1994 DODGE DAKOTA

4 recalls, 240 complaints - 45 TSBs

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

STEERING: STEERING WHEEL/HANDLE BAR

Defect Description

WHILE MAKING A TURN, THE EXTRA KEYS ON A VEHICLE OPERATOR'S KEY RING CAN BECOME TEMPORARILY LODGED IN THE SCREW ACCESS HOLES IN THE BACK COVER OF THE STEERING WHEEL.

Consequence

THIS CONDITION CAN HAMPER THE STEERING WHEEL RETURN ORCAUSE THE IGNITION TO BE TURNED OFF, RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy

DEALERS WILL REPLACE THE STEERING WHEEL BACK COVER WITH A REDESIGNED COVER.

293,043 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SUSPENSION:FRONT:CONTROL ARM

Defect Description

SOME UPPER CONTROL ARM ATTACHING BOLTS CAN FAIL DUE TO IMPROPER HEAT TREATMENT. THE BOLTS ARE TOO SOFT TO WITHSTAND THE STRESSES IN THE STEERING SYSTEM AND CAN BREAK.

Consequence

IF THE ATTACHING BOLTS OF THE UPPER CONTROL ARM BREAK, THE VEHICLE CAN EXPERIENCE LOSS OF STEERING CONTROL WHICH COULD RESULT IN AN ACCIDENT.

Remedy

REPLACE THE UPPER CONTROL ARM ATTACHING BOLTS.

1,500 vehicles affected

Manufacturer: CHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Defect Description

TWO FUEL TANK SUPPORT STRAP ATTACHING STUDS WERE NOT ADEQUATELY TIGHTENED, WHICH COULD CAUSE ONE OR BOTH OF THE STRAP(S) TO SEPARATE, MISLOCATING THE FUEL TANKS OR ALLOW COMPLETE SEPARATION OF THE FUEL TANK FROM THE VEHICLE.

Consequence

IN EITHER CASE FUEL TANK SUPPORT STRAP(S) FAILURE RESULTS IN FUEL LEAKAGE WHICH COULD RESULT IN A FIRE.

Remedy

THE FUEL TANK SUPPORT STRAP ATTACHING STUDS WILL BE PROPERLY TIGHTENED.

9,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

Complaint Statistics

240 total complaints 44 crashes 4 fires 29 injuries 2 deaths

Top Reported Components

Component	Complaints
STEERING: STEERING WHEEL/HANDLE BAR	18
AIR BAGS:FRONTAL	16
POWER TRAIN:AUTOMATIC TRANSMISSION	13
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	13
SEATS:FRONT ASSEMBLY:RECLINER	8
ELECTRICAL SYSTEM:IGNITION	7
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	7
AIR BAGS	7
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	6
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	5

Incident date: Jan 1, 2007

FRONT LEFT DOOR SNAPPED OFF. I CAN'T OPEN THE DRIVERS DOOR FROM THE INSIDE. ALSO, BOTH SEAT BELTS SNAPPED, THE AIR AND HEAT DOESN'T WORK, THE BRAKES LOCKED UP, WHICH AFFECTED THE STEERING. THE TRANSMISSION WAS REPLACED THREE TIMED, THE VEHICLE WOULD LOOSE POWER AND THE ENGINE WOULD DIE. THE CATALYTI... Read more

Incident date: Jan 1, 2007

Incident date: Oct 10, 2010

DODGE DAKOTA FRAME ROTTING OUT TOYOTA RECALLED THEIRS THE TRUCK IN GREAT SHAPE AND I HAVE SEEN ALOT OF TRUCKS WITH THE SAME PROBLEM COULD CAUSE DEATH IN CRASH.*TR

Incident date: Oct 22, 2010

DRIVING DOWN ROAD, ABOUT TO TURN RIGHT, BUT AIRBAG DEPLOYED BEFORE I WAS OFF THE MAIN ROAD. HAD TO STOP IMMEDIATELY. HAD SLOWED DOWN TO APP. 10 MPH TO MAKE TURN. ROAD CLEAR. HAD MADE THIS TURN MANY TIMES BEFORE (ON WAY TO WORK). *TR

