2006 DODGE CHARGER Recalls, Complaints & Safety

I filled up my gas tank on way home from work in [XXX] . Once i got on on ramp to get on freeway my 2006 dodge charger stalled. I lost all power and barely was able to get to side of on ramp. I waited a couple minutes after shutting car off. Then it started up again for me to get home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After filling the gas tank with gas.Car starts missing and engine will stall . If you stop at red light after filling up car will stall and the engine stops running. If you dot fill the car up to full it has no problem running it does as it should

The contact owns a 2006 Dodge Charger. The contact stated while idling at the traffic light, the vehicle stalled. The contact stated that the failure also occurred while driving at various speeds. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The contact stated that the vehicle failed to restart on several occasions and was towed to the residence. The vehicle was taken to the dealer, where DTC: U0100 and P0700 were retrieved. The dealer flashed the computer; however, the failure persisted. The vehicle was taken to an independent mechanic, were the same DTC were retrieved and the failure was related to a loss of communication with the PCM and the Transmission Control Module. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 111,415.

I HAVE A DODGE CHARGER RT 2006 HEMI. I WAS COMMING OFF THER HIGHWAY . AFTER TAKING THE EXIT RAMP I WAS HEADING TO A RED LIGHT MY BREAKS FAILED! I HAD NO BREAKS AT ALL SUDDENLY CAUSING MY CAR TO CRASH INTO THE CAR AT THE LIGHT. MY CAR THEN TRAVELED BACKWARDS WITHOUT BREAKS. THE POLICE DID ARRIVE ON SCENE. THE GUY IN OTHER CAR THOUGHT I FELL ASLEEP AS MY CAR DIDNT EVEN SKID. I HAD TO GO IN TH EAMBULANCE AND HOSPITAL SAID I HAD A CONCUSSION. I HAD INSURANCE SINCE BUYING THE DODGE SECOND HAND BUT, DUE TO WRONG INFO MY INCURANCE WAS CANCELLED. IN nh you dont have to have insurance but now im left with my car in need of serios repair!! im devastated. i had no issue to say i was at risk for break issues.

Crash

My 2006 Dodge Charger stalls after refueling, and now stutters when driving as if not getting fuel. I have noticed when attempting to break and stopping at stops this is happening more often. The car shuts down and could cause a accident. After researching this issue I found that this has been addressed already under investigation number PE13-016 by the NHTSA.

I was almost rear-ended by a semi when the vehicle stalled at a light while picking my son up from work. It seems to stall at stop signs or waiting at lights completely. It stalls while idling here and there sometimes. Sometimes when driving on the e-way it jerks as it wants to stall but not completely. The main codes that pop up is u0100. Sometimes p0700 pops up and then sometimes the u0100 pops up along with a bunch of other codes. This has just started happening with my previous 2006 Dodge Charger 5.7 which has happened once or twice and a u0100 code pops up when scanned. I've scoured the internet for solutions and notice. There's a lot of people going through this similar situation and it so happens to be the 2006 year that's plagued with this problem. Even getting a new PCM doesn't solve the problem. Whomever is in charge of the Dodge company needs to figure out the exact cause of this problem before a driver/passengers gets injured or killed in an accident because of it. Please put some fire under their butt

The issue is that after fueling up my car I will drive a little ways down the road and the car will shut off and I will need to steer out of the way of traffic and restart the car. This will happen several times after refueling. This appears to be a common problem with 2006 Dodge Chargers, Magnums, and Chrysler 300s. It appears that the issue is that fuel was observed entering the purge line prior to initial shut off of the fill nozzle. This causes fuel to escape from the fuel tank assembly into the evaporative system. The multi-function control valve’s refueling float stays stuck in an open position and is the cause of this issue. “Rich fuel” gets into the engine and the engine will shut down. The NHTSA has investigated the issue under investigation number PE13-016. I was directed to report the issue to the NHTSA website if I have the issue, which I do.

Upon looking for my vehicle recalls it said my car had been repaired and I've owned it the last 7 years and it definitely has not since I've owned it.. That isn't true...

when i refuel start out in highway car stalls almost results in getting rear ended i found dodge knew about this but i did not get recall i bought car new this just started bout 12 months ago car only has around 65000 miles on it .it happened today 3/20/24

When I fill my car with gasoline, it starts to putter and shuts off. I have replaced the fuel pump and fuel transfer unit over 4 times since I have owned this vehicle. I had the same issue with my Chrysler 300. It is very frustrating and cost full. I just dropped my car at the shop to be looked at again. I just had a fuel/transfer pump done less than a year ago

After filling up with gas my car stalled 3 times within 30 minutes. One time while making a turn and my power steering locked up almost making me crash, another time at a red light and also while idling in my driveway.

I FUEL MY CAR UP AND IT STALLS AND I CAN'T CONTROLL WHERE I AM GOING, THIS IS HAPPENING MORE AND MORE. ALMOST GOT HIT FROM BEHIND.

