALIZATION. *SC

020000 SUSPENSION

UPPER BALL JOINT EXTENDED WARRANTY. *TT

162000 STRUCTURE:BODY

PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT

180000 VEHICLE SPEED CONTROL

IDLE FLUCTUATION WHILE TURNING. *TT

110000 ELECTRICAL SYSTEM

INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT

162000 STRUCTURE:BODY

DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER. *TT

100000 POWER TRAIN

CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS.

330000 INTERIOR LIGHTING

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION OF A SMALL LEAK IN THE VEHICLE'S EVAPORATIVE SYSTEM. *TT

100000 POWER TRAIN

CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS. *TT

071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

FUEL CAP DIFFICULT TO REMOVE. *TT

012000 STEERING:COLUMN

STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT

980000 UNKNOWN OR OTHER

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

980000 UNKNOWN OR OTHER

SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR ERRONEOUS DIAGNOSTIC TROUBLE CODE P0456, EVAP MONITOR SMALL LEAK DETECTED. *SLC

071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING 4.7L CRANKSHAFT TO BEDPLATE INTERFERENCE. *SLC

350000 EQUIPMENT

MISSING TONNEAU COVER. *SLC

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC

980000 UNKNOWN OR OTHER

CHROME WHEEL CARE. *SLC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

RAPID REPONSE TRANSMITTAL REGARDING TRANSMISSION FILLER TUBE RATTLE CONDITION. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A TRANSMISSION FILLER TUBE RATTLE CONDITION. *TT

035000 SERVICE BRAKES, HYDRAULIC:FLUID

SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC

015300 STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID

INFORMATION ON NEW POWER STEERING FLUID.*SLC

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

350000 EQUIPMENT

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ

NHTSA Safety Investigations, DODGE DAKOTA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2006

Clutch Interlock Switch Malfunction

On December 16, 2104, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the clutch ignition interlock switches in approximately 66,819 model year (MY) 2006 through early-2007 Dodge Ram Trucks, Dodge Dakota, and Mitsubishi Raider vehicles equipped with manual transmi... ssions and built between July 1, 2005 and July 31, 2006 (NHTSA Recall No. 14V-795, Chrysler Recall No. P80), including 38,969 MY 2006 Dodge Ram 2500 and 3500 vehicles that are part of the subject vehicle population for PE14-013.Chrysler's Safety Report states that:1) the clutch ignition interlock switch return springs may experience fatigue failure due to material issues; 2) if the return springs are broken, the switch contacts may not reflect actual clutch pedal position; and 3) the failures could result in a vehicle experiencing unintended movement if the ignition is cranked when the clutch pedal is not being pressed.Chrysler's recall remedy will replace the clutch ignition interlock switch on all affected vehicles with a switch with a more robust design.On May 19, 2014, ODI opened PE14-013 to investigate clutch ignition interlock failure in MY 2004 through 2006 Dodge Ram 2500 and 3500 trucks with manual transmissions, based on two MY 2006 complaints and one MY 2004 complaint.One of the MY 2006 complaints involved a fatality that occurred when a young child was able to start a MY 2006 Ram 3500 truck that was parked with the transmission in gear, without depressing the clutch.The diesel engine started and the vehicle moved forward under power running over another child resulting in fatal injuries.ODI's analysis of failure data from all sources identified a total of 14 complaints and 16 warranty claims for the subject vehicles.Thirteen (13) of the complaints and all 16 warranty claims were for the 38,969 MY 2006 Dodge Ram 2500 and 3500 trucks that were included in 14V-795.The single complaint that was outside the scope of Chrysler's recall was the MY 2004 ODI complaint identified in the opening resume for PE14-013.Further analysis of this incident indicates that the cause of the clutch switch failure in this vehicle was spring damage caused by hydraulic fluid leakage from the clutch master cylinder into the switch.The field data did not show any other similar incidents of switch failures caused by clutch master cylinder leakage. This investigation is closed based on Chrysler's recall.Read more

EA, Open , Model Year: 2005

STEERING WHEEL AND STEERING SHAFT BOLTS

ON MARCH 9, 2006 ODI UPGRADED PRELIMINATRY EVALUATION PE05-056 TO ENGINEERNING ANALYSIS EA06-004 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING SHAFT COUPLING BOLTS AND STEERING COLUMN RETAINING BOLTS IN MODEL YEAR (MY) 2004 THROUGH 2006 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 THRO... Read more

PE, Closed , Model Year: 2005

STEERING WHEEL AND SHAFT BOLTS

ON OCTOBER 26, 2005 ODI OPENED PE05-056 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING WHEEL OR STEERING SHAFT COUPLING BOLTS IN MODEL YEAR (MY) 2004 AND 2005 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 DODGE DAKOTA PICKUP TRUCKS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION (DCC).DURING... Read more

EA, Closed , Model Year: 1997

UPPER BALL JOINT SEPARATION

DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANT... Read more

DP, Closed , Model Year: 1995

FRAME CRACKS

MR. EDWARD W. BAILEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION BY LETTER, UNDATED, REQUESTING THAT AN INVESTIGATION BE CONDUCTED INTO THE MATTER OF A FRAME CRACK IN HIS 1995 DODGE DAKOTA TRUCK.THE PETITIONER ALLEGES THAT THE FRAME ON THE PASSENGER SIDE OF THE VEHICLE... Read more

EA, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE

ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.

PE, Closed , Model Year: 2000

STOP LAMP SWITCH

ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE

PE, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE DISENGAGEMEN

ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS

RQ, Open , Model Year: 1994

STEERING WHEEL AND COLUMN