Incident date: Nov 1, 2006

NIGHT DRIVING, SMELLED ELECTRICAL SMOKE IN CAB. HEADLAMPS WENT OFF THEN CAME BACK ON AFTER 5 TO 10 SECONDS. MOVED HEADLAMP SWITCH IN AND OUT BUT CONDITION STILL PERSISTED. LUCKILY I WAS LESS THAN ONE MILE FROM HOME ON DIVIDED HWY WITH NO TRAFFIC. IF LAMP SWITCH IS OFF THEN THERE IS NO SMELL OF ELECT... Read more

Incident date: Oct 22, 2006

DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH, THE VEHICLE WAS INVOLVED IN DRIVER SIDE COLLISION. THE AIRBAGS DID NOT DEPLOY. THERE WAS PRE-IMPACT BRAKING. THE OCCUPANT WAS WEARING A SEAT BELT, BUT SUFFERED OF HYPERTHERMIA DUE TO THE ACCIDENT. A POLICE REPORT WAS TAKEN, AND THE VEHICLE WAS DEEME... Read more

Crash 1 injured

Incident date: May 20, 2005

FRONT SEAT BOLT-DRIVER SIDE BROKE WITH SEAT GOING STRAIGHT BACK INTO BACK SEAT-REACHING FOR WALLET BOTH TIMES IT BROKE!

Incident date: May 20, 2005

FRONT SEAT BOLT-DRIVER SIDE BROKE WITH SEAT GOING STRAIGHT BACK INTO BACK SEAT-REACHING FOR WALLET BOTH TIMES IT BROKE!

Incident date: Apr 27, 2005

NO FAILURE JUST YET. EVERY SO OFTEN THE AIR BAG, ABS LIGHT COMES ON ONCE THAT HAPPENS THE FAN STOPS WORKING, THE POWER WINDOWS WILL NOT WORK. NOW MY HEADLIGHTS WILL NOT WORK AT ALL BUT MY PARKING LIGHTS WILL. I HAVE TRIED TO GET THE DEALER TO FIX IT UNDER A RECALL THEY WON'T DO IT. I KNOW IT COULD ... Read more

Incident date: May 14, 2005

SUDDEN NEAR-COMPLETE BRAKE FAILURE DUE TO DEFECTIVE BOLT HOLDING MASTER CYLINDER IN PLACE TO HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR. ON 05-14-2005, MY 18 YEAR OLD SON COMPLETED HIS SHIFT AT WORK. HE WENT OUT TO OUR 1994 DODGE DAKOTA PICKUP AND STARTED THE ENGINE. AS HE DEPRESSED THE BRAKE... Read more

Incident date: Dec 15, 2004

I HAVE A "PRISTINE" DODGE DAKOTA THAT I PURCHASED FROM THE ORIGINAL OWNER. IT CURRENTLY HAS 34,500 MILES ON IT AND I RECENTLY HAD TO REPLACE ALL OF THE BALL-JOINTS/ UPPER & LOWER/BOTH SIDES. I HAVE HEARD OF RECALLS FOR DAKOTA BALL-JOINTS. DID ANY OF THE RECALLS COVER A 1994 MODEL ? - PLEASE ADVISE. ... Read more

Incident date: Dec 15, 2004

Incident date: Jul 10, 2002

DRIVING DOWN THE ROAD AND LOWER BALL JOINT ON RIGHT SIDE OF TRUCK BROKE . DID NOT WRECK. WHEEL FELL OFF OF TRUCK ALONG WITH AXLE END, BRAKE ROTOR AND CALIPER. SPINDLE ALSO BROKE . I HAVE ALREADY REPLACED SPINDLE AND AXLE BUT HAVE NOT YET PUT ALL BACK TOGETHER BECAUSE IM TRYING TO SEE IF MY TRUCK ... Read more