My car has been stalling intermittently. But lately it's becoming more frequent. I've taken it to 3 different repair shops. Diagnostics shows P0700 and U1000 codes. The last shop charged me 150 dollars just to tell me that they don't know what's causing my car to stall. So I'm kind of lost here. Please help me.

The fuel tank with this car have issues when filled up. This issue started about 3-4 years ago. The gas tank haven't been inspected but I've changed literally every component associated with the fueling system. I wish I would've done research before hand and would've just saved money and known that there are issues with the fuel tank. The car when filled up or sometimes just putting a little gas it will either sputter or shut off. No check engine light comes on or nothing. However after doing research I found out that my VIN isn't in the recall listing. This makes absolutely no sense for the investigation into a broader VIN listing to be closed with the amount of complaints these year model cars fuel tank.

Valve in the top of the tank to release vapor through the purge system is stuck open allowing fuel in the system, is available for inspection. Car stalls while driving and at stops, stalled infront of ambulance. Has not been reproduced of confirmed by dealer, but it has happened everytime i fully refuel the car. Has not been inspected. No symptoms or warnings prior to issue occurring.

I got ZD1-00000 recall procedure done at Joe Cooper Dodge of Shawnee 4940 North Automall Dr. Shawnee, OK 74804. Recently I noticed my blower had started to perform rattling sounds, so I opened the glovebox, inspected the blower and found one little screw inside the turbine. I wondered where it should be screwed, so I looked everything around and realized the passenger-side airbag is screwed on 2 screws instead 4 like it was designed. I am not in a position to make technical conclusions but looks like probably the serviceman who performed the airbag recall procedure gave up screwing all 4 screws. So, I called to Dodge Contact Center (FCA US LLC. Case #[XXX] and asked what they thought about this. Susan, the lady I talked to said they are basically not responsible for the recall procedure performing quality and I should ask for help from Joe Cooper Dodge of Shawnee. I declined any contact with Joe Cooper Dodge of Shawnee as far as in my opinion they neglected their professional duties and put me and my family in jeopardy. The point is simple, my intention was not to hide the situation and get a bonus from someone, but to inform the corporation about the possible quality issues with the recall procedure performed by their representatives. I also asked the FCA US LLC. to schedule an appointment with any other dealers to independently inspect the job quality related to recall procedures performed on my car. So, Susan from Dodge Contact Center a representative of FCA US LLC ignored the possible safety issue information that had been provided, she said Case # would[XXX] be closed. She also said the possible safety issues could be solved by another dealer but for the extra fee. FCA US LLC. forcing me to pay for the procedure, which is supposed to be free of charge regarding the Safety Act and Federal regulations. I kindly ask you to pay attention to Joe Cooper Dodge of Shawnee 4940 North Automall Dr. Shawnee, OK 74804. and FCA US LLC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA

Was backing our of a parking spot when the driver's airbag went off. I was looking to the back right as I was slowly turning the wheel clockwise when the airbag triggered. At such low speeds I was able to safely hit the brake and park the vehicle. As a result my left hand was minorly injured, while my front passenger only reported his ears ringing. My vehicle never made any contact with another vehicle or object. The Publix parking lot is a flat, paved surface. I took pictures all around and of my car soon after. I did have the airbags replaced because of the Takata recall some time ago (2017/2018 i think). If the vehicle was operated at a higher speed and the airbag went off, this would certainly cause an accident. I did inspect the vehicle afterwards and performed an EDR download. The CDR report is attached, however it reports that it is "Not retrievable by CDR Tool". There was a check engine light on at the time, I believe it was for code P0420. There may have been a low tire pressure light as well. Alignment was recently performed (~1 month ago) by a Tires Plus.

1 injured

Vehicles pcm failed causing the vehicle to shutdown randomly with no warning leaving you with a non running car in the middle of running traffic the PCM is not available for inspection sadly but have found through research that this is a common issue the PCM was found to be faulty by a technician at south pointe cjdr

After filling up with gas car shut off 1/2 mile causing loss of power steering. Restarted and did the same thing about 1/2 mile again

The contact owns a 2006 Dodge Charger. The contact stated that while parked, the driver's and the passenger air bags unintendedly deployed. The dealer was made aware of the failure. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V313000 (Air Bags) and 16V352000 (Air Bags) for which the VIN was included. The manufacturer was not made aware of the failure. The failure mileage was unknown.

My 2006 Dodge Charger R/T HEMI 5.7 has experienced multiple breakdowns in my transmission. Come to find out it is actually a Mercedes Benz transmission. Replaced multiple times after getting towed multiple times for transmission going out. Totally unacceptable.

When you fill the gas tank the vehicle cuts off and stalls in the middle of traffic and cannot restart. This has happened every time the tank was filled. Multiple times and every time

After filling up my gas tank I went to start driving again and my vehicle stalled out. It did this several more times.

