1992 DODGE DAKOTA

2 recalls, 314 complaints - 27 TSBs

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH A500 AUTOMATIC TRANSMISSION. INADVERTENT PLACEMENT OF THE SHIFT LEVER IN REVERSE CAN OCCUR WHEN THE DRIVER BELIEVES THAT THE TRANSMISSION HAS BEEN PLACED IN PARK.

Consequence

THIS CAN CAUSE THE VEHICLE TO ROLL AWAY WITH THE ENGINE ON AFTER THE DRIVER HAS LEFT THE VEHICLE.

Remedy

DEALERS WILL REPLACE THE STEEL MANUAL VALVE IN THE TRANSMISSION WITH AN ALUMINUM VERSION.

123,000 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

Complaint Statistics

314 total complaints 22 crashes 11 fires 26 injuries

Top Reported Components

Component	Complaints
POWER TRAIN:AUTOMATIC TRANSMISSION	84
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	21
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)	15
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	8
VEHICLE SPEED CONTROL	7
ELECTRICAL SYSTEM:IGNITION	7
ENGINE AND ENGINE COOLING:ENGINE	7
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	6
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT	6
POWER TRAIN	6

Incident date: Jul 26, 2016

WELL MY TRUCK WHEN I AM DRIVING DOWN THE RD AT NIGHT THE LIGHTS WILL TURN OFF OUT OF NO WHERE AND I ALMOST GOT IN A COUPLE OF WRECKS BECAUSE OF IT FLICKERING AND I HAVE CHANGED AND FIXED EVERYTHING AND IT STILL DOSE IT SO IT LIKE A WIRE ISSUE OR SOMETHING BUT I DON'T FEEL SAFE AT ALL DR... Read more

Fire 5 injured

Incident date: Jul 26, 2016

Fire 5 injured

Incident date: Jul 26, 2016

Fire 5 injured

Incident date: Jan 16, 2012

TL* THE CONTACT OWNS A 1992 DODGE DAKOTA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION OF A FAILURE WHICH INVOLVED THE VEHICLE ABNORMALLY SLIPPING FROM PARK AND INTO REVERSE. THE FAILURE CAUSED THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THE CONTACT STATED THAT HE HAD EX... Read more

Crash

Incident date: Mar 1, 2010

ON MY 1992 DODGE DAKOTA (V8 5.2L WITH AT, 4X4) THE ENGINE QUITS INTERMITTENTLY, SOMETIMES WHILE PARKED IDLING AND OTHER TIMES WHILE DRIVING. IT DOES IT WITHOUT WARNING, AS IF THE KEY IS TURNED OFF. SOMETIMES IT STARTS RIGHT UP AGAIN AND OTHER TIMES IT WILL HAVE TO CRANK FOR A WHILE BEFORE IT START... Read more

Incident date: Apr 18, 2010

I WAS BACKING OUT OF MY GARAGE ON MY WAY TO A JOB INTERVIEW, WHEN I REALIZED I FORGOT SOMETHING . I DROVE BACK IN THE GARAGE, PUT THE SHIFTER IN PARK AND I STEPPED OUT OF THE TRUCK. NO SOONER HAD I GOTTEN AROUND THE TRUCK DOOR WHEN THE TRUCK JUST STARTED BACKING UP BY ITSELF. I ATTEMPTED TO JUMP BAC... Read more

Crash 1 injured

Incident date: Oct 9, 2008

2 ISSUES-THE POWER TRAIN-I DON'T THINK IT WAS EVER FIXED AS MY GEARSHIFT LEVER INDICATOR IS NOT IN THE GEAR IT INDICATES-CAN THIS STILL BE FIXED UNDER THE RECALL-2ND PROBLEM-I CAN BE DRIVING DOWN THE ROAD AND THE TRUCK JUST SHUTS ITSELF OFF WITHOUT WARNING-SOMETIMES IT WILL RESTART AFTER SITTING A F... Read more

Incident date: Oct 9, 2008

Incident date: Apr 27, 2007

TL*THE CONTACT OWNS A 1992 DODGE DAKOTA. HE HEARD A CHATTER NOISE AND THE LIFTER NEEDED TO BE TIGHTENED. THE MECHANIC STATED THAT THE LIFTER FAILED IN THE CAM SHAFT WHICH AFFECTED THE ENGINE. THE DEALER STATED THAT THERE WAS NO RECALL FOR THIS YEAR, MAKE, AND MODEL VEHICLE. THE FAILURE AND CUR... Read more

Incident date: Jul 27, 2004

WHILE DRIVING AT ANY SPEED VEHICLE SHUT OFF INTERMITTENTLY. *AK

Incident date: Apr 21, 2004

VEHICLE WAS IN PARK WHILE RUNNING AND IT JUMPED OUT OF GEAR, ROLLED DOWN THE HILL, AND HIT A MOTOR HOME. CONSUMERE WAS ABLE TO DRIVE THE VEHICLE TO A BODY SHOP. *AK

Crash 1 injured

Incident date: Jun 1, 1993

THE PAINT IS PEELILING OFF. I CALLED THE DEALERSHIP WHEN IT FIRST HAPPENED AND THEY SIAD THAT THIS WAS THE FIRST THEY HEARD OF ANY PROBLEMS AND SAID WE HAD TO PAY FOR IT OURSELVES. NOW THE MAJORITY OF THE PAINT IS GONE AND RUSTING THROUGHOUT THE WHOLE VEHICLE. *AK

Incident date: May 15, 2003

VEHICLE WAS PARKED AND STILL RUNNING WHEN WITHOUT WARNING THE VEHICLE POPPED OUT OF PARK AND ROLLED BACK INTO ANOTHER PARKED VEIHICLE.*AK

Crash

WHILE DRIVING THE VEHICLE DEVELOPED A VIBRATION . WHEN THE VEHICLE WAS PUT IN REVERSE THERE WAS A LOUD BANG. THE MECHANIC STATED THE TRANSMISSION MOUNTS FAILED. *NLM

Incident date: Apr 1, 1992

ON DAYS OVER 90 DEGREE TEMPERATURE THE ENGINE WILL REV VERY LOUD AT FIRST START, WHILE VEHICLE WILL BARELY MOVE. THE DEALER REPLACED THE FAN CLUTCH TWICE AND REBUILT THE TRANSMISSION, HOWEVER THE REMEDIES DID NOT HELP. *JB THIS PROBLEM HAS ALSO OCCURRED WHILE AT TRAFFIC LIGHTS, WHEN DRIVEN AT LOW ... Read more

THE TRANSMISSION RECALL WAS DONE IN JUNE 2000. SINCE THEN, THE VEHICLE HAD TO WARM UP FOR AT LEAST 15 MINUTES BEFORE THE TRANSMISSION SHIFTED FROM PARK TO DRIVE. *JB PH *JB

THE TRANSMISSION WAS REPLACED TWICE, THE DEALER ATTRIBUTED THE PROBLEM TO THE OVER DRIVE CONTROL FEATURE. *PH *JB

THE VEHICLE WAS TURNED OFF AND THE TRANSMISSION WAS PLACED IN REVERSE. THE DRIVER THOUGHT THE KEY WAS IN THE ACCESSORY POSITION BUT IT WAS NOT. THE DRIVER EXITED THE VEHICLE AND WENT TO PULL THE KEY OUT THE IGNITION WHEN IT SUDDENLY STARTED AND RAN OVER HER. THE DRIVER SUSTAIN 2 BROKEN BONES IN H... Read more

1 injured

Incident date: Mar 4, 2003

THE VEHICLE LEAKED TRANSMISSION FLUID. THE DEALER STATED THAT THE LEAK WAS NOT RELATED TO THE TRANSMISSION RECALL. *NLM THE VEHICLE LEAKED TRANSMISSION FLUID. DEALER STATED THAT THE LEAK WAS NOT RELATED TO THE TRANSMISSION RECALL.

Incident date: Oct 25, 2002

VEHICLE FRAME IS DISINTERGRATING, BREAKING OFF IN BIG CHUNKS, IN TIRE FRAME FROM CAB BACK MUST BE REPLACED. THIS VEHICLE HAS BEEN GARAGE KEPT FOR 8 OF ITS 10 YEARS. THE VEHICLE HAS HAD THE SALT WASHED OFF FREQUENTLY DURING THE WINTERS ALSO. THIS MUST BE A DEFECT IN THE FRAME MATERIAL. DT

CONSUMER RECEIVED A RECALL NOTIFICATION, HOWEVER WHEN HE ARRIVED AT THE DEALERSHIP, HE WAS INFORMED HE WOULD BE NOTIFIED WHEN THE PART CAME IN, AND THE DEALER TOOK THE CONSUMERS RECALL CARD, CONSUMER HAS NOT HEARD FROM THE DEALER REGARDING THE PART.*JB

Incident date: Feb 15, 2002

15 DAYS AFTER PUCHASING THIS VEHICLE IT CAUGHT ON FIRE WHILE I WAS DRIVING IT. THE FIRE DESTROYED EVERYTHING UNDER THE HOOD BUT THE METAL ENGINE PARTS AS WELL AS MELTED PART OF THE DASH & CARPET ON THE INTERIOR. AFTER PRYING OPEN THE HOOD & DOUSING THE FLAMES COMPLETELY, THE FIRE DEPARTMENT TOLD M... Read more

Fire

Incident date: May 7, 2002

CONSUMER APPLIED BRAKE AT 40 MPH, PEDAL WENT TO THE FLOOR, NO BRAKING ACTION. DEALER DETERMINED BRAKE LINE HAD RUSTED AND ALL BRAKE FLUID HAD DRAINED.*AK *MJ

Incident date: Apr 14, 2002

THERE IS A DESIGN FLAW ON VEHICLE, FUEL LINE IS ROUTED AGAINST THE BODY OF VEHICLE, AND OVER TIME THAT PART HAS CREATED A HOLE IN THE FUEL LINE THAT CAUSES FUEL TO LEAK OUT. CONTACTED DEALER. *AK

Incident date: Feb 19, 2002

PLASTIC COVER ON DRIVERS SIDE RESTRAINT BROKE WHILE TRYING TO UNLATCH IT.*AK. CONSUMER WAS TRAPPED IN THE VEHICLE, CONSUMER STATED MANUFACTURER IS NOT WILLING TO FIX SEATBELT.*JB

Incident date: Jul 25, 2001

THE DOOR ASSEMBLY ON THE DRIVER-SIDE FAILED WHEN THE LOWER HINGE COLLAPSED INTO THE DOOR. THIS CAUSED THE DOOR TO BE MISALIGNED, PREVENTING THE LATCH FROM ENGAGING LATCH BOLT. THE FUEL GAUGE READS 1/4 SHORTLY AFTER FUELING AND WILL STAY THEIR UNTIL THE TANK IS ALMOST EMPTY. THE RADIATOR CORE FINS D... Read more

Incident date: Jul 25, 2001

RECALL 00V199000; FUEL LEAKING FROM THE FUEL TANK. DEALER HAS BEEN NOTIFIED. A RECALL HAS BEEN ISSUED ON SIMILAR MAKES AND MODELS. HOWEVER, THIS VEHICLE NOT INCLUDED DUE TO VIN. PLEASE PROVIDE FURTHER INFORMATION. *AK

Incident date: Aug 15, 2001

CONSUMER RECEIVED RECALL NOTICE 00V106000, AND MADE CONTACT WITH DEALERSHIP TO REPAIR THE DEFECT. DEALERSHIP WAS REFUSING SERVICE BECAUSE THERE WAS AN ONGOING PROBLEM WITH TRANSMISSION, AND MUST BE CORRECTED BEFORE THEY PERFORM RECALL REPAIRS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTAC... Read more

WHILE DRIVING VEHICLE COMPLETELY SHUTS DOWN WITHOUT WARNING, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK

Incident date: Aug 16, 1996

AFTER TURNING OFF IGNITION VEHICLE AND ELECTRICAL EQUIPMENT (RADIO, ETC) CONTINUED TO RUN WITH KEY OUT OF THE IGNITION, ONLY WAY TO STOP ENGINE AND ELECTRICAL SYSTEM EQUIPMENT WAS TO STEP ON THE BRAKE PEDAL. * AK

Incident date: Jun 1, 1998

BODY SHEET METAL BREAKAGE WHERE LOWER DOOR HINGES ARE WELDED, BOTH SIDES OF VEHICLE. REPAIR SHOP ADVISES TYPICAL ON DODGE DAKOTA AND DOOR COULD POSSIBLE FALL OFF WHILE DRIVING. COST TO REPAIR EACH DOOR APPROX $400.

AFTER PARKING VEHICLE, PUTTING GEAR IN PARK, COULD NOT GET GEAR SHIFT OUT OF PARK GEAR, HAD TO PUT GEAR IN NEUTAL, THEN BACK TO PARK WITH ENGINE RUNNING BEFORE TRUCK WOULD MOVE OUT OF PARK.

Incident date: Jan 25, 2001

THE VEHICLE WAS TAKEN TO DEALER FOR RECALL REPAIR 00V-106, AFTER REPAIR THE VEHICLE BEGAN EXPERIENCING DIFFICULTY SHIFTING GEARS WHICH IT HAD NEVER EXPERINCED PRIOR TO HAVING THE VALVE REPLACED, THE VEHICLE WAS RETURNED AND THE MANUAL SHIFT VALVE WAS REPLACED AGAIN AND THE CONSUMER WAS CHARGED FOR R... Read more

VEHICLE SUSTAINED EXTENSIVE BODY DAMAGE PRIOR TO RECALL NOTICE 00V-106 WHEN THE VEHICLE ROLLED WHILE IN PARK. NLM

Incident date: Jun 21, 2000

RECALL 871 WAS PERFORMED ON 21 JUNE 2000 AND WHEN COMPLEATED TRANSMISSION WOULD NOT SHIFT INTO OVERDRIV ( 4TH GEAR), ALSO CRUISE CONTROL WOULD NOT WORK. ON 10 JULY 2000 TRUCK WAS TAKEN BACK TO DEALER AND TRANSMISSION INSPECTED AND COULD FIND NOTHING WRONG. MANUFACTURE CALLED AND THEY WOULD DUE NOTHI... Read more

Incident date: Jun 21, 2000

Incident date: Nov 5, 2000

CONSUMERS VEHICLE SLIPPED FROM THE PARKED POSITION INTO REVERESE POSITION RUNNING OVER CONSUMER WHO WAS STANDING BEHIND THE TRUCK AT TIME, VEHICLE WAS RECENTLY RECALLED FOR FAULTY STEEL MANUAL VALVE IN THE TRANSMISSION, CHRYSLER DENIES ANY RESPONSIBILITY (ATTORNEY FOR CLIENT). NLM

1 injured

Incident date: Mar 27, 2000

THE VEHICLE WAS EXPERIENCING SYMPTOMS OF THE TECHNICAL SERVICE BULLETIN # 09-07-97(TIMING CHAIN), CONSUMER WAS NOT AWARE OF THE BULLETIN AND THE VEHICLE BROKE DOWN AND WAS REPAIRED DUE TO TIMING BELT FAILURE, CONSUMER IS REQUESTING REIMBURSEMENT FOR REPAIR AND FEELS THE REPAIR WAS MISDIAGNOSED. *M... Read more

Incident date: Dec 20, 2000

WHILE DRIVING ABOUT 60 MPH . ENGINE WILL SHUT DOWN WITHOUT A PRIOR WARNING. SOMETIMES CONSUMER COULD BE FOLLOWED BY OTHER VEHICLES WITH CAUTION WHILE DRIVING OFF THE ROAD. *AK

Incident date: Nov 24, 2000

WHILE VEHICLE WAS IN PARK, CONSUMER GOT OUT AND WALKED BEHIND CAR, AND VEHICLE TOOK OFF BACKWARDS. *AK

Crash

TRANSMISSION FAILURE. *SLC

Incident date: Nov 5, 2000

THE ENGINES HAVE HIGH FAILURE RATE OF BUSHING FOR OIL PUMP DRIVE SHAFT. THIS CAUSES EXCESSIVE WEAR OF DISTRIBUTOR, WHICH WILL BREAK OFF THE END OF THE ROTOR, CAUSING INSTANT ENGINE FAILURE, LOSS OF POWER STEERING ASSIST. THE IS NO WARNING, SO IS VERY DANGEROUS TO PULL OVER IN HEAVY TRAFFIC (I WAS ... Read more

DEFROSTER FAILURE CAUSING POOR VISIBILITY.*ET

MECHANIC FOUND BURNT TERMINALS AND WIRING, THIS CAUSED THE BACK UP LAMPS TO NOT FUNCTION.*ET

Incident date: Jun 8, 2000

RECALL 00V106000, CONSUMER TOOK VEHICLE FOR RECALL REPAIRS. AFTER REPAIRS WERE DONE CONSUMER NOTICED OTHER PROBLEMS WITH VEHICLE, SUCH AS SHIFTER DOES NOT PERFORM PROPERLY/TRANSMISSION DOES NOT SHIFT PROPERLY, HAS TO BE SHIFTED MANUALLY SOMETIMES. 50% OF TIME VEHICLE DOES NOT START IN PARK, HAS TO... Read more

VEHICLE WENT IN REVERSE AFTER PARKING, CRASHING INTO A HOUSE CAUSING DAMAGE TO HOUSE AND TO THE BUMPER AND FENDER OF VEHICLE, WHILE FIXING RADIO, CONSUMER CAME ACROSS THE WIRING IN THE DASH AND FOUND A FASTENER HAD FALLEN OUT WHICH WOULDN'T ALLOW VEHICLE TO REALLY GO IN TO PARK ALSO AFFECTING THE RA... Read more

Incident date: Jun 1, 2000

VEHICLE STALLS INTERMITTENTLY WHEN APPLYING BRAKES AND TURNING CORNERS. DEALER CHECKED VEHICLE OUT, BUT COULDN'T FIND CAUSE. *AK

Incident date: Jun 6, 2000

CONSUMER RECEIVED NHTSA RECALL 00V106000/ MANUFACTURER'S RECALL 871 CONCERNING TRANSMISSION SHIFT LEVER. DEALER HASN'T RECEIVED TOOL FROM CHRYSLER SINCE JUNE TO PUT THE PART IN. DEALER ADDRESS:TURNER JOHNSON DODGE 1210 HWY 39 N MERIDIAN, MS. PHONE# 601-693-6343. *AK

Showing 50 of 314 complaints.

Technical Service Bulletins, 1992 DODGE DAKOTA

27 manufacturer communications from 22 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	2
350000 EQUIPMENT	2
160000 STRUCTURE	2
220000 SEATS	2
116200 ELECTRICAL SYSTEM:IGNITION:MODULE	1
062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN	1
072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	1
034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	1

350000 EQUIPMENT

Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacemen

160000 STRUCTURE

350000 EQUIPMENT

160000 STRUCTURE

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

FRAME CRACKING. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

114000 ELECTRICAL SYSTEM:WIRING

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT

162000 STRUCTURE:BODY

SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS

220000 SEATS

INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

INFORMATION REGARDING FRONT BRAKE CALIPER MOUNTING TO STEERING KNUCKLE THREAD REPAIR. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

THE OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE AND BREAK. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

THE OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE AND BREAK. *YC

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONCERNS WITH A/C EVAPORATOR ODOR. *NLM

061000 ENGINE AND ENGINE COOLING:ENGINE

TIMING CHAIN NOISE. *TW

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC

060000 ENGINE AND ENGINE COOLING

CONCERNS WITH ENGINE COOLANT USAGE. *NLM

102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION ON TRANSMISSION COOLER REVERSE FLUSHING WITH COOLER BYPASS KIT INSTALLED. *NLM

161000 STRUCTURE:FRAME AND MEMBERS

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW

180000 VEHICLE SPEED CONTROL

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPER

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

SLIGHT FRONT BRAKE LEAD/DRIFT. *TW

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

PCM NOT PROPERLY DISENGAGING A/C CLUTCH VIA THE RELAY ALSO THE PCM MAY NOT ENERGIZE THE A/C CLUTCH RELAY. *TW

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

COOLING FAN NOISE. *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

OIL LEAK DIAGNOSIS OF THE REAR MAIN BEARING AREA. *TW

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

IMPROVED FUEL PUMP. *TW

NHTSA Safety Investigations, DODGE DAKOTA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2006

Clutch Interlock Switch Malfunction

On December 16, 2104, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the clutch ignition interlock switches in approximately 66,819 model year (MY) 2006 through early-2007 Dodge Ram Trucks, Dodge Dakota, and Mitsubishi Raider vehicles equipped with manual transmi... ssions and built between July 1, 2005 and July 31, 2006 (NHTSA Recall No. 14V-795, Chrysler Recall No. P80), including 38,969 MY 2006 Dodge Ram 2500 and 3500 vehicles that are part of the subject vehicle population for PE14-013.Chrysler's Safety Report states that:1) the clutch ignition interlock switch return springs may experience fatigue failure due to material issues; 2) if the return springs are broken, the switch contacts may not reflect actual clutch pedal position; and 3) the failures could result in a vehicle experiencing unintended movement if the ignition is cranked when the clutch pedal is not being pressed.Chrysler's recall remedy will replace the clutch ignition interlock switch on all affected vehicles with a switch with a more robust design.On May 19, 2014, ODI opened PE14-013 to investigate clutch ignition interlock failure in MY 2004 through 2006 Dodge Ram 2500 and 3500 trucks with manual transmissions, based on two MY 2006 complaints and one MY 2004 complaint.One of the MY 2006 complaints involved a fatality that occurred when a young child was able to start a MY 2006 Ram 3500 truck that was parked with the transmission in gear, without depressing the clutch.The diesel engine started and the vehicle moved forward under power running over another child resulting in fatal injuries.ODI's analysis of failure data from all sources identified a total of 14 complaints and 16 warranty claims for the subject vehicles.Thirteen (13) of the complaints and all 16 warranty claims were for the 38,969 MY 2006 Dodge Ram 2500 and 3500 trucks that were included in 14V-795.The single complaint that was outside the scope of Chrysler's recall was the MY 2004 ODI complaint identified in the opening resume for PE14-013.Further analysis of this incident indicates that the cause of the clutch switch failure in this vehicle was spring damage caused by hydraulic fluid leakage from the clutch master cylinder into the switch.The field data did not show any other similar incidents of switch failures caused by clutch master cylinder leakage. This investigation is closed based on Chrysler's recall.Read more

EA, Open , Model Year: 2005

STEERING WHEEL AND STEERING SHAFT BOLTS

ON MARCH 9, 2006 ODI UPGRADED PRELIMINATRY EVALUATION PE05-056 TO ENGINEERNING ANALYSIS EA06-004 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING SHAFT COUPLING BOLTS AND STEERING COLUMN RETAINING BOLTS IN MODEL YEAR (MY) 2004 THROUGH 2006 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 THRO... Read more

PE, Closed , Model Year: 2005

STEERING WHEEL AND SHAFT BOLTS

ON OCTOBER 26, 2005 ODI OPENED PE05-056 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING WHEEL OR STEERING SHAFT COUPLING BOLTS IN MODEL YEAR (MY) 2004 AND 2005 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 DODGE DAKOTA PICKUP TRUCKS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION (DCC).DURING... Read more

EA, Closed , Model Year: 1997

UPPER BALL JOINT SEPARATION

DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANT... Read more

DP, Closed , Model Year: 1995

FRAME CRACKS

MR. EDWARD W. BAILEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION BY LETTER, UNDATED, REQUESTING THAT AN INVESTIGATION BE CONDUCTED INTO THE MATTER OF A FRAME CRACK IN HIS 1995 DODGE DAKOTA TRUCK.THE PETITIONER ALLEGES THAT THE FRAME ON THE PASSENGER SIDE OF THE VEHICLE... Read more

EA, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE

ALLEGE THAT THE FRONT SAFETY BELT ANCHOR BOLTS DISENGAGE FROM THEIR MOUNTING POINTS OR ARE FOUND TO BE LOOSE.

PE, Closed , Model Year: 2000

STOP LAMP SWITCH

ALLEGED THAT ELECTRICAL FAILURE OF THE BRAKE STOP LAMP SWITCH MAN RESULT IN STOP LAMPS NOT ILLUMINATION DURING SERVICE BRAKE APPLICATION, AND THE VEHICLE'S CRUISE CONTROL SYSTEM MAY FAIL TO DISENGAGE

PE, Closed , Model Year: 2000

FRONT SAFETY BELT ANCHORAGE DISENGAGEMEN

ALLEGED THAT THE DRIVER'S SEAT SAFETY BELT ANCHORS DISENGAGE FROM MOUNTING POINTS

RQ, Open , Model Year: 1994

STEERING WHEEL AND COLUMN