Incident date: Oct 28, 2004

SRS AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CRUISE CONTROL FAILED TO WORK WHEN APPLIED. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. THIS VEHICLE WAS NOT COVERED UNDER A RECALL DUE TO VIN. *AK *TC

Incident date: Oct 28, 2004

Incident date: Sep 19, 2004

WHILE DRIVING 40 MPH A DEER APPEAR OUT OF NO WHERE AND WAS HIT BY CONSUMER'S VEHICLE. IT WAS BADLY DAMAGED AND KNOCKED OFF THE ROAD. UPON IMPACT, DRIVER'S AIR BAG FAILED TO DEPLOY. STEERING WHEEL SEPARATED AND CAUSED SEVERE DAMAGE TO DRIVER'S RIGHT LEG. DRIVER WAS HOSPITALIZED. VEHICLE HAD ... Read more

Crash 1 injured

Incident date: Sep 19, 2004

Crash 1 injured

Incident date: Nov 15, 2001

PAINT PEELING OFF OF ROOF AND HOOD.

Incident date: Jan 15, 2004

WHILE AT A STOP VEHICLE WAS REAR ENDED, CAUSING THE DRIVER'S SEAT TO RECLINE BACK. *AK

Crash

Incident date: Dec 10, 2003

WHILE WAITING AT AN INTERSECTION VEHICLE WAS REAR ENDED. THIS CAUSED THE DRIVER'S SEAT TO COLLAPSE BACKWARDS. DRIVER SUSTAINED INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL . *AK

Crash 1 injured

Incident date: Dec 10, 2003

WHILE WAITING AT AN INTERSECTION VEHICLE WAS REAR ENDED. THIS CAUSED THE DRIVER'S SEAT TO COLLAPSE BACKWARDS. DRIVER SUSTAINED NECK INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. *AK

Crash 1 injured

Incident date: Jul 3, 2003

I HAVE HAD TO PURCHASE AT LEAST 3 GAS FUEL PUMPS FOR MY 94 DODGE DAKOTA FOR THREE YEARS IN A ROW. I'VE TAKEN IT TO THE DODGE DEALER EACH TIME AN IT SEEMS TO BE THE SAME PROBLEM EVERY TIME. I ONLY USE ONE GAS STATION WHEN I'M NOT TRAVELING AND JUST IN MY NEIGHBORHOOD . I HAVE USED THE SAME TYPE OF GA... Read more

Incident date: May 18, 2003

WHEN THE CONSUMER ATTEMPTED TO EXIT THE VEHICLE THE FRONT SEAT BELT BUCKLE FAILED TO RELEASE. THE CONSUMER WAS FORCED TO CUT THE SEAT BELT IN ORDER TO EXIT THE TRUCK. *JB *CB *NLM

THE TRANSMISSION SHIFTED IMPROPERLY. THE CONSUMER CHANGED THE TRANSMISSION FLUID, AND THE TRANSMISSION SEIZED UP, DUE TO WRONG INFORMATION PRINTED ON THE DIP STICK. *JB

Incident date: Mar 2, 2003

WHEN THE CONSUMER STOPPED THE VEHICLE, THE DRIVER SIDE SEAT BELT CAME APART. *JB

Incident date: Nov 10, 2001

NO SUMMARY. DT

SEVERAL MONTHS TO A YEAR, A MODULE IN THE STEERING COLUMN NEEDS TO BE REPLACED. THIS MODULE CONTROLS THE HEADLIGHTS HIGH/LOW BEAM, TURN SIGNAL, 4-WAY FLASHER AND WIPER MOTION. THE HEADLIGHTS WILL GO OUT WHILE IN USE FOLLOWING THE OTHER COMPONENTS FAILING. PLEASE DESCRIBE DETAILS TS

Incident date: Feb 3, 2002

FUEL GAUGE READING VERY ERRATIC. DEALER CHECKED WIRING FROM TANK TO GAUGE AND FOUND NO SHORTED WIRING. ALSO CHECKED OPERATIONS AND FOUND FUEL SENDING UNIT IN TANK HAS CONTACTS SHORTED CAUSING GAUGE TO READ VERY ERRATIC. THIS IS 5TH TIME SENDING WILL BE REPLACED. *TT

Incident date: Apr 26, 2002

WHILE MAKING A TURN AT 5 MPH DRIVER'S AIRBAG DEPLOYED. CONSUMER SUSTAINED INJURIES TO HER FACE AND LOST HER VOICE FOR 2 WEEKS DUE TO INHALING FUMES.*AK DEALER REPLACED AIRBAG, STEERING WHEEL AND CRUISE CONTROL AND STATED THAT THE CLOCKSPRING WAS CAUSE OF THE AIRBAG TO DEPLOY. *TT

1 injured

Incident date: Aug 15, 1998

CONSUMER STATES THAT THE FUEL PUMP AND FUEL FLOAT FAILED. *TT

Incident date: Aug 15, 1998

CONSUMER STATES THAT THE FUEL PUMP AND FUEL FLOAT FAILED. *TT

Incident date: Oct 15, 2001

CONSUMER STATES THAT THE POWER SUPPLY TO THE MAIN COMPUTER FAILED POSSIBLY CAUSING A FIRE UNDER THE DASH, ENTIRE CAB CAUGHT ON FIRE. *TT

Fire

Incident date: Nov 5, 2001

CONSUMERS VEHICLE WAS TRAVELING ABOUT 20MPH COMING OFF A RAMP INTO SURFACE STREET, ANOTHER VEHICLE IN FRONT OF CONSUMERS VEHICLE HAD TO STOP, BUT CONSUMERS VEHICLE WOULD NOT STOP, AND HIT THE OTHER VEHICLE FROM BEHIND. *AK *SLC

Crash

Incident date: Mar 25, 2001

VEHICLE WAS PARKED, ENGINE OFF, PARK BRAKE NOT APPLIED. VEHICLE JUMPED OUT OF PARK INTO DRIVE AND ROLLED FORWARD ON A SLIGHT DOWN GRADE. CONSUMER WAS ABLE TO JUMP IN, APPLIED PARK BRAKE, AND STOPPED VEHICLE. DAMAGE WAS $ 3000.00, NO INJURIES.*AK

Crash

Incident date: May 10, 2001

FRONT PASSENGER SEAT BELT BUCKLE RELEASE BUTTON FAILED TO OPERATE, WILL NOT DISCONNECT THE LATCH. CHILD HAD TO TWIST OUT OF THE SEAT BELT TO GET FREE. MANUFACTURER WAS NOTIFIED, AND UNWILLING TO ASSIST. STATED THAT VEHICLE WAS OUT OF ITS WARRANTY, AND NOT COVER UNDER A RECALL. PROVIDE ANY FURTHER... Read more

HAD CHILD IN REAR MIDDLE/REAR FACING WHEN BRAKES WERE APPLIED, AND PLASTIC LAP BUCKLE BROKE AND RELEASED LAP BELT. CHILD SEAT NOT RESTRAINED. CAME FORWARD WITH CHILD IN IT AND HIT DASHBOARD. HAD CONTACTED DEALERSHIP, INFORMED CONSUMER THAT SEAT BELTS ONLY WARRANTY UP TO 3,000 MILES. *AK

Incident date: May 2, 2000

THIS IS THE 2ND DODGE TRUCK TRANSMISSION I HAVE HAD TO REPLACE THE OTHER WAS A 96 RAM WITH 63,000 AND I WAS TOLD THERE HAS BEEN A PROBLEM WITH DODGE TRUCK TRANSMISSIONS AS THE PLACES I TOOK THE 94 DAKOTA THERE WERE 2 IN FOR THE SAME THING ONE WAS A 1999 RAM. *AK

Incident date: Jan 15, 1998

DEALER REFUSED TO DO APPLICABLE TEST TO SEE IF TSB WAS WARRANTED PRIOR TO TRANSMISSION FAILURE. WHEN TRANSMISSION BEGAN TO FAIL DODGE ONLY OFFERED TO PAY HALF OF COSTS AND LATER RENEGED ON THAT OFFER. *AK

THE TRUCK POPS OUT OF O/D INTO DRIVE AND SLOWS DOWN THE VEIHICLE DRASTICALLY. THIS COULD CAUSE A SERIOUS ACCIDENT WHEN TRAVELING AT 55-70 MPH. IT HAS DONE THIS ABOUT 6 TIMES TO ME AND IT JUST STARTED WITH MY BOSSES 1998 2 WD DAKOTA. IT REALLY SCARES TH

BOTH FRONT DISC BRAKE ROTORS ARE PITTED, APPEARS TO BE CORROSION, SUCH AS FROM ROAD SALTS, ETC. PREVIOUSLY OWNED FORD TAURUS WHICH WAS RECALLED. ALSO LEARNED THE CHRYSLER RECALLED OTHER MODELS (NHTSA RECALL NO 98V005/CHRYSLER RECALL #747. NOT CERTAIN OF EXACT DATE WHEN CORROSION WOULD HAVE FIRST ... Read more

Showing 50 of 240 complaints.

Technical Service Bulletins, 1994 DODGE DAKOTA

45 manufacturer communications from 39 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	3
110000 ELECTRICAL SYSTEM	3
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	3
145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY	3
116000 ELECTRICAL SYSTEM:IGNITION	2
220000 SEATS	2
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	2
350000 EQUIPMENT	2

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

350000 EQUIPMENT

Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacemen

160000 STRUCTURE

350000 EQUIPMENT

160000 STRUCTURE

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

FRAME CRACKING. *TT

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB

140000 AIR BAGS

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT

114000 ELECTRICAL SYSTEM:WIRING

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT

162000 STRUCTURE:BODY

SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT

220000 SEATS

INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

INFORMATION REGARDING FRONT BRAKE CALIPER MOUNTING TO STEERING KNUCKLE THREAD REPAIR. *TT

116000 ELECTRICAL SYSTEM:IGNITION

SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

THE OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE AND BREAK. *YC

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

THE OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE AND BREAK. *YC

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DISCUSSION ON AIRBAG ON- OFF SWITCHES FOR SELECTED VEHICLES *AK

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK

140000 AIR BAGS

AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC

110000 ELECTRICAL SYSTEM

INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONCERNS WITH A/C EVAPORATOR ODOR. *NLM

061000 ENGINE AND ENGINE COOLING:ENGINE

TIMING CHAIN NOISE. *TW

190000 TIRES

INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

COLD SAG/HESITATION. *TW

116000 ELECTRICAL SYSTEM:IGNITION

INFORMATION REGARDING NO START - ENGIN FAILED TO CRANK. *NLM

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

WHEN VEHICLES IN THE START POSITION, ENGINE WILL NOT CRANK OVER. *YC

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC

060000 ENGINE AND ENGINE COOLING

CONCERNS WITH ENGINE COOLANT USAGE. *NLM

102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION ON TRANSMISSION COOLER REVERSE FLUSHING WITH COOLER BYPASS KIT INSTALLED. *NLM

161000 STRUCTURE:FRAME AND MEMBERS

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW

180000 VEHICLE SPEED CONTROL

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPER

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

UNKNOWN

011000 STEERING: STEERING WHEEL/HANDLE BAR

UNKNOWN

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

UNKNOWN

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

RWD AUTOMATIC TRANSMISSION COLD TEMPERATURE COOLER BYPASS KIT. *TW

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

SLIGHT FRONT BRAKE LEAD/DRIFT. *TW

173100 LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

PICK UP BOX TAILGATE HARD TO LATCH IN COLD TEMPERATURES. *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

OIL LEAK DIAGNOSIS OF THE REAR MAIN BEARING AREA. *TW

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

COOLING FAN NOISE. *TW

NHTSA Safety Investigations, DODGE DAKOTA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2006

Clutch Interlock Switch Malfunction

On December 16, 2104, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the clutch ignition interlock switches in approximately 66,819 model year (MY) 2006 through early-2007 Dodge Ram Trucks, Dodge Dakota, and Mitsubishi Raider vehicles equipped with manual transmi... ssions and built between July 1, 2005 and July 31, 2006 (NHTSA Recall No. 14V-795, Chrysler Recall No. P80), including 38,969 MY 2006 Dodge Ram 2500 and 3500 vehicles that are part of the subject vehicle population for PE14-013.Chrysler's Safety Report states that:1) the clutch ignition interlock switch return springs may experience fatigue failure due to material issues; 2) if the return springs are broken, the switch contacts may not reflect actual clutch pedal position; and 3) the failures could result in a vehicle experiencing unintended movement if the ignition is cranked when the clutch pedal is not being pressed.Chrysler's recall remedy will replace the clutch ignition interlock switch on all affected vehicles with a switch with a more robust design.On May 19, 2014, ODI opened PE14-013 to investigate clutch ignition interlock failure in MY 2004 through 2006 Dodge Ram 2500 and 3500 trucks with manual transmissions, based on two MY 2006 complaints and one MY 2004 complaint.One of the MY 2006 complaints involved a fatality that occurred when a young child was able to start a MY 2006 Ram 3500 truck that was parked with the transmission in gear, without depressing the clutch.The diesel engine started and the vehicle moved forward under power running over another child resulting in fatal injuries.ODI's analysis of failure data from all sources identified a total of 14 complaints and 16 warranty claims for the subject vehicles.Thirteen (13) of the complaints and all 16 warranty claims were for the 38,969 MY 2006 Dodge Ram 2500 and 3500 trucks that were included in 14V-795.The single complaint that was outside the scope of Chrysler's recall was the MY 2004 ODI complaint identified in the opening resume for PE14-013.Further analysis of this incident indicates that the cause of the clutch switch failure in this vehicle was spring damage caused by hydraulic fluid leakage from the clutch master cylinder into the switch.The field data did not show any other similar incidents of switch failures caused by clutch master cylinder leakage. This investigation is closed based on Chrysler's recall.Read more

EA, Open , Model Year: 2005

STEERING WHEEL AND STEERING SHAFT BOLTS

ON MARCH 9, 2006 ODI UPGRADED PRELIMINATRY EVALUATION PE05-056 TO ENGINEERNING ANALYSIS EA06-004 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING SHAFT COUPLING BOLTS AND STEERING COLUMN RETAINING BOLTS IN MODEL YEAR (MY) 2004 THROUGH 2006 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 THRO... Read more

PE, Closed , Model Year: 2005

STEERING WHEEL AND SHAFT BOLTS

ON OCTOBER 26, 2005 ODI OPENED PE05-056 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING WHEEL OR STEERING SHAFT COUPLING BOLTS IN MODEL YEAR (MY) 2004 AND 2005 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 DODGE DAKOTA PICKUP TRUCKS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION (DCC).DURING... Read more

EA, Closed , Model Year: 1997

UPPER BALL JOINT SEPARATION

DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANT... Read more

DP, Closed , Model Year: 1995

FRAME CRACKS

MR. EDWARD W. BAILEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION BY LETTER, UNDATED, REQUESTING THAT AN INVESTIGATION BE CONDUCTED INTO THE MATTER OF A FRAME CRACK IN HIS 1995 DODGE DAKOTA TRUCK.THE PETITIONER ALLEGES THAT THE FRAME ON THE PASSENGER SIDE OF THE VEHICLE... Read more

EA, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE

ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.

PE, Closed , Model Year: 2000

STOP LAMP SWITCH

ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE

PE, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE DISENGAGEMEN

ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS

RQ, Open , Model Year: 1994

STEERING WHEEL AND COLUMN