On 3/10/2023 my vehicle suddenly starting trembling and shaking profusely! It terrified me severely. I immediately called my mechanic and it was towed in to be repaired. I was told it needed a tune- up. Towing, 3-Direct Ignition coils replaced, 6-spark plugs replaced and 1- fuel injection plenum gasket set replaced. Four weeks later on 4/16/2023 a warning sign of a backwards meeting parenthesis with a lightening bolt between to the two backwards parenthesis showed up on my warning lamp-Electronic Throttle Control (ETC) Indicator symbol; causing my vehicle on shake, jump and stall as I was driving on 29S heading toward 70W towards Baltimore to get home. I was able to drive to side of the road and my car completely stopped. A the horrific sounds of the traffic wizzed by me and my 12 year old child, I immediately called AAA, as we were in danger and severely terrified. We were finally picked up after 3 long hours!!!!! My car was the towed up the street from my home because the huge tow truck was unable to get directly in front of my door at that late hour. As I called AAA back the next morning to have my car towed to my mechanic shop, I was told I could only get 1 tow/ breakdown. I was totally in disbelieve after all we endured the evening/ night before. After explaining to a supervisor at AAA, she agreed that we had such a horrible experience the night before and adjusted the policy to accommodate my vehicle to be towed to my mechanic for repairs. This time, my fuel pump needed to be replaced and it has been. My vehicle still feels hesitate in its acceleration and as of today my engine light is on on my warning panel. I have been contacted by a NHTS recall team agent and have been scheduled for an appt

Every time I get gas, my Charger stalls at stops and while driving. Not good!!! I have had several close calls! I do not top off and I always use premium. Something has to be done this is not safe for anyone on the road.

The contact owns a 2006 Dodge Charger. The contact stated that the vehicle would start after the second attempt. Additionally, the contact stated that the vehicle shut off while driving from a complete stop. Several unknown warning lights were illuminated. The contact was able to restart the vehicle and continued driving. Additionally, the contact stated that the failure occurred while driving at various speeds. The contact was able to veer to the side of the road. The contact restarted the vehicle and continued driving. The contact also stated that while driving at various speeds, the vehicle jerked and shuddered. The vehicle was taken to an independent mechanic where it was diagnosed that there was a communication failure to the transmission. The independent mechanic cleaned the throttle body; however, the failure persisted. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000. The VIN was not available.

Car stalled after refueling, restarted pulled out stalled again a minute later. No warning lamps. Able to drive 15 miles home, parked it. Investigation # PE13-016

Usually after I fill my car up with premium gas and start to drive it around it will stall out of nowhere especially when stopped or low idle.

The contact owns a 2006 Dodge Charger. The contact stated that on various occasions after refueling the vehicle over half tank, the vehicle would stall and then lose motive power while driving at slower speeds or while coming to a stop. No warning lights were illuminated. The contact stated that she was only able to restart the vehicle after refueling again. The vehicle was then taken to an independent mechanic to be diagnosed. The contact was informed that the passenger’s side fuel pump needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that she was unable to refuel the vehicle past half tank without the failure recurring. The local dealer was then made aware of the failure and confirmed that the VIN was not included in a recall. The manufacturer was made aware and also confirmed the VIN was not included in a recall and a case was opened. The approximate failure mileage was 190,000.

The contact owns a 2006 Dodge Charger. The contact stated that after starting the vehicle, he was unable to shift the gear shifter out of park(P). The contact stated no warning light was illuminated. The vehicle was not drivable. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. Upon investigation, the contact associated the failure with Customer Satisfaction Number: K39. The failure mileage was approximately 78,000.

The contact owns a 2006 Dodge Charger. The contact stated while driving approximately 70 MPH, the vehicle started shaking, then lurch and the vehicle stalled. The contact stated that the vehicle lost power steering and braking functionality. The contact was able to coast the vehicle off the side of the road. The contact stated that the check engine, ABS, and the throttle control warning lights were illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the fuel tank and fuel system needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was again exhibiting the same failure. Additionally, the failure was more frequent and that there were days when the contact could not keep the vehicle from stalling after starting the vehicle. The manufacturer had not been informed of the failure. The failure mileage was approximately 136,000.

Car will stall and not start after filling with gas. After awhile car will run but shut off randomly. This can happen while driving. Car has been stuck at intersections and will stall even doing highway speeds. All lights will appear on dash engine car will lose all power. Small ding before it dies.

I swerved to avoid animal in the roadway. Over corrected my skid and went into the ditch at highway speed. The airbag never deployed and I had a fracture to my lumbar 1. Insurance denied my claim and have the vehicle listed as a 2007 charger. They should have at least covered part of this incident as there was full coverage through progressive insurance at the time.

Crash 1 injured

After filling up the car with fuel (93 octane) the car stalls after a couple of minutes. This has caused unsafe situations as the car has stalled in the middle of intersections and on the road. This has happened consistently after filling up. The car does not start immediately after stalling. After a couple of minutes post stall, I am able to restart the car. At times, the car studders while moving. This all happens after topping off with fuel. The vehicle has approximately 106,000 miles.

Car will shut off and or stall after filling up.

My Dodge charger has 4 codes I can't figure out and one is a is a manufacturer code that popped up and lost connection to tcm and something to do with the